2009 BUICK LUCERNE Electrical System Problems

The contact owns a 2009 Buick Lucerne. The contact stated that while attempting to start the vehicle, the engine failed to turn over. No warning light was illuminated. The contact stated that upon inspection he became aware that one of the relays from the electric fuel pump under the rear passenger’s seat needed to be replaced. The contact stated that the fuel pump relay prong base had melted due to overheating. In addition, the contact stated that the fuse was a 10.01 AMP instead of a 5 AMP which could have caused the failure. The local dealer was not contacted. The vehicle was repaired; however, the failure reoccurred 2 days later. The manufacturer was made not aware of the failure. The failure mileage was approximately 66,000.

Mileage: 66,000

The car died suddenly and would not start, with no warnings or codes. Towed it to a Midas repair shop and it was diagnosed as a corroded Low Profile Fuel Pump relay. This was replaced, and the car ran fine for 3 days before going dead in the middle of driving and left me stranded in an intersection. Had to get it towed back to Midas where it was more accurately diagnosed that the issue with the relay was being caused by a faulty Rear Electrical Center. Both of these parts have been recalled, and I have only owned this car for a little over a year. It has only around 40,000 miles on it. Despite this recall, upon taking the car to the local Buick dealership, they stated they could not cover the recall due to it being expired before I even owned the car. I do not understand how it is right or fair for this to have to be paid out of pocket, for $183.53 and $818.81 respectively, when it is not my fault, it is a faulty GM parts issue, and GM stated they will not stand behind their product and cover the recall despite the evident risk to my safety if I was to continue driving the car without repair. I understand it is expired, but I fail to see how this is ethical when the part is still faulty to the point of being dangerous.

Fuel Pump relay fuse is getting burnt up and not allowing car to start. This is a known problem and Nhtsa has already made a recall but mine isn’t recalled. You would think since mine is a 2008-2011 Buick Lucerne it would be able to get fixed. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2009 Buick Lucerne. The contact stated that while starting the vehicle, the vehicle sputtered and failed to start. There was no warning light illuminated. The vehicle was taken to an independent mechanic who recommended that the fuel pump relay be replaced. The mechanic became aware that the fuse was melted. The vehicle was repaired but the failure persisted. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 140,000.

Mileage: 140,000

The contact owns a 2009 Buick Lucerne. The contact stated that while driving approximately 70 MPH, the fuel pump relay overheated and burned the fuse box. The accelerator pedal and steering wheel became inoperable. The contact was able to control the vehicle and park the vehicle. There were no warning lights illuminated. The contact replaced the relay, but the vehicle failed to start. The contact called the local dealer and was advised to schedule an appointment for diagnostic testing. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 170,000.

Mileage: 170,000

The fuse box or fuse holder under the back seat had the fuel pump relay fail due to pressure on the fuse box lid from the seat above it. This is a known issue by Buick as they keep the fuse box in stock (for about $300) I have owned two similar Lucernes with this issue. The fuel pump relay caused enough heat to melt into the fuse box, causing a disconnection. This caused the fuel pump to stop pumping, causing the car to stop running. The problem can be confirmed by calling any Buick dealer. I'm sure they have had several examples of this issue besides my pair. There are many examples mentioned on the internet, as well as videos as to how to fix it. There are no warning lamps prior to the failure. The engine dies and refuses to restart.

Fuel pump relay keeps burning out.

Fuel pump relay under vehicles back seat fried out due to the back seat hitting the fuse box cover and grounding out the fuel pump relay. My child was in the back seat and said there was smoke coming from the back seat and the fuse box nearly caught on fire. After reading online I am appalled that this has not been recalled yet. There was 0 warning, no lights on dash, I did not file a police report or do anything with my insurance as there was no accident. Just a car bomb manufactured by GM

failed fuel pump relay and melted fuse block. Car would not start in garage. Knew this vehicle is known to have this issue and when investigating the failure to start the first thing I checked was the fuel pump relay and fuse block and sure enough that was the issue. Common issue that Buick never addressed adequately.

Vehicle was no start. Dealer found fuel pump relay bad on 10/05/201. Next time using vehicle same problem. On 10/20/2021 dealer service department diagnosed bad fuse box. The fuse box is located under the rear passenger seat. It was extremely hot and melting. Fortunately no fire, this time.

The contact owns a 2009 Buick Lucerne. The contact stated that on multiple occasions the vehicle would not immediately start-up. The vehicle was examined by an independent mechanic who diagnosed that the fuel pump relay was faulty and needed to be replaced. After replacing the fuel pump relay the failure was temporarily fixed before it recurring. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 79,000.

Mileage: 79,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT WHENEVER THEY WOULD START THE VEHICLE, THE VEHICLE WOULD START THEN SUDDENLY SHUT-OFF. THE CONTACT STATED THAT THEY TOOK THE TO BE INSPECTED AND NOTICED THAT THE RELAY TO THE FUEL PUMP HAD OVERHEATED AND HAD STARTED TO MELT. THE CONTACT REPLACED THE RELAY HOWEVER, THE FAILURE PERSISTED. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT WHILE HIS GIRLFRIEND WAS DRIVING AT AN UNKNOWN RATE OF SPEED UPON EXITING A HIGHWAY, THE VEHICLE HAD SHUT OFF WITHOUT WARNING. SHE WAS ABLE TO PULL THE VEHICLE OVER AND RESTART THE VEHICLE. AS THE CONTACT'S GIRLFRIEND PROCEEDED TO DRIVE, SHE INITIALLY SMELLED SMOKE COMING FROM THE VEHICLE; SHE THEN SAW A FLAME IGNITE FROM THE BOTTOM REAR PASSENGER SEAT. SHE STATED THAT SHE WAS INITIALLY UNABLE TO UNLOCK THE DOORS OR ROLL DOWN THE DRIVER SIDE WINDOW; AFTER A SECOND ATTEMPT, SHE WAS ABLE TO ROLL DOWN THE DRIVER SIDE WINDOW AND EXITED THE VEHICLE. A FELLOW MOTORIST SAW THE SITUATION AND CALLED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. A FIRE REPORT WAS FILED AND NO INJURIES WERE REPORTED AS A RESULT OF THE FIRE. THE VEHICLE WAS DESTROYED AT THE SCENE AND WAS TOWED TO AN INDEPENDENT JUNK YARD. THE CONTACT CALLED PENSKE BUICK GMC(100 S MUSEUM RD, SHILLINGTON, PA 19607) WHERE HE WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.

