2009 CHEVROLET CORVETTE Fuel/propulsion System Problems

Approximately 2 months ago I noticed a faint gasoline odor when I entered our garage. I thought that it might be due to a recent re-call on my Honda Gold Wing which involved the fuel system. The motorcycle was repaired by the dealer, returned and I never rode it until yesterday. The smell went away. I filled the Corvette, probably 3 weeks ago and the odor returned. We parked my wife's Mazda outside but the odor continued with the Corvette inside, in its normal space. I checked the floor under each vehicle, diligently, and thankfully no liquid fuel was apparent. Parking the Corvette outside, the odor went away and perhaps the same day, when leaving an evening event, I placed some folding chairs in the "trunk" of the Corvette and noticed the odor. The following day, I went to the Chevrolet dealer I normally have repair work done to make arrangements to bring it in for inspection and did so on September 8th. A few days later, I was advised that there was a leak at the top of the left tank and that the tank would have to be removed and re-sealed at the top where there is an entry area for a part involved with the fuel system. The dealer advised that they thought there was a re-call for this matter but found that either there wasn't one or it expired. I forget which. My search on GM's website for recalls as well as yours, doesn't indicate that there was one BUT this is really a serious matter and the fix is expensive. I bought the vehicle from the original owner, who is a retired GM engineer for their manufacturing plants. It has not been in an accident.

Unknown. Gasoline fumes when parked with over a half tank of fuel. Fills my garage with the smell..purchased this in 2022 and I was unaware of this problem until I put it in my garage after filling the tank completely.

Fuel leak issue. I have a fuel leak coming from a faulty fuel pump on the driver'side. Very dangerous. Leaking down on side of tank. Could possibly leak down onto exhaust.GM said there was nothing they could do. I have taken it to Landers Mclarty Chevrolet in Huntsville, AL for replacement. Cost is $1963.02. There should have been a recall instead of a special advisory since they admitted it was a faulty plastic that causes the problem.

fuel leak on driver side tank elbow on gas pump is cracked. Low beam headlights do not work, high beams are ok.

warning light came on checked code p0442 came up stating a small vapor leak in fuel system. replaced fuel cap , smoke test and found that the evap vent solenoid was leaking. Remove and replace fuel tank vent valve program module. Still smelled fuel. Took vette to a dealership had them do a multipoint inspection they pinpointed and diagnose the problem as the left side fuel tank module and all necessary gaskets and seals needed to be replace at a out of this world price. I believe this to be a safety risk.

Strong fuel smell from defective part on fuel assembly. I was told this is a $4000 fix for a part that was knowingly bad and GM did nothing about it. This is a fire hazard and could burn my house down the gas smell in my garage is overwhelming

The vehicle in question was 14 years old with 20,950 original miles on it. This safety issue was the direct result of a faulty part from the factory [leaking fuel pump flange assembly] that manifested itself in a very strong fuel smell, both in the vehicle while driving, as well as in my garage. It was caused by raw gasoline leaking out of the primary fuel pump that was cracked and leaked out of the fitting on the top of the fuel tank. [NOTE: GM had previously acknowledged the problem in a service advisory bulletin on Jan 17, 2017 #N150682 but was not subject to a recall]. I believe this problem should have resulted in a recall, not just a Service Advisory Bulletin. This vehicle could have very easily caught fire, while driving down the highway or idling in traffic; not to mention the fact that a buildup of gasoline fumes in the confined space of a garage could have caused an explosion and / or fire. Either or both situations could have resulted in loss of life to the driver, passengers or other innocent bystanders as well as the destruction of property. There were no warning messages on the Driver Information System of the car.

Leaking fuel around defective fuel pump. Serious fire/fume hazard.

Special Coverage Adjustment 15682 Primary Tank Module Flange Fuel and Vapor Leaks The above Special Coverage Adjustment was issued by General Motors regarding fuel leakage problem in certain Corvette and Cadillac vehicles. General Motors established a date certain for the vapor and/or fuel leakage involving a failing plastic located on the left side top of the fuel cell. Unfortunately, the condition of the platic part failing is not predicable and might not be detected within the date range GM set. My 2009 Corvette is now experiencing the issue--vapor detection which means there is a small but maybe unnoticed amount of fuel actually leaking at the top of the fuel cell. Fuel leaking in area immediately above the exhaust might well result in a fire while being driven and garaged. GM should have made repairs regardless of the Company date range. GM should make repairs regardless of when the vehicle might demonstrate a hazard situation do to a part failure.

Fuel pump / Fuel tank Cracks due to bad plastic use by GM

Gasoline smell when sitting in in closed garage!

when you fill the fuel tank over half full if you park in garage by morning the garage smells of gas fumes. Also can smell while driving. car only has 39,968 miles, and no accidents. worried that this could catch fire!

Leaking fuel from faulty gas tank/fuel pump

Gas is leaking/spraying from a defective high pressure fitting on top of left side fuel tank fuel pump. My garage was full of gas fumes and a strong odor was seeping into my home. Car had to be removed from garage for fear of explosion. This is a known and very common problem with C6 Corvette fuel pumps. GM will only fix if less than 10 years old and less than 120,000 miles. Dealer first said my car would be covered and not to worry, but after disassembling and confirming this common issue, they then tell me I'm not covered and must pay out of pocket. My car is in pieces and they are waiting for a back ordered pump. My car has 45000 miles but is more than 10 years old so I must now pay $2,700. to correct a potentially deadly and well documented fuel system defect. Why is there no recall for this extremely hazardous defect?

