2005 CHEVROLET CORVETTE Air Bags Problems

This lead to an injury accident which totaled the car. I have documentation stating that the recall was fixed, but after I moved to Germany with the Army, the recall regularly activated the active handling when not needed (e.g parking) but then when we started slipping, the active handling did not engage and we crashed, totaling the car. The airbags did not engage even though the car played pinball on both sides of the autobahn. If we were going any faster, we would have died.

THE AIRBAG LIGHT KEEPS ILLUMINATING FOR NO REASON. FROM WHAT I READ, THE AIRBAG SYSTEM WILL NOT OPERATE WHEN THE RED INDICATOR LIGHT ON THE DASHBOARD LITE

Mileage: 41,000

DRIVERS SIDE AIR BAG LIGHT COMES ON AND OFF,BOTH WHEN STATIONARY AND WHEN IN MOTION

AIRBAG ERROR LIGHT COMES ON AND OFF. EVEN AFTER HAVING THE FRONT SENSOR REPLACED. HAPPENS ALL THE TIME. APPEARS RELATED TO CONNECTOR UNDER SEATS. DON'T KNOW IF AIRBAG WILL ACTIVATE IF NEEDED.

Mileage: 35,000

AIR BAG WARNING LIGHT COMES ON. CONNECTOR UNDER SEAT LOOSES CONTACT. VERY COMMON PROBLEM WITH CORVETTES.

Mileage: 15,670

AIRBAG WARNING LIGHT COMES ON AND GOES OFF EACH TIME THE CAR IS RUNNING. SOMETIMES IT STAYS ON FOR MINUTES, OTHER TIMES IT MAY STAY ON THE ENTIRE TIME THE CAR IS RUNNING. THE CAR CURRENTLY HAS 26000 MILES. THE LIGHT IS ON BOTH WHEN THE CAR IS SITTING STILL IN PARK AND WHEN IT IS BEING DRIVEN. DO I HAVE AIRBAG PROTECTION WHEN THIS OCCURS ? THE OWNERS MANUAL STATES THAT IF THE LIGHT IS ON THE AIRBAGS MAY DEPLOY FOR NO REASON. VERY UNSAFE IF CAR IS BEING DRIVEN AT HIGHWAY SPEEDS. CORVETTE OWNERS NEED TO BE MADE AWARE OF THE RISKS INVOLVED IN DRIVING THIS CAR.

Mileage: 26,000

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. WHILE DRIVING AT ANY SPEED, THE AIR BAG WARNING LIGHT ILLUMINATED AND BLINKED ON AND OFF INTERMITTENTLY. THE DEALER AND MANUFACTURER WERE NOTIFIED; HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

AIRBAG WARNING LIGHT GOES ON, RENDERING AIRBAG INOPERATIVE. POOR CONNECTORS BELOW SEAT, A DESIGN FLAW, LEAD TO THIS. RECURS NO MATTER HOW OFTEN YOU RETURN TO DEALER. THIS IS SO COMMON IN 2005 CORVETTES, AND SO POTENTIALLY DANGEROUS, THAT ALL 2005 CORVETTES SHOULD BE RECALLED TO HAVE THIS DEFECT REPAIRED...

Mileage: 100,000

AIR BAG LIGHT ON BECAUSE OF FAULTY CONNECTOR DISABLING VEHICLE AIR BAGS. NOT SAFE.

Mileage: 35,200

AIR BAG LIGHT GOES ON -- DEALER TRIES TO FIX (AT CONSIDERABLE EXPENSE) AND SAID FIX LASTS FOR MAYBE A MONTH OR TWO. I HAVE GIVEN UP SPENDING FOR THIS TEMPORARY FIX -- I USE MY 3 POINT SEAT BELT EVERY TIME AND HOPE IT IS GOOD ENOUGH.... THIS PROBLEM IS WELL KNOWN IN THE CORVETTE COMMUNITY AND TO GM, AND HAS BEEN FOR A LONG TIME. GM SIMPLY REFUSES TO COME UP WITH AN APPROPRIATE FIX FOR THIS AND IT IS A DANGEROUS SITUATION. *TR

Mileage: 106,000

AIR BAG LIGHT GOES ON AND OFF. INTERMITTENTLY. FAULTY CONNECTOR UNDER DRIVERS SEAT. CHRONIC PROBLEM WITH C6 CORVETTES. *TR

Mileage: 39,000

ABOUT EVERY DAY WHILE DRIVING MY CORVETTE. THE SERVICE ACTIVE HANDLING LIGHT WILL COME. AND MY BRAKES WILL START JERKING. ALSO THE AIR BAG LIGHT KEEPS COMING ON AND GOING OFF THE WHOLE TIME I DRIVE IT. I HAVE SEEN MANY OTHER PEOPLE HAVING THE SAME PROBLEMS WITH THERE 05 CORVETTES. SOMETHING NEEDS DONE ABOUT THIS. GM NEEDS TO STEP UP AND RECALL FOR THESE PROBLEMS BEFORE SOMEONE REALLY GETS HURT.. PLEASE HELP. *TR

