2001 CHEVROLET CAVALIER Electrical System Problems

TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE GEAR SHIFT WAS DIFFICULT TO MOVE AND THE LEVER BECAME STUCK. OCCASIONALLY, THE KEY BECAME STUCK IN THE IGNITION AND THE GEAR SHIFT WOULD NOT GO INTO GEAR. ALSO, THE HOOD WAS HOT, THE ENGINE OVERHEATED, AND THE VEHICLE EXPERIENCED ELECTRICAL FAILURES. THERE WERE ALSO MULTIPLE UNKNOWN WARNING INDICATORS ILLUMINATED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT SCHEDULED A DIAGNOSTIC APPOINTMENT WITH AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 138,000.

Mileage: 138,000

TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. UPON EXITING THE VEHICLE AND CLOSING THE DOORS, THE INTERIOR DOME LIGHT REMAINED ILLUMINATED. THE CONTACT ALSO NOTICED A BURNING ODOR COMING FROM THE LIGHT BULB WIRING IN THE ROOF. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. *LN

Mileage: 100,000

IGNITION SWITCH AND THE IGNITION LOCK CYLINDER MALFUNCTIONED IN 2009, ROUGHLY FIVE YEARS AFTER GM'S RECALL. THE ORIGINAL OWNER OF THE VEHICLE TOOK ADVANTAGE OF THE IGNITION SWITCH'S SERVICE. IN ADDITION TO THE RECALL, GM INSTALLED AN IGNITION WIRING HARNESS. BACK IN 2009, THE VEHICLE'S IGNITION WOULD OVERTURN, AND THEN, THE ENGINE WOULD AUTOMATICALLY SHUT-OFF. TO REPAIR THE PROBLEM, BOTH THE IGNITION SWITCH AND LOCK CYLINDER WERE REPLACED AT A COST OF $492. IN 2014, THE IGNITION SWITCH MALFUNCTIONS. THIS TIME, IT APPEARS THE IGNITION LOCK CYLINDER TO BE WORKING PROPERLY. THE IGNITION SWITCH BECAME DAMAGE DUE TO CURRENT FLOW TO THE IGNITION WHEN HOLDING THE KEY IN THE START POSITION. THE HEAT MELTED THE INTERNAL SWITCH. I HAD NOT KNOWN IN 2014 THAT THE PROBLEM WAS THE IGNITION SWITCH. IN THE SAME YEAR, HOWEVER, GM RECALLED A MASSIVE NUMBER OF VEHICLES FOR IGNITION SWITCH DEFECT. CHEVROLET CAVALIER WAS NOT ON THE LIST. TODAY, IT COSTS $180.00, EXCLUDING TAXES AND FEES, TO GET THE IGNITION SWITCH INSTALLED BY A CHEVROLET TECHNICIAN. A LOCKSMITH RATE STARTS AT $90 BUT DOES NOT INCLUDE SERVICE FEE, AND LABOR. BASED ON FEW ONLINE REPORTS, THE INSTALLATION TAKES A MINIMUM OF 20 MINUTES. WOULD INSTALLED THE IGNITION SWITCH MYSELF BUT CANNOT LOCATE STEP BY STEP INSTRUCTIONS. ALL THE CHEVROLET MANUALS OWNED DO NOT PROVIDE INSTRUCTIONS ON REPLACING THE IGNITION SWITCH. IF I DO INSTALL THE IGNITION SWITCH, I AM UNSURE IF THE VEHICLE'S COMPUTER WILL NEED REPROGRAMMING. A FEW REPORTS MADE REFERENCE TO REPROGRAMMING THE VEHICLE'S COMPUTER FOLLOWING THE CHANGING OF THE IGNITION SWITCH. SOLUTION: I THINK GM NEEDS TO ADD CHEVROLET CAVALIER TO THE "RECALL" LIST. THE ALTERNATIVE, IGNITION WIRING HARNESS DOES NOT SUPPORT THE ELECTRICAL SYSTEM ENTIRELY WHEN THE CHARGING SYSTEM LIGHT REMAINS ON THE DASHBOARD.