A strong fuel odor persists around the driver's side fuel tank/fuel filler neck. This odor is stronger when the tank exceeds 5/8ths full. A Special Coverage Adjustment was issued by Chevrolet, ref #N150682, GWM #2015682 in January 2017 which extended the factory warranty to 10 years or 120,000 miles. I purchased this vehicle in July 2020 which exceeds that extended warranty. The fuel odor is a major problem as the vehicle is parked inside a closed garage and the vapors are strong enough to enter the house. Also the fuel odor is present inside the cabin as the vehicle is being driven. Chevrolet has not issued a recall on the dangerous problem and is unwilling to work with me on what will end up being an extremely expensive repair. Their best estimate is that the plastic OEM fitting on the downstream side of the fuel pump has a minor fracture causing fuel to spew out on top of the fuel tank where it eventually evaporates, leaving no evidence of fuel leaks under the car. This problem has been acknowledged by GM as the factory warranty was extended to cover repairs of a known factory issue causing the fuel leaks.

FUEL LEAK APPROXIMATELY 6" INSIDE LEFT REAR TIRE LOCATION..

Mileage: 55,000

FUEL AND VAPOR LEAK. FIRE HAZARD

MY 2009 CORVETTE HAS AN INCREASING FUEL SMELL EMANATING FROM MY CORVETTE'S DRIVER SIDE REAR WHEEL WELL. THE FUEL VAPOR SMELL IS SO STRONG THAT CAN CREATE A DANGEROUS SITUATION WHEN THE CAR IS PARK IN THE GARAGE WHERE MY GAS HOT WATER HEATER IS LOCATED. AFTER RESEARCHING THE ISSUE, I'VE COME ACROSS NUMEROUS REPORTS OF COVETTE C6 OWNERS REPORTING THE SAME ISSUE. THE CONSENSUS SEEMS TO BE THAT HAIRLINE CRACKS DEVELOP ON THE TOP OF THE FUEL TANKS CAUSING FUEL TO LEAK ON AND DOWN THE SIDE OF THE TANK. OBVIOUSLY THIS COULD LEAD TO A SERIOUS FIRE HAZARD IF IT WERE TO LEAK ON TO THE VEHICLES EXHAUST. WITH THE AMOUNT OF C6 OWNERS REPORTING THIS SAME ISSUE AND THE POTENTIAL FOR EXTREME FIRE HAZARD, I FEEL THAT GENERAL MOTORS SHOULD ADDRESS THE ISSUE. I AM THE ORIGINAL OWNER OFTHE CAR AND NEVER BEEN INFORMED BY GENERAL MOTORS ABOUT A RECALL OR A REPAIR TO CORRECT THE PROBLEM. I HOPE THAT FILING THIS REPORT WILL HELP GETTING THIS PROBLEM CORRECTED.

Mileage: 83,000

FUEL SMELL AFTER FILLING UP GAS TANK. APPARENTLY THE GAS PUMP ON DRIVERS SIDE MADE OF PLASTIC HAS TENDENCY TO CRACK. GM HAD PREVIOUSLY PAID FOR THIS REPAIR BUT LIMITED COVERAGE TO 10 YRS AND/OR 120 THOUSAND MILES. BOUGHT NEW TO ME 2009 VETTE WITH 132K MILES, DELAER NOW WANTING TO CHARGE $3300 FOR PARTS/LABOR. CANNOT PARK IN GARAGE DUE TO GAS FUMES, ALSO DANGEROUS TO DRIVE.

Mileage: 132,000

STRONG FUEL SMELL AND LEAK ON DRIVER SIDE NOTICED AFTER FUELING ONLY TO AROUND 3/4 TANK HAS BEEN THIS WAY SINCE 19800MI WHEN I BOUGHT THE CAR I SMELT GAS BUT ONLY ON 11/23/20 HAVE I SEEN FUEL ON THE GROUND

Mileage: 49,940

PROBLEM WITH STRONG FUEL SMELL AND IT IS COMING FROM BEHIND THE DRIVER SEAT.

Mileage: 66,589

SMELL OF FUEL IN CABIN WHILE DRIVING OR PARKED.

Mileage: 50,000

I BOUGHT THIS CAR LAST YEAR ON SEPTEMBER, THE CAR FOR JUST 3500 MILES, ON NOVEMBER THAT YEAR I PUT MY CAR IN STORAGE, I PICKED MY CAR UP THIS YEAR ON MARCH. TWO MONTHS AGO, I REALIZED THAT AFTER FUELING MY CAR A REALLY STRONG SMELL LIKE GAS WAS PRESENT, I CHECKED UNDERNEATH BOTH I COULDN'T SEE ANY LEAKAGE, BUT I CHECKED THE DRIVER'S SIDE GAS TANK AND IT WAS KIND OF WET, I SAW TRACES OF GAS DROPLETS. I FOUND ONLINE THAT GMC POSTED A BULLETIN TO GET FIXED THIS ISSUE ON LOTS OF C6 CORVETTES, I TOOK THAT BULLETIN TO THE DEALER AND THEY SAID THAT THE TIME FOR THAT BULLETIN EXPIRED LAST YEAR ON JUNE, I EXPLAINED TO THEM THAT I GOT THE CAR ON SEPTEMBER AND ALSO MY CAR JUST HAD 3500 MILES, BUT THE SAID THAT IF I WANT MY CAR TO GET FIXED I HAVE TO PAY. I TOLD ME THAT IT'S NOT FAIR BECAUSE THIS ISSUE IS GMC FAULT. THIS IS WHY I'M FILLING THIS COMPLAIN WITH YOU. I WAS ABLE JUST TO UPLOAD ONE PIC BUT I HAVE MORE, SHOWING THE GAS TANK WET.*DT*JB

