2006 BMW X5 Service Brakes Problems

The brake vacuum pump has leaked a small amount of lubricating oil into the hose. This contamination resulted in a loss of power assist braking. The loss of power assist in braking has increased stopping distance and lead to a near vehicle crash. No indicator lights were present. Repair: Replacement of the brake vacuum line with one that contains a check valve, eliminating the possibility that oil will reach the brake booster; as well as the brake booster and brake master cylinder will also be replaced.

THE BRAKES PEDAL BECOMES HARD AND IS UNABLE TO STOP VEHICLE. THIS OCCUR WHILE THE VEHICLE IS MOVING. IN ADDITION THE BRAKE PEDAL IS HARD WHILE STATIONARY AS WELL

Mileage: 140,000

SUDDEN LOSS OF BRAKE FUNCTION AND LEAKING BRAKE FLUID DURING NORMAL WEATHER AD ROAD OPERATIONS. AFTER DOING RESEARCH THERE IS A LARGE GROUP OF SIMILAR YEAR MAKE AND MODEL WITH THIS SAME ISSUE.

Mileage: 195,000

BRAKE BOOSTER FAILED WHILE STOPPED WITHOUT ANY WARNING LIGHTS

Mileage: 120,000

TL* THE CONTACT OWNS A 2006 BMW X5. WHILE DRIVING 65 MPH, THE BRAKES FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE BOOSTER, CYLINDER, AND VACUUM FAILED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V446000 (SERVICE BRAKES). IN ADDITION, THE BRAKE PADS WERE REPLACED A YEAR AGO. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN THE VIN AND THAT IT WOULD BE AN OUT OF POCKET EXPENSE. THE FAILURE MILEAGE WAS UNKNOWN.

2006 X5 VIN [XXX] WHILE IN MOTION ON A CITY STREET AND HWY! 1. BRAKE BOOSTER / VACUUM LINE FAILURE SAME AS RECALLED 2007-2010 ISSUE. WHY IS MY 2006 X5 BMW NOT COVERED WHEN THERE IS CLEARLY A SYSTEMIC FAILURE OF THIS SAME SYSTEM? I SEEK IMMEDIATE RELIEF AND DEMAND UPON YOU A RECALL FOR MY SPECIFIC BMW NOW TODAY. [XXX] CALL ME! 2. ALTERNATOR FAILURE X5 ACTED POSSESSED WITH ALL LIGHTS GOING ON AND OFF BEFORE SHUTTING THE CAR DOWN ON A FREEWAY WHILE AT MAX LEGAL SPEED. ALTERNATOR IS PLACED LOW ON THE LEFT SIDE WHERE OIL LEAKS INTO IT CAUSING A FAILURE MODE. THE SAME OIL LEAKS CAUSE OTHER RUBBER COMPONENTS TO SWELL UP CRACK AND FAIL SUCH AS BOOTS AND RUBBER BUSHINGS ON ARMS. WHERE IS THE RECALL?? 2006 WHERE IS IT?? 3. BRAKE LIGHT SYSTEM FAILURE BACK R/H AND CHANGING LIGHT BULBS DIDN'T BRING IT TO WORKING CONDITION. BMW USED A SCREW DRIVER TO MAKE IT WORK AGAIN AFTER THE AIRBAG AND ALTERNATOR REPAIR THEY DID..I PAID FOR THE ALTERNATOR BUT IT SHOULD HAVE BEEN A RECALL ITEM! NOW MY BRAKE LIGHTS DON'T WORK BACK R/H SIDE. 5. 1 HEAD LIGHT OUT 6. ENGINE LEAKS OIL ON THE SIDE ONTO MY X5 RUBBER COMPONENTS AND I ALREADY HAD TO PAY FOR A NEW BOOT AND ARM! OTHER RUBBER ITEMS ARE ALL BAD AND GETTING WORSE! WHERE IS THE RECALL? WHY ARE THESE SAFETY ITEMS NOT BEING RECALLED BY YOUR GOVERNMENTAL ORGANIZATION? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE ISSUE IS SPECIFICALLY WITH THE BRAKING SYSTEM. THE CAR DEVELOPED A SUDDEN DANGEROUS LOSS OF BRAKING POWER. ONE MOMENT THE BRAKES WERE WORKING CORRECTLY AND THE NEXT THEY WERE NOT. BMW HAS 2 RECALLS FOR THIS ISSUE BUT FOR UNKNOWN REASONS MY CAR IS NOT INCLUDED IN EITHER RECALL. THE RECALL CAMPAIGNS ARE 10V-446 & 13V-045. THE DESCRIPTION OF THE PROBLEM IS THE FOLLOWING: "THIS RECALL INVOLVES THE POWER ASSIST BRAKING FUNCTION. A SMALL AMOUNT OF OIL COULD LEAK FROM THE BRAKE VACUUM PUMP INTO THE BRAKE VACUUM HOSE. OVER TIME, CONTAMINATION OF THE BRAKE BOOSTER COULD OCCUR. THIS COULD AFFECT THE POWER ASSIST BRAKING FUNCTION. IN CERTAIN CASES, LOSS OF POWER BRAKE ASSIST COULD OCCUR. IF THIS HAPPENED, IT WOULD REQUIRE GREATER BRAKE PEDAL FORCE, INCREASE THE STOPPING DISTANCE, AND INCREASE THE RISK OF A CRASH. " MY CAR HAS THE EXACT ISSUE AS DESCRIBED IN THE RECALLS. THERE IS NO WARNING LIGHT TO INDICATE THERE ARE ANY ISSUES WITH THE BRAKES. I CALLED BMW NA AND DESCRIBED THE ISSUE TO THEM AND THEY TOLD ME TO TAKE IT TO MY LOCAL BMW DEALERSHIP TO HAVE THE ISSUE DIAGNOSED. THE LOCAL DEALERSHIP DETERMINED MY CAR HAD THE ISSUE AS DETAILED IN BOTH BMW RECALLS. AS INSTRUCTED BY BMW I REPORTED THIS BACK TO THEM AND AFTER SEVERAL WEEKS THEY FOLLOWED UP WITH ME (2/10/15 TO BE EXACT) ONLY TO TELL ME THEY WILL NOT FIX THE ISSUE AS PART OF THE RECALL AND THUS I WOULD HAVE TO PAY FOR IT OUT OF MY OWN POCKET. THIS DECISION WAS MADE DESPITE THE FACT THAT MY CAR MEETS NEARLY ALL PARAMETERS OF THE RECALLS (MY EXACT MODEL IS NOT LISTED AS PART OF THE RECALL BUT THE MODEL OF BRAKING SYSTEM AND ENGINE MATCHES THE RECALL DETAILS). THIS IS A SERIOUS SAFETY ISSUE AND ONE THAT I DO NOT BELIEVE BMW SHOULD BE OVERLOOKING OR DENYING COVERAGE FOR. THIS BRAKE ISSUE AFFECTS MORE THAN JUST THE CARS LISTED IN THE TWO BMW RECALLS.

