High Severity Issue
This component has been associated with crashes, fires, or deaths.
This Problem Across All Years
On 10/13 after refuling my 2023 Chevy Corvette. I was cruising on a freeway when the car started showing signs of staying in 5th gear. The rev limiter was going from 500 to 2500 rpm rhythmically at a cruising speed of 65mph. At this time, I noticed the loss of response from the gas pedal. The car was then placed in manual shifting mode so that i can attempt to regain population control and maintain the flow of traffic as this was a high crash area. Unfortunately, this attempt did not work and the dash cluster illuminated with the following alerts "rear axil system offline" "idle creep disabled," "service transmission" at this time. The gear indicator on the dash that shows the mode and gear, for example: D3 (drive 3rd gear), completely disappeared and the gas pedal completely went unresponsive. At this point i used the momentum of the car in motion to exit off of the freeway into a parking center. The vehicle proceeded to not respond in regards to going into park, reverse, or drive. The only thing that worked was the electronic parking brake. This was a very scary situation that, without my federal law enforcement driving training I may not have coasted safely out of traffic.
On 10/13 after refuling my 2023 Chevy Corvette. I was cruising on a freeway when the car started showing signs of staying in 5th gear. The rev limiter was going from 500 to 2500 rpm rhythmically at a cruising speed of 65mph. At this time, I noticed the loss of response from the gas pedal. The car was then placed in manual shifting mode so that i can attempt to regain population control and maintain the flow of traffic as this was a high crash area. Unfortunately, this attempt did not work and the dash cluster illuminated with the following alerts "rear axil system offline" "idle creep disabled," "service transmission" at this time. The gear indicator on the dash that shows the mode and gear, for example: D3 (drive 3rd gear), completely disappeared and the gas pedal completely went unresponsive. At this point i used the momentum of the car in motion to exit off of the freeway into a parking center. The vehicle proceeded to not respond in regards to going into park, reverse, or drive. The only thing that worked was the electronic parking brake. This was a very scary situation that, without my federal law enforcement driving training I may not have coasted safely out of traffic.
On 8/3/2025 I was at a stop light. It turned green. I went to go and my car would not go past first gear. Had to pull over. Waited turned the car off. Turned it back on and started driving, then I got an alert 545. Then my entire screen went blank only showing the alert. I called my dealership to explain. They said there were recalls on the 2023 and 2024 transmissions. That’s why I got the alert 545. But they said there was nothing they could do. I could bring it in for a test drive with a technician and if it pops up alert 545 then they would submit a ticket to GM. But the earliest to fix my corvette would be October. But also saying I would have to pay full price for everything. I bought my 2023 Corvette 1LT C8 stingray in 2022 and have only put 19,000 miles on it. I do not miss maintenance or anything. I’m not sure how to get GM to pay for my transmission and labor. It also would not let me acknowledge and click the button on the steering wheel. My display went off and I could not get it back on even turning the knob. This is incredibly dangerous for my safety. Transmission failure. Can’t see the speed I’m going.
On 8/3/2025 I was at a stop light. It turned green. I went to go and my car would not go past first gear. Had to pull over. Waited turned the car off. Turned it back on and started driving, then I got an alert 545. Then my entire screen went blank only showing the alert. I called my dealership to explain. They said there were recalls on the 2023 and 2024 transmissions. That’s why I got the alert 545. But they said there was nothing they could do. I could bring it in for a test drive with a technician and if it pops up alert 545 then they would submit a ticket to GM. But the earliest to fix my corvette would be October. But also saying I would have to pay full price for everything. I bought my 2023 Corvette 1LT C8 stingray in 2022 and have only put 19,000 miles on it. I do not miss maintenance or anything. I’m not sure how to get GM to pay for my transmission and labor. It also would not let me acknowledge and click the button on the steering wheel. My display went off and I could not get it back on even turning the knob. This is incredibly dangerous for my safety. Transmission failure. Can’t see the speed I’m going.
