2016 CHEVROLET CRUZE Fuel/propulsion System Problems

I was driving the car, stopped at a light took my foot off the brake started to move and the car completely shut off. No warning lights went on. I had to start the car again. I took the car to a local dealership to be looked at. They pulled the codes, nothing showed up. I did an internet search for a possible cause, sent my search results to the dealership and I asked them to check the fuel system, they found a bad injector. They then cleaned the fuel system and replaced the bad injector.

Purchased a 2016 Chevrolet Cruze on [XXX]. [XXX]. As of July 26th I paid $862 on repairs for the car to be smoking this morning on my way to work [XXX]. In total I’ve spent Almost or close to $2,000 in car repairs. This purchase was for my 17 year old daughter as a graduation present and for college. She was driving and car started to run hot and cut off in a busy intersection. She was unable to take the car to North Carolina. The owner blocked me and the staff haven’t been accommodating since this process. Nor will they look at the car. This has put me in a financial burden and the safety conditions this vehicle is under. And damage this could have cause my daughter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Water leak in trunk. Took car in 3 time to have it fixed after them doing the recall( 84279073 f-lamp kit). Every time it went in they found a leak in a different spot. 15Feb17 they found water leaking from right side of the spoiler retainer holes. Dealer removed spoiler applied double back tape and sealer. Reinstalled spoiler 02Mar17 found pin hole leak in weather strip. Dealer replaced weather strip. 01jan24 start having electrical issues. Hard starting/ running weird and finally dead battery. Had les swabs install battery and remove water in trunk. Car starts but shuts off when driving. 05mar24 Dealer finds leak coming from right side spoiler and now 1 licence plat bolt. Charged me 600.00 . to reseal. Here we go again They could never stop/find the leak before and will not warranty previous work. Isn't this a fire/safty issue? That started the recall in the 1st place. And why wasn't drain plugs required for this yr.car. I believe it was in the newer one. I would like to know how many people had to take their car in multiple times to never have the problem truly fixed. Is this a tactic used to make consumers go away and say they fixed the recall, but never really did.

Stability Track came on randomly all of sudden car was stalling, running poorly and smell Gas , sure enough leaking Gas Everywhere, very dangerous. Lucky car did not catch on fire. I am still paying for this car. Just thankful no one got injured. THERE IS NO RECALLS FOR THIS VIN ABSOLUTELY SHOULD BE.

Keep having the engine light on. First time it was my Catalyst and now my engine light is on again with code P0420 and keeps leaving from the coolant

My car was recalled for problems with fuel system or something of that nature, I took it to get repaired not once but about 3 times and problem is still ongoing. When I press the gas, the car shoots all the way to the 3rd gear and gets stuck at about 27 miles which is very dangerous, especially when I’m on the freeway. It will also cut off in the middle of the road making me have to put my car in park and recrank the car, multiple people have almost ran dead into the back of my car. They basically told me it is no way to fix my car. Now, it has caused more problems. My car is now saying “engine power reduced” and “service brake assist” when I try to press the brakes, it’s literally almost impossible. I have to almost stand on the brake and it still does not stop all the way. My brakes are new btw, so it shouldn’t still have this error message. I’m basically driving a lemon. This car is not reliable at ALL. I have put so much money into this car and with it being a 2016, you would think it wouldn’t have all of these problems… the car just jerks when I’m driving and nobody can seem to fix it! Oh, and let me not forget about the fuse that blew in my USB ports causing me not to be able to use all the features of my vehicle. This car is a nightmare. Also, I believe that when there are recalls for safety issues like this, we should be notified but of course that’s asking for too much. I have only had this car since 2019. It was serviced on 4/28/21, 5/26/21, 6/6/21 and after that I literally gave up and just hope I don’t wreck out and die.

