2005 CHEVROLET COBALT Engine And Engine Cooling Problems

I WOULD LIKE TO START A PETITION FOR AN INVESTIGATION ON THE REPLACEMENT PARTS BEING USED FOR THE IGNITION SWITCH RECALL AND THE SOFTWARE THEY USE TO RE-PROGRAM OR RE-LEARN THE COMPUTER IN THE VEHICLES THAT HAVE BEEN RECALLED. THE REASON I AM REQUESTING THIS IS BECAUSE MY MOMS 2005 CHEVY COBALT WAS TAKEN IN FOR THIS RECALL REPLACEMENT AND WAS RUNNING FINE WHEN WE BROUGHT IT IN. GOT A CALL THAT THE CAR WAS READY TO BE PICKED UP 7 HOURS LATER. A COUPLE DAYS LATER I'M DRIVING THE CAR AROUND IT STARTED TO RUN TERRIBLE. THE CAR IDLED ERRATICALLY AND IT WOULD STALL EVERY TIME I STOPPED. NOW THE CAR STARTS AND DRIVES AWHILE BUT IF I SHUT IT OFF AND THEN START IT AGAIN THE ENGINE LIGHT STARTS BLINKING,IT BOGS DOWN AND HAVE NO POWER WHEN I ACCELERATE. I CAN SMELL GAS BUT THERE ARE NO LEAKS AND I ONLY SMELL THE GAS WHEN THE CAR STARTS TO DO THIS. I HAVE BEEN ON THE GM RECALL UPDATE WEBSITE AND HAVE READ ABOUT SIMILAR STORIES TO MINE SAYING THERE IS A DEFECT IN THE PARTS OR THERE'S A PROBLEM WITH THE RE-PROGRAMING. I THINK ONE OR BOTH OF THESE IS THE CAUSE OF MY PROBLEM. SO COULD YOU PLEASE LOOK INTO THIS ASAP BECAUSE IT IS A SAFETY HAZARD. THANK YOU

Mileage: 109,498

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING AND IMMEDIATELY BURST INTO FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 125,000. UPDATED 12/17/14*LJ UPDATED 01/26/15.*JB UPDATED 06/2/2015 *JS

Mileage: 125,000

2005 CHEVROLET COBALT. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE. *SMD THE CONSUMER STATED THE FIRST WEEK OF OWNING THE VEHICLE, IT WOULD NOT START. WHEN SHE CALLED THE DEALER, THE TOLD HER TO MOVE THE STEERING WHEEL UP AND DOWN AND TAP ON THE ACCELERATOR PEDAL. THERE WERE TIMES THROUGH OUT THE YEARS, WHERE THE VEHICLE WOULD NOT START. ALSO, THE VEHICLE WOULD PULL TO THE LEFT, THE OIL PAN WAS LEAKING, THE IGNITION SWITCH WAS REPLACED, THE LEFT TURN SIGNAL WAS INOPERABLE, AND THE OXYGEN SENSOR WAS REPLACED. *JB

WAS DRIVING ON 1-40 AT HIGHWAY SPEED AND SUDDENLY ENGINE SHUT DOWN - DASHBOARD LIT UP. MANAGED TO REACH SHOULDER SAFELY. COULD DISCERN NO PROBLEM BY CHECKING UNDER THE HOOD. VEHICLE RESTARTED WITH NO PROBLEM. APPROXIMATELY 60 MILES FURTHER THE SAME THING HAPPENED BUT I WAS ABLE TO RESTART THE ENGINE WHILE MOVING AND CONTINUE WITHOUT FURTHER INCIDENT. TECHNICIAN AT CHEVROLET DEALER IN SANTA FE, NM TOLD ME THE PROBLEM WAS TOO WEIGHTY A KEY CHAIN - HE ALSO GAVE ME A PRINTOUT INDICATING THE PROBLEM, WHICH I STILL HAVE. I LIGHTENED THE KEY CHAIN AND NEVER HAD THE PROBLEM AGAIN.. VERY SCARY TO HAVE YOUR CAR KONK OUT AT 70 MGH WITH 3 LANES OF TRAFFIC ON YOUR TAIL. *TR

Mileage: 500

VEHICLE WAS PARKED INSIDE GARAGE, FILLING TIRES WITH AIR. A CIGARETTE LIGHTER POWERED AIR COMPRESSOR WAS BEING USED TO FILL TIRES. WAS ONLY IN USE FOR A FEW MINUTES, WHEN AIR COMPRESSOR STOPPED. THE FUSE FOR THE CIGARETTE LIGHTER WAS BLOWN. THIS WAS A COMMON PROBLEM WITH THE CAR. ON SEVERAL OCCASIONS THE FUSE FOR THE CIGARETTE LIGHTER WOULD BE BLOWN FOR NO APPARENT REASON. I HAVE ONLY USED IT IN THE PAST TO USE MY OBD II SCANNER, BEING THAT THE OBD DIAGNOSTIC PORT IS POWERED BY THE SAME FUSE AS THE CIGARETTE LIGHTER. BESIDES USING THE OBD SCANNER, NO OTHER THINGS HAVE BEEN USED VIA THE CIGARETTE LIGHTER. REGARDLESS THE FUSE WOULD BE BLOWN. AFTER THE FUSE WAS BLOWN WITH THE AIR COMPRESSOR, I UNPLUGGED IT FROM THE CIGARETTE LIGHTER, ONLY TO SEE SMOKE COMING FROM UNDER THE HOOD. THE FUSE MELTED IN THE FUSE BLOCK. FROM THERE, THE WINDOW WIPERS BEGAN OPERATING, AS WELL AS THE WINDSHIELD WIPER FLUID BEING SHOT OUT FROM THE NOZZLES. SMOKE BEGAN POURING FROM THE INSIDE OF THE CAR, FROM UNDER THE DASH. I QUICKLY RAN TO THE TRUNK WHERE THE BATTERY IS LOCATED, AND DISCONNECTED THE BATTERY AS SOON AS I COULD. GARAGE WAS FILLED WITH SMOKE, WITH THE OMINOUS BURNT ELECTRONIC SMELL. *TR

Mileage: 47,500

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT THE VEHICLE WOULD COMPLETELY LOOSE POWER SPORADICALLY, WHILE DRIVING AT VARIOUS SPEEDS. THE DEALER AND MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIR TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 90,000. UPDATED 05/10/12*LJ