MY VEHICLE WAS IN AN ACCIDENT ON 2/15/2012. I HAD MY VEHICLE TOWED TO GREENLEAF COLLISION INC., LOCATED AT 5100 A. KENTUCKY AVENUE, NASHVILLE,TN 37209,615.320.7818, OWNER [XXX]. ON 2/16/2012 MY VEHICLE WAS TOWED IN TO GREENLEAF COLLISION INC, FOR REPAIRS. ONCE I FOUND OUT FROM GREENLEAF COLLISION, INC. THAT MY CHEVROLET CAVALIER 2001 WAS ON RECALL LIST TO BE REPAIRED FOR "IGNITION SWITCH FAILURE", GENERAL MOTORS. THE GREENLEAF COLLISION INC., HAD MY CHEVROLET CAVALIER 2001, TOWED TO FREELAND CHEVROLET 5333 HICKORY HOLLOW PARKWAY, ANTIOCH, TN. 37013, 615.731.3020. MY CHEVROLET CAVALIER, IS IN THE RECALL FOR "IGNITION SWITCH FAILURE", ONCE MY VEHICLE WAS SENT OVER TO FREELAND CHEVROLET FOR REPAIR OF THE "IGNITION SWITCH FAILURE", TO MY UNDERSTANDING BY GREENLEAF COLLISION INC. I WAS INFORMATED THAT MY VEHICLE THE CHEVROLET CAVALIER, WAS NOT REPAIRED FOR "IGNITION SWITCH FAILURE", ON 3/8/2012 I WAS IN AN ACCIDENT WERE MY CHEVROLET CAVALIER," IGNITION SWITCH FAILURE" . MY WAS TOTALED OUT, THE VEHICLE JUST CUT OFF IN THE MIDDLE OF THE STREET, AND WE WERE HIRE AND TOTALED OUT. MY "IGNITION SWITCH FAILURE" WITH MY CHEVROLET CAVALIER TOTALED OUT, AND WAS NOT REPAIRED, AT FREELAND CHEVROLET ON 3/7/2012 THE" IGNITION SWITCH", WAS NOT REPLACE/NOR REPAIRED. MY VEHICLE WAS TOTALED OUT, AND I WAS LEFT WITHOUT VEHICLE COMPENSATION, AND I WAS INJURED, AND MY GRANDCHILDREN WERE INJURED ALSO. I HAVE AN CLAIM NUMBER WITH GENERAL MOTORS:[XXX]. WHO HAS A THIRD PARTY COMPANY NAMED ESIS/GM CENTRAL CLAIMS UNIT P.O. BOX 300, DETROIT, MI 48265-3000. 800.888.0164. ESIS/GM CENTRAL CLAIMS UNIT HAS NOT PROCESSED MY CLAIM WITH THE" IGNITION SWITCH FAILURE", ON THE CHEVROLET CAVALIER. I REQUEST HELP IN RECEIVING COMPENSATION ON MY TOTALED OUT VEHICLE. YOUR URGENT ASSISTANCE IS GREATLY NEED. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 188,288

TL* THE CONTACT OWNED A 2001 CHEVROLET CAVALIER. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. AS A RESULT, ANOTHER VEHICLE CRASHED INTO THE DRIVER SIDE OF THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED A BACK INJURY, THE REAR DRIVER SIDE PASSENGER SUSTAINED BODY AND HEAD INJURIES, THE REAR MIDDLE PASSENGER SUSTAINED A HEAD INJURY AND THE REAR MIDDLE PASSENGER SUSTAINED BODY INJURIES. THE INJURIES REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. IN ADDITION, THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE IGNITION KEY WAS SLIPPING IN AND OUT OF THE IGNITION. AS A RESULT, THE INTERIOR LIGHT WAS TURNING ON AND OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 13,000.

Mileage: 13,000

MY KEY CAME OUT OF THE IGNITION WHILE THE CAR WAS STILL RUNNING AND IN THE ON POSITION, AND ALSO ANOTHER TIME THE CAR KEY TURNED OFF BY ITSELF AND I LOST POWER TO THE VEHICLE AND MY BRAKES LOCKED AND ALMOST CAUSED ME TO GET INTO A CRASH. *TR

Mileage: 92,000

KEY CAN BE REMOVED FROM IGNITION WHILE CAR IS IN GEAR AND IN PARK. AND CANNOT BE PUT BACK IN DURNING VEHICLE RUNNING

Mileage: 220,000

TL* THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE KEY WAS DIFFICULT TO TURN WHEN INSERTED INTO THE IGNITION SWITCH, PREVENTING THE VEHICLE FROM BEING STARTED. THE VEHICLE WAS STARTED AFTER THE CONTACT ATTEMPTED TO TURN THE KEY TO THE START POSITION SEVERAL TIMES. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE IGNITION SWITCH. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 85,610 AND THE CURRENT MILEAGE WAS 85,615.

Mileage: 85,610

UPON DRIVING VEHICLE AT LOW SPEEDS 20-30 MPH WITH FRONT AND REAR WINDOW DEFROSTER ON,IT BECAME MORE,AND MORE EVIDENT OF A POSSIBLE FIRE. FIRST THERE WAS AN INCREASING BURNING SMELL FOLLOWED BY SMOKE. A CONNECTOR ON THE DRIVERS SIDE KICK PANEL HAS MELTED BEING SO CLOSE TO THE CARPET ITS POSSIBLE THAT IT BEING WINTER MOISTURE FROM MELTED SNOW SOMEHOW MAY HAVE CAUSED THIS TO HAPPEN, A SEARCH ON GOOGLE SEEMS TO PULL MULTIPLE CARS WITH THIS SAME PROBLEM. ALSO I WANT TO NOTE THAT I WAS NOT ABLE TO TURN OFF MY REAR DEFROSTED WITH THE REAR DEFROSTER SWITCH, I HAD TO PULL THE 30 AMP FUSE THAT STILL HAD A COMPLETE CIRCUIT IN IT! *TR

