2001 CHEVROLET CORVETTE Service Brakes, Hydraulic Problems

TL*THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE ABS LIGHT ILLUMINATES INTERMITTENTLY. HE TOOK THE CAR INTO THE DEALERSHIPS THEY COULD DIAGNOSE A PROBLEM ON THE VEHICLE. HE HAS BEEN EXPERIENCING THIS FAILURE SINCE THE PURCHASE OF THE VEHICLE. THE FAILURE MILEAGE WAS 5,000. THE CURRENT MILEAGE WAS 52,000.(SC)

Mileage: 5,000

TL*THE CONTACT OWNS A 2001 CHEVROLET CORVETTE. TWO MONTHS AGO, THE ABS TRACTION CONTROL SYSTEM LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE OWNER'S MANUAL STATED THAT THE LIGHT WOULD ILLUMINATE INTERMITTENTLY, HOWEVER, IT SHOULD DIM WHEN THE VEHICLE WAS SHUT OFF AND RESTARTED. APPROXIMATELY ONE WEEK AGO, THE CONTACT NOTICED THAT THE LIGHT REMAINED ILLUMINATED. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THERE WAS INTERNAL FAILURE WITH THE ABS AND BRAKE MODULES. THEY ALSO STATED THAT THE ABS WAS NOT WORKING. THE MANUFACTURER STATED THAT THEY WOULD NOT REPAIR THE VEHICLE FOR FREE BECAUSE IT WAS NOT UNDER WARRANTY. THE CURRENT MILEAGE WAS 24,277 AND FAILURE MILEAGE WAS 24,200.

Mileage: 24,200

2001 CHEVROLET CORVETTE COUPE WITH 50,000 MILES SERVICE ABS, ACTIVE HANDLING AND TRACTION CONTROL WARNING APPEARED INTERMITTENTLY, ABOUT 6 TIMES IN THE LAST 3 MONTHS. LONGEST IT STAYED THAT WAY WAS FOR A WEEK. ABS, TRACTION CONTROL AND ACTIVE HANDLING WERE DISABLED WHICH I BELIEVE WAS A SERIOUS SAFETY ISSUE. IT COULD HAPPEN JUST BEFORE OR DURING AN EMERGENCY SITUATION. MANY OTHER OWNERS OF THIS MODEL HAD THE SAME PROBLEM - SEE CORVETTE FORUMS.*AK

Mileage: 47,700

ELECTRONIC BRAKE CONTROL MODULE (EBCM) FAILURE. MUST REPLACE MODULE. THERE SEEMS TO BE MANY PEOPLE WITH MY SAME PROBLEM. GO TO WWW.CORVETTEFORUM.COM AND SEARCH "EBCM FAILURE" AND YOU WILL SEE THE LIST OF PEOPLE WITH MY SAME ISSUE. *TR

Mileage: 47,000

2001 CORVETTE CONVERTIBLE, THE ABS/TRACTION CONTROL SYSTEM HAS FAILED TWICE, ONCE AT 40,000 MILES THEN AFTER HAVING IT REPLACED IT FAILED AGAIN AT APPROXIMATELY 75,000 MILES. IT IS THE ABS MODULE AND CONTROL VALVE, THE CODE IS C1214, WHICH STATES SET CURRENT-SOLENOID RELAY COIL OPEN. IT'S FAILURE CAUSES COMPLETE AND TOTAL LOSS OF THE ABS SAFETY FEATURES AS WELL AS THE SAFETY FEATURES OF THE TRACTION CONTROL LOST. THESE FAILURES CAN LEAD TO LOSS OF TRACTION WHILE TURNING OR ON SLIPPERY SURFACE AS WELL LOSS OF CONTROL OF VEHICLE DURING EMERGENCY BRAKING OR ATTEMPTING TO STOP QUICKLY OR ON WET OR ICY SURFACES. THIS COULD LEAD TO ACCIDENTS RESULTING IN SERIOUS INJURY OR EVEN DEATH. THE FIRST DEFECTIVE ABS MODULE AND VALVE WERE REPLACED AND I NO LONGER HAVE THEM, HOWEVER THE CURRENT DEFECTIVE ABS MODULE AND VALVE ARE STILL IN THE CAR AND AVAILABLE. *NM