Mileage: 3,500

FUEL LEAKING REAR DRIVERS SIDE POSSIBLE FUEL PUMP ASKED ABOUT RECALL WAS TOLD IT WAS NOT A RECALL ITEM THEN FOUND MULTIPLE COMPLAINTS OF THE SAME ISSUE AND SAME MODEL CAR HAS LESS THAN 40,000 MILES. *TR

Mileage: 39,894

NOTICEABLE FUEL SMELL WHEN SITTING IN THE CAR, AND IN GARAGE WHEN CAR HAS BEEN PARKED FOR A FEW HOURS. IT IS THIS ISSUE: HTTPS://WWW.CORVETTEFORUM.COM/FORUMS/C6-CORVETTE-GENERAL-DISCUSSION/3563123-DANGER-FUEL-LEAKS-SAFETY-RECALL.HTML. *TR

Mileage: 39,000

HEAVY FUEL ODOR FROM CAR WHEN PARKED IN GARAGE. NO GASOLINE DRIP ON FLOOR.

Mileage: 21,000

MY 2009 CORVETTE (BASE MODEL) IS EXPERIENCING FUEL VAPOR LEAK. THERE ARE NO LIQUID LEAKS VISIBLE BENEATH THE CAR, OR ON THE GARAGE FLOOR. THE SMELL OF FUEL IS MORE INTENSE TOWARD THE DRIVERS REAR QUARTER PANEL, NEAR THE FILLER TUBE. I HAVE CHANGED MY GAS TANK CAP AND THIS MADE NO DIFFERENCE. THE SMELL OF FUEL PERSISTS. THE SMELL IS NOT PRESENT INSIDE THE CAR, OR WHILE IN MOTION. THE SMELL IS STRONGEST WHEN THE FUEL TANK IS FILLED AND SEEMS TO DIMINISH WHEN FUELS IS 1/2 TANK OR BELOW. I AM CONCERNED OF FIRE IN THE CAR, OR IN MY GARAGE, ATTACHED TO MY HOUSE.

Mileage: 81,000

FOR THE LAST COUPLE WEEKS, I'VE NOTICED AN INCREASING FUEL SMELL EMANATING FROM MY CORVETTE'S DRIVER SIDE REAR WHEEL WELL. THE FUEL VAPOR SMELL IS NOW AT THE POINT WHERE I NEED TO PARK MY VEHICLE OUTSIDE. AFTER RESEARCHING THE ISSUE, I'VE COME ACROSS NUMEROUS REPORTS OF COVETTE C6 OWNERS REPORTING THE SAME ISSUE. THE CONSENSUS SEEMS TO BE THAT HAIRLINE CRACKS DEVELOP ON THE TOP OF THE FUEL TANKS CAUSING FUEL TO LEAK ON AND DOWN THE SIDE OF THE TANK. OBVIOUSLY THIS COULD LEAD TO A SERIOUS FIRE HAZARD IF IT WERE TO LEAK ON TO THE VEHICLES EXHAUST. WITH THE AMOUNT OF C6 OWNERS REPORTING THIS SAME ISSUE AND THE POTENTIAL FOR EXTREME FIRE HAZARD, I FEEL THAT GM SHOULD ADDRESS THE ISSUE.

AFTER FILLING THE GAS TANK THERE IS A STRONG GAS SMELL PRESENT. ONCE THE GAS LEVEL IS BELOW HALF TANK, THE ODOR IS GONE. ONLINE RESEARCH POINTS TO THE CROSSOVER TUBE, FUEL PUMP, EVAP SYSTEM ETC

Mileage: 60,000

CAR HAS A SMELL OF GASOLINE ESPECIALLY AFTER I FILL UP MY TANK, I NEVER OVER FILL THE TANK, WHEN I PARK IN MY GARAGE MY WHOLE GARAGE SMELLS LIKE GASOLINE.I SMELL IT MORE WHEN TH CARE IS STATIONERY .

Mileage: 55,000

2009 CORVETTE Z06, VERY STRONG ODOR OF FUEL BOTH IN CAB AND OUTSIDE OF VEHICLE!!! LOOKED UNDER CAR ON DRIVERS SIDE AND WAS ABLE TO SEE WET/DAMP AREAS AROUND FUEL TANK. WHAT REALLY SUCKS, IS THAT I CANT EVEN PARK IT IN MY GARAGE. THE FUMES ARE SO STRONG, I'M AFRAID SOMETHING WILL CAUSE THE FUMES TO IGNITE AND PUT EVERYONE'S LIVES IN DANGER. I LOOKED ON ALLDATADIY AND FOUND A RECALL/SERVICE BULLETIN HOWEVER, WHEN I CALLED THE DEALERSHIP, THEY SAID BASED ON MY VIN# THAT MY CAR WAS NOT AFFECTED....WTF!!!!! HOW CAN IT NOT BE? MY CAR IS DOING EXACTLY WHAT THE RECALL/SERVICE BULLETIN SAYS.

Mileage: 63,000

CONSTANT SMELL OF GASOLINE COMING FROM THE LEFT REAR OF THE CAR.

Mileage: 46,811

TAKATA RECALL WHEN THE FUEL TANK IS ABOVE 1/2 IS SMELL LIKE FUEL IN MY GARAGE THERE A RECALL I HAVE IT AT THE DEALERSHIP SERVICE WRITER CALL GMC AND TOLD HIM THAT THEY ONLY COVER 30 %,IT WAS DO AT THE END OF THE YEAR OR 120,000MIL I DON'T HAVE NONE OF THOSE IT BELOW MIL AND TIME

Mileage: 95,000

THERE IS A STRONG GAS ODOR COMING FROM THE FUEL FILLER TUBE (DRIVER'S SIDE) AREA AND AN EVEN STRONGER SMELL ON THE INSIDE OF THE COCKPIT. BUT THERE ARE NO VISIBLE LEAKS ON THE DRIVER WAY (INCLINED) OR GARAGE FLOOR. AND THERE ARE NO VISIBLE WET AREAS UNDER THE TANKS OR TANK SHIELDS. GAS ODOR IS RELATED TO GM BULLETIN #15682 DATED JULY 2016.