Mileage: 88,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, A BURNING PLASTIC TYPE ODOR AND SMOKE WAS PRESENT COMING FROM THE REAR SEAT AREA. UPON INSPECTION IT WAS DISCOVERED THAT THE FUEL PUMP RELAY HAD BURNED AND WAS VERY HOT TO THE TOUCH. THE CONTACT INDICATED THAT THE ELECTRICAL FUSE BOX WAS LOCATED UNDER THE DRIVER SIDE REAR SEAT AND HAD MADE CONTACT WITH THE FUEL PUMP RELAY CAUSING THE FAILURE. THE FAILURE WAS NOT YET REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

Mileage: 103,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 75 MPH, THE VEHICLE LOSS POWER AS A SMOKE ODOR WAS DETECTED IN THE CABIN OF THE VEHICLE. THE CONTACT EXITED THE HIGHWAY AND WENT TO A LOCAL AUTO STORE. WHILE PARKED, HE INSPECTED THE VEHICLE, OPENING THE REAR PASSENGER DOOR AND FOUND THAT THE PLASTIC BURNING ODOR WAS COMING FROM THE UNDERNEATH THE SEAT. THE CONTACT LIFTED THE REAR SEAT AND DISCOVERED THAT THE FUSE BOX WAS EXTREMELY HOT TO TOUCH. UPON OPENING THE BOX SMOKE AND A BURNT FUSE RELAY WAS SEEN. THE CONTACT STATED THAT HE PURCHASED AND REPLACED THE BURNT FUSE. THE CONTACT DROVE THE VEHICLE TO HIS RESIDENCE, WHERE IT WAS LATER TOWED FROM TO THE DEALER THOMAS CHEVROLET-BUICK INC. (2128 S BYRON BUTLER PKWY, PERRY, FL 32348) WHO INFORMED THE CONTACT THAT NO RECALL WERE UNDER THE VIN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE FUEL RELAY KIT NEEDED TO BE REPLACED. THAT CONTACT MENTIONED MANUFACTURER COMMUNICATION NUMBER: 15-NA051 (ELECTRICAL SYSTEM, SEATS, FUELS SYSTEM, GASOLINE) (NHTSA ID NUMBER: 10108617) AS A POSSIBLE SOLUTION TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, A CASE WAS OPENED AND THE CONTACT WAS INSTRUCTED TO TAKE THE VEHICLE TO THE DEALER FOR REPAIRS. THE FAILURE MILEAGE WAS APPROXIMATELY 149,000.

Mileage: 149,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. AFTER THE VEHICLE WAS DRIVEN FOR A SHORT PERIOD OF TIME AND PARKED, IT FAILED TO RESTART. THE VEHICLE WAS TOWED TO EMPIRE CHEVROLET BUICK (1931 US-421, WILKESBORO, NC 28697, (336) 838-2191) WHERE IT WAS DIAGNOSED THAT THE RELAY AND FUSE PANEL UNDERNEATH THE REAR SEAT HAD MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. THE VIN WAS INVALID.

Mileage: 64,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHEN THE CONTACT STOPPED AND TURNED OFF THE VEHICLE AFTER A LONG DRIVE, THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUSE BOX HAD BURNED OUT AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 80,406. *BF CONSUMER STATED FAILER TO START AFTER DRIVING 400 MILES.*JB

Mileage: 80,406

AFTER BEING DRIVEN NORMALLY ALL DAY, THE CAR ALL OF A SUDDEN WOULDN'T CRANK PROPERLY AFTER BEING PARKED FOR A FEW HOURS. THE CAR NEEDED TO BE TOWED TO A CAR SHOP. ACCORDING TO A LOCAL MECHANIC, THE BACK SEAT PRESSED ON THE WIRING THAT, IN TURN, BURNED UP THE ELECTRIC PANEL AND THE FUEL PUMP. DUE TO THIS, THE ELECTRIC PANEL AND THE FUEL PUMP NEED TO BE REPLACED.

GOING DOWN HIGHWAY 70 MPH STRAIGHTAWAY CAR STALLED ABLE TO GET TO SIDE OF HIGHWAY PULLED OFF SEAT FOUND FUSE BOX TEMP HOT WHEN COOLED DOWN NOTICED FUEL RELAY SWITCH BURNT OUT. COMMON PROBLEM WITH CAR DUE TO ENGINEERING OF SEAT BRACKETS HITTING FUSE BOX AND DAMAGING IT. THIS IS THE SECOND TIME IN 5 YEARS FUSE BOX HAS BEEN REPLACED BY CERTIFIED DEALERSHIP. OBVIOUSLY PROBLEM IS WITH THE ENGINEERING OF SEAT BRACKET BUT APPARENTLY DEALER DOES NOT TAKE ME SERIOUSLY AND DID NOT TRIM SEAT CLIPS PER MY SPECIFIC REQUEST BC THERE IS ONLY A BULLETIN FROM GM 15-NA-051 NOT A RECALL. SEVERAL COMPLAINTS HAVE BEEN MADE AND MUST BE COMMON ENOUGH FOR A BULLETIN LUCKILY NO ONE WAS TAILGATING OR THIS COULD HAVE BEEN A VERY SERIOUS ACCIDENT.

Mileage: 208,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT AFTER TURNING THE VEHICLE OFF, LATER THE VEHICLE WOULD NOT RESTART. UPON INSPECTION IT WAS DISCOVERED THAT THE BATTERY RELAY WAS FAULTY AND THE FUSE BOX HAD MELTED. THE CONTACT INDICATED THAT THE BATTERY AND FUSE BOX WERE LOCATED UNDER THE REAR SEAT AND WITH REAR PASSENGERS SEATED THE SEAT CUSHION MADE CONTACT WITH THE BATTERY AND FUSE BOX. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 98,000.

