2012 CHEVROLET CORVETTE Problems & Recalls

Recently purchase used car. Very strong a gas smell/fumes in garage whenever fuel is pumped more than 1/2 tank. Concerned over fire or explosion hazard.

Smelling gas fumes when parked. There were no other indicators of an issue. I took car to dealership, turns out there is a flaw with the fuel system, causing a leak at the top of the tank. Fuel was leaking through a valve and into the inside of the car frame. This issue should be a recall. The...

Fuel smell coming from gas cap area replaced the gas cap twice. Continue to have strong fuel smells in garage where car is kept. Started about one month ago.

Strong gas smell after filling gas tank. This is a known issue on these cars and although it can develop at any time they only warranty the problem for 10 years. This creates a fire hazard. The attached service bulletin was just released by GM today: Special Coverage Adjustment 15682 Primary Tank ...

Purchased my 2012 Corvette Grand Sport used on 06/08/2023 and the first night parked in my garage noticed a seriously strong fuel smell. Have run down to half tank and parked it again and still have the strong smell. Dropped off at my local Chevrolet dealer for inspection. Research shows this is a c...

The contact owns a 2012 Chevrolet Corvette. The contact stated that while the vehicle was parked inside the garage there was an abnormally strong gasoline odor coming from the vehicle. Upon inspection, there was no fuel leak visible inside the garage. The cause of the failure was not yet determined....

Mileage: 36,000

We smelled gasoline from time to time since June of 2022 & could not see any leaks. Approximately October 22 2022 we contacted Premier Chevy Buick GMC in Beatrice Nebraska because the smell was really bad. After they inspected our car they said it had a defective fuel pump that had cracked & it was ...

The car has a strong smell of gas inside the garage and in the compartment of the vehicle after driving

Airbag light intermittently comes on and goes off whilst driving. Per GM, they will not say whether the airbag will or will NOT deploy while the light is on. There is a TSB for the issue, but it only last 10 years past the in-service date. When safety is affected, there should be no limit on time to...

The contact owns a 2012 Chevrolet Corvette. The contact stated that after taking the vehicle out of storage and starting the vehicle, he noticed that the active handling and traction control error messages were displayed. The local dealer was not contacted. The vehicle was not diagnosed or repaired...

Mileage: 15,800

Get a intermittent red air bag light on the dash when driving. Not sure if air bag system is working properly. Would affect safety if the air bag malfunctions. Not inspected by anyone, car is for sale.

Failure of Active Handling System with onboard computer message to have the system serviced. Other drivers (owner forums) have reported significant safety hazards related to this system failure. Reported issues include system-driven steering and braking actions that lead to mishandling of the car th...

Failure of Active Handling System with onboard computer message to have the system serviced. Other drivers (owner forums) have reported significant safety hazards related to this system failure. Reported issues include system-driven steering and braking actions that lead to mishandling of the car th...

Failure of Active Handling System with onboard computer message to have the system serviced. Other drivers (owner forums) have reported significant safety hazards related to this system failure. Reported issues include system-driven steering and braking actions that lead to mishandling of the car th...

Low beam headlights stop working while driving.

The air bag warning light comes on and off at various times. Sometimes it stays on and other times it goes out after a while. If i shut the car off and wait a few then when restarted it goes out Sometimes it stays off other times it comes back on. This appears to be a common problem on this gene...

I HAVE A VERY STRONG GASOLINE SMELL COMING FROM, INSIDE AND OUT SIDE MY CAR WHEN IT IS STATIONIONARY. IT SEEMS TO BE WORST, WHEN I HAVE MORE THAN A HALF TANK OF GAS. THE SMELL OF GAS IS IN MY GARAGE AND INSIDE MY HOME WHEN PARKED INSIDE MY GARAGE. I MADE AN APPOINTMENT WITH THE FREMONT CHEVROLET ...