Mileage: 100,500

THERE IS A STRONG SMELL OF GAS IN THE WHOLE COCKPIT AFTER FILLING UP. I DON'T OVER FILL THE CAR AND I TRY NOT TO GET ANY DROPS SPEWING WHEN FILLING UP. THE SMELL IS STRONGER ON THE REAR SIDE OF DRIVER. I CAN SMELL GAS IN MY GARAGE WHEN I PARK IT IN.

Mileage: 34,000

GASOLINE SMELL REALLY BAD IN CAB. NO EVIDENCE OF FUEL LEAK ON GARAGE FLOOR. SEEMS TO BE COMING FROM TOP OF TANK, MAYBE.. GARAGE FILLS WITH THESE GASOLINE FUMES. I AM CONCERNED ABOUT THE DAMAGE THIS COULD CAUSE. SEEMS AN ON GOING ISSUE WITH 2008-2009 YEAR MODELS. WAITING YOUR REPLY..

Mileage: 49,000

FUEL LEAK

Mileage: 34,000

I'M PURCHASED THE VEHICLE A MONTH AGO AND EVER SINCE I HAD IT IT GIVES OUT A FUEL SMELL SOMETIMES IT SMEEL A LOT AND OTHER TIMES IT'S NOT AS NOTICEABLE

Mileage: 100,000

VERY STRONG GAS SMELL WHEN THE TANK IS FILLED. FILLED GARAGE WITH SMELL. WAS AFRAID TO START CAR. PUSHED OUT OF GARAGE AND LET SIT FOR 2 DAYS. STARTED AND DROVE TO DEALERSHIP.

Mileage: 46,000

FUEL SMELL AFTER FULLY FILLING THE GAS TANK. KNOW ISSUE UNDER SPECIAL COVERAGE BULLETIN 15682 BY GM.

FUEL LEAK FROM TOP OF TANK DRIVERS SIDE - DANGEROUS

Mileage: 82,000

GAS SMELL IN AND AROUND CAR. USUALLY AFTER FILLING THE GAS TANK.

Mileage: 41,000

FUEL LEAKING FROM AROUND FUEL TANK. POSSIBLY FROM FUEL PUMP AREA. STRONG GAS SMELL FILLS GARAGE OVER NIGHT. GAS CAN ALSO BE SMELT INSIDE OF THE CAR WHILE DRIVING. THIS HAPPENS REGARDLESS OF THE AMOUNT OF FUEL IN THE GAS TANK, BUT IS MORE NOTICEABLE WHEN TANK IS 1/2 OR MORE FULL.

Mileage: 45,383

STRONG GASOLINE SMELL WHENEVER THE TANK IS MORE THAN HALF FULL. SO STRONG THAT I CAN SMELL GASOLINE IN THE HOUSE IF THE CAR HAS BEEN PARKED IN THE ATTACHED GARAGE OVERNIGHT. I AM CONCERNED THAT THE HIGH CONCENTRATION OF GASOLINE VAPOR MIGHT B E A FIRE HAZARD TO THE HOUSE. I AM ALSO CONCERNED THAT GASOLINE COULD TOUCH THE EXHAUST AND CATCH FIRE WHILE DRIVING. NO ODOR WHATSOEVER WHEN THE TANK IS BELOW HALF FULL.

Mileage: 85,000

AFTER FUEL TANK IS FILLED PAST 1/2 FULL, SMELL OF FUEL IN MY GARAGE UNTIL FUEL CAPACITY GOES BELOW 1/2 FULL.

Mileage: 27,000

I'VE NOTICED A FUEL SMELL COMING FROM THE VEHICLE AFTER DRIVING. MY MECHANIC FOUND LEAKING FUEL FROM THE TOP OF THE GAS TANK. THERE WAS A RECALL FOR THIS DEFECT.

Mileage: 33,260

THIS IS MY SECOND COMPLAINT. WHEN I FILL MY GAS TANK ABOVE 1/2 A TANK I GET A STRONG SMELL OF GASOLINE IN MY GARAGE AND IN MY CAR. I FILED A COMPLAINT WITH THE AG AND WATSON CHEVY HAD MY CAR FOR 4 DAYS AND SUPPOSEDLY FIXED THE ISSUE. IT IS NOW BACK. EVERY TIME I FUEL UP AND I DO NOT FILL MY CAR TO FULL ONLY JUST ABOVE HALF A TANK AND I STILL GET THIS STRONG SMELL

Mileage: 58,451

FUEL PUMP STOP WORKING 5 YEARS AGO. AND I NEVER GOT IT FIX COST IS HIGH. WELL WHEN I WENT IN TO HAVE IT FIX THIS YEAR 2017. I WAS TOLD THERE IS GOOD NEWS. THERE IS A RECALL ON THE FUEL PUMPS, BUT THEN NEXT DAY. I WAS TOLD MY VEHICLE HAS TO MANY MILES. I NEVER WAS SENT A LETTER OR NEW ABOUT THIS. IT IS NOT RIGHT. I NEED NEW FUEL PUMPS. WILL YOU PLEASE TAKE OFF THE MILE LIMIT. AND ALLOW US OR ME TO GET MY CAR FIX

Mileage: 95,000

STRONG FUEL SMELL IN THE GARAGE WHEN IT'S PARKED. EVEN AFTER DAYS OF BEING PARKED. NO FUEL LEAKING ON THE FLOOR. CAR IS 3/4 TO FULL OF GAS WHEN PARKED. ONLY HAS 49000 MILES ON IT.