Mileage: 156,000

TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKES UPON ENGAGING FOR A BRIEF MOMENT. AFTER COMING TO A STOP, THE CONTACT WAS ABLE TO RESUME DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THAT THE POWER ASSIST WAS FAULTY. THE BRAKE BOOSTER, VACUUM PUMP AND POWER ASSIST WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.

Mileage: 143,000

BRAKE WARNING LIGHT CAME ON, WENT TO MY REPAIRMAN WHO ADDED BRAKE FLUID AND SAID TO WATCH FOR BRAKE FLUID SPOTS ON GARAGE FLOOR. FOUND SPOTS COMING FROM AREA BEHIND FRONT WHEEL ON DRIVERS SIDE. TOOK IT BACK FOR CHECK AND IT WAS DETERMINED THAT LINE HAD ROTTED THROUGH. HARD TO UNDERSTAND THIS WAS IN ENCLOSED PROTECTED AREA. *TR

I ALREADY FILED COMPLAINTS FOR A FAILED BRAKE BOOSTER, MASTER CYLINDER PUMP, WATER PUMP LEAKING COOLANT, POWER STEERING PUMP LEAKING OIL. I FAILED TO MENTION THAT THE VALVE GASKET COVER ALSO NEEDED TO BE REPLACED AS OIL WAS SPEWING ALL OVER THE ENGINE. AT THIS POINT, THIS VEHICLE SHOULD BE RECALLED IN ITS ENTIRETY. *TR

Mileage: 108,000

BRAKE BOOSTER AND MASTER CYLINDER FAILED IN JUNE. NOT COVERED UNDER RECALL SINCE A RECALL HAD NOT BEEN ISSUED FOR THE 2006 MODELS. SHORTLY THEREAFTER THE WATER PUMP BEGAN LEAKING COOLANT. AGAIN, NOT COVERED FOR 2006 MODELS. NOW THERE IS A SEVERE LEAK IN THE POWER STEERING PUMP. ALL SHOULD BE RECALLED. ALREADY SPENT OVER $4K IN REPAIRS FOR A VEHICLE THAT, GIVEN ITS PRICE AND CLAIMS OF EXTRAORDINARY GERMAN ENGINEERING, SHOULD NOT HAVE BEEN NECESSARY. VERY DISAPPOINTED. *TR