Mileage: 20,000

MY CAR SHUT OFF WHILE DRIVING OUT OF A PARKING LOT A COUPLE OF DAYS AGO. EVERYTHING SHUT DOWN. I COULDN'T EVEN BRAKE. I WAS ABLE TO PUT THE GEAR IN PARK AND RESTART IT JUST FINE. HOWEVER THIS IS THE FOURTH TIME THIS HAS HAPPENED. THE LAST TIME BEING ON THE GEORGE WASHINGTON BRIDGE. THE VERY FIRST TIME WAS 2 MONTHS AFTER I PURCHASED THIS CAR. I ASSUMED IT WAS BECAUSE I WENT OVER A SPEED BUMP THAT WAS LARGER THAN NORMAL. THE SECOND TIME I WENT OVER A POTHOLE. THE THIRD TIME WAS ON THE HIGHWAY. SO I HAD A MECHANIC LOOK AT IT AND HE STATED THAT I COULD BE THE ALTERNATOR. THIS WAS ABOUT 2-3YRS AFTER PURCHASE. HOWEVER MY TIME WAS VERY LIMITED. I LIVE IN MD BUT I WORK IN NEW YORK SO I SPEND A LOT OF TIME THERE AND LEAVE MY CAR AT HOME. SO I HAVEN'T HAD A CHANCE TO GET IT FIXED. WITH THIS LAST INCIDENT I DECIDED TO SEARCH THE INTERNET AND IT TURNS OUT THAT I AM NOT THE ONLY ONE WITH THIS ISSUE. I FOUND IT FUNNY THAT THERE WERE MANY OTHERS WITH THE SAME OR SIMILAR PROBLEM. I PUT IN A SEARCH FOR "COBALT SHUTTING OFF WHILE DRIVING" AND FOUND A COUPLE OF SITES DESCRIBING SIMILAR ISSUES. THIS LAST INCIDENT REMINDED ME OF HOW DANGEROUS THIS COULD BE. I HAD MY 4 YR OLD NIECE IN THE BACKSEAT AND THE EXIT OF THE PARKING LOT WAS ON A HILL. FEELING THE CAR ROLLING BACK AND NOT BEING ABLE TO BRAKE WOULD SURELY BE CONSIDERED A SAFETY ISSUE. ON A SIDE NOTE I DID HAVE MY CAR EXAMINED FOR THE RECALL I WAS GIVEN NOTICE ABOUT. THIS WAS COMPLETED LAST YEAR. NOTHING ABNORMAL WAS REPORTED.

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ENGINE POWER REDUCED LIGHT ILLUMINATED. THE VEHICLE THEN DECELERATED TO 10 MPH AND BEGAN TO SHAKE VIOLENTLY. THE CONTACT SAFELY STOPPED THE VEHICLE AND UPON RESTARTING, THE VEHICLE OPERATED AS NORMAL. THE FAILURE RECURRED INTERMITTENTLY AND THE VEHICLE ALSO STALLED ON A FEW OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND SEVERAL MECHANICS WHERE THE IGNITION COIL PACK, SPARK PLUGS AND THE AIR MASS FLOW SENSOR WAS REPLACED. THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 112,000.

Mileage: 112,000

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH INTO AN INTERSECTION, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AND THE CONTACT WAS ABLE TO RESUME NORMALLY. THE FAILURE RECURRED ON A SEPARATE OCCASION. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS 104,000.

Mileage: 104,000

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT WAS DRIVING 65 MPH WHEN THE VEHICLE BEGAN TO SHIFT OUT FOURTH GEAR. THE CONTACT STATED PRIOR TO THE FAILURE, THE LOW FUEL SENSOR ILLUMINATED INTERMITTENTLY WITH THE TRACTION CONTROL AND THE CHECK ENGINE WARNING SENSORS ENGAGED. THE BRAKE AND ANTI LOCK SENSORS ILLUMINATED BUT DID NOT REMAIN ON CONSISTENTLY. THE ODOMETER ALSO BEGAN TO FLUCTUATE ON THE CONTROL PANEL. THE FAILURE WAS CORRECTED TEMPORARILY WHEN THE VEHICLE WAS RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER CONFIRMED THE BODY CONNECTOR MODULE GEAR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 178,000.

Mileage: 50,000

TL*THE CONTACT OWNS 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 25 MPH THE VEHICLE STALLED. THE CONTACT PLACED THE VEHICLE IN PARK AND TURNED THE IGNITION OFF. THE CONTACT RESTARTED THE VEHICLE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

Mileage: 58,000

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED AND THE ENGINE DISABLED WARNING LIGHT WAS ILLUMINATED. AFTER WAITING A COUPLE OF MINUTES THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND CONTINUE DRIVING. THE FAILURE RECURRED APPROXIMATELY FOUR TIMES IN THE SAME DAY AND CONTINUED TO RECUR INTERMITTENTLY. THE VEHICLE WAS LATER TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS AWAITING A DIAGNOSIS OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 80,000. UPDATED 04/07/11 *BF UPDATED 04/08/11

Mileage: 80,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE TRAVELING AT ANY SPEED, THE CONTACT STATED THAT THE VEHICLE WOULD SUDDENLY STALL INTERMITTENTLY WITHOUT WARNING. THE DEALER MADE THREE ATTEMPTS TO DUPLICATE THE FAILURE. THE CONTACT WAS AWAITING A RESPONSE FROM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 87,000 AND THE FAILURE MILEAGE WAS 84,000.

