2021 CHEVROLET EXPRESS Problems & Recalls
Detailed safety information and owner complaints
Problem Breakdown
Compare to Other Years
Common Problems
General Motors, LLC (GM) is recalling certain 2021 Chevrolet Express and GMC Savana vehicles equipped with 6.6L gasoline engines. The positive battery cable terminals may contact a fuse block assembl...
General Motors LLC (GM) is recalling certain 2020 Buick Enclave, Cadillac XT4, XT5, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, Traverse, GMC Yukon, Yukon XL, 2018-2021 Chevrolet Express, GMC S...
My 2021 Chevrolet express van with an 8L90 transmission has failed after only 80k miles, willing to have it inspected. Check engine codes show P0700 and P2714 on 02/08/25. No prior warning lamps. This product has put my safety at risk due to overheating and making the vehicle go into limp mode while...
The contact owns a 2021 Chevrolet Express. The contact stated that while driving at an undisclosed speed, the vehicle started to pull to the left, prompting the contact to pull over to the shoulder off the roadway. After a visual inspection, the contact stated there was smoke coming from the driver'...
Mileage: 18,000
This is a Forest River Sunseeker Motorhome on a 2021 Chevrolet Express chasis. On Friday, [XXX], after being in stop and go traffic for 10-15 minutes on [XXX] driving at 65 mph, a smell of burning brakes started filling up the motorhome. Then the vehicle started to wobble and the ABS light came on...
Fuel Pump Control Module failed in vehicle with only 26,000 miles. No warning light came on. No previous issue. Vehicle stalled while driving speed limit, all control of steering and braking was lost and vehicle did not restart. Needed to have vehicle towed. Vehicle was diagnosed by a dealership. ...
When I come to stop in traffic the drivetrain suddenly jolts and pushes the vehicle forward potentially pushing me into the car or traffic in front of me unless I put it in neutral or press hard on the brakes approaching the stoplight. Happens everyday.
The contact owns a 2021 Chevrolet Express. The contact stated while driving at approximately 55 MPH the contact was crashed into by a deer, the contact stated that the deer struck the driver's side front headlight and then the driver's door. The contact stated that the left headlight was fractured a...
Mileage: 65,000
The contact owns a 2021 Chevrolet Express. The contact stated while driving out of the driveaway, the vehicle shut off inadvertently and failed to restart. The vehicle was towed to the dealer, where it was diagnosed that the fuel pump control module had failed and needed to be replaced. The vehicle ...
Mileage: 5,000
The fuel pump power control module in this vehicle has caused the fuel pump to fail or operate intermittently, interrupting the flow of fuel to the engine. When the engine does not receive adequate fuel, the vehicle has unexpectedly stalled. This has happened several times. At times has seen a check...
While driving engine inexplicably shut off leaving us without power steering or brakes and unable to safely navigate off of the roadway. Fault: Fuel Pump Control Module GM representative stated they are seeing numerous failures of these components
The contact rented a 2021 Chevrolet Express. The contact stated that while driving approximately 30 MPH, the power steering malfunctioned, and the steering wheel became difficult to turn in either direction. The vehicle was slowed to 10 MPH for the contact to regain control of the steering wheel. Th...
Mileage: 23
TPS monitoring system displayed front right tire pressure low. Seconds later tire blew-out where sidewall meets tread. We luckily were traveling at low rate of speed (25mph). This is new van with 100 miles on it.
TPS monitoring system displayed front right tire pressure low. Seconds later tire blew-out where sidewall meets tread. We luckily were traveling at low rate of speed (25mph). This is new van with 100 miles on it.