2014 BMW 328D Fuel/propulsion System Problems

While operating a normal speed and tempature, the low pressure fuel retuen lone burst. Fuel sprayed throughout the engine bay to include the exhaust manifold. Had this been a gasoline car a fire could have ensued.

I was driving to work when my engine started sputtering acting like it was about to turn off. I quickly pulled off to the side of the road and as soon as I did, the engine stalled and turned off. I'm lucky that I pulled off the road because if it turned off while on the road I could have caused an accident. The car is no longer able to turn on. I had to get it towed to my work where I had a mechanic look at it. They said they believe the high-pressure fuel pump failed. I researched this online and saw that there is an open NHTSA campaign for it (#21V586000). My car is a 2014 BMW 328D with the N47 engine. It seems that my car would fall under this recall but when I put in my VIN it says it does not have a match for it. How is it possible for my vehicle to be accepted into this recall.

Due to its diesel related scandals, BMW has agreed to extend its diesel emission related components' warranty to 10 years or 120k miles. My 2014 BMW 328d's nox sensor failed in 2022 and i submitted my repair bill for replacing the nox sensor to bmw recently. BMW denied my reimbursement claiming the warranty expired despite the documents i submitted was for a repair done in 2022 with credit card receipts and repair shop copy of work done.

Faulty fuel injectors , that are known to prematurely fail. The same injectors are covered by BMW for model years 2015-2018 Under NHTSA SIB 01 09 19. My complaint is my 2014 has the same fuel injectors as the 2015-2018 that are known to be faulty and yet it is deliberately excluded from the same “limited warranty extension “

While driving our 2014 BMW 328d the engine misfired then stalled on the highway. This was a very dangerous and frightening scenario trying to push it off of the roadway while my wife and children were inside the car while highway traffic on the I-15 interstate rushes by. I was not able to restart, so we had it towed to our local BMW shop. Diagnosed as High Pressure Fuel Pump complete failure. Metallic debris throughout the entire fuel system, lines, tank filter, injectors, pumps. No check engine light or any prior warning. Many of the components have already been disassembled to determine the extent of damage, and all the components are currently with the vehicle, and available for inspection. The vehicle has been at the shop since the end of June. Some parts were initially ordered then all repairs put on hold while awaiting direction/ recall approval from BMW of North America. 5 months later we are being told this vin does not qualify for the safety recall. We can not afford the cost of the repairs and they will likely exceed the value of the car. We also need to remove it from storage at the shop it was towed to, and take it somewhere else while this is sorted out.

High pressure fuel pump failed while underway causing vehicle to immediately stall in traffic and lock in "Park" making it unable to move. Mechanic (Werner's European Auto) confirmed diagnosis of catastrophic failure of the pump. Part is available for inspection. This part for the gasoline version of the 2014 328 series car is subject to a recall notice but for some reason the notice does not apply to the diesel version of this model. Repair cost is estimated at $11,000 to replace entire fuel system due to metal particles released when the pump broke

Subject: Urgent Complaint Regarding Potential Safety Hazard in 2014 BMW 328D Fuel Injector I am writing to report a serious safety concern regarding my 2014 BMW 328D. On about August of 2023, while operating my vehicle, I experienced a sudden and alarming issue that poses a significant risk to both myself and other motorists. As I came to a routine stop, smoke began pouring out from under the hood of the vehicle, obscuring my vision through the windshield. Simultaneously, a strong odor of diesel permeated the interior of the passenger compartment. Concerned for my safety, I immediately investigated and discovered that the fuel injector area was drenched with diesel fuel. Upon further inspection by a qualified mechanic, it was determined that a crack had developed in the fuel injector, causing the leak. This defect not only poses a serious fire hazard but also exposes occupants to toxic diesel fumes, creating an immediate and grave risk to safety. My concern is exacerbated by the fact that this incident appears to be part of a larger pattern of failures in BMW diesel automobiles. I have conducted research and found numerous recalls related to faulty fuel injectors in various BMW models over different years. However, to my astonishment, the 2014 BMW 328D, including mine, has not been included in any such recall despite the clear evidence of a recurring issue with fuel injectors. Given the severity of the situation and the potential danger it poses to myself and others on the road, I urge the National Highway Traffic Safety Administration (NHTSA) to thoroughly investigate this matter. It is imperative that immediate action be taken to address this safety hazard, including the consideration of a recall for the affected vehicles. I kindly request a prompt response regarding the steps being taken to address this issue and ensure the safety of all BMW 328D owners.

stall/loss of power while entering highway on ramp. Engine died and would not restart. After inspecting car found the gas tank to be filled with metal shavings which is indicative of a failed high pressure fuel pump. My year make and model vehicle has a recall on the HPFP for the same reason but my VIN was supposedly not affected.

Driving vehicle home from work and it completely lost power and died. ""Drivetrain Malfunction" error popped up on the screen. Vehicle would crank but not start. Towed to repair shop. High Pressure Fuel Pump issue is on the radar for 2014 BMW 328D, BMW has recalled less than 12000 cars. My vehicle is not currently on the recall list.