Mileage: 70,000

THE ABS, TRACTION CONTROL, AND ACTIVE HANDLING INDICATORS STARTED COMING ON WHEN STARTING VEHICLE. VEHICLE IS 2001 CHEVROLET CORVETTE WITH 32,000 MILES. I TOOK THE VEHICLE IN FOR REPAIR AND WAS TOLD IT WOULD COST $3,189 TO REPLACE A VALVE AND A MODULE (BPMV AND EBCM). I THOUGH THIS WAS UNUSUAL FOR TWO PARTS TO GO OUT ON A VEHICLE WITH SUCH LOW MILES. THE TECHNICIAN TOLD ME THAT THERE HAD BEEN OTHER VEHICLES WITH THE SAME PROBLEM. I FEEL THAT I SHOULD NOT HAVE TO PAY THE FULL PRICE FOR THE FAILURE OF A DEFECTIVE SAFETY DEVICE ON MY VEHICLE, ESPECIALLY WHEN IT FAILS AT 32,000 MILES. ALTHOUGH I HAVE ONLY HAD TO RELY ON ABS ONCE SINCE I PURCHASED THE VEHICLE NEW IN 2001, I FEEL THAT IT SAVED ME FROM GETTING INTO AN ACCIDENT. NOW, THE FEATURE DOESN'T WORK AND GM HAS MADE IT NEARLY COST PROHIBITIVE TO GET IT FIXED! WHEN I HAD A DEFECTIVE SEAT BELT ON ANOTHER GM VEHICLE, GM WAS FORCED TO FIX IT FOR FREE. I FEEL THE SAME SHOULD OCCUR ON ANY VEHICLES WHOSE SAFETY DEVICES, SUCH AS ABS, FAIL AT LESS THAN 100,000 MILES. *JB

Mileage: 31,500

ACTIVE HANDLING SYSTEM MALFUNCTIONS AT HIGHWAY SPEEDS. WHEN TRAVELING ON DRY SMOOTH HIGHWAYS, IN A STRAIGHT LINE, THE ACTIVE HANDLING SYSTEM WILL ACTIVATE AND RANDOMLY ACTUATE INDIVIDUAL BRAKE CALIPERS. WHEN THIS OCCURS, THE "DRIVER INFORMATION SYSTEM" WILL FLASH "ACTIVE HANDLING". IN EVERY CASE, THIS CAUSES MOMENTARY, UNINTENDED CHANGES IN DIRECTION AND SPEED OF THE AUTOMOBILE. THE EVENT DOES NOT REGISTER ANY CODES IN THE OBD II. THE PROBLEM CAN ONLY BE DEFEATED BY TURNING OFF THE ACTIVE HANDLING SYSTEM. THE PROBLEM CAN BE INDUCED BY MAKING MINUTE ADJUSTMENTS TO THE STEERING WHEEL WHILE TRAVELING IN A STRAIGHT LINE. THIS PROBLEM HAS BEEN LOOK AT BY THE DEALER SEVERAL TIMES, AND THEY HAVE BEEN UNABLE TO DIAGNOSE OR REPAIR THE PROBLEM. THIS IS SIMILAR TO COMPLAINT 757075.

