2006 CHEVROLET HHR Latches/locks/linkages Problems

The contact owns a 2006 Chevrolet HHR. The contact stated that while driving at various speeds, the vehicle lost motive power and would not properly accelerate. Additionally, the front passenger’s side door would not open while using the interior door latch. The contact stated while using the cigarette lighter, the vehicle shut off, and smoke filled the cabin of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were not contacted. The failure mileage was 92,000.

Mileage: 92,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE, THE ENGINE TEMPERATURE GAUGE INDICATED THAT THE ENGINE WAS OVERHEATING. ADDITIONALLY, THE PASSENGER'S SIDE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY AND THE REAR HATCH DOOR WOULD ERRONEOUSLY OPENED AND WOULD NOT REMAIN SECURELY CLOSED. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT CONTACTED OR NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 220,000.

Mileage: 220,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE DOOR HANDLES FRACTURED. THE FAILURE HAPPENED WITHOUT WARNING. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE BATTERY ALSO FAILED AND PREVENTED THE DRIVER AND PASSENGER SIDE WINDOWS FROM BEING USED. THE VEHICLE WAS DIAGNOSED AND THE DOOR HANDLES WERE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 175,000.

Mileage: 175,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACTED STATED WHILE EXITING THE VEHICLE, THE DOOR HANDLE FAILED. AS A RESULT THE CONTACT WAS UNABLE TO EXIT THE VEHICLE. THE FAILURE RECURRED ON THREE OCCASIONS. THE VEHICLE WAS TAKEN A DEALER. THE MECHANIC STATED THAT THE DOOR HANDLE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

Mileage: 50,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER'S SIDE EXTERIOR DOOR LATCH FRACTURED ON TWO SEPARATE OCCASIONS. THE DEALER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 08V444000 (LATCHES/LOCKS/LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 20,000.

Mileage: 20,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE INTERIOR DOOR HANDLES BECAME FRACTURED AND WERE NOT REPLACED. IN ADDITION, NHTSA CAMPAIGN NUMBER 14V171000 (ELECTRICAL SYSTEM) WAS REFERENCED HOWEVER, THE CONTACT WAS UNABLE TO HAVE THE VEHICLE SERVICED UNDER THE RECALL BECAUSE THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER AND FRONT PASSENGER SIDE INTERIOR DOOR HANDLES WERE FRACTURED. THE CONTACT WAS UNABLE TO EXIT THE VEHICLE USING THE INTERIOR DOOR HANDLES. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE DOOR HANDLES HAD BROKEN OFF DUE TO THE WEAKENED PLASTIC MATERIALS USED TO MANUFACTURE THEM. THE MANUFACTURER WAS NOTIFIED AND NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 100,000. UPDATED 07/08/14 MA THE CONSUMER ALSO STATED THE VEHICLE STALLED.

Mileage: 10,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR FAILED TO OPEN FROM THE INSIDE OR OUTSIDE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 93,724. *TR UPDATED 04/30/13*LJ

Mileage: 93,724

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE INTERIOR DOOR HANDLE ON THE FRONT DRIVER'S SIDE BROKE OFF. THE VEHICLE WAS TAKEN TO A REPAIR SHOP, HOWEVER IT WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, HOWEVER NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE AND CURRENT MILEAGES WERE 124,000.

Mileage: 124,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE PASSENGER SIDE DOOR HANDLE BROKE AWAY FROM THE CABLE THAT ALLOWED THE DOOR TO OPEN. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE CONTACT STATED THAT THE SAME FAILURE OCCURRED ON THE DRIVER'S SIDE IN THE PAST. THE DEALER STATED THAT THEY HAD TO REPLACE THE DOOR LATCH AND RECONNECT THE CABLE TO THE LATCH. THE MANUFACTURER WAS CONTACTED AND WOULD INVESTIGATE THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 77,000. ... UPDATED 07/27/12 *BF . THE COSUMER BELIEVES THAT THE PLASTIC BECOMES DEHYDRATED FROM AIR FLOW AND BAKING HEAT FROM THE SUN. UPDATED 08/02/2012 *JS

