2013 CAN-AM SPYDER RT Engine Problems

CAN"T STOP AN OIL LEAK. AFRAID IT MIGHT GET HOT AND CATCH ON FIRE!!! *DT

Mileage: 17,000

I RECEIVED A RECALL NOTICE ABOUT THE ELEVATED TEMPERATURE IN THE ENGINE COMPARTMENT ON FEBRUARY 26, 2015. IN THE SAFETY RECALL NOTICE I WAS ADVISED TO CONTACT BRP DEALERSHIP, WHICH I DID IMMEDIATELY. I WAS TOLD THE PART WAS ON BACK ORDER AND TO CALL BACK IN APRIL I CONTACTED THEM AGAIN IN APRIL, WAS TOLD THE STATES WITH THE HOTTEST TEMPERATURE WAS FIRST CALL BACK IN A MONTH. I CALL IN MAY, WAS TOLD AGAIN, THE PART WAS NOT AVAILABLE. CALLED BACK IN JUNE WAS TOLD THE TOOL TO FIX THE PROBLEM WAS NOT AVAILABLE. MEANWHILE IN OHIO THE SUMMER MONTHS ARE HERE, AND THIS STILL HAS NOT BEEN RESOLVED. I CONTACTED BRP IN CANADA, NO RESPONSE. THIS CAN AM WAS PURCHASED NEW OFF THE SHOW ROOM FLOOR IN 2014, AND I AM ADVISED TO NOT RIDE IT WHEN ITS HOT, OR IN TRAFFIC. I AM NOT A HAPPY CAMPER RIGHT NOW, I PURCHASED THE BIKE TO ENJOY THE SUMMER MONTHS, RIDE WITH THE LEGION RIDERS AND IT SITS IN THE GARAGE.

WHILE RIDING MY CAN AM SPYDER FOR APPROXIMATELY 30 MINUTES, I WAS STOPPED AT A RED LIGHT FOR OVER A MINUTE. I THEN BEGAN TO FEEL EXCESSIVE HEAT FROM THE RIGHT SIDE OF THE BIKE, WHERE MY LOWER THIGH AND KNEE TOUCHES THE PANEL OF THE BIKE. I ALSO BEGAN TO SMELL A STRONG ODOR OF BURNING PLASTIC (SORT OF LIKE WHEN A RESISTER OR COMPUTER CHIP GETS FRIED). I IMMEDIATELY DROVE HOME WHERE I CHECKED THE BIKE FOR BURNT PLASTIC. I DID NOT NOTICE ANY BURNT PLASTIC, HOWEVER I DID NOT REMOVE ANY OF THE PANELS TO CHECK UNDERNEATH THEM. IT WAS APPROXIMATELY 77F WHEN THIS HAPPENED. I AM VERY CONCERNED THAT THE EXCESSIVE HEAT WILL MELT COMPONENTS UNDERNEATH THE PANELS OR START A FIRE. THE PANEL WAS VERY HOT TO THE TOUCH. I DID RECEIVE A VERY SLIGHT BURN TO MY THIGH AREA AFTER THE RIDE.

Mileage: 2,875

WE HAVE BEEN WAITING FOR A RECALL FIX THAT WAS INFORMED BY BRP WOULD BE IN MAY 2015. THROUGH SOCIAL MEDIA WE WERE TOLD BY BRPCARE THAT THE FIX WAS READY AND SUPPLIED PICTURES. WE HAVE SCHEDULED THE WORK BUT AM NOT HAPPY WITH THE FIX AS IT CHANGES THE APPEARANCE OF THE VEHICLE. WHEN I CALLED NHTSA I WAS INFORMED THAT SHE COULD NOT FIND ANY INFORMATION THAT THIS FIX WAS APPROVED. *TR

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. WHILE DRIVING APPROXIMATELY 15 MPH, THE MOTORCYCLE BEGAN TO OVERHEAT AND STALLED WITHOUT WARNING. THE MOTORCYCLE WAS ABLE TO RESTART HOWEVER, THE FAILURE RECURRED ON TWO OTHER OCCASIONS. THE MOTORCYCLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE CONTACT WAS DRIVING TO SLOW WHICH CAUSED THE MOTORCYCLE TO OVERHEAT. THE COMPUTER WAS REPROGRAMMED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE), HOWEVER THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 900.

Mileage: 900

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER ROADSTER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) HOWEVER, THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS UNAVAILABLE.

2013 CAN AM SPYDER RT. CONSUMER WRITES IN REGARDS TO RECALL RECEIVED REGARDING ELEVATED TEMPERATURE IN THE ENGINE COMPARTMENT. *SMD THE CONSUMER IS CURRENTLY WAITING FOR THE BIKE TO BE REPAIRED. *JB UPDATED 12/17/15 *JB

TL* THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) AND STATED THAT THE PARTS WERE NOT AVAILABLE UNTIL MID MAY 2015. THIS WAS AN UNREASONABLE TIMEFRAME BECAUSE THE DEALER AND THE MANUFACTURER HAD NO INTERIM REPAIR TO APPROVE FOR THE AUTHORIZED DEALER. THE DEALER DID NOT PROVIDE A SPECIFIC DATE WHEN THE PART WOULD BECOME AVAILABLE TO REPAIR THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL*THE CONTACT OWNS A 2013 CAN-AM SPYDER RT. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THERE WAS A BURNING FUEL ODOR AS WELL AS EXCESSIVE HEAT COMING FROM THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE TECHNICIAN WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V095000 (ENGINE) HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 700.

