2018 BUICK ENCORE Engine Problems

After filling up fuel vehicle starts and stalls out. This occurs while driving at stop signs. And also while driving loss of power. There is something wrong in the engine, timing belt, fuel, etc.

Brought my car to get an oil change and was told they could not do it as my oil filter housing unit is cracked and leaking oil they said to check for recalls as this is an issue with other vehicle same problem. Upon checking i was informed that Buick is not making this a recall item at this time. They put in enough oil for me to get home.

COMPONENT FAILURE: THE ENGINE TIMING CHAIN. YES, IT IS AVAILABLE FOR INSPECTION. SAFETY RISK: VEHICLE HESITATED AND LOST POWER IN TRAFFIC, CAUSING MY VEHICLE TO AUTOMATICALLY SLOW DOWN WHERE I WAS NO LONGER DRIVING AT THE SPEED LIMIT. MY SAFETY AND OTHER DRIVERS AROUND ME WAS COMPROMISED AS THIS COULD HAVE CAUSED A MAJOR ACCIDENT SHOULD I HAVE BEEN REAR ENDED. I HAD IT TOWED TO LAMBERT BUICK, CUYAHOGA FALLS, OHIO. THEY DIAGNOSED A TIMING CHAIN MALFUNCTION WHICH WAS CONFIRMED BY DEALERSHIP DIAGNOSTIC TESTING. I WAS ADVISED NOT TO DRIVE VEHICLE DUE TO ENGINE DAMAGE POTENTIAL. I HAD IT TOWED BACK TO MY HOME AND HAVE NOT DRIVEN IT SINCE. VEHICLE HAS NOT BEEN INSPECTED BY THE MANUFACTURER, POLICE, INSURANCE OR ANYONE ELSE. THERE WAS NO WARNING, MESSAGES OR ANY SYMPTOMS PRIOR TO THE ENGINE TIMING CHAIN ISSUE. A WARNING LIGHT ONLY CAME ON WHEN THE CAR HESITATED AND LOST POWER IN TRAFFIC.

The contact owns a 2018 Buick Encore. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the timing chain, resulting in damage to the crankshaft. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 98,507.

Mileage: 98,507

Engine stalls, intake hose, power issues, multiple oil leaks

The contact owns a 2018 Buick Encore. The contact stated while driving at undisclosed speeds, the vehicle was shaking abnormally with the check engine and stabili-trak warning lights illuminated. The contact pulled over to the side of the road and turned off and restarted the vehicle and the warning lights were cleared, and the vehicle drove normally. The contact stated that the failure was intermittent but was a recurring failure. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and replaced the ignition coils and spark plugs; however, the failure reoccurred. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 109,800.

Mileage: 109,800

During normal driving the car would lose power. RPM's would drop and with engine sputtering. No trouble codes show up.

I have been alerted by General Motors, via a letter that I received in March, 2024, that, due to a defect, my car's (a 2018 model year Buick Encore) engine may have a "condition where the turbocharger could fail" and that "the engine may run rough or have reduced power." In the letter, they have offered "additional protection for the condition" if the "condition occurs...within 10 years of the date your car was originally placed in service or 120,000 miles...whichever occurs first." On [XXX], my car was at 126,819 miles, and had all of the symptoms of the issue that were described in the March 2024 letter ("the Malfunction Indicator Light (Check Engine Light) will illuminate and a diagnostic trouble code will set. Additionally, the engine may run rough or have reduced power.") On May 3, 2024, I contacted GM at the phone number provided in the March 2024 letter ((800) 521-7300.) I was told by the GM representative that, because I was "over the mileage", that any GM dealer would have to charge me a $130.00 Diagnostic Fee to diagnose the issue, and, that even after diagnosing, there was no guarantee that GM would fix the issue, because I was "over the mileage". The GM representative also said I could ask the dealer to waive the Diagnostic Fee, at the dealer's discretion. If, after paying the Diagnostic Fee, and if the Diagnostic Fee revealed that my car did have the "turbocharger fail condition", that I could THEN contact GM to see IF they would cover the repair cost. In May, 2024, my car was at about 128,000 miles. I contacted two GM dealers: Les Stanford Buick in Ferndale, MI, and James Martin Chevy in Detroit, MI. Both refused to waive the Diagnostic Fee. So, in other words: - GM has created a defective, potentially DANGEROUS product, that GM acknowledges is defective. - GM created a warranty extension in which GM arbitrarily extended the warranty mileage and time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Buick Encore. The contact stated while the vehicle was parked, the contact's husband noticed there was oil leaking onto the ground underneath the vehicle. The contact’s husband, who is a certified mechanic, diagnosed the vehicle and determined that the failure was caused by a leaking oil cooler pipe. The contact was informed that the oil cooler pipe needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the leak was persistent. The manufacturer was made aware of the failure but provided no assistance. The contact referenced GMC recall 43210; however, the contact was informed that the VIN was not associated with the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 152,000.