Mileage: 118,000

RED AIR BAG LIGHT STARTED COMING ON INTERMITTENTLY AND HAS CONTINUED DOING IT FOR THE PAST 6 YEARS. THE PAST 4 MONTHS OR SO IT NOW STAYS ON CONSTANTLY. *TR

Mileage: 88,000

AIR BAG LIGHT GOES ON IF I MOVE THE DRIVERS SEAT FORWARD PAST A CERTAIN POINT. DEALER REPLACED THE WIRING HARNESS 2 YEARS AGO BUT THE PROBLEM DID NOT GO AWAY. *TR

Mileage: 60,000

SEVERAL YEARS AGO AIRBAG RED LIGHT CAME ON INDICATING AIRBAGS INOPERATIVE. G M MECHANIC FIXED BY REFASTENING SOMETHING UNDER DRIVER'S SEAT. RECENTLY RED LIGHT FOR AIR BAGS BEING INOPERATIVE HAS BEEN INTERMITTENTLY COMING ON AGAIN. I WILL HAVE G M MECHANIC REFIX. HOWEVER, THIS IS A WELL KNOWN PROBLEM BY A LOT OF CORVETTE OWNERS.. ANOTHER CORVETTE PROBLEM IS THE RECENT HEADLIGHTS TURNING OFF RECALL. RECEIVED RECALL NOTICE SEVERAL MONTHS AGO, BUT THERE ARE NO PARTS AVAILABLE FOR G M TO BE ABLE TO FIX THIS. BOTH OF THE ABOVE ARE CERTAINLY LIFE AND SAFETY ISSUES THAT SHOULD RECEIVE BETTER ATTENTION THANK YOU *TR

Mileage: 70,000

TL* THE CONTACT OWNS 2005 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING AT 10 MPH, THE CHECK AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC BUT IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 2,000.

Mileage: 2,000

MY AIR BAG INDICATOR LIGHT COMES "INTERMITTENTLY". THIS HAPPENS AT LEGAL OPERATING SPEEDS AND NORMAL CONDITIONS. IT WILL EVEN HAPPEN WHILE STANDING STILL. GM RECALLED A NUMBER OF BUICKS AND GMCS THAT HAVE A PROBLEM WITH THE AIRBAG WARNING LIGHT STAYING ON (SOME 2008-2009 AND ALL 2010-2013 BUICK ENCLAVE AND GMC ACADIA, SOME 2009 AND ALL 2010-2013 CHEVROLET TRAVERSE, AND SOME 2008-2009 AND ALL 2010 SATURN OUTLOOK TO REPAIR THE WIRING HARNESS OF SEAT MOUNTED SIDE AIR BAGS). THE FIX WAS TO SPLICE THE HARNESSES AND SOLDER THE WIRES TOGETHER! COULD THIS BE A FIX FOR THE CORVETTE TOO? SHOULD THE CORVETTE HAVE BEEN INVOLVED IN THIS RECALL? *TR

Mileage: 12,500

RED AIR BAG LIGHT STARTED COMING ON INTERMITTENTLY AND HAS CONTINUED DOING IT FOR THE PAST 6 YEARS. THE PAST 6 MONTHS OR SO IT NOW STAYS ON CONSTANTLY. *TR

Mileage: 7,500

CHECK AIR BAG LIGHT IS ON AGAIN. IT GOES OFF AND ON RANDOMLY. WHEN IS THIS GOING TO BE CORRECTED? MY CORVETTE HAS BEEN AT THE DEALER NUMEROUS TIMES FOR THIS ISSUE. THEY JUST MOVE THE WIRES UNDER THE SEAT AND THE LIGHT GOES OUT FOR AWHILE. AT ONE POINT THEY SAID THE PRE-TENSIONER WAS DEFECTIVE AND REPLACED IT. I HAD AN EXTENDED WARRANTY AT THE TIME AND PAID MY $200 DEDUCTIBLE. A FEW MONTHS LATER THE LIGHT WAS BACK AND MY DEALER WAS SHUT DOWN BY GM. IT WENT OUT BECAUSE THEY MOVED THE WIRES NOT BECAUSE OF A DEFECTIVE TENSIONER. THEIR TECH 11 SAW AN OPEN CIRCUIT, NOT A DEFECTIVE TENSIONER. THEY OWE ME $200. THAT'S A LAUGH. I ZIP TIED THE CONNECTOR'S UNDER THE SEAT. THAT LAST FOR AWHILE AND THE LIGHT COMES BACK. THIS PROBLEM IS THE EXACT PROBLEM THAT THE BUICK WAS RECALLED FOR. THE SAME FIX IS REQUIRED FOR THE CORVETTE. A CONNECTOR UNDER THE SEAT NEEDS TO BE REMOVED AND THE WIRES SOLDERED TOGETHER ARE WE WAITING FOR A DEATH? IT WILL HAPPEN SOONER OR LATER. THE AIR BAG WILL NOT DEPLOY WHEN THE LIGHT IS ON. I HAVE FILED MANY COMPLAINT'S WITH THE NHTSA AND SO HAVE MANY MEMBERS OF THE C6 CORVETTE FORUM WITH NO LUCK OR RESPONSE TO LET US KNOW THAT YOU EVEN READ THEM. I CONTINUE TO HOPE TO GET A CHANCE TO TALK TO YOU. PLEASE CALL OF EMAIL ME.