My car, started to get a messaged saying reduced engine power, after that it started to make a noise I took it to re pair and the car, sometimes makes that noise and I’m driving and out of nowhere the car turns off

Catalytic Converter , it is a 2016 , it absolutely should not be faulty/defective AT ALL . I checked with Dick Wolstrom Chevy Dealer , if this would be included in the Powertrain Warranty and they said it expired in December . I checked with the other Yearly Recalls for this problem, and it did show this exact same recall for the all the previous years of this make and model of car . It should be fixed , I never heard of a Catalytic Converter be defective like this especially in a newer year car . Can you please help me ? Also, I am having problem with the Fuel pressure Sensor , Air flow intake sensor, Knock sensor , all (3) this is crazy . This is the 2nd time the knock sensor has been replaced . My main concern is the Catalytic Converter , please advise , it should be covered in the powertrain warranty on this car , regardless . It is very expensive to be replaced .

While at red light, stop signs, or transitioning turns, the engine shuts off and does not restart. Sometimes it shuts down when driving at extremely low speeds. This is dangerous because I have had to push the car while transitioning in multipile lane intersections. Luckily others stop and help me push the car to shoulder or convenience gas stations. The battery and spark plugs are new, and the car has plenty of fuel.

My 2016 Chevy Cruise heating and cooling system failed. Car engine over heats causing engine to stop in mid drive. Hoses (main) and connections to heating and cooling systems faulty. Main hose to cooling system faulty (dry rotted ).

WHEN IM DRIVING AND STOP AT A LIGHT IT SOUNDS LIKE MY CAR IS GONNA DIE IT SPUTTERS AND ALMOST DIES AND NOW ITS DYING WHEN I STOP AT A LIGHT BUT CRANKS RIGHT BACK UP AFTER IT DIES THERE WAS A ERG VALVE RECALL WE GOT FIXED BUT IT SEEMS TO BE THE SAME ISSUE AS BEFORE

Mileage: 4

THE VEH STARTED WITH A SMALL WATER LEAK, THEN A VERY LARGE LEAK. FOUND OUT THAT THE WATER PUMP WAS BAD AND THE THERMOSTAT WAS BAD. THE WINDSHIELD WIPER FLUID HOLDER HAS A LARGE CRACK IN IT. THE VEHICLE STILL NEEDS MAINTENANCE ON IT AND CAN'T AFFORD IT. NO PHOTOS TO SHARE BUT RECEIPTS OF MY BILL TO REPLACE IT

Mileage: 2

MY CHECK ENGINE LIGHT HAD COME ON I GOT IT CHECKED AT MY MECHANIC BUT CAN'T SEEM TO FIGURE OUT THE PROBLEM. WHEN YOU FIRST START THE IGNITION IT FEELS LIKE THE CAR IS BOBBING BACK AND FOURTH. ALSO AFTER THE AUTO STOP GOES ON AND YOU TAKE YOUR FOOT OFF THE BRAKE AND PUT IT ON THE GAS PEDAL THE CAR STUTTERS. I ALSO HAD A PROBLEM WHEN I WAS COMING OUT OF MY DRIVEWAY IT STALLED AND LOST ALL POWER STEERING I HAD TO TURN THE CAR OFF AND BACK ON AGAIN.

CHECK ENGINE LIGHT CAME ON. TOOK CAR TO DEALERSHIP TO GET CHECKED. THE PURGE VALVE, WATER PUMP, AND CAM ACTUATOR SEALS ALL WENT BAD.

Mileage: 71,600

MY CAR IS PARKED LOOKS LIKE A RAINBOW COLOR IS COMING OUT FROM UNDER THE ENGINE. IT LOOKS LIKE WATER FROM A DISTANCE UNTIL YOU GET CLOSER. I HAVE NOTIFIED THE DEALERSHIP WHERE I BOUGHT IT AND HE TELLS ME THERE IS NOTHING THEY CAN DO