Mileage: 77,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE PARKED, THE CONTACT ATTEMPTED TO OPEN THE FRONT DRIVER SIDE DOOR FROM THE INTERIOR OF THE VEHICLE BUT THE DOOR HANDLE DETACHED ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS WHERE THE TECHNICIAN ADVISED THAT THE DOOR PANEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 99,900. UPDATED 01/20/12*LJ THE CONSUMER STATED THE ENTIRE DOOR PANEL NEEDED TO BE REPLACED, JUST FOR AN EXPENSIVE HANDLE. UPDATED 01/27/12

Mileage: 99,900

2006 DOOR HANDLE BROKE FOR NO REASON. IS UNABLE TO OPEN FROM INSIDE. ITS A SEFETY ISSUE IF U HAVE TO GET OUT IN AN EMERGENCY. *TT

THE POWER STEERING DOESNT WORK ANYMORE, BOTH OF THE FRONT INSIDE DOOR HANDLES BROKE OFF, WATER LEAKING IN PASSENGER FRONT COMING FROM THE MOTER AREA SOMEWHERE I CALLED THE DEALERSHIP BUT NO RECALLS AND I HAVE READ ON NUMORUS FORUMS OF OTHER PEOPLE HAVING THE SAME PROBLEM BUT GM STILL HASN'T ISSUED A RECALL. *TT

Mileage: 75,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE PARKED, THE INTERIOR DRIVERS SIDE DOOR HANDLE DETACHED FROM THE VEHICLE. AFTER OPENING THE WINDOW, THE CONTACT WAS ABLE TO OPEN THE DOOR FROM THE EXTERIOR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC TEST AND THE TECHNICIAN STATED THAT THE DOOR PANEL WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. UPDATED 10/4/11 *CN UPDATED 10/26/11 IN DECEMBER 2013, THE DRIVER'S SIDE SEAT BELT FASTENER JAMMED AND WOULD NOT RELEASE. THE CONSUMER HAD THE DEFECT REPAIRED. IN MARCH 2014, SUDDENLY, WITHOUT WARNING, THE VEHICLE LOST POWER STEERING. THE CONSUMER PAID TO HAVE THE DEFECT CORRECTED. UPDATED 04/14/14

Mileage: 35,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT HANDLE DETACHED FROM THE FRONT DRIVER SIDE DOOR WHEN ENTERING THE VEHICLE. THE SAME FAILURE OCCURRED A MONTH PRIOR TO THE RECENT FAILURE ON THE FRONT PASSENGER SIDE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 74,500 AND THE CURRENT MILEAGE WAS 74,600.

Mileage: 74,500

DRIVERS DOOR IS BROKEN, HAVE TO ROLL WINDOW DOWN TO GET OUT, ALSO, REMOTE IS NOT WORKING, I HAVE TO LOCK/UNLOCK WITH THE HORN HONKING EVERYTIME I PARK. AFTER DOING A SEARCH ONLINE, I FOUND THAT A LOT OF OTHER PEOPLE HAVE HAD THE SAME PROBLEM, AND IT SEEMS TO STEM FROM THE FACT, THAT CHEVY HAS DECIDED NOT TO BE BUILT LIKE A ROCK, INSTEAD, BUILT WITH PLASTIC. (CAN YOU EVEN RECYCLE IT?)

INSIDE DRIVER SIDE HANDLE BROKE OFF, UNABLE TO OPEN DOOR FROM THE INSIDE THE ELECTRONIC WINDOW MUST BE OPENED AND DOOR OPENED FROM THE OUTSIDE. *TR

INSIDE DOOR HANDLE ON MY 2006 CHEVROLET HHR BROKE OFF WHEN I OPENED THE DOOR. THIS CREATES A SAFETY ISSUE FOR THE DRIVER AS THE DOOR CANNOT BE OPENED FROM THE INSIDE WITHOUT LOWERING THE LEFT FRONT WINDOW AND OPENING WITH THE OUTSIDE HANDLE. IF THE ELECTRICAL SYSTEM IS DAMAGED THEN THE WINDOW WILL NOT OPEN. THE DRIVER WOULD THEN NEED TO CRAWL OVER THE CENTER CONSOLE TO THE RIGHT DOOR OR THE FRONT SEAT TO EXIT THE CARS REAR DOOR. IN A COLLISION OR FIRE THE DRIVER MAY BE INJURED, PANICKED OR CONFUSED AND NOT BE ABLE TO EXIT THE VEHICLE. THE PLASTIC HANDLE SHOULD BE REPLACED WITH A MORE SUBSTANTIAL METAL ONE. *TR

Mileage: 16,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE ATTEMPTING TO OPEN THE DRIVERS DOOR THE INSIDE DOOR HANDLE DETACHED FROM THE DOOR PANEL. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER INSPECTED THE VEHICLE, AND STATED THAT THE DOOR HANDLE, AND THE DOOR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 64,000.