Mileage: 36,100

I WAS DRIVING ON THE HIGHWAY SERVICE HANDLING TRACTION SYSTEM LIGHT CAME ON AND CAR WENT TO RIGHT AND L RAN IN A DITCH 11000 DOLLARS IN DAMAGE AND NOT ONE AIR OPEN. *TR

Mileage: 110,000

WHAT ARE YOU WAITING FOR? THE C6 (2005-2013) CORVETTE HAS A SERIOUS CHECK AIR BAG LIGHT PROBLEM. THERE WERE 215,000 PRODUCED AND MOST ALL OF THEM HAVE THE PROBLEM AND THE DEALERS WILL NOT DO ANYTHING. MANY OWNERS DRIVE EVERY DAY WITH THE CHECK AIR BAG LIGHT ON 100% OF THE TIME MEANING THE SYSTEM WILL NOT WORK WHEN NEEDED. I HAVE COMPLAINED ABOUT THIS MANY TIMES AND OTHER OWNERS ON THE CORVETTE FORUM HAVE ALSO. THERE ARE AROUND 20,000 MEMBERS AND WE FEEL WE ARE BEING IGNORED BY THE NHTSA AND GENERAL MOTORS. THE BUICK RECALL IS FOR THE EXACT SAME THING AND THE EXACT SAME THING IS CAUSING IT. THE WIRING UNDER THE DRIVERS SEAT. ARE WE WAITING FOR A SERIOUS ACCIDENT? PLEASE CALL ME FOR MORE INFORMATION. *TR

Mileage: 35,500

MY AIRBAG WARNING LIGHT CONTINUES TO STAY ON WHILE DRIVING. *TR

Mileage: 44,000

WHAT ARE YOU WAITING FOR? THE C6 CORVETTE (2005-2013) HAS BEEN REPORTED HUNDREDS OF TIMES FOR THE CHECK AIR BAG LIGHT BEING RANDOMLY ON AND OFF. THE PROBLEM IS THE SAME AS THE BUICK THAT WAS RECALLED. ARE WE WAITING FOR A DEATH? I HOPE NOT. I AM ONLY ONE THAT HAS REPORTED THIS MANY TIMES IN THE LAST NINE YEARS. CHECK MY PREVIOUS COMPLAINTS FOR A COMPLETE LIST OF ALL THE DETAILS EVEN A LETTER FROM GM ADMITTING THEY HAVE KNOWN ABOUT THE PROBLEM FOR YEARS. IS IT BECAUSE ONLY 215,000 C6 CORVETTES WERE PRODUCED? IF ANYONE READS THIS AND WANTS TO TALK TO ME, EMAIL ME AT [email protected] OR CALL ME AT THE NUMBER BELOW. *TR

Mileage: 5,000

THE AIR BAG LIGHT IS LIT SOLID WHEN THE CAR IS ON AND WILL NOT SHUT OFF. THIS IS A COMMON PROBLEM WITH EARLY MODEL YEAR C6 CORVETTES (2005 - 2007) AND GM HAS NOT ISSUED A RECALL ON IT. THERE ARE MANY MEMBERS ON THE CORVETTE FORUM WEBSITE AT HTTP://WWW.CORVETTEFORUM.COM/ WHO HAVE THE SAME EXACT ISSUES. GM HAS ISSUED MANY RECALLS IN THE PAST MONTH REGARDING LIT AIR BAG LIGHTS ON OTHER CARS. WHY HAS THE CORVETTE BEEN EXCLUDED? IT IS A BIG SAFETY ISSUE IF THE AIR BAG DOES NOT DEPLOY IN AN ACCIDENT. I WENT TO CRANE CHEVROLET IN NJ WITH THE AFTERMARKET WARRANTY THAT I BOUGHT WITH MY CAR FOR $2200 AND THEY REFUSED TO HONOR IT. AND THE DEALERSHIP WANTS $100 JUST TO RUN A SCAN TO SEE WHAT THE PROBLEM IS. THEN IT CAN BE ANYWHERE FROM A FEW HUNDRED TO ALMOST A THOUSAND DOLLARS TO FIX DEPENDING ON WHAT PART OF THE AIR BAG SYSTEM IT IS. *TR

Mileage: 2,200

AIR BAG INDICATOR LIGHT ON DASH STAYS ON, FOUND CONNECTOR UNDER DRIVERS SEAT WORKS ITSELF LOOSE AFTER REPEATED SEAT MOVEMENT. *TR