Mileage: 130,000

I WAS DRIVING DOWN THE FREE WAY AND ALL OF A SUDDEN THE CAR LOST ALL ACCELERATION POWER. GOT IT TO THE SIDE OF THE ROAD AND TRIED TO RESTART THE CAR. IT TRIES BUT WON'T START. ALL POWER IS WORKING AND STARTER AND ALTERNATOR ARE TRYING TO WORK. *TR

THE DEFROST WOULDN'T WORK WHEN REALLY RAINY OR COLD AND THIS STARTED IN WINTER OF 2009. IN SUMMER OF 2010 THE AC WORKED ONLY WHEN FAN WAS ON MED OR HIGH, BUT FINALLY ONLY ON HIGH. THESE WERE ELECTRICAL WIRING PROBLEMS: AC DUE TO BLOWER RESISTOR BURNED OUT AND DEFROST CAUSED BY A RESISTOR BURNED OUT. AC STARTED TO SMELL LIKE SOMETHING ELECTRICAL WAS BURNING. IF THIS WASN'T FIXED ANY SOONER COULD HAVE CAUSED FIRE I'M SURE. NOW I HAVE TO SEE WHAT NEEDS TO BE FIXED NOW THAT I HAVE SERVICE ENGINE CHECK LIGHT ON. WITH THESE ELECTRICAL ISSUES HAD NO SERVICE ENGINE CHECK LIGHT COME ON. O2 SENSOR REPLACED @ 68,000 AND CATALYTIC CONVERTER CHANGED @ 56,000 AND THE RECALL FOR THIS VEHICLE REPLACED. *TR

Mileage: 90,000

WHENEVER THE STEERING WHEEL IS TURNED A "CLUNK" CAN BE HEARD AND FELT. THIS HAPPENED BACK IN ABOUT 2003 AND STILL CONTINUES TO THIS DAY. ON SECOND COMPLAINT, ODOMETER NUMBERS NO LONGER SHOW UP PROPERLY. ONLY WHEN PRESSURE IS APPLIED TO THE ODOMETER AREA DO THE NUMBERS LIGHT UP. *TR

Mileage: 20,000

TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING 25-35 MPH, THE TRACTION LIGHT FLASHED AND THE ENGINE BEGAN TO MAKE KNOCKING AND RATTLING NOISES. THE CONTACT PULLED THE VEHICLE OVER TO CHECK THE ENGINE AND THE NOISE STOPPED. WHEN HE BEGAN DRIVING AGAIN, EVERY LIGHT ON THE INSTRUMENT PANEL ILLUMINATED. THE CONTACT PULLED OVER AGAIN AND TURNED OFF THE VEHICLE. WHEN HE RESTARTED THE VEHICLE, THE KNOCKING STOPPED AND THE LIGHTS STOPPED FLASHING. THE FAILURE HAS OCCURRED ON THREE OCCASIONS. A MECHANIC DIAGNOSED THE VEHICLE, BUT COULD NOT REMEDY THE ISSUE. THE CONTACT IS AFRAID TO DRIVE THE VEHICLE. THE CURRENT MILEAGE WAS 67,358 AND FAILURE MILEAGE WAS 67,000.

Mileage: 67,000

IN DECEMBER, 2006 I HAD A NEW ALTERNATOR AND A NEW FUEL PUMP PUT IN (895.00). 1/10/07 MY IGNITION MODULE AND THE FUEL PRESSURE REGULATOR WENT OUT (695.45). 5/14/07 MY IGNITION COIL NEEDED REPLACING (252.18). NOVEMBER 8, 2007 I NEEDED TO REPLACE THE IGNITION SWITCH AND VALVE COVER GASKET ($500) I'M AM TIRED OF REPAIRING. IT'S GOT AN ELECTRICAL PROBLEM THAT'S CAUSING MY IGNITION STUFF TO BURN OUT. *TR

Mileage: 135,000

IN DECEMBER, 2006 I HAD A NEW ALTERNATOR AND A NEW FUEL PUMP PUT IN (895.00). 1/10/07 MY IGNITION MODULE AND THE FUEL PRESSURE REGULATOR WENT OUT (695.45). 5/14/07 MY IGNITION COIL NEEDED REPLACING (252.18). NOVEMBER 8, 2007 I NEEDED TO REPLACE THE IGNITION SWITCH AND VALVE COVER GASKET ($500) I'M AM TIRED OF REPAIRING. IT'S GOT AN ELECTRICAL PROBLEM THAT'S CAUSING MY IGNITION STUFF TO BURN OUT. *TR

Mileage: 115,000

TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. ONE DAY AFTER PURCHASING THE VEHICLE, IT WOULD NO LONGER START. THE VEHICLE WAS TOWED TO A MECHANIC AND AN INJECTOR, PUSH ROD, AND SPARK PLUG WERE INSTALLED. APPROXIMATELY TWO DAYS AFTER RETRIEVING THE VEHICLE, IT WOULD NOT START AGAIN. THE CURRENT AND FAILURE MILEAGES WERE 91,000. UPDATED 10/16/08. *LJ UPDATED 10/17/08. *JB

Mileage: 91,000

AIR BAGS WILL NOT WORK, RUNNING LAMPS OR HEADLIGHTS WILL NOT WORK WINDOW WASHERS WILL NOT WORK, WIPERS ERRATIC, ETC.*TR

Mileage: 20,000

TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLIGHTS WOULD SPORADICALLY FAIL AND CAUSE POOR VISIBILITY. SHE TOOK THE VEHICLE TO A MECHANIC AND THEY STATED THAT THE WIRING HARNESS WAS CORRODED IN THE PLASTIC SLEEVES, WHICH CAUSED THE HEADLIGHTS TO FAIL. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 131,000.

