2016 CHEVROLET EXPRESS Problems & Recalls
Detailed safety information and owner complaints
Problem Breakdown
Compare to Other Years
Common Problems
General Motors LLC (GM) is recalling certain 2016-2019 Chevrolet Express and GMC Savana vehicles. One or both of the rear-quarter windows may be tempered glass instead of laminated glass. As such, t...
General Motors LLC (GM) is recalling certain 2016-2018 Chevrolet Express and GMC Sierra vehicles equipped with a single, manual, rear climate control module (CCM). If the temperature is set to maximu...
General Motors LLC (GM) is recalling certain 2014-2017 Chevrolet Express and GMC Savana vehicles equipped with power windows. Liquid may leak into the driver's power window switch and cause corrosion...
General Motors LLC (GM) is recalling certain 2009-2014 Chevrolet Silverado HD and GMC Sierra HD, 2009 GMC Topkick 5000, 6000, 7000 and 8000 Series and Isuzu F Series, and 2009-2018 Chevrolet Express, ...
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Express manufactured September 25, 2015, to August 22, 2016, and 2016 GMC Savana cargo and cutaway vans manufactured January...
General Motors LLC (GM) is recalling certain model year 2014-2016 Chevrolet Express and GMC Savana incomplete vehicles equipped with a 159 inch wheel base manufactured August 2, 2013, to January 30, 2...
The contact owns a 2016 Chevrolet Express. The contact stated while driving 65 MPH, the “Service Engine” warning light flashed on and off. The contact stated that after arriving to the residence and shifting into reverse(R), the vehicle failed to respond as needed. The vehicle was turned off and...
Mileage: 88,000
The contact owns a 2016 Chevrolet Express. The contact stated while driving 65 MPH, the “Service Engine” warning light flashed on and off. The contact stated that after arriving to the residence and shifting into reverse(R), the vehicle failed to respond as needed. The vehicle was turned off and...
Mileage: 88,000
ABS Module Broken. Needs repair. No part available. Part Number 84055065 needed. Vehicle was on highway slowed on to onramp when ABS went off for no reason. Van Pulled to right drastically.
ABS Module Broken. Needs repair. No part available. Part Number 84055065 needed. Vehicle was on highway slowed on to onramp when ABS went off for no reason. Van Pulled to right drastically.
LT245/75R16 The fist tire failure was rear driver's side which caused a code service stable trac- this caused the vehicle to lose power and engine to die. I made home at 20mph in yraffic.I spent $500 for diagnostic check and new tire. The tire is misshapen and alerts sensor that caused engine to lo...
LT245/75R16 The fist tire failure was rear driver's side which caused a code service stable trac- this caused the vehicle to lose power and engine to die. I made home at 20mph in yraffic.I spent $500 for diagnostic check and new tire. The tire is misshapen and alerts sensor that caused engine to lo...
I'd be driving down the street when my brakes would apply by them selves slowing my car down . after that my dash would bong and the ABS light would come on . I took it to my Chevy dealer and they replaced the brakes and said it was fixed . I pulled out of the dealers lot and was driving at 35MPH wh...
I'd be driving down the street when my brakes would apply by them selves slowing my car down . after that my dash would bong and the ABS light would come on . I took it to my Chevy dealer and they replaced the brakes and said it was fixed . I pulled out of the dealers lot and was driving at 35MPH wh...
I'd be driving down the street and the brakes would start applying themselves by themselves . I took the van to Ganly Chevrolet the first time and they did a brake job and said it was fixed . I drove it about a half mile and was doing about 35MPH when the brakes locked , if I wasn't buckled in I pro...
PROBLEM: POWER WINDOW WOULDN'T WORK, REAR DEFROSTER WOULD NOT WORK, VEHICLE WOULD NOT START, VEHICLE WOULD CRANK BUT NOT START. CAR HAD TO BE TOWED. THE RELAYS WERE DEFECTIVE AND WERE REPLACED. UPON TAKING THE RELAYS APART , I FOUND THAT THEY WERE RUSTED INSIDE AND THE RUST WAS FLAKING OFF. I CO...