Mileage: 700

TO BRP CAN AM SPYDER 2013 CAN AM SPYDER RT LIMITED 9-29-2014 I HAVE A BRAND NEW CAN AM SPYDER RT LIMITED STOPPED ON ME 2 TIMES IN FIRST GEAR WITH 120 MILES. NEXT THIS BIKE STOPPED ON ME AGAIN 11 TIMES OVER THE WEEKEND. THIS BIKE SHUTS OFF AT EVERY LIGHT I STOP AT. WHICH IS DANGEROUS. I WAS ALMOST REAR ENDED AT LEAST 2 TIMES .. I TOLD MY SALESMAN THAT I HAVE A STRONG GAS SMELL IN MY GARAGE .I TOOK BIKE AND DEALERSHIP TOLD ME TO LEAVE OVERNIGHT DUE TO STRONG GAS SMELL AND SHUTTING OFF. MY BIKE WAS READY FOR PICK UP THE NEXT DAY. I WAS TOLD THE CANISTER WAS OK AND THE LOUD FUEL SMELL SHOULD BE GONE .I WAS ADVISED THAT ALL RECALLS FOR THIS MODEL HAVE BE DONE. I WAS TOLD DEALER DID A GAS TREATMENT AND WAS ADVISED BIKE IS A 2013 MODEL WHICH HAD GAS SITTING IN TANK FOR A LONG TIME . I WAS ASK IF I TOP OFF GAS AND I TOLD THE DEALER NO! I READ ALL THE BOOKLET AND WATCH VIDEO PERTAINING TO THIS BIKE ALONG WITH SIGNING UP FOR SPYDERLOVER.COM. . I KNOW ALL BIKE HAVE BREAK IN PERIODS, BUT THIS IS TOTALLY UNACCEPTABLE AND SURELY NOT SAFE. I WAS INFORMED TO JUST RIDE MY BIKE AND TO REV THE ENGINE WHEN IT SEEMS LIKE IT'S GOING TO SHUT OFF. NOW WITH 500 MILES THE FUEL SMELL IS EVEN STRONGER AND I HAVE LOST COUNT ON HOW MANY TIMES IT SHUTS OFF IN 1ST GEAR AT A LIGHT OR JUST SITTING IN THE GARAGE. I CALL THE DEALER AGAIN. THEY INFORMED ME THAT AFTER 1,000 TO 1,500 MILES THESE ISSUES SHOULD GO AWAY AFTER THE 600 SERVICE. NOW, . THE REASON FOR THIS LETTER IS THAT THIS BIKE IS NOT SAFE BECAUSE OF THE STRONG FUEL SMELL AND I DON'T WANT TO BE REAR ENDED DUE TO BIKE SHUTTING OFF AT EVERY LIGHT. I AM ADDRESSING THIS ISSUE TO PREVENT THE ISSUE OF A POSSIBLE ACCIDENT OR A FIRE. NOW WITH 1,300 MILES AND SERVICED AT THE DEALER THE GAS SMELL HAS GOTTEN WORSE. IM TRYING TO PREVENT A FIRE OR BAD ACCIDENT FROM HAPPENING. SPYDER WEBSITE HAVE SEVERAL COMPLAINTS ONTHIS ISSUE WITH THE GAS. *TR

Mileage: 500

MY SPYDER HAS BEEN LEAKING OIL SINCE THE DAY I BOUGHT IT NEW. I HAVE OWNED IT FOR 6 MONTHS, HAS BEEN IN THE SHOP SEVERAL TIMES. STILL LEAKING. GAS FUMES SO BAD COMING FROM THE ENGINE AFTER RIDING I CAN NOT CLOSE THE GARAGE DOOR FOR AT LEAST AN HOUR/. SMELLS OF GAS REALLY STRONG EVERY TIME I AM ON THE BIKE. GAS CAP SO HOT I CAN HARDLY TOUCH IT WHEN I NEED TO GET GAS. *TR

THE BIKE GETS VERY HOT. I HAVE ALREADY HAD THE EXAUST WRAPPED BUT IT IS STILL VERY HOT TO RIDE. *TR

Mileage: 1,250

HAVE OWNED RT LIMITED FOR LESS THAN ONE YEAR WITH HEAT ISSUES. WHILE RETURNING FROM EVENT IN NORTH CAROLINA BIKE RAN FINE IN THE COOLER TEMPERATURES. AS SOON AS RETURNED TO THE SOUTH, ENGINE BEGAN TO RUN HOT AND CHECK ENGINE LIGHT ON AND OFF AS WELL AS BIKE CHUGGING AND RUNNING ROUGHLY. BIKE SHUTTING DOWN AND HAD TO LET COOL OFF BEFORE WOULD RESTART. HAVE HAD EXTREME HEAT ISSUES SINCE PURCHASING BIKE ESPECIALLY IN HOTTER MONTHS HERE IN HOUSTON AREA. HAVE HAD UPDATES DONE PER BRP RECOMMENDATIONS TO NO SUCCESS. BIKE IS NOT SAFE AND FEAR RIDING ANY LENGTH OF TIME OR PROLONGED DISTANCE. WHEN PARKED IN GARAGE AFTER RIDING FIND THERE IS A STRONG GAS SMELL IN THE GARAGE. FOR THIS REASON USUALLY LEAVE BIKE IN YARD FOR UPTO 30 MINUTES PRIOR TO PUTTING GARAGE FOR FEAR OF FIRE CONSUMING HOME. NOT SURE WHAT THIS REPORT WILL DO BUT FEEL LIKE SOMEONE SHOULD BE MADE AWARE OF HOW UNSAFE AND POTENTIALLY DANGEROUS THESE VEHICLES ARE. DEALERS ARE AT A LOSS FOR WHAT TO DO AS I HAVE EXPERIENCED SAME PROBLEMS WITH A 2013 ST LIMITED MODEL THAT WAS TRADED DUE TO BRAKE FAILURE AND EXTREME HEAT ISSUE MELTING PARTS. THOUGHT THE RT MODEL WOULD BE BETTER BUT FIND MYSELF IN SAME SITUATION. *TR