Mileage: 98,000

REC- BATTERY DRAIN NO START CONDITION OR A STALL MAY MELT OR OVERHEAT. I REVEIVED LETTER ON 1/2019 HOWEVER EXPERIENCED THIS ISSUE IN JULY 2018 HAD TO HAVE CAR TOWED MECHANIC REP;ACED BETTERY. TK TO DEALERSHIP THEY EXPERIENCED THE SAME AND DRAINING BATTERY. SENT INVOICE TO BUICK FOR REIMBURSEMENT OF BATTERY THAT WAS STILL IN WARRANTY AND TOWING REFUSED TO REIMBURSE THIS SHOULD BE A RECALL SEVERAL COMPLAINTS AND A SAFETY ISSUE. VEHICLE WAS STATIONARY IN PARKING LOT COULD HAVE BEEN WORSE

Mileage: 82,500

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE CONTACT PULLED OUT THE REAR SEAT TO REACH THE FUSE BOX AND NOTICED THAT THE FUSE BOX WAS PARTIALLY BURNT AND FUEL PUMP RELAY ALSO BURNT ON AUGUST 17, 2018. NEW FUEL PUMP RELAY PURCHASED AND TEMPORARILY REPAIRED BY CONTACT. IN JANUARY 2019, THE VEHICLE WAS TAKEN TO PHILLIPS BUICK GMC (2160 US WHY 441, FRAUDULENT PARK, FL 34731) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP AND FUSE BLOCK (BOX) NEEDED REPLACEMENT AND THE REAR SEAT NEEDED TO BE MODIFIED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. *TTT CONTACT SAYS THERE HAS BEEN NUMEROUS REPORTED FUEL PUMP RELAY, FUSE BLOCK AND FUEL PUMP REPORTED FAILURES ON BUICK LAGRANGE. THE MAJOR SAFETY PROBLEM ARE THE FAILURES THAT OCCURRED WHILE THE CARS WERE BEING DRIVEN AND THE ENGINE STOPPED RUNNING. ENCLOSED IS A COPY OF THE BILL FROM PHILLIPS BUICK/GMC. *JB

Mileage: 75,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THE VEHICLE DID NOT START. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT ALSO MENTIONED THAT THE SAME FAILURE OCCURRED SIX OTHER TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DETERMINED THAT THE RELAY PANEL SHORTED OUT. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.

Mileage: 77,000

A PIECE TO THE FUSE BOX UNDER BACK SEAT HAS MELTED INSIDE OF THE FUSE BOX, WHICH HAS CAUSED THE CAR NOT TO START. THE VEHICLE IS NOW IN FRONT OF MY HOME, SITTING. BUICK HAS NO RECALL BUT YET THIS KEEPS HAPPENING.

Mileage: 106,789

WHEN DRIVING THE CAR DIED AND WOULD NOT START. THE FUEL PUMP RELAY HAD BURNED UP AND SO WE CHANGED THE RELAY, BUT THAT DID NOT FIX THE PROBLEM SO WE WENT AHEAD AND CHANGED THE FUEL PUMP; THIS DID NOT FIX THE PROBLEM. THE FUEL PUMP RELAY SWITCH IS STILL GETTING RED HOT AND NOT SURE AT THIS TIME WHAT IS CAUSING THE ISSUE. HAVING IT LOOKED INTO FURTHER. I AM NOT SURE IF THERE IS A RECALL ON THIS ISSUE OR NOT BUT HAVE SEEN QUITE A FEW PEOPLE HAVING THIS SAME ISSUE,

Mileage: 89,000

FUEL PUMP RELAY HEATED UP AND BURNED UP FUSE BLOCK WITCH IS LOCATED UNDER REAR SEAT.FIRE HAZARD. SITS ABOVE GAS TANK. CAR WILL NOT START OR WILL LOSE POWER WHILE DRIVING.LOST STEERING AND BRAKES. THERE HAS BEEN NUMEROUS COMPLAINTS ABOUT THIS. ALSO IGNITION SWITCH NOT WORKING.

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL FUSE BOX FAILED AND NEEDED TO BE REPAIRED. THE DEALER (MUSSON-PATOUT AUTOMOTIVE GROUP, 214 U.S. 90 FRONTAGE RD, NEW IBERIA, LA 70560, (337)-223-6923) WAS CONTACTED AND REPAIRED THE VEHICLE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000.

Mileage: 75,000

MY 2009 BUICK LUCERNE WOULD NOT START IN MY DRIVEWAY ON THE MORNING OF JUNE 8, 2019. THE MILEAGE OF THE VEHICLE IS 109466. THE ENGINE WOULD CRACK BUT NOT START. I FOUND THAT THE RELAY FOR THE FUEL PUMP WAS BURNT WHICH IS LOCATED UNDER THE REAR SEAT IN A FUSE BOX. THIS WAS REPLACED AND THE VEHICLE STARTED AGAIN AND RAN. THAT EVENING AFTER DRIVING APPROXIMATELY 160 MIIES, THE VEHICLE SHUT OFF WHILE TRAVELING AT A SPEED OF 45 MILES PER HOUR. I LOST ALL POWER FUNCTIONS OF THE VEHICLE BUT WAS ABLE TO AVOID HAVING AN ACCIDENT WHILE PULLING OFF THE ROAD. AT THE TIME MY WIFE WAS IN THE FRONT PASSENGER SEAT AND MY MOTHER WAS IN THE REAR SEAT BEHIND MY WIFE. THE FUSE BOX IS LOCATED UNDER THE REAR SEAT BEHIND THE DRIVER. AS LONG AS WE OWNED THIS VEHICLE NOBODY HAS SAT BEHIND THE DRIVER AS I'M 6'3" TALL. THE VEHICLE WAS TOWED TO COUNTRYSIDE AUTO GROUP LOCATED AT N8167 KELLOM RD. BEAVER DAM, WI 53916. THE SERVICE DEPARTMENT THERE REPLACED THE FUSE BOX, REPLACED THE RELAY WITH A LOW PROFILE RELAY, AND TRIMMED THE METAL SEAT BRACKETS SO IT WOULD NOT PUSH DOWN ON THE FUSE BOX. THE TECHNICIAN STATED THAT FROM THE WEIGHT OF PEOPLE SITTING ON THE SEAT PUT PRESSURE ON THE BOX WHICH CAUSED THE RELAY TO SHORT OUT AND FAIL. THE REPAIR COST $647.79 AFTER RESEARCHING THIS PROBLEM I FOUND OUT THIS IS AN ISSUE WITH THE 2009 BUICK LUCERNE AS THERE IS A SERVICE BULLETIN #15-NA-051. IT CLEARLY SHOWS HOW TO CORRECT THIS PROBLEM. MY CONCERN IS THE SAFETY ISSUE RELATED TO THIS PROBLEM IS YOU LOSE COMPLETE POWER FUNCTION OF THE VEHICLE WHICH COULD HAPPEN AT ANYTIME. THERE SHOULD BE A SAFETY RECALL FOR THIS PROBLEM NO MATTER WHAT THE MILEAGE OF THE VEHICLE IS AT TIME OF FAILURE. I WILL INCLUDE A PIC OF THE BURNT RELAY. I WAS NOT RETURNED THE MELTED FUSE BOX.