Mileage: 39,656

THE AIRBAG SAFETY LIGHT CONTINUES TO GO OFF BETWEEN 2000 AND 2500 RPMS. GM KNOWS ABOUT THE ISSUE, BUT HAS NOT ISSUED A SAFETY RECALL. THE FIX IS TO REGROUND A WIRE UNDER THE SEAT, BUT NO DIAGRAM HAS BEEN PROVIDED BY GM DETAILING HOW TO DO THIS. *TR

Mileage: 62,000

CHECK AIR BAG LIGHT. WHAT IS TAKING SO LONG. THIS HAS BEEN AN ON GOING ISSUE WITH THE 2005 THRU 2013 CHEVROLET CORVETTE. WE HAVE COMPLAINED TO THE NHTSA BY THE HUNDREDS IF NOT MORE. THE DEALERS DON'T KNOW HOW TO FIX IT. GM ENGINEERING SENT ME A LETTER (I SENT IT TO YOU) ADMITTING THEY KNOW ABOUT THE PROBLEM BUT HAVE NO PLANS ON A RECALL. ARE WE WAITING FOR A DEATH? GM RECALLED THE BUICK FOR THE EXACT SAME PROBLEM AS THE CORVETTE. THEY ARE REMOVING A DEFECTIVE CONNECTOR UNDER THE DRIVERS SEAT AND SOLDERING THE WIRES. WE CORVETTE OWNERS CAME UP WITH THAT PLAN MANY MONTHS AGO. I AM RELUCTANT TO DO IT MYSELF FOR LEGAL REASONS. I'M A MEMBER OF THE CORVETTE FORUM WITH OVER 26,200 POST AND THIS ISSUE IS DISCUSSED EVERY DAY. HELP. *TR

Mileage: 35,600

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE SERVICE ACTIVE HANDLING SYSTEM WARNING LAMP ILLUMINATED AS THE VEHICLE DECELERATED INDEPENDENTLY. ALSO, THE CONTACT MENTIONED THAT THE PASSENGER SIDE AIR BAG WARNING LAMP ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN PERFORMED THE REPAIRS FOR NHTSA CAMPAIGN NUMBER: 10V172000 (STEERING). THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 60,000.

Mileage: 55,000

THIS IS A LETTER SENT TO ME ABOUT THE CHECK AIR BAG LIGHT AND THAT THEY KNOW ABOUT IT AND HAVE NO PLANS ON DOING ANY THING ABOUT IT. I HOPE THINGS HAVE CHANGED. PLEASE CONTACT ME FOR ADDITIONAL INFORMATION. I HAVE NUMEROUS EMAILS FROM GM ON THE SUBJECT. [XXX] I AM SORRY THAT IT HAS TAKEN ME SOMETIME TO GET BACK TO YOU ABOUT YOUR AIR BAG LIGHT, I HAD TO SPEAK WITH INTERNAL RESOURCES. THE AIR BAG LIGHT CONCERN IS CAUSED BY THE SEAT BELT CONNECTOR UNDER THE DRIVERS SEAT COMING LOOSE. THERE WAS A CHANGE MADE IN 2008 THAT MOVED THE CONNECTOR THAT HELPS SOME BUT DID NOT COMPLETELY REMEDY IT. IT CAN ALSO BE SEEN IN FEWER NUMBERS IN 2008 ? 2010. IT WAS DRIVEN BY THE CONNECTOR BEING PLACED DIRECTLY UNDER THE SEAT CUSHION. WHEN A CUSTOMER USES EASY EXIT OR MEMORY SO THE SEAT MOVES AT EACH DOOR OPENING IT WILL WORK THE CONNECTOR LOOSE OVER TIME. THE FIX WAS TO ATTACH IT TO THE SEAT FRAME SO IT DID NOT GET DRUG ACROSS THE BOTTOM OF THE CARPET. IN 2008 THEY MADE THE WIRE A LITTLE LONGER TO MOVE THE CONNECTOR OUT OF THE WAY. I AM NOT AWARE OF ANY DISCUSSION FOR A RECALL OR CUSTOMER SATISFACTION ACTION BECAUSE IT WAS SELF-DECLARING. I AM SORRY THIS IS NOT THE RESOLUTION THAT YOU WISHED FOR ON THIS MATTER. I DID LOOK INTO THE CONCERN AND I DID SPEAK WITH THE APPROPRIATE DEPARTMENTS. I AM SORRY TO BE THE ONE TO BRING YOU THIS NEWS. I DO THANK YOU FOR BEING DILIGENT IN REACHING OUT TO ME. I DO HOPE YOU HAVE A GOOD HOLIDAY, [XXX] CHEVROLET CUSTOMER CARE INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 35,600

AIRBAG LIGHTS WILL FLASH AT RANDOM OR STAY LIT. THIS INDICATED THAT THE SYSTEM WILL NOT FUNCTIION. GM IS AWARE OF THE ISSUE, A FRAIL GROUND SIGNAL, AND WILL NOT FIX THE ISSUE. *TR