Mileage: 58,000

WHEN THE VEHICLE WAS STARTED THE BRAKE PEDAL WENT TO THE FLOOR. (NAR) *LA *CB

Mileage: 23,982

SENSOR ON DRIVER'S DOOR HAS BEEN REPLACED NUMEROUS TIMES, INTERMITTENTLY DRIVERS DOOR WILL NOT RESPOND TO REMOTE OPTION.*AK CUSTOMER STATED THAT OIL LEAKED FROM ENGINE AREA. THE DRIVER DOOR RATTLES WHILE DRIVING AND WAS HARD TO CLOSE. THE RIGHT DOOR GLASS HAS WIND NOISE DUE TO DOOR GLASS FAILURE. BRAKES FAILED TO GRAB. THERE WAS A NOISE WHILE DRIVING DUE TO LEFT SEAT BELT RETRACTOR FAILURE. CONSUMER STATES CD CHARGER WOULD NOT EJECT CD CARTRIDGE, THE STEERING TILT WAS INOPARTIVE, THE DOOR RATTLED, THE SEATS WOULD NOT HOLD PROGRAMMING. *YH

AT TIMES AT HIGHWAY SPEEDS WHEN BRAKING FRONT BRAKES WILL STICK ON AND WILL NOT RELEASE. BEEN TO THE DEALER AND SAYS THEY KNOW OF THE PROBLEM,BUT UPON THEM TEST DRIVING CAR IT WILL NOT REPRODUCE THE PROBLEM. THEY SAY IF THEY CAN'T REPRODUCE THE PROBLEM, THEY CAN NOT FIX. OTHER 2000 AND 2001 CORVETTE OWNERS REPORT THIS PROBLEM ON CORVETTEFORUM.COM. *AK

BRAKE PEDAL STICKS WHEN YOU JUST TAP IT TO SLOW DOWN. PEDAL DOES NOT SPRING BACK UP AFTER INITAL TAP. I HAVE TO PLACE MY FOOT BEHIND BRAKE PEDAL TO LIFT T PEDAL BACK UP. *AK

BRAKE PEDAL STICKS WHEN YOU JUST TAP IT TO SLOW DOWN. PEDAL DOES NOT SPRING BACK UP AFTER INITAL TAP. I HAVE TO PLACE MY FOOT BEHIND BRAKE PEDAL TO LIFT T PEDAL BACK UP. *AK

UPON APPLICATION OF BRAKES AT HIGHWAY SPEEDS, WHEN THE DRIVER THEN LETS OFF OF THE BRAKES, THE PEDAL STAYS DOWN AND THE BRAKES ARE STILL APPLIED. *AK

VEHICLE WILL PULL TO LEFT OR RIGHT WHILE BRAKING. CONSUMER MUST HOLD STEERING WHEEL TIGHTLY EVEN AT LOW SPEEDS OR WILL LOSE CONTROL OF VEHICLE. *AK THE TIRE MANUFACTURER AND THE INDEPENDENT ALIGNMENT SPECIALISTS STATE THAT THE PROBLEM IS WITH THE SUSPENSION. *SLC

BRAKES DO NOT FULLY RELEASE. WHEN BRAKES APPLIED AND REPLEASED, THEY STUCK AND CONTINUED TO BRAKE. DEALER ACKNOWLEDGED PROBLEM, BUT WILL NOT REPLACE BRAKE BOOSTER WHICH SEEMED TO BE CULPRIT BECAUSE IT APPEARED TO BE OPERATIONAL TO SPEC.*AK

BRAKES DO NOT FULLY RELEASE. WHEN BRAKES APPLIED AND REPLEASED, THEY STUCK AND CONTINUED TO BRAKE. DEALER ACKNOWLEDGED PROBLEM, BUT WILL NOT REPLACE BRAKE BOOSTER WHICH SEEMED TO BE CULPRIT BECAUSE IT APPEARED TO BE OPERATIONAL TO SPEC.*AK

DEFECT #1: BRAKES STICK CLOSED AT RANDOM TIMES. SEEMS RELATED TO ENGINE RPM AND TO DECELERATION. DEFECT #2: DRIVERS SIDE SEAT BELT & HARNESS WILL NOT EXTEND AT RANDOM INTERVALS. INERTIA REEL APPEARS TO LOCK SEVERAL TIMES AS THE BELT IS DEPLOYED.

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK