2022 BMW X5 Power Train Problems

Like numerous other BMW owners, my transfer case is failing in my vehicle. It’s actively causing jerking/shuddering/locking up at low speeds and while making turns. This poses a significant danger to the driver and passengers in the vehicle, and other drivers as well while turning or trying to merge with traffic. I’ve brought the car into the dealer had the transfer case fluid changed according to the service bulletin that exists for this problem but it persists. I’ve brought the vehicle back into the dealer and told that now BMW suggests paying for another fluid change. This is obviously a known problem (thus the service bulletin), it’s persisted with models like mine for over 5 years, had cost numerous owners significant amounts of monies out of pocket, and poses a safety risk given the transfer case is a foundational component of these vehicles’ drive trains. Finally it’s a problem BMW openly admits they caused with improper fluid in the component. I believe the above meets all criteria for a formal recall that BMW should cover (or reimburse) the costs for given their negligence and the risks it poses. Can you confirm why this hasn’t risen to a formal recall? And confirm the steps you’re actively taking to elevate this to that status with BMW?

Sudden loss of power. Vehicle warning after starting stating power supply issue even after a brand new battery from the dealership. 3 similar incidents in a month. During the final incident the vehicle was again towed to the dealership where it’s been there for over a week and power supply issues persist. They are changing the whole high voltage box due to some unfixable errors.

Reoccurring drivetrain and high voltage issues with my 2022 BMW X545e

There is a jerking or shuddering during either or both of the following: Cornering or accelerating from low speeds Driving with low to medium loads [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The malfunction is my water pump is cracked & leaking coolant at 40k miles. The get up performance speed is lagging and delayed especially driving using Eco mode. The safety is at risk as the car is overheating, slow to accelerate and drive comfortably or safely. BMW of Riverside, CA has had to top off my coolant levels twice in a month or so. Bavarian Auto House located at 1009 E Balsam Ave, Anaheim, CA 92805 inspected my vehicle during a brake fluid flush and noticed my cracked leaking water pump. The low coolant levels pop up alert first appeared on my vehicle a month ago in the end of January 2025.

On Dec 9, 2024 I was driving my 2022 BMW X5 45E on (in EV mode) local roads at approximately 30-35mph when all of a sudden I lost power and the steering wheel became tight. My instrument panels all showed a multitude of errors including: "Chassis stabilization", "Power Supply", "Reduced Power", "Transmssion Malfuction", and others I do not recall. I was fortunately able to turn into a parking lot slowly, but the steering was tight to the point I had to use 2 hands to make turn. There was also no throttle response. As soon as the car came to a stop, I powered it off and turned it on. The car's screens were blinking and the car would not turn on. I contacted BMW Roadside and the car was towed to the dealership at East Bay BMW in Pleasanton. As of today I am still waiting for a reply on the condition of the vehicle. Yesterday I was told that they will change out the battery first and see if this solves the problem. My biggest concern is that had this happened to me on the highway that I or someone would have gotten seriously injured or may result in death from an accident. I lost power to the car and the steering became stiff.

The contact owns a 2022 BMW X5. The contact stated while entering into a parking lot, the vehicle accelerated on its own without any warning, causing the contact to strike some plants in the parking lot and causing damages under the vehicle. No one was injured. A police report was filed. The dealer was contacted but did not diagnose the vehicle. The manufacturer was contacted and sent a tech to diagnose the vehicle that stated no failure was found. The failure mileage was 10,000. The VIN was not available.

Mileage: 10,000

1. Drivetrain Malfunction 2. It may cause danger while driving with limited power output, even stopping the vehicle in the middle of the road. 3. Still waiting for the dealer to diagnose the problem, but have found out that the same model has the same issue.

The active and passive safety systems would disable themselves and I would get the following errors from the vehicle. 1. Rear Differential lock 2. Four-wheel drive system 3. Chassis stabilization 4. Drivetrain malfunction 5. Reduced driver assistance 6. Traction control reduced or off 7. Dynamic stability control 8. Dynamic traction control When these errors came up on the multimedia screen it would say that it was ok to continue to drive and to call and make a service appointment, no need for BMW roadside assistance. The following systems would be affected or turned off automatically. 1. Lane keep/lane departure assist 2. Blind spot monitoring 3. Cruise control 4. Forward collision warning/braking 5. Pedestrian warning/mitigation 6. Auto hold 7. Auto high beam assistant 8. Remote start 9. Side collision avoidance 10. Intelligent safety 11. Drive recorder 12. Back-up assistance 13. Auto park assistance 14. Active protection 15. Dynamic stability control 16. Dynamic traction control 17. Hill descent control 18. Speed limit information 19. Speed limit assistance 20. Park distance control 21. Cross traffic warning The warnings for these systems could come on right after starting the vehicle or anytime you are driving. What happens when the above systems are not working properly is the car can and will cut the throttle, that can be a temporary event or during the entire drive. It has happened to me where the throttle pedal and throttle response was working as normal then getting onto the freeway the systems went crazy and the gas pedal stopped working. So either the car comes to a stop or you stop the car. When stopped you have to put the vehicle in park, turn it off, turn it back on and put into drive and hope this resolves the issue so you can continue to drive. Sometimes it works and everything will be fine the rest of the drive, other times it doesn’t.

Drive Train Malfunction. At about 1500 miles on the vehicle, while driving on a highway, the vehicle automatically shifted to Neutral. The vehicle came to a full stop on a highway. This could have been a multiple car accident if the cars were going at highway speed. BMW SOS called me saying they received a Drive Train Malfunction alert. They had me pull over, asked me a few questions about the car and roads and let me go back on the road. I reported the issue to the manufacturer who inspected it but said the issue cannot be reproduced.

The car came to a complete stop due to the Drivetrain Malfunction. The surprising part was that I noticed the error after 45 mins of buying the car.