Mileage: 48,000

CAR CONSTANTLY SMELLS LIKE GASOLINE COMING FROM UNDER, INSIDE AND AROUND CAR. THERE ISN'T ANY PUDDLES BUT SMELLS STRONG I RECENTLY BOUGHT THE CAR AND IT SMELLS LIKE IT ALREADY STATIONARY WHEN SMELL

Mileage: 59,000

HEAVY FUEL SMELL COMING FROM THE LEFT FUEL TANK

Mileage: 111,000

FUEL ODOR IN CABIN EVERY MORNING AFTER BEING PARKED OUTSIDE ALL NIGHT. 5 DAYS IN A ROW. SMELL IS NOT APPARENT OUTSIDE OF VEHICLE. SMELL DISSIPATES AFTER DRIVING A LITTLE WITH WINDOWS DOWN. NO CHECK ENGINE LIGHT. NO FLAGS ON ONSTAR DIAGNOSTICS. NO PRECEDING EVENT THAT WOULD HAVE CAUSED DAMAGE. *TR

Mileage: 85,000

I HAVE A 2009 CHEVROLET CORVETTE WITH 30,000 MILES. I STARTED HAVING HIGHLY GAS FUMES. I STARTED READING SOME OF THE FORUMS AND NOTICED THERE WERE A LOT OF THE SAME COMPLAINTS. I BROUGHT IN TO A DEALERSHIP FOR REPAIR. THEY SAID IT WAS A CRACK IN THE FUEL MODULE. COST ME $2,000 TO REPAIR. IT WAS FINE FOR ABOUT 2 WEEKS NOW I'M HAVING THE SAME PROBLEM. THIS CONCERNS ME BECAUSE THE FUMES ARE SO BAD. I'M HAVING TO PARK OUTSIDE UNTIL I FIGURE THIS OUT. I'M WORRIED FOR IT TO CAUSE A FIRE IN MY GARAGE. *TR

Mileage: 30,000

READ ABOUT FUEL SMELL- IE CRACK PLASTIC CONNECTOR OF FUEL PUMP. I AM REALLY CONCERNED OF PARKING IN GARAGE WITH PILOT LIGHTS OF GAS HEATERS. ALSO DID NOT GET NOTICE ON EMISSION (CAT. CONVERTER REPLACEMENT).

Mileage: 25,000

I RECENTLY FILLED CAR WITH FUEL , AFTER FUELING I NOTICED EXTREM FUEL SMELL INSIDE THE VEHICLE AFTER PARKED FOR SEVERAL HOURS I NOTICED A LARGE AREA OF FUEL HAD RAN OUT DRIVER SIDE FUEL TANK AREA ONTO THE GROUND AND SMELL OF FUEL WAS EXTENSIVE . I CALLED KOONS CHEVROLET IN TYSON CORNER VIRGINIA WHERE I PORCHED IT AND DESCRIBED THE PROBLEM TO THEM , I TOOK THE CAR TO THEM . I WAS TOLD THEY HAVE DIGNOSET THE PROBLEM , AFTER FEW DAYS THE CONTACT ME AND TOLD ME THAT THE FUEL MODUL WAS LEAKING ON DRIVER SIDE FUEL TANK AND THERE IS A SPECIAL COVERAGE BULLTEN WARRANTY FOR JUST THAT FILAR ON 07-09 CORVETTE OF THE SAME MODEL AS MINE. THEY TOLD THEY WOULD ORDER THE PARTS AND CALL ME WHEN THE CAME IN , PARTS WERE IN WEEK AND MADE AN APPOINTMENT AND TOOK IT BACK TO BE REPAIRED UNDER WARRANTY . THEY CALLED ME THE NEXT MORNING AND TOLD ME BECAUSE MY VIN # WAS NOT INCLUDED IN SPECIAL COVERAGE BULLTEN THAT THEY WOULD NOT BE REPAIRING THE CAR UNDER WARRANTY . I WAS VERY UPSET NO WORRIED ABOUT MY SAFETY AND OTHERS BY HAVING A CAR THAT LEAKS ALL OVER THE ROAD . THEY TOLD ME IT WOULD COST ME $2700 TO BE REPAIRED AND WANT ME TO PAY FOR IT . I TOLD ME THAT I DON'T HAVE $2700 AND WHAT SHOULD I DO ? THEY DEALER TOLD ME TO NOT TO PUT MUCH FUEL IN IT UNBELIVABLE TO ME . I HAVE CONTACT GM CUSTOMER SERVICE AND OPENED A CASE WITH THEM BUT I HAVEN'T HEARD ANYTHING BACK BUT SORRY FOR YOUR LUCK EMAILES . I'M VERY FRUSTRATED AND WORRIED ABOUT MY SON DRIVING IT TO SCHOOL AND WORK . LEAKING FUEL IS NO JOKE ESPECIALLY IF I'M IN TRAFFIC A DAY SOMEBODY THROWS A CIGARETTE UNDER CAR I WOULD LOSE MY SON OR HURT OTHERS . PLEASE HELP ME WITH THIS SITUATION BEFORE IT'S TOO LATER . I DON'T KNOW WHAT ELSE TO DO .