THE INTAKE MANIFOLD BLEW OUT IT'S SENSOR. NOT LIKE IT JUST WENT OUT, BUT SOME HOW PRESSURE BUILT UP AND BLEW IT OUT OF THE MANIFOLD. THIS IS EXACTLY WHAT THE REPRESENTATIVE AT THE DEALERSHIP JUST TOLD ME OVER THE PHONE. CAR IS AT THE SERVICE DEPARTMENT BECAUSE OF THE ONGOING ISSUES WITH THE TURBO AND THE MISSING BOLTS AND THE FACT THAT THIS ENGINE WAS OBVIOUSLY A FAULTY BUILD, AS GM HAS ALREADY ACKNOWLEDGED. I AM TERRIFIED TO DRIVE THIS CAR AND I STILL OWE ON IT. SO NOW WITH THE INTAKE MANIFOLD BLOWING UP AND A LEAKING VALVE COVER....I JUST DON'T UNDERSTAND HOW GM ISN'T RESPONSIBLE FOR GETTING THESE CARS OFF THE ROAD. I AM SO AFRAID OF BLOWING UP WHILE DRIVING THIS CAR I DON'T KNOW WHAT TO DO AND I BELIEVE IN KARMA AND DO NOT WANT TO TRADE IT IN FOR FEAR OF RISKING SOMEONE ELSE'S LIFE. I'VE OWNED A LOT OF VEHICLES IN THE 30 YEARS I'VE BEEN DRIVING AND AM THANKFUL I'VE NEVER HAD THIS PROBLEM BUT GOOD LORD, HOW DO I FIX THIS?

Mileage: 81,000

REOCCURING PROBLEMS WITH PCV SYSTEM.EMISSIONS SYSTEM, MASS AIR FLOW SENSORS,O2 SENSORS,INTAKE MANIFOLD, VALVE COVERS WONT ACCELERRATE, STALLS WHILE DRIVING AND IDLING, HARD SHIFTING, STABILITY CONTROL SSUES AND STABILITRACK ISSUES, INTAKE AIR FLOW SYSTEM,FUEL TRIM SYSTEM LEAN BANK

Mileage: 67,240

MY VALVE COVER HAS WENT BAD AND STARTED LEAKING OIL AROUND MY SPARK PLUGS. UPON FURTHER INVESTIGATION OF MY OWN I HAVE FOUND OUT THAT THIS IS A COMMON ISSUE FOR MANY YEAR MODELS OF THE CHEVY CRUZE. MY VALVE COVER IS AN UPDATED VERSION OF THE PLASTIC ON THE 2015 AND OLDER AND IS NOW A METAL ONE. I SPOKE WITH A LOCAL MECHANIC WHO INFORMED ME HE HAS REPLACED 75 NEW VALVE COVERS THAT GENERAL MOTORS HAS BUILT A NEW VALVE COVER TO REPLACE THE METAL ONE ON MY CAR. ALSO THIS METAL VALVE COVER HAS CAUSED MY CAR TO START SMOKING HEAVILY WHEN I DROVE IT TO MAKE ME HAVE TO HAVE MY CAR TOWED HOME UNTIL I CAN GET THE ISSUE FIXED.

Mileage: 123,000

CAR WHILE DRIVING SUDDENLY SPUTTERS AND STALLS. I GET AN ERROR MESSAGE SAYING TO CHECK AIRBAGS. THE LOCKS ON THE DOORS WILL UNLOCK AND LOCK AND UNLOCK AN LOCK MULTIPLE TIMES WHILE DRIVING. CHECK ENGINE LIGHT COMES ON. WHEN I PUMP GAS THE CAR WONT START IMMEDIATELY IT SPUTTERS AND CLICKS EVERY TIME.

Mileage: 80,000

CLUTCH HYDRAULICS FAILED WHILE DRIVING IN MY STANDARD TRANSMISSION CAR DUE TO POORLY MANUFACTURED PARTS. CLUTCH WOULD STAY ON THE FLOOR WHEN PUSHED DOWN. MULTIPLE MECHANICS STATED AIR WAS GETTING INTO HYDRAULIC LINE DUE TO POOR MANUFACTURING.