Mileage: 152,000

Overdrive recall and check engine lights is on. We were just informed about the recall from our mechanic

Stalling and shuts off. Low power when accelerating. Car has been so slow to take off that when merging into on coming traffic I have to move to shoulder & then try again to prevent an accident. Coughs, putt & squeaking sounds.Car shakes while in park or not in motion. Check engine light on.

There are many Buick Encores, including 2018 that have a problem with acceleator position sensors. My car’s vin # shows that it does not have this notice, and thus no problem. However, in July this 2018 Buick Encore went into ‘limp mode, check engine light came on. Code for problem was 2138 (accelerator Pedal Position Sensor) The initial dealer solution was to apply dielectric grease. However, this ‘cure’ lasted . 15 miles, when it went into limp mode,,, again check engine icon came on THIS is very dangerous, as it cannot accelerate and from a stop, it does not move until a minute later… that is so frightening, I again took it to the deaer, same code of P2138, and now they recommend the accelerator pedal positon sensor replacement…. THIS is identical to the problems with the other Encores, This is a severe safety issue, and the rest of the 2018 Buick Encores should be included for notification AND repair .

The contact owns a 2018 Buick Encore. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power, power steering, and brake functionality. The vehicle began to shake, and the brakes and steering wheel became inoperable. The check engine warning light was illuminated. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The vehicle was not diagnosed or repaired. The vehicle was taken back to the local dealer, where the mechanic test drove the vehicle but was unable to duplicate the failure. While driving, the fan failed to turn off. The vehicle was taken to the local dealer Orange Buick GMC (3883 W Colonial Dr, Orlando, FL 32808), where it was diagnosed that the coil and relay needed to be replaced. The vehicle was repaired, but the failure recurred. The contact stated that while driving the vehicle failed to accelerate above 65 MPH. The brake pedal was depressed but the vehicle failed to respond. The vehicle was taken back to another local dealer, Gettel Chevrolet Buick GMC (1901 Tamiami Trl, Punta Gorda, FL 33950), where it was diagnosed that the fan, relay, and spark plugs needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed the contact about repairing the vehicle and the process for reimbursement. The failure mileage was approximately 20,000. The VIN was not available.

Mileage: 20,000

Turbo charger has A leak, dealer stated they knew it had a leak but they couldn't find it. All they did was clear the code. My car has A check engine light, and a trouble code of PO299, does not maintain proper speed, has issues with acceleration.

The contact owns a 2018 Buick Encore. The contact stated that the check engine warning light was illuminated. The contact stated that soon after the warning light appeared, the engine struggled to remain running. The contact depressed the accelerator pedal while in park to prevent the engine from shutting off. In addition, the contact stated that the vehicle hesitated upon depression of the accelerator pedal while driving at various speeds. The dealer and the manufacturer were notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown.

We took our 2018 buick encore in to get the turbo fixed for the recall. The mechanic told us he can't test the turbo on it because the oil line going into the turbo isn't working and he has multiple other vehicles in for the SAME issue and they have been sitting in his back lot since December because he can't get the part in because everyone is out of stock. We will have to pay out of pocket for the oil line issue which will be $2300. So the turbo going bad is not the only issue this recall should cover. Because the oil line supplying the turbo should be included with the recall!

I have been employed in the Automotive Parts and Repair business for over forty years. I notice my vehicle exhaust sounded different than usual. I suspected the flex pipe part of the front exhaust pipe was leaking. This was confirmed by my local auto repair shop during a service visit. During my time as GM Parts Manager I can speak from experience to the problems these flex pipes cause because I kept two or three of them on the shelf to repair vehicles. My concern is exhaust fumes entering the passenger compartment of my vehicle because the flex pipe leaking which is just off the exhaust manifold. I contacted the local dealership where my vehicle was purchased because there still is a "Emission Warranty in effect. My 2018 Buick Encore has less than 50000 miles on it . I also contacted the Northeast Region District Service Manger with my concerns.

When driving, the vehicle will stutter and make the car feel as though it’s bubbling, once you come to a stop, the vehicle will shut off. This is a huge safety concern considering I have children and if the vehicle just turns off and I shouldn’t be braked for a while I can get hit. I have almost been hit 4x since this has started because the car shuts off when attempting to brake or braking completely. After speaking to multiple mechanics over this car it seems to be a common issue for it.

Feel like the car is loosing drive/power and not accelerating. I was driving and the engine light started flashing. No power to go up the hill, it could have gone backwards. Car does not accelerate made a whirring noise when it was turned off. Dangerous situation. Service Bulletin #N212338400

Turbo charger malfunction. Confirmed by dealership and had to be replaced. Stabilitrak malfunction. Car is stalling out at a red light or stop sign, and/or jerking hard. Stalled out in middle of an intersection with my children in the car. Ongoing problem.