Mileage: 108,000

WHILE SITTING AT A RED LIGHT THE BRAKE PEDAL ALL OF SUDDEN BECAME HARD AND APPLIED A UNREASONABLE AMOUNT OF PRESSURE AGAINST MY LEG. IN ORDER TO MAKE THE CAR STOP I NEEDED TO EXERT A TREMENDOUS AMOUNT OF PRESSURE IN ORDER TO STOP THE CAR FROM ROLLING FORWARD AND HITTING THE CAR IN FRONT OF ME. THERE HAS BEEN A RECALL FOR THE 2007 AND NEWER 8 CYL X5 BRAKE BOOSTERS. OBVIOUSLY THIS IS THE SAME PROBLEM AND THERE SHOULD BE A RECALL DONE WITH THIS CAR AS WELL. ANY DENIAL ON THE PART OF BMW THAT THIS IS A PRODUCT DEFECT IS A DENIAL ON THEIR PART. *TR

Mileage: 94,000

TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT WHILE AT A TRAFFIC LIGHT, THE BRAKES FAILED TO RESPOND. THE PROBLEM RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, THE VEHICLE CONTINUED TO MOVE FORWARD ALTHOUGH THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN WAS UNABLE TO LOCATE A FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Mileage: 95,000

THE BRAKES FAILED WHILE I WAS DRIVING TO WORK. I STEPPED ON THE BRAKES TO STOP FROM APPROXIMATELY 30MPH AND THE VEHICLE DID NOT SLOW DOWN OR COME TO A STOP. I HAD TO STEER ONTO THE MEDIAN TO AVOID HITTING THE VEHICLE IN FRONT OF ME. MECHANIC SAID THE BOOSTER NEEDS TO BE REPLACED. NO WARNINGS DISPLAYED IN DASHBOARD. EXTREMELY DANGEROUS AND I'M LUCKY TO HAVE AVOIDED A MORE SERIOUS ACCIDENT. SOMEONE COULD HAVE BEEN SERIOUSLY HURT GIVEN THE SIZE OF THIS VEHICLE. *TR

Mileage: 107,000

MY X5 4.4 BEGAN TO HAVE A HARDER AND HARDER BRAKE PEDAL. IN A THREE WEEK PERIOD IT WENT FROM A LITTLE HARD AT THE END OF THE STOP TO ABSOLUTELY NO BRAKES. WHAT IS MORE CONCERNING IS THAT MY MOTHER-IN-LAW ALSO HAS A 2006 X5 4.4 THAT THE SAME EXACT THING HAS HAPPENED AND SHE HAS HALF THE MILES. THIS APPEARS TO BE A WORKMANSHIP OR DESIGN FAULT SINCE IT IS NOT MILEAGE DEPENDENT BUT AGE. IT IS AN ABSOLUTE SAFETY CONCERN SINCE THE BRAKES WILL COMPLETELY FAIL SHORTLY AFTER THE 1ST INDICATION. BMW HAS A HISTORY OF SKATING ON RECALLS, THE SAME PROBLEM HAPPENS TO 5 SERIES USING THE SAME SET UP AND IT WAS RECALLED. *TR

Mileage: 72,000

ON AUGUST 8TH 2013 WHILE WE WERE ON VACATION IN NORTHERN NY, THE VEHICLE BRAKING SYSTEM FAILED -' PEDAL TO THE FLOOR WITH VERY MINIMAL BRAKING FUNCTION. THIS IS A HUGE CONCERN IN ANY AREA, BUT WE WERE IN A MOUNTAINOUS REGION OF NY AND THIS COULD HAVE ENDED VERY VERY BAD. LUCKILY IT DIDN'T. I CALLED THE CLOSEST BMW (KEELER) DEALER AND SPOKE WITH A SERVICE REPRESENTATIVE. I NOTED THE YEAR AND MODEL AND EXPLAINED THE SYMPTOMS. THE SERVICE REPRESENTATIVE KNEW IMMEDIATELY WHAT IT WAS. HE HAD ME CHECK UNDER THE DRIVER'S SIDE OF THE VEHICLE FOR A BRAKE LINE LEAK. SURE ENOUGH HE WAS CORRECT; BRAKE FLUID WAS DRIPPING FROM THE COVER UNDER THE DRIVER'S FLOOR. HE MADE NOTE THAT THEY SEE THIS VERY FREQUENTLY IN THEIR SERVICE GROUP. THEY HAD ANOTHER X5 IN THE SHOP FOR THE SAME PROBLEM AND BECAUSE THAT OWNER WAS A "LOCAL", KEELER USED THEIR PARTS FOR OUR VEHICLE. VERY CONCERNING IS THE FACT THAT A MONTH EARLIER, WE HAD A NYS INSPECTION AND THE CORRODED BRAKE LINES WENT UNNOTICED. WHEN WE RETURNED HOME, I SPOKE TO THE BMW OF ROCHESTER SERVICE GUYS ABOUT THIS. TO MY SURPRISE, THEY CONFIRMED THAT THEY TO SEE THIS CORRODED BRAKE LINE PROBLEM ON A REGULAR BASIS. I PAID $2106.57 FOR A PROBLEM THAT YOUR SERVICE TEAMS SEE ON A REGULAR BASIS, YET NOTHING HAS EVER BEEN MENTIONED TO ME AND THE VEHICLE PASSED THE NYS SAFETY INSPECTION A MONTH EARLIER. I WORKED WITH BMW OF ROCHESTER SERVICE AND DISCUSSED MY CONCERNS REGARDING THE BRAKE FAILURE. BMW EXTENDED A GOOD FAITH OFFER OF $2000.00 TOWARDS A NEW VEHICLE. THIS APPEARS TO BE A COMMON PROBLEM THAT THE BMW SERVICE SHOPS SEE FREQUENTLY. IT RENDERED THE VEHICLE UNSAFE TO DRIVE AND SHOULD HAVE BEEN DISCOVERED WITH A PROPER SAFETY INSPECTION. BEST REGARDS. *TR

Mileage: 72,269

TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT THE WHILE DRIVING 10 MPH, THE CONTACT ATTEMPTED TO BRAKE BUT THE BRAKE PEDAL SEIZED. THE VEHICLE DID STOP, BUT HESITATED TO RESPOND. THE FAILURE RECURRED AT DIFFERENT SPEEDS. THE VEHICLE WAS INSPECTED AT AN INDEPENDENT REPAIR SHOP WHERE IT WAS DETERMINED THAT THE FAILURE WAS CAUSED BY OIL THAT WAS PRESENT IN THE BRAKE BOOSTER. THE VACUUM PUMP LEAKED OIL INTO THE BRAKE BOOSTER, CAUSING THE BRAKE ASSIST TO FAIL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

Mileage: 120,000

VERY DISAPPOINTED IN BMW THIS TIME. MY BRAKES SYSTEM SUDDENLY FAILED, CAUSING MY VEHICLE TO CRASH INTO A POLL IN THE STREET PARKING. FRONT BUMPER WAS COMPLETELY DAMAGED. RIGHT AFTER, WE FOUND OUT THAT THE BRAKES WERE NOT WORKING PROPERLY, HAS TO KEEP FULL FORCE ON BRAKE TO KEEP AT FULL STOP. WE CALLED BMW SERVICE THEY SAID TO JUST BRING THE CAR AS THEY RECENTLY RECALLED MY CAR FOR RECALL FOR THIS ISSUE. WE TOOK THE CAR TO BMW SERVICE, AFTER THEY CHECKED MY VIN # THEY SAID MY CAR WAS ACTUALLY NOT COVERED IN THAT RECALL, EVEN THOUGH IT WAS THE SAME PROBLEM. THIS INCIDENT COULD HAVE BEEN WORST, SOMEONE COULD HAVE BEEN SERIOUSLY INJURED OR KILLED AS A RESULT TO THIS SUDDEN LOSS OF BRAKE ASSIST. CALLED BMW, BUT THEY ARE NOT WILLING TO DO ANYTHING AT THIS POINT UNTIL A OFFICIAL RECALL IS POSTED FOR 2006 YEAR X5 4.4 MODELS. NOW I HAVE BODY DAMAGE AND A $1,500 BRAKE REPAIR ESTIMATE I HAVE TO DEAL WITH. "NOT GOOD BMW. NOT GOOD." PLEASE CONSIDER THIS AS A RECALL GUYS, EVERY X5 4.4 OWNER SHOULD GET THIS PREVENTIVE MAINTENANCE, I SEE MANY OTHER PEOPLE COMPLAINING ABOUT THE SAME ISSUE. *TR

Mileage: 98,000

TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE CONTACT APPLIED THE BRAKES BUT THE VEHICLE FAILED TO DECELERATE. THE CONTACT HAD TO APPLY BOTH FEET TO THE BRAKE PEDAL TO STOP THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST. THE TEST RESULTS SHOWED A DEFECTIVE BRAKE BOOSTER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 114,000.

Mileage: 114,000

TL* THE CONTACT OWNS A 2006 BMW X5. THE CONTACT STATED THAT OIL WAS LEAKING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHO INFORMED THE CONTACT THAT THE BRAKE VACUUM PUMP WOULD NEED TO BE REPLACED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN THE MANUFACTURER'S RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 46,000.

Mileage: 46,000