Mileage: 8,500

SMELL GAS VAPORS IN THE GARAGE AND HOUSEBAFTER DRIVING IT. SEAT FRONT TOP WHERE IT MEETS THE BODY(STORAGE COMPARTMENT) TO HOT TO TOUCH OR SIT ON WITHOUT A SHEEPSKIN PAD AND STILL VERY UNCOMFORTABLE AND LIKELY DANGEROUS. RIGHT FOOT GETS SO HOT FROM THE MOTOR YOUR CAN'T KEEP YOUR FOOT IN PLACE. HAVE TO WEAR HEAVY BOOTS. HAVE HAD THE RECALL AND ELECTRONIC UPDATES. *TR

Mileage: 300

I WAS RIDING ON HIGHWAY 291 IN LEES SUMMIT MO TRAVELING AT 65 MPH. THE DAILY TEMP WAS BETWEEN 92 - 95 DEGREES. THE FAN WAS BLOWING THE HOT AIR OUT FROM THE BIKES RADIATOR AREA AND WITH THE BIKE BEING IN MOTION THE HOT AIR WAS BEING ROUTED ONTO MY RIGHT LEG AND I COULD FEEL MY LEG GETTING HOT TO THE POINT THAT I WAS UNABLE TO KEEP MY FOOT ON THE FOOT PEG FOR LONGER THAN 10-15 SECONDS AFTER WHICH, I NEEDED TO KEEP SHIFTING THE LOCATION OF MY FOOT ON THE FOOT PEG. I ALSO NOTICED THAT THE RIGHT SIDE PANELS AND THE AIR COMING FROM UNDER THE SEAT WAS UNCOMFORTABLY HOT. ALSO WHEN REFUELING THE GAS TANK FILLER NECK WAS TOO HOT TO TOUCH. DURING THE FIRST LONG TRIP ON THIS BIKE (WEEKEND OF OCT 25-26) FROM GRAIN VALLEY MO TO EUREKA SPRINGS AR (540 MILES ROUND TRIP). TEMPS WERE IN THE 70'S DURING THE TRIP TO AR AND WHEN REFUELING I NOTICED THAT THE GAS TANK FILLER NECK WAS OVERLY WARM. THE RETURN TRIP, WITH TEMPS IN THE MID 80S, THE HEAT ON MY RIGHT LEG WAS BECOMING UNCOMFORTABLE, THE RIGHT SIDE PANELS WERE HOT AND THE HEAT UNDER THE SEAT WAS OVERLY WARM. REFUELING, THE GAS TANK FILLER NECK WAS ALMOST TOO HOT TO TOUCH. *TR

Mileage: 3,300

I TOOK A TRIP TO GEORGIA ON OCTOBER 24, , AND ON SUNDAY MORNING, OCTOBER 26, WHEN I STARTED THE SPYDER TO LEAVE, IT BEGAN TO STALL AT IDLE, IT CUT OFF REPEATEDLY, AND IDLED ROUGH. IT WOULDN'T MAINTAIN THE NORMAL IDLE RANGE OF 1200-1300 RPM. I FINALLY WAS ABLE TO DRIVE IT OFF, AND AS I RODE, THE IDLE WAS ROUGH FOR A FEW MILES, BUT AFTER I GOT IT ON THE FREEWAY, IT SEEMED OKAY. ONCE AGAIN, THE HEAT ISSUE AND FUEL SMELLS BECAME EVIDENT AS I RODE BACK TO ALABAMA, AND THE OUTSIDE TEMPERATURE ROSE. IT SEEMS THAT ANY OUTSIDE TEMPERATURES ABOVE 70 DEGREES AND THE HEAT FROM THE VEHICLE BECOMES WORSE WITH THE RESULTING FUEL SMELL AND A LOT OF HEAT COMING FROM THE ENGINE AND FUEL TANK WHEN GOING TO FILL UP. I WAS A BIT WORRIED BEING SO FAR FROM HOME, BUT I GOT BACK OKAY. *TR

Mileage: 9,150

ON FRIDAY, 24 OCTOBER 2014I RODE THE SPYDER TO THE DEALER, WHERE THE TECHNICIAN, [XXX], CONNECTED IT TO THE B.U.D.S. COMPUTER. I AM ALSO SENDING [XXX]. A COURTESY COPY OF THIS EMAIL. THE COMPUTER OBTAINED INFORMATION THAT POINTED TO A PROBLEM WITH THE PURGE VALVE AND VAPOR RECOVERY CANISTER, AS WELL AS A PROBLEM WITH THE ENGINE CONTROL MODULE (ECM). THIS IS IN ADDITION TO HEAT AND GAS VAPOR ISSUES WHEN THE AMBIENT OUTSIDE TEMPERATURE IS 75 DEGREES AND ABOVE. YESTERDAY AFTERNOON 27 OCTOBER 2014, I TOOK THE SPYDER ON A RIDE YESTERDAY OF ABOUT 30 MILES ON LOCAL ROADS. AFTER I RETURNED HOME AND SHUT OFF THE SPYDER BRIEFLY TO OPEN THE GARAGE DOOR, IT DIDN'T WANT TO START. THE STARTER TURNED THE MOTOR OVER, BUT THE MOTOR WOULD NOT START. AFTER 4 ATTEMPTS, I WAS FINALLY ABLE TO GET IT STARTED. I AM FORTUNATE THAT THIS DID NOT HAPPEN OUT ON THE ROAD. THE SPYDER HAD A STRONG GAS VAPOR SMELL, WHICH WAS STILL EVIDENT THE MORNING IN MY GARAGE. I CHECKED THE SPYDER THIS MORNING AND IT STARTED WITH NO PROBLEM. I SUSPECT THE ECM AND PURGE VALVE CODES THAT THE B.U.D.S. COMPUTER DETECTED ARE TO BLAME, BUT THE HEAT ISSUE IS SOMETHING THAT BRP NEEDS TO ADDRESS. I, ALONG WITH MANY OWNERS OF THE CAN-AM SPYDER, HAVE CONCERNS WITH SAFETY AND HEAT ISSUES. I WILL SAY THAT I ENJOY THE SPYDER, BUT I WOULD ENJOY IT FAR MORE IF MY CONCERNS WITH SAFETY AND RELIABILITY ARE ADDRESSED. MY SPYDER IS STILL UNDER BRP ORIGINAL WARRANTY, AND I'D LIKE THESE PROBLEMS TO BE ADDRESSED BY BRP UNDER THOSE TERMS AND NOT AT ADDITIONAL COST TO ME, BECAUSE THE SPYDER IS NOT INEXPENSIVE TO BUY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 9,350