Mileage: 30,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE DOOR HANDLE FRACTURED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE ENTIRE DRIVER SIDE DOOR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 63,000.

Mileage: 63,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THE FRONT DRIVER SIDE INTERIOR DOOR HANDLE COMPLETELY FRACTURED AND SHE COULD NOT EXIT THE VEHICLE. AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE ENTIRE DOOR PANEL WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS THEN NOTIFIED AND THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 60,000.

Mileage: 60,000

THE INTERIOR DOOR HANDLES ON THE 2006 CHEVROLET HHR FELL OFF. THE ONLY WAY TO FIX IT IS TO REPLACE THE ENTIRE DOOR PANEL JUST FOR THE CHEAP PLASTIC HANDLE FOR APPROXIMATELY $500.00. IF I WAS IN AN ACCIDENT AND THE CAR WOULD NOT START AGAIN, I COULD NOT GET OUT OF THE CAR THROUGH THE DRIVER'S SIDE BECAUSE I WOULD NOT BE ABLE TO ROLL DOWN THE WINDOW TO OPEN THE DOOR FROM THE OUTSIDE. OR IF THE CAR WERE ON FIRE, I SIMPLY WOULD NOT BE ABLE TO ESCAPE. THIS NEEDS TO BE A RECALL ITEM AS THIS IS A HUGE SAFETY FACTOR. A BIGGER SAFETY FACTOR THAT THE LATCH ON THE POP UP MIDDLE CONSOLE ON THE CHEVY HHR THAT WAS RECALLED BACK IN 2008 (I THINK). THERE ARE BLOGS ALL OVER THE INTERNET OF PEOPLE LIKE ME WHO ARE EXPERIENCING THE SAME PROBLEM. I AM A SINGLE WORKING GIRL WHO SIMPLY CANNOT AFFORD A $500 INTERIOR DOOR PANEL REPLACEMENT FOR A CHEAP PLASTIC HANDLE BECAUSE THIS IS NOT REASONABLE. I TRIED TO GET CHEVY TO REPLACE IT AND THEY SIMPLY SAID THEY WOULD GIVE ME A $40 DISCOUNT. THAT IS RIDICULOUS!!! I BOUGHT THE CAR BE CAUSE IT WAS ECONOMICAL AND NOT ONE THING ABOUT THIS REPLACEMENT SOUNDS ECONOMICAL. THIS IS A SAFETY HAZARD AND COULD LEAD TO A DEATH. *TR

Mileage: 56,663

I HAVE A 2006 HHR. WHILE TRYING TO EXIT OUT THE PASSENGER SIDE DOOR THE DOOR HANDLE BROKE IN MY HAND SO NOW ANYONE SITTING THERE HAS TO OPEN THE WINDOW AN REACH OUT AND OPEN THE DOOR (OR SOMEONE HAS TO OPEN FOR THEM). THE OTHER PROBLEM I JUST ENCOUNTERED IS THAT THE "DOOR OPEN" MESSAGE AND DINGING NOISE KEEPS COMING UP WHILE I AM DRIVING. THE DOOR IS NOT OPEN! ALSO, THE RADIO WON'T SHUT OFF WHEN YOU TURN THE CAR OFF AND OPEN THE DOOR. WHEN PUSHING THE INSIDE LOCK/UNLOCK BUTTON ON THE DRIVER'S SIDE, ALL THE DOORS LOCK EXCEPT THE DRIVER'S SIDE. IT GOES DOWN, BUT COMES BACK UP. MY MECHANIC THINKS IT IS A DOOR LATCH PROBLEM. ALSO THE ALARM GOES OFF BY ITSELF AFTER LOCKING THE CAR WITH THE REMOTE. I WAS AWOKEN AT 3:00 AM TO THE SOUND OF MY CAR GOING OFF, THIS HAS NEVER HAPPENED BEFORE! GM NEEDS TO DO SOME RECALLS ON THESE ITEMS, AS I SEE A LOT OF COMPLAINTS CONCERNING THE SAME ITEMS. *TR

Mileage: 85,000

DRIVER SIDE INSIDE DOOR HANDLE BFOKE OFF, NEED TO OPEN WINDOW AND REACH OUTSIDE TO OPEN DOOR.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR LT. THE CONTACT STATED THAT WHILE OPENING THE DRIVER SIDE DOOR, THE INTERIOR HANDLE FRACTURED FROM THE DOOR FRAME. THE MANUFACTURER ADVISED THAT THE DOOR HANDLE FAILURE WAS NOT RECALLED AND THAT THEY WILL NOT ASSIST WITH THE REPAIR. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 67,000 AND THE CURRENT MILEAGE 70,648.