I was in a busy Freeway driving & Now my 2014 Bmw 328 D high pressure fuel failed which caused me to stall and be stuck in the middle of the freeway which also almost made me cause like 10 car crashes it was sorry scary but lucky police helped out and other driver where also caution

I am having the same exact issues at the models 2015 and up have experienced with the fuel injectors. 2014 wasn’t involved in the extension of the warranty when It experiences the same failures because It’s the same parts. I have 3 fault codes for injectors

i was told by BMW that my vehicle doesn't qualify for RECALL 21V-586. however my high pressure fuel pump failed at about 130,000 miles. i am trying to be reimbursed for my cost of parts under the TREAD ACT but BMW says my vin wasn't included by NHTSA. the recall seems to cover all BMW diesels from 2014 to 2018. please help. Michael Kanterakis, [email protected] 973-432-0673. thanks

High pressure fuel pump failed while BMW dealership mechanic was test-driving car after replacing two tires/oil change/replacing fuel filter/performing fix for recall of egr cooler part; per the service manager at the dealership, metal particles were subsequently found in the quantity control valve, necessitating complete replacement of fuel system. There is a known recall for year, make and model of my car (2014 BMW 328d) for the fuel pump, but apparently my VIN number is not falling under the recall. This issue appears identical to the issue the recall was issued for other cars with this same year/make/model. I have not performed the repair as they are quoting about $17,000 for the fix. There were no warning lights, messages or symptoms of the problem prior to this issue. In addition, they indicated I needed a new o-ring part for the fuel filter they were replacing as it was the wrong part, but they said it had nothing to do with the fuel pump. (Service said the o-ring continued to hold and was working as normal, and they recommended putting the correct by part number o-ring in its place so the fuel filter would not have come unsecured from its fitting in the future. They said the issue with the vehicle did not come from the o-ring/fuel filter; it is by their determination based upon the metal shavings in the quantity control valve, caused because the high pressure pump came apart internally and contaminated your fueling system. They said this is due to age.) They indicated that had the pump failed while I was on the highway or traveling I and/or others could have been seriously injured or killed. No one else has inspected the car at this point and it remains at the dealership for now.

ISSUE: HPFP High Pressure Fuel Pump is failing resulting in an increasing deposit of metallic shavings within the pump housing and a corresponding deviation in the measured fuel rail pressure. SAFETY: The vehicle will code and shut down while you are driving. BMW DEALERSHIP: Replaced items other then the root cause HPFP. A new fuel rail and sensors installed at my expense because of dealership decision. 1,000 miles after repair at dealership, codes came back for low pressure and high pressure faults. Warning lamps on and car shut offs while driving. Make and model of car with the same issues but VIN is not on this recall? NHTSA Campaign Number: 21V586000

I suffered a breakdown in my 2014 BMW 328d on 26 Oct 21 with a drive train malfunction warning. Vehicle stalled and was unable to be restarted. Vehicle was towed to local repair shop, International Auto Specialist, located in Fredericksburg, VA, and diagnosed as a high pressure fuel pump failure and calling for the entire replacement of the vehicles fuel system. At the recommendation of my local repair shop, the vehicle was then towed 59 miles to the closest BMW dealership, BMW Fairfax, VA, for repair. The safety issue I have is that a recall notice (Recall Campaign #21V-586) was issued by BMW North America in September 2021 for High Pressure Fuel Pump failures affecting 2014-2018 BMW diesel engine vehicles ranging from 3 Series, 5 Series, 7 Series, X3 SAV, and X5 SAV models. I never received a recall notice for this vehicle, or my 2015 BMW X5d SAV, and have been told by BMW Fairfax, VA, and BMW Corporate that my high pressure fuel pump only carries an extended 10-year, 120,000 warranty, even through both vehicles falls within the parameters of the open recall notice issued by BMW North America. Further, BMW Fairfax, VA has informed me that all other parts damaged by the High Pressure Fuel Pump failure are not covered by the extended warranty and any cost associated with additional repairs is the customers responsibility, regardless of the fact that they will only replace the defective part at the time of failure and not before. How can BMW North America issue a recall notice for a specific group of vehicles, but not include all vehicles that fall within the specifications associated to the recall? This part failure occurred while I was driving in heavy traffic and I was fortunate it did not cause series bodily harm to myself or others. I respectfully request you investigate the situation to determine BMW's liability and inept handling of this recall in order to prevent others from being harmed. Documentation can be provided if necessary. Thank you.

In July 2021 I was driving on a residential street when my vehicle experienced loss of power. The vehicle shutdown and stopped in the middle of the road. Mechanic found metal particles in fuel system that may have been cause by fuel pump failure. It was reported to insurance company. The fuel system was replaced but vehicle continues to have issues with leaks etc.

While on a red light we were at a dead stop. As the light turned green to turn right I accelerated the gas pedal and the car stalled out in the middle of the road while traffic was flowing. Had to push the car out of the road and had to get the car towed home. Now the car doesn’t turn on it just cranks over.

On my drive home I noticed a strong smell of dizel fuel.Stoped as soon as it was possible . Noticed a fuel was poring to the ground under my engine. Shut it down and call AAA. At the BMW dealership repair shop they found a broken fuel supply line that was rubbing against the vacuum pipe.My car was covered with fuel from engine to a trunk to everything under including muffler ,soaking wet weals and tires, I lost a half tank of fuel in about 5 minutes. It's scare me a lot ,I think it was a miracle it did not catch a fire on 93 degree day, my wife will never sit in this car again.I will feel guilty if I will sell this car to somebody else.Don't know what to do now. What kind of design it is? How fuel line can constantly rub something else? This car just over 70000 miles, garage kept, never been in any accidents, well maintain.

