2011 BMW 550I Power Train Problems

Vehicle displays Transmission Malfunction & DSC and xDrive malfunction, this vehicle is available upon request for inspection. Currently been to two dealerships and all I got from the first dealership is to replace transmission at 59k mile. I purchased a used transmission same problem exist in the replacement transmission. As I was driving on highway, the transmission began displaying message above and caused the vehicle suddenly slow down without warning lights causing me to avoid an accident by pulling over to avoid being rear ended. The problem has been reproduced by dealer: tech and service advisors manager( authorized to drive) and he charge me for a tow even after I mention to him I have AAA if he needs it. Service manager stated that it may need the mechatronics unit which $4k for part but they’re unsure because they didn’t take it apart but it’s a known issue. They mention that it’s a known problem for the TCM (mechatronic valve throttle body control module to go bad). Manufacturer has not inspected vehicle. So currently it’s at BMW of Owings Mills get a second opinion.

I started my car to drive to an appointment and noticed that the car was jerking/bucking as I pulled out of my driveway onto the main road. I was unable to accelerate appropriately for oncoming traffic behind me because the car was jerking violently and it was a bit scary since this had not happened before. This continued for several days, primarily when I would attempt to drive the car in the morning. On one occasion the drive train malfunction light illuminated as I was making my way to an appointment at the Veterans Administration and I had to gingerly turn the car around and head back home. Someone could have ran into me because the car didn't have much power. What followed next was the inability to get my car to move when it was placed in reverse. I took the car to the dealership and was told that the car's transmission needs to be replaced ($11,000) because the car is trying to drive in reverse and first gear at the same time. What?!! In over 20 years of servicing BMW's, they have never seen a situation like this. I don't believe I should bear the cost for this when I bought a pretty expensive car in good faith, which has only 80,000 miles.

DRIVETRAIN MALFUNCTION COMES ON DASH, DUE TO TIMING CHAIN BEING OUT OF "TIME" MEANING THAT THE CRANSHAFT AND CHAIN HAS MOVE OUT OF PLACE, THIS REPAIR IS ESTIMATED TO COST ABOUT 10K, OTHER VEHICLES OF THE THIS TYPE ARE ALSO INCLUDED, THE RECALL FROM BMW IS CALL THE "N63 CUSTOMER SERVICE PACKET", N63 IS THE KIND OF ENGINE THAT THIS CAR AND OTHER IN SIMILAR SERIES AND YEARS ARE KNOWN AND INNEVIDATABLE TO PREVENT SINCE ITS A MANUFACTURER MISTAKE. I PERSONALLY LOST OUT ON A LOT OF MONEY DUE TO THE PROBLEM THAT LANDED IN MY HANDS.

BMW SAID THEY REPLACED THE STEM SEAL OR VALVE SEAL AROUND 50K MILES I GOT THE CAR AROUND 69K MILE AND AFTER IT HIT 90K MILE I STARTED TO SEE SOME SMOKE I REALLY DIDNT PAY ATTENTION UNTIL ONE DAY I WAS COIMING OUT OF MY HOUSE THEN THAT'S WHEN I SEEN THE BLUISH SMOKE I CALLED BMW AND SAID IF THE SHOP THAT DID THE WORK REALLY REPLACED THE SEAL CAUSE IF THEY DID AND FOR IT TO SMOKE AGAIN THE CAR HAS NOW 143K MILES AND I CAN'T SMOG IT CAUSE OF THE SMOKE IT WON'T PASS SMOG CHECK HERE IN CALIFORNIA

I OWN MY BMW 550I GRAN TURISMO SEDAN 2011 F10(N63). THERE IS A RECALL ON MY EXACT MODEL. NHTSA NUMBER: 18V248000/ ENGINE AND ENGINE COOLING. I AM HAVING THE SAME EXACT ISSUES THAT THE RECALL SHOWS. I HAVE PROOF OF DOCUMENTS SHOWING MY WATER PUMP FAILING, GETTING SERVICE WATER PUMP AND ALTERNATOR REPAIR. AUGUST 24, 2019 SHOWS SMALL EVAPORATIONS LEAK, CYLINDER MISFIRES AND HAS BAD HEAD GASKET. WATER PUMP FAILURE CAUSED MY ENGINE TO OVER HEAT AND BAD HEAD GASKETS.I ALSO HAD SIMILAR PROBLEM AS OTHER CUSTOMERS WITH THE TURBO COOLANT HOSES, MY HOSES CRACKED LIKE GLASS, EJECTING COOLANT ALL OVER THE ENGINE AND ALTERNATOR, WHICH CAUSED SMOKE REALLY BAD ALMOST LEADING TO AN CAR CRASH BECAUSE I COULDN'T SEE ON THE HIGHWAY, WHEN I PULLED OVER ON THE SIDE OF THE ROAD THE ALTERNATOR WAS BURNING UP. I HAVE CONTACTED MANUFACTURER BMW OF NORTH AMERICA AND MY VIN NUMBER IS NOT ON THE RECALL LIST AND I HAVE THE SAME EXACT ENGINE THAT IS RECALLED(N63/F10) I AM NEEDING MY CAR ADDED TO THE RECALL LIST, THIS MISTAKE NEARLY COST ME AND MY FAMILY LIFE. APRIL 12TH, THE CAR WAS IN MOTION, IN KANSAS CITY,MO ON THE HIGHWAY 435, BIG CLOUDS OF WHITE SMOKE, ENGINE LOSS POWER, CAUSING A CAR TO ALMOST CRASH INTO THE REAR OF THE CAR. I AM NOW LOCATED IN KANSAS CITY, MO. I CAN BE CONTACTED BY EMAIL: [XXX] OR CELL: [XXX] REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC

Mileage: 120,000

ENGINE OVERHEATING,BURNING A LOT OF OIL,ALSO HAVING ISSUES WITH THE SPARK PLUG AND COILS,HAVING MISFIRES FOR THE ENGINE COMPARTMENT HEAT EXPANDING GASKETS ALLOWING OIL TO REACH SPARK PLUGS LOOSING POWERTRAIN WHILE DRIVING CAUSING CAR TO SLOW DOWN,THIS IS THE FOURTH TIME IN THE LAST 2 YEARS THAT WE HAVE THIS ISSUE,ALSO HAVING ISSUES WITH WATER COMING INTO THE RIGHT SIDE BACK SEAT UNABLE TO PINPOINT THE PLACE WHERE WATER IS COMING IN FROM.

Mileage: 83,900

CAR PERFORMANCE GREATLY DECREASED, THEN FAILED TURBO, FUEL SMELL, AND DRIVE TRAIN MALFUNCTION WARNING INTERMITTENTENTLY ON AND OFF, EITHER IN PARK OR IN MOTION. TOOK VEHICLE TO DEALERSHIP. BMW NORTHWEST IS CURRENTLY DENYING ANY RECALLS ARE IN PLACE AND.

TL* THE CONTACT OWNS A 2011 BMW 550I. WHILE DRIVING 70 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE DRIVE TRAIN WARNING INDICATOR ILLUMINATED. THE VEHICLE LOST MOMENTUM. ALSO, THE BRAKE PEDAL DID NOT STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE CONTACT WAS ABLE TO SLOW DOWN THE VEHICLE BY DEPRESSING THE BRAKE PEDAL WITH BOTH FEET. THE DEALER STATED THAT THE VACUUM PUMP FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 101,000.

Mileage: 101,000

DRIVETRAIN MALFUNCTION CAR LOST POWER (NO ACCELERATION) ON THE HIGHWAY SHOCK VIOLENTLY, HAPPENED 3 TIMES IN LESS THEN A YEAR CAR DOES HAVE 70K MILES BUT THIS SHOULDN'T HAPPEN.

Mileage: 73,000

TL* THE CONTACT OWNS A 2011 BMW 550I. WHILE DRIVING 35 MPH, THE DRIVE TRAIN MALFUNCTION WARNING MESSAGE ILLUMINATED. THE CONTACT ALSO STATED THAT WHEN DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE SHOOK VIOLENTLY, THE CHECK ENGINE WARNING LIGHT ILLUMINATED, AND THE VEHICLE STALLED ALONG WITH THE DRIVE TRAIN WARNING LIGHT. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 49,500.