Mileage: 103,000

I HAVE BEGUN TO SMELL FUEL COMING FROM THE DRIVERS SIDE WHEEL WELL. IT HAS FILLED THE GARAGE WHILE PARKED AND I CAN SMELL IT COMING INTO THE CAR'S INTERIOR WHILE DRIVING. I ONLY HAVE 24,000 MILES ON THE CAR.

Mileage: 24,000

SERVICE ACTIVE HANDLING SYSTEM ON DISPLAY. WHILE DRIVING THE DAY BEFORE, THE CAR MADE A VERY QUICK MOTION TO THE LEFT WHILE DRIVING AT 65MPH. INVESTIGATION FOUND THE STEERING WHEEL SENSOR PUSHED OUT OF IT'S HOUSING AND DANGLING ON THE STEERING COLUMN SHAFT UNDER THE DASH. THE POWERED TELESCOPING ...

Mileage: 44,000

THE AIRBAG WARNING LIGHT ON THE DASH COMES ON FOR THE DRIVER SIDE FOR NO REASON WHILE DRIVING THE CAR. MY UNDERSTANDING IS THAT WHEN THE LIGHT IS ON, THE AIR BAG IS NON-FUNCTIONAL. SOMETIMES, IF I ADJUST THE SEAT FORWARD, BACKWARD, UP, AND DOWN, THE LIGHT WILL GO OFF, BUT NO ALWAYS. I'VE HAD THE ...

Mileage: 11,600

SEVER GAS SMELL OCCURS SPORADICALLY. WHEN THIS HAPPENS, I CAN'T DRIVE WITH THE TOP UP OR PLACE VEHICLE IN MY GARAGE. IT WENT TO CHEVY THE FIRST OCCURRENCE AND THEY DID NOT INSPECT, BUT DID SAY THERE WAS NO PROBLEM. IT HAS SINCE HAD ANOTHER 4 OCCURRENCES OF GAS SMELL. IT IS NOT OVERFLOW BECAUS...

Mileage: 9,000

AFTER FILLING THE GAS TANK THERE IS A NOTICEABLE SMELL OF GAS THAT'S EXISTS. WHEN GARAGE KEPT THE SMELL FILLS THE ENTIRE GARAGE WITH A GAS SMELL. THE GAS CAP IS FULLY SECURED AND THERE ARE NO NOTICEABLE LEAKS OR PUDDLES ON THE GROUND.

Mileage: 44,000

I WAS IN MY GARAGE, I OPENED THE DRIVER DOOR SAT DOWN AND SECURED THE SEAT BELT. I ATTEMPTED TO START THE CAR BY STEPPING ON THE BRAKE PEDAL AND PRESSING THE START BUTTON BUT THE ENGINE DID NOT TURN OVER. I MADE A SECOND AND THIRD ATTEMPT TO START THE ENGINE TO NO AVAIL. THEN, I ATTEMPTED TO EXIT...

Mileage: 38,000

WHEN TANK IS 1/2 OR FULL STATIONARY, FUEL SMELLS AND FUEL LEAKS. LEAVES SPOTS IN MY GARAGE AND THE SMELL IN GARAGE IS DISGUSTING. FUEL SMELL PENETRATES IN VEHICLE CABIN AS WELL.

Mileage: 102,000

I OWN A 2012 CORVETTE GRANDSPORT PURCHASED NEW. CAR HAS 12,635 MILES IN IT. I WAS DRIVING INTO TOWN LAST NIGHT AND HEAD LIGHTS JUST SHUT OFF LEAVING ME IN COMPLETE DARKNESS. I WAS COMING INTO TUSCALOOSA AND MANAGED WAS FORTUNATE TO HAVE ENOUGH AREA LIGHTING TO SAFELY COME TO A STOP AND PULL INTO A ...

Mileage: 12,635

MY 2012 CORVETTE GRAND SPORT HAS AN INCREASINGLY STRONG FRESH GASOLINE SMELL ESPECIALLY AFTER FILLING UP. WHEN I START TO SLOW DOWN AND THEN COME TO A COMPLETE STOP THE SMELL BEGINS TO PERMEATE THE PASSENGER CABIN. AFTER READING ONLINE FORUMS IT APPEARS TO BE A RECURRING SAFETY ISSUE/ HAZARD WITH TH...