Mileage: 21,253
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. WHILE TRAVELING UP A HILL AT APPROXIMATELY 45 MPH, THE VEHICLE STARTED MISFIRING AND HESITATING. AFTER DEPRESSING THE ACCELERATOR PEDAL SEVERAL TIMES, THE VEHICLE RESPONDED NORMALLY. THE CONTACT STATED THAT THE FAILURES OCCURRED SINCE MAY OF 2019. THE V...
Mileage: 35,000
FRONT A/C SWITCH TO TURN A/C OFF AND ON AND ALSO TO GO FROM DASH VENT TO FLOOR VENTS AND DEFROST WILL NOT GO TO ANYTHING BUT FRONT VENTS...
Mileage: 40,000
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. THE CONTACT STATED THAT WATER WAS LEAKING FROM THE DRIVER'S SIDE VISOR CONNECTION. WATER ALSO LEAKED ONTO THE CONTACT AND THE FLOOR. THE INSTRUMENT PANEL WAS ALSO LEAKING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SAWYER CHE...
Mileage: 36,000
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. THE CONTACT STATED THAT WATER WAS LEAKING FROM THE DRIVER'S SIDE VISOR CONNECTION. WATER ALSO LEAKED ONTO THE CONTACT AND THE FLOOR. THE INSTRUMENT PANEL WAS ALSO LEAKING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SAWYER CHE...
Mileage: 36,000
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. UPON STARTING THE VEHICLE, THE SERVICE THEFT DETERRENT SYSTEM WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO HAYWARD MITSUBISHI (25601 MISSION BLVD, HAYWARD, CA 94544, (510) 999-5999) AND THE CONTACT WAS INFORMED THAT THE IGNITION KEY COULD BE ...
VEHICLE BOUNCES WHEN TRAVELLING ON AN UNEVEN SURFACE. I.E., CONCRETE BRIDGE OR OVERPASS. THIS CONDITION IS MORE PREVALENT WHEN TRAVELLING ON THE HIGHWAY. THIS VEHICLE IS UNSAFE TO OPERATE AND THE MANUFACTURER IS UNWILLING TO REMEDY THE PROBLEM, STATING THIS IS A CHARACTERISTIC OF THE VEHICLE AND THE...
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS BEING OPERATED AT 55 MPH, THE VEHICLE STALLED AND THERE WAS AN ABNORMAL FUEL ODOR. THE FAILURE OCCURRED WITHOUT WARNING. UPON INSPECTION, IT WAS NOTICED THAT THERE WAS A FUEL LEAK. THE VEHICLE WAS TOWED TO A TOW TRUCK LOT. THE VEHI...
Mileage: 1,000
THIS COMPLAINT IN REGARDS TO HOW GENERAL MOTORS HAS CONFISCATED MY NEW CAR!! MY RECENTLY PURCHASED (AND, PAID FOR) CHEVY SS HAS BEEN CONFISCATED BY GM DUE TO GM'S POORLY WORDED RECALL. I HAVE THE TITLE AND KEYS TO THE VEHICLE BUT DUE TO THE RECALL THAT EFFECTS MODEL YEARS 2014-2016, GM HAS BEEN DEC...
Mileage: 20
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PARKED ON AN INCLINE AND THE SLIDING DOOR WAS OPENED, THERE WAS NO LOCKING MECHANISM TO PROHIBIT THE SLIDING DOOR FROM CLOSING INDEPENDENTLY. THE CONTACT STATED THAT ON SEVERAL OCCASIONS THE DOOR CLOSED INDEP...
Mileage: 300
TL* THE CONTACT OWNS A 2016 CHEVROLET EXPRESS. WHILE THE VEHICLE WAS PARKED, THE DOOR CLOSED WITHOUT WARNING EVEN WHEN THE VEHICLE WAS ON AN INCLINE. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS ADVISED BY THE TECHNICIAN THAT THE DOOR WAS PERFORMING AS D...
Mileage: 2,000