VEHICLE GIVES OFF SUCH A STRONG FUEL ODOR AFTER A RIDE, WE NOW PARK THE VEHICLE OUTSIDE OUR ENCLOSED GARAGE FOR A FEW HOURS SO THE ODOR WILL NOT BE OVERWHELMING IN OUR GARAGE. ALSO, THE VEHICLE'S FUEL TANK IS VERY HOT TO THE TOUCH WHEN RE-FILLING WITH GAS. VEHICLE WAS TAKEN TO AN AUTHORIZED BMP DEALERSHIP ABOUT THE STRONG FUEL ODOR AND THEY DID NOT FIND ANYTHING WRONG. *TR

Mileage: 2,000

WENT FOR A RIDE HAD FUEL SMELL WHEN STOP AT LIGHT ,TOOK A BREAK AT FAST FOOD PLACE AND SMELLED FUEL AGAIN LOOK ON DRIVEWAY SAW FUEL VAPORS , WENT HOME PARKS IN GARAGE ,LATER SMELLED FUEL, HAD TO OPEN DOORS AND WINDOWS TO LET THE SMELL OUT , THIS HAPPEN SEVERAL TIMES ,WENT TO DEALER TO FIND OUT WATT GOING ON WITH THE SPYDER THEY WORK ON IT 3 -4 TIMES . THIS BIN GOING BACK TO DEALER ALL SUMMER LONG ABOUT THE HEAT AND SMELL THEY DON'T KNOW WHAT TO DO ABOUT IT. *TR

Mileage: 1,800

I PURCHASED THIS WHEN THERE WAS A LARGE REBATE FOR BUYING THE 2013 SPYDERS. I HAVE BEEN PLAGUED WITH A HOT SEAT AND RIGHT FOOT SINCE THE BEGINNING. I WIND UP HAVING TO MOVE MY RIGHT FOOT TO THE REAR PASSENGER FLOOR BOARD TO ESCAPE THE HEAT AND THERE ARE TIMES WHERE MY INNER THIGHS ARE BURNED WHERE THE HEAT IS COMING UP AROUND THE SEAT. I FOUND OUT THAT THERE WAS A RECALL ON THIS BIKE AND WILL BE HAVING THIS DONE AS SOON AS THEY GET THE PARTS IN BUT FROM READING INFORMATION ON A BLOG THAT I SUBSCRIBED TO, IT PROBABLY WON'T HELP. I ALSO UNDERSTAND THAT THERE IS AN INVESTIGATION GOING ON AND WANT TO ADD MY INFORMATION TO IT. THANKS *TR

Mileage: 900

AFTER BUYING MY SPYDER I NOTICED EXCESSIVE HEAT COMING FROM THE ENGINE AREA UNDER MY SEAT. AT TIMES ITS SO HOT THAT I CAN BARELY TOUCH MY GAS CAP WITH IS LOCATED UNDER THE SEAT. THERE HAVE BEEN A FEW TIME THAT AFTER RIDING FOR A EXTENDED PERIOD AND STOPPING THE BIKE I'VE NOTICED THE SMELL OF GASOLINE. I'VE CHECKED FOR FUEL LEAKS AND FOUND NONE, AND CALLED THE DEALERSHIP TO COMPLAIN. THEY TOLD ME THAT IT WAS PROBABLY THE FUEL TANK OVER PRESSURIZING BECAUSE OF THE HEAT AND VENTING TO THE AIR. I WAS ADVISED TO PARK THE BIKE OUT SIDE UNTIL IT COOLED DOWN BEFORE BRINGING IT INTO THE GARAGE. WHILE RIDING THE HEAT COMING UP FROM UNDER THE SEAT IS REALLY BAD, MAKING RIDING NOT MUCH FUN. I'VE CALLED BRP TO COMPLAIN ABOUT THE PROBLEM BUT AS OF YET HEARD ANY THING BACK FROM THEM. I'VE READ THAT SEVERAL SPYDER'S HAVE CAUGHT FIRE, AND STILL NOTHING HAS BEEN DONE. MY FELLOW SPYDER RIDERS HAVE ALL COMPLAINED ABOUT THE HEAT PROBLEM, OTHER THAN THAT THE BIKE IS GREAT. I JUST WANT BRP TO COME UP WITH A SOLUTION TO THE HEAT PROBLEM. *TR

Mileage: 30

EXCESS HEAT COMING FROM ENGINE COMPARTMENT CREATED HEAT BLISTERS ON RIGHT CALF. ALSO, AN INTERMITTENT FUEL SMELL THAT EMANATES FROM THE ENGINE COMPARTMENT. *TR