Mileage: 84,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL. THE WARNING ENGINE POWER REDUCED LIGHT WOULD ILLUMINATE ON THE INSTRUMENTAL PANEL. THE FAILURE OCCURRED ON A INTERMITTENT BASIS FOR THREE WEEKS. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HER TO TAKE IT TO THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 64,000. UPDATED 03/16/11 *BF THE CONSUMER STATED THE VEHICLE IS OPERATING CORRECTLY, AFTER SUGGESTIONS WERE MADE BY THE DEALER. UPDATED 11/04/11

Mileage: 64,000

I WAS DRIVING ON THE HIGHWAY AT 75-80 MPH WHEN THE ENGINE SUDDENLY STOPPED. "REDUCED ENGINE SPEED" AND "ENGINE DISABLED" WARNINGS SCROLLED ACROSS THE ILLUMINATED ON THE INSTRUMENT CONTROL PANEL. AFTER PULLING OVER TO THE SHOULDER, I WAS ABLE TO RESTART THE CAR AND CONTINUE DRIVING WITHOUT FURTHER INCIDENT. PRIOR TO THIS, I NOTICED THAT THE VEHICLE'S RPMS DROPPING AND THEN NEARLY STALLING WHEN SLOWING DOWN AT TRAFFIC LIGHTS OR STOP SIGNS. I TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE THROTTLE BODY AND ECM. THE CAR RAN FINE FOR A COUPLE OF WEEKS AND HAS JUST RECENTLY STARTED AGAIN WITH THE EARLY SYMPTOMS OF NEARLY STALLING AT STOP SIGNS AND TRAFFIC LIGHTS. I HAVE NOT YET TAKEN THE CAR BACK TO THE DEALER, BUT WHEN I CALLED THEM THEY SAID THEY PROBABLY WOULDN'T BE ABLE TO TELL ANYTHING WITHOUT SOME KIND OF ERROR MESSAGE. *TR

Mileage: 138,000

ENGINE STOPS WHILE DRIVING - CANNOT STEER NOR BRAKE SO CONTROLLING THE CAR TO A SAFE STOP IS VERY DANGEROUS OCCURRED 3 TIMES OVER THE LAST 3 MONTHS WITHOUT ANY WARNING. LUCKILY THE CAR RESTARTS AFTER A COUPLE OF MINUTES. *LN

Mileage: 75,000

CAR STALLS WHILE DRIVING DOWN THE ROAD, PULLING OUT, SITTING STILL. HAS BEEN DOING IT ALOT I HAVE 95,000 MILES I TOOK IT TO BE PUT ON THE SCOOP AT THE DEALERSHIP AND IT DIDN'T READ ANYTHING. HAD IT TO NUMEROUS SHOPS AND NO ONE KNOW WHAT THE PROBLEM IS. IT IS VERY DANGEROUS AND I HAVE CHILDREN. CHEVY SHOULD BE MADE TO RECALL THEM. ALL I HAVE READ ON THE INTERNET IS THE SAME PROBLEMS AS IM HAVING AND NOTHING IS BEING DONE ABOUT IT. I ALSO HAVE ANOTHER COMPLAINT I TOOK IN FOR A RECALL ON THE POWER STEERING BUT THEY ONLY FIXED THE MOTOR ON THE POWER STEERING AND SAID I HAD TO FIX THE MODULE WHICH WAS 700.00 IF I TOOK IT THERE TO HAVE THE RECALL DONE ON THE POWER STEERING ALL OF IT SHOULD HAVE BEEN FIXED. CHEVY COBALT 2005. *TR

Mileage: 80,000

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE VEHICLE STALLED WITHOUT WARNING. WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE PERSISTED INTERMITTENTLY. THE DEALER ADVISED THERE WAS AN OPEN, UNRELATED RECALL ON THE VEHICLE AND MADE UNKNOWN REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER 10V073000 (STEERING: ELECTRIC POWER ASSIST SYSTEM). THE FAILURE PERSISTED AND THE VEHICLE WAS NOT DIAGNOSED FOR THE STALLING FAILURE. THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 69,003.

2005 CHEVY COBALT, WHILE MY DAUGHTER WAS DRIVING THIS CAR, SHE LOST POWER, MOTOR WAS REVVING, RPM GOING UP, THEN ENGINE LIGHT CAME ON. TOOK TO 2 CHEVY DEALERSHIPS, 12 CODES CAME UP, BUT WAS TOLD NONE WOULD MAKE IT DO "THAT"... HELP!! WHAT IF SHE IS ON HIGHWAY AND LOSES POWER, SOMEONE CAN BE KILLED... *TR

Mileage: 91,763

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT STATED WHILE APPROACHING A TRAFFIC STOP AND DEPRESSING THE BRAKES, THE VEHICLE STALLED. THE VEHICLE AHD NOT BEEN TAKEN TO THE DEALER FOR A DIAGNOSIS OF THE FAILURE. THE CONTACT CONFIRMED THE FAILURE WOULD OCCUR INTERMITTENTLY WHENEVER DEPRESSING THE BRAKE PEDAL. THE APPROXIMATE FAILURE MILEAGE WAS 135,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 136,000.

Mileage: 135,000

2005 CHEVY COBALT CAUGHT FIRE WHEN THE IGNITION KEY TRIED TO START THE ENGINE. THIS CAR WAS PARKED DURING THE WORK DAY AT THE HOSPITAL COVERED PARKING LOT. *TR

Mileage: 33,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. SHE STATED THAT WHILE DRIVING AT SPEEDS OF 40 MPH OVER A RAILROAD TRACK, THE VEHICLE STALLED WITHOUT WARNING. WITHIN A FEW SECONDS, THE POWER STEERING WARNING LIGHT ILLUMINATED AND FLASHED ACROSS THE INSTRUMENT PANEL. SHE WAS ABLE TO RESTART THE VEHICLE MOMENTS LATER AND TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE POWER STEERING COLUMN DUE TO ELECTRICAL FAILURES. THE REPAIRS WERE COVERED BY HER FACTORY WARRANTY. THE REPAIRS DID NOT CORRECT THE FAILURE AND THE PROBLEM PERSISTED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY REPLACED THE POWER STEERING COLUMN A SECOND TIME. THE FAILURE OCCURRED AGAIN AND THE POWER STEERING COLUMN WAS REPLACED A THIRD TIME. SHE ALSO STATED THAT MOST OF THE ELECTRICAL COMPONENTS ON THE VEHICLE HAD FAILED; UPON OPENING THE DRIVER'S DOOR, THE HORN WOULD BLOW. THE POWER LOCKS WOULD NOT OPERATE, THE ELECTRICAL TRUNK RELEASE WOULD NOT OPERATE AND THE CATALYTIC CONVERTER ALSO FAILED. THE CATALYTIC CONVERTER WAS REPLACED UNDER WARRANTY. THERE WERE NO ADDITIONAL POWER STEERING FAILURES AFTER THE THIRD REPAIR, HOWEVER THE STEERING WHEEL WOULD FEEL HARD AT TIMES. THERE WERE NO RECALLS FOR ANY OF THE FAILURES. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 79,000.