Mileage: 109,466

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT AN UNKNOWN SOURCE SHORTED OUT THE RELAY SWITCH. AN UNKNOWN LOCAL DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 78,000.

Mileage: 78,000

VEHICLE STALLS OUT WITHOUT WARNING. UNABLE TO START. BURNING SMELL UNDER REAR SEAT (DRIVER SIDE). SERVICE BULLETIN ISSUED BY GM #15-NA-051 (JULY 26, 2016). DESIGN DEFECT CAUSING NO START/STALLING CONDITION BECAUSE REAR SEAT BOTTOM BRACKET PRESSING ON FUEL PUMP RELAY CAUSING FUEL PUMP RELAY TO SHORT OUT (BURN OUT). THIS IS A SAFETY ISSUE WHICH COULD CAUSE SERIOUS INJURY OR DEATH BY CAUSING AN ACCIDENT WHEN CAR STALLS OUT WITHOUT WARNING. GM REFUSES TO ISSUE RECALL. GM SAYS TO TAKE VEHICLE TO LOCAL DEALER AND HAVE REPAIR/MODIFICATION DONE AT OWNERS EXPENSE.

Mileage: 53,100

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE THE VEHICLE WAS PARKED, THE CONTACT ATTEMPTED TO START THE VEHICLE, BUT IT WOULD SHUT OFF AFTER A FEW SECONDS. THE CONTACT MADE APPROXIMATELY THREE ATTEMPTS TO START THE VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO THE DEALER (TODD WENZEL BUICK GMC IN WESTLAND, MICHIGAN, 734-721-1144) WHERE IT WAS DIAGNOSED THAT THE FUSE BOX HAD A SHORT, WHICH WAS SENDING THE WRONG SIGNAL TO THE FUEL RELAY DELIVERY PUMP. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT ALSO STATED THAT THE SAME FAILURE OCCURRED AROUND JUNE OF 2016. THE APPROXIMATE FAILURE MILEAGE WAS 129,000.

Mileage: 129,000

CAR WAS FINE 1 DAY NEXT DAY WOULD NOT START. HAD IT TOWED MECHANIC REPLACED FUEL PUMP AND RELAY. NEXT DAY I'M DRIVING GOING DOWN HILL AND IT LOOSES ALL POWER AND WON'T START. HAD IT TOWED AGAIN. MECHANIC REPLACED RELAY. PICKED CAR UP AND DROVE IT FOR ABOUT 2 HOURS AND RELAY BURNED OUT IN MIDDLE OF INTERSECTION. WALKED TO PARTS STORE AND BOUGHT RELAY. REPLACED AND DROVE HOME. NEXT DAY GOING TO WORK AND RELAY BURNS OUT AGAIN. IT IS SUPER HOT AND MELTS PLASTIC AROUND THE HOLE IN FUSE BOX WHERE THE PRONG GOES IN. HAVE REPLACED IT SEVERAL MORE TIMES AND I AM NOW TAKING IT BACK TO MECHANIC BEFORE IT CATCHES ON FIRE OR GETS ME KILLED DRIVING DOWN THE ROAD. THIS IS A MAJOR PROBLEM WITH THE BUICK LUCERNE. I ONCE TRUSTED THIS VEHICLE. PLEASE PLEASE PLEASE RECALL AND FIX THIS PROBLEM. STRANDED EVERY TIME I LEAVE THE HOUSE.

Mileage: 105,000

FUSE BLOCK AND RELAY BURNED UP UNDER REAR SEAT. CAR WOULDN'T START SEVERAL TIMES. AFTER CAR BECAME WARM, IT WOULDN'T START ANYMORE. IT ACTUALLY BURNED THE FOAM AROUND THE SEATS.

Mileage: 90,113

I HAD JUST DRIVEN THE CAR ON A 2 HOUR TRIP WITH NO ISSUE. I DROVE THAT TRIP IN THE MORNING AND THAT AFTERNOON I WENT TO START THE CAR AND THE STARTER WAS GOING BUT THE ENGINE WOULDN'T START. I LIFTED THE BACK SEAT TO FIND AN AWFUL SMELL COMING FROM THE FUSE BOX. I PULLED THE FUEL PUMP FUSE TO FIND IT SINGED. THE VEHICLE WILL BE NEEDING A NEW FUSE BOX AND I'M STILL WAITING TO FIND THE PART.

Mileage: 82,000

I OWN A 2009 BUICK LUCERNE THAT I ATTEMPTED TO START THE VEHICLE ON RANDOM OCCASSIONS. ON ANOTHER OCCASION THE VEHICLE STALLED ON HIGHWAY 49 IN THE MIDDLE OF TRAFFIC. IT FAILS TO START, SOME RELAYS ARE HOT EVEN WHEN THE CAR IS OFF, FUEL RELAY HAS BEEN REPLACE 4 TIMES AND IT GETS EXTRA HOT AND WILL ALMOST BURN YOUR HAND, THE FUSE BOX IS MELTED PARTLY AND HAS A BURNING SMELL. THE FUEL PUMP VOLTAGE WAS CHECKED AND IS GOOD. ON THE LAST TRY TO CRACK NOW THE DRIVER DOOR WINDO AND DOOR LOCK IS NOT WORKING. THERE IS NO CORRISON UNDER THE FUSE BOX. BUICK DOES NOT HAVE A RECALL OUT ON THE FUSE BOX OR RELAY. THE VEHICLE HAD TO BE TOWED 25 MILES. THIS IS A SAFETY HAZARD. I HAVE A DISABLED DAUGHTER WHO IS TRANSPORTED IN MY CAR AND I WORRY ABOUT THE SAFETY OF THIS VEHICLE. BUICK IS AWARE OF THIS ISSUE WITH THIS PARTICULAR CAR. THE BUCIK FORUM AND NHTSA WEBSITES BOTH HAVE COMPLAINTS ABOUT THIS ISSUE. THE MANUFACTURE HAS BEEN NOTIFIED. IT WILL TAKE ACCIDENTS, INJURY, OR DEATHS FOR THIS ISSUE TO BE RESOVLED IT SEEMS. AS BUICK AND DEALERS CONTINUE TO SELL THESE CARS MANY PEOPLES LIVES ARE I JEOPARDY. I HAVE REVIEWED PAGES ON COMPLAINTS AND AGAIN BUICK IS AWARE OF THESE ISSUES.