Mileage: 62,000

I HAVE COMPLAINED TO GM AND NHTSA MANY TIMES ABOUT THIS WITH NO HELP FROM EITHER. THE AIR BAG SYSTEM ON THE C6 (2005 - 2012) CORVETTE IS DEFECTIVE. THE CHECK AIR BAG LIGHT GOES OFF AND ON AT RANDOM. WE KNOW WHAT IS CAUSING IT BUT GM WILL NOT FIX IT. I JUST RECEIVED THE LETTER BELOW FROM GM EXPLAINING THE PROBLEM AND WHAT IS CAUSING IT. THEY ADMIT THEY KNOW THERE IS A PROBLEM BUT HAVE NO PLANS ON CORRECTING IT. THOUSANDS OF CORVETTE FORUM MEMBERS COMPLAIN ABOUT THIS. WE HAVE COME UP WITH OUR OWN TEMPORARY FIX UNTIL GM REDESIGNS THE DEFECTIVE (BAD DESIGN) CONNECTOR UNDER THE SEAT. WE ZIP TIE IT TOGETHER. MANY MEMBERS DRIVE WITH THE LIGHT ON ALL THE TIME. GM WILL NOT TELL US IF THE BAG WILL DEPLOY WHEN THE LIGHT IS ON. I'M SURE IT WONT. ARE WE GOING TO WAIT FOR SOMEONE TO BE KILLED TO FIX IT? I HOPE NOT. LETTER FROM GM THE AIR BAG LIGHT CONCERN IS CAUSED BY THE SEAT BELT CONNECTOR UNDER THE DRIVERS SEAT COMING LOOSE. THERE WAS A CHANGE MADE IN 2008 THAT MOVED THE CONNECTOR THAT HELPS SOME BUT DID NOT COMPLETELY REMEDY IT. IT CAN ALSO BE SEEN IN FEWER NUMBERS IN 2008 ' 2010. IT WAS DRIVEN BY THE CONNECTOR BEING PLACED DIRECTLY UNDER THE SEAT CUSHION. WHEN A CUSTOMER USES EASY EXIT OR MEMORY SO THE SEAT MOVES AT EACH DOOR OPENING IT WILL WORK THE CONNECTOR LOOSE OVER TIME. THE FIX WAS TO ATTACH IT TO THE SEAT FRAME SO IT DID NOT GET DRUG ACROSS THE BOTTOM OF THE CARPET. IN 2008 THEY MADE THE WIRE A LITTLE LONGER TO MOVE THE CONNECTOR OUT OF THE WAY. I AM NOT AWARE OF ANY DISCUSSION FOR A RECALL OR CUSTOMER SATISFACTION ACTION BECAUSE IT WAS SELF-DECLARING. [XXX] CHEVROLET CUSTOMER CARE THE NEW OWNER'S CENTER IS HERE, VISIT MY.CHEVROLET.COM! __________________ THE NEW OWNER'S CENTER IS HERE, VISIT MY.CHEVROLET.COM! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 35,550

I HAVE HAD AN INTERMITTENT AIR BAG LIGHT ON/OFF FOR 8 YEARS. *TR

Mileage: 2,450

THE AIR BAG LIGHT CAME ON A FEW WEEKS AFTER I BOUGHT THE CAR AND WILL NOT GO OFF. CAR HAD APPROXIMATELY 2,300 MILES ON IT AT THE TIME. IT IS A SOLID LIGHT THAT IS ALWAYS ON AS LONG AS THE CAR IS ON. I TOOK IT TO A DEALERSHIP (CRANE CHEVROLET) AND THEY SAID THEY WILL NOT HONOR THE WARRANTY THAT I PURCHASED FOR $2000 FROM THE GRAY CHEVROLET DEALERSHIP IN PENNSYLVANIA (ALSO WHERE I BOUGHT THE CAR). GRAY TOLD ME THE WARRANTY IS GOOD AT ANY GM DEALERSHIP IN THE COUNTRY. I AM GOING TO CALL ANOTHER LOCAL CHEVROLET DEALERSHIP AND SEE WHAT THEY CAN DO. *TR

Mileage: 2,300

I HAVE COMPLAINED ABOUT THIS MANY TIMES WITH NO HELP OR RESPONSE FOR NHTSA OR GM. PLEASE READ MY PREVIOUS REQUEST FOR HELP. CONFIRMATION NUMBERS 10546935,10544479,10489161, 10511438 AND MAYBE OTHERS. IT HAPPENED AGAIN TODAY. I FIXED IT AGAIN WITH ZIP TIES. I HOPE IT WORKS IF I HAVE AN ACCIDENT. THIS IS A COMMON PROBLEM WITH ALL C6 2005 THRU 2013 CORVETTES. I EVEN READ ABOUT A NEW C7 CORVETTE WITH A CHECK AIR BAG LIGHT. IF YOU READ MY OTHER COMPLAINTS YOU WILL SEE I'VE HAD IT IN THE DEALERS MANY TIMES. THEY EVEN REPLACED A SEAT BELT PRE-TENSIONER THAT I PAID FOR WITH NO LUCK. WE KNOW WHAT THE PROBLEM IS. IT'S THE CONNECTORS UNDER THE SEAT. THEY ARE DEFECTIVE AND NEED TO BE REDESIGNED AND REPLACED BEFORE SOMEONE IS KILLED BECAUSE THE AIR BAG FAILED TO DEPLOY. YOU CAN GOOGLE IT AND SEE MANY POST ON THE SUBJECT. I'M A MEMBER THE CORVETTE FORUM WITH OVER 25,000 POST. IT IS A TOPIC OF DISCUSSION OFTEN. OUR QUESTION THAT NO ONE WILL ANSWER IS WILL THE AIR BAG DEPLOY WHEN THE CHECK AIR BAG LIGHT IS ON? OF COURSE NO ONE WILL ANSWER THAT. MANY OWNERS HAVE GIVEN UP AND DRIVE AROUND WITH LIGHT ON. *TR