Mileage: 131,000

TL*THE CONTACT OWNS A 2001 CHEVROLET CAVALIER. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE MECHANIC STATED THAT THE STARTER CAUSED THE FAILURE AND THEY MADE THE REPLACEMENT; HOWEVER THE VEHICLE STILL WOULD NOT START. IN ADDITION, THE INSTRUMENT PANEL AND EXTERIOR LIGHTS WOULD NOT ILLUMINATE. AS OF DECEMBER 21, 2007, THE DEALER HAD NOT INSPECTED OR REPAIRED THE VEHICLE. THERE ARE TWO RECALLS: ELECTRICAL SYSTEM: IGNITION: SWITCH (NHTSA CAMPAIGN ID NUMBER 04V036000) AND EXTERIOR LIGHTING (NHTSA CAMPAIGN ID NUMBER 06E026000); HOWEVER, THE MANUFACTURER STATED THAT HER VIN WAS NOT INCLUDED. THE POWERTRAIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 56,000.

Mileage: 56,000

I BOUGHT A 2001 CHEVROLET CAVILIER ON JANUARY 2007 USED AT 71,000 MILES IN MARCH MY CAR BROKE DOWN ON THE HIGHWAY WITH 1/4 TANK OF GAS, NEVER THOUGHT ANYTHING OF IT UNTIL IT BROKE DOWN AGAIN NEAR MY HOME, AND I REALIZED THE GAUGE WAS READING WRONG. I HAD TO USE THE TRIP SETTING TO ENSURE I DIDN'T RUN OUT OF GAS. I TOOK IT TO A MECHANIC AND SPENT $500 ON A NEW FUEL PUMP , THE MAN SAID THE SENSOR IN THE PUMP WAS OUT AND THE WIRES WERE DAMAGED. NOW, I AM HAVING TROUBLE WITH THE ODOMETER THAT SEEMS TO BE SCRAMBLING UNLESS I PUSH ON THE COVER, IT JUST SHOWS RANDOM NUMBERS AND WONT STAY ON TRIP OR MY MILEAGE, NOTHING HAS BEEN DONE ABOUT THIS YET.*AK

ONCE KEY INSERTED INTO IGNITION, IGNITION SWITCH WILL NOT TURN AND STEERING COLUMN IS IN A "LOCKED" POSITION; FRONT WHEELS ARE STRAIGHT AND NOT TURNED LEFT NOR RIGHT. SOME 5 MONTHS AGO THIS HAPPENED AND AFTER SOME 1.5 HOURS OF JIGGLING STEERING WHEEL AND TRYING IGNITION, IT FINALLY STARTED. CAR WAS LEVEL WITH WHEELS FACING STRAIGHT. *NM

Mileage: 99,000

2001 CHEVROLET CAVALIER DEVELOPED PROBLEMS WITH THE BRAKES AND THE ENGINE.***NO ANSWER REQUIRED***. *MR WHILE TURNING THE STEERING WHEEL THE CONSUMER HEARD GRINDING/RUBBING NOISES INTERMITTENTLY. THE FOG LAMP WENT OUT. THE BRAKES WERE NOISY AND WOULD STICK WHEN APPLIED. WATER LEAKING INTO THE TRUNK. THE VEHICLE WOULDN'T START AND THE VEHICLE CHECK ENGINE LIGHT ILLUMINATED. THE KEYLESS ENTRY SYSTEM AND ALARM STOPPED WORKING. THE TRANSMISSION NOT SHIFT INTO LOW GEAR. THE DAYTIME RUNNING LIGHT WOULD NOT SHUT OFF. THE HVAC BLOWER WOULD NOT WORK IN THE FIRST AND SECOND SPEED. THE DEALER FOUN AIR IN THE BRAKE LINE AND DETERMINED THAT HTE LOWER CONTROL ARM BUSHING WAS FALLING OUT