Mileage: 70,000

I HAVE TWO ISSUES WITH MY 2014 BMW 328D. FIRST, ON SEVERAL OCCASIONS WHILE BACKING UP INTO MY DRIVEWAY ON REVERSE THE TRANSMISSION SHIFTS UNEXPECTEDLY INTO NEUTRAL. I HAVE TO PUT IT INTO "D" AND DRIVE THE CAR FORWARD BEFORE THE TRANSMISSION ENGAGES AGAIN INTO REVERSE. THE PROBLEM IS INTERMITTENT AND OCCURS ABOUT ONCE A MONTH AND ONLY WHILE PUTTING THE GEAR IN REVERSE. THE SECOND ISSUE IS THAT MY VEHICLE RECENTLY FAILED THE CA EMISSIONS TEST. ON 11/23/2021 I TOOK THE VEHICLE TO BMW OF EL CAJON FOR AN INSPECTION. THE DEALER DIAGNOSED A PROBLEM WITH THE 4 DIESEL INJECTORS AS FAULTY AND ISSUED A REPAIR ESTIMATE. AFTER ONLINE RESEARCH ON YOUR SITE NHTSA.GOV, I FOUND THAT BMW HAD ISSUED A LIMITED EXTENDED WARRANTY OF 10 YEARS OR 120K MILES FOR THE DIESEL INJECTORS BUT ONLY FOR MODEL YEARS 2015-2016, OR PRODUCTION DATE OF 7/2014 TO 6/2016. MY VEHICLE WAS PRODUCED ON 08/2013. I AM ASKING THE NHTSA TO PLEASE INVESTIGATE WHY MY VEHICLE'S MODEL YEAR/PRODUCTION DATE WAS NOT INCLUDED IN THE LIMITED WARRANTY EXTENSION CONSIDERING THAT IS THE SAME PRODUCTION MODEL (F30), AND ENGINE (N47T) AS THOSE COVERED IN THE EXTENDED WARRANTY, AND IS HAVING THE SAME DIESEL INJECTORS PROBLEM. FOR REFERENCE BMW'S SIB IS 01 09 19 ISSUED ON 10-11-2019.

Mileage: 109,621

I HAVE A 2014 328D F31 THREE WEEKS AGO WHILE TURNING INTO A PARKING SPOT AT A GROCERY STORE PARKING LOT AT LOW SPEED, MY 328D SHIFTED TO P MID TURN, AND THE ENGINE SHUT OFF. UPON TRYING TO RESTART IT, IT WOULD CRANK BUT NOT TURN OVER. (THANKFULLY, I WAS IN A PARKING LOT AND GOING AT SLOW SPEED - AND NOT ON THE INTERSTATE). WE HAD TO MANUALLY GET IT SHIFTED INTO NEUTRAL TO BE ABLE TO PUSH IT INTO A PARKING SPOT. UPON FURTHER INSPECTION, IT WAS DETERMINED THAT THE HIGH PRESSURE FUEL PUMP HAS FAILED. (THANKFULLY IT DOESN'T APPEAR TO BE DISINTEGRATED AS SOME OTHERS HAVE REPORTED). ALL OPEN RECALLS HAVE BEEN REPAIRED. THIS VEHICLE HAS BEEN VERY WELL MAINTAINED, AND GREAT EFFORTS HAVE BEEN TAKEN TO ENSURE ONLY QUALITY, FRESH DIESEL HAS BEEN PUMPED IN THE CAR. BMW HAS OFFERED AN EXTENDED WARRANTY FOR THIS (NOT CHEAP) PART. HOWEVER, IT'S ONLY UP TO 10 YEARS OR 120,000 MILES, AND MY VEHICLE IS AT 128,000. I AM INCREDIBLY GRATEFUL THAT NO ONE WAS HURT, INJURED, OR WORSE IN THIS INCIDENT. BUT GIVEN THE HIGH FREQUENCY OF THIS HAPPENING AMONGST OTHER 328D OWNERS, AND THE SAFETY IMPLICATIONS (MANY TIMES ON THE INTERSTATE), I WOULD EXPECT THAT BMW WOULD RECALL THIS VEHICLE AND GET THESE PARTS REPLACED BEFORE ANYTHING WORSE HAPPENS. IT HAPPENED QUICKLY AND SUDDENLY WITH NO PRIOR PERFORMANCE WARNINGS, CODES, OR LIGHTS. IN FACT WHEN RUNNING A FOXWELL SCHWABEN 14020SCH SCANNER, NO CODES ARE BEING RETURNED. AN ADDITIONAL SAFETY CONCERN OF COURSE IS THAT THIS PROBLEM IS NOT PREVENTABLE WITH TRADITIONAL DIAGNOSTICS. MY GOOGLE RESEARCH SHOWS THE BOSCH FUEL PUMP WAS RECALLED IN OTHER MODELS, BUT THE RECALL EXEMPTED THE DIESEL VARIANTS. I CAN'T IMAGINE AN ITEM PRONE TO FAILURE, THAT'S NOT LISTED ON A REPLACEMENT SCHEDULE. THERE ARE MULTIPLE LAWSUITS OUT THERE ON THE BOSCH CP4 FUEL PUMPS. (HOWEVER CP4.2 SEEMS TO BE MORE RELIABLE THAN THE CP4.1).

Mileage: 128,000

TL* THE CONTACT OWNS A 2014 BMW 328D. THE CONTACT STATED WHILE DRIVING AT 5 MPH, WHEN THE VEHICLE STALLED. THE CONTACT STATED UNKNOWN RED ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO LOCAL DEALER BMW OF RIVERSIDE LOCATED AT 3060 ADAMS ST, RIVERSIDE, CA 92504, (951) 373-5000, WHERE IT WAS DIAGNOSED WITH NEEDING THE FUEL SYSTEM REPLACED. THE VEHICLE WAS REPAIRED HOWEVER THE CONTACT STATED HE CONTINUED TO EXPERIENCE THE FAILURE. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 70,000. *LN CONSUMER SAYS THAT THE SECOND TIME THE FAILURE OCCURRED HIS WIFE WAS DRIVING ON THE FREEWAY. THE FAILURE MILEAGE WAS 90,000. THE MANUFACTURER CREATED AN EXTENDED WARRANTY FOR THE ISSUE. *DL

Mileage: 70,000

AT AROUND 70K BOTH NOX SENSORS IN MY CAR FAILED. BMW COVERED IT UNDER WARRANTY, BUT I'M WORRIED ABOUT RELIABILITY OF THIS SYSTEM. IT MIGHT HAPPEN AGAIN IN FUTURE AND IF IT HAPPENS AFTER 120K MILES BMW WON'T COVER IT.

Mileage: 72,000

DEF TANKS FROZE IN COLD WEATHER CAUSING MULTIPLE PARTS TO FAIL IN THE ENGINE. DEF SYSTEM I BELIEVE IS NOW COMPROMISED AS A RESULT OF POOR ENGINEERING FOR THE OVERALL SYSTEM. VEHICLE IS PARKED OUTSIDE AND THERE WERE TEMPERATURES WELL BELOW ZERO.

Mileage: 90,000

I GOT A CEL AND DROPPED IT OFF AT THE DEALER. THEY SAID IT WAS TO THE ACTIVE SCR TANK. AFTER RESEARCH I FOUND OUT A LOT OF BMW VEHICLES HAVE THE ITEM FAIL. THE 328D IS NOT ON THE LIST OF EXTENDED WARRANTIES. ARE THERE MANY 328D'S THAT FAIL?

Mileage: 53,996

MY VEHICLE CURRENTLY HAS AN EGR PROBLEM BUT FOR SOME REASON ISN'T COVERED UNDER THE RECALL... SOMETIMES MY FRONT PASSENGER DOOR WILL NOT OPEN! LIKE AT ALL! I WILL HAVE TO HIT THE UNLOCK BUTTON MULTIPLE TIMES BEFORE I CAN OPEN THE DOOR. MY DEF WAS FILLED WITH THE CORRECT FLUID AT THE APPROPRIATE TIME ABOUT 1K MILES AGO. SUDDENLY AS I'M DRIVING DOWN THE ROAD A LIGHT APPEARED THAT SAYS INCORRECT FLUID ADDED NO START AFTER XXX MILES. NOW VEHICLE WILL NO LONGER START. AFTER SEARCHING THE WEB OTHERS HAVE HAD THIS ISSUE CONNECTED TO NOX SENSOR. TAKING TO SHOP HOPEFULLY COVERED SINCE NOX SENSOR WAS JUST REPLACED FROM A RECALL.

Mileage: 99,000

VEHICLE CRUISING AT 70MPH ON THE FREEWAY WHEN THE CAR STALLED OUT WITH NO WARNING. IT SIMPLY WENT INTO NEUTRAL AND CUT THE ENGINE, RENDERING THE VEHICLE HARD TO CONTROL SINCE POWER STEERING AND BRAKING WERE NOT WORKING. THE CAR BROKE DOWN AGAIN WITHOUT WARNING ON A CITY SURFACE STREET WITH A SPEED LIMIT OF 45MPH. INDEPENDENT MECHANIC DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP IMPLODED, SENDING METAL THROUGHOUT THE ENTIRE FUEL SYSTEM. AGAIN THERE WAS NO WARNING AND BRAKING/STEERING WERE AFFECTED.

Mileage: 176,000

WHEN CAR WAS IN MOTION IT SPUTTERED, STARTED LOSING POWER, AND WHEN I PULLED OVER THE ENGINE DIED AND WOULDN'T RESTART. DEALER DIAGNOSED IT AS FAILURE OF FUEL PUMP, WITH BMW REQUIRED REPAIR TO INCLUDE REPLACEMENT OF ENTIRE FUEL DISTRIBUTION SYSTEM AT ESTIMATED COST OF $11,400

Mileage: 153,000

EXHAUST GAS RECIRCULATION (EGR) COOLER RECALL: CONTACTED BMW CUSTOMER RELATIONS AS PER RECALL LETTER FROM BMW OF N.A. VIA EMAIL AND THEY LEFT A VOICE MAIL THAT PARTS HAVE NOT BEEN AVAILABLE. RECALL STATUS ALSO HAS BEEN STATING - "REMEDY NOT YET AVAILABLE". RECALL WAS MADE IN OCT 25, 2018 AND IT IS NEARING 6 MONTHS BUT NO SOLUTION OR REPAIR PROCESS HAS BEEN INITIATED. LETTER STATES POSSIBILITY OF INCREASED RISK OF FIRE COULD OCCUR IF ENGINE INTAKE MANIFOLD HAS SMALL HOLES DUE TO FAILURE OF EGR. KINDLY PLEASE HELP WITH THIS UNTIMELY AND UNREASONABLE TIME PERIOD OF REPAIR LINGERING WITHOUT ANY SAFETY FOR THE DRIVER OF THIS CAR. CURRENTLY NO PROBLEM HAS OCCURRED BUT FEELING OF DRIVING ON BORROWED LUCK AND TIME IS NOT A SAFE ONE. THANK YOU FOR YOUR HELP.

WHILE DRIVING AT 65 MPH OR SO THE VEHICLE'S ON-BOARD MESSAGE CENTER READ "DRIVE-TRAIN MALFUNCTION". I PRESSED ON THE ACCELERATOR AND THERE WAS NO RESPONSE. THE VEHICLE WAS LOOSING MOMENTUM QUITE QUICKLY WHICH REQUIRED ME TO SWIFTLY, BUT SAFELY TO PULL OVER TO THE ROADWAY EDGE. THIS IS THE THIRD TIME THE ISSUE HAS PRESENTED ITSELF. THE FIRST TIME WAS A FEW MONTHS FROM PURCHASING THE VEHICLE. THE DEALER FOUND METAL SHAVINGS IN THE FUEL LINES. THEY REPLACED THE ENTIRE FUEL SYSTEM AND SENT ME OFF. A FEW MONTHS LATER I TOOK THE VEHICLE IN FOR SERVICE I.E. OIL CHANGE, INSPECTION, ETC. WHILE INSPECTING MY CAR THEY AGAIN FOUND METAL SHAVINGS IN THE FUEL LINES. THEY AGAIN REPLACED THE ENTIRE FUEL SYSTEM AND SAID IT WAS FIXED. JUST THIS WEEKEND SEPTEMBER 30, 2018, I WAS DRIVING MY VEHICLE ON THE FREEWAY AND AGAIN THE CAR WENT LIMP. NO POWER, LIMITED STEERING CONTROL, NO RESPONSE FROM ACCELERATOR. ESSENTIALLY A CATASTROPHIC EVENT BECAUSE WITHOUT POWER A VEHICLE IS A ROLLING PROJECTILE. ACCORDING TO THE DEALERSHIP THE VEHICLE ONCE AGAIN HAS METAL SHAVINGS IN THE FUEL SYSTEM. TOTAL COUNT FOR REPLACING FUEL SYSTEM (3).

Mileage: 64,917

MARCH 6, 2018, MY CAR STARTED SHAKING AS I MERGED FROM 101 TO 405 S IN LOS ANGELES. MESSAGE INDICATED A DRIVE TRAIN PROBLEM AND TO "DRIVE MODERATELY". CAR STOPPED AND WOULD NOT RESTART SECONDS LATER. WHILE WAITING FOR A TOW, WAS REAR ENDED AT A DEAD STOP. BMW SANTA MONICA FOUND METALS SHAVINGS IN FUEL LINE AND REPLACED FUEL SYSTEM; MY CAR ALSO HAD $13,000 OF BODY DAMAGE. I HAVE SEEN MANY OTHER REPORTS OF THE SAME PROBLEM - BMW SHOULD HAVE RECALLED THE CAR TO FIX THE FUEL SYSTEM BEFORE I HAD AN ACCIDENT. NOW MY CAR IS DEVALUED AND I DO NOT HAVE SAME LEVEL OF CONFIDENCE IN DRIVING IT.

Mileage: 30,000

WITHOUT ANY WARNING, THE VEHICLE LOST POWER SUDDENLY/ ABRUPTLY STOPPED ON A BUSY CITY STREET. THE VEHICLE ALMOST GET SLAMMED INTO BY OTHER VEHICLES TRAVELING BEHIND IT. THIS WAS POTENTIALLY A CAUSE FOR A FATAL ACCIDENT. BMW DEALERSHIP INFORMED THAT THE CAUSE WAS THE SUDDEN FAILURE OF THE FUEL PUMP. VEHICLE IS AT 39,900 MILES, & IS COVER BY BMW CERTIFIED PRE-OWNED WARRANTY.

Mileage: 39,900

WHILE ACCELERATING MY 2014 BMW 328D I HEARD A GRINDING NOISE AND THE CAR HIT THE BRAKES SO HARD THAT THE SEAT BELT PINNED ME AGAINST THE SEAT AND MY CHEST HURT AFTER THAT FOR A COUPLE DAYS. I CALLED BMW ROADSIDE AND THE POLICE TO ASSIST WITH TRAFFIC SINCE I WAS IN THE MIDDLE OF THE ROAD, WAS LATE EVENING AND RAINING ALSO. THE POLICE OFFICER TRIED TO MOVE THE CAR BUT THE WHEELS WERE LOCKED AND WAS UNABLE TO PUT IT IN NEUTRAL OR MOVE. WHILE GETTING OUT OF CAR HE TELLS ME THAT I AM LUCKY IN HIS OWN WORDS "ON THIS WEATHER ON THE FREEWAY YOU WOULD'VE BEEN DEAD BY NOW". ALSO THE TOW TRUCK DRIVER HAD THE SAME LINE AS THE OFFICER AND HE DRAGGED THE CAR ON THE BED SINCE THE WHEELS WERE LOCKED. THE CAR WAS TAKEN TO THE DEALER AND BMW DIAGNOSED IT AS "FUEL PUMP BLEW UP INTERNALLY AND DISTRIBUTED METAL SHAVINGS THROUGHOUT THE ENTIRE FUEL SYSTEM AND THROUGH INJECTORS." 4 INJECTORS NEED REPLACEMENT ALONG WITH THE FUEL RAIL, THE FUEL PUMP AND REPAIRS MADE TOT THE ENTIRE FUEL SYSTEM INCLUDING THE TANK. BMW WILL COVER EVERYTHING SINCE THE CAR IS STILL UNDER WARRANTY ( I AM AT 45 K MILES)! MOST TRAUMATIZING EXPERIENCE OF MY 40 YEARS LIFE IN A 50K+ CAR! BMW NEVER WARNED ME OF POSSIBLE FUEL PUMP FAILURE PROBLEM WITH THEIR DIESEL CARS AND NO CAR SHOULD PIN YOU WITH THE SEAT BELT AGAINST THE SEAT UNLESS IT'S AN ACCIDENT!

Mileage: 45,000

I WAS DRIVING HOME FROM WORK ON NOVEMBER 16TH AND WAS WITHIN A COUPLE MILES OF MY HOUSE WHEN I HEARD A LOUD BANG AND A WHIRRING SOUND COMING FROM MY CAR. THERE WAS AN ERROR MESSAGE THAT POPPED UP STATING DRIVETRAIN MALFUNCTION, DRIVE CAUTIOUSLY.' THE CAR BECAME VERY JERKY AND I DROVE SLOWLY. I WAS FORTUNATE TO MAKE IT BACK TO MY DRIVEWAY, BUT THEN MY CAR COMPLETELY FAILED. I HAD THE CAR TOWED TO THE DEALERSHIP AND THE CALLED TO LET ME KNOW THE TRANSFER CASE HAD FAILED. THANKFULLY I WASN'T INJURED IN A CAR WRECK WHEN THE IT FAILED. THE CAR ONLY HAD ABOUT 46,500 MILES AND WAS COMPLETELY COVERED UNDER WARRANTY. I WAS FORTUNATE TO GET HOME, BUT A COMPLETE FAILURE COULD HAVE LED TO BEING STRANDED OR WORSE, AN ACCIDENT.

WHILE DRIVING DOWN THE INTERSTATE ON OCT. 22, 2017 MY VEHICLE TURNED OFF IN THE MIDDLE OF THE ROAD DISPLAYING AN ERROR SAYING "DRIVE TRAIN MALFUNCTION". THE CAR WENT FROM GOING 60MPH TO A DEAD STOP. I WAS STRANDED IN THE ROAD WHILE CARS WERE ZIPPING PAST ME AT LEAST 60MPH. I WAS IN SOME SERIOUS DANGER IF IT WASN'T FOR THE FAST RESPONSE OF THE TOW TRUCK TO GET ME OUT OF THERE (THE POLICE WERE CALLED AS WELL TO DO TRAFFIC CONTROL BUT THE TOW TRUCK SHOWED UP BEFORE THEY EVEN GOT THERE). THE VEHICLE WAS TOWED TO A BMW DEALER. THEY RAN SOME TESTS AND TOLD ME IT WAS A FUEL PUMP PROBLEM. THEY SAID THE FUEL PUMP BROKE INTERNALLY AND DISTRIBUTED METAL SHAVINGS THROUGHOUT MY ENTIRE FUEL SYSTEM AND THROUGH MY INJECTORS. ALL 4 INJECTORS NEED REPLACED ALONG WITH THE FUEL RAIL AND THE FUEL PUMP AND REPAIRS MADE TOT THE ENTIRE FUEL SYSTEM. MY CAR IS ONLY AT 66K MILES. I DID SOME RESEARCH TO SEE IF THIS PROBLEM WAS RECALLED BECAUSE THIS IS A VERY UNSAFE PROBLEM TO HAVE. AFTER LOOKING, I SAW THAT A RECALL WAS SENT OUT FOR ALL BMW MODELS EXCEPT FOR THE 328D(DIESEL). WHY IS THAT? HOW DO YOU CLAIM SOMETHING IS UNSAFE ON A CAR USING THE SAME PARTS THAT JUST GOT RECALLED BUT EXCLUDED THE DIESEL MODEL. I HAVE READ SOMETHING STATING THERE WAS NOT ENOUGH COMPLAINT TOWARDS THE DIESEL MODEL BUT THE 328D WAS NOT PRODUCED NEARLY AS MUCH AS SAY THE 328I, SO OBVIOUSLY IT WILL HAVE FEWER COMPLAINTS. I CAN SEE RIGHT NOW 5 PAGES OF COMPLAINTS ABOUT THE SAME SAFETY ISSUE I AM HAVING THAT SAYS OTHERWISE. NOW I AM PAYING UPWARDS OF $16,000 DOLLARS DUE TO A SAFETY ISSUE. THIS DOESN'T SEEM ETHICALLY CORRECT ON ANYONE'S END. HOW IS THERE NO RESOLUTION TO THIS PROBLEM? WE ARE GOING TO LET PEOPLE COME TO A COMPLETE STOP ON THE INTERSTATE AN RISK A MAJOR ACCIDENT. I CAN'T BELIEVE THIS HAS SLIPPED THROUGH THE CRACKS WHEN ALL OTHER MODELS WERE RECALLED FOR THE EXACT SAME PROBLEM!!

Mileage: 66,000

HIGH PRESSURE FUEL PUMP FAILED CAUSING CATASTROPHIC DAMAGE TO ENTIRE FUEL SYSTEM, REQUIRING REPLACEMENT OF ENTIRE FUEL SYSTEM INCLUDING FUEL PUMPS, FUEL LINES, TANK ETC. STALL OCCURRED ON BUSY STREET WHICH WAS A NEAR DEATH EXPERIENCE THAT COULD HAVE RESULTED IN ACCIDENT / INJURY / DEATH. MOST TERRIFYING EXPERIENCE OF MY LIFE. TOOK CAR TO CREVIER BMW AND DEALER STATED THAT THERE WAS NOTHING I COULD HAVE DONE TO PREVENT THE INCIDENT. 2014 2 SERIES, 3 SERIES, AND 4 SERIES ALL HAVE BEEN RECALLED FOR HIGH PRESSURE FUEL PUMP FAILURE. THE DIESEL MODEL APPEARS TO BE THE ONLY ONE NOT COVERED IN THE RECALL AND CLEARLY IS DEFECTIVE.

Mileage: 110,000

TL* THE CONTACT OWNS A 2014 BMW 328D. WHILE DRIVING 50 MPH AND SLOWING DOWN TO MAKE A TURN, THE VEHICLE SUDDENLY LOST ALL POWER AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO STEVE THOMAS BMW INC (411 E DAILY DR, CAMARILLO, CA 93010 (805) 482-8878) WHERE IT WAS DIAGNOSED THAT THE HIGH PRESSURE FUEL PUMP FAILED AND RELEASED METAL SHAVINGS INTO THE FUEL SYSTEM AND ENGINE. THE FUEL SYSTEM NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT RESEARCHED ONLINE AND FOUND NHTSA CAMPAIGN NUMBER: 15V189000 (FUEL SYSTEM, GASOLINE), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

Mileage: 50,000

2 OF 4 INJECTORS HAVE FAILED AT OR BEFORE 40000 MILES I THINK THE PROBLEM IS THE FUEL PUMP, THEY HAVE BEEN RECALLED IN THE GAS MODELS CHECK ENG.LIGHT CAME ON FUEL MILEAGE DROPED BY 35% DID NOT DRIVE ANYMORE TILL INJECTOR WAS REPLACED

Mileage: 41,000

AT 55K MILES IN APRIL 2017, IN FAST LANE OF FREEWAY, DRIVE-TRAIN MALFUNCTION MESSAGE DISPLAYED WITH SERVICE ENGINE LIGHTS. CAR LOST POWER AS I WAS FORTUNATELY ABLE TO CHANGE MULTIPLE LANES TO SHOULDER AS CAR LOST COMPLETE POWER. BMW SOS DID NOT FUNCTION. IT TOOK 3 TOW DRIVERS AND 3 HOURS TO MANUALLY OVERRIDE SYSTEM TO GET CAR IN NEUTRAL TO SAFELY PUT ON TRUCK. BMW ADVISED THEY WOULD HAVE TO JACK CAR AND REMOVE TRANSMISSION PANEL TO MANUALLY PUT IN 'DRIVE' WHICH WAS NOT AN OPTION ON THE NARROW SHOULDER OF I-10 IN CA. DIAGNOSTICS REVEALED HIGH PRESSURE FUEL PUMP FAILED AND 'EXPLODED' SENDING METAL PARTICLES THROUGH ENTIRE FUEL SYSTEM. DEALER ADVISED OVER $10K IN PARTS HOWEVER BMW COVERED UNDER THE 'CA EMISSIONS WARRANTY.' ENTIRE FUEL SYSTEM REPLACED (TANK, LINES, INJECTORS AND PUMP). UNSURE IF IT IS RELATED TO THE ULTIMATE FAILURE OF THE PUMP BUT ALL INJECTORS FAILED AND REPLACED IN 2016. 42,162 MI / SEPTEMBER 8, 2016 ENGINE LIGHT -FAULTY CYL 3FUEL INJECTOR FAULT CODE 24BD00 'REPLACED #3 44,495 MI / OCTOBER 13, 2016 ENGINE LIGHT-FAULT CODE 24C000 - REPLACED INJECTORS 1 AND 2 & 4

Mileage: 55,114

GOING ABOUT 60MPH, MY CAR COMPLETELY LOSES POWER AND SHUTS DOWN. POWER TRAIN MALFUNCTION LOSS OF POWER FLASH ON THE SCREEN. IVE HAD THE CAR FOR 20 DAYS, AND AT 52000 MILES. 2000 OVER MY WARRANTY. BMW IS AUOTIBG NE $5,000 TO FIX THE HIGH PRESSURE FUEL PUMP AND SYSTEM, FUEL RAIL SENSOR, AND FUEL RAIL PRESSURE VALVE WHICH ALL ULTIMATELY WORK TOGETHER. BUT BMW HAS ALREADY RECALLED ALL OTHER 2014 328 MODELS FOR THE EXACT SAME FUEL PUMP PROBLEMS IM HAVING EXCEPT THE 328D MODEL WAS THE ONLY ONE LEFT OUT????! BMW MAKES VERY FEW OF THESE MODELS TO BEGIN WITH, SO NATURALLY THERE ARENT GOING TO VE AS MANY COMPLAINTS WITH THE 328D IF THERE ARE FEWER PRODUCED. ITS COMMON SENSE. LOOKING THROUGH THE COMPLAINTS ON SAFECAR.GOV 98% OF THE COMPLAINTS ON THE CAR ULTIMATELY COME TO SOME SORT OF FUEL SYSTEM FAILURE CAUSING LOSS OF POWER AND TOTAL SHUT DOWN. AT 60 MPH AND 2 BABIES IN MY BACK SEAT IT WAS MORE THAN SCARY. IM DISGUSTED WITH BMW LEAVING OUT AND NOT RECALLING THE 328D WHEN THEY DID ALL THE OTHERS. I MEAN WHAT DOES IT TAKE TO GET SOME ANSWERS AROUND HERE ON THIS WHEN THERE ARE MULTIPLE UPON MULTIPLE COMPLAINTS?? I MEAN I GOT ON MY PHONE IMMEDIATELY AND DIAGNOSED THE PROBLEM BEFORE SOS EVEN CAME ON MY SPEAKERS JUST OFF OF THE TERRIBLE REVIEWS AND COMPLAINTS PEOPLE ARE SAYING OFF THE INTERNET ALONE! THE BMW SERVICE CENTER ALSO TOLD ME ALL OF THAT EXACT YEAR AND MODEL THAT THEY HAVE HAD IN THERE LATELY HAVE BEEN DUE TO THE SAME ISSUE!! THIS IS A COST I CANNOT EVEN AFFORD AT THE MOMENT, ESPECIALLY FOR A VEHICLE 2000 MILES OUT OF WARRANTY. AND IS BASICALLY A BRAND NEW CAR AND TO ALREADY BE FAULTY?? I'M AFRAID TO EVEN DRIVE IT AGAIN ONCE IT DOES GET FIXED, BEING THAT THEY ARE REPLACING THE PARTS THAT JUST FAILED!! WITH THE EXACT SAME PARTS?!!! WHAT TO JUST FAIL AGAIN, AND TAKE THE CHANCE OF NEXT TIME ON A BUSY ROAD WHEN IT SHUTS DOWN,ACTUALLY HAVING A COLLISON WITH A VEHICLE INSTEAD?!

