This Problem Across All Years
Vehicle arrived with windshield chip, transport company provided proof happened before transport. Brake failure on first use after delivery. Reduced-propulsion warning triggered. Both passenger-side door locks failed. Center-console power and data failed (replacements pending). Rear and passenger-side cameras blurry (replacements pending). GM manufacturer buyback vehicle. Safety defect occurred immediately after delivery. Vehicle down more than 50 days. Dealer delayed title paperwork to Tennessee for 44 days and delayed delivering finance contract/payment instructions to buyers for 50 days. GM Financial issued late notices before contract was delivered. Dealer has not responded to reimbursement deadline. Safety and delivery failures created unsafe condition and administrative harm.
Vehicle arrived with windshield chip, transport company provided proof happened before transport. Brake failure on first use after delivery. Reduced-propulsion warning triggered. Both passenger-side door locks failed. Center-console power and data failed (replacements pending). Rear and passenger-side cameras blurry (replacements pending). GM manufacturer buyback vehicle. Safety defect occurred immediately after delivery. Vehicle down more than 50 days. Dealer delayed title paperwork to Tennessee for 44 days and delayed delivering finance contract/payment instructions to buyers for 50 days. GM Financial issued late notices before contract was delivered. Dealer has not responded to reimbursement deadline. Safety and delivery failures created unsafe condition and administrative harm.
On 4/5/2025 I was driving at 35mph and the steering wheel began to violently shimmy. The vehicle became difficult to steer putting safety at risk. Slowed to 25mph but shimmy did not stop. ABS warning light came on and Stabilitrak warning light came on and warning that steering was being was being automatically reduced. Driving became very difficult. Stopped and had car towed to Chevrolet. Car was diagnosed with broken left and right front axle anticlick washers and metallic debri found on sensors. Both front axle anticlick washers were replaced, sensors cleaned, and codes cleared, and brake fluid had to be flushed. Cost $850 to repair. Subsequently found out another friend had same thing happen to their 2018 Bolt. This was a safety issue and put us at risk while driving.
On 4/5/2025 I was driving at 35mph and the steering wheel began to violently shimmy. The vehicle became difficult to steer putting safety at risk. Slowed to 25mph but shimmy did not stop. ABS warning light came on and Stabilitrak warning light came on and warning that steering was being was being automatically reduced. Driving became very difficult. Stopped and had car towed to Chevrolet. Car was diagnosed with broken left and right front axle anticlick washers and metallic debri found on sensors. Both front axle anticlick washers were replaced, sensors cleaned, and codes cleared, and brake fluid had to be flushed. Cost $850 to repair. Subsequently found out another friend had same thing happen to their 2018 Bolt. This was a safety issue and put us at risk while driving.
Brake modules not working properly and need reprogramming. GM not honoring their buyback warranty.
Brake modules not working properly and need reprogramming. GM not honoring their buyback warranty.
While driving at highway speed, the steering wheel started to shimmy, making the vehicle difficult to control. On inspection, the front wheel was very hot. The mechanic advised that the front caliper is defective. The Bolt EV is equipped with a regenerative braking system that stops the vehicle. This vehicle has been stopped by using this regenerative braking system about 99% of the time. The mechanic advised that since the caliper has not been used, it has started freezing, causing the brakes to continue to be applied after they are used. This causes the wheel to heat during driving, and at continuous highway speeds, causes the steering wheel to shimmy and makes the vehicle difficult to control. The vehicle has less than 10,000 miles. The brake dragging also causes reduced acceleration. The unexpected reduced acceleration can cause a hazard in the event of passing where the vehicle is unable to pass and return to the driving lane before oncoming vehicles arrive. There were no warning lamps, and the part has not been removed from the vehicle at this writing. It is not known whether the mechanic reproduced this fault. The fault has been intermittent, but has occurred on more than one occasion.
While driving at highway speed, the steering wheel started to shimmy, making the vehicle difficult to control. On inspection, the front wheel was very hot. The mechanic advised that the front caliper is defective. The Bolt EV is equipped with a regenerative braking system that stops the vehicle. This vehicle has been stopped by using this regenerative braking system about 99% of the time. The mechanic advised that since the caliper has not been used, it has started freezing, causing the brakes to continue to be applied after they are used. This causes the wheel to heat during driving, and at continuous highway speeds, causes the steering wheel to shimmy and makes the vehicle difficult to control. The vehicle has less than 10,000 miles. The brake dragging also causes reduced acceleration. The unexpected reduced acceleration can cause a hazard in the event of passing where the vehicle is unable to pass and return to the driving lane before oncoming vehicles arrive. There were no warning lamps, and the part has not been removed from the vehicle at this writing. It is not known whether the mechanic reproduced this fault. The fault has been intermittent, but has occurred on more than one occasion.