Mileage: 139,952

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START AND VARIOUS INSTRUMENT CLUSTER INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO RIZZA CADILLAC BUICK GMC (8425 159TH ST, TINLEY PARK, IL 60487) WHERE IT WAS DIAGNOSED THAT THE FUSE BOX UNDER THE BACK SEAT HAD SUFFERED A SHORT AND MELTED. THERE WERE NO VISIBLE SIGNS OF A FIRE. THE FIRE DEPARTMENT WAS NOT CONTACTED. THERE WERE NO INJURIES. THE FUSE BOX WAS REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.

Mileage: 79,000

CRANK, BUT NO START. FUEL PUMP RELAY PIN MELTED INTO FUSE BLOCK (UNDER REAR SEAT). REPLACED FUEL PUMP RELAY, WITH SAME RESULT: NO START MELTED THE 4TH PIN IN RELAY AND PLASTIC ON FUEL BLOCK CREATING AN OBVIOUS FIRE HAZARD, THAT CLOSE TO THE FUEL TANK, UNDER REAR SEAT.

Mileage: 130,000

FUEL PUMP RELAY BURNS OUT AND IS SO HOT TO THE TOUCH IT WILL BURN YOUR HAND. WAS FOUND WHEN THE CAR WOULD NOT START. HAS HAPPENED TWICE NOW, A WEEK APART, AND ON THE SECOND OCCURRENCE THE FUEL PUMP WAS REPLACED BY THE MECHANIC TO RULE OUT A POSSIBLE SHORT CAUSING THE ISSUE. THE RELAY IS STILL GETTING HOT SO MUCH SO THAT THE SEAT GETS HOT AND I FEAR IT WILL CATCH ON FIRE. THE MECHANIC IS GOING TO LOOK AT THE FUSE BLOCK TO SEE IF THERE IS CORROSION OR DAMAGED WIRING CAUSING THE ISSUE. THE RELAY WAS HOT WHEN THE CAR WAS RUNNING, AND JUST HADN'T COOLED BY THE TIME IT WAS FOUND. THIS SPEAKS FOR HOW HOT IT WAS GETTING AS IT BURNED THE MECHANIC WHEN IT HAD BEEN SITTING A FEW MINUTES. IT DOES COOL DOWN AFTER A WHILE SO IT IS NOT HEATING UP WHILE STATIONARY.

Mileage: 115,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO PATRIOT AUTO SALES (12100 LORAIN AVE, CLEVELAND, OH 44111) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP RELAY SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED A WEEK LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY REPAIRED THE SWITCH AGAIN. THE FAILURE RECURRED TWO DAYS LATER AND THE VEHICLE WAS TAKEN BACK TO THE DEALER AGAIN. THE DEALER NOTICED THAT THE FUSE BOX AND THE RELAY SWITCH WERE MELTED. THE MANUFACTURER WAS NOTIFIED AND COULD NOT DETERMINE THE CAUSE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

Mileage: 113,000

TAKATA RECAL.L ALL OF THE ABOVE .RIGHT REAR DOOR LOCK.KEY FOB.PERMANENT CARBON MONOZIDE POSION.SEE THE COMPLAINTS ON FILE.

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO OPERATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP AND FUSE BOCK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.

Mileage: 78,000

CAR WOULD TURN OVER WILL NOT START. MECHANIC SAID THAT FUSE UNDER SEAT OVER HEATED. PURCHASED WITH 95K 7 DAYS AGO. AFTER RESEARCHING THIS IS AKNOW ISSUE FOR THIS MODEL. I HAVE IT TOWED TO A DEALER I SEE FUEL PUMP MAY NEED TO BE REPLACED AS WELL. WILL IT TAKE A FIRE OR A HIGHWAY ACCIDENT BEFORE BUICK HAS TO UWN UP TO THIS DANGEROUS PROBLEM. I AM SURE YOU ARE AWARE OF THE PROBLEMS WITH THIS MODEL. CAR WAS STAITIONARY BUT WHAT CAN PREVENT THIS HAPPENING TO THE OWNERS DRIVNG IN MOTION.

Mileage: 96,020

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL RELAY FUSE MELTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED ON THREE SEPARATE OCCASIONS, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 119,000. THE VIN WAS NOT AVAILABLE.

Mileage: 119,000

WHILE DRIVING IN POURING RAIN, ENGINE STOPPED RUNNING. NO POWER STEERING OR BRAKES. I WAS JUST BEGINNING TO PARK MY CAR IN A PARKING STALL BETWEEN TWO OTHER CARS. THANK GOD I WASN'T TRAVELING FAST AND WAS ABLE TO AVOID HITTING ANOTHER VEHICLE. I COME TO FIND OUT THAT MY FUSE BLOCK MELTED. BUICK/GM TECHNICAL SERVICE BULLETIN TSB TITLE: 15-NA-051 NO START CONDITION- SEAT BRACKET CONTACTING REAR ELECTRICAL CENTER (REC) - (NOV 5, 2015) COST ME $477.39 TO REPAIR. UNBELIEVABLE THAT THERE WAS NOT A RECALL DONE ON THIS PROBLEM

Mileage: 61,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE FUSE BOX MELTED AND CAUSED THE FUEL PUMP RELAY TO MALFUNCTION. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THERE WAS NO SMOKE OR BURNING ODOR PRIOR TO THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,700. UPDATED 01/27/17*LJ UPDATED 01/31/17.*JB

Mileage: 100,700

FUEL PUMP RELAY BURNED OUT 3 TIMES IN LESS THAN A MONTH, AND THE CAR WOULD NOT START, CAUSING THE FUSE BLOCK TO BURN. THE FIRST TIME, THE VEHICLE WAS PARKED IN THE GARAGE, AND WOULDNT START ONE MORNING, CAUSING ME TO HAVE TO CALL OFF WORK. THE NEXT TIME, VEHICLE WAS IN MOTION, ON A CITY STREET, ON MY WAY TO WORK ONE MORNING, AND THE POWER STEERING AND ACCELERATION DIED, CAUSING ME TO HAVE NO CONTROL OF THE VEHICLE.

Mileage: 62,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THE VEHICLE SEIZED WHILE DRIVING AT ANY SPEED AND THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REAR SEAT FUSE BOX MALFUNCTIONED. THE VEHICLE WAS REPAIRED BY THE DEALER. THE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

FUEL PUMP RELAY BEING BURNED OR MELTED BY SHORTAGE IN FUSE BOX.

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AFTER THE IGNITION WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT FAILED TO REMEDY THE VEHICLE. THE CONTACT HAD TO REPLACE A RELAY SWITCH FOR THE FUEL PUMP AND TWO WEEKS LATER THE FAILURE REOCCURRED. FURTHERMORE, THE CONTACT STATED THAT THE REAR SEAT ON THE DRIVER'S SIDE WOULD GET EXTREMELY HOT. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD CAUSE A FIRE. THE VEHICLE WAS THEN TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUSE BOX NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 99,600.

Mileage: 99,600

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AFTER BEING FILLED WITH FUEL AND THE INSTRUMENT CLUSTER FAILED TO ILLUMINATE. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE IT WAS DIAGNOSED THAT THERE WAS A SHORT IN THE FUSE BLOCK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED. THE FAILURE OCCURRED RANDOMLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH, STARTER RELAY, AND STARTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 53,000.

Mileage: 53,000

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT THERE WAS AN INTERNAL FAILURE WITH THE FUSES AND THAT THE FUSE BOX BURNED. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TOWED TO THE CONTACT RESIDENCE DUE TO THE FAILURE. THE CONTACT REPLACED THE FUEL PUMP RELAY, FUSE BOX AND FUSES. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM). THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

POWER DISTRIBUTION/FUSE BLOCK UNDER BACK SEAT SHORTED AND GOT HOT ENOUGH TO MELT WIRES.VISIBLE SIGNS OF HEAT AND SMOKE ON THE UNIT AND PLUGS. PICTURES ATTACHED I CAN FWD MY LETTER TO BUICK IF NEEDED.

Mileage: 70,655

VEHICLE WAS STATIONARY IN DRIVEWAY. VEHICLE WOULD NOT START. IT HAD WORKED FINE THE DAY PRIOR. THE VEHICLE WAS CRANKING AND CLEARLY HAD POWER BUT WOULD NOT TURN OVER. I NOTICED THAT I COULD NOT HEAR THE FUEL PUMP PRIME WHEN THE KEY WAS TURNED. LIKE MANY OTHERS, I FOUND THE FUEL PUMP RELAY TO BE CHARRED LIKE IT HAD BEEN BURNING. THE FUSE BLOCK WAS ALSO MELTED AT PIN 30. THIS IS SUCH A FIRE HAZARD BEING UNDER THE BACK SEAT, DEALING WITH THE FUEL PUMP, AND OVERHEATING LIKE IT DOES. IT SEEMS TO BE A COMMONLY REPORTED PROBLEM AND I CANNOT BELIEVE THERE HAS NOT BEEN A RECALL. CURRENTLY WAITING ON PARTS TO REPLACE THE MELTED FUSE BLOCK AND THE RELAY.

Mileage: 60,000

DRIVING DOWN THE ROAD THE CAR QUITS AND CRANKS BUT NO START. FOUND FUSE BOX AT FUEL PUMP RELAY MELTED TOGETHER. CLEANED TERMINALS AND REPLACED RELAY DROVE CAR 20 MILES TO HAVE IT DO IT AGAIN. FUSE BOX GET HOT AND IT IS LOCATED UNDER REAR PASSENGER SEAT NEXT TO BATTERY. I HAVE READ WHERE OTHER PEOPLE WITH SAME YEAR, MAKE AND MODEL HAVING THE SAME PROBLEM AND AROUND THE 70,000-80,000 MILEAGE. I FEEL THAT IT IS A SAFETY PROBLEM IN BOTH ACCIDENTS AND FIRE.

Mileage: 79,609

VEHICLE WOULD NOT START IN THE GARAGE. HAD IT TOWED TO A LOCAL GARAGE WHERE THE DIAGNOSIS WAS FAILED FUEL PUMP RELAY. FUEL PUMP RELAY OVERHEATED AND MELTED THE FUSE BLOCK. THE 20 AMP FUSE FOR THE FUEL PUMP RELAY DID NOT FAIL. A VISUAL INSPECTION OF THE RELAY SHOWS AN INTERNAL BURN MARK BETWEEN PINS 85 & 86. SINCE THIS BLOCK IS UNDER THE REAR SEAT, ON WHICH MY GRANDCHILDREN OUR STRAPPED IN I AM CONCERNED ABOUT THE CHANCES OF FIRE. AS FAR AS I CAN TELL THEIR IS NO RECALL, BUT A QUICK SEARCH OF THE INTERNET INDICATES AN ONGOING PROBLEM.

Mileage: 91,156

THE FUEL PUMP RELAY OVERHEATED AND MELTED IN THE FUSE BOX. I SMELLED THE BURNING IN THE CAR. I HAD TO HAVE THE FUEL PUMP, RELAY AND FUSE BOX REPLACED. THE MECHANIC TOLD ME THAT THE FUSE BOX COULD HAVE STARTED A FIRE AND HE HAS NEVER SEEN THIS HAPPEN, LET ALONE IN A VEHICLE WITH SUCH LOW MILEAGE. HE TOLD ME TO GOOGLE THE PROBLEM WITH MY CAR BECAUSE HUNDREDS OF OTHER CAR OWNERS HAVE HAD THE SAME PROBLEM. SURE ENOUGH I DID JUST THAT AND I SAW HUNDREDS OF PEOPLE WITH THE SAME COMPLAINT ABOUT THIS MODEL CAR. GM NEEDS TO BE HELD ACCOUNTABLE. ARE THEY WAITING UNTIL SOMEBODY DIES FIRST BEFORE THEY ACKNOWLEDGE THE PROBLEM OF THE FUEL PUMP RELAY AND THE FUSE BOX?

Mileage: 60,000

CAME OUT FROM WORK AND CAR WOULD NOT START BUT WOULD TRY TO TURN OVER. GOT CAR TOWED TO MECHANIC SHOP TO GET FIXED. THEY FOUND THAT THE FUSE BOX UNDER THE BACK SEAT WAS MELTED. THEY STATED THAT THIS HAS BEEN COMMON IN BUICK LUCERNE MODELS BUT THAT THERE HASN'T BEEN A RECALL. I DON'T UNDERSTAND WHY NO RECALL WHEN MANY PEOPLE HAVE EXPERIENCED SAME EXACT PROBLEM.