Mileage: 96,376

DT: HORN DID NOT BLOW UNLESS CALLER HIT THE RIGHT SPOT. CALLER SAID THERE WAS A DEAD SPOT IN THE HORN PAD. DEALER AND MANUFACTURER HAVE NOT BEEN CONTACTED. ALSO, TORQUE CONVERTER LIGHT DID NOT COME ON.. COIL PACKS WERE DEFECTIVE. CALLER STATED THERE WERE NO WARNING LIGHTS FOR THIS PROBLEM, AND CALLER WAS CONCERNED THAT THE PROBLEM COULD NOT BE DETECTED UNTIL IT WAS TOO LATE. DEALER REPLACED THE COIL PACKS. MANUFACTURER SAID WARRANTY EXPIRED, AND THEY COULD NOT HELP. ALSO, SEAT BELTS COME OUT OF THE GUIDE AND HIT THE PEOPLE IN THE EYE. CALLER SAID THE FRONT BRAKES WERE DEFECTIVE. WHEN HITTING THE BRAKES THEY DID NOT SLOW DOWN VEHICLE. CALLER DOWN SHIFTED THE GET THE VEHICLE TO SLOW DOWN. ALSO, HAD TO REPLACED THE FRONT ROTORS THREE TIMES. IN ADDITION, THE TRUNK LATCH HAD A GAP IN IT, THE LID DID NOT CLOSE TIGHTLY. *AK *NM

Mileage: 11,000

DT: HORN DID NOT BLOW UNLESS CALLER HIT THE RIGHT SPOT. CALLER SAID THERE WAS A DEAD SPOT IN THE HORN PAD. DEALER AND MANUFACTURER HAVE NOT BEEN CONTACTED. ALSO, TORQUE CONVERTER LIGHT DID NOT COME ON.. COIL PACKS WERE DEFECTIVE. CALLER STATED THERE WERE NO WARNING LIGHTS FOR THIS PROBLEM, AND CALLER WAS CONCERNED THAT THE PROBLEM COULD NOT BE DETECTED UNTIL IT WAS TOO LATE. DEALER REPLACED THE COIL PACKS. MANUFACTURER SAID WARRANTY EXPIRED, AND THEY COULD NOT HELP. ALSO, SEAT BELTS COME OUT OF THE GUIDE AND HIT THE PEOPLE IN THE EYE. CALLER SAID THE FRONT BRAKES WERE DEFECTIVE. WHEN HITTING THE BRAKES THEY DID NOT SLOW DOWN VEHICLE. CALLER DOWN SHIFTED THE GET THE VEHICLE TO SLOW DOWN. ALSO, HAD TO REPLACED THE FRONT ROTORS THREE TIMES. IN ADDITION, THE TRUNK LATCH HAD A GAP IN IT, THE LID DID NOT CLOSE TIGHTLY. *AK *NM

Mileage: 11,000

WHILE DRIVING, THE VEHICLE HESITATED STALLED AND AT TIMES IT WOULD NOT RESTART. THE CONSUMER STATED THIS HAS HAPPENED THREE TIMES AND EACH TIME THE VEHICLE HAS TO BE TOWED TO THE MECHANIC TO GET IT RESTARTED. SHE ALSO SAYS THIS HAS HAPPENED 3 TIMES SINCE NOV. 03. SHE SAID ONE MECHANIC SAID IT WAS AN ELECTRICAL PROBLEM. THEN ANOTHER SAID IT WAS THE STARTER SWITCH , WHICH WAS THEN REPLACED. THEN SHE SAID ONE MECHANIC SAID HE COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE.*JB VEHICLE CONTINUES TO STALL, 3 TIMES IN APPROXIMATELY 5 DAYS. *BF *NM

MANY PROBLEMS EXIST WITH THE CHEVROLET CAVALIER 2001. *BF THE CONSUMER RECEIVED A RECALL LETTER STATING THAT THE VEHICLE COULD CATCH ON FIRE. *NM

WHILE DRIVING 55 MPH VEHICLE STALLED. CONSUMER RESTARTED VEHICLE, AND TOOK IT TO THE DEALER FOR INSPECTION. *AK

CONSUMER RECEIVED RECALL 04V036000 CONCERNING IGNITION SWITCH FAILURE. TOOK VEHICLE TO DEALER FOR REPAIRS, AND WAS CHARGED FOR LABOR IN THE AMOUNT OF $171.00, AND $156.00 FOR THE PARTS. DONNA WILLIAMS WAS THE CONTACT PERSON AT GWATNEY CHEVROLET, COVINGTON PIKE, MEMPHIS TN 38128, 901-387-2000. *AK *TC

Mileage: 93,842

ODOMETER LIGHTS NOT WORKING PROPERLY. *BF ODOMETER NUMERALS FLICKERED ON AND OFF. THE ODOMETER OFTEN LOOKED LIKE IT WAS 29999 BECAUSE THE LAST NUMERALS WERE NOT WORKING PROPLERLY. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR SERVICE BUT WAS NOT COVERED UNDER WARRANTY. *TC

Mileage: 29,431

CONSUMER RECEIVED A NHTSA RECALL 04V036000 CONCERNING IGNITION FAILURE. ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS. DEALER REFUSED TO HONOR RECALL UNLESS $35.00 WAS PAID UP FRONT TO PERFORM A DIAGNOSTIC TEST.*AK

