2012 BMW 528XI Power Train Problems

The contact owns a 2012 BMW 528XI. The contact received notification of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); and the vehicle was taken to the dealer for the recall repair. The contact was informed that the recall repair had been performed. The contact stated that upon driving off the parking lot at the dealer and coming to a complete stop at the traffic light, the message "Drive Train Malfunction - Service to Nearest BMW Dealer as Convenient" was displayed. Additionally, the vehicle was significantly sluggish and failed to respond upon depressing the accelerator pedal. The vehicle was taken back to the dealer, where the contact was informed that the failure could be related to the coolant pump, and the part was not covered under the recall; however, the recall remedy information stated that the dealer would inspect and replace the water pump and plug connector as necessary, and would install a protective shield, free of charge. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 129,000.

Mileage: 129,000

My BMW started leaking fluid 4 months ago. Lights on dash came on one light was the triangle light which engine light. I had it serviced completely oil & filter change hooked up to machine that checks all components senors everything checked out great. One week later I was driving I was coming to a stop my brakes sounded like they were grinding next day had mechanic check the brakes all good. Next day I am pulling out of Attorney Parking lot as I am turning the steering wheel my BMW makes a load screaming cracking noise so I turn my steering wheel up right to drive straight it makes the same noise. I stop to look around my vehicle to see if anything is leaking or dragging nothing was dragging but maybe one or drops of something I touched the solution to feel if it was water or oil? It felt oily so I drove to my mechanic he lifted it up on the racks. We both could see some solution was leaking around possibly where engine oil plug is then we saw it had been leaking back to middle of my vehicle water area and running back to the middle of my vehicle. My mechanic decided to put the machine that checks for certain items on vehicles I know it checks my sensors not sure what else?? He and a couple of the other mechanic stop and help him. I left my vehicle he let me drive his vehicle home he wanted to check other issue tomorrow. Next day I got to the mechanic he said he knew it needed a transfer case and 4 sensors he said it would take time to buy a new transfer case for 2012 BMW 528I xl so to leave my vehicle with him.Then I get this letter today 12/13/24 from BMW DATED 10/2024 it states there defect which relates to motor vehicle safety issue which means a part is being recalled on my vehicle!! My question my vehicle has already gotten damaged by this recall I am trying to fix the problems plus paid already $1500. For repairs to my mechanic whom thought that fix my issue but has not. Please inform me as to what I the owner of this model vehicle that has a defective part

Car just wouldn't start one day. Drivetrain malfunction warning indicating timing chain replacement. Car just sits in my driveway. Will cost 6 grand to fix. Timing Chain failure probably effected my engine.

The contact owns a 2012 BMW 528XI. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with the low oil warning light illuminated. The vehicle was towed to an independent mechanic who diagnosed that the timing chain needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,000.

Mileage: 146,000

While driving on the Grand Central Plwy, Queens, NY, a drive train motification came on and stated to drive moderately, right after the oil light came on. We were near a gas station, and added a quart of oil. The oil light went out, the car started without hesitation. We decided to go home, we got off the highway about a mile out, the car just stopped went into park and could not start again. It would crank over, but not connect. We were on a four lane road, luckily there was no one behind us, it could have been a terrible incident. The car was towed to a BMW dealership in Great Neck, NY and we were told it was either the engine or the timing chain and it was not worth fixing. The car was then towed to my mechanic, who stated there was a technical warning #N20 & N26 regarding the timing issue. Hoping something can be done

Car begin to stall on traffic, drivetrain malfunction light appeared..Took it to BMW DEALER My Fuel Pump replace with new EKP module- Which is the same recall that BMW issued in 2017 which included the Model/year vehicle that i have.

in 2020 the engine started malfunctioning at 76,000 miles. I took it into the BMW dealership to get it inspected and they stated that it was a valve issue and charged replacement. After replacement, the engine lit would come on and I called the representative. He stated that it would need time to reset so I continued driving it. Eventually the light did not come on for some time. A year later in 2021 after driving to work the engine started to stall on my way to work on the highway. I since taken it back to BMW stating that it was less than 10,000 miles since the repair and I'm having engine troubles again. After talking to the BMW service representative, they stated that I will need a new engine because it is now blown. The engine only has 84,000 miles on it and I requested root cause analysis on the engine. After reviewing online, I discovered that this engine is mounted on multiple platforms BMW sold and is known to have issues since 2017 and a lawsuit in 2020, the same year I took my car to the BMW dealership for repairs. They neglected to inform me of the issue with the engine when I first took the car in and put my car back on the road with a faulty engine. Gross negligence by BMW.

TL* THE CONTACT OWNS A 2012 BMW 528XI. THE CONTACT STATED WHILE DRIVING 80 MPH, THE VEHICLE SHUT-OFF. THE CONTACT PULLED OVER TO THE SIDE OF THE ROADWAY. THE CONTACT STATED THAT MESSAGE READ "DO NOT STOP VEHICLE, MAYBE UNABLE TO RESTART; CHARGING ERROR" WAS DISPLAYED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH NEEDING THE SERPENTINE BELT TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY WERE UNABLE TO ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 127,000.

Mileage: 127,000

DRIVING DOWN THE STREET WHEN ALL OF A SUDDEN CAR SAYS DRIVE TRAIN MALFUNCTION I WAS STOPPED AT THE LIGHT ON A ONE WAY STREET ON 11/20/2020 WHEN THE CAR JUST DIED NO WARNING JUST SHUT OFF WOULDN'T START COULDN'T PUT IT IN NEUTRAL BLOCKED TRAFFIC FOR ABOUT 90 MINUTES BEFORE I COULD GET A TOW TRUCK TO REMOVE MY CAR. I HAVE A 2012 BMW 528XI WITH ABOUT 90K + MILES ON IT I WAS SO SCARED BECAUSE IT COULD HAVE HAPPENS TO ME ON THE HIGHWAY OR IN THE MIDDLE OF THE STREET AND I WOULD NO HAVE BEEN ABLE TO GET OUT OF HARMS WAY.

Mileage: 91,000

WHEN TURNING MY CAR ON AND WHILE DRIVING ON THE HIGHWAY, MY CAR DISPLAYED A DRIVETRAIN MALFUNCTION ERROR. I TOOK THE CAR TO MY LOCAL BMW DEALER ON AUGUST 3, 2020 FOR SERVICE AND THEY DIAGNOSED THE CAR WITH A COMPUTER ERROR. THEY MADE A REPAIR TO THE COMPUTER AND TOLD ME IT WAS FIXED. THIS COST $350. ON AUGUST 7, I DROVE FROM MARYLAND TO SOUTH CAROLINA AND RECEIVED THE SAME DRIVETRAIN ERROR MESSAGE AND THE OIL SERVICE LIGHT WARNING CAME ON. WE HAD TO ADD A QUART OF OIL AND DRIVE SLOWLY PER THE DRIVETRAIN ERROR MESSAGE. AS SOON AS I RETURNED TO MARYLAND, I TOOK THE CAR BACK TO BMW OF ANNAPOLIS. THEY TOLD ME THAT THE FRONT END OF THE ENGINE WAS GONE AND THAT THEY WOULD NEED TO REBUILD THE MOTOR INCLUDING NEW TIMING CHAINS, CHAIN TENSIONER, CHAIN GUIDES, AND EXHAUST VANOS UNIT (A $6000 REPAIR). THE CAR ONLY HAD 72,000 MILES AND I HAD NEVER MISSED A SERVICE APPOINTMENT. BMW NORTH AMERICA OFFERED TO PAY HALF OF $6000 AFTER BEING CONTACTED BY BMW OF ANNAPOLIS. HOWEVER, I THOUGHT THAT BMW NORTH AMERICA SHOULD HAVE PAID THE ENTIRE AMOUNT BECAUSE THIS IS A KNOWN PROBLEM WITH THE 2012 BMW 528I AND I COULD HAVE HAD A MAJOR ACCIDENT. IN ADDITION, THIS CAR HAS HAD 2 PRIOR MAJOR RECALLS. I SENT BMW NORTH AMERICA A FORMAL COMPLAINT, BUT THEY STILL ONLY PAID $3000.

Mileage: 72,000

WARNING FOR CHASSIS STABILIZATION IS ON, I ENCOUNTERED NOT BEING ABLE TO ACCELERATE AND HAD THE CAR TOWED. I WAS ON A MAIN ROAD AND I GOT REAR ENDED IMMEDIATELY AFTER I WAS NOT ABLE TO ACCELERATE AND I HAD MY HAZARD LIGHTS FLASHING

Mileage: 67,000

MY 2012 528XI HAS 117K MILES ON IT. WHILE I WAS ON A LONG ROAD TRIP, DRIVING ON I-95 AT 1AM ON A FRIDAY NIGHT, WITHOUT ANY WEIRD ENGINE NOISES OR ANYTHING OUT OF THE NORM, THE CAR DISPLAYED A WARNING MESSAGE THAT SAID "DRIVETRAIN MALFUNCTION" IMMEDIATELY FOLLOWED BY WARNING "ENGINE OIL PRESSURE LOW" WARNING. WITHIN A FEW SECONDS, THE ENGINE SHUT OFF AND THE CAR TOLD ME TO PULL OVER SAFELY. LUCKILY, THERE WAS A NICE BIG SHOULDER AND THERE WAS NO TRAFFIC AROUND, SO I WAS ABLE TO SAFELY COAST TO A STOP. HAD THE CAR TOWED 100 MILES TO AN INDEPENDENT MECHANIC, AND HE SAID THERE WAS NO OIL PRESSURE, SO THERE WAS TOO MUCH FRICTION DUE TO LACK OF LUBRICATION, WHICH SEIZED THE CAMSHAFT AND CAUSED JUMPED TIMING. I'VE HAD A LOT OF "VERY UNUSUAL" (MECHANIC'S WORDS) ISSUES WITH THIS CAR, OF COURSE ALL OUT OF WARRANTY. AND NOW THE ENGINE IS COMPLETELY FRIED. I CAN SPEND ANOTHER $11K TO PUT A BRAND NEW ENGINE IN THERE, BUT THE CAR ITSELF ISN'T WORTH $11K ANYMORE. LOTS OF OTHER PEOPLE HAVE THE SAME ISSUE. HASN'T BEEN REPORTED TO NHTSA BUT CAN FIND IT ON BMW ENTHUSIAST FORUMS (LIKE BIMMERFEST DOT COM).