Mileage: 67,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED WHILE ATTEMPTING TO EXIT THE VEHICLE, FROM THE DRIVERS SIDE, THE INTERIOR DOOR HANDLE FRACTURED. THE CONTACT WAS UNABLE TO ACCESS THE EXTERIOR DOOR HANDLE AND FIFTEEN MINUTES LATER, HE WAS ASSISTED IN EXITING THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE FAILURE WHERE HE WAS ADVISED THAT THE ENTIRE DOOR WOULD NEED REPLACING IN ORDER TO CORRECT THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE DOOR HANDLE REMAINED FRACTURED. IN ADDITION, THE KEYS WOULD SPORADICALLY BECOME STUCK IN THE IGNITION AND THE CONTACT WOULD HAVE TO ENGAGE THE EMERGENCY RELEASE BUTTON IN ORDER TO DISENGAGE THE KEYS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS ADVISED THAT THE IGNITION LOCK CYLINDER AND REMOTE WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 27,920. UPDATED 05/25/11 *BF UPDATED 1/5/12 *CN

Mileage: 21,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE FRONT DRIVER SIDE INTERIOR PLASTIC DOOR HANDLE FRACTURED FOR THE SECOND TIME. THE DOOR HANDLE WAS PREVIOUSLY REPAIRED FOR THE SAME FAILURE. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER BUT WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 59,000. UPDATED 4/11/2011 *CN UPDATED 04/25/11

Mileage: 59,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DOOR PANEL INTERIOR WAS INTERFERING WITH THE OPENING OF THE DOOR. SHE ALSO MENTIONED THAT SHE WOULD HAVE TO WIND DOWN THE WINDOW IN ORDER TO OPEN IT FROM THE OUTSIDE. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT SHE NEEDED TO REPLACE THE INTERIOR DRIVER SIDE DOOR PANEL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. UPDATED 3/7/11 *CN THE CONSUMER STATED HE/SHE WAS UNABLE TO OPEN THE DOOR, UNLESS HE STUCK HIS HAND OUT THE WINDOW TO OPEN IT FROM THE OUTSIDE. UPDATED 03/14/11

Mileage: 80,000

WHILE OPENING THE LEFT FRONT DOOR FROM THE INSIDE THE PLASTIC CHROME DOOR HANDLE BROKE OFF IN MY HAND MAKING IT IMPOSSIBLE TO OPEN THE DOOR FROM THE INSIDE. THIS WILL IMPAIR THE ABILITY OF THE OCCUPANTS TO EXIT THE VEHICLE IN THE EVENT OF AN EMERGENCY. *TR

Mileage: 75,000

2006 CHEVROLET HHR. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE *TGW THE CONSUMER STATED HIS SONS VEHICLE HAD A SEVERE SHIMMY IN THE STEERING WHEEL AND BECAME PROGRESSIVELY WORSE WHEN THE BRAKE WAS APPLIED. THE PADS AND ROTORS WERE REPLACED TWICE AND THE THIRD TIME THE ROTORS WERE MACHINED, BUT THE PROBLEM CONTINUED. THERE WAS ALSO A STRANGE NOISE COMING FROM THE FRONT SUSPENSION, BUT THE DEALER WAS UNABLE TO PINPOINT THE PROBLEM. AT 42,000 MILES THE AIR CONDITION MADE A LOUD SCREECHING NOISE FOR 2 MINUTES, THEN STOPPED WORKING. AT 68,000 MILES, A METAL SKID PLATE HAD FALLEN FROM UNDERNEATH THE VEHICLE. SOON AFTER, THE EXHAUST WAS VERY LOUD. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP AND THE CONSUMER WAS INFORMED THE CATALYTIC CONVERTER HAD CRACKED. THE VEHICLE LOST POWER AND A CYLINDER HAD TO BE REPLACED, THE CHECK ENGINE LIGHT WOULD COME ON AND THEN GO OFF, THE TEMPERATURE GAUGE DID NOT WORK, SO THE AIR CONDITION ONLY WORKED IF THE CHECK ENGINE LIGHT WAS OFF. THE DOOR LOCKS DID NOT WORK, THE RADIO WORKED INTERMITTENTLY, THE SUN VISOR WOULD FALL DOWN AT RANDOM TIMES. THERE WERE TIMES WHEN THE VEHICLE WOULD NOT START. THE CONSUMER STATED EVEN WITH AN ALIGNMENT, NEW STRUTS, SHOCKS AND GOOD TIRES, THE VEHICLE CONTINUALLY PULLED TO THE RIGHT. *JB