CAR PARKED IN THE GARAGE AND NEXT MORNING, I SMELL GASOLINE ORDER COMING AROUND GAS FILLER NECK AND INSIDE THE CAR. I LOOK UNDER THE CAR AND FOUND SMALL AMOUNT OF GASOLINE COMING FROM THE TOP OF THE TANK.

MAJOR GAS SMELL COMING INTO THE CAR AND OUTSIDE THE CAR. CAN SMELL IT TEN FEET AWAY IN THE PARKING GARAGE. IT APPEARS TO BE A FUEL LEAK IN THE FUEL PUMP.

Mileage: 38,000

PURCHASED A 2009 CORVETTE IN FEB.2016 FROM PRIVATE SALE. WHEN PURCHASED SELLER SAID HE HAS BEEN SMELLING GAS FOR A LONG TIME SO HE PARKED IT OUTSIDE AND COVERED IT. I TOOK VECH. TO FILL UP WITH FUEL NO GAS SMELL DROVE HOME PARKED IN MY HOUSE GARAGE. AROUND 8:PM WIFE WOKE ME UP AROUND 7:AM NEXT MORNING SAID GAS SMELL IN GARAGE VERY BAD CAN HARDLEY BREATH. WENT OUT AND SURE ENOUGH BAD OPEN ALL DOORS. LOOKED UNDER CAR AND HOOD NO SIGN OF GAS OR NOT A STRONG SMELL. SOON AS I GET BUY FUEL FILLER DRIVERS SIDE SMELL VERY STRONG. WENT ON CORVETTE FORM THEY WAS A SAFTEY ALERT ABOUT THE WHOLE THING DOZEN OF COMPLAINT ABOUT THE GAS SMELL. STILL SMELLS IF YOU FILL IT OVER HALF A TANK SO HAVE TO KEEP CAR OUTSIDE AND COVER. GM NEEDS TO DO SOMETHING ABOUT THIS BEFORE SOMEONE BURNS DOWN THERE HOME OR CAR UP. I WAS TOLD GM IS WELL AWHARE OF THIS DON'T UNDERSTAND WHY THEY DON'T HAVE A RECALL. ALWAYS TRUSTED GM JUST BOUGHT NEW SILVERODO LOVE IT PLEASE TRY AND GET THIS FIXED DON'T NEED TO HERE ABOUT ANY MORE PEOPLE GETTING HURT OR WORSE BECAUSE SOME DUDE SITTING IN HIS OFFICE DOSENT REALLY CARE.

Mileage: 77,000

STRONG GAS SMELL COMING FROM THE DRIVERS SIDE REAR. (WHEN PARKED IN GARAGE) MY CAR IS A 2009 CORVETTE WITH 40,500 MILES. CAR WAS AT DEALER FOR A MONTH, STILL NOT FIX, WAITING FOR PARTS. CALL GM WAS TOLD PARTS WILL BE IN BY 10/17/2016 TWO MORE MONTHS OF WAITING.

WHEN I FILL MY CAR WITH GAS ABOVE 1/2 A TANK. I NOTICE MY FUEL GAUGE GOES TO FULL AND THEN TO EMPTY AND I GET A WARNING LIGHT THAT STATES SERVICE FUEL SYSTEM. I ALSO NOTICE A STRONG ODOR OF GAS WHEN I PARK IN MY GARAGE.

Mileage: 29,000

A STRONG FUEL ODOR IS COMING OUT FROM THE DRIVERS SIDE REAR. WHENEVER I FILL UP THE ODOR IS PRESENT. WHEN I'M UNDER 1/2 TANK ODOR IS GONE. IT'S ONLY WHEN I HAVE A FULL TANK. GM HAS ISSUED A "SPECIAL COVERAGE ADJUSTMENT" FOR 2007-2013 CORVETTES.THE # IS N150682. GM SAID MINE IS CURRENTLY NOT COVERED EVEN THOUGH I HAVE ALL THE SAME SYMPTOMS. MY CAR IS A 2009 WITH ONLY 37,000 MILES.

Mileage: 37,000

DEALER INDICATES A LEAK IN THE DRIVER SIDE FUEL TANK. STRONG SMELL OF GAS EVERY TIME VEHICLE IS REFUELED. VEHICLE HAS APPROX. 39000 MILES AND HAS NEVER BEEN IN AN ACCIDENT.

Mileage: 39,000

FUEL SMELL COMMING FROM GAS TANK WENT TO DEALER WHERE I PURCHASED THE CAR FROM IT WS A USED CAR DEALER TOLD ME IT WOULD IT WOULD ABOUT 4,000 DOLLER TO FIX IT WAS A CRACKED FILLER LINE AND CROSSOVER TUBE AFTER A LOT OF COMPLANING ABOUT IT ENDED UP COSTING ME 1200 DOLLERS.

Mileage: 43,653

SMELLING GAS WHEN I FILL UP MY GAS TANK

Mileage: 80,000

STRONG GASOLINE SMELL WHEN TANK IS MORE THAN 1/2 FULL. CAN'T LEAVE VEHICLE PARKED IN ENCLOSED PLACES, OR DRIVE WITH THE WINDOWS UP. GAS SMELL IS STRONGEST AROUND THE DRIVERS SIDE REAR TIRE.