PROBLEMS WITH ODOMETER ON 2001 CHEVROLET CAVALIER.*MR THE VEHICLE WAS TAKEN TO THE DEALER FOR RECALL WORK. THE CONSUMER PICKED THE VEHICLE UP ONLY TO BE TOLD THAT THE DEALER HAD REPLACED ALL THE GAUGES IN THE VEHICLE. THE CONSUMER DID NOT AUTHORIZE ANY REPAIR OTHER THAN THE RECALL REPAIR. THE TECHNICIAN INDICATED THAT THE COMPONENT NEEDED TO BE REPLACED BECAUSE THEY COULD START A FIRE. THE CONSUMER HAD TO PAY $500. FOR WORK HE DID NOT AUTHORIZE. *NM

AFTER RECALL#04V036000 WAS PERFORMED, IT WAS DIFFICULT TO START THE IGNITION. PLEASE PROVIDE MORE INFORMATION. *JB

Mileage: 46,000

THE CONSUMER WAS ADVISED THAT REPAIRING THE RECALL ON THE IGNITION SYSTEM WILL NOT CORRECT THE PROBLEM. *LA THE CONSUMER WAS ALSO TOLD THAT IT WOULD COST TO REPAIR. *SC *JB

CONSUMER COMPLAINING ABOUT THE REPAIR OF HIS 2000 CHEVROLET CAVALIER VEHICLE. *LA RECALL# 04V036000 (ELECTRICAL IGNITION SWITCH) AFTER THE VEHICLE WAS PICKED UP FROM REPAIR, THE CHECK ENGINE LIGHT HAD COME ON. *SC THE CONSUMER HAD TO WAIT FIVE HOURS TO HAVE THE VEHICLE REPAIRED. *JB

SAFETY RECALL NOTICE 04002 2001 CHEVROLET CAVALIER.*MR THE VEHICLE WAS COMPLETELY DESTROYED BY FIRE. THE CONSUMER STATED THE CIRCUMSTANCES OF THE FIRE WERE IDENTICAL TO THE IGNITION SWITCH RECALL. *JB

AFTER MAKING 2 APPOINTMENTS TO HAVE THE IGNITION SWITCH RECALL 04V03600 PERFORMED THE CONSUMER WAS INFORMED UPON ARRIVAL THAT THE PARTS WEREN'T AVAILABLE. THE DEALERSHIP DOESN'T KNOW WHEN THE PARTS WILL BE AVAILABLE. *NM

THE VEHICLE FAILED TO START AFTER THE DEALERSHIP INSTALLED THE RELAY KIT FOR THE IGNITION SWITCH RECALL 04V036000. *NM

VEHICLE FAILED TO START WHEN THE CONSUMER TURNED THE KEYS IN THE IGNITION. RECALL 04V036000 WAS ISSUED FOR THE IGNITION SWITCH. BUT THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

Mileage: 40,000

THE HORN FAILED TO FUNCTION WHEN THE BUTTON WAS DEPRESSED TO WARN ANOTHER MOTORIST AND AS A RESULT THE MOTORIST RAN THE CONSUMER OFF THE ROAD. THE LOCATION OF THE HORN ASSEMBLY IS ACCESSIBLE TO WATER, SNOW OR ANY DEBRIS WHICH RESULTED IN CORROSION. PLEASE PROVIDE ANY ADDITIONAL DETAILS. *NLM *MR

Mileage: 37,000

BRAKES MALFUNCTIONED, RESULTING IN EXTENDED STOPPING DISTANCE. *AK THE DEALER INFORMED THE CONSUMER THE BRAKES WERE SENSITIVE. THE DASHBOARD WAS REPLACED, BECAUSE THE AIR BAG LIGHT WAS ON. THE DASH BOARD LIGHTS CAME ON AND WENT OFF AT LEAST TWENTY TWO TIMES. *JB