Mileage: 600

HEAT UNDER THE SEAT IS TO HOT TO RIDE SAFETY. ALWAYS TRYING TO SHIFT AND OPEN LEGS TO TRY AND GET SOME RELIEF. HEAT COMING OFF THE RIGHT SIDE HAS ACTUALLY CAUSED A RED HEAT RASH ON MY RIGHT SHIN FROM MY ANKLE UPWARDS. WHEN REFUELING I AM SO SCARED THAT THE GAS IS GOING TO FLAME UP BECAUSE OF THE FUMES AND THE HEAT RADIATING FROM UNDER THE SEAT WHICH MUST BE LIFTED TO REFUEL. I HAVE TRIED PLACING ALUMINUM FOIL UNDER THE SEAT IN THE HOPES OF DISSIPATING THE HEAT BUT IT HAS NOT WORKED. I STORE MY CAN AM SPYDER IN A TRAILER AND MUST LEAVE ALL THE DOORS OPEN FOR SEVERAL HOURS UNTIL THE FUMES SUBSIDED. I AM AFRAID OF A FIRE AND HAVE MOVED THE TRAILER FAR AWAY FROM MY OTHER VEHICLES AND HOUSE. *TR

Mileage: 100

I PURCHASED A 2013 CAN AM SPYDER IN JULY 2013. FROM THE FIRST DAY I PURCHASED THE VEHICLE I HAVE EXPERIENCED WHAT I CONSIDER A DANGEROUS AMOUNT OF HEAT RADIATING FROM THE ENGINE. ALSO, I CAN SMELL GAS FUMES AND I AM TOLD THAT IS BECAUSE THE GAS IS ACTUALLY BOILING DUE TO THE HEAT PROBLEM. I HAVE TRIED DIFFERENT FIXES RECOMMENDED BY OTHER OWNERS AND THEY DID REDUCE THE HEAT SOMEWHAT BUT IT STILL FEELS LIKE I AM RIDING ON A BOMB JUST WAITING TO EXPLODE. SINCE I PAID OVER $27,000 I CAN'T JUST PUT IT AWAY. THE REPUTATION IS SO BAD THE UNIT HAS REALLY DEPRECIATED AND THE ONLY PERSON WILL TO BUY THE VEHICLE WOULD BE SOMEONE WHO DID NOT DO THEIR HOMEWORK. ARE YOU AWARE OF SIMILAR COMPLAINTS AND DO YOU HAVE ANY SUGGESTIONS? I CAN'T GET ANYONE AT BRP TO DISCUSS THE ISSUE. IT IS NOT THE DEALERS FAULT. *TR

Mileage: 3,000

2013 RT LIMITED 204 DEGREES HEAT OFF OF BIKE PANELS GAS IS BOILING IN GAS TANK NHTSA CHECK THE BIKE OUT SMELL OF GAS IN GARAGE AFTER RIDING MOTORCYCLE 3750 MILES. *TR

Mileage: 3,750

THIS IS MY 2ND REPORT, I RODE THE SPYDER AGAIN YESTERDAY AND I BURNED MY INNER THIGHS AND MY RIGHT CALF FROM THE EXTREME HEAT COMING FROM UNDER THE SEAT AND A VENT ON THE RIGHT SIDE. THE ENGINE TEMPERATURE IS NOT SHOWING IT RUNNING HOT. THERE IS A DESIGN FLAW THE BODY PLASTICS NOT ALLOWING PROPER VENTING FOR THE HEAT. THIS IS MY SECOND SPYDER, MY FIRST WAS A 2008 MODEL AND NEVER HAD PROBLEMS WITH THE ENGINE HEAT, I HAD 25,000 MILES ON IT BEFORE I SOLD IT AND BOUGHT THIS PILE OF JUNK, I HAVE LEFT MANY E-MAILS ON BRP'S WEBSITE AND HAVE NEVER GOTTEN A REPLY, *TR

Mileage: 1,628

THE AREA AROUND THE FRONT OF THE SEAT AND BODYWORK GETS EXTREMELY HOT, HOT ENOUGH THAT LEGS/THIGHS BECOME VERY UNCOMFORTABLE AND HAVE TO RAISE OFF OF SEAT WHENEVER STOPPED TO GET SOME RELIEF FROM THE HEAT. THIS IS ESPECIALLY APPARENT WHEN RIDING IN WARMER WEATHER AND SITTING AT STOPLIGHTS AND STOP AND GO TRAFFIC. THE HOT AIR COMING OUT OF THE LOWER RIGHT SIDE DIRECTLY ONTO RIGHT LEG AND BOOT IS ALSO BECOMES VERY UNCOMFORTABLE. THE STORAGE BOX IN FRONT OF THE SEAT IS BASICALLY UNUSABLE DUE TO THE HEAT AND THE BODYWORK ALSO BECOMES EXTREMELY HOT AT TIMES. *TR

Mileage: 2,387

THIS IS A NEW BIKE WITH EXTREMELY HEAT ISSUES FROM THE ENGINE. AT FIRST DEALER APPOINTMENT IT MEASURED 140 DEGREES AFTER I PARKED 10 MINUTES. WHILE RIDING EXTREMELY HOT AIR BLOWS AT YOUR BOTTOM RIGHT LEG AND TRAVELS UP THE SEAT. THE WHOLE RIGHT SIDE PANEL THE FRONT OF THE SEAT AND TANK MAKES IT TO HOT TO THE TOUCH. PIPES WERE WRAPPED FROM DEALER WHICH DID NOT TAKE CARE OF PROBLEM. I WAS TOLD BRP WILL DO NO FURTHER SOLUTIONS REGARDING THE HEAT ISSUES. I AM CONCERNED ABOUT THE TANK GETTING TO HOT TO THE TOUCH. *TR