Mileage: 79,500

PURCHASED USED 2009 CORVETTE Z06. IMMEDIATELY NOTICED GAS SMELL IN GARAGE. DISSIPATES AFTER SITTING FOR SEVERAL DAYS. IMMEDIATELY RETURNS UPON DRIVING A FEW MILES. THIS IMPLIES IT IS AT LEAST FROM A PRESSURIZED LINE (PROBABLY THE FUEL PUMP FITTING.) RESEARCHED CORVETTE FORUMS AND FOUND THIS IS COMMON PROBLEM ON C6 CORVETTES USUALLY WITH FUEL PUMP FITTING. CONTACTED GM CUSTOMER ASSISTANCE. THEY AUTHORIZED DEALER TO CONFIRM LEAK. DEALER DID SO. REQUESTED GM TO PROVIDE REPAIR OR AT LEAST PROVIDE REPLACEMENT PARTS. GM REFUSED. THESE GAS TANKS AND FUEL PUMPS SIT IMMEDIATELY BEHIND THE SEATS IN A CORVETTE AND VERY CLOSE TO THE EXHAUSTS. COME ON NHTSA. DO A RECALL ON THESE FUEL PUMPS BEFORE PEOPLE DIE FROM FIRES OR EXPLOSIONS.

Mileage: 49,000

STRONG SMELL IF GAS AFTER FILLING UP. GAS IS LEAKING AFTER I FILL UP.

Mileage: 90,000

DETECT A STRONG GAS ODOR AFTER HAVING BEEN PARKED IN A CLOSED GARAGE OVERNIGHT. I HAVE NOTICED THIS PROBLEM EACH MORNING FOR ONE WEEK NOW THE VEHICLE HAS 41,600 MILES ON IT.

Mileage: 41,600

I HAVE A 2009 CORVETTE WITH ABOUT 68,000 MILES. FOR MY LAST THREE TANKS OF GAS, I HAVE NOTICED THE SMELL OF GAS COMING FROM WITHIN THE DRIVER SIDE REAR WHEEL AREA WHEN THE FUEL TANK IS MORE THAN HALF FULL. THE SMELL FILLS MY ENTIRE GARAGE AT NIGHT, AND THE SMELL IS VERY STRONG. EVEN WHEN PARKED OUTSIDE, THE SMELL OF GAS IS RECOGNIZABLE FROM ABOUT TEN FEET AWAY. THE SMELL IS ALSO PRESENT WHILE DRIVING WITH THE WINDOWS DOWN. THE DEALERSHIP DID A PRESSURE TEST, SMOKE TEST, AND VISUAL CHECKS. THEY WERE UNABLE TO FIND ANY ISSUES, EVEN THOUGH EVERYONE AGREED THAT THEY COULD SMELL GAS FROM THE REAR DRIVER SIDE WHEEL AREA. AFTER THOROUGHLY RESEARCHING THIS ISSUE ON THE CORVETTE FORUM, IT SEEMS THAT THE PROBLEM IS MOST LIKELY RELATED TO THE FUEL PUMP, WHICH IS MOST LIKELY CRACKED. A RATHER LARGE NUMBER OF PEOPLE HAVE REPORTED IDENTICAL SYMPTOMS. THE PROBLEM IS DIFFICULT TO DIAGNOSE, BECAUSE THERE ARE NO VISUAL SIGNS OF A LEAK, AND THE DEALERSHIP SEEMED AT A LOSS AS TO WHAT MIGHT BE CAUSING THIS PROBLEM. MOREOVER, THIS IS A DANGEROUS ISSUE, BECAUSE GAS IS HIGHLY FLAMMABLE AND VERY HOT EXHAUST PIPES RUN DIRECTLY IN BETWEEN THE TWO GAS TANKS.

Mileage: 68,000

AFTER INTERMITTENTLY SMELLING FUEL IN OUR GARAGE I CRAWLED UNDER THE VEHICLE AND NOTICED A WET SPOT ON THE FUEL TANK. THE DEALER FOUND A CRACKED FUEL TANK. IT SEPARATED ALONG A SEAM. IT WAS LEAKING FUEL WHEN IT WAS OVER 1/2 FULL. THE VEHICLE HAS LESS THAN 40,000 MILES AND I FEEL IT SHOULD HAVE BEEN COVERED AS A RECALL AS I HAVE SEEN MANY OWNERS HAVE REPORTED A FUEL SMELL. THIS IS AN EXTREMELY DANGEROUS MANUFACTURING DEFECT.

Mileage: 40,000

SIGNIFICANT GASOLINE FUMES IN GARAGE AFTER FILLING THE GAS TANK AND STORING THE CAR OVERNIGHT. GASOLINE SMELL OBVIOUS WHEN DRIVING WITH THE TARGA TOP IS ON. WORSE SMELL WHEN THE TOP IS OFF. FUMES ARE MOSTLY GONE AFTER THE GAS TANK LEVEL DROPS BELOW HALF.

Mileage: 33,000

2ND OCCURANCE IN 6 MONTHS I WENT TO FILL MY CAR WITH GAS. FILLED IT UP AND GAS GAUGE WENT TO 0. ENGINE LIGHT CAME ON, FUEL SYSTEM WARNING CAME ON AND THEN LOW FUEL WARNING. DROVE A FEW MILES AND GAS GAUGE WENT UP AND DOWN OVER AND OVER AGAIN. JUST CALLED DEALER AND HE WANTS $2000 TO REPLACE FUEL SENDING UNIT. I HAVE READ A HALF DOZEN CORVETTE FORUMS AND THIS IS A POPULAR PROBLEM FOR C-5 AND C6 CORVETTES. YOU WOULD THINK CHEVY WOULD HAVE FIGURED OUT THE FSU IS DEFECTIVE AND NEEDS TO BE RECALLED

Mileage: 39,500

WHEN I PARK MY VEHICLE IN MY GARAGE I HAVE A STRONG GASOLINE SMELL FROM CAR. ESPECIALLY WHEN I FILL MY GAS TANK. AFRAID ONE OF TANKS IS LEAKING MAY DRIP ON HOT EXHAUST AND EXPLODE

Mileage: 34,666

SMELL GASOLINE

Mileage: 32,000

EVERY TIME YOU FILL UP YOUR GAS TANK TO FULL THERE IS SOME GAS LEAKAGE AND CAR SMELLS OF GAS. I STOP AT 3/4 AND DO NOT SEEM TO HAVE A PROBLEM. I HAVE 3 GM CARS AND THIS IS THE ONLY ONE THAT HAS THIS PROBLEM.