Mileage: 20,000

MY DAUGHTER DRIVES A 2005 COBALT. ON 8-10-2009 SHE WAS DRIVING ON A TWO LANE ROAD WITH A SPEED LIMIT OF 55 MPH WHEN HER CAR SHUTOFF AND SHE LOST STEERING ABILITY. SHE CROSSED THE ONCOMING LANE ON A BLIND CURVE AND STOPPED IN A DRIVEWAY. IF THERE HAD BEEN A CAR COMING TOWARD HER IN THE ONCOMING LANE SHE WOULD HAVE BEEN SEVERELY INJURED AT A MINIMUM. THE CHEVROLET DEALER SAID HE HAD NEVER HAD NEVER SEEN THAT HAPPEN. THE DEALER REPLACED THE ECM AND PUT THE PCM CAUSED A SHORT. *TR

Mileage: 36,233

TL* HE CONTACT OWNS A 2005 CHEVROLET COBALT. THE CONTACT WAS DRIVING 50 MPH ON NORMAL ROAD CONDITIONS. THERE WAS A LOSS OF POWER STEERING, FOLLOWED BY AN ENGINE STALL. THE FAILURES OCCURRED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE FAILURE WAS CONTRIBUTED TO A SHORTAGE IN THE ELECTRONIC CONTROL MODULE (ECM) AND PCM. THE COMPONENTS WERE REPLACED AND REPROGRAMMED. THE FAILURE MILEAGE WAS 36,233.

Mileage: 36,233

I OWN A 2005 CHEVY COBALT AND AS I WAS DRIVING IT BEGAN TO ACT ALMOST LIKE IT WAS GOING TO STALL OUT ON ME AS IN DRIVING ON A MAJOR HIGHWAY! MY POWER STEERING IS SHOT AND NEEDS TO REPLACED I HAVEN'T HAD IT THAT LONG GOT IN AUG 2008! *TR

Mileage: 45,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHEN THE CONTACT STARTED THE VEHICLE HE NOTICED THAT THE IT BEGAN TO STALL AND SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT GASOLINE WAS POURING INTO THE ENGINE AND THAT THE IGNITION CONTROL MODULE NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 64000.

Mileage: 64,000

BOUGHT A NEW 2005 CHEVY COBALT. THE CAR HAD SERIOUS AIR CONDITIONING LEAKING PROBLEMS RIGHT AWAY THAT TOOK OVER A YEAR TO SOLVE. WE WERE ABOUT TO GO LEMON LAW ON THE CAR WHEN CHEVY CAME OUT WITH A SERVICE NOTICE AND GOT THE LEAK SOLVED. THE CAR THEN HAD A HEADLIGHT THAT WOULD FILL UP WITH WATER AND SHORT OUT THE HEAD LIGHT. THE DEALER TOLD ME TO DRILL A HOLE IN THE BOTTOM OF THE HEADLIGHT CASE AND THE WATER WOULD LEAK OUT. THE DEALER TOLD ME TO DO THIS!!! THE CAR RECENTLY STARTED TO HAVE PROBLEMS WITH THE ODOMETER JUMPING AROUND WHILE YOUR DRIVING. WHILE THAT'S HAPPENING THE POWER STEERING LOCKS UP AS THE CAR IS BEING DRIVEN. IT HAPPENED THE FIRST TIME WITH MY 22 YEAR OLD DAUGHTER DRIVING THE CAR TO SCHOOL DOING 65 ON I95. SCARED HER AND SHE HAD TO TRY GET THE CAR OVER THREE LANES TO THE SIDE OF THE ROAD. SHE WAS ABLE TO DO IT AND AFTER RESTARTING THE CAR, THE STEERING WAS WORKING AGAIN. IT TOOK TWO WEEKS FOR IT TO HAPPEN AGAIN, THIS TIME ON A SIDE ROAD AS SHE IS NOT ALLOWED TO DRIVE IT ON THE HIGHWAY ANYMORE. SHE IS A STUDENT AND NEEDS TO GET TO COLLEGE. WE HAVE CONTACTED CHEVY AND THEY TELL US IT'S NOT UNDER RECALL AND IT'S GOING TO COST BETWEEN $600- $1200 DOLLARS. IT COULD EITHER BE THE POWERSTEERING MOTOR OR THE STEERING COLUMN. THEY WON'T KNOW UNTIL THEY GET IN TO THE WORK. I LOOKED ON LINE AND FOUND A LOT OF OTHER PEOPLE WITH THE SAME PROBLEM IN THE 05-06 MODEL. THIS CAR NEEDS TO BE RECALLED AS THE PROBLEM IS GOING TO KILL SOMEONE ON THE ROAD. THE EXPENSE IS BOTH UNNECESSARY AND A BURDEN IN THESE TOUGH TIMES. MY CHILD IS A STUDENT AND DOES NOT NEED TO SHOULDER THIS BURDEN BECAUSE OF THE BAD ENGINEERING BY CHEVY. I KNOW THEY ARE BANKRUPT AND THIS IS A BURDEN WE SHOULD NOT HAVE TO TAKE. SOME ONE IS GOING TO DIE! *TR

Mileage: 45,000

TL* THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 55 MPH THE "REDUCED ENGINE SPEED" AND "ENGINE DISABLED" WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THE VEHICLE STALLED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP. THE CURRENT AND FAILURE MILEAGES WERE 103000.