Mileage: 601

THIS MACHINE IS JUST TOO HOT TO RIDE AND BE SAFE. REPORTS OF OTHER UNITS CATCHING ON FIRE. EMAILED BRP BUT NEVER GOT A RESPONSE. I'VE HAD TO GET OFF AND TURN IT OFF TO LET IT COOL DOWN. ENDED UP SELLING IT AT A HUGE LOSS. *TR

Mileage: 3,000

THIS IS MY 3RD SPYDER. ALTHOUGH I AM HAPPY WITH IT, IT DOES EMIT HEAT IN WHICH SOMETIMES ON HOT SUMMER AND HUMID DAYS IS NOT AN ACCEPTABLE FEELING. THIS MODEL YEAR EMITS MORE HEAT THAN PREVIOUS YEAR MODELS. *TR

MY SPYDER GET SO HOT THAT IT IS NOT BEARABLE TO RIDE, EXTREME HEAT FROM THE ENGINE COMPARTMENT SENDS EXTREME HEAT TO MY LEGS AND HEAT COMING FROM THE SEAT. I HAVE SEEN REPORTS ON THIS PARTICULAR SPYDER CATCHING FIRE WHICH MAKE ME VERY UNCOMFORTABLE TO RIDE. BRP IN CANADA NEEDS TO RECALL THEIR SPYDER'S IN REGARDS TO THIS PROBLEM. I CURRENTLY HAVE ABOUT 1,500 MILES. I HAVE HAD PROBLEMS SINCE MARCH 2013 TO PRESENT. THE HEAT ALSO CAUSES THE GASOLINE IN THE TANK TO BOIL WHICH IS A HAZARD ALSO. *TR

Mileage: 5,000

VEHICLE GETS EXTREMELY HOT TO THE TOUCH ON THE RIGHT SIDE , BLOWS VERY HOT AIR ONTO RIGHT LEG. HEAT TRAVELS UP TO LEG AND UNDER SEAT RIGHT WHERE YOU SIT ON TOP OF TANK. MIDDLE CLOVE DEPARTMENT TO HOT TO TOUCH AS WELL TANK UNDERNEATH. DEALER TOOK COMPLAIN AND WRAPPED PIPES AND INSTALLED HEATSHIELD WHICH DID NOT TAKE CARE OF PROBLEM AND REDIRECTED THE HEAT COMING OUT ON A DIFFERENT ANGLE. BRP REFUSES TO COOPERATE ON ANY MORE SOLUTIONS AND FIX THE PROBLEM. I AM CONCERND THAT THE MOTOR WILL OVER HEAT SINCE THE AIRFLOW AT THE ENGINE HAS REALY NO ESCAPE. *TR

Mileage: 20

THIS MOTORCYCLE CONTINUALLY HAS A VERY HEAVY FUEL SMELL AFTER RIDING. THE HEAT GENERATED BY THE ENGINE IS EXTREME AND CAUSES MY RIGHT FOOT TO BE VERY HOT. WHEN I ARRIVE AT HOME I HAVE TO USE A FAN IN THE GARAGE TO GET RID OF THE FUEL SMELL. BRP/DEALER CLAIMS THIS IS NORMAL. I AM AFRAID THAT THERE WILL BE A FIRE SIMILAR TO THE ONE THAT HAPPENED THIS PAST SATURDAY, 26 JULY 2014 HERE IN CALIFORNIA. *JS

Mileage: 11,000

I WAS OUT FOR A RIDE AND NOTICED THE HEAT ON MY THIGH AND LEG I REPORTED IT TO THE DEALER, AND THEY SAID IT WAS A RECALL ISSUE AND THEY APPLIED A THIN STRIP OF HEAT TAPE UNDER GLOVE BOX. SO ON JUNE 10TH I NOTICED IT WAS GETTING EVEN HOTTER SO I GOT A THERMOSTAT AND PUT IN GLOVE BOX AND RODE OVER TO THE DEALER, A 20 MINUTE RIDE, THE THERMOSTAT REGISTERED 155 THIS AREA WAS SO HOT IT MELTED MY SEAT AND BURN MY THIGH. SO ON JUNE 23RD I LEFT IT AT DEALERS AND BRP INFORMED THEM TO APPLY MORE HEAT TAPE AND REPLACE THE SEAT,WHICH WAS DONE. I PICKED IT UP ON JULY 9 THE AND RODE IT HOME AND GOT BURNED AND IT REGISTERED 150 AFTER A 20 MINUTE RIDE AND THE OUTSIDE TEMP WAS MID 70'S. SEEMS LIKE HEAT LIKE THAT OVER A GAS TANK IS ASKING FOR TROUBLE BEFORE SOMEONE GET BLOWN UP. BRP HAS NO ANSWERS FOR US, PLEASE INVESTIGATE WHY NOT AND SAVE US FROM INJURIES. *TR

