2004 BMW M3 Problems & Recalls

Passenger side rear sub-frame crack observed . Vehicle has never been in any accident or collision. It's a commonly know problem about BMW 3 series made between 1999 to 2006 that happens naturally without cause due to manufacture issue, so I decided to look under my car to look for any cracks as des...

WIRING PROBLEM WITH FACTORY HEADLIGHTS. THIS ISSUE CAUSES HEADLIGHTS TO FLICKER AND EVENTUALLY TURN OFF. IT HAPPENS WHILE THE VEHICLE IS IN MOTION AND SITTING STILL.

Mileage: 100,000

TL* THE CONTACT OWNS A 2004 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWA...

TAKATA RECALL -- IT'S BEEN 2 YEARS SINCE THE RECALL WAS ISSUED, BUT THE MANUFACTURER / DEALERSHIP DO NOT SEEM TO BE ABLE TO GET THE PARTS TO REPAIR MY CAR. THIS ESSENTIALLY RENDERS MY CAR UNSAFE, AND IN MANY WAYS, UNUSABLE. I STILL HAVE NOT HEARD ABOUT A DATE BY WHEN THE PARTS WILL BE AVAILABLE / RE...

TAKADA RECALL: NOTIFIED BY BMW JULY 2015 DRIVER-SIDE AIR BAG MODULE DEFECTIVE. IN MAY 2016, BMW ADVISED THEY DID NOT KNOW WHEN AIR BAG WOULD BEFIXED. SINCE THEN ANOTHER PERSON HAS DIED. CONCERNED ABOUT SAFETY AND LENGTH OF TIME WAITING FOR FIX.

Mileage: 91,000

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTUR...

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 BMW M3. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT WAS PLACED ON A WAITING LIST. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABL...

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 BMW M3. THE CONTACT STATED THAT AFTER THE VEHICLE WAS STARTED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V318000 (AIR BAGS) HOWEVER, THE PART ...

NO ACCIDENT. JUST WAITING SINCE SEPTEMBER 2014 TO HAVE MY PASSENGER SIDE AIRBAG REPLACED. I CAN'T DRIVE THE CAR WITH A PASSENGER BECAUSE THE AIRBAG IS AFFECTED BY A RECALL AND THE BMW DEALERS DON'T HAVE THE PARTS TO REPLACE IT. *TR

TL* THE CONTACT OWNS A 2004 BMW M3 CONVERTIBLE. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V428000 (AIR BAGS). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE ...

I WAS DRIVING MY CAR ON LAKE SHORE DRIVE AND I HIT A POT HOLE NEAR LAWRENCE AVE. I ENDED UP GETTING FLAT ON BOTH OF MY RIGHT TIRES. IT POSSIBLY BENT MY RIM, SUSPENSION ISSUES, AND TIRE HAVE BEEN FLAT. *TR

Mileage: 60,800

I WAS DRIVING MY CAR ON LAKE SHORE DRIVE AND I HIT A POT HOLE NEAR LAWRENCE AVE. I ENDED UP GETTING FLAT ON BOTH OF MY RIGHT TIRES. IT POSSIBLY BENT MY RIM, SUSPENSION ISSUES, AND TIRE HAVE BEEN FLAT. *TR

Mileage: 60,800

FAULTY SMG PUMP POSSIBLY CAUSED BY A CULMINATION OF OTHER FAILING PARTS IN SMG SYSTEM. CAR IS RENDERED INOPERABLE IN POTENTIALLY HAZARDOUS DRIVING SITUATIONS THAT WOULD OTHERWISE BE CIRCUMVENTED BY A SYSTEM MORE CAPABLE OF WARNING THE OWNER OF AN IMPENDING FAILURE. THE REMEDY THE MAJORITY OF DEALERS...

Mileage: 110,201

ONE OF THE VANOS EXHAUST HUB TAB BROKE AND DAMAGED THE OIL PUMP DISC. I HAD TO REPLACE THE VANOS EXHAUST HUB AND OIL PUMP DISC. *JS

Mileage: 102,786

VEHICLE DROPS OUT OF GEAR RANDOMLY. AS I WAS TAKING A LEFT TURN, THE VEHICLE DROPPED INTO 0 GEAR AND ON COMING TRAFFIC ALMOST RAN INTO ME HEAD ON. I HAD NO WAY OF MOVING THE CAR DUE TO TRANSMISSION BEING SHIFTED INTO NEUTRAL. THIS IS DUE TO A DEFECTIVE TEMPERATURE SENSOR ON THE SMG PUMP. BMW IGNORE...

Mileage: 65,000

VEHICLE DROPS OUT OF GEAR RANDOMLY. AS I WAS TAKING A LEFT TURN, THE VEHICLE DROPPED INTO 0 GEAR AND ON COMING TRAFFIC ALMOST RAN INTO ME HEAD ON. I HAD NO WAY OF MOVING THE CAR DUE TO TRANSMISSION BEING SHIFTED INTO NEUTRAL. THIS IS DUE TO A DEFECTIVE TEMPERATURE SENSOR ON THE SMG PUMP. BMW IGNORE...