Mileage: 49,500

TL* THE CONTACT OWNS A 2011 BMW 550I. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STARTED SHAKING AND LOST ALL POWER. THE DRIVE TRAIN MALFUNCTION WARNING LIGHT ILLUMINATED. THE VEHICLE RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE HIGH PRESSURE SENSOR, LOW PRESSURE SENSOR, AND DRIVE TRAIN WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 41,900.

Mileage: 41,900

I AM CURRENTLY HAVING PROBLEMS WITH MY VEHICLE AND THE LOCAL AUTHORIZED DEALER/SERVICE CENTER, I BELIEVE THEY HAVE BEEN NEGLIGENT WITH THEIR ACTIONS TO MULTIPLE PROBLEMS THAT HAVE OCCURRED, INCLUDING THE REPAIR AND INSPECTION PERTAINING TO A RECALL OF THE N63 ENGINE VEHICLES. THE VEHICLE HAS HAD MULTIPLE ISSUES IN THE PAST, INCLUDING SEVERAL "DRIVETRAIN MALFUNCTIONS" FOR WHICH I BELIEVE HAVE THE DATES AND SERVICE RECORDS THEY RELATE FUEL INJECTORS, BATTERY, PUMPS, ECT.. SINCE JANUARY 2015 I HAVE CONTACTED THE SERVICE CENTER, AUTOGERMANA BMW OF PUERTO RICO, TO REQUEST AN INSPECTION AND REPAIR OF THE VEHICLE DUE TO RECURRENT ISSUES AND CONCERNS, THE REPRESENTATIVE INITIALLY TOLD ME THAT THE DEALER HAD RECEIVED NO INFORMATION ABOUT THE "RECALL" OR SERVICE BULLETIN "B001314". IN MARCH THE VEHICLE WAS SERVICED AGAIN AND THE "RECALL" WAS INCLUDED IN THE SERVICE ORDER BUT THEY ALLEGED THAT THEY DID'T HAVE THE PARTS AVAILABLE AND THAT THEY WOULD CONTACT ME AS SOON AS THEY BECAME AVAILABLE. THE REPRESENTATIVE EVEN RECOMMENDED AGAINST EXTENDING THE VEHICLE WARRANTY FOR REPAIRS UNTIL THE VEHICLE WAS REPAIRED AND/OR INSPECTED AS IT RELATED TO THE RECALL. THE VEHICLE IS NOW PAST THE 50K MILE WARRANTY AND THE ISSUES HAVE NOT BEEN RESOLVED, AND AGAIN IT IS AT THEIR SERVICE CENTER BECAUSE OF A NEW "DRIVETRAIN MALFUNCTION". THE SERVICE REPRESENTATIVE CALLED ME AND TOLD ME THAT THEY WOULD AGAIN INSPECT THE VEHICLE TO DETERMINE IF THE MALFUNCTION HAD ANY RELATION TO THE PREVIOUS ISSUES AND /OR THE RECALL, IF IT HAS NO RELATION THEY WOULD HAVE TO BE REPAIRED WITHOUT THE WARRANTY COVERAGE. I BELIEVE THIS TO BE SYSTEMATIC NEGLIGENCE OR QUITE POSSIBLY INTENTIONAL IRRESPONSIBILITY. AT THIS POINT LEGAL ACTION IS THE NEXT LOGICAL STEP. I APPEAL TO THE NHTSA FOR RESPONSIBLE ASSISTANCE WITH THESE SERVICE ISSUES AND A RESOLUTION OF THE PROBLEMS.