Mileage: 11,910

SINCE PURCHASING THE 2001 CHEVROLET CAVALIER, LET ME TELL YOU, IT HAS TRULY BEEN LIKE A ROCK THROWN IN THE WATER. LESS THAN 3000 MILES ON THE CAR AND I HAD TO BRING THE CAR IN TO THE DEALERSHIP AND WAS TOLD THAT THE ALTERNATOR WAS DEFECTIVE. THE CAR ALMOST DIED ON ME ON THE ROAD WHILE MAKING A LEFT TURN ACROSS TWO LANES OF TRAFFIC. I WAS LATE FOR WORK, AND I WAS STUCK IN THE WAL-MART PARKING LOT FOR FOUR HOURS. I FINALLY GOT OVER THAT. OF COURSE, I DIDN'T TAKE OUT THE EXTENDED WARRANTY, WHICH IF I HAD KNOWN THAT WHEN I PURCHASED THIS VEHICLE THAT I WAS GETTING A LEMON, I DEFINITELY WOULD HAVE BEEN A TRUE SOUR PUSS AND BOUGHT A FORD. RECENTLY I HAVE HAD PROBLEMS WITH THE FUEL, NOT ONLY DOES IT NOT GET GOOD GAS MILEAGE THAT IT SHOULD, I WAS RECENTLY TOLD THAT THE FUEL PUMP INSIDE THE GAS TANK FAILED. $643.77 LATER, I HAVE MY LEMON BACK, AFTER NOT HAVING A CAR FOR WORK FOR A FULL WEEK. THE DEALERSHIPS AROUND MY AREA WERE SOLD OUT OF THE FUEL PUMPS, WHEN TALKING TO SEVERAL PARTS SALESMAN, I WAS TOLD THAT THEY HAD A RUN ON FUEL PUMPS DUE TO THEIR FAILURES, THEY SELL SEVERAL PER WEEK. HUH, IMAGINE THAT? I HAVE 43,000 MILES AND MY WARRANTY EXPIRED AT 36,000. WHAT I AM SUPPOSE TO DO WITH MY LEMON? MY WIFE IS SCARED TO DRIVE THE VEHICLE, NOT ONLY BECAUSE IT HAS STALLED SEVERAL TIMES, BUT BECAUSE IT IS AN ACCIDENT WAITING TO HAPPEN. HOPEFULLY SOMETHING CAN BE DONE IN THE NEAR FUTURE TO CORRECT THIS DEFECT. I AM ASKING THAT THE GOVERNMENT RECALLS THESE VEHICLES FOR THEIR DEFECTIVE FUEL PUMPS BEFORE IT IS TOO LATE. I KNOW THE FUEL PUMP IS THE SAME GENUINE CHEVROLET PART THAT WAS IN THERE TO BEGIN WITH. CAN I DEPEND ON THIS? HOPEFULLY, SOMEONE WILL FOLLOW UP ON THIS AND CALL ME SO I CAN REALLY EXPRESS HOW I FEEL. *AK

Mileage: 43,000

WHILE DRIVING ALL WARNING INDICATOR LIGHTS ILLUMINATED. THIS CAUSED VEHICLE TO STALL. DEALER REPLACED THE BODY CONTROL MODULE TWICE, BUT THE PROBLEM STILL OCCURRED. *AK

Mileage: 50,500

DEFECTIVE BATTERY CAUSED LEAKING ON ELECTRICAL WIRING HARNESS CAUSING BURNING AND DAMAGE. GM MECHANIC STATED COMMON PROBLEM WITH FACTORY BATTERIES. GM HQ WILL NOT AGREE TO REPLACE NOR COMPENSATE FOR DAMAGES OR REPAIRS. *NLM

ENGINE WIRING HARNESS STARTED ON FIRE CAUSING SMOKE TO POUR OUT OF THE ENGINE AND DAMAGE TO THE ENTIRE WIRING HARNESS AND OTHER CABLES WITHIN THE ENGINE. THE WIRES CONTINUED TO BURN UNTIL THE BATTERY WAS DISCONNECTED. *NLM

THE CAR DIES WHEN PUT INTO REVERSE, THE HEADLIGHTS GO DIM WHEN PUTTING ON THE BRAKES, THE WINDSHIELD WIPERS ARE NOT WORKING PROPERLY AND ARE GETTING STUCK HALF WAY UP THE WINDSHIELD. THE CAR ALSO ACCELERATES EVEN THOUGH YOU ARE NOT TOUCHING THE GAS. *JB

Mileage: 16,000

CIGARETTE LIGHTER SHOOTING SPARKS, BLOWING FUSES, DAMAGED CELL PHONE CHARGER

Mileage: 44,896

CIGARETTE LIGHTER SHOOTING SPARKS, BLOWING FUSES, DAMAGED CELL PHONE CHARGER

Mileage: 44,896

THE VEHICLE'S BRAKE DRUMS AND ROTORS WORE EXCESSIVELY CAUSING THE VEHICLE TO VIBRATE WHEN THE BRAKES WERE APPLIED. THE TRUNK LIGHT REMAINED ON ALTHOUGH THE TRUNK WAS SHUT. THE INSTRUMENT CLUSTER WAS DRAWING TOO MUCH POWER AND CAUSED THE BATTERY TO BECOME DRAINED. *TS *NLM

CONSUMER HAD TAKEN VEHICLE TO BE SERVICED DUE TO FAILURE OF THE TURN SIGNALS AND BRAKE LIGHTS, CONSUMER ASKED THEM TO CHECK THE ELECTRICAL SYSTEM, HOWEVER THEY DID NOT AND ONLY REPLACED A BURNED OUT FUSE, 9 DAYS LATER THE CONSUMER AND HER SON WERE INVOLVED IN AN ACCIDENT IN WHICH THE BRAKES WERE APPLIED ON A DRY ROAD AT APPROXIMATELY 55 MPH, THE VEHICLE DID NOT STOP AND SPUN AROUND, HITTING A GUARDRAIL HEAD ON, THE VEHICLE WAS TOTALED AND THE AIR BAGS DID NOT DEPLOY, ONE PERSON WAS INJURED, CONSUMER FEELS THIS IS ELECTRICAL RELATED AND FEELS THAT THE VEHICLE SHOULD HAVE PROPERLY BEEN SERVICED AT THE TIME OF THE FAULTY TURN SIGNALS. *SLC