Mileage: 65,000

VEHICLE DROPS OUT OF GEAR RANDOMLY. AS I WAS TAKING A LEFT TURN, THE VEHICLE DROPPED INTO 0 GEAR AND ON COMING TRAFFIC ALMOST RAN INTO ME HEAD ON. I HAD NO WAY OF MOVING THE CAR DUE TO TRANSMISSION BEING SHIFTED INTO NEUTRAL. THIS IS DUE TO A DEFECTIVE TEMPERATURE SENSOR ON THE SMG PUMP. BMW IGNORE...

Mileage: 65,000

THE REAR LAMPS IN MY BODY PANEL THAT HOUSE THE BRAKE LAMP, TURN SIGNAL, AND TAIL LAMP STOPPED WORKING AND NEEDED TO BE FULLY REPLACED. MY CAR IS A LOW MILEAGE VEHICLE. THIS SAME ISSUE WAS THE SUBJECT OF NHTSA #11V438000. HOWEVER, THIS RECALL DID NOT INCLUDE THE M3, JUST ALL OF THE OTHER 3 SERIES B...

Mileage: 31,000

THIS IS THE SECOND TIME THIS HAPPENED TO MY CAR THE SMG (SEQUENTIAL MANUAL GEAR) LIGHT COMES ON AND THEN MY SERVICE ENGINE LIGHT COMES ON AS WELL EVERY TIME IN THAT ORDER , ALSO MY CAR SHIFTS ITSELF INTO NEUTRAL ALL ON ITS OWN AND I CAN,T CONTROL THE ACCELERATION ON THE HIGHWAY OR ANYWHERE ELSE SO T...

Mileage: 54,462

THIS IS THE SECOND TIME THIS HAPPENED TO MY CAR THE SMG (SEQUENTIAL MANUAL GEAR) LIGHT COMES ON AND THEN MY SERVICE ENGINE LIGHT COMES ON AS WELL EVERY TIME IN THAT ORDER , ALSO MY CAR SHIFTS ITSELF INTO NEUTRAL ALL ON ITS OWN AND I CAN,T CONTROL THE ACCELERATION ON THE HIGHWAY OR ANYWHERE ELSE SO T...

Mileage: 54,462

I INSPECTED THE TRUNK FLOORPAN AND NOTICED BUCKLING, CRACKING OF THE TRUNK FLOOR AND WELDED SEAMS COMING APART. THE REAR SUBFRAME MOUNTS WERE CRACKED ON BOTH SIDES. THE REAR SUBFRAME IS RIPPING ITSELF OUT OF THE CAR AND I'M VERY LUCKY I FOUND THIS WHILE THE CAR WAS AT REST AND NOT DRIVING AT SPEED...

Mileage: 128,000

I INSPECTED THE TRUNK FLOORPAN AND NOTICED BUCKLING, CRACKING OF THE TRUNK FLOOR AND WELDED SEAMS COMING APART. THE REAR SUBFRAME MOUNTS WERE CRACKED ON BOTH SIDES. THE REAR SUBFRAME IS RIPPING ITSELF OUT OF THE CAR AND I'M VERY LUCKY I FOUND THIS WHILE THE CAR WAS AT REST AND NOT DRIVING AT SPEED...

Mileage: 128,000

GOT INTO MY CAR IN THE AFTERNOON AND NOTICED THE REAR VIEW MIRROR WAS DISTORTED. AFTER INSPECTING, REALIZED THAT THE LIQUID HAD SEPARATED BEHIND MIRROR. HAD TO RUN AN ERRAND. STARTED DRIVING AND THEN HEARD A LOUD "POP" NOISE. LOOKED AT MIRROR AND THE LIQUID WAS VERY VISIBLE MOVING BEHIND GLASS. ...

Mileage: 83,488

AUTOMATIC TRANSMISSION SMG HYDRAULIC PUMP FAILED. *TR

Mileage: 72,500

HAD MY CAR INSPECTED BY A MECHANIC AND HE NOTICED A TEAR IN THE SUBFRAME NEAR THE REAR DRIVERS SIDE. TUNES OUT THIS IS A KNOWN PROBLEM FOR E46 BMWS. BMW WILL ONLY COVER 50% OF THE REPAIRS AND HAS ADMITTED THAT THIS IS A DEFECT IN THEIR DESIGN. IT'S NOW A SAFETY ISSUE AS THE CAR IS OUT OF ALIGNM...

Mileage: 95,000

HAD MY CAR INSPECTED BY A MECHANIC AND HE NOTICED A TEAR IN THE SUBFRAME NEAR THE REAR DRIVERS SIDE. TUNES OUT THIS IS A KNOWN PROBLEM FOR E46 BMWS. BMW WILL ONLY COVER 50% OF THE REPAIRS AND HAS ADMITTED THAT THIS IS A DEFECT IN THEIR DESIGN. IT'S NOW A SAFETY ISSUE AS THE CAR IS OUT OF ALIGNM...

Mileage: 95,000

BEFORE I START EXPLAINING, I SHOULD MENTION THAT THE CAR HAS BEEN METICULOUSLY MAINTAINED WITH MAJORITY OF THE PARTS BEING GENUINE BMW. THE CHASSIS HAS 110,XXX MILES AT THE MOMENT, AND THE ENGINE HAS 78,XXX MILES. THE ENGINE HAD A FAILURE IN 2006 DUE TO A ROD BEARING FAILURE (RECALLED FROM BMW), AND...

Mileage: 110,000

THE SMG TRANSMISSION IN A 2004 BMW M3 WILL RANDOMLY SHIFT INTO NEUTRAL DISABLING THE VEHICLE ON HOT DAYS WITHOUT WARNING. OCCURS ON ANY DAY WHERE TEMPERATURES EXCEED 95 DEGREES. *TR

Mileage: 95,000

TL* THE CONTACT OWNS A 2004 BMW M3 CONVERTIBLE. THE CONTACT STATED THAT THE VEHICLE WOULD SLIP OUT OF GEAR WHILE DRIVING AT ANY SPEED. THE CONTACT STATED THAT BECAUSE THE VEHICLE HAD A SMG TRANSMISSION, THE FAILURE WOULD NOT ALLOW THE CONTACT TO ACCELERATE AND HE WOULD HAVE TO SHUT THE VEHICLE OFF A...

Mileage: 40,000

REARVIEW MIRROR LEAKED ELECTROCHROMIC FLUID ALL OVER CONSOLE AND SEATS, BADLY DAMAGING THEM. WILL NEED TO REPLACE MIRROR AND DAMAGED PARTS. *TR

Mileage: 95,000

REARVIEW MIRROR LEAKED ELECTROCHROMIC FLUID ALL OVER CONSOLE AND SEATS, BADLY DAMAGING THEM. WILL NEED TO REPLACE MIRROR AND DAMAGED PARTS. *TR

Mileage: 43,400

HADN'T DRIVEN THE CAR IN 2 WEEKS, WAS OUT OF TOWN. DROVE IT TO WORK ON MONDAY AND MONDAY EVENING OR TUESDAY MORNING NOTICED WHAT LOOKED LIKE A BUBBLE AT THE TOP OF MY REAR VIEW MIRROR. BY TUESDAY NOON, THE BUBBLE WAS IN THE CENTER OF THE MIRROR AND WHEN I CAME OUT TO THE CAR AT ABOUT 5:30 THAT AFT...

Mileage: 60,000

2004 BMW M3 AUTO DIMMING REARVIEW MIRROR, MIRROR LEAKED CAUSTIC/CORROSIVE UNKNOWN LIQUID ONTO PASSENGER SEAT AND CENTER CONSOLE, LIQUID WAS SO CORROSIVE IT DAMAGED LEATHER SEAT AND CENTER CONSOLE, BUBBLING PAINT AND EATING AWAY AT LEATHER SEAT. APPARENTLY THIS HAS BEEN HAPPENING TO ALOT OF BMW M3'S...

Mileage: 25,340

LIQUID LEAKING FROM REAR VIEW MIRROR, POSSIBLY CORROSIVE AS CENTER DOME AROUND SHIFTER KNOB BEGAN TO PEEL FROM CONTACT WITH LIQUID. REAR VIEW MIRROR NO LONGER FULLY FUNCTIONAL; BLURRY, DISTORTED VIEW. *TR

Mileage: 94,000

REAR VIEW MIRROR LEAKS CAUSTIC FLUID, AND TURNS BLACK, UNABLE TO BE USED. DEALERSHIPS WILL NOT REPLACE THE FAULTY UNIT. DOCUMENTATION OF COMMON OCCURRENCE: HTTP://WWW.M3FORUM.NET/M3FORUM/SHOWTHREAD.PHP?T=167927&HIGHLIGHT=MIRROR+LEAK ACID HAS BEEN REPORTED TO CAUSE SKIN INJURIES. *TR

Mileage: 55,000

TL*THE CONTACT OWNS A 2004 BMW M3. WHILE DRIVING 65-70 MPH, THE CALIPERS LOCKED SUDDENLY. THE CONTACT PULLED OFF THE HIGHWAY AND WAITED FOR THE CALIPERS TO COOL DOWN IN ORDER TO DRIVE THE VEHICLE. THE MANUFACTURER STATED THAT THEY HAD NEVER HEARD OF THIS TYPE OF FAILURE. CURRENTLY, THE DEALER IS...

Mileage: 37,000