2017 ALFA ROMEO GIULIA Engine Problems

I am filing a complaint in regard to recall 93c for my 2017 Alfa Romeo. The dealership/manufacturer has failed to provide me with a fix, parts or even just a loaner car due to the safety hazard. My car has gone limp mode several times on the highway at speeds of 70mph. This is unacceptable.

My 2017 Alfa Romeo Giulia, VIN [XXX] , is currently disabled and inoperable at the authorized dealer, Alfa Romeo Fiat of Daytona (Service Advisor: Kevin Chapman). The vehicle is subject to the active and known Safety Recall 93C (Low-Pressure Fuel Pump). My vehicle is experiencing a total loss of motive power and engine stall, which is the exact safety hazard described in the recall. Furthermore, the initial failure of the low-pressure fuel system appears to have caused secondary consequential damage to the expensive High-Pressure Fuel Pump (HPFP), and the vehicle is also exhibiting a severe and recurring electrical defect (new battery dying, random dash warnings/brake lights flashing). The manufacturer, FCA/Stellantis (Customer Care Case #XXX...), and the dealer are engaging in a runaround to deny basic safety recall provisions: 1. Refusal to Cover Consequential Damage: FCA Customer Care stated that if the issue is 'not the 93C recall then it will all be customer pay,' which conflicts with NHTSA guidelines requiring the manufacturer to remedy the primary defect and all damage proximately caused by it. 2. Refusal to Provide Loaner/Rental Car: FCA stated the loaner is up to the dealer, and the dealer stated it is up to the diagnostic. This runaround has created an unreasonable delay in the repair of a federally mandated safety recall, leaving the owner without transportation for a disabled, unsafe vehicle. I am requesting NHTSA intervention to compel FCA/Stellantis to: a) Authorize a complimentary rental car/loaner until the vehicle is fully repaired. b) Provide a formal commitment that all damage proven to be a direct, proximate consequence of the 93C fuel pump failure will be covered at no cost. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Oil Pump Solenoid will get stuck and will cause the car to go into LOMP mode or in worse cases cause the drivetrain to lock up and a lose all power. It can happen at random.

The oil pump is defective and is a known issue at Alfa Romeo which causes the car restrict function which could result in loss of control of the vehicle.

This has been an issue slowly getting worse over the last few months and escalated this week. June 20th, 2025 my car has literary died over (4) times during traffic and I had to try and stay calm while using a code reader to clear the codes to get the engine to start. Very scary, I have a 2017 Giulia Ti that just hit 100k miles. Even took it to the dealership and they couldn't explain it. Parasitic draw on my battery and they gave it a pass :( Codes: P2510-ECM/PCM POWER RELAY SENSE CKT RANGE/PERFORMANCE P0103-VAF CIRCUIT HIGH INPUT P0100- VAF CIRCUIT MALFUNCTION P0451-EVAP SYSTEM PRESSURE SENSOR/SWITCH 'A' RANGE/PERFORMANCE P0106-MANIFOLD ABSOLUTE PRESSURE/BAROMETRIC PRESSURE SENSOR CIRCUIT

Multiple times the check engine light will come on while driving. It shuts engine down at any speed. This usually happens during warm up phase of vehicle. You have to pull over and cycle power off and on multiple times before it starts and runs again. It has stalled in intersections causing traffic delays. Once it starts and codes clear it typically runs fine for long periods. Symptom codes include throttle system failure, fuel pump low pressure, miss fire, bcm communication error. Cycling off and on clears codes and car operates normally until next cold start. Symptoms seem to worsen when driving in n or a mode. Symptoms seem to worsen when remote starting vehicle.

Car go in limp mode when accelerating. Lost of power

When I'm driving on the highway, the vehicle suddenly have a notification stating 'Service Electronic Throttle Control' and started to lose power, no matter howbjard the pedal was being depressed, it's notbgiving enough power out and start dropping speed. That drop me almost hit the vehicle behind me and inposing a serious risk because I'm on the highway. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, the dealer mentioend it might be a fuel pump problem. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, it start almodt everytime suddenly from nowhere. Usually it will be ok after a few restart, but this t.ime it's persistent

Fuel pump failed while driving causing car to go into neutral with no power. Had to have it towed after risking my safety on a busy road. Had to pay for a new fuel pump and repairs at dealer. This happened in 2023 a few months back.