Mileage: 35,550

I HAVE COMPLAINED TO THE NHTSA SEVERAL TIMES WITH NO HELP. YOU ARE OUR LAST HOPE TO CORRECT THIS SAFETY ISSUE BEFORE SOMEONE IS KILLED OR SERIOUSLY INJURED. THE CHECK AIR BAG LIGHT ON THE C6 CORVETTE (2005 THRU 2013) COMES ON OFTEN. I'M A MEMBER OF THE CORVETTE FORUM WITH OVER 25,000 POST AND I KNOW THAT THIS IS AN ISSUE WITH MOST IF NOT ALL C6 CORVETTES. I HAVE COME UP WITH A TEMPORARY FIX. I INSTALL ZIP TIES AROUND THE CONNECTOR UNDER THE SEAT THAT IS FOR THE PRE-TENSIONER. THAT WILL TAKE CARE OF THE PROBLEM FOR AWHILE. LAST TIME IT WAS ONLY A MONTH BUT OTHER TIMES IT WILL LAST FOR UP TO A YEAR. CHECK OUT MY PREVIOUS COMPLAINTS AND YOU WILL SEE THAT I'VE HAD IT IN THE DEALERS MANY TIMES FOR THIS ISSUE. THEY EVEN CHARGED ME FOR A PRE-TENSIONER THAT WAS NOT THE PROBLEM. THEY KNOW LIKE MY BUDDIES ON THE CORVETTE FORUM KNOW GM NEEDS TO DESIGN AND INSTALL NEW AND IMPROVED CONNECTORS. WE DON'T KNOW IF THE AIR BAG WILL DEPLOY IF THE LIGHT IS ON. MOST OF MY BUDDIES USE THE SAME ZIP TIE TRICK. I HOPE YOUR WILL GIVE THIS ISSUE SERIOUS CONSIDERATION BEFORE YOU IGNORE IT AGAIN. I SEE AUTOS RECALLED FOR MANY PROBLEMS THAT MAY OR MAYBE THIS SERIOUS AND I HOPE THE CORVETTE WILL BE RECALLED SOON. *TR

Mileage: 35,525

I BOUGHT A NEW 2005 CORVETTE 4/5/2005. SINCE NEW THE CHECK AIR BAG LIGHT GOES OFF AND ON. THIS IS A SERIOUS PROBLEM THAT MOST OF THE 215,000 C6 OWNERS EXPERIENCE. I AM A MEMBER OF THE CORVETTE FORUM AND IT IS DISCUSSED OFTEN. MANY DEALERS ACROSS THE US CLAIM THEY HAVE NEVER HEARD OF THE PROBLEM. IN MY CASE IT STARTED SHORTLY AFTER I PURCHASED THE C6. EVERY TIME I TOOK IT TO THE DEALER THEY TOLD ME TO RETURN WHEN THE LIGHT WAS ON. THAT WAS ALMOST IMPOSSIBLE BECAUSE IT GOES OFF AND ON. SOMETIMES A WEEK OR MORE GOES BY AND IT'S OKAY. FINALLY WHEN MY WARRANTY WAS UP BUT I HAD AN EXTENDED WARRANTY I GOT IN WITH THE LIGHT ON AND THEY GOT A CODE. IT WAS THE DRIVERS SEAT SEATBELT PRE-TENSIONER. THAT DIDN'T FIX THE PROBLEM AND GM SHUT DOWN DEALERS ACROSS THE US AND MINE WAS ONE OF THEM. THE MEMBERS ON THE CORVETTE FORUM DIAGNOSED THE PROBLEM AS DEFECTIVE (BAD DESIGN) WIRE CONNECTORS UNDER THE SEAT. EVERY TIME THE MEMORY SEAT MOVES IN AND OUT IT LOOSENS CONNECTOR. I CAME UP WITH THE PLAN TO ZIP TIE THE CONNECTOR TOGETHER. NOW OWNER'S ACROSS THE US USE THIS METHOD. IT WORKS TEMPORARILY. SOMETIMES FOR A YEAR OR MORE BUT NOW THAT MY AND OTHERS CORVETTES HAVE A FEW MILES ON THEM THE PROBLEM IS GETTING WORSE. I HAVE TO REPLACE AND ENLARGE THE ZIP TIES MORE OFTEN. I DID IT A FEW WEEKS AGO AND TODAY THE CHECK AIR BAG LIGHT CAME ON AGAIN. THIS IS A SERIOUS SAFETY ISSUE. GM CAN'T OR WON'T ANSWER THE QUESTION "WILL THE AIR BAG WORK WHEN THE CHECK AIR BAG LIGHT IS ON". I'M SURE THEY CAN'T ANSWER THAT. I HAVE FILED THIS COMPLAINT WITH THE NHTSA SEVERAL TIMES WITH NO HELP. WHAT WILL IT TAKE TO GET SOME HELP WITH THIS SERIOUS PROBLEM. WILL GM CLAIM THEY DIDN'T KNOW ABOUT THE PROBLEM? THERE IS A GM CUSTOM CARE EMPLOYEE ON THE CORVETTE FORUM AND HE CLAIMS HE HAS GIVEN THIS INFORMATION TO THE ENGINEERS SEVERAL TIMES. *TR