On [XXX] I was driving my corvette in Atlantic City, New Jersey, which at that time I noticed smoke coming from the rear of the vehicle. I looked at my dash to see if any warning lights or check engine lights were on and nothing Indicate there was a problem. So I did continue to drive to get to a safe place where I can pull over and look at the engine. When I came up to the red light, the car next to me told me that my vehicle was on the fire. I was able to pull over on the side of road next to the hospital in Atlantic City. And then I got out of my car to nattempt to put out the fire myself as I noticed Melting Plastic that was on fire, was dripping all my tires to avoid the tires Catching on fire. I Remove the plastic that was on fire, causing burns to my hand. Then I called the fire to department to help me put out the fire. Once the fire was put out. I had it towed to the dealership they Told me to call my insurance company. Doing insurance process one of their technicians looked at the vehicle and determined that the rear Transmission case cracked from a Defective part in the transmission breaking, Which Cause the transmission fluid to pour out onto the exhaust system, Then the hot Transmission fluid ignite and set the rear of the car on fire. The insurance company liberty Mutual Refuse to fix the car due to mechanical malfunction. I then Contact General Motors and file a claim Which has been open for several months with zero repairs done to the vehicle. GM motors also sent a technician to look at the vehicle and came to the same conclusion but still has not attempted to fix the vehicle. This vehicle with a Defect like this is very unsafe. I could’ve been driving on the parkway and the vehicle locked up because the transmission broke and caused an shi accident or the fire could’ve been a lot worse could’ve been burnt to death. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
On [XXX] I was driving my corvette in Atlantic City, New Jersey, which at that time I noticed smoke coming from the rear of the vehicle. I looked at my dash to see if any warning lights or check engine lights were on and nothing Indicate there was a problem. So I did continue to drive to get to a safe place where I can pull over and look at the engine. When I came up to the red light, the car next to me told me that my vehicle was on the fire. I was able to pull over on the side of road next to the hospital in Atlantic City. And then I got out of my car to nattempt to put out the fire myself as I noticed Melting Plastic that was on fire, was dripping all my tires to avoid the tires Catching on fire. I Remove the plastic that was on fire, causing burns to my hand. Then I called the fire to department to help me put out the fire. Once the fire was put out. I had it towed to the dealership they Told me to call my insurance company. Doing insurance process one of their technicians looked at the vehicle and determined that the rear Transmission case cracked from a Defective part in the transmission breaking, Which Cause the transmission fluid to pour out onto the exhaust system, Then the hot Transmission fluid ignite and set the rear of the car on fire. The insurance company liberty Mutual Refuse to fix the car due to mechanical malfunction. I then Contact General Motors and file a claim Which has been open for several months with zero repairs done to the vehicle. GM motors also sent a technician to look at the vehicle and came to the same conclusion but still has not attempted to fix the vehicle. This vehicle with a Defect like this is very unsafe. I could’ve been driving on the parkway and the vehicle locked up because the transmission broke and caused an shi accident or the fire could’ve been a lot worse could’ve been burnt to death. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Put vehicle in reverse. Vehicle would not move. Vehicle placed back in park. Put vehicle in reverse again; and after advanced acceleration heard a loud clunk sound and jarring movement. Car continued in reverse normally. Vehicle was put into drive and driven approximately 500 feet at which time vehicle shut down. Service transmission and “rear axle not engaged” messages showing, as well as an overheating message. Dealership unresponsive.
Put vehicle in reverse. Vehicle would not move. Vehicle placed back in park. Put vehicle in reverse again; and after advanced acceleration heard a loud clunk sound and jarring movement. Car continued in reverse normally. Vehicle was put into drive and driven approximately 500 feet at which time vehicle shut down. Service transmission and “rear axle not engaged” messages showing, as well as an overheating message. Dealership unresponsive.
The contact owns a 2023 Chevrolet Corvette. The contact stated that while the vehicle was in reverse(R), the transmission failed to engage as the gear indicator light began to flash and the service transmission message was displayed on the instrument panel. After multiple attempts, the contact was able to engage the transmission and drove the vehicle to dealer where they were unable to diagnose or service the failure. The manufacturer was notified of the failure and a complaint was filed. The vehicle was not repaired. The failure mileage was 812.
The contact owns a 2023 Chevrolet Corvette. The contact stated that while the vehicle was in reverse(R), the transmission failed to engage as the gear indicator light began to flash and the service transmission message was displayed on the instrument panel. After multiple attempts, the contact was able to engage the transmission and drove the vehicle to dealer where they were unable to diagnose or service the failure. The manufacturer was notified of the failure and a complaint was filed. The vehicle was not repaired. The failure mileage was 812.