Mileage: 103,000

2005 CHEVY COBALT--POWER STEERING GOES OUT SUDDENLY ON CAR. *TR

Mileage: 80,000

WHILE TRAVELING AT HIGHWAY SPEEDS (~65 MPH) THE CAR HAS SHUT OFF 4 TIMES. EACH TIME CAR BEHAVED THE SAME WAY, AS IF THE KEY HAD BEEN REMOVED: THE ENGINE STOPPED, INSTRUMENT PANEL DIALS WENT TO 0, LIGHTS TURNED OFF. RADIO STAYED ON (AS IT WOULD IF THE CAR WAS TURNED OFF). THE SHUT OFFS WERE SUDDEN: THERE WERE NO WARNINGS (LIGHTS, SOUNDS, VIBRATIONS) BEFORE SHUT OFF. I WAS ABLE TO COAST/BRAKE AND PULL TO THE SIDE OF THE ROAD, SHIFT TO PARK AND RESTART THE CAR EACH TIME. THE FIRST INCIDENT WAS IN JULY 2008 APPROXIMATELY 100 MILES INTO A TRIP. THE SECOND THREE INCIDENTS HAPPENED IN ABOUT A 30 MINUTE TIME SPAN ON THE SAME TRIP IN MID OCTOBER. I TOOK THE CAR TO THE CHEVY DEALERSHIP AFTER THE OCTOBER INCIDENTS AND THEY COULD NOT REPRODUCE THE PROBLEM. THEY PERFORMED A COMPUTER UPDATE. I HAD THEM CHECK THE WIRING IN JANUARY 2009 AND THEY COULD NOT FIND ANY PROBLEMS. THE CLOCK RADIO RESETS TO 12:00 (WHEN I TURN ON THE CAR, NOT DURING DRIVING) ABOUT ONCE EVERY 3 MONTHS SINCE I BOUGHT THE CAR IN 2005 - I'M NOT SURE IF THIS PROBLEM IS RELATED. THE CAR IS AN AUTOMATIC 2005 COBALT, 4 DOORS WITH ABOUT 35000 MILES. *TR

Mileage: 35,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 70 MPH ON THE FREEWAY, THE "REDUCE ENGINE SPEED" INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE SHIFTED INTO LOW GEAR AND THE CONTACT COULD NOT ACCELERATE BEYOND 40 MPH, WHICH SHE CONSIDERED VERY DANGEROUS ON A HIGHWAY ALLOWING 70 MPH SPEEDS. THE VEHICLE BEGAN OPERATING NORMALLY. PRIOR TO THE FAILURE, SHE NOTICED THAT THE VEHICLE BEGAN STALLING WHEN SHE WOULD SLOW DOWN AT TRAFFIC LIGHTS OR STOP SIGNS. OCCASIONALLY, THE CONTACT WOULD HAVE TO SHIFT THE VEHICLE INTO NEUTRAL SO THAT IT COULD PERFORM CORRECTLY. ON THREE OCCASIONS, A MECHANIC STATED THAT MULTIPLE CODES WERE PRESENT AFTER DIAGNOSING THE VEHICLE. THE MANUFACTURER STATED THAT THERE WAS NO RELEVANT RECALL TO-DATE. THE CURRENT MILEAGE WAS APPROXIMATELY 82,000 AND FAILURE MILEAGE WAS APPROXIMATELY 80,000. UPDATED 4/23/09 *CN UPDATED 04/27/09*JB

Mileage: 80,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. THE VEHICLE WAS TAKEN TO THE CHEVROLET DEALER FOR MAINTENANCE. WHILE REPAIRING THE VEHICLE, A MECHANIC LEFT A RAG ON TOP OF THE ENGINE UNDERNEATH THE HOOD. AFTER THE CONTACT RETRIEVED THE VEHICLE, IT CAUGHT FIRE DUE TO THE RAG BEING LEFT ON THE ENGINE. THE DEALER REPAIRED THE VEHICLE, BUT THE CONTACT DOES NOT FEEL THAT IT IS SAFE TO DRIVE BECAUSE IT CONTINUES TO BREAK DOWN. IN ADDITION, THE TRACTION CONTROL LIGHT CONTINUES TO ILLUMINATE. THE DEALER STATED THAT THEY COULD ONLY REPAIR THE VEHICLE TO ITS ORIGINAL STATE. THE CURRENT MILEAGE WAS 60,059 AND FAILURE MILEAGE WAS 59,083.

Mileage: 59,083

I HAVE HAD MY 2005 CHEVY COBALT SINCE JULY 2005. AT 800 MILES I HAD IT SERVICED FOR A LEAK IN THE PASSENGER FLOORBOARD. IT WAS IN THE SHOP 5 TIMES BEFORE THEY FOUND A FIX. NEXT WAS THE LIGHTS FLASHING ON THE DASHBOARD, SPECIFICALLY THE CHECK ENGINE, BRAKE AND HIGH BEAM LIGHTS. THEN THE HEATER WOULD NOT BLOW SO IT WAS IN THE SHOP TO HAVE THAT FIXED. THEN THE REVERSE LIGHTS STOPPED WORKING AND THERE IS CONDENSATION IN THE HEADLIGHTS. NOW, TWO DAYS AGO, MY POWER STEERING LIGHT COMES ON AND IT BECOMES VERY HARD TO STEER. I ALMOST HAD AN ACCIDENT WHEN I COULDN'T TURN FAST ENOUGH. WHEN YOU TURN THE CAR ON AND OFF IT WORKS AGAIN TEMPORARILY. I WILL BE TAKING IT TO THE SHOP AGAIN, BUT AT THIS POINT IT HAS 50,000 MILES AND IS OUT OF WARRANTY. VERY DISAPPOINTED WITH THE QUALITY OF THIS CAR!! *TR

Mileage: 49,862

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING BETWEEN 65-70 MPH, THE VEHICLE COMPLETELY SHUT DOWN WITHOUT WARNING. ALSO, THE POWER STEERING SHUTS OFF WITHOUT WARNING. THE POWER STEERING LIGHT WOULD ILLUMINATE. THE VEHICLE HAS NOT YET BEEN DIAGNOSED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 25,000 AND FAILURE MILEAGE WAS 22,000.

Mileage: 22,000

THE CHECK ENGINE LIGHT CAME ON SO I TOOK THE VEHICLE STRAIGHT TO THE DEALERSHIP. THEY SAID IT WAS A HISTORY CODE AND NOT A BIG DEAL, SO THEY RESET IT. AFTER LEAVING THE DEALERSHIP IT CAME BACK ON SO I WENT TO A DIFFERENT DEALERSHIP. THEY SAID THE SAME THING AND SAID THEY DON'T KNOW WHY IT IS COMING BACK ON. *TR

Mileage: 24,420

ENGINE LIGHT TURNED ON AT 3,000 MILES NOW THE CAR HAS 45K AND ENGINE LIGHT IS STILL ON CAR HAS BEEN TO THE DEALER NUMEROUS TIMES AND THEY CAN;T FIND THE PROBLEM. THE LIGHT BANK ONE LEAN CODE. THE DEALERS STILL CAN'T FIND THE PROBLEM. CAR RUNS ROUGH AND IT MAY RESULT IN ENGINE DAMAGE OR OTHER PROBLEMS OR SAFETY PROBLEMS IF SITUATION PERSISTS. TO MUCH AIR NOT ENOUGH FUEL. *JB

Mileage: 3,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING BETWEEN 40 AND 50 MPH, THE ENGINE STALLED. ALL THE WARNING INDICATOR LIGHTS FLASHED ON THE INSTRUMENT PANEL. THE VEHICLE WAS ABLE TO BE RESTARTED AND THE DEALER REPLACED THE CAM SHAFT SENSOR. THE CURRENT AND FAILURE MILEAGES WERE 17,000.

Mileage: 17,000

TL*THE CONTACT OWNS A 2005 CHEVROLET COBALT. WHILE DRIVING 45 MPH THE VEHICLE TURNED OFF AND CAME TO A COMPLETE STOP. THE VEHICLE RESTARTED AFTER A FEW MINUTES. THERE WERE NO WARNING INDICATOR LIGHTS. THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 20,536. THE CURRENT MILEAGE WAS 20,636.

Mileage: 20,536

THE CAR HAS STOPPED WITH NO WARNING NO LIGHTS CAME ON AND NOTHING HAPPENED TO CAUSE THIS. I WAS DRIVING ON THE EXPRESSWAY GOING 55 MPH AND IT CAME TO A SUDDEN AND COMPLETE STOP AS I SAID NO WARNING LIGHTS CAME ON. I TOOK THE CAR TO THE DEALERSHIP AND THEY INVESTIGATED AND SAID THAT THEY COULD NOT FIND THE NATURE OF THE PROBLEM. THIS IS BULL! IT HAS HAPPENED ON TWO OTHER OCCASIONS AND IT IS DANGEROUS. *JB

SAME THING BRAND NEW 2005 AND IT HAS DONE THIS TO ME ABOUT 6 TIMES NOW AND STRANDED ME AT NIGHT EVEN FOR HALF AN HOUR BEFORE IT WOULD RESTART AND THE DEALERSHIP KEEPS SAYING THEY FIXED IT AND LAST TIME THEY SAY THEY REPROGRAMMED IT EVEN BUT IT JUST HAPPENED TO ME AGAIN LATE LAST NIGHT ... POWER STEERING BECOMES HARD AND SERVICE LIGHT POPS ON AS THE ENGINE STALLS OUT ON THE FREEWAY THEN IT WILL NOT RESTART FOR A BIT THEN IT SEEMS OK BUT IT KEEPS HAPPENING AGAIN TO ME ANOTHER TIME. *AK

MY 2005 CHEVY COBALT SEDAN RANDOMLY SHUTS OFF WHILE DRIVING. SO FAR IT HAS HAPPENED ABOUT 6 TIMES. THE FIRST TIME WAS A FEW MONTHS AGO. I WAS DRIVING AT A SPEED OF ABOUT 30MPH MAKING A LEFT TURN CROSSING A VERY BUSY LANE OF ONCOMING TRAFFIC WHEN THE CAR JUST SHUT OFF. THE RADIO WAS STILL ON BUT IF I PRESSED ON THE GAS, NOTHING. I HAD TO PUT THE CAR IN PARK, SHUT OFF THE IGNITION AND THEN RESTART IT. IT IMMEDIATELY STARTED BACK UP. I CALLED THE DEALERSHIP RIGHT AWAY AND WAS TOLD THAT BECAUSE NO WARNING LIGHTS CAME ON THEY WOULDN'T BE ABLE TO TRACE THE PROBLEM AND HOPEFULLY IT WAS A ONE TIME THING. WELL THEN ABOUT A MONTH LATER IT HAPPENED AGAIN. THE DEALERSHIP TOLD ME TO WAIT ABOUT A WEEK AND CALL BACK, WELL WITHIN A WEEK IT HAPPENED AGAIN SO I CALLED AND TOLD THEM I WAS BRINGING IT TO THEM. WHEN I BROUGHT THE CAR IN THEY INSTALLED A FLIGHT RECORDER AND SENT ME ON MY WAY. ABOUT A WEEK LATER THE CAR SHUT OFF AGAIN SO I PRESSED THE BUTTON ON THE FLIGHT RECORDER AND BROUGHT IT BACK TO THE DEALERSHIP. THE MECHANICS INFORMED ME THAT THE FLIGHT RECORDER DID NOT WORK BECAUSE THEY FORGOT TO PUT SOMETHING ELSE ON MY CAR AT THE TIME OF THE INSTALLATION IN ORDER TO MAKE THE RECORDER WORK AND WANTED ME TO BRING THE CAR BACK TO HAVE THE RECORDER RE-INSTALLED. I REFUSED AND TOLD THEM I WOULD BRING THE CAR BACK BUT THEY NEEDED TO KEEP IT UNTIL THEY FIGURED OUT THE PROBLEM. ON MY WAY BACK TO THE DEALERSHIP THE CAR SHUT OFF AGAIN WHILE GOING 65MPH ON THE HIGHWAY. THE DEALERSHIP HAD THE CAR FOR ABOUT A WEEK AND CLAIMED IT WAS FIXED FOR SURE. THEY SAID THEY FOUND THE PROBLEM AND REPLACED THE IGNITION SWITCH AND POWER TRAIN RELAY. WELL I HAVE NOW HAD MY CAR BACK FOR TWO WEEKS AND AS OF LAST NIGHT IT HAPPENED AGAIN. I CALLED THE DEALERSHIP AND TOLD THEM TO HAVE THE CAR TOWED BECAUSE I REFUSE TO DRIVE IT. AT THIS POINT I DO NOT WANT THE CAR AND HAVE NO FAITH IN THEM REPAIRING IT. THE CAR SHOULD BE RECALLED BEFORE THERE IS A FATALITY. *TR