AT 55 MPH CONSUMER APPLIED BRAKE, VEHICLE VIBRATED AND CONSUMER LOST CONTROL WITHOUT WARNING. VEHICLE SPUN AROUND, HIT A GUARDRAIL HEAD ON, THEN SKIDDED 35 YARDS DOWN A EMBANKMENT. PASSENGER SUFFERED BACK INJURIES. VEHICLE WAS TOTALLED YET THE AIR BAGS DID NOT DEPLOY, THE ABS SYSTEM DID NOT WORK AND THE VEHICLE DID NOT STOP UNTIL IT HIT THE GUARDRAIL AND SKID 35 YDS DOWN THE GUARDRAIL, THE TURN SUGNAL FAILED DUE TO A BLOWN FUSE. *JB *NLM

AT 55 MPH CONSUMER APPLIED BRAKE, VEHICLE VIBRATED AND CONSUMER LOST CONTROL WITHOUT WARNING. VEHICLE SPUN AROUND, HIT A GUARDRAIL HEAD ON, THEN SKIDDED 35 YARDS DOWN A EMBANKMENT. PASSENGER SUFFERED BACK INJURIES. VEHICLE WAS TOTALLED HOWEVER THE AIR BAGS DID NOT DEPLOY, THE ABS DID NOT WORK AND THE VEHICLE DID NOT STOP UNTIL IT HIT THE GUARDRAIL AND SKID 35 YARDS DOWN THE GUARDRAIL, THE TURN SUGNAL FAILED DUE TO A BLOWN FUSE. *JB *NLM

VEHICLE WAS PARKED IN CONSUMERS DRIVEWAY WHEN IT CAUGHT ON FIRE. VEHICLE WAS TOTALED. THE CONSUMER COMPLAINED TO DEALER THAT THE CD'S COMING OUT CD PLAYER WERE VERY HOT. DEALER SHOWED NO CONCERN. CHEVROLET'S LEGAL DEPARTMENT WILL NOT GIVE ANY INFORMATION UNTIL A INVESTIGATOR HAS LOOKED AT THE VEHICLE.*AK

CONSUMER IS HEARING A CLICKING NOISE COMING FROM LEFT FRONT WHEEL. VEHICLE WAS OVERHEATING, COOLING SYSTEM MOTOR WAS MAKING THE NOISE.*AK CONSUMER STATES ENGINE LIGHT WAS ALSO ILLUMINATING ALONG WITH THE CLICKING NOISE, DEALER FIRST STATED IT WAS THE COOLING SYSTEM MOTOR, AND THEN THE BEARING AND HUB ASSEMBLY, CONSUMER STATES THE NOISE IS STILL PRESENT. DEALER STATED A FUSE SHORTED AND WAS THE CAUSE OF THE ENGINE LIGHT TO ILLUMINATE. CONSUMER STATED VEHICLE WAS SHIFTING ROUGH, DEALER COULD NOT FIND ANY PROBLEMS. AIR CONDITIONER WAS MAKING A GRINDING NOISE. *SLC

VEHICLE HAS BEEN TO THE DEALER 3 TIMES FOR STALLING AND NOT STARTING. DEALER REPLACED SENSOR AND STARTER ON 2 SEPARATE OCCASIONS. VEHICLE HAS TO GO BACK TO DEALER BECAUSE PROBLEM HASN'T BEEN RECTIFIED. PROBLEM STARTED AT 3500 MILES. *AK *JB

VEHICLE HAS BEEN TO THE DEALER 3 TIMES FOR STALLING AND NOT STARTING. DEALER REPLACED SENSOR AND STARTER ON 2 SEPARATE OCCASIONS. VEHICLE HAS TO GO BACK TO DEALER BECAUSE PROBLEM HASN'T BEEN RECTIFIED. PROBLEM STARTED AT 3500 MILES. *AK *JB

AFTER 500 MILES VEHICLE STARTED MAKING A LOUD NOISE. DEALER LATER REPLACED ALTERNATOR AND IDLE ARM. VEHICLE CONTINUED GRINDING NOISE, AND DEALER REPLACED PARTS OF CLUTCH AND TRANSMISSION. ALSO, DEALER ADVISED CONSUMER THAT GMC WAS AWARE OF PROBLEM, BUT NO REMEDY HAS BEEN ISSUED. DEALER WILL NOT PROCESS FURTHER REPAIRS. *AK

VEHICLE STALLED INTERMITTENTLY, AT ANY SPEED, AND WILL START AGAIN AFTER 3 TO 10 MINUTES. BEEN TO DEALER 3 TIMES, ONCE A BURNT OUT WIRE ON ALTERNATOR WAS REPLACED. DEALER KEPT TELLING CONSUMER THERE WAS NOTHING WRONG WITH VEHICLE. *AK

WHILE DRIVING ABOUT 55 MPH SOMETHING FELL FROM UNDER VEHICLE, HITTING THE LOWER FRAME/BUMPER AND HOOD. VEHICLE WAS DRIVEN TO DEALERSHIP FOR REPLACEMENT OF COMPUTER MODULE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK