2009 BMW R1200 GS Problems & Recalls

I WAS DRIVING MY MOTORCYCLE WHEN I NOTICED A GAS LEAK COMING FROM THE FITTING WHERE THE FUEL LINE GOES INTO THE FUEL PUMP ON THE LEFT SIDE OF THE GAS TANK. THIS CAUSED GAS TO DRIP DIRECTLY ONTO THE LEFT SIDE EXHAUST MANIFOLD, WHICH COULD CAUSE A FIRE. IN THE PAST I HAD AN ISSUE WITH THE PLASTIC ...

Mileage: 10,700

MULTIPLE FUEL STRP FAILURES, RESULTING IN LOSS OF FUEL RELATED WARNINGS.

Mileage: 12,500

THE FUEL PUMP FLANGE CONNECTION IS CRACKED AND LEAKING FUEL. THERE ARE MULTIPLE PICTURES VIDEOS AND THREADS REGARDING RECALLS FOR THE EXACT SAME FUEL LEAK THAT I AM EXPERIENCING ON THE INTERNET. HOWEVER WHEN I CALLED BMW OF NORTH AMERICA THEY TELL ME THAT MY MOTORCYCLE IS NOT INCLUDED IN THE RECA...

Mileage: 23,000

I WAS ACCELERATING ON THE ON-RAMP TO MERGE IN TO THE SLOW LANE WITH HEAVY TRAFFIC ON THE 80 NORTH BOUND HEADING HOME. I HAD JUST SHIFTED THE MOTORCYCLE IN TO 3RD GEAR WHEN IT LOST ALL POWER AND STARTED SLOWING DOWN. THE NEXT EXIT WAS NOT AVAILABLE TO REACH SAFELY AND MY ONLY OPTION WAS TO COAST INT...

Mileage: 28,650

FUEL LEVEL SENSOR FAILURE TWICE. UNABLE TO DETERMINE LEVEL OF FUEL IN TAKE WHILE DRIVING AND STOPPED. INCREASED RISK OF RUNNING OUT OF GAS IN TRAFFIC.

Mileage: 4,700

ON FOUR DIFFERENT OCCASIONS, THE FUEL GAGE HAS FAILED. TWICE IT SHOWED FUEL WHILE RUNNING EMPTY, ONCE IN TRAFFIC. ON TWO OTHER OCCASIONS THE FUEL SCREEN HAS GONE BLANK. THREE TIMES THEY HAVE REPAIRED IT UNDER WARRANTY. IT HAS NOW HAPPENED AGAIN. I HAVE SINCE HEARD THEY RECALLED THERE CARS WITH THE ...

Mileage: 3,500

FUEL GAUGE SUDDENLY FAILED AND GAVE INACCURATE READING. I HAVE HAD THE FUEL GAUGE REPLACED 4 TIMES, MOST RECENTLY LESS THAN ONE MONTH AGO, ALWAYS BY A BMW DEALER. THAT MOST RECENT GAUGE, INSTALLED 6/7/2014 BY THE DEALER, FAILED COMPLETELY, WITHOUT WARNING, ON 7/3/14 AFTER LESS THAN 250 MILES. THE...

Mileage: 22,520

TL* THE CONTACT OWNS A 2009 BMW 1200 GS MOTORCYCLE. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE REAR FINAL DRIVE BEARING BECAME SEPARATED. THE CONTACT WAS ABLE TO STOP THE MOTORCYCLE WITH THE FRONT BRAKE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE REAR FINAL BEARING WAS REPLACED. THE...

Mileage: 42,182

TRAVELING APPROX 60 MPH DURING RUSH HOUR IN MIDDLE LANE OF THREE LANE DIVIDED HIGHWAY. FUEL GAUGE SHOWED TWO BARS AND DISPLAY INDICATED APPROX 60 MILES OF RANGE LEFT. ENGINE SUDDENLY LOST POWER. I WAS ABLE TO GET TO RIGHT SHOULDER WHEN ENGINE DIED AND WOULD NOT RESTART. WAS ABLE TO PUSH APPROX 1/4 M...

Mileage: 20,434

30,000 MILES, ONE WEEK AFTER DEALERSHIP COMPLETED THE REQUIRED 30K SERVICE, DRIVING 35-40 MPH ON ASPHALT ROAD, FELT EXTREME WOBBLE ON BACK WHEEL, BLACK OIL ALL OVER BACK RIM AND WHEEL. DEALERSHIP REPORTS THE COMPLETE FINAL DRIVE SYSTEM FAILED AT A COST OF $2500.00 TO ME AS IT JUST WENT OUT OF WARRA...

Mileage: 30,000

REFER TO ODI NO. 10439549/CAMPAIGN DP12001. DRIVING AT FREEWAY SPEEDS AND MOTORCYCLE REAR TIRE BEGAN TO DRIFT UNEXPECTEDLY AND MOVE SIDEWAYS. PULLED OVER EXIT AND FOUND FINAL DRIVE (DIFFERENTIAL), BRAKE AND REAR TIRE COVERED IN OIL. DISASSEMBLY REVEALED FAILED BALL BEARING (CAGE HAD DISINTEGRA...

Mileage: 41,240

BIKE FUEL METER DOES NOT FUNCTION. REPLACED UNDER WARRANTY 8/12/11 AND 8/10/13. FUEL METER RELIES ON SENSOR STRIP INSIDE FUEL TANK. SENSOR STRIP FAILS WITHOUT WARNING. OBVIOUS SAFETY ISSUE IF FAILURE CAUSES BIKE TO UNKNOWINGLY AND SUDDENLY RUN OUT OF FUEL WHILE MOVING. *TR

Mileage: 15,329

BIKE FUEL METER DOES NOT FUNCTION. REPLACED UNDER WARRANTY 8/12/11 AND 8/10/13. FUEL METER RELIES ON SENSOR STRIP INSIDE FUEL TANK. SENSOR STRIP FAILS WITHOUT WARNING. OBVIOUS SAFETY ISSUE IF FAILURE CAUSES BIKE TO UNKNOWINGLY AND SUDDENLY RUN OUT OF FUEL WHILE MOVING. *TR

Mileage: 15,329

THE FUEL GAUGE STOPPED WORKING AND THERE WAS A YELLOW WARNING LIGHT APPEARED ON THE DISPLAY. PRIOR TO THE OUTRIGHT FAILURE, THE GAUGE HAD OCCASIONALLY SHOWN A FALSE VALUE, SHOWING TOO MUCH FUEL FOR THE MILES COVERED, AND THEN SUDDENLY IT WOULD DROP TO THE CORRECT VALUE, INDICATING ALMOST ZERO FUEL ...

Mileage: 9,800

THE FUEL GAUGE STOPPED WORKING AND THERE WAS A YELLOW WARNING LIGHT APPEARED ON THE DISPLAY. PRIOR TO THE OUTRIGHT FAILURE, THE GAUGE HAD OCCASIONALLY SHOWN A FALSE VALUE, SHOWING TOO MUCH FUEL FOR THE MILES COVERED, AND THEN SUDDENLY IT WOULD DROP TO THE CORRECT VALUE, INDICATING ALMOST ZERO FUEL ...

Mileage: 9,800

WHILE OPERATING THE MOTORCYCLE AT APPROXIMATELY 50 MPH IT SUDDENLY STOPPED RUNNING. AFTER COASTING TO A STOP I OBSERVED FUEL STEADILY LEAKING FROM THE FUEL PUMP, DOWN THE FRONT OF THE ENGINE AND ONTO THE HOT EXHAUST. I HAD TO LEAN THE BIKE AGAINST A FENCE POST IN ORDER TO GET FUEL TO FLOW AWAY FROM ...

Mileage: 5,200

FUEL GAUGE FREQUENTLY INDICATES PLENTY OF FUEL IN TANK WHEN TANK RUNS EMPTY. GAUGE WILL ALSO OCCASIONALLY SHOW EMPTY WHEN SEVERAL GALLONS OF FUEL IN TANKS. *TR ## VIN FAILED ##

Mileage: 12,000

FUEL GAUGE FREQUENTLY INDICATES PLENTY OF FUEL IN TANK WHEN TANK RUNS EMPTY. GAUGE WILL ALSO OCCASIONALLY SHOW EMPTY WHEN SEVERAL GALLONS OF FUEL IN TANKS. *TR ## VIN FAILED ##

Mileage: 12,000

RIDING THE MOTORCYCLE TO DEALERSHIP WHEN I NOTICED A VIBRATION IN THE DRIVE TRAIN. DEALERSHIP DIAGNOSED AS FINAL DRIVE CROWN BEARING FAILURE(ESSENTIALLY REAR WHEEL BEARING). *TR

Mileage: 28,519

RIDING THE MOTORCYCLE TO DEALERSHIP WHEN I NOTICED A VIBRATION IN THE DRIVE TRAIN. DEALERSHIP DIAGNOSED AS FINAL DRIVE CROWN BEARING FAILURE(ESSENTIALLY REAR WHEEL BEARING). *TR

Mileage: 28,519

BMW MOTORCYCLES FUEL GAUGE WITH "ELECTRONIC FUEL STRIP" FAIL RESULTING IN SAME CONDITION AS THEIR CAR RECALL SHOWN BELOW! DANGEROUS CONDITION RESULTS. (POST 2010 MODELS CHANGED TO FLOAT TYPE SYSTEM). SUMMARY: BMW IS RECALLING CERTAIN 2010 AND 2011 5-SERIES AND 5-SERIES GRAN TURISMO PASSENGER VEHI...

Mileage: 19,404

AT THE INDICATED TIME, I NOTICED ROUGHNESS WHILE DRIVING. I STOPPED, EXAMINED THE DRIVETRAIN, AND FOUND ROUGHNESS WHEN TURNING THE REAR WHEEL BY HAND. I DRAINED THE DRIVETRAIN OIL AND FOUND METALLIC PARTICLES THE TEXTURE OF COARSE SAND ADHERING TO THE MAGNETIC DRAIN PLUG. THE LOCAL AUTHORIZED BMW DE...

Mileage: 10,000