2022 BMW X5 Unknown Or Other Problems

Windshield cracks with slightest chip Happened twice

Electrical-soy covered wires causes rodents to chew wires causing electrical defaults and faulty control. Windshield - Minor chips causing massive cracks - happened twice in a 2 week time frame. After it was replaced. Cracked again

Car has premature failure from the AC system. My system started to fail between 40-50k miles. Both the AC compressor and condenser failed causing metal pieces to be in the system. If not fixed, those metal shavings will cause failure in other electrical systems including the HV battery.

Reoccurring drivetrain and high voltage issues with my 2022 BMW X545e

I was turning right into a parking space when the vehicle suddenly accelerated and did not stop when I removed my foot from the accelerator and tried to brake. The car continued to accelerate through a low cinder block wall and did not stop until it dropped 3-4 feet off the side of the parking lot into the sidewalk/street. Fortunately I was not hurt and there were no pedestrians or vehicles in the roadway, but my car was deemed a total loss. The collision warning didn’t come in, and airbags did not deploy. I reported the incident to BMW NAmerica, who sent an inspection team to the collision center. After 7 weeks I was told that the vehicle data recorder captured ‘an incident” but did not record any information to verify that I attempted to brake, or to otherwise provide details of the incident. I was told the inspection found no mechanical issues and the all weather floor mat (installed by the BMW dealer) was installed incorrectly and must have gotten stuck on the accelerator. Furthermore, I was told that although the mat was a BMW product, it was installed by the dealer so the manufacturer was not responsible. BMW offered me a small goodwill settlement provided I sign a non disclosure agreement, which I declined to do. I’m reporting this to ensure you have a record should you receive similar reports from others. I received no written communication from BMW detailing the safety investigation.

On 06-02-2024, at approximately 1430 hours, I was stopped in Traffic, because of a Red Traffic light and I was the last Vehicle in line. In less than a minute later, I was hit by another Vehicle. The other Vehicle left approximately 183' of Skid Marks on the Road and I determined that Vehicle was traveling at approximately 60 MPH, before it hit me, when I was stopped in Traffic. The damage was moderate. I have the Executive Package on my BMW X5, which has a 4 way Camera system, that records an incident, when an impact occurs. After the impact, the Camera system is to record 20 seconds before the impact, as well as 20 seconds after the impact. I was not sure how to retrieve the Video, so I had to call BMW Genius and the Employee had to walk me thru the steps to retrieve the Video. The Camera system was set up for Automatic Recording, as well as Manual Recording, but no Video of the accident was ever recorded. The only Video that was Recorded and saved, was from January 13, 2024, when I was showing my Wife, how to manually record something. According to the person who hit me, he said "I could not stop, because I had a bad Wheel" and that person also included that Statement in the Accident Report. Since the Accident, I sustained lower left Back pain, left Hip pain and upper left Leg pain in the Muscles. According to my X-Ray Images of my left Hip, the Head of the Femur Bone is flattened, due to the impact sustained following the collision. According to my Doctor, I have Bone Spurs, which causes me pain when standing, walking, sitting and Complete Hip Replacement is now required, to eliminate my pain. My Lawyer suggested that I file a complaint with the NHTSA, because the Camera system should have recorded the collision and that would have given us a clear view and understanding, on what the other Driver was doing before the collision. BMW is at fault for the Camera system, which did not record the accident, when it was set up for Automatic and Manual.

Over the last 2 years, I have taken m 2022 BMW x5 45e to authorized BMW dealer to have my Air Conditioning fixed but they have not been able to do so after 4 or 5 attempts. Coolant was replaced, hose was replaced, compressor was replaced. Without Air Conditioner the temperature inside the car, especially during summer, goes over 90 Deg F that it is causing heat stroke, dehydration and potential for black out. This can cause fatal accident. The alternate to which is not to drive the car, which is not a viable solution after having paid for the car so that we can drive it when necessary.