Hello, I was driving in the highway at highway speed and my engine shutdown with any sort of warning. I almost caused a huge accident. After I took it to the Alfa Romeo dealer, I had to replace the fuel pump according to the dealer, which is a common problem. I think Alfa Romeo should do a recall on the fuel pump. I also,scratched my car due to this incident avoiding a bigger accident. This car needs to be recalled for fuel pump repairs for all the car with the old bad fuel pump design. Thank you

When driving vehicle it randomly goes into Limp mode and gives an “electronic throttle module error”. This in turns decreases the power of the vehicle significantly and causes you to move over lanes as to not cause traffic. This issue is common for a lot of Alfa Romeo Guilia owners.

Engine recently began making a loud ticking sound, that everyone who heard it asked, "What's wrong with your car?" I purchased the vehicle new 5.5 years ago and it presently has 38,475 miles on it. The dealer determined the noise was due to a loose oil pump bolt under the timing cover. It was a 10.5 hour repair to remove a bolt and reapply lock-tite to it and then reinstall. Had the repair not been performed the bolt could have vibrated all the way out and caused internal damage to the engine, which I believe is a safety issue. The repair cost was $1,813.68. Per the dealer this was the first Giulia model that they had to service for this issue, but they had serviced several Stelvio models that were newer but shared the same engine. In today's automotive market such repairs should not be necessary on a vehicle with low mileage. The brand offers a 4 year / 50,000 mile warranty, but not a separate powertrain warranty. In hindsight, it appears the brand does not have a great deal of confidence in the durability of the powertrains it builds.

On August 18, 2022, I was driving the vehicle at a speed of approximately 45 mph when the vehicle motor suddenly and without any prior warning completely shut down. Several warning lights appeared immediately but none prior to the shutdown. I was driving in moderately heavy traffic and had to coast to a spot off the shoulder of the road. This was a dangerous situation and if I had been in heavier higher speed traffic, this would have been a very risky safety situation since I had no power whatsoever to control the vehicle movement. The vehicle would not restart and had to be towed to a repair shop. The problem was with the Fuel Pump Control Module which had to be replaced along with replacing the fuel pump. The manufacturer had previously issued a Technical Service Bulletin (TSB) concerning this but had not issued a recall. I was unaware of the TSB. The manufacturer was obviously aware of issues with the Fuel Pump Control Module but did not issue a recall for vehicles. The TSB was for cars produced prior to August of 2017 and my car was produced in May of 2017.

* The engine parts melted, yes; its available for inspection at the dealership. * I could have crashed into others from the heavy smoke that blinded my sight, my family and i could have burned up or gotten blown up. * UNKNOWN * NO * NO

Car was being driven on a highway going around a turn and message for “ATV Service” appeared. Shortly after power to the steering wheel and lost jerked the car and came back. All electric lighting flickered and several other messages for service engine and transmission appeared.

Car started itself. Vehicle was sitting in garage and was Locked. The radiator fans came on and vehicle started on its own. it continued to run until we unlocked and hit the stop button. Since this has happened it does not turnover on the first attempt. It has set several codes, Start stop unavailable, service electronic throttle, service engine now. My concern is if the vehicle were to start in the garage while we were asleep and carbon monoxide would leak into the house.

The brake by wire system failed, and another component caused the vehicle to accelerate when I hit the brake pedal. I didn't have any proof on the last complaint, but I have it now. This brake failure caused me to rear end someone, which caused a multiple vehicle accident. The dealership I took it to was aware that I was having electrical issues with the car, but they said they couldn't do anything about it because they couldn't find any fault codes. I even sent them a video of it as well. I also believe this car was involved in a prior accident as well by one of the previous owners and fixed by one of them under the table, because the front bumper shock absorber plate broke in half, and had writing on it as well that looked like something a repair shop would do. This car is unsafe.

My Alfa Romeo only has 29,000 miles on it. It randomly dies on you and does not start. Might happen while you drive with the start/stop and also when you try to turn on the car. When speaking to an Alfa Romeo representative, they inform you that to fix it’s about $600 or higher and they are also aware that is a common problems with their cars. The representative informed me that to turn it back on, I have to disconnect the a wire on top of the battery. I’m not a mechanic and should not have to work with the electrical system of the car. After reconnecting that wire, there’s the electric stability control light that turns on and the steering wheel assist light turns on. It’s crazy that this is a know issue with these cars and the dealers try everything they can to charge you for that repair. Which makes the car completely unsafe.

While waiting for a traffic light to change, the vehicle turned off but immediately turned back on. About four miles later, the same situation happened again but this time it took me a few minutes to get it to start. The vehicle had 1/4 fuel on the tank. After refueling, it drove fine. It was fine again on my way home from work, at least most of the way. When I was near home, it started to shut off and back on at a few traffic lights, but was able to drive it home.

The contact owns a 2017 Alfa Romeo Giulia. The contact stated while driving at various speeds, the vehicle would suddenly shut off. During the failure, the check engine and auto stop/start warning lights were illuminated. The vehicle was taken to the local dealer who diagnosed that an unknown relay needed to be replaced. No further information was available. The contact indicated that the vehicle had been serviced for the failure on multiple occasions. The manufacturer was not notified of the failure. The failure mileage was 3,000.

Mileage: 3,000

DRIVING ALONG THE HIGHWAY THE CAR COMPLETELY SHUTS DOWN AND GOES INTO LIMP MODE. NO POWER STEERING, NO BRAKES, NOTHING. ABSOLUTELY HAZARDOUS AND A SAFETY ISSUE. NO WAY TO START THE CAR. NO WAY TO MOVE THE CAR UNLESS OWNER GOES UNDER THE CAR WITH A SPECIFIC TOOL AND UNLOCKS THE BREAKS MANUALLY. THIS IS THE SECOND TIME IT HAPPENED TO BE. I BELONG TO A GROUP OF CAR ENTHUSIASTS WHICH OWN THE SAME MODEL AND SEVERAL HAVE REPORTED TO HAVE THE EXACT SAME ISSUE.

Mileage: 19,120

TL* THE CONTACT OWNS A 2017 ALFA ROMEO GIULIA. THE CONTACT STATED THAT THE AUTO START STOP FEATURE FAILED TO FUNCTION AND THE VEHICLE SPONTANEOUSLY JERKED. THE AUTO STOP WARNING LIGHT ILLUMINATED ON OCCASION. ADDITIONALLY, THE HEADLIGHTS RANDOMLY TURNED ON AND FLASHED FOR HOURS WHILE THE VEHICLE WAS TURNED OFF. THE CONTACT ATTEMPTED TO TURN THE VEHICLE ON AND OFF HOWEVER THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO DORSCHEL AUTOMOTIVE GROUP (3817 W HENRIETTA RD, ROCHESTER, NY 14623, (585)334-9440), WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE OPERATED AS DESIGNED REGARDING THE AUTO START/STOP FEATURE. THE CONTACT WAS ALSO INFORMED THAT WATER ENTERED THE HEADLAMP ASSEMBLY AND THE PINS WERE CORRODED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 25,000.*BF*JB

Mileage: 25,000

ENGINE OVER HEATS TO POINT U FEEL THE HEAT IN THE CAR WHILE DRIVING AT TIMES THE ELECTRICAL WHICH THEY HAVE RECENTLY PUT IN NEW SYSTEM FOR RADIO NAVIGATION WHILE DRIVING WHEN ELECTRICAL SHUTS THE RADIO HEAD ODOMETER SYSTEM AND AND INTERIOR LIGHTS SHUT CAUSING TO PULL OVER SUNROOF HAD RECENT ISSUES AS WELL AND NOW DOES OPEN OR CLOSE INTO BUTTONS POSITIONS ONLY ONE BUTTON OPENS AND CLOSES IT SIMULTANEOUSLY WITH INSIDE SUN BLOCKER AND CAN'T CONTROL DISTANCE OF POSITION U WANT IT OPENED MOSTLY CONCERNED THE ENGINE REVS HIGH AND AC WHICH DOESN'T SEEM TO WORK WELL WHILE DRIVING AND FEEEL HEAT AND ODOR AS IF IT'S OVERHEATING AND HAVE TAKEN TO PROFESSIONALS THAT CHECKED ALL OIL ANTIFREEZE ALL FINE ANTIFREEZE SUPPOSE FEED INTO MUTILPLE TANK DOESN'T AS ITS SUPPOSE TO