Mileage: 35,500

SEVERAL YEARS INTO OWNERSHIP (I PURCHASED NEW) I NOTICED INTERMITTENT AIR BAG WARNING LIGHT WHILE DRIVING. IT WOULD NOT STAY PERSISTENT. THIS WOULD HAPPEN INFREQUENTLY. SEVERAL YEARS LATER THE AIRBAG LIGHT MORE FREQUENTLY WOULD FLASH BUT NOT STAY PERSISTENT. NOW THE LIGHT IS PERMANENTLY ON. NO ACCIDENTS HAVE TRIGGERED THE AIR BAG LIGHT. NO MODIFICATIONS TO THE AIR BAG SYSTEM HAVE BEEN IMPLEMENTED. NO MODIFICATIONS TO THE SAFETY SYSTEMS AT ALL. EVERY DAY DRIVING AND USE AND FOR NO APPARENT REASON THE AIR BAG SAFETY SYSTEM HAS BEEN RENDERED DISABLED BY THE CARS SYSTEMS. FOR THE 2005-2013 CORVETTES OWNERS BELIEVE THAT ONE OR SEVERAL OF THE FOLLOWING MAY CONTRIBUTE TO THE FAILING AIR BAG SYSTEM: SEAT PRETENSIONER, UNDER SEAT WIRING HARNESS, UNDER SEAT WIRING CONNECTORS, THE POWER SEAT CONTROLS HAVING AN INFLUENCE ON THE FUNCTIONING OF THE AIR BAG SYSTEM. *TR

Mileage: 30,000

AIR BAG LIGHT ON THE INSTRUMENT CLUSTER LIT UP AND WILL NOT GO AWAY. I READ ABOUT THIS ISSUE FROM 100S OF PEOPLE ON THE CORVETTE FORUMS, SO IT IS A MAJOR PROBLEM. *TR

Mileage: 2,300

SINCE SHORTLY AFTER THE CAR WAS NEW, I HAVE HAD REPEATED PROBLEMS WITH THE AIRBAG MALFUNCTION INDICATOR LIGHTING UP. I HAVE TAKEN THE CAR TO VARIOUS AUTHORIZED DEALERS NUMEROUS TIMES TO HAVE THE PROBLEM REPAIRED. IN ALL CASES, THE PROBLEM SEEMS TO GET CORRECTED BUT THEN REAPPEARS ANYWHERE FROM SEVERAL WEEKS TO SEVERAL MONTHS LATER. IT'S MY UNDERSTANDING THAT WHEN THE AIRBAG MALFUNCTION INDICATOR IS ILLUMINATED THE AIRBAG SYSTEM IS NON-FUNCTIONAL. *TR

Mileage: 4,500

I HAVE COMPLAINED ABOUT THIS SEVERAL TIMES WITH NO LUCK. THE C6 CORVETTE WAS PRODUCED FROM LATE 2004 UNTIL EARLY 2013 AND APPROXIMATELY 215,000 WERE PRODUCED. THE CHECK AIR BAG LIGHT HAS BEEN A PROBLEM FROM DAY ONE. MANY OWNERS HAVE HAD OR HAVE THE PROBLEM. MANY DEALERS SAY THEY DON'T KNOW WHAT TO DO ABOUT IT. IN MY CASE I TOOK IT TO THE DEALER NUMEROUS TIMES AND WAS TOLD IF THE LIGHT WASN'T ON WHEN I TOOK IT IN THEY COULDN'T HELP ME. FINALLY AFTER MY THEE YEARS WARRANTY WAS UP THEY WERE ABLE TO GET A CODE. A PRE-TENSIONER WAS REPLACED AND ALL WAS WELL FOR SEVERAL MONTHS. BY THIS TIME MEMBERS OF THE CORVETTE FORUM DIAGNOSED THE PROBLEM AS DEFECTIVE CONNECTORS UNDER THE SEAT. AS THE SEAT MOVED IN AND OUT THEY WOULD COME LOOSE. I CAME UP WITH A PLAN TO ZIP TIE THE CONNECTORS. MANY MEMBERS USED MY METHOD AND WERE HAPPY. AFTER SEVERAL YEARS I HAD TO REDO MINE WITH HEAVER ZIP TIES BECAUSE THE CHECK AIR BAG LIGHT CAME BACK. MANY MEMBERS STILL HAVE THE PROBLEM AS DO MANY OTHERS. DO A GOOGLE SEARCH AND YOU WILL SEE WHAT I'M TALKING ABOUT. WHEN WILL SOMEONE BE SERIOUSLY INJURED OR KILLED? I SEE MANY OTHER AUTOS HAVE BEEN RECALLED FOR THE SAME ISSUE. PROBABLY BECAUSE THEY ARE HIGHER PRODUCTION AUTOS. I HOPE SOMETHING CAN BE DONE ABOUT THIS BEFORE SOMETHING SERIOUS HAPPENS. *TR