Mileage: 220

I ROAD MY RT FROM MARYLAND TO MYRTLE BEACH SC. ON THE WAY THERE THE BIKE WAS HEATING UP ON THE RIGHT SIDE BURNING MY PASSENGER AND MY LEG. ONCE I GOT THERE I TOOK THE BIKE TO A BRP DEALERSHIP TO GET AN OIL CHANGE AND HAD TO PAY $335. I ASKED THEM TO DO A CHECK UP BECAUSE MY BREAKS WERE SQEAKING AND THERE WAS HOT AIR COMING FROM THE RIGHT SIDE AND THAT THE CONTROLS FOR THE PASSENGER DO NOT WORK . WHEN I WENT TO PICK MY BIKE UP THEY TOLD ME I HAD SEVERAL RECALLS ON MY BIKE, AND THE SWITCH WAS BAD. I SAID I JUST GOT IT MAY 17, 2014 AND THEY SAID NONE OF THE RECALLS WERE DONE. THE DEALERSHIP DID NOT TELL ME THERE WERE RECALLS ON THE RT. I THINK THEY SHOULD BE HELD RESPONSIBLE TO TELL CUSTOMERS THAT THERE ARE RECALLS. I DID NOT RECEIVE AND RECALL NOTIFICATION IN THE MAIL EITHER. I DID CONTACT A BRP DEALERSHIP AND THEY TOLD ME THEY WILL HAVE TO KEEP MY BIKE FOR 1 - 2 WEEKS TO FIND OUT WHAT THE RECALLS ARE. E ARE 25 COMPLAINTS AND NO INVESTIGATIONS I THINK NHTSA NEED TO DO SOME INVESTIGATIONS BEFORE SOMEONE GETS BADLY INJURED. EVERYTHING I HAVE READ HAD BASICALLY HAPPENED TO ME TOO. PLEASE HELP US TO GET THIS PROBLEM SOLVED. *TR

Mileage: 500

HOT AIR FROM THE RADIATOR BLOWING ON THE RIGHT LEG REACHES 140 DEGREES FAHRENHEIT AT THE ANKLE. THE TEMPERATURE WAS MONITORED USING A DIGITAL THERMOMETER WITH A REMOTE READOUT. THIS TEMPERATURE READING WAS REPEATED ON SUBSEQUENT TESTS. THE HEAT MAKES THE BIKE VIRTUALLY UNRIDEABLE DURING THE SUMMER WITHOUT TAKING THE RISK OF BURNS TO THE RIGHT LEG. THE MANUFACTURER HAS REFUSED TO TALK WITH ME ABOUT THIS ISSUE. *TR

Mileage: 100

THIS VEHICLE HAS AN EXTREMELY DANGEROUS HEAT PROBLEM. HEAT BUILDS UP UNDER THE FIBERGLASS PANELS WHICH RESULTS IN THE GAS CAP BECOMING TOO HOT TO TOUCH WITH YOUR BARE HAND, AND GASOLINE BOILING IN THE TANK. ALSO, THE RADIATOR FAN BLOWS VERY HOT AIR ON MY RIGHT FOOT WHICH IS VERY UNCOMFORTABLE. ADDITIONALLY, I CAN SMELL GAS FUMES WHEN RIDING, AND THE FUMES ARE OVERPOWERING WHEN PARKING THE BIKE AFTER RIDING. I LEAVE THE BIKE OUTSIDE MY GARAGE UNTIL THE FUMES DISSIPATE, AS I FEEL THAT IT DANGEROUS TO PARK IN THE GARAGE WITH THE OVERPOWERING GAS FUMES. BRP AND THE DEALERS ARE AWARE OF THESE PROBLEMS, AND CAN OFFER NO FIX FOR THEM. THESE PROBLEMS HAVE BEEN ADDRESSED IN THE 2014 MODELS, SO OBVIOUSLY THERE IS A WAY TO REMEDY THEM. WHENEVER I AM ASKED HOW I LIKE THE BIKE, I TELL PEOPLE THAT THE GAS MILEAGE IS HORRENDOUS, THE HEAT PROBLEM IS UNCOMFORTABLE, AND THE GAS FUMES ARE UNBEARABLE AND DANGEROUS. I ADVISE THEM NOT TO BUY THIS VEHICLE. *TR

Mileage: 2,000

VEHICLE HAS NO MEANS OF RELEASING HEAT TRAPPED UNDER PLASTIC PANELING WHEN AT LOW SPEEDS OR WHEN VEHICLE IS STOPPED. HAD TWO BREAKDOWNS AT STOP AND GO SITUATIONS WHERE THE VEHICLE WAS NOT MOVING ALLOWING HEAT TO ESCAPE. THIS AFFECTED OTHER COMPONENTS (EVAPORATOR CANISTER...ECT) WHICH CAUSE FAILURE AND RENDERS THE VEHICLE UNSAFE. HAVING CONVERSATIONS WITH BRP I KNOW THEY ARE AWARE AND HAVE NO SOLUTION. THIS IS NOT AN ISOLATED INCIDENT BRP NOW HAS COME OUT WITH THE 2014 MODEL AND CLEARLY STATES IN ITS ADVERTISING CAMPAIGN THAT "ON OUR NEW MODELS WE ADDRESS THE HEAT ISSUE" SO YOU KNOW YOU HAVE IT... AND YOU FIXED IT ON THE NEWER MODELS WHILE BEHIND YOU LIES CUSTOMERS WITH OLDER MODELS THAT ARE CLEARLY DEFECTIVE AND QUITE UNSAFE... I SAY THIS NOT BY WHAT I'VE READ, BUT ONLY ON MY PERSONAL EXPERIENCE, THE MACHINE HAS HEAT ISSUES. *TR