Mileage: 6,170

AFTER FILLING MY CAR UP WITH GAS AND PARKED IT OVERNIGHT IN THE GARAGE, THE NEXT MORNING MY ENTIRE GARAGE SMELLED LIKE GAS. I DIDN'T THINK ANYTHING OF IT BUT THE SMELL WAS INSIDE AND OUTSIDE OF MY CAR AS I DROVE AND/OR PARKED IT ANYWHERE. I LEFT IT OUTSIDE OF MY GARAGE UNTIL I DIDNT NOTICE THE SMELL ANYMORE AT WHICH POINT I PARKED IT INSIDE THE GARAGE. I NOTICED THAT THE ISSUE ONLY STARTS WHEN THERE IS MORE THAN HALF A TANK OF GAS. ONCE THE FUEL GAUGE DROPS TO UNDER HALF A TANK, THE SMELL GOES AWAY. I TOOK IT TO TWO SEPARATE DEALERSHIPS THAT DID SMOKE TESTS AND VISUAL CHECKS AND THEY DO NOT SEE ANY ISSUES, EVEN THOUGH THE SMELL IS THERE WITH MORE THAN HALF A TANK (IN BOTH OCCASIONS THE TANKS WERE MORE THAN HALF AND THE DEALER NOTICED THE SMELL BUT DID NOT SEE ANY ISSUES AND ATTRIBUTED IT TO MY VEHICLE RUNNING RICH, EVEN AFTER I TOLD THEM THE SMELL WENT AWAY WHEN THE FUEL GAUGE WAS UNDER HALF A TANK). IT IS APPARENT TO ME THAT THERE IS AN ISSUE, A DANGEROUS ONE AT THAT SINCE GAS FUMES ARE HIGHLY FLAMMABLE AND THE HOT EXHAUST PIPES RUN IN BETWEEN THE TANKS THEMSELVES. AFTER FURTHER RESEARCH, IT APPEARS THAT THERE IS A PLASTIC PIECE ON THE TOP OF THE FUEL PUMP THAT SEEMS TO BE THE ISSUE AND ENDS UP HAVING SMALL CRACKS. THERE ARE MULTIPLE CORVETTE OWNERS THAT HAVE REPORTED THE SAME ISSUE AND HAVE HAD TO REPLACE THE PART AT THEIR EXPENSE (AN EXPENSIVE PROPOSITION AT THAT). PLEASE INVESTIGATE THIS ISSUE AS SOON AS YOU CAN. I AM CONCERNED THERE MAY BE A MAJOR FAULT WHICH WILL/CAN CAUSE AN INJURY DUE TO THE NATURE OF THE PROBLEM (IE: GAS FUMES AND HOT EXHAUST PIPES).

Mileage: 59,000

HI, I BOUGHT THE CORVETTE USED. THE FIRST TIME I FILLED IT ALL THE UP WITH GAS I NOTICED A VERY STRONG GAS SMELL THE NEXT DAY IN MY GARAGE. I HOPED IT WOULD GO AWAY OR IT WAS JUST SOMETHING I WASN'T AWARE OF ABOUT THE CAR SINCE I JUST BOUGHT IT USED. THE NEXT TIME I FILLED IT UP THE SAME THING THE WHOLE GARAGE SMELLED LIKE GAS THE NEXT DAY. DID SOME RESEARCH ONLINE AND FOUND OUT THERE ARE ALLOT OF THE C6 CORVETTES WITH THIS DEFECT. IF YOU FILL THE CAR UP OVER HALF FULL GAS LEAKS FROM THE TOP OF THE TANK DOWN THE INSIDE AND ON TO THE TAILPIPE. CALLED THE DEALER AND THEY REFUSED TO FIX IT OR RECALL THE DEFECTIVE PART. IM AFRAID OF TWO POSSIBLE THINGS HAPPENING EITHER THE CAR CATCHING FIRE OR THE FUMES IGNITING MY GAS WATER HEATER THATS IN THE GARAGE AS WELL. HOPE YOU GUYS CAN GET SOMETHING DONE ABOUT IT. THANKS FOR YOUR TIME. *JS

Mileage: 45,000

STRONG GAS SMELL AFTER FILLING UP GAS TANK. CAN BE SMELLED IN CAR AND OVERWHELMS GARAGE IF TANK IS OVER HALF FULL.

Mileage: 72,500

MY FUEL GAUGE WOULD NOT RECORD ANY FUEL LEVEL AFTER FILLING THE TANK AND DRIVING FOR APPROXIMATELY ONE QUARTER OF THE TANK OF FUEL.THE GAUGE WOULD DROP TO "EMPTY". THIS TRIGGERED THE CHECK ENGINE LIGHT, AND AN ERROR CODE, RESULTING IN NOT BEING ABLE TO PASS MY CAR INSPECTED IN AZ, WHERE IT IS REGISTERED. I WAS CHARGED $2300.00 BY THE DEALER TO FIX THIS PROBLEM IN ORDER TO BE ABLE TO USE MY CAR. THIS PRESENTS A PROBLEM OF POSSIBLY RUNNING OUT OF GAS WHILE IN THE PASSING LANE OF A HIGHWAY. FORTUNATELY THIS DID NOT HAPPEN TO ME. *TR

Mileage: 30,129