My vehicle would not start and I had no control over the computerized system.

Unknown. On Highway total loss of power, unable to steer.

WITH ESTIMATING MY MONTHS OVER A SPAN OF 4 MONTHS I HAD MY TURBO CHARGER REPLACEDBECAUSE IT HAD GONE BAD. I WAS OUT OF TOWN THE LIGHT CAME ON. AND WHEN I RETURN I TOOK IT TO THE SHOP THEY DIAGNOSE IT AND SAID IT WAS A TURBO CHARGER. I HAD AN EXTENDED WARRANTY ON THE CAR SO THEY REPLACE THE TURBO CHARGER WITH NO PROBLEMS GIVE ME A RENTAL WITH NO PROBLEMS EVERYTHING WAS COVERED.. AND A MONTH AND A HALF LATER MY ENGINE LIGHT CAME ON AND I REPLACED THE PURGE VALVE ANOTHER MONTH OR SO LATER THE ENGINE LIGHT CAME BACK ON AND IT WAS A TURBO CHARGER GONE BAD AGAIN. IT TOOK ABOUT WEEK TO FIND OUT WHY THE TURBO CHARGE WENT BAD. THEY FINALLY SAID IT HAD SOMETHING TO DO WITH THE RETURN AND SUPPLY LINE LIKE THERE WAS NO LUBRICATION COMING THROUGH A HOSE TTHAT RUNS TO THE TURBO CHARGE. THIS IS THE ONLY PLACE THAT I'VE HAD MY OIL CHANGE SINCE I BOUGHT THE CAR FROM KING CADILLAC BUICK GMC. I WENT ONE OTHER PLACE ONE OTHER TIME AND THAT WAS IT.I WONDER WHY THEY DID NOT CHECK THE SUPPLY LINE WHEN THEY CHANGE THE TURBOCHARGER THE FIRST TIME IS THAT NOT A PART OF CHANGING THE TURBO CHARGE. I WAS TOLD THAT THEY HAVE SEEN THIS ISSUE BEFORE BUT NOT A LOT.WHEN THIS FIRST HAPPENED I WAS ON INTERSTATE 40 ON MY WAY TO WAS TO SALEM NORTH CAROLINA. AND I NOTICED A DECLINE WHEN I WENT TO CELEBRATE ON THE GAS. WHEN IT HAPPENED THE SECOND TIME I WAS RIDING TO CHURCH HERE IN MY HOMETOWN AND THE ENGINE LIGHT CAME ON AND JUST RIDING AROUND HELL IS AS IF THE CAR DID NOT WANT TO GO LIKE I WOULD GIVE IT TO GAS AND IT WOULD HESITATE OR NOT WANT TO DRIVE.

Mileage: 80,000

WHEN IT RAINS MOST IF THE TIME THE VEHICLE ONSTAR SETS OFF ALERTS FOR MY ANTILOCK BRAKES AND STABILITY TO BE CHECKED. DEALER SAID IT IS NORMAL AND NOT CONCERNING BUT CHECKED AT THE 1 YEAR INSPECTION FOR ME. NPF. A MONTH LATER A RAINY DAY, ALERTS, AND THE VEHICLE WOULDN'T START. ALL THE LIGHTS CAME ON, 'PRESS BRAKE TO START' APPEARED BUT PRESSING BREAK DID NOT START IT. AFTER AN HOUR OF TRYING VARIOUS 'TRICKS' IT STARTED WITH THE REMOTE STARTER. A WEEK LATER SAME THING. RAIN, ALERTS, AND NO START. THIS TIME 2 HOURS OF TRYING VARIOUS TRICKS- (EMERGENCY BREAK ON OFF/ PARK PUSHED ALL THE WAY UP, WHEELS FORWARD, REMOTE START ATTEMPTS, ONSTAR DIAGNOSTICS ETC) I HAD TO HAVE IT TOWED. THE MECHANIC FROM AAA TRIED AND NOTHING, WE TOWED AN HOUR BACK TO DEALERSHIP AND HE TRIED ONCE MORE, NOTHING. NEXT MORNING THE DEALERSHIP REPORTED NPF. I AM PICKING IT UP TOMORROW BUT EXPECT TO REPORT THIS HAPPENING AGAIN SOON.

THERE IS A MALFUNCTION WITH THE TURBO HOSE ON A MAJORITY OF 2018 BUICK ENCORE'S THAT REQUIRE A NEW HOSE. THERE IS A NATIONWIDE BACK ORDER ON THESE PARTS DUE TO ALL OF THE REPAIRS. WHEN THIS ITEM BROKE I WAS DRIVING ABOUT 70 MPH ON THE INTERSTATE, THERE WAS A LOUD POP FROM THE ENGINE COMPARTMENT AND THE VEHICLE WOULD NOT ACCELERATE APPROPRIATELY.

Mileage: 4,000