2009 CHEVROLET EXPRESS 3500 Problems & Recalls

EXTERIOR PAINT PEELS & FLAKES OFF IN SHEETS AS OF NOT ADHERING TO THE METAL. PEELS OFF BOTH WHILE DRIVING & WHEN PARKED. FLAKING OF PAINT IS CONTINUOUS.

Mileage: 92,000

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY ACCELERATED TO APPROXIMATELY 10 MPH. THE ENGINE WAS ON; HOWEVER, THE GEAR SHIFT WAS IN THE PARK POSITION WITH NO DRIVER. THE CONTACT MENTIONED THAT THE FRONT PASSENGER SEAT WAS OCCUPIED AT THE TIME ...

Mileage: 123,000

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. UPON STARTING THE VEHICLE, THE SERVICE AIR BAG INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ROLL OVER SENSOR BECAME INOPERABLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPA...

Mileage: 59,747

I TOOK THE VAN IN TO A DEALER TO FIND OUT WHY THE SERVICE AIR BAG LIGHT IS ON. AFTER PAYING $60.00 FOR A DIAGNOSTICS CHECK, (WHICH I STILL DON'T LIKE) THEY TOLD ME THE ROLLOVER SENSOR NEEDS TO BE REPLACED AT A CRIMINAL $700.00 WHICH I WILL NOT PAY. SOUNDS LIKE A GM ISSUE TO ME SO I CALLED THE HOT L...

Mileage: 59,747

VEHICLE WAS SHAKING. TOOK TO [XXX] INC.IN SYRACUSE, NY FOR ALIGNMENT. WAS TOLD VEHICLE WAS IN ALIGNMENT. WAS TOLD THAT THE STEEL BELTS IN THE TIRES WERE BAD DUE TO TIRES BULGING ON THE OUTSIDE AND INDENTED IN THE CENTER OF THE TIRE. WOULD NOT RECOMMEND TIRE ROTATION. ALL 6 TIRES ARE EFFECTED. THE W...

Mileage: 14,000

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN THE IGNITION IN ORDER TO START THE VEHICLE AND THE KEY COULD BE REMOVED FROM THE IGNITION WHILE THE VEHICLE WAS TURNED ON. THIS FAILURE OCCURRED INTERMITTENTLY FOR SEVERAL YEARS. THE VEHICLE WAS T...

Mileage: 110,000

TL* THE CONTACT OWNS A 2009 CHEVROLET EXPRESS 3500. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN THE IGNITION IN ORDER TO START THE VEHICLE AND THE KEY COULD BE REMOVED FROM THE IGNITION WHILE THE VEHICLE WAS TURNED ON. THIS FAILURE OCCURRED INTERMITTENTLY FOR SEVERAL YEARS. THE VEHICLE WAS T...

Mileage: 110,000

WHEN REFUELING THIS VEHICLE, THE GASOLINE DOES NOT FLOW WITH EASE THROUGH THE INTAKE TUBES. IT BACKS UP, OVERFLOWING THE FILLER PIPE, SPILLING OUT OR SHUTTING OFF THE GAS NOZZLE REPEATEDLY. IT CAN TAKE TEN MINUTES TO PUT TEN GALLONS OF GASOLINE IN THE TANK. THERE ARE MANY OTHER OWNERS HAVING THE ...

Mileage: 18,000

WHEN REFUELING THIS VEHICLE, THE GASOLINE DOES NOT FLOW WITH EASE THROUGH THE INTAKE TUBES. IT BACKS UP, OVERFLOWING THE FILLER PIPE, SPILLING OUT OR SHUTTING OFF THE GAS NOZZLE REPEATEDLY. IT CAN TAKE TEN MINUTES TO PUT TEN GALLONS OF GASOLINE IN THE TANK. THERE ARE MANY OTHER OWNERS HAVING THE ...

Mileage: 18,000

CHEVY EXPRESS 4500 DIESEL CUTAWAY. FUEL OIL HEATER (FOH) IS AN AUXILIARY HEATER LOCATED UNDER THE CAB OF THE VEHICLE AND EXHAUSTS IN THE SAME AREA. ODOR OF PARTIALLY BURNED FUEL AND A STRONG EXHAUST SMALL WOULD ENTER THE CAB OF THE VEHICLE DURING LOW SPEED OPERATION IN COLD WEATHER. DUE TO THE INTER...

Mileage: 82,000

I HAVE A 2009 CHEVROLET EXPRESS 3500 WITH 51,000 MILES ON IT. IN A TWO WEEK PERIOD AT THE END OF JAN '10 I HAD 3 TIRE VALVE STEM FAILURES. WHEN I ATTEMPTED TO REMOVE THE VALVE CAP TO CHECK AIR PRESSURE THE TOP OF THE STEM BLEW RIGHT OFF. I'VE REPLACED THREE AND THE ONE REMAINING FACTORY VALVE STEM I...

Mileage: 51,000