Mileage: 38,000

I CURRENTLY OWN A 2006 CHEVROLET HHR. ON 1-13-11, I HAD THE INTERIOR DOOR HANDLE BREAK OFF IN MY HAND MAKING IT IMPOSSIBLE TO OPEN THE DOOR FROM THE INSIDE OF THE CAR. THIS IS A HUGE SAFETY HAZARD WHILE DRIVING THE CAR. UPON FURTHER RESEARCH ON CAR FORUMS ONLINE, I AM NOT THE ONLY PERSON THAT HAS HAD THIS PROBLEM. *TR

Mileage: 172,000

I OWN A 2006 CHEVY HHR LT. THANKSGIVING DAY I WENT TO MOVE MY CAR OUT OF THE DRIVEWAY AND WHEN I TRIED TO GET OUT OF THE CAR THE INTERIOR DOOR HANDLE ON THE DRIVER DOOR CAME OFF IN MY HAND. I HAVE DONE MY RESEARCH AND FOUND THIS IS A COMMON PROBLEM WITH THIS VEHICLE. I EVEN WALKED UP TO ANOTHER HHR I SAW ON A PARKING LOT AND IT HAD THE SAME PROBLEM. MY SAFELY CONCERN IS THAT I CANNOT OPEN THE DOOR WITHOUT ROLLING DOWN MY WINDOW AND REACHING OUTSIDE THE CAR TO THE EXTERIOR HANDLE. IF I WAS IN AN ACCIDENT AND HAD A ELECTRICAL FAILURE I COULD NOT EXIT THE CAR BECAUSE I COULD NOT ROLL DOWN THE WINDOW. EVERYTHING I HAVE FOUND IN MY RESEARCH IS THAT CHEVROLET IS NOT RECGONIZING THIS AS A REAL PROBLEM AND FROM WHAT I HAVE SEEN/READ THEY HAVE BEEN UNWILLING TO CORRECT THE PROBLEM WHEN IT OCCURS OR HELP THE VEHICLE OWNERS IN ANY WAY. I HAVE CHECKED ON THE REPAIR AND FOUND THAT THE DOOR HANDLE ITSELF CAN NOT BE REPLACED THAT YOU HAVE TO BUY AN ENTIRE DOOR PANEL FOR OVER $400 AND THAT IS JUST THE PART, NO LABOR. HOW CAN THIS BE A KNOWN PROBLEM, AND CHEVROLET NOT STAND BEHIND THEIR PRODUCT? THE INABILITY TO EXIT MY VEHICLE IN THE AFTERMATH OF AN ACCIDENT GREATLY CONCERNS ME AND SHOULD CONCERN CHEVROLET ESPECIALLY WITH THE MULTIPLE COMPLAINTS I HAVE READ ONLINE OF THIS ISSUE OCCURRING. *TR

Mileage: 69,000

MY KEY CONTINUES TO GET STUCK IN THE IGNITION. ABOUT 4 MONTHS AGO THIS HAPPENED AND I TOOK MY CAR BACK TO THE DEALER,THEY CHARGED ME $50.00 TO GET THE KEY OUT THEY SAY THEY GREASED THE IGNITION I GUESS. I WAS LOOKING THROUGH MY CAR MANUAL AND IT TELLS YOU HOW TO GET THE KEY OUT OF THE IGNITION.I DON'T THINK THE DEALER CHARGING ME $50.00 WAS FAIR. IS THERE SOME WAY THAT CAN BE FIXED? I CAN NOT AFFORD $50.00 AND I'M GET TIRED OF PUTTING MY FINGER IN THE HOLE UNDER THE STEERING WHEEL TO RELEASE THE KEY. *TR