Mileage: 27,000

#1 I BROUGHT IT BACK BECAUSE STEERING WHEEL ALWAYS WAS TO THE LEFT EVEN THOUGH I WAS GOING STRAIGHT. DEALER SAID IT WAS FINE, I COMPLAINED TO CUSTOMER SERVICE AND THEN DEALER SAID THEY FIXED IT. WHEN GOING STRAIGHT THE STEERING STILL LOOKS LEFT. #2 AIR CONDITIONING NOT WORKING, #3 LIQUID COMING OUT OF VENTS #4 CRICKET NOISES OUT OF PASSENGER SIDE DASH AREA. I WAS TOLD AIR CONDITIONING WAS FINE, NO CRICKET NOISES AND IT WAS NORMAL FOR FLUID TO COME OUT OF VENTS. I BROUGHT THE CAR BACK AGAIN SAID A/C IS NOT FINE I ASKED THEM IF IT COULD BE SOME SORT OF FILTER (I AM NO MECHANIC) BUT IT WAS. THEY HAD CAR ALL DAY, WENT TO PICK IT UP BUT THEY SAID DASH WAS APART BECAUSE THEY WERE FIXING THE PROBLEM WITH THE FLUID COMING OUT OF THE DASH (AND I SAID I WAS TOLD THERE WAS NO PROBLEM) THEY HAD THE CAR FOR THE WEEKEND. THEY TRIED TO CHARGE ME FOR THE FILTER AND I SAID I WOULD NOT PAY FOR IT BECAUSE THERE WAS PROBLEMS WITH THAT AC AND DEFROSTER ETC SINCE DAY ONE. THEY TOOK OUT THE FILTER AND PUT IN AN OLD DIRTY FILTER THAT DID NOT COME FROM MY VEHICLE AS THE GUY FROM THE CHEVY DEALERSHIP IN MALDEN SAID HE FOUND IT IN THE TRASH, (HAS MADE MY DAUGHTER SICK). #5 WHILE DRIVING THE CAR I WAS GETTING OFF OF THE HIGHWAY INTO A REST AREA AND THE CAR JUST DIED, THERE WAS NO POWER STEERING NO BRAKES ETC. THE KEY WAS IN THE SWITCH AND IT WAS NOT OFF. I STARTED THE CAR UP AGAIN. #6 THE ELECTRICAL DIDNT WORK, THEY FIXED THAT. I HAVE CONTACTED CHEVY CUSTOMER SERVICE ON SEVERAL OCCASIONS AND THEY SAY THEY WILL CHECK INTO IT ETC AND CALL ME BACK, BUT THEY NEVER DO. I WANT THEM TO FIX THE STEERING WHEEL, FIX THE CAR STALLING OUT FOR NO REASON (WE COULD HAVE BEEN KILLED) AND PUT IN A NEW FILTER NOT SOMEONE ELSES DIRTY FILTER. I DON'T TRUST THE MALDEN DEALERSHIP. I HAVE BROUGHT THE CAR TO THE DEALERSHIP ON AT LEAST 7 OCCASIONS MOST OF WHICH THEY SAY NOTHING WRONG. *NM

Mileage: 18,000

DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE ENGINE REVVED AND STALLED WITHOUT WARNING. AFTERWARDS, THE ENGINE WAS EASILY RESTARTED. THE VEHICLE WAS INSPECTED BY A DEALER SEVERAL TIMES BUT WERE UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER WAS ALERTED.

Mileage: 9,600

FIRST IT WAS THE ENGINE STALL DUE TO FAULTY FUSE BOX WHICH THEY FIXED. THEN THERE WAS THE SUN ROOF CAP WHICH FELL OF TWICE AND THEY ATTEMPTED TO FIX FOUR (4) TIMES. BOTH WHICH ARE UNDER THE COBALTS TSBS I THINK. NOW IT'S THE SES LIGHT WITH A P0171 DTC CODE OR THE AIR FUEL MIXTURE IS OFF. I TOOK IT IN THREE (3) TIMES AND ON THE FINAL ONE THEY SAID THEY HAVE NO SOLUTION AND THEY CANT DO ANYTHING ABOUT IT. IT IS CURRENTLY UNDER INVESTIGATION BY GM NOT ONLY IN THE 2005-2006 CHEVY COBALT, THE 2005-2006 PONTIAC PURSUIT, AND THE 2005-2006 SATURN ION. ALL WHICH HAVE THE 2.2L ECOTEC L61 ENGINE. IT TROUBLES ME THAT THEY SAY THEY CANT DO ANYTHING ABOUT IT AND TO JUST KEEP BRINGING IT IN WHEN LIGHT COMES ON. THAT IS TRULY A PATHETIC ANSWER TO THIS PROBLEM. THEY ARE COSTING ME TIME AND MONEY AND THIS IS NO WAY TO RUN A BUSINESS. THIS IS CLEARLY AN ISSUE THEY CANT SOLVE AND THAT IS AFFECTING 3 DIFFERENT CARS. THERE WAS NOTHING DONE TO FIX THE DEFECT EXCEPT TURN OFF THE CHECK ENGINE LIGHT, NO OTHER REPAIRS HAVE DEVELOPED FOR THIS DEFECT IN GM'S VEHICLES. *JB

Mileage: 8,257

WE PURCHASED A 2005 CHEVROLET COBALT (LS) IN DECEMBER, 2005. STARTING IN JANUARY 2006, WE NOTICED THAT THE ENGINE LIGHT GOES ON AND OFF AND WE HAD THE CHEVY DEALER WHOM WE PURCHASED CAR FROM CHECK IT. THEY TOLD US THAT THE ENGINE IS FINE AND IT HAPPENS TO MANY COBALT THAT THE ENGINE LIGHT WILL GO ON SOMETIMES WITHOUT ANY REASON. WE CALLED CHEVROLET AND WE WERE TOLD THAT THEY WERE AWARE OF THE PROBLEM BUT HAVE NO SOLUTION TO IT. WE WERE ASKED TO KEEP DRIVING THE CAR WITH ENGINE LIGHT ON. WE FEEL VERY UNCOMFORTABLE DRIVING A CAR WITH ENGINE LIGHT ON. WE WOULD NOT KNOW IF THERE IS REALLY NOTHING WRONG WITH THE CAR. CHEVROLET REFUSED TO TAKE ANY ACTION REGARDING TO THIS MATTER. WE DON'T KNOW WHERE TO SEEK FURTHER HELP ON THIS INCIDENT. THERE IS CURRENTLY 6000 MILES ON THE CAR AND THE ENGINE MAY BE FINE AT THIS MOMENT. BUT SINCE THE ENGINE LIGHT IS NOT WORKING PROPERLY, WE WOULD NOT KNOW IF SOMETHING REALLY HAPPENS IN THE FUTURE. WE DON'T FEEL SAFE BUT NOWHERE TO SEEK HELP. *JB

Mileage: 4,000

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE CHECK ENGINE LIGHT ILLUMINATED AND FIRE CAME FROM THE EXHAUST PIPE. THE EXHAUST TURNS BRIGHT RED AND THE FLOOR BOARD GETS HOT. THE DEALERSHIP REPLACED THE CATALYTIC CONVERTER HOWEVER THE PROBLEM STILL EXISTS.