Mileage: 175

VEHICLE MESSAGED ME WHILE DRIVING THAT OIL PRESSURE WAS LOW. STOPPED, AND RESTARTED WITH NO ISSUES. INVESTIGATED ONLINE AND DISCOVERED THAT THE ENGINE HAD A WELL KNOWN PROBLEM WITH THE TIMING GUIDES BECOMING BRITTLE AND DISINTEGRATING SENDING PARTS INTO THE SPROCKETS AND THE OIL SENSORS. ALSO CHAIN MAKES A WHINING NOISE IF AFFECTED. HAD THE VEHICLE TOWED TO DEALERSHIP WHERE THE TIMING CHAIN GUIDES WERE DIAGNOSED AS BEING THE PROBLEM. OUT OF EXTENDED WARRANTY (7YR/70K) BY ONE YEAR AND 5K MILES. BMW KNOWS OF THE PROBLEM AND REFUSES TO VOLUNTARILY RECALL AFFECTED VEHICLES. COULD RESULT IN CATASTROPHIC ENGINE FAILURE AT HIGHWAY SPEEDS AND RESULT IN A SERIOUS ACCIDENT.

Mileage: 75,600

I BOUGHT A CERTIFIED BMW AND HAD CONTINUOUS ISSUES WITH MY ENGINE, CONSTANTLY REFILLING THE OIL, EVEN AFTER SERVICE. AFTER TAKING THIS TO THE DEALER, I WAS TOLD THAT EVERYTHING WAS FINE AND THERE WEREN'T ANY ISSUES. ALL OF THIS FINALLY CAME TO A HEAD-ON SUNDAY, 6/21/2020 WHEN MY CAR FINALLY CAME TO AN ABRUPT STOP. AFTER TOWING, I WAS TOLD THAT THIS IS A TIMING CHAIN ISSUE AND WOULD COST ME $7,400 WHICH WOULDN'T NECESSARILY REMEDY THE ISSUE, I HEARD THIS COULD REACH TOWARDS 15-20K. I FIND THIS HARD TO BELIEVE AFTER HAVING ONLY DRIVEN THIS CAR ON AVG 8K/YEAR AND HAVING ROUGHLY 84K MILES IN TOTAL. MY EXPERIENCE WITH BMW HAS SINCE BEEN PAINFUL TO SAY THE LEAST SINCE. I'VE HAD THIS TOWED TWICE IN 2 DAYS, BEEN GIVEN AN ULTIMATUM ON EITHER FIXING THE VEHICLE OR BUYING A NEW ONE - WHEN ASKING FOR A LOANER, I WAS TOLD THAT I NEEDED CONTACT ENTERPRISE AND RESERVE ONE ON MY OWN. I'VE OWNED MULTIPLE GERMAN CARS AND NEVER HAD TO DEAL WITH THIS LEVEL OF UNPROFESSIONALISM. *TR

Mileage: 84,000

I HAD ISSUES WITH MY CAR WHILE DRIVING AND WHEN TAKEN TO THE DEALER FOR CHECK, THEY MENTIONED MY TIMING CHAIN AND ENGINE HAS SOME ISSUES AND NEEDS TO BE REPLACED WITH AN ESTIMATE OF $14000 WHILE THE CAR LOAN I HAD ON IT WAS $12000. THIS IS RIDICULOUS AS WE ALREADY KNOW BMW 2012 MODELS HAVE ENGINE ISSUES.

Mileage: 70,000

MY 2012 BMW 528 XDRIVE SUDDENLY GOT A WARNING LOW OIL PRESSURE FOLLOWS BY DRIVE TRAIN MALFUNCTION, AND SLOWS DOWN-WENT ON NEUTRAL AND STOP IN THE MIDDLE OF THE ROAD. ALL THAT HAPPENED WITHIN LESS THAN A MINUTE. I GOT IT TOWED TO THE BMW DEALERSHIP FOR A DIAGNOSTIC AND THEY TOLD ME THAT THE TIMING CHAIN GUIDE HAS BROKEN APART, TIMING CHAIN CAME OFF, JUMPED TIME, STARVED ENGINE FOR OIL & CONTAMINATED ENGINE AND WILL REQUIRE A WHOLE NEW ENGINE REPLACE WHICH WILL COST AROUND $13756.56 +LABOR+TAX MY TOTAL WAS $ 16456. I FOUND OUT I AM NOT ALONE AND THIS IS A KNOWN PROBLEM WITH BMW OF THIS MAKE AND MODEL. I ALSO CALLED THE BMW NORTH AMERICA THEY TOLD ME THAT THE EXTENDED WARRANTY WAS ONLY UP TO 70,000 MILES AND THEY CAN NOT DO ANYTHING ABOUT IT, MY CAR FAILS AT 105K MILES. I THINK BMW MUST STAND BEHIND THERE PRODUCT. WE CAN NOT BUY AN EXPENSIVE CAR LIKE BMW WITH AN ENGINE LIFE IS LESS THAN 8YRS.

Mileage: 105,628

TURBO CHARGER SYSTEM IS AFFECTED DUE TO THE ENGINE OIL FILTER HOUSING FAILING WHICH CAUSED OIL TO TRANSFER THROUGH OUT THE TURBO SYSTEM INTO THE COOLANT RESERVOIR RESULTING IN BLACK SLUDGE THAT CAUSED MY CAR TO STALL AND NOT RUN AND HAVE TO BE TOWED. EVERY SINCE THIS RECALL ISSUE MY CAR GIVES THE DRIVE-TRAIN MALFUNCTION WARNING WHICH WHEN DIAGNOSED INDICATES LOW TURBO BOOST PRESSURE WHICH I'M CERTAIN HAS TO DO WITH THE BLACK SLUDGE THAT RAN THROUGH THE TURBO SYSTEM AND COOLANT SYSTEM BECAUSE OF THE ENGINE OIL FILTER HOUSING FAILING. A SOFTWARE UPDATE WAS RECOMMENDED THAT BMW IS NOT WILLING TO PAY FOR OR I NEED TO PAY $3660 TO REPLACE THE TURBO CHARGER WHICH I TRULY BELIEVE IS THE RESULT OF THE OIL FILTER HOUSING FAIL AND OIL LEAKING INTO THE TURBO SYSTEM AND THE COOLANT SYSTEM.

Mileage: 89,000

IN OCT. 2015 I PULLED OUT OF MY STREET INTO TRAFFIC AND LOST ALL POWER. " DRIVETRAIN MALFUNCTION" DISPLAYED ON DASH, THE CAR LOSES ALL POWER AND GOES INTO "LIMP" MODE, GOES LIKE 5 MPH MAX. THANKFULLY I GOT IT OFF THE STREET WITHOUT BEING HIT, TURNED IT OFF AND RESTARTED IT, DISPLAY WAS GONE AND I WAS ABLE TO DRIVE IT NORMALLY. AFTER MY HEARTRATE SLOWED AND I GOT TO THE OFFICE I CALLED AND MADE AN APPT. TO HAVE IT LOOKED AT. IT HAD 48K MILES AT THE TIME OF THE FIRST INCIDENT AND STILL UNDER WARRANTY. AFTER LEAVING IT WITH THE DEALER FOR OVER A WEEK, THEY TOLD ME THAT THEY REPROGRAMMED THE CAR TO THE LATEST SOFTWARE AND SHOULD BE FINE. NOW FAST-FORWARD TO JAN 2016, 54K MILES, MY WIFE WAS DRIVING IT ALONG AND SAME THING HAPPENED, "POWERTRAIN MALFUNCTION" DISPLAYED ON DASH CAR WENT INTO LIMP MODE, THERE WAS NO WHERE TO PULL OVER IN MORNING RUSH HOUR, HAD TO PUT HAZARDS ON UNTIL SHE COULD GET TO A SAFE LOCATION TO PULL OVER. TURNED IT OFF, RESTARTED AND WAS ABLE TO DRIVE AGAIN. SHE WAS VERY SCARED AND SHAKEN. CALLED THE DEALER FROM WHICH WE BOUGHT IT NEW AND AM TAKING IT IN TODAY. THUS, AFTER RESEARCHING THIS ISSUE IT SEEMS TO BE A COMMON OCCURRENCE WHICH HAS BEEN GOING ON WITH BMW'S. BEFORE SOMEONE GETS HURT OR KILLED SOMETHING NEEDS TO BE DONE TO MAKE SURE THIS DOES NOT HAPPEN. FROM WHAT I'VE READ I AM NOT THE ONLY BMW OWNER WHO HAS EXPERIENCED THIS PROBLEM!

Mileage: 54,000