2006 CHEVROLET HHR INTERIOR DOOR HANDLE FAILURES. IN MY INSTANCE THE PLASTIC HANDLE THAT IS USED TO OPEN THE DOOR ON THE DRIVERS SIDE BROKE OFF. THIS IS A WIDELY COMPLAINED ABOUT ISSUE ON THE WEB. IF YOU GOOGLE "HHR DRIVERS SIDE INTERIOR DOOR HANDLE BROKEN" YOU GET 1000'S OF PEOPLE DISCUSSING THIS ISSUE. THE COST TO REPAIR IS VERY HIGH AND PEOPLE ARE NOT DOING IT. CHEVY DOES NOT SELL JUST THE PLASTIC PART, THEY REQUIRE YOU TO PURCHASE AN ENTIRE ASSEMBLY, THE COST RUNS NEARLY $600 WITH LABOR FOR A PLASTIC PART. THE ISSUE IS THAT DEALERSHIPS DO NOT STOCK THIS PART, THEY NEED TO ORDER IT AND IT TAKES TIME, THIS IS A SAFETY ISSUE AS THE ONLY WAY TO EXIT THE CAR IS TO OPEN THE DOOR FROM THE OUTSIDE, SO THAT REQUIRES ROLLING A WINDOW DOWN AND OPENING IT FROM THE OUTSIDE. IF YOU NEEDED TO EXIT THE VEHICLE IN A HURRY, SUCH AS AFTER AN ACCIDENT, YOU WOULD NOT BE ABLE TO DO SO. THIS IS A GREAT CONCERN. BESIDES THE FACT THAT THIS IS BEING REPORTED AS A PROBLEM AND CHEVY IS NOT TRYING TO RECTIFY THE SITUATION, OR TO EVEN PROVIDE THE PART OUTSIDE OF PURCHASING THE ENTIRE ASSEMBLY. *TR

Mileage: 93,000

DOOR HANDLES IN THIS VEHICLE ARE PLASTIC AND BREAK. THISIS THE 2ND TIME THE SAME DOOR HANDLE HAS BROKEN. THE COST TO REPLACE IS APPR. $300 - $400. IN AN ACCIDENT THE DRIVER WOULD NOT BE ABLE TO EXIT THE VEHICLE. *TR

Mileage: 100,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE PLASTIC DOOR HANDLE BROKE OFF NOVEMBER 2008. THE HANDLE WAS REPLACED AT THAT TIME BUT IT BROKE OFF AGAIN TWO WEEKS LATER. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD LOOK INTO IT. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 30,194.

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE DRIVER SIDE INTERIOR DOOR HANDLE WAS INOPERABLE. WHEN ATTEMPTING TO EXIT THE VEHICLE AND ENGAGING THE DOOR HANDLE, THE DOOR WOULD NOT OPEN. THE VEHICLE WAS INSPECTED AT AN AUTHORIZED DEALER BUT NOT REPAIRED. THE MANUFACTURER ADVISED THE CONTACT THAT THE TECHNICIAN DID NOT LOCATE A MANUFACTURING DEFECT THEREFORE THEY WOULD NOT ASSIST WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 30,600. UPDATED 12/22/10 *BF UPDATED 12/29/10*JB

Mileage: 30,600

WHILE OPENING THE LEFT FRONT DOOR FROM THE INSIDE THE PLASTIC CHROME DOOR HANDLE BROKE OFF IN MY HAND MAKING IT IMPOSSIBLE TO OPEN THE DOOR FROM THE INSIDE. THIS WILL IMPAIR THE ABILITY OF THE OCCUPANTS TO EXIT THE VEHICLE IN THE EVENT OF AN EMERGENCY. *TR

Mileage: 50,000

CHEVY HHR 2006 DRIVERS SIDE INTERIOR DOOR HANDLE BROKE OFF IN HAND DURING NORMAL USE. MADE OF CHEAP PLASTIC. AUTO MAKER STATES THAT THE ONLY WAY TO REPAIR IS TO COMPLETELY REMOVE THE DOOR AND PAY. ALL OF THIS FOR A PIECE OF PLASTIC WHICH SHOULD COST PENNIES TO REPLACE? I SUFFER FROM NECK PAIN AND HAVE TROUBLE ROLLING THE WINDOW DOWN TO REACH OUT AND OPEN THE DOOR. THEY HAVE TO FIX THIS AT THEIR COST. THIS IS OBVIOUSLY NO FAULT OF THE OWNERS AND ONLY DUE TO FAULTY (PLASTIC) EQUIPMENT THEY ARE USING. *TR