Mileage: 27,500

I PURCHASED A USED VEHICLE FROM ATLANTA LUXURY MOTORS AT KIA SOUTH ON AUGUST 11, 2019. I PURCHASED THIS VEHICLE AS-IS, BUT NO MECHANIC CLAIMS TO HAVE FOUND ANY ISSUES AT THE TIME OF INSPECTION. THE VEHICLE IS A 2016 CHEVROLET CRUZE AND ONLY HAD 70,000 MILES ON IT AT THE TIME OF PURCHASE. ABOUT TWO WEEKS AFTER PURCHASE, THE ENGINE CUT OFF AFTER THE AUTO-STOP INITIATED AND THE CHECK ENGINE LIGHT CAME ON. I HAD TO RESTART THE VEHICLE IN ORDER TO GET OUT OF THE ROAD. SINCE THEN, THE NUMBER OF TIMES THE ENGINE HAS CUT OFF HAS INCREASED IMMENSELY. AS OF OCTOBER 29, 2019, MY ENGINE CUTS OFF ANYTIME THE CAR FALLS INTO AUTO-STOP. TODAY IT HAPPENED EIGHT TIMES DURING ONE FORTY-FIVE MINUTE COMMUTE.

Mileage: 72,680

TL* THE CONTACT OWNS A 2016 CHEVROLET CRUZE. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED AN ABNORMAL FUEL ODOR COMING FROM THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED AND THE FAILURE RECURRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND PROVIDED THE CONTACT WITH CASE NUMBER: 9-542-4410467. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 18V304000 (FUEL SYSTEM, GASOLINE). THE FAILURE MILEAGE WAS APPROXIMATELY 8,000.

Mileage: 8,000

MY 2016 CHEVY CRUZE LIMITED STARTED TO LOSE ACCELERATION AND WOULDN'T GO OVER 40 MILES AN HOUR. NO CODE LIGHTS ARE ON AND NONE DETECTED. SO I DROVE HOME AND PARKED THE CAR AND WAITED UNTIL IT WAS COOLED DOWN AND OPENED THE HOOD TO CHECK MY OIL. I UNSCREWED THE OIL CAP WHERE YOU ADD OIL AND IT COMPLETELY SMELLED LIKE GASOLINE. NOW THE ENGINE IS STARTING TO GO CRAZY AND I AM TAKING IT IN BEFORE IT CATCHES FIRE AND PUTS ME AND ANYONE ELSE IN DANGER.

Mileage: 66,000

"TAKATA RECALL" CAR RANDOMLY LOOSES POWER AND SHUTS OFF WHILE DRIVING ON FREEWAY, ELECTRICAL OUTLETS WON'T WORK, STABILIZATION WARNING APPEAR, BATTERY LEAKS ACID.

Mileage: 45,000

CONTINUING ILLUMINATION OF THE "CHECK ENGINE" LIGHT. TIED TO EMISSION SUSPECT MALFUNCTION CODES. HAS BEEN SERVICE FOR THIS PROBLEM AT LEAST FIVE TIMES. REPLACED FUEL INDUCTION SYSTEM, TURBO, FUEL INDUCTION SOLENOID AND OTHER COMPONENTS. STILL NO RESOLUTION. PROBLEM IS MADE KNOWN BY ILLUMINATION OF "CHECK ENGINE" LIGHT WHILE THE CAR IS RUNNING. NO AFTER MARKET PARTS, APPROX 48,000 MILES. THE DEALER SERVICE DEPARTMENT CANNOT SEEM TO CORRECT THE PROBLEM AFTER MULTIPLE TRIES.

Mileage: 48,000

ENGINE IS KNOCKING CLICKING AND ROCKING. ACTING LIKE IT'S GOING TO STALL STATIONARY. ENGINE LIGHT ON, TRACTION CONTROL LIGHT ON AND ALL START DOES NOT WORK. ALL CAME ON AT THE SAME TIME.

Mileage: 60,257

TAKATA RECAL THE ENGINE SHUTDOWN COMPLETELY WITHOUT A REASON, GAS TANK ALL THE SUDDEN IS EMPTY AND THE WHEELS LOCKED AND SHUTDOWN.