Mileage: 1,200

THE RIGHT SIDE PANEL BY THE SEAT GETS EXCESSIVELY HOT TO THE POINT YOU CANNOT LAY YOUR HAND ON IT, THE SCREWS WILL CAUSE A BURN IF TOUCHED. THE EXCESSIVE HEAT CAUSED A 1ST DEGREE BURN TO THE THIGH. THE GAS CAP GETS SO HOT IT WILL BURN YOUR FINGERS UNLESS YOU WEAR GLOVES AND THE GAS IN THE TANK GET NEAR BOILING FROM THE EXCESS HEAT. I DO BELIEVE THIS IS A SERIOUS ISSUE, GASOLINE CAN BE COME EXPLOSIVE IF IT GET TOO HOT. I HAVE CONTACTED THE DEALER AND BRP, ABOUT THE PROBLEM AND WAS TOLD IT IS JUST CHARACTERISTIC. I HAVE RECEIVED A 1ST DEGREE BURN TWICE AND THE BOILING GASOLINE ISSUE JUST IS NOT AN ACCEPTABLE ANSWER. IT IS A SERIOUS SAFETY ISSUE. I WOULD HOPE THAT ACTION TO CORRECT THE PROBLEM WILL NOT WAIT UNTIL THERE IS A SERIOUS INJURY OF DEATH. I BELIEVE IMMEDIATE ACTION SHOULD BE TAKEN TO CORRECT THE EXCESSIVE HEAT PROBLEM AND BRP WELL AWARE OF THE ISSUE BUT HAS CHOSEN TO IGNORE IT UNTIL THERE IS OFFICIAL ACTION TO CORRECT THE PROBLEM. *TR

Mileage: 975

THE PANELS ON THE RIGHT HAND SIDE GET EXCESSIVELY HOT, TO THE POINT OF BURNING MY INNER RIGHT THIGH & RIGHT FOOT. THE EXHAUST IS TOO CLOSE TO THE PANELS AND THE PANELS AND SCREWS GET HOT TO THE POINT YOU CANNOT TOUCH THEM WITHOUT BEING BURNED. AND CANNOT RIDE WITH YOUR LEGS AGAINST THE BODY. I HAVE REPORTED THIS ISSUE TO THE DEALER AND WAS TOLD THIS IS "NORMAL".

Mileage: 25

MY MOTORCYCLE SUFFERS FROM EXCESSIVE HEAT BUILD UP DUE TO CHANGES MADE TO THE 2013 MODEL INCLUDING THE MASTER CYLINDER AND GAS CAP. SOMETIMES THE GAS CAP IS TOO HOT TO TOUCH AND WHEN OPENED IT IS BOILING GASOLINE. YOU CAN BARELY TOUCH THE FRONT OF THE SEAT DUE TO ELIMINATION OF HEAT INSULATION MATERIAL IN FRONT OF IT FOR THIS MODEL YEAR. I HAVE SEEN AND SUSPECT THE MASTER CYLINDER IS STARTING TO MELT ON MANY 2013 RT & ST MODELS. BRP HAS ACKNOWLEDGED THIS IN A CANADA RECALL. AS SOME OF YOU MIGHT ALREADY KNOW, TODAY TRANSPORT CANADA PUBLISHED A RECALL NOTIFICATION FROM BRP ON ALL 2013 CAN-AM SPYDER RT AND ST SERIES ROADSTERS. BRP HAS PROPOSED A SOLUTION TO THE ISSUE RAISED BY THE RECALL; THIS RECALL NOTIFICATION HAS BEEN APPROVED FOR AFFECTED MOTORCYCLES WITHIN CANADA BY TRANSPORT CANADA. AGENCIES IN OTHER COUNTRIES ARE ALSO REVIEWING THE SOLUTION FOR THEIR OWN JURISDICTIONS, INCLUDING THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) IN THE UNITED STATES. ALL OF THE DETAILS ON THE ISSUE, THE RECALL AND THE SOLUTION ARE BEING COMMUNICATED TO BRP'S CANADIAN DEALERS AS WELL AS TO ALL CANADIAN OWNERS OF A VEHICLE THAT IS AFFECTED BY TRANSPORT CANADA'S. AS SOON AS WE HAVE THE GREEN LIGHT FROM AGENCIES IN OTHER COUNTRIES, WE WILL RELEASE THE SAME INFORMATION TO THE DEALER NETWORK AND OWNERS OF AFFECTED VEHICLES WITHIN THOSE COUNTRIES, INCLUDING NHTSA IN THE UNITED STATES.

Mileage: 1,000

BRP CANADA HAS ISSUED A RECALL ON ALL CANADIAN SPYDER RT'S FOR HEAT RELATED MELTING OF THE SECONDARY MASTER CYLINDER PLASTIC TOP WHICH COULD CAUSE FIRE. I JUST RETURNED FROM A 300 MILE TRIP TODAY ON MY 2013 CAN-AM SPYDER RT-S AND HEARD ABOUT THE CANADIAN RECALL. I CHECKED THE SECONDARY MASTER CYLINDER AND DISCOVERED THE PLASTIC TOP PIECE HAD BEGUN TO MELT. IT IS VERY CLOSE TO THE EXHAUST PIPE. I HAVE COMPLAINED TO THE DEALER THAT THERE WAS A HEAT ISSUES AND WAS TOLD THE HEAT WAS NORMAL. I HAVE ALSO HAD TO USE A GLOVE TO REMOVE THE GAS CAP AS IT WILL BURN YOUR FINGERS AFTER RIDING FOR ANY DISTANCE. YOU CAN ALSO HEAR THE GAS BOILING IN THE TANK WHEN REFUELING. I HAVE PHOTOS OF THE MELTED PLASTIC TOP OF THE MASTER CYLINDER. PLEASE DO A RECALL ON THESE CAN-AM SPYDERS. BRP SAYS IT IS UP TO NHTSA TO DO THE RECALL. THE DEALER WILL NOT COVER THIS UNDER WARRANTY AT THIS TIME. I WAS TOLD NOT TO RIDE OR RIDE AT OWN RISK. I HAVE HEARD OF SEVERAL CAN-AM SPYDERS ERUPTING INTO FLAMES FOR UNKNOW REASONS. *JS

Mileage: 2,000