Mileage: 35,000

MY CHECK AIR BAG DASH BOARD LIGHT CONTINUES TO GO OFF AND ON. IT WAS TAKEN TO THE DEALER SEVERAL TIMES AND I WAS TOLD UNLESS IT WAS ON WHILE I WAS THERE THE PROBLEM COULD NOT BE DIAGNOSED. FINALLY IN 2008 I WAS ABLE TO DRIVE TO THE DEALER WITH THE CHECK AIR BAG LIGHT ON. THE CODE SAID THE DRIVERS PRE-TENSIONER NEEDED TO BE REPLACED. THAT WAS DONE A FEW DAYS LATER AND THE LIGHT STAYED OFF FOR SEVERAL MONTHS. WHEN IT RETURNED I WAS TOLD IF THEY COULDN'T SEE THE LIGHT NO CODE WAS SET. I SPEND A LOT OF TIME ON THE CORVETTE FORUM. (OVER 24,000 POST) THIS IS A VERY COMMON PROBLEM WITH THE 2005 TO CURRENT CORVETTE. THE OWNERS HAVE DIAGNOSED THE PROBLEM AS DEFECTIVE CONNECTORS UNDER THE SEATS. THE AUTOMATIC SEATS MOVING CAUSES THE CONNECTORS TO LOOSEN AND THE LIGHT WILL COME ON. I CAME UP WITH A SIMPLE SOLUTION THAT MANY OF US DO OUR SELVES. WE ZIP TIE THE CONNECTOR TOGETHER. IN MY CASE IT WORKED FOR SEVERAL YEARS BUT THE LIGHT HAS STARTED APPEARING AGAIN. THIS IS NOT ALWAYS THE PROBLEM AS FORUM MEMBERS HAVE HAD COMPONENTS REPLACED THAT SEEMED TO HELP. IT'S AN ON GOING PROBLEM AND ONE OF THESE DAYS A CORVETTE AIR BAG WILL NOT DEPLOY DURING AN ACCIDENT. GM DOESN'T SEEM TO CARE. *TR

Mileage: 3,000

TL* THE CONTACT OWNS A 2005 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT KEPT ILLUMINATING. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HER THAT WHEN SHE MOVED HER SEAT BACK AND FORTH, IT FRACTURED THE WIRE FOR THE AIR BAGS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 27,000.

Mileage: 27,000

I FILED MY FIRST COMPLAINT 8/1/08 WITH NHTSA AND NOTHING HAS CHANGED. MY NUMBER IS 10236693. MY AIR BAG WARNING LIGHT GOES OFF AND ON. I TOOK IT TO THE DEALER AND OF COURSE THE LIGHT WAS OFF. THEY SAID TO BRING IT BACK WHEN THE LIGHT IS ON. I'VE HAD THE CAR OVER FOUR YEARS AND IT'S NEVER ON LONG ENOUGH TO TAKE IT IN. HOW LONG DO I HAVE TO DRIVE IT NOT KNOWING IF I'M PROTECTED? *TR

Mileage: 6,000

CHECK AIR BAG LIGHT COMES ON OFTEN. IT WILL STAY ON FOR A MINUET OR UP TO 7 OR 8 MINUTES. I AM A MEMBER OF THE CORVETTE FORUM WITH OVER 15,000 POST. IT IS A PROBLEM THAT MANY C6 CORVETTE OWNERS HAVE WITH LITTLE TO NO LUCK GETTING IT FIXED. I HAVE HAD THIS PROBLEM OFF AND ON SINCE 2005. ONE PERIOD IT WENT FOR OVER A YEAR WITH NO PROBLEM. I AM TRYING TO WAIT UNTIL THE LIGHT STAYS ON TO TAKE IT TO THE DEALER. I KNOW HOW HARD IT IS TO TROUBLE SHOOT AN INTERMITTENT PROBLEM. MANY FORUM MEMBERS HAVE HAD IT FIXED ONLY TO HAVE TO LIGHT COME ON AGAIN. NO MEMBERS HAVE HEARD OF A FOR SURE FIX. I WONDER IF MY AIR BAGS EVEN WORK AND HOW DOES THE DEALER KNOW THEY WORK IF THEY CAN'T FIX THE LIGHT? *TR

Mileage: 6,000