We have started noticing a burning smell whenever the vehicle is plugged into a charging station. At first we thought it was due to the charger, but the issue continued after we replaced the charging unit. Further, we also tried charging the unit at another station and experienced the same issue. This can be a potential fire risk and we'd like to get the matter resolved at the earliest. We have not seen this same issue with the 2023 version of the X5 hybrid.

I was driving on a road, the road was clear. No bridges, no underpasses & my sunroof exploded Startling me. I looked around thinking my car was shot at, noticing all my windows were fine. I heard glass falling and noticed it was my sunroof.

The active and passive safety systems would disable themselves and I would get the following errors from the vehicle. 1. Rear Differential lock 2. Four-wheel drive system 3. Chassis stabilization 4. Drivetrain malfunction 5. Reduced driver assistance 6. Traction control reduced or off 7. Dynamic stability control 8. Dynamic traction control When these errors came up on the multimedia screen it would say that it was ok to continue to drive and to call and make a service appointment, no need for BMW roadside assistance. The following systems would be affected or turned off automatically. 1. Lane keep/lane departure assist 2. Blind spot monitoring 3. Cruise control 4. Forward collision warning/braking 5. Pedestrian warning/mitigation 6. Auto hold 7. Auto high beam assistant 8. Remote start 9. Side collision avoidance 10. Intelligent safety 11. Drive recorder 12. Back-up assistance 13. Auto park assistance 14. Active protection 15. Dynamic stability control 16. Dynamic traction control 17. Hill descent control 18. Speed limit information 19. Speed limit assistance 20. Park distance control 21. Cross traffic warning The warnings for these systems could come on right after starting the vehicle or anytime you are driving. What happens when the above systems are not working properly is the car can and will cut the throttle, that can be a temporary event or during the entire drive. It has happened to me where the throttle pedal and throttle response was working as normal then getting onto the freeway the systems went crazy and the gas pedal stopped working. So either the car comes to a stop or you stop the car. When stopped you have to put the vehicle in park, turn it off, turn it back on and put into drive and hope this resolves the issue so you can continue to drive. Sometimes it works and everything will be fine the rest of the drive, other times it doesn’t.

The Sunroof spontaneously exploded, putting all occupants of the vehicle in danger of injury from the glass and/or collision as a result of the sunroof spontaneously exploding. As there have been several class action lawsuits filed against BMW over the past decade for similar issues, it is clear that the sunroof is defective in design, manufacturing, materials and/or workmanship. Furthermore, BMW has exhibited negligence as BMW has a knowledge of the defect in the sunroofs and never disclosed to owners or lessees that the defect exists or that drivers and occupants of the vehicles are at risk and that vehicles equipped with the sunroofs expose drivers and passengers to a risk of sudden explosion or shattering. This is a gross deviation from the duty of ordinary care owed to consumers.

The car's start and stop feature due to the way it is programed started up the car when it was already turned off in a garage causing carbon monoxide to fill up in the garage. There is no way to turn off the start/stop feature on the car to protect yourself or to make sure it's off. Very confusing and can create a risk of a person being hurt or killed due to the confusion of how the system works. This is a very dangerous situation.

I put my car in reverse this evening and the screen kept clicking and unclick the back up assistance button. The steering wheel was moving on its own. I was not controlling it. The brakes were hard and I could not press down more than 1/5-1/4 of the way. The car was not in my control. After an hour on the phone with support and reporting the issues they advised they would tow it. I was able to put the car in reverse push a button off that was selecting without being pressed manually near the driving shifter to get the car to drive normally. At home the same issues continued when I tried to put it in reverse. Even when shifting to drive these problems persisted until I pressed actual tangible buttons in the car to try and move it out of that mode. I am not able to back the car up properly. I have had this issue before on a smaller way where in different scenarios I am unable to press the brakes. The brakes are hard like trying to press on a brick wall. This has happened when driving, when turning the car on and when backing up but usually it would shift back to normal within a few seconds. Today was different with the screen blipping selecting and deselecting the item. I have videos of the incident on my phone.