Mileage: 32,700

CAR HAS 8750 MILES PASSENGER DOOR WILL NOT OPEN AND WINDOW WILL NOT ROLL UP

FUEL SYSTEM LEAK AROUND FUEL PUMP, STRONG GAS SMELL, FIRE HAZARD.

Mileage: 11,000

DEFECTIVE FUEL TANK. MOST OWNERS HAVE REPORTED CRACKS IN THE FUEL TANK THAT RESULT IN GAS LEAKAGE AND STRONG SMELL OF GASOLINE WHEN THE AUTOMOBILE IS PARKED AFTER FUELING. FIRST NOTICED 3 WEEKS AGO AFTER PURCHASING GASOLINE AND RETURNING TO COVERED GARAGE FOR STORAGE. GASOLINE CAN BE SMELLED INSIDE ...

Mileage: 50,000

FUEL TANK LEAK.

Mileage: 25,000

FUEL SMELL,REPLACED FUEL CAP, THAT HELP A LITTLE,SMELL AROUND FUEL DOOR,CAN'T KEEP CAR IN GARAGE AFRAID TO RE FUEL AND DRIVE HELP

Mileage: 35,019

FUEL SMELL,REPLACED FUEL CAP, THAT HELP A LITTLE,SMELL AROUND FUEL DOOR,CAN'T KEEP CAR IN GARAGE AFRAID TO RE FUEL AND DRIVE HELP

Mileage: 35,019

THE DRIVER AND PASSENGER SIDE MAIN HEADLIGHT ASSEMBLY IS A SEALED UNIT AND CANNOT BE REPAIRED. THE SEALS IN BOTH UNITS IN MY CAR ARE DEFECTIVE AND THAT ALLOWS MOISTURE AND ENVIRONMENTAL CONTAMINATES TO COLLECT INSIDE THE UNIT AND FOG UP THE MAIN LENSES THAT THE DRIVING HEADLIGHTS PROJECT THROUGH. ...

Mileage: 60,000

THE WIRE TO THE STARTER MELTS OUT CAUSING THE ENTIRE CHARGING SYSTEM TO STOP WORKING AN DRAINS THE BATTERY CAUSING THE MOTOR TO SHUT OFF WHILE DRIVING . THEN NO POWER STEERING OR BREAKS

Mileage: 60,000

THE WIRE TO THE STARTER MELTS OUT CAUSING THE ENTIRE CHARGING SYSTEM TO STOP WORKING AN DRAINS THE BATTERY CAUSING THE MOTOR TO SHUT OFF WHILE DRIVING . THEN NO POWER STEERING OR BREAKS

Mileage: 60,000

THE WIRE TO THE STARTER MELTS OUT CAUSING THE ENTIRE CHARGING SYSTEM TO STOP WORKING AN DRAINS THE BATTERY CAUSING THE MOTOR TO SHUT OFF WHILE DRIVING . THEN NO POWER STEERING OR BREAKS

Mileage: 60,000

FUEL SMELL COMING FROM DRIVERS SIDE FUEL TANK. NOTICE FUEL LEAK FROM HIGH SPOT OF TANK AND FUEL RESIDUE ON SIDE OF TANK. NUMEROUS OWNER COMPLAINTS.

Mileage: 77,000

WHILE DRIVING AT ANY SPEED, THE RED SEAT BELT LIGHT WILL INTERMITTENTLY FLASH. JUST MOVING MY BUM FROM JUST GETTING COMFY, THE LIGHT WILL COME ON STEADY, THEN FLASH, THEN BE ACCOMPANIED BY FOUR CHIMES, THEN, GO OFF. A FEW MILES DOWN ROAD, AT LEGAL SPEEDS, (DOESN'T MATTER THE SPEED) THE LIGHT WILL CO...

Mileage: 8,600

WHILE DRIVING AT ANY SPEED, THE RED SEAT BELT LIGHT WILL INTERMITTENTLY FLASH. JUST MOVING MY BUM FROM JUST GETTING COMFY, THE LIGHT WILL COME ON STEADY, THEN FLASH, THEN BE ACCOMPANIED BY FOUR CHIMES, THEN, GO OFF. A FEW MILES DOWN ROAD, AT LEGAL SPEEDS, (DOESN'T MATTER THE SPEED) THE LIGHT WILL CO...

Mileage: 8,600

WHEN I FILL THE GAS TANK OF MY 2012 CORVETTE THERE IS A STRONG SMELL OF GAS IN MY GARAGE. I HAVE READ ON SEVERAL FORUMS THAT THIS IS A KNOWN PROBLEM WITH THESE CORVETTES HAVING A LEAK AT THE TOP OF THE GAS TANK. THIS LEAKING GAS CAN GET ONTO THE EXHAUST AND CAUSE A FIRE.

Mileage: 11,200

STATIONARY VEHICLE WAS FILLING ENCLOSED GARAGE WITH GAS FUMES. SOURCE OF PROBLEM WAS FRACTURED HIGH PRESSURE 90 DEGREE FITTING IN FUEL PUMP ATOP LEFT FUEL TANK. ENTIRE FUEL PUMP ASSEMBLY HAD TO BE REPLACED. PHOTO ATTACHED SHOWING FRACTURE IN FITTING AND SHOWING THE FUEL PUMP PART NUMBER. CONTACT...

Mileage: 31,512

WE RECENTLY PURCHASED THE CAR (TWO WEEKS AGO) AND THE CAR SMELLS UP THE GARAGE OF HEAVY GAS FUMES. WE TRIED REPLACING THE GAS CAP BUT IT STILL HAPPENS. SEEMS TO BE AT ITS STRONGEST AFTER GASSING UP THE CAR. GAS FUMES CAN ALSO BE SMELLED WHEN THE CONVERTIBLE TOP IS DOWN DRIVING ON THE HIGHWAY. I AM S...

Mileage: 29,300

THE CAR ONLY HAS 2388 MILES. BACKING STRAIGHT OUT THE DRIVE WAY THE DASH STARTING DISPLAYING SERVICE ANTILOCK BREAKS, SERVICE TRACTION SYSTEM, SERVICE ACTIVE HANDLING SYSTEM. THE DASH LIGHTS FROM ABS AND TRACTION STAY ON AND THE TRACTION CONTROL CONTROL BUTTON IS DISABLED.

Mileage: 2,367

THE CAR ONLY HAS 2388 MILES. BACKING STRAIGHT OUT THE DRIVE WAY THE DASH STARTING DISPLAYING SERVICE ANTILOCK BREAKS, SERVICE TRACTION SYSTEM, SERVICE ACTIVE HANDLING SYSTEM. THE DASH LIGHTS FROM ABS AND TRACTION STAY ON AND THE TRACTION CONTROL CONTROL BUTTON IS DISABLED.

Mileage: 2,367

STRONG FUEL SMELL INSIDE PASSENGER COMPARTMENT, MOST NOTICEABLE AFTER REFUELING. CAN BE NOTICED STATIONARY AND IN MOTION. NO VISIBLE FUEL LEAKS NOTICEABLE.

Mileage: 49,000

INVESTIGATION NUMBER EA09-002 GOING INTO A SLOW LEFT SHARP TURN THE VEHICLE CUT OFF FUEL, TRIGGERED SERVICE ABS, SERVICE ACTIVE HANDLING, SERVICE TRACTION CONTROL. DURING THIS TIME I COULD NOT ACCELERATE. ABS BRAKING IS NOW DISABLED AND WILL NOT RESET WITH IGNITION CYCLES.

Mileage: 36,000

INVESTIGATION NUMBER EA09-002 GOING INTO A SLOW LEFT SHARP TURN THE VEHICLE CUT OFF FUEL, TRIGGERED SERVICE ABS, SERVICE ACTIVE HANDLING, SERVICE TRACTION CONTROL. DURING THIS TIME I COULD NOT ACCELERATE. ABS BRAKING IS NOW DISABLED AND WILL NOT RESET WITH IGNITION CYCLES.