CRITICAL ISSUES: 'START / STOP DISABLED WHEN AUTO IS ACCELERATED DURING OVER TAKE OR ENTERING FREEWAYS. 'CHECK ENGINE LIGHT FAULTS WHEN CAR SURGES AND ENGINE BECOMES UNRESPONSIVE DURING DRIVING. 'INFOTAINMENT SYSTEM CRASHES FREQUENTLY. 'ENGINE STALLS WHILE DRIVING IN TRAFFIC OR WHEN IN USE DURING NORMAL DRIVING. 'WHEN STALL OCCURS POWER IS LOST TO THE VEHICLE WHILE DRIVING. (SHUTS OFF) 'AUDIO SYSTEM UNAVAILABLE WARNING LIGHT COMES ON. ONO AUDIO AVAILABLE OPARTIAL AUDIO AVAILABLE (NO AMPLIFICATION OR QUALITY AUDIO AVAILABLE) ONO WARNING SOUNDS OR AUDIO ALERTS AVAILABLE OLOUD HISSING STATIC OVER THE SPEAKERS. 'CAR GASPS FOR AIR AND WILL NOT FOR ACCELERATE 1-2 SECONDS WHILE DRIVING

Mileage: 24,000

TL* THE CONTACT OWNS A 2017 ALFA ROMEO GIULIA. WHILE THE VEHICLE WAS PARKED IN THE GARAGE, THE ENGINE STARTED ON ITS OWN AND THE ELECTRONIC IGNITION AND ENGINE ERROR INDICATORS ILLUMINATED. ON ANOTHER OCCASION, WHILE THE VEHICLE WAS STOPPED, IT STALLED. THE VEHICLE WAS TOWED TO LANDERS MCLARTY DODGE CHRYSLER JEEP RAM (256-830-6450, LOCATED AT 6533 UNIVERSITY DR NW, HUNTSVILLE, AL 35806), BUT THE TECHNICIAN WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.

Mileage: 12,000

I PURCHASED THIS VEHICLE AT THE END OF MAY 2017, AFTER PUTTING ON ABOUT 500 MI WITHIN 4 WEEKS, A CHECK ENGINE LIGHT CAME ON, I TOOK IT TO THE DEALERSHIP, THEY KEPT IT OVERNIGHT,LOOKED AT IT, AND CALLED THE FOLLOWING DAY & SAID THERE WAS "SOMETHING LOOSE THAT NEEDED TO BE TIGHTENED" AND THAT THE CAR WAS READY FOR PICK UP. I DROVE THE CAR AND PARKED IT IN MY GARAGE. THE FOLLOWING DAY, I TOOK THE CAR OUT, TURNED IT AROUND AND BACKED IT UP TO PARK IN FRONT OF MY GARAGE, I WAS GOING SLOWLY (UNDER 5 MPH) THE BRAKED LOCKED UP AND THE CAR ACCELERATED IN REVERSE HITTING MY GARAGE BEFORE I COULD STOP IT BY TURNING OFF THE ENGINE. I CALLED THE DEALERSHIP, BUT GOT NO RESPONSE. A FEW HOURS LATER I HAD A LUNCH APPOINTMENT. THE MAN I WAS MEETING WANTED ME TO TAKE HIM FOR A SHORT RIDE IN THE CAR, WHICH I DID. AS WE RETURNED TO THE RESTAURANT, I PULLED INTO THE PARKING SPACE SLOWLY, AND ENGAGED THE BRAKES, AGAIN THE CAR WENT INTO SUDDEN ACCELERATION, GOING OVER ARBORVITAE TREES AND INTO A NEIGHBORING PARKING LOT. THE DEALERSHIP WAS CALLED AND THE CAR TOWED. ON BOTH OF THESE OCCASIONS I WAS DRIVING SLOWLY, BOTH TIMES I HAD MY FOOT ON THE BRAKE AND FELT THEM LOCK AS THE CAR WENT INTO ACCELERATION, AND BOTH TIMES I HAD TO TURN OFF THE CAR TO GET IT TO STOP.

Mileage: 500

THE ENGINE STALLED FOLLOWING FUEL TOP OFF. IT STALLED MOVING IN SLOW TRAFFIC.

Mileage: 800