Mileage: 112,000

MY 2009 BUICK LUCERNE THAT I USE IN MY DAILY COMMUTE TO WORK DID NOT GIVE ME ANY ISSUES UNTIL THAT FRIDAY,10/23/2015. I TRIED TO START MY VEHICLE THAT MORNING AND IT SEEM AS IF IT WAS NOT GETTING ANY FUEL. HAD THE VEHICLE TOLLED AFTER CONTACTING MY EXTENDED WARRANTY COMPANY. MONDAY I RECEIVED A CALL FROM THE DEALERSHIP THAT THE PROBLEM WAS DIAGNOSIS AS THE FUEL PUMP RELAY HAS NOT ONLY OVERHEATED BUT HAS MELTED THE FUSE BOX. MY CONCERNS ARE THAT THIS COULD HAVE OCCURRED WHILE I WAS DRIVING, ALSO THIS SEEMS TO BE A KNOWN BUT NOT PUBLICIZED ISSUE BY BOTH THE MANUFACTURER AND THE INSURANCE COMPANY. TOO MANY IDENTICAL INCIDENTS HAVE OCCURRED AND HAS BEEN REPORTED, YET NO ONE HAS RECEIVED ANY REPORTED ACTION TO CORRECT THIS DANGEROUS PROBLEM. IT DOES NOT TAKE A MECHANICAL EXPERT TO KNOW THAT A DEVICE THAT CAN CAUSE FIRE TO SOMETHING ASSOCIATED WITH THE FUEL SYSTEM IS A MATTER OF GREAT CONCERN. HOPEFULLY THIS PROBLEM WILL BE TAKEN SERIOUSLY BEFORE SOMETHING FATAL HAPPENS.

Mileage: 80,000

I WAS DRIVING DOWN THE HIGHWAY WHEN MY CAR JUST STOPPED RUNNING. LUCK HAD IT I WASN'T ON AN INTERSTATE, THIRTY MINUTES LATER I WOULD HAVE BEEN. (I'M A RETIRED MECHANIC OF 48 YEARS.) UP ON CHECKING THE CAR I FOUND THAT THERE WAS NO FUEL PRESSURE. HAD THE CAR TOWED TO GM AUTO CENTER IN LARAMIE, WY. I TOLD THE SERVICE WRITER THAT I PRESUMED THAT THE FUEL PUMP HAD WENT OUT. WHEN THE TEC. RAN DIAGNOSTICS AND A VISUAL CHECK THEY FOUND THAT THE FUEL PUMP CONTROL MODULE AND FUSE BOX WERE BURNT. THE TEC. TOLD ME THAT HE HAD SEEN THIS BEFORE AND SHOWED ME ANOTHER FUSE BOX WITH THE EXACT DAMAGE. AFTER RETURNING HOME I WAS TOLD BY ANOTHER MECHANIC THAT ONE OF HIS CUSTOMERS HAD THE SAME PROBLEM. THIS IS A SERIOUS PROBLEM AS ALL THESE ITEMS GET MELTING HOT AND ARE LOCATED UNDER THE BACK SEAT JUST IN FRONT OF THE GAS TANK WHICH IS PLASTIC AND THE SEAT IS NOTHING BUT FOAM CREATING A SERIOUS FIRE HAZARD. I HAD THE RECALL ON THE IGNITION SWITCH DONE. AFTER MY EXPERIENCE WITH MY CAR I THINK IT WAS A SMOKE SCREEN FOR THE REAL PROBLEM THE FUSE BOX, FUEL PUMP CONTROL MODULE OR FUEL PUMP. NO ONE WANTS TO TAKE THIS SERIOUSLY. THIS ALL STARTED ON 09/25/2015 CAR MILLAGE 61855. I HAVE THE ITEMS IN QUESTION.

Mileage: 61,855

CAR CRANKED BUT WOULD NOT START, CHECKED EVERY THING OUT FOUND FUEL PUMP FUSE BURNT REMOVED FUSE FOUND FUSE BLOCK BURNT, FUSE LOOKED LIKE IT HAD BEEN ON FIRE AT ONE TIME. I LIVE IN THE COUNTRY WITH NOTHING BUT CURVEY ROADS IF THAT FUSE WOULD HAVE GONE OUT WHEN I WAS DRIVING I WOULD HAD RUN OFF ROAD AND HIT A TREE KILLING ME OR MY PASSENGERS. [XXX] [XXX] RICHLAND, MISSOURI 65556 VIN UNAVAILABLE INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

Mileage: 116,400

FUSE BOX UNDER REAR SEAT BURNED LEAVING CAR UNABLE TO RUN, LEAVING US STRANDED IN HUMID 90 DEGREE TEMPERATURE. CAR TOWED, REPAIRED COSTING NEARLY $800.

Mileage: 72,071

6/2/15 VEHICLE WOULD NOT START, FULL POWER AND CRANK BUT WOULD NOT ENGAGE. CAR TOWED TO BUICK DEALER WHERE I PURCHASED CAR. CK ECM CODES - NONE CK IGN AND FUEL SYSTEM - NO FUEL PRESSURE - CK FUEL DELIVER SYSTEM FOUND FUEL PUMP FAILURE. REPLACED FUEL MODULE ASSEMBLY. $624.00. 6/08/15 VEHICLE WOULDN'T START. PULLED RELAY FOR FUEL PUMP AND PUT IT BACK IN AND IT STARTED. I DROVE IT BACK TO THE DEALERSHIP. THEY CHECKED FUEL PUMP RELAY, FOUND REAR FUSE PANEL DAMAGED DUE TO POOR CONNECTION AT FUEL PUMP RELAY. REPLACED REAR FUSE BLOCK. COST $291.00. AFTER DOING SOME RESEARCH PROBLEM SEEMS COMMON AND STEMS FROM AN OBVIOUS PROBLEM WITH THESE FUSE BOXES. READ THERE WAS A NATIONAL BACKORDER ON THESE FUSE BOXES AT ONE POINT. SOUNDS LIKE THIS SHOULD OF BEEN A RECALL AND REPLACED FOR FREE.

