2012 BMW 528I Unknown Or Other Problems

The failure involved the breaking of the oil chain, which resulted in catastrophic engine damage. Consequently, the timing chain and splash shield were also compromised due to the initial failure. The incident appears to be caused by a malfunction or defect in the oil chain assembly. The affected components are available for inspection and further investigation. This information may be useful for evaluating the need for a recall or identifying underlying manufacturing or design issues.

On [XXX], the water pump's electrical plug connector became defective, ultimately putting myself and [XXX] son in a dangerous situation. While on the highway coming home from work/daycare, the car overheated rapidly, my car started slowing down in the middle of the highway. The car ultimately stopped and had to pull to the side. I tried to call 2 BMW dealerships in San Jose, but at that time the recall remedy was unavailable and said there was nothing they could do for me. So I had to tow to my home. Towed to my mechanic the next day, and they had to fix it. The car was repaired after being in the shop for 1 week. I took the car home and shortly after, the car overheated again. Luckily, I was on my way home and in the neighborhood. This was a very traumatic experience that I never set foot in the care since then and am requesting a refund for the repair that wasn't even fixed in the first place. I do not want to use the car anymore given it is a huge safety risk for me and my son. I travel to the city 4 days a week for work and daycare. I have the receipts for repair. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The turbocharger wastegate actuator issues causing a drivetrain malfunction. The actuator has been changed several times ,that regulates the westgate yet there’s a loss in power. Safety when merging onto freeway as you accelerate the warning light comes on and vehicle losses power other vehicles have to slow significantly to avoid possible running into vehicle entering freeway

I had been having problems with my seatbelt alarm coming on for a while with nothing in the seat of the passenger and then as I was trying to turn in to park I heard a click from my steering wheel as if it didn’t want to turn and the driver seat restraint malfunction error popped up . Now my horn will not work as well . I’m told that the dealership is the only place it can be repaired. I’m worried that it will deploy on me while driving . I’m sure this is an issue others have experienced as well .

DEFECTIVE DRIVE TRAIN - ON MARCH 11, 2019 MY DRIVE TRAIN MALFUNCTION AND WHICH DAMAGE MY ENGINE. THIS IS AN SAFETY CONCERN BECAUSE MY CAR STOP ON THE FREEWAY WHILE I WAS DRIVING. BMW MFG KNEW ABOUT THE DEFECTIVE DRIVE TRAIN PRIOR TO ME PURCHASING CAR FROM FIELDS BMW ON JULY 2013. BMW NORTH AMERICA OFFER TO PAY 21,000 FOR THE ENGINE REPLACEMENT AND THEY WANT ME TO PAY 6,000.00 AND I FEEL BMW KNOW ABOUT THE FAULTY DESIGN IN 2012 AND DID NOT INFORM THE CONSUMER. WHEN I PURCHASE THE CAR, IT HAD 18,000 MILES ON IT AND I PUT 62,000.00

Mileage: 80,000

LAST WEEK I WAS ON THE NJ TURNPIKE WHEN ALL OF A SUDDEN MY CAR STALL AND LOST POWER, I BARLEY GOT OFF THE TURNPIKE WHEN THE CAR CAME TO A COMPLETELY STOP. NO WARNING MESSAGES OR NOISES JUST STOPPED. FORTUNATELY NO ACCIDENT OCCURRED DUE TO THIS BUT COULD HAVE BEEN AN UGLY ONE. THE CAR WOULD NOT START AND WAS TOWED TO THE BMW DEALER. THE CAR WAS INSPECTED, OIL WAS CLEAN, NO WATER DAMAGE, HOWEVER THEY TELL ME I NEED A NEW ENGINE (13K) HAS THE ENGINE SEIZED WITHOUT TELLING ME WHAT CAUSED IT.THE CAR HAS 83K MILES. I'VE BEEN A BMW OWNER FOR 19 YEARS. I NOW HAVE MIXED FEELINGS ABOUT BMW AND THE WAY I FEEL NOW I WILL NEVERY BUY ANOTHER BMW AS I'M NOT GETTING THE ATTENTION I THIN I DESERVE. ANY ADVICE IS GREATLY APPREICATED!

Mileage: 83,000

I OWN A 2012 BMW 528I (OCT 2011). WHILE DRIVING VARIOUS SPEEDS, THE ENGINE SUDDENLY STALLED AND BECAME INOPERABLE. THE FAILURE OCCURRED WHILE DRIVING ON THE FREEWAY. THE VEHICLE WAS TAKEN TO AN BMW WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE WAS FAULTY AND NEEDED TO BE REPLACED. I WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V746000 (FUEL SYSTEM), ALTHOUGH THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 63000. THIS IS ILLEGAL AND UNFAIR.

Mileage: 63,000

VEHICLE ENGINE DIED ON THE HIGHWAY WHILE MOVING IN 55MPH TRAFFIC. COULD NOT GET THE VEHICLE INTO NEUTRAL TO MOVE IT TO A SAFE LOCATION. ALMOST HIT BY SEVERAL VEHICLES. VERY VERY VERY DANGEROUS! THE TOW OPERATOR COULD NOT GET THE VEHICLE INTO NEUTRAL TO TOW IT.

Mileage: 69,000

AT 2:30AM ON 4/29/17 SATURDAY MORNING, WE HEARD A LOUD BANG WHILE DRIVING 70MPH ON THE INTERSTATE...TURNS OUT THAT THE SUNROOF EXPLODED OUT OF NO WHERE...GLASS WAS ALL OVER US...VERY SCARY SITUATION.

