2006 BMW K1200 R Problems & Recalls

FUEL STRIP INSIDE FUEL TANK THAT SENDS FUEL LEVEL INDICATIONS FAILED. THIS IS THE 4TH STRIP IN 3 YEARS. THIS PROBLEM IS PRESENT IN SEVERAL BMW MOTORCYCLES BUILT FROM 2005 TO PRESENT. *TR

Mileage: 18,000

WHEN I WAS STOPPED AT AN INTERSECTION I NOTICED A VERY STRONG FUEL SMELL COMING FROM MY MOTORCYCLE. I LOOKED FOR LIQUID FUEL LEAKING TO THE GROUND BUT FOUND NONE. I WAS VERY NEAR HOME, SO I RETURNED AND REMOVED THE BODY PANELS TO EXAMINE THE FUEL SYSTEM. I FOUND FUEL LEAKING FROM THE FUEL TANK/PUMP ...

Mileage: 29,180

THERE ARE SEVERAL CRACKS ON THE FLANGE WHERE FUEL LINE HAS A CONNECTION. THESE CRACKS ARE CAUSING FUEL TO LEAK ONTO THE MOTOR AND ALTERNATOR CREATING A FIRE HAZARD. FUEL ALSO POOLS IN AREAS WITH SENSITIVE ELECTRONICS WHERE FUEL WASN'T MEANT TO BE STORED. I HAVE NO DOUBT THAT THIS WOULD EVENTUALLY ...

Mileage: 22,900

THERE ARE SEVERAL CRACKS ON THE FLANGE WHERE FUEL LINE HAS A CONNECTION. THESE CRACKS ARE CAUSING FUEL TO LEAK ONTO THE MOTOR AND ALTERNATOR CREATING A FIRE HAZARD. FUEL ALSO POOLS IN AREAS WITH SENSITIVE ELECTRONICS WHERE FUEL WASN'T MEANT TO BE STORED. I HAVE NO DOUBT THAT THIS WOULD EVENTUALLY ...

Mileage: 22,900

TL* THE CONTACT OWNS A 2006 BMW K1200R. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE SHIFTED OUT OF SECOND GEAR AND LUNGED FORWARD. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FAILURE OCCURRED BECAUSE THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTUR...

Mileage: 56,000

TL* THE CONTACT OWNS A 2006 BMW K1200 R MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE SHIFTED OUT OF GEAR AND VIBRATED. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THE TRANSMISSION HAD FAILED. THE TRANSMISSION WAS REPLACED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. TH...

Mileage: 5,600

AFTER FINISHING A RIDE, HAD STRONG SMELL OF GASOLINE COMING FROM UNDER INSTRUMENT UNIT. DEALER TODAY FOUND CRACKED FUEL PUMP UNIT CAUSING BIKE TO LEAK GAS RIGHT ABOVE ENGINE. *TR

Mileage: 17,411

I NOTICED PETROLEUM SMELL WHEN AT A STOP LIGHT WHEN RIDING THE BIKE HOME FROM WORK. WHEN I PARKED THE BIKE ON THE SIDE STAND IN THE GARAGE FUEL BEGAN TO LEAK DOWN THE LEFT SIDE OF THE MOTORCYCLE. I IMMEDIATELY CALLED MY BMW MECHANIC WHO INFORMED ME TO RIDE THE BIKE OVER TO THE SHOP FOR INSPECTION....

Mileage: 16,700

I RODE BIKE TO WORK AND PARKED IT ON SIDE STAND. AFTER WORK I NOTED A WET SPOT UNDER BIKE BUT COULD NOT DETERMINE IF IT WAS OIL OR GAS. ON THE RIDE HOME I NOTED A PETROLEUM SMELL WHEN AT STOP LIGHTS. I PARKED THE BIKE IN THE GARAGE ON ITS SIDE STAND AND GASOLINE STARTED LEAKING FROM THE LEFT SIDE...

Mileage: 16,000

TL* THE CONTACT OWNS A 2006 BMW K1200 R MOTORCYCLE. THE CONTACT STATED THAT THE ANTI LOCK BRAKING SYSTEM ENGAGED WHEN THE BRAKES WERE APPLIED. THE BRAKES THEN RELEASED MOMENTARILY WHILE THE VEHICLE JERKED FORWARD BEFORE THE MANUAL BRAKES FINALLY ENGAGED. THE FAILURE RECURRED INTERMITTENTLY AT VARIOU...

Mileage: 28,000

ABS BRAKE MODULATOR UNIT FAILED ON PANIC STOP. STOPPING DISTANCE WAS SIGNIFICANTLY INCREASED AND NO POWER BRAKING ASSIST WAS AVAILABLE. COLLISION WITH ANOTHER VEHICLE WAS NARROWLY AVOIDED. ABS MODULATOR HAD TO BE REPLACED. COST OF PART IN EXCESS OF $2000 AND 6 HOURS OF LABOR. *TR

Mileage: 15,000

WHILE RIDING THE VEHICLE, A STRONG FUEL SMELL WAS DETECTED. WHILE STOPPING TO INVESTIGATE, THE REAR TIRE LOCKED UP, BUT A CRASH WAS AVOIDED. I FOUND A LARGE VOLUME OF FUEL SPRAYING FROM BOTH SIDES OF THE MOTORCYCLE. THE FUEL CAME IN CONTACT WITH THE ALTERNATOR, THE HOT EXHAUST, AND THE REAR TIRE. BY...

Mileage: 16,728

TL* THE CONTACT OWNS A 2006 BMW K1200R. THE CONTACT STATED THE VEHICLE INDEPENDENTLY SHIFTS OUT OF SECOND GEAR. THE CONTACT STATED THIS FAILURE OCCURS IN SECOND GEAR, BUT THEN THE FAILURE WILL PROGRESS TO INCLUDE THIRD AND FORTH GEAR. THE DEALER STATED THE RODS IN THE TRANSMISSION WERE BENT AND THA...

Mileage: 300

WHILE DEMONSTRATING THE ABS BRAKING SYSTEM ON MOTORCYCLES FOR A NUMBER OF MOTORCYCLE SAFETY INSTRUCTORS (IN A PARKING LOT,) I HAD RIDDEN WITHIN 5 MINUTES A HANDFUL OF SUCCESSFUL ABS DEMO RUNS. I WAS STARTING AT ONE SIDE OF THE LOT, GETTING UP TO 30-40 MPH, AND APPLYING THE BRAKES WITH ENOUGH FORCE ...

Mileage: 19,893

TL*THE CONTACT OWNS A 2006 BMW K1200 R MOTORCYCLE. THE BRAKES FAILED WHILE THE VEHICLE WAS IN MOTION. THE MANUFACTURER STATED THAT THEY COULD NOT DUPLICATE THE FAILURE WITH THE ABS BECAUSE THEY NO LONGER PRODUCE THOSE PARTICULAR BRAKES. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE CONTACT HAS SEEN...

Mileage: 15,000