2004 CHEVROLET EXPRESS 2500 Problems & Recalls

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 2500. THE CONTACT STATED THAT WHEN THE BRAKES WERE APPLIED, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BRAKE PADS AND ROTORS WERE REPLACED; HOWEVER, THE FAILURE CONTINUED. THE CONTACT HAD TO APPLY EXTREME FORC...

Mileage: 115,000

TL* THE CONTACT OWNS A 2004 CHEVROLET EXPRESS 2500. THE CONTACT STATED WHENEVER AT AN IDLE A LOUD METAL TO METAL NOISE WOULD EMIT CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON TWO SEPARATE OCCASIONS WHERE THE CRACKED FLYWHEEL WAS REPLACED EACH TIME. THE MANUFACTURER WAS NOT NOTIF...

Mileage: 119,000

AS I ATTEMPTED TO SPEED UP IN TRAFFIC, I HEARD A NOISE AND THE VEHICLE SUDDENLY SLOWED DOWN. I WAS ABLE TO GET IT OFF THE HIGHWAY ON TO A SIDE ROAD. ONCE THERE, IT WOULD NOT START. ON CLOSER INSPECTION, I SAW THAT THE BELT HAD COME APART AND OFF THE PULLEY'S. I HAD THE VAN TOWED TO MY HOME AND SUBSE...

Mileage: 15,500

MYSTERIOUS COOLANT LEAK. RESERVOIR IS LOW AND NEEDS REFILLING OFTEN. MECHANIC HAS PERFORMED PRESSURE TEST TO NO AVAIL. NO COOLANT ON GROUND AT ANY POINT. NO VISIBLE SIGNS OF LEAK. THIS BEGAN RIGHT AFTER 2ND CRACKED FLYWHEEL WAS REPLACED. AT THE SAME TIME A LIFTER KNOCK BEGAN AS WELL. 1ST FLYW...

Mileage: 103,000

MYSTERIOUS COOLANT LEAK. RESERVOIR IS LOW AND NEEDS REFILLING OFTEN. MECHANIC HAS PERFORMED PRESSURE TEST TO NO AVAIL. NO COOLANT ON GROUND AT ANY POINT. NO VISIBLE SIGNS OF LEAK. THIS BEGAN RIGHT AFTER 2ND CRACKED FLYWHEEL WAS REPLACED. AT THE SAME TIME A LIFTER KNOCK BEGAN AS WELL. 1ST FLYW...

Mileage: 103,000

REPEATED CRACKED FLYWHEEL. ORIGINAL CRACKED JUST OVER 100K MILES. REPLACEMENT NOW CRACKED 40K MILES LATER. *TR

I OWN A 2004 SILVERADO 2500 HD WITH 26,500 MILES ON IT. I HAD MY TRUCK SERVICED FOR SPEEDOMETER THAT WAS NOT WORKING AND WAS TOLD BY KARL CHEVY HERE IN ANKENY, IA THAT ALL OF MY ROTORS AND BRAKE PADS NEEDED TO BE REPLACED BECAUSE OF RUST. GM OUGHT TO FIX MY BRAKES FOR FREE, THEY NEED TO RECALL. ...

Mileage: 26,500

I OWN A 2004 SILVERADO 2500 HD WITH 26,500 MILES ON IT. I HAD MY TRUCK SERVICED FOR SPEEDOMETER THAT WAS NOT WORKING AND WAS TOLD BY KARL CHEVY HERE IN ANKENY, IA THAT ALL OF MY ROTORS AND BRAKE PADS NEEDED TO BE REPLACED BECAUSE OF RUST. GM OUGHT TO FIX MY BRAKES FOR FREE, THEY NEED TO RECALL. ...

Mileage: 26,500

DT*: THE CONTACT STATED THE ELECTRICAL MODULE THAT CONTROLS THE AUDIO WARNING SYSTEM IS LOCATED IN THE ORIGINAL RADIO. THE CONTACT SWITCHED THE RADIO AND LOST ALL OF THE AUDIO WARNING SYSTEMS. THE DEALER AND MANUFACTURER WAS ALERTED AND DETERMINED THE MODULE WAS IN THE ORIGINAL RADIO AND IT SHOUL...

Mileage: 21,000

DURING A SUDDEN STOP CHEVY 2500 EXPRESS ABS BRAKES PULLED TO THE RIGHT OR LEFT. *TS THE CONSUMER STATED THE PROBLEM USUALLY OCCURRED DURING A PANIC STOP. THE CONSUMER STATED HE HAD THREE SEPARATE ACCIDENTS BECAUSE OF THE DEFECTIVE BRAKES. *JB