Mileage: 53,000

I BOUGHT THE CAR ON MAY 6, 2015 WITH ABOUT 53K MILES ON IT. DROVE IT FOR ONLY ABOUT 45 DAYS AND WHILE DRIVING THE CAR THE DRIVETRAIN MALFUNCTION AND OTHER LIGHTS CAME ON AND THE CAR LOST POWER AND STOPPED IMMEDIATELY. AT FIRST, I THOUGHT IT WAS THE BATTERY AND HAD THE CAR JUMPED BUT THAT DIDN'T WORK. THE CARE ENGINE WAS TOTALLY DEAD, NO SOUND NO ANYTHING OTHER THAN THE ENGINE LIGHT THAT POPPED ON BEFORE IT STOPPED. I HAD PURCHASED AN EXTENDED WARRANTY FROM GWC AT THE PURCHASE OF THE CAR SO INFORMED THEM. I HAD THE CAR TOWED TO A PLACE (LMC AUTO IN NORCROSS GEORGIA) THAT GWC WAS WILLING TO PAY FOR REPAIRS. LMC SAID THE ENGINE WAS LOCKED AND NEEDED TO BE REPLACED. GWC REFUSED TO REPLACE THE ENGINE BECAUSE OF THE EXPENSE AND INSTEAD HAD LMC AUTO REPAIR THE ENGINE. NEEDLESS TO SAY, LMC IS STILL REPAIRING THE ENGINE ALMOST 5MONTHS LATER. I HAD CALLED GOVERNOR'S OFFICE OF CONSUMER PROTECTION, [XXX], ETC.. TRYING TO GET HELP WITH GETTING THE CAR FIXED. WHEN I TALKED TO BMW OF NORTH AMERICA THEY SAID THEY WARRANTY IS UP AT 50K MILES SO THEY CANNOT COMMIT TO DO ANYTHING. I AM AT MY WITS END AND THE CAR STILL DOES NOT SEEM TO BE ANY CLOSER TO GETTING FIXED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 55,000

I WAS DRIVING ON A RESIDENTIAL STREET AND SHIFTED INTO 3RD GEAR. THE CAR BEGAN TO BUCK VIOLENTLY. I PUSHED IN THE CLUTCH TO STOP THE BUCKING. I WAS APPROACHING AN INTERSECTION. I ATTEMPTED TO ACCELERATE AND THE GAS PEDAL WAS NON-RESPONSIVE. THE VEHICLE THEN INDICATED THAT IT HAD A DRIVETRAIN MALFUNCTION. I WAS ABLE TO PULL OVER, TURN THE CAR OFF AND BACK ON AND DRIVE 0.5 MILES TO MY DESTINATION. WHILE PARKED, THE PARKING BRAKE ALSO MALFUNCTIONED AND I WAS UNABLE TO TURN IT OFF. THE CAR WAS TOWED TO THE DEALERSHIP. THERE IS A SIGNIFICANT DESIGN DEFICIENCY WITH THIS VEHICLE. THE PROBLEM WITH MY CAR HAD TO DO WITH A BROKEN PLASTIC PART ON THE WATER CHANNEL THAT LEADS AROUND THE TRUNK. THE PLASTIC COVER IS SUPPOSED TO SNAP INTO A GROMMET THAT IS IN A HOLE, THUS SEALING THE HOLE FROM WATER. IN MY SITUATION, THE GROMMET WAS MISSING. GIVEN THE DESIGN OF THE PLASTIC PART, THERE IS NO WAY TO KNOW THAT THERE IS AN ISSUE WITHOUT REMOVING THE PLASTIC PART. THE HOLE THAT THE PLASTIC PIECE SNAPS INTO LEADS DIRECTLY INTO THE TRUNK. IN THE BOTTOM OF THE TRUNK ARE SENSITIVE ELECTRONIC MODULES THAT CONTROL THE FUEL MANAGEMENT SYSTEM AND THE PARKING BRAKE. THERE IS NO DRAIN IN THE TRUNK THAT WOULD ALLOW WATER TO LEAVE THE VEHICLE. MY VEHICLE WAS PARKED IN A PARKING LOT DURING A RAIN STORM. AS A RESULT OF THE DESIGN, I GOT WATER IN THE TRUNK, WHICH RUINED THESE TWO MODULES, RESULTING IN THE VEHICLE BECOMING DISABLED WHILE DRIVING. I BELIEVE THAT THIS IS A SIGNIFICANT SAFETY ISSUE FOR THE FOLLOWING REASONS: I) AS A CONSUMER, I HAD NO IDEA THAT THE ELECTRONICS THAT ENABLE THE VEHICLE TO MANAGE FUEL WERE LOCATED IN THE TRUNK; II) THE DESIGN OF THE WATER CHANNEL AROUND THE TRUNK SEEMS INADEQUATE GIVEN THAT ANY FAILURE OF THE PLASTIC SHIELD / GROMMET COMBINATION WOULD LEAD TO WATER IN THE TRUNK AND EXPOSE THESE CRITICAL COMPONENTS. *TR

Mileage: 24,000