Mileage: 11,500

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE CHECK ENGINE LIGHT ILLUMINATED AND FIRE CAME FROM THE EXHAUST PIPE. THE EXHAUST TURNS BRIGHT RED AND THE FLOOR BOARD GETS HOT. THE DEALERSHIP REPLACED THE CATALYTIC CONVERTER HOWEVER THE PROBLEM STILL EXISTS.

Mileage: 11,500

DT: THE CONTACT STATED WHILE DRIVING THE COOLANT LIGHT ILLUMINATED ON THE DASHBOARD. SHE PULLED TO THE SIDE OF THE ROAD, AND THEN THE VEHICLE WAS TOWED TO A DEALERSHIP. THEY STATED THE RADIATOR NEEDED TO BE REPLACED. *AK UPDATED 01/25/06. *JB

Mileage: 1,100

THREE MONTHS AFTER REPLACEING THE RADIATOR IN MY CAR FROM HITTING A RACCOON. I STARTED THE CAR AND SMOKE CAME FROM THE EXAUST. TOOK THE CAR BACK TO THE DEALERSHIP ON FRIDAY. ON THE FOLLOWING MONDAY I GOT A CALL SAYING "WE CAN NOT FIND ANYTHING WRONG" AND DROVE THE CAR HOME. THE NEXT MORNING I STARTED THE CAR AND SMOKE CAME FRON THE EXAUST AGAIN, THE SAME THING HAPPEND AFTER WORK EXCEPT THE CAR STARTED AFTER TURNING THE KEY A FEW TIMES. THE SAME THING HAPPEND THE NEXT TWO DAYS IT DIDN'T WANT TO START AND AFTER IT DID, IT SMOKED FOR APPROXIMATLY 10 MINUTES. THAT FRIDAY MORNING WAS NO DIFFERENT AND THE SAME WITH LEAVING FROM WORK UNTILL I GOT 12 MILES FROM AWAY WHEN THE TEMPERATURE GAGE CAME ON, SO I TOOK IT BACK TO THE DEALERSHIP. THERE I TALKED TO A DIFFERENT MECHANIC AND TOLD HIM WHAT WAS GOING ON AND IN LESS THEN A MINUTE HE TOLD ME WHAT IT WAS PROBABLY A CRACKED HEAD ON THE ENGINE. THE FOLLOWING MONDAY AND FURTHER INSPECTION HE WAS RIGHT IN SAYING IT WAS THE HEAD AND NEEDS TO BE SENT OUT FOR REPAIR. NOW THEY ARE NOT WILLING TO FIX THIS PROBLEM SAYING THAT IT IS NON WARRANTY AND WE ARE STUCK WITH ALL COSTS.

(1) THERE HAVE BEEN NO PROBLEMS WITH THE CAR (2005 CHEVY COBALT SEDAN) UNTIL 9/24/05. THE CAR STALLED ONCE THIS MORNING AND THEN COMPLETELY SHUT DOWN WITHOUT WARNING. BOTH EVENTS HAPPENED AFTER HE TOOK HIS FOOT OFF THE ACCELERATOR SO HE COULD SLOW DOWN AND EXIT THE FREEWAY. NO WARNING LIGHTS CAME ON. (2) MY HUSBAND THOUGHT HE WAS GOING TO DIE. HE COULD NOT STEER THE CAR, THE BRAKE PEDAL WENT MUSHY, AND THE ENTIRE SYSTEM SHUT DOWN. THERE WERE NO CARS AROUND HIM SO HE JUST SLID UNTIL THE CAR STOPPED ON ITS OWN IN SOME BUSHES. (3) HE GOT TO A PHONE AND WE CALLED ROADSIDE ASSISTANCE, THEY TOWED THE CAR TO THE DEALERSHIP. *JB

Mileage: 8,000

DT : THE CALLER SAID THAT WHILE DRIVING IF SHE BUMPED THE KNEE UNDER THE STEERING COLUMN THE ENGINE DIED. SHE WAS NOT HITTING THE IGNITION SWITCH, BUT JUST BUMPING THE UNDERNEATH SIDE OF THE COLUMN. IT DID NOT NEED TO BE HIT VERY HARD TO HAPPEN. THIS HAPPENED THREE TIMES WHILE SHE WAS GOING DOWN THE HIGHWA,Y AND ONCE TO HER SON. DEALER AND MANUFACTURER HAVE NOT BEEN CONTACTED YET. *AK

Mileage: 3,000

WE PURCHASED OUR 2005 CHEVROLET COBALT IN MID DECEMBER. IN THE MIDDLE OF JANUARY WE NOTICED THAT THE AIR CONDITIONER WAS NOT BLOWING COLD AIR. DEALERSHIP REPLACED THE AIR CONDITIONER COMPRESSION VALVE. APPROXIMATELY ONE WEEK LATER THE VEHICLE BEGAN TO DISPLAY THE "CHECK ENGINE" LIGHT AND READ "POWER LESS REDUCED" THEN ,WE BEGAN TO HAVE DIFFICULTY ACCELERATING. THE GAS PEDAL BECAME STIFF. THE DEALEARSHIP REPLACED THE AIR CONDITIONER COMPRESSION VALVE ONCE AGAIN. AGAIN THE PROBLEM SURFACED ABOUT A WEEK LATER. THE SAME PART WAS REPLACED ONCE AGAIN ,AND AN APPOINTMENT WAS MADE FOR THE FOLLOWING TUESDAY TO DROP THE VEHICLE OFF FOR FURTHER INVESTIGATION. DEALERSHIP DISCOVERED A FAULTY WIRING HARNESS CAUSING THE PROBLEM. WE WERE THEN TOLD THAT THIS WAS AN ENGINEERING PROBLEM WITH THE VEHICLE. PROCEEDINGS ARE UNDERWAY TO REPLACE THE VEHICLE WITH ANOTHER CAR. *AK

Mileage: 4,300