Mileage: 68,500

VEHICLE BOUGHT IN JULY 2014 WITH ~24K MILES; STILL UNDER FACTORY WARRANTY. MAINTENANCE MAINTAINED. 9-12 MONTHS LATER, A "DRIVE TRAIN MALFUNCTION" LIGHT CAME ON. I HAD JUST LEFT THE DEALERSHIP SO I CALLED THEM AND THEY TOLD ME TO BRING IT BACK IMMEDIATELY; I DID. MANY TESTS LATER, WAS TOLD MY "MOTHERBOARD DIED" (DME UNIT); AFTER A MONTH IN THE SHOP...REPAIRED. NOW, 4/2016, LESS THAN 60K AND FRESH OUT OF WARRANTY...I WAS DRIVING HOME WITH MY SON ON THE INTERSTATE, ABOUT TO GET OFF OF MY EXIT AND ANOTHER "DRIVE TRAIN MALFUNCTION AND LOW ENGINE PRESSURE" LIGHT COMES ON AND THEN ALL OF A SUDDEN MY CAR STOPPED ON THE 4 LANE OFF-RAMP. AFTER WAITING FOR AN HOUR FOR THE TOW TRUCK TO ARRIVE AND TRYING TO PUT MY CAR INTO NEUTRAL AND ABOUT 30 MIN WITH THE TOW TRUCK DRIVER TRYING TO PUT THE CAR IN NEUTRAL, I CALLED THE BMW DEALERSHIP AND I FOUND OUT THAT BECAUSE MY CAR IS ALL ELECTRIC IT CANNOT BE PUT INTO NEUTRAL; A WEEK AT THE DEALERSHIP AND STILL THERE AS I TYPE'DIAGNOSIS: TIMING CHAIN BROKE INTO THE ENGINE AND NOW THE CAR NEEDS A NEW ENGINE WHICH I WAS QUOTED TO BE $21,000. THE CAR IS ONLY 4 YEARS OLD!!!!! NEEDLESS TO SAY, IT WAS BY THE GRACE OF GOD THAT MY SON AND I WERE NOT INJURED OR KILLED WHEN THE ENGINE JUST SHUT OFF IN THE MIDDLE OF TRAFFIC. AND ON TOP OF THAT, IT IS ABSURD THAT THE CONSUMER CANNOT MANUALLY PUT THIS VEHICLE INTO NEUTRAL TO MOVE IT OUT OF HARM'S WAY IF IT'S POSSIBLE TO DO SO. THE ONLY WAY TO PUT THE CAR IN NEUTRAL WHEN INOPERABLE IS TO TAKE IT TO THE DEALERSHIP. UNSAT! AND FOR A CAR COMPANY THAT IS SUPPOSED TO HAVE A GREAT REPUTATION AND HIGH STANDARDS, IT'S ABSURD THAT A NEW ENGINE IS NEEDED FOR A CAR THAT IS BARELY 4 YEARS OLD. I HAVE SEEN THE SAME ISSUES WITH OTHER BMW OWNERS ALL OVER THE INTERNET. LOVE BMW AND HAVE OWNED 3 OF THEM AND IT'S UNFORTUNATE THAT THIS ONE WILL BE MY LAST BECAUSE I DO NOT FEEL SAFE IN THIS VEHICLE ANYMORE.

Mileage: 56,000

THIS 2012 BMW 528, WHILE STANDING STILL ON A CITY STREET, WAS STRUCK FROM BEHIND ON THE LEFT REAR CORNER AND THE ACTIVE HEADREST RESTRAINT SYSTEM WAS ACTIVATED STRIKING THE DRIVER IN THE HEAD AND CAUSING A TRAUMATIC BRAIN INJURY.

Mileage: 20,090

MY BMW 528I 2012 I BOUGHT USED IN APRIL 2015. IN NOVEMBER 2015 MY CHECK ENGINE LIGHT CAME ON. THEN IT WENT AWAY , BUT A WEEK LATER IT CAME ON AND ANOTHER LIGHT SAYING THE COOLANT WAS LOW. I TOOK IT TO BE TOPPED OFF THAT DID NOT WORK. MY CAR WENT FROM YELLOW ZONE TO RED SEVERE WHEN DRIVING HOME WITH MY KIDS ON A BUSY STREET. MY CAR BEGIN TO OVERHEAT . I TOOK IT HOME IMMEDIATELY . THE CAR LOSS ALL POWER IT WOULD NOT DRIVE FASTER THAN 25 MPH . I KNEW WHAT EVER IT WAS GOING TO BE COSTLY. MY CAR SAT FOR A MONTH UNTIL I THOUGHT I HAD ENOUGH MONEY TO FIX. LOW AND BEHOLD I TOOK IT TO A BMW DEALERSHIP THERE HAVE BEEN ONE CAMPAIGN FOR THERMOSTAT AND ONE RECALL ON THE OIL FILTER HOUSING. THERE HAS SEEM TO BE AN ISSUE I WAS UNAWARE ABOUT. THE DEALER IS SAYING BECAUSE OF THE COOLANT MIXING WITH OIL AND THE CAR OVERHEATING THERE IS POSSIBLE ENGINE DAMAGE. 20K WORTH OF DAMAGES . I HOPING BMW HELPS BECAUSE MY CAR IS AT THE DEALER STILL BECAUSE OF THIS HORRIBLE MALFUNCTION. I HAVE ATTACHED A THREAD I FOUND ONLINE THAT BMW SENT OUT TO ALL THE CONSUMERS IN JULY 2015 THAT I WAS NOT MADE AWARE OF.

Mileage: 63,000