Mileage: 52,034

ALL 3 SERIES FROM 2014 WERE RECALLED BY BMW EXCEPT DIESELS. MY CAR IS 3 YEARS OLD 328 DIESEL AND THE FUEL PUMP DISINTEGRATED CAUSING ENTIRE FUEL SYSTEM TO BE CONTAMINATED WITH NICKEL SHAVINGS. THE RECALLED GAS BMWS FROM 2014 EXPERIENCED THE SAME PROBLEMS SO CLEARLY MY CAR HAS THE SAME FAULTY FUEL PUMP WITH IMPROPER NICKEL PLATING INSTALLED, AND SHOULD ALSO BE UNDER THIS RECALL. SINCE I COMMUTE (HENCE DIESEL) A LOT AND MY CAR IS OUT OF WARRANTY DESPITE THE FACT IS 3 YEARS OLD I WILL HAVE TO PAY OUTRAGEOUS $13,000 TO RESURRECT IT. IN FACT I ALMOST DIED WHEN THE ENGINE SUDDENLY STALLED WITH THE INFAMOUS "POWERTRAIN MALFUNCTION" MESSAGE. I HAD A HARD TIME PULLING TO THE SIDE OF THE ROAD. MY CAR, JUST LIKE ANY 2014 GASOLINE VERSIONS, SHOULD BE UNDER THE SAME BMW RECALL AND THE FUEL SYSTEM SHOULD BE REPLACED BY THE COMPANY FOR FREE, NOT A THIRD OF THE PRICE OF THE CAR! I HAVE PICTURES OF FUEL TANK FULL OF NICKEL PARTICLES, AND THE FUEL PUMP ITSELF. THEY ARE MADE BY BOSH NOT BMW AND CLEARLY NOT DONE PROPERLY. THE NEW PUMP IS DIFFERENT NOW SO BMW FIXED IT, YET THEY DON'T ADMIT THEY EVEN CHANGED THIS PART. IF THEY NOTIFIED THEIR COSTUMERS, I'D JUST REPLACED THE PUMP FOR $1250, NOT AN ENTIRE FUEL SYSTEM FOR SUCH ENORMOUS PRICE. THIS IS UNACCEPTABLE AND SUCH FAULTY CARS SHOULD NOT BE ALLOWED FOR SALE IN US. IF THE HIGH PRESSURE FUEL PUMP DESTROYS ITSELF AND THE ENTIRE FUELS SYSTEM INCLUDING LOW PRESSURE PUMP AND EVEN A FUEL TANK, THIS IS CLEARLY A BADLY DESIGN CAR. I HAD TO REPLACE ONE OF THE FUEL INJECTORS JUST AFTER 1.5 YEARS OF USING THE CAR (I PURCHASED BRAND NEW) BECAUSE OF A SLOW PILLING NICKEL SHAVINGS. I HAVE THIS CAR FOR 3 YEARS AND ALREADY PAID OVER $10,000 FOR MAINTENANCE! THIS HAPPENED IN THE CITY DRIVING AROUND A ROUNDABOUT AT NIGHT AND CAR WAS IN MOTION.

Mileage: 101,000

VEHICLE HAS ON 4 SEPARATE OCCURRENCES STALLED/FAILED TO ACCELERATE. "DRIVETRAIN MALFUNCTION" ERROR CODE IS DISPLAYED. THE VEHICLE HAD 11564 MILES ON THE ODOMETER AT THE FIRST OCCURRENCE. THE FAULTS WERE CLEARED, BUT BECAUSE THEY COULD NOT REPLICATE THE FAILURE, NO ACTION WAS TAKEN. THE SECOND OCCURRENCE, 6 MONTHS AND 9000 MILES LATER, A SENSOR WAS REPLACED, FAULTS CLEARED, NO FURTHER ACTION TAKEN. THE THIRD TIME, SIX WEEKS LATER, A FUEL QUANTITY CONTROL VALVE WAS REPLACED. THE CAR HAS JUST BEEN TOWED FOR A FOURTH TIME. ON 3 OF THE 4 OCCURRENCES, THE CAR WAS ON A HIGHWAY OR BUSY STREET, AT ONE TIME TRAVELING IN EXCESS OF 60 MPH. THE LAST TIME WAS TURNING ONTO A BUSY HIGHWAY, NARROWLY AVOIDING AN ACCIDENT. THE FIRST TIME WAS ON A DOWNTOWN CITY BLOCK, STALLING IN AN INTERSECTION AT LOW SPEED.

Mileage: 23,000

TL* THE CONTACT OWNS A 2014 BMW 328D. THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WHILE APPROACHING A STOP LIGHT AT 10 MPH. THE VEHICLE HAD TO BE TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE FAILURE WAS A RESULT OF A FAULTY FUEL PUMP THAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CHECK ENGINE LIGHT ILLUMINATED TWICE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000.

Mileage: 15,000

ON OCTOBER 26, 2014 AT APPROX. 5:00 PM EST, MY WIFE HAD PULLED OUR CAR, LISTED ABOVE, INTO OUR NEIGHBOR'S DRIVEWAY AFTER A SMALL TRIP. AS SOON AS SHE PARKED THE CAR, SHE NOTICED SMOKE COMING FROM UNDER THE HOOD OF THE BMW. WITHIN A FEW MINUTES, THE CAR WAS ENGULFED IN FLAMES. THE FIRE STARTED UNDER THE HOOD AND COMPLETELY ENGULFED THE FRONT END, MELTED THE ENGINE COMPARTMENT AND DESTROYED OUR CAR AND NEIGHBORS GARAGE SIDING AND DRIVEWAY. THIS WAS A BRAND NEW BMW PURCHASED IN AUGUST 2014. *TR

Mileage: 8,000