Mileage: 22,000

I WENT TO THE DEALER WHERE I BUT MY CAR AND THEY TOLD THAT THEY SOLD THE SERVICE CONTRACT TO ANOTHER DEALER WHO IS TO FAR FROM WHERE I LEAVE AN I AM A DIALYSIS PATIENT AND 74 YRS OLD TAHTS WHY I CAN TAKE THE CAR FOR BE INSPECTED. THE DEALER ALBERIC COLON AUTO SALES

WAS IN REVERSE GOING OUT THE DRIVE WAY THAT WAS ON A SLIGHT HILL. CAR CUT OFF AND WOULD NOT START. GOT OUT CAR AND SEEN GAS LEAKING AND CHECK ENGINE LIGHT CAME ON. THE CAR WAS IN MOTION ON A NEIGHBORHOOD ROAD. HAD TO HAVE CAR TOW WAS UNSAFE TO DRIVE. ON 8/8/2018 TOOK CAR TO BRADSHAW OF GREER BECAUSE OF A RECALL ON THE FUEL LEAK. CERTAIN GM VEHICLES COULD POSSIBLY HAVE AN ISSUE THAT COULD CAUSE A FUEL LEAK AND THE VPS SENSOR NEEDS A LOCK RING INSTALLED. HAD THE CAR WORKED ON FOR THE RECALL AND I STILL HAD A GAS LEAK. VERY DANGEROUS AND UNSAFE. DEALER SHIP WOULD NOT HAVE MY CAR TOW AFTER THE RECALL SHOULD HAD BEEN FIXED. 18159 NONCOMPLIANCE RECALL---FUEL LEAK DURING F/CMVSS TESTING

Mileage: 36,000

TL* THE CONTACT OWNS A 2016 CHEVROLET CRUZE. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS UNABLE TO RESTART. THE VEHICLE WAS TOWED TO WALKER CHEVROLET (3940 CAR OTHERS PKWY, FRANKLIN, TN, 37067) WHERE IT WAS DIAGNOSED THAT THE CO2 SENSOR FAILED. THE SENSOR WAS REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, TWO MONTHS LATER, THE FAILURE RECURRED. THE VEHICLE STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. AFTER MULTIPLE ATTEMPTS, THE VEHICLE RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE SECOND LOCAL DEALER (LUCAS CHEVROLET CADILLAC, 101 S JAMES CAMPBELL BLVD, COLUMBIA, TN, 38401). IT WAS DIAGNOSED THAT DUE TO AMBIENT TEMPERATURES OVER 100 DEGREES FAHRENHEIT, VAPOR BUILD-UP WAS IN THE FUEL FEED LINE AND CAUSED THE VEHICLE TO STALL. THE DEALER STATED THAT THERE WAS NO REMEDY EXCEPT HIGHER OCTANE. THE DEALER ALSO RECOMMENDED THAT THE VEHICLE BE KEPT IN COOLER TEMPERATURES AND REFRAIN FROM IDLING. THE FAILURE WAS UNDER BULLETIN PIP5507B. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. .UPDATED 11/09/17 *BF UPDATED 11/13/2017*JS

Mileage: 60,000

APPROACHED A CURVE IN ROAD AT APPROXIMATELY 50MPH, TOOK FOOT OFF THE GAS AND ACCELERATOR DID NOT DISENGAGE AND CONTINUED AT FULL SPEED SO FAST COULD NOT NEGOTIATE THE CURVE AND WENT OFF THE CURVE AND CRASHED INTO RAVINE BELOW. THIS OCCURED ONE DAY AFTER THE CAR HAD BEEN SERVICED BY A GM GARAGE ON 1/31/17 ABOUT A COMPLAINT ABOUT THE GAS PEDAL.

Mileage: 30,000

THE THROTTLE STICKS. ITS HAPPENED THREE TIMES NOW

Mileage: 5,000