Mileage: 36,000

INVESTIGATION NUMBER EA09-002 GOING INTO A SLOW LEFT SHARP TURN THE VEHICLE CUT OFF FUEL, TRIGGERED SERVICE ABS, SERVICE ACTIVE HANDLING, SERVICE TRACTION CONTROL. DURING THIS TIME I COULD NOT ACCELERATE. ABS BRAKING IS NOW DISABLED AND WILL NOT RESET WITH IGNITION CYCLES.

Mileage: 36,000

EXCESSIVE FUEL SMELL. UNSAFE TO PARK IN GARAGE. GM CAN'T FIX

Mileage: 44,000

UPON BRAKING TO ENTER A TIGHT LEFT HAND TURN IN THE COUNTRY THE DIC DISPLAYED SEVERAL WARNING INDICATORS, ABS AND TRACTION CONTROL. THE RIGHT FRONT BRAKE LOCKED UP (CONFIRMED BY THE FLAT SPOT ON THE TIRE). I BEGAN MODULATING THE BRAKES THINKING THAT I HAD LOST ANTI-LOCK BRAKES, BUT THE RIGHT FRONT B...

Mileage: 52,000

UPON BRAKING TO ENTER A TIGHT LEFT HAND TURN IN THE COUNTRY THE DIC DISPLAYED SEVERAL WARNING INDICATORS, ABS AND TRACTION CONTROL. THE RIGHT FRONT BRAKE LOCKED UP (CONFIRMED BY THE FLAT SPOT ON THE TIRE). I BEGAN MODULATING THE BRAKES THINKING THAT I HAD LOST ANTI-LOCK BRAKES, BUT THE RIGHT FRONT B...

Mileage: 52,000

UPON BRAKING TO ENTER A TIGHT LEFT HAND TURN IN THE COUNTRY THE DIC DISPLAYED SEVERAL WARNING INDICATORS, ABS AND TRACTION CONTROL. THE RIGHT FRONT BRAKE LOCKED UP (CONFIRMED BY THE FLAT SPOT ON THE TIRE). I BEGAN MODULATING THE BRAKES THINKING THAT I HAD LOST ANTI-LOCK BRAKES, BUT THE RIGHT FRONT B...

Mileage: 52,000

AIR BAG LIGHT STAYS ON ON INSTRUMENT CLUSTER. FOUND OUT THRU RESEARCH ON THE CORVETTE FORUM AND TALKING TO CHEVY DEALERSHIPS THAT THIS IS A VERY COMMON PROBLEM.USUALLY FIXED BY UNPLUGGING AND CLEANING OR TIE WRAPPING THE CONNECTOR UNDER THE SEATS.WHICH USUALLY KEEPS THE LIGHT OUT TEMPORARILY. BU...

Mileage: 20,892

THE AIRBAG LIGHT CAME ON WHILE DRIVING AT 35-45 MPH SPEEDS AND STAYED ON. THE LIGHT DID NOT GO OFF AFTER TURNING THE VEHICLE OFF AND ON AGAIN.

Mileage: 60,500

STARTED SMELLING GAS IN THE CABIN. HAS HAPPENED 2 OR 3 TIMES. *TR

Mileage: 18,000

TL* THE CONTACT OWNS A 2012 CHEVROLET CORVETTE. THE CONTACT STATED THAT WHILE DRIVING 5 MPH ATTEMPTING TO MAKE A TURN, THE VEHICLE STARTED TO SKID. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT BOTH FRONT TIRES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE R...