INTERMITTENT EXTREME VIBRATIONS OF THE VEHICLE WHEN DRIVING. THIS ISSUE COME AND GOES WITH OUT ANY WARNING LIGHTS DISPLAYING. THE VIBRATIONS ARE SO EXTREME THAT I MUST SLOW DOWN TO 30 MILES PER HOUR OUR LESS TO MAINTAIN CONTROLL. I TOOK THE VEHICLE TO THE LOCAL DEALERSHIP AND LEFT IT FOR A EWEEK AND THEY COULD NEVER REPRODUCE THE PROBLEM. THE PROBLEM HAS OCCURED SEVERAL TIMES SINCE TAKING THE VEHICLE TO THE DEALERSHIP EARLY 2022. IF YOU DRIVE THE VEHICLE LONG ENOUGH IT WILL USUALLY STOP THE VIBRATIONS AND IF YOU TURN OFF THE VEHICLE AND LET SIT OVERNIGHT; THE VIBRATIONS ARE NOT PRESENT WHEN YOU DRIVE THE VEHICLE THE NEXT MORNING. IF YOU TURN OFF THE VEHICLE FOR JUST A FEW MINUTES THE VIBRATIONS ARE STILL THERE, BUT MNAY STOP IF YOU CAN DRIVE IT LOGER. I CAN NOT TELL IF THE PROBLEM IS THE BRAKES OR THE DRIVE TRAIN. I DO NOT KNOW IF THE VEHICLE MAY JUST LOCK UP IN THE MIDDLE OF TRAFFIC.
INTERMITTENT EXTREME VIBRATIONS OF THE VEHICLE WHEN DRIVING. THIS ISSUE COME AND GOES WITH OUT ANY WARNING LIGHTS DISPLAYING. THE VIBRATIONS ARE SO EXTREME THAT I MUST SLOW DOWN TO 30 MILES PER HOUR OUR LESS TO MAINTAIN CONTROLL. I TOOK THE VEHICLE TO THE LOCAL DEALERSHIP AND LEFT IT FOR A EWEEK AND THEY COULD NEVER REPRODUCE THE PROBLEM. THE PROBLEM HAS OCCURED SEVERAL TIMES SINCE TAKING THE VEHICLE TO THE DEALERSHIP EARLY 2022. IF YOU DRIVE THE VEHICLE LONG ENOUGH IT WILL USUALLY STOP THE VIBRATIONS AND IF YOU TURN OFF THE VEHICLE AND LET SIT OVERNIGHT; THE VIBRATIONS ARE NOT PRESENT WHEN YOU DRIVE THE VEHICLE THE NEXT MORNING. IF YOU TURN OFF THE VEHICLE FOR JUST A FEW MINUTES THE VIBRATIONS ARE STILL THERE, BUT MNAY STOP IF YOU CAN DRIVE IT LOGER. I CAN NOT TELL IF THE PROBLEM IS THE BRAKES OR THE DRIVE TRAIN. I DO NOT KNOW IF THE VEHICLE MAY JUST LOCK UP IN THE MIDDLE OF TRAFFIC.
AT 25,000 MILES MY BRAKE PADS ARE CRUMBLING AND THE ROTOR ARE SCORED AND POCK MARKED .. I DRIVE THE CAR IN L MODE EXCLUSIVELY AND I DON'T USE THE BRAKES. ED SHUTS CHEVY CADILLAC SAYS THE BRAKES ARE WARRANTED. I SAY THERE IS A PROBLEM WITH THE BRAKE SYSTEM. THEY SHOULD NOT WEAR OUT OR CRUMBLE IF I DON'T USE THEM ON A 2 YEAR OLD CAR.
AT 25,000 MILES MY BRAKE PADS ARE CRUMBLING AND THE ROTOR ARE SCORED AND POCK MARKED .. I DRIVE THE CAR IN L MODE EXCLUSIVELY AND I DON'T USE THE BRAKES. ED SHUTS CHEVY CADILLAC SAYS THE BRAKES ARE WARRANTED. I SAY THERE IS A PROBLEM WITH THE BRAKE SYSTEM. THEY SHOULD NOT WEAR OUT OR CRUMBLE IF I DON'T USE THEM ON A 2 YEAR OLD CAR.
THE BOLT EV HAS A STEERING-WHEEL MOUNTED REGENERATIVE BREAKING PADDLE, WHICH APPLIES THE REGENERATIVE BREAKING, SLOWING THE VEHICLE. HOWEVER, WHEN THE BATTERY IS FULLY CHARGED, THIS PADDLE DOES NOTHING, WHICH HAS RESULTED IN SOME NEAR MISSES. A WARNING INDICATOR SHOULD BE PRESENT, OR THE DOCUMENTATION SHOULD SUGGEST ENABLING "HILLTOP RESERVE" TO PREVENT THIS FROM OCCURRING. I HAVE REPORTED THIS TO CHEVY, BUT NO RESPONSES WERE RECEIVED.
THE BOLT EV HAS A STEERING-WHEEL MOUNTED REGENERATIVE BREAKING PADDLE, WHICH APPLIES THE REGENERATIVE BREAKING, SLOWING THE VEHICLE. HOWEVER, WHEN THE BATTERY IS FULLY CHARGED, THIS PADDLE DOES NOTHING, WHICH HAS RESULTED IN SOME NEAR MISSES. A WARNING INDICATOR SHOULD BE PRESENT, OR THE DOCUMENTATION SHOULD SUGGEST ENABLING "HILLTOP RESERVE" TO PREVENT THIS FROM OCCURRING. I HAVE REPORTED THIS TO CHEVY, BUT NO RESPONSES WERE RECEIVED.