Mileage: 58,268

ENGINE FAILS TO START. AFTER RESEARCH ONLINE, CHECKED FUEL PUMP RELAY FUSE AND SURE ENOUGH RELAY BLOWN AND HAD MELTED TO FUSE BLOCK AT ONE PIN ON RELAY. REPLACED FUSE AND CAR STARTED AND RAN LIKE NOTHING WAS EVER WRONG. WITHIN A WEEK THE SAME THING HAPPENED ONLY THIS TIME THE CAR WOULD NOT START AFTER REPLACING THE FUEL PUMP RELAY. HAD CAR TOWED TO BUICK DEALER. THEY REPLACED THE COMPLETE FUSE BLOCK THAT CONTAINS THE FUEL PUMP RELAY WHICH IS LOCATED UNDER THE REAR CAR SEAT. COST ABOUT $840.00 TOTAL ( $40.00 FOR THE 2 FUEL PUMP RELAYS; $75.00 FOR THE TOWING AND THE REST WAS DEALER CHARGE TO REPLACE FUSE BLOCK). ASKED THEM IF THEY FOUND WHAT WAS CAUSING THIS AND THEY SAID EVERYTHING CHECKED OK AFTER REPLACING FUSE BLOCK. HAVE NOT HAD ANY MORE ISSUES SO FAR ALTHOUGH IT HAS ONLY BEEN A COUPLE WEEKS BUT WOULD THINK SOMETHING HAS TO BE CAUSING TOO MUCH AMPERAGE TO BE DRAWN TO HAVE CAUSED THIS. DON'T KNOW IF FUEL PUMP CAN CAUSE TOO MUCH AMPERAGE DRAW. AGAIN, DEALER SAID NOTHING SHOWED UP AFTER REPLACING FUSE BLOCK

Mileage: 86,000

MY FUSED BOX MELTED AND STOPPED THE FUEL THE FROM GOING TO MY ENGINE. THE FUSED BOX WAS HEATED TO THE POINT OF BURNING AND MELTING. *TR

Mileage: 76,000

AFTER RETURNING FROM A TWO HOUR TRIP I PARKED MY CAR AT HOME. THE NEXT DAY I TRIED TO START MY CAR AND IT WOULD ONLY TURN OVER.A MECHANIC FOUND THE FUEL PUMP DEFECTIVE, FUEL PUMP RELAY BURNT AND THE POWER PANEL BURNT AS WELL.

Mileage: 84,453

TL*THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, THERE WAS A BURNING SMELL OF WIRES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT REAR FUSE BOX HAD MELTED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000. UPDATED 7/7/15*CN

Mileage: 75,000

WHILE DRIVING IN PETOSKEY THE CAR STARTED TO MISS AN BACKFIRING THEN THE MOTOR STOP RUNNING. I COULDN'T STOP OR STEER THE CAR. AFTER I GOT THE CAR FINELY STOPPED THE CAR WOULDN'T START UP AN I COULD SMELL LIKE WIRE BURNING. I HAD THE CAR DELIVERED TO AN AUTO SHOP BROWN MOTORS IN HARBOR SPRINGS MI. AFTER THE DIAGNOSIS THEY FOUND THAT THE FUSE BLOCK UNDER THE REAR SEAT WAS BURNED UP AT THE FUEL PUMP FUSE, AN WAS ON FIRE AT ONE TIME.. THE FUSE BLOCK WAS BEYOND FIXING AN NEEDED A NEW ONE INSTALLED. THERE WAS A RECALL ON THE IGNITION SWITCH, BUT THIS ISN'T WHAT IS WRONG WITH THESE CARS, I DON' BELIEVE THAT THE IGNITION SWITCH ON THERE RECALL ARE WHAT IS WRONG, I BELIEVE THAT THE FUSE BLOCK IS WHAT WRONG WITH THERE RECALLS WHEN THE FUSE SHORTS OUT THE FUEL PUMP STOPS AN SO DOES THE CAR MOTOR. STRANGE THAT THE CAR DEALERS FOR SOME REASON HAS THEM IN STOCK, THERE SHOULD BE A RECALL ON ALL CAR WITH THIS TYPE OF FUSE BOX, THIS IS WHAT CAUSING THESE CAR TO STOP RUNNING AN GET IN A ACCIDENTS. TO DAY I GOT LUCKY. *TR

Mileage: 108,290

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 01/20/15*LJ UPDATED 10/5/2015*JS

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

Mileage: 74,000

SUBMISSION FROM CONSTITUENT RE 2009 BUICK LUCERNE RECALL NOTICE. *SMD ACCORDING TO THE RECALL NOTICE, THE PARTS WERE NOT AVAILABLE.*JB RECALL # 14V355000. *JB

TL* THE CONTACT OWNS A 2009 BUICK LUCERNE. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM). HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

RED LIGHT WARNING INDICATED THAT AIRBAG NEEDED SERVICING. TOOK IT TO THE DEALERSHIP WHERE CAR WAS PURCHASED. DEALER STATED THAT IT WAS AN ELECTRICAL PROBLEM. THERE IS NO WARRANTY FOR THIS. SEEMS STRANGE THAT A 5 YR. OLD AUTOMOBILE WITH LOW MILEAGE SHOULD NEED A WHOLE NEW SYSTEM OR HAVE THIS PROBLEM. IT IS VERY EXPENSIVE TO REPAIR. *TR

Mileage: 39,600

CORROSION OF FUSE BOX LOCATED UNDER BACK SEAT. *TR

Mileage: 120,000

CORROSION OF FUSE BOX LOCATED UNDER BACK SEAT. *TR

Mileage: 120,000

THE BUICK WAS IN MY GARAGE WHICH IS ATTACHED TO THE HOUSE, BEFORE GOING TO BED I ALWAYS OPEN THE DOOR TO THE GARAGE TO BE SURE THE GARAGE DOOR IS DOWN AND THE FLAG IS INSIDE. DID SO THAT NIGHT AND ALL WAS NORMAL. THE NEXT MORNING WHEN I OPENED THE DOOR TO THE GARAGE TO PUT THE BIG DOOR UP AND THE FLAG OUT THE GARAGE WAS VERY WARM. NO OTHER INDICATION OF A PROBLEM, ASSUMED HE FURNACE HAD ACTED UP. WE TOOK THE CAR TO HAVE BREAKFAST DID NOTICE THE HOOD WAS VERY WARM AS IF THE CAR HAD BEEN RUNNING (I DO NOT HAVE A SENSE OF SMELL SO DID NOT SMELL AN EXHAUST) FUEL WAS VERY LOW ( I WONDERED IF THERE WAS ENOUGH TO GET TO A SERVICE STATION) FILLED HE CAR HAD BREAKFAST THEN CAME HOME NOT APPARENT PROBLEMS. LATER THAT MORNING MY WIFE USE THE CAR TO GO TO AN APPOINTMENT WHEN IT STARTED TO MISS, SHE PULLED OFF THE ROAD AND CALLED AAA WHO TOWED THE CAR TO THE NEAREST BUICK DEALER. THE CAR IS THERE NOW, THEY HAD NO YET DETERMINED THE PROBLEM. *TR