Mileage: 10,300

AIR BAG LIGHT COMES ON AND STAYS ON, MAY GO OFF FROM TIME TO TIME BUT REMAINS ON WHILE DRIVING. AIR BAG MAY NOT DEPLOY WHILE LIGHT IS ON. NO CODE SHOWS UP WHEN LIGHT IS OFF, SO DEALER HAS BEEN UNABLE TO LOCATE PROBLEM. *TR

Mileage: 12,000

TL* THE CONTACT OWNS A 2012 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BELT CONTINUOUSLY TIGHTENED AND WOULD NOT RELEASE. THE SEAT BELT RELEASED ONLY AFTER THE VEHICLE WAS STOPPED. THE VEHICLE WAS TAKEN TO A DEALER, WHO REPLACED THE SEAT BELT HOWEVER, THE FAILURE WAS...

Mileage: 5,100

JUST BACK FROM THE DEALER. SERVICEMAN SAID "FRAYED WIRE AT SEAT BELT", CODE B0040. WRITTEN UP AS "DRIVER SEAT CONNECTOR UNPLUGGED". THEY ADDED DIELECTRIC GREASE, RE-MATED THE CONNECTOR AND NOW THE INTERMITTENT AIRBAG DASH WARNING LIGHT HAS CEASED. *TR

Mileage: 1,900

JUST BACK FROM THE DEALER. SERVICEMAN SAID "FRAYED WIRE AT SEAT BELT", CODE B0040. WRITTEN UP AS "DRIVER SEAT CONNECTOR UNPLUGGED". THEY ADDED DIELECTRIC GREASE, RE-MATED THE CONNECTOR AND NOW THE INTERMITTENT AIRBAG DASH WARNING LIGHT HAS CEASED. *TR

Mileage: 1,900

CLUTCH MASTER CYLINDER FAILED CAUSING THE CAR TO NOT BE ABLE TO DISENGAGE CLUTCH WITH PEDAL MAKING IT EXTREMELY DANGEROUS TO STOP CAR OR REMOVE IT FROM GEAR. FUTURE ATTEMPTS TO START CAR WITH ON-STAR ON THE PHONE SO THEY COULD RUN DIAGNOSTIC CHECK REMOTELY FAILED. 3 ATTEMPTS TO START CAR AND IT WOUL...

Mileage: 4,600

CLUTCH MASTER CYLINDER FAILED CAUSING THE CAR TO NOT BE ABLE TO DISENGAGE CLUTCH WITH PEDAL MAKING IT EXTREMELY DANGEROUS TO STOP CAR OR REMOVE IT FROM GEAR. FUTURE ATTEMPTS TO START CAR WITH ON-STAR ON THE PHONE SO THEY COULD RUN DIAGNOSTIC CHECK REMOTELY FAILED. 3 ATTEMPTS TO START CAR AND IT WOUL...

Mileage: 4,600

AIR BAG WARNING LIGHT WOULD COME ON AND THEN GO OFF BEFORE COMING ON AGAIN AND OFF. DIAG. CODE B0041,B0065. DIAG. INTERMITTENT OPEN CIRCUITS TO DRIVER'S SEAT PRETENSIONER AND SIDE AIR BAG. FOUND TERMINAL FRETTING CONDITION IN X377. *TR

Mileage: 14,393

PASSENGER AIR BAG LIGHT SHOWS OFF WHEN MY 120 POUND WIFE SITS IN THE PASSENGER SEAT...TOOK THE CAR TO THE DEALER TODAY AND WAS TOLD THAT IT WORKS IF THE PASSENGER WEIGHS 150 POUNDS...PLEASE ADVISE NEXT STEPS AS THIS SEEMS VERY UNSAFE AND I WANT THE AIR BAG FUNCTIONAL FOR MY PASSENGERS WHO ARE ADULTS...

Mileage: 1,200

MY MODEL IS EQUIPPED WITH GOODYEAR "EAGLE F1 SUPERCAR GEN2 TIRES" FEATURING AN ASYMMETRIC TREAD PATTERN. THEY ARE VERY HARD AND TREACHEROUS IN COLD RAINY WEATHER AND HAVE A TENDENCY TO "FLOAT" ON ANY KIND OF PONDING WATER ON THE ROAD (PARTICULARLY EXPRESSWAYS) CAUSING THE VEHICLE TO ACT AS IF IT IS...

Mileage: 1,900