Mileage: 56,000

MY HHR DRIVER'S INTERIOR HANDLE BROKE OFF A FEW WEEKS AGO. I FEEL THAT GM NEEDS TO RECALL 2006 HHR CARS AND REPLACE THE DOOR HANDLE. I DO NOT HAVE $400.00 TO GIVE THE DEALERSHIP. A MONTH AGO I JUST PAID FOR KEY IGNITION SWITCH TO BE FIXED FOR $400.00. *TR

Mileage: 89,000

AS FILED BY MANY OTHER OWNERS OF A CHEVY HHR, SOMETHING NEEDS TO BE DONE ABOUT THE INSIDE DOOR HANDLES. THEY ARE MADE OF CHEAP PLASTIC AND MINE BROKE AS WELL. I CAN'T BELIEVE A US COMPANY SUCH AS GM WOULD MAKE A CHEAP PART THAT COULD END UP ENDANGERING THE LIVES OF ITS CUSTOMERS. IF YOU WERE TO GET IN AN ACCIDENT OR NEED TO EXIT THE CAR IN ANY EMERGENCY SITUATION, THIS COULD COST YOUR LIFE. GM NEEDS TO RECALL THESE CARS AND DO THE RIGHT THING. REPLACE THEM WITH A MORE DURABLE HANDLE AS SOON AS POSSIBLE. OR WILL THEY WAIT UNTIL SOMETHING HAPPENS BEFORE THEY TAKE ACTION? *TR

Mileage: 26,000

THE INTERIOR DOOR HANDLE OF MY 2006 CHEVROLET HHR BROKE OFF DURING NORMAL USE. IT'S MADE FROM A CHEAP PLASTIC. THIS IS A SERIOUS SAFETY HAZARD AS A PERSON CANNOT QUICKLY EXIT THE CAR IF THIS HAPPENS. IF MY DRIVER'S SIDE DOOR JUST BROKE, HOW SOON BEFORE THE OTHER THREE IN THE CAR BREAK OFF FROM NORMAL OPERATION. THIS IS A MANUFACTURING DEFECT AND SHOULD BE TAKEN CARE OF FROM THE MANUFACTURER. THE DEALER WANTS ME TO PAY $400-$450 TO REPLACE A $10 PLASTIC DOOR HANDLE THAT THEY POORLY DESIGNED. THIS SHOULD BE A RECALL FROM GM TO REPLACE THESE CHEAP HANDLES BEFORE SOMEONE DOES HAVE A SERIOUS SITUATION. *TR

Mileage: 72,500

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE ATTEMPTING TO OPEN THE DRIVER SIDE DOOR FROM THE INSIDE THE CONTACT NOTICED THAT THE DOOR HANDLE BROKE OFF IN HER HAND. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE HANDLE NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 49000. UPDATED 09/24/10. *LJ THE CONSUMER STATED THE HANDLE CAN NOT BE REPLACED WITHOUT THE ENTIRE INSIDE DOOR PANEL BEING REPLACED. UPDATED 09/24/10

Mileage: 49,000

INTERIOR DOOR HANDLE BROKEN. DOOR MUST BE OPENED USING OUTSIDE HANDLE. HANDLE IS PLASTIC. ENTIRE INTERIOR DOOR PANEL MUST BE REPLACED. PART COSTS $400.00 PLUS LABOR - REPLACEMENT HANDLE IS PLASTIC ALSO. CAR IS 2006 CHEVROLET HHR WITH 53,000 MILES. *TR

Mileage: 53,000

2006 HHR LS - DRIVER'S SIDE DOOR HANDLE BROKE OFF WITH NORMAL OPENING OF THE DOOR. COULD NOT GET OUT OF THE CAR WITHOUT PUTTING WINDOW DOWN AND USING THE OUTSIDE HANDLE. IF THIS WAS AN EMERGENCY - I WOULD HAVE BEEN STUCK IN THE CAR. *TR POWER STEERING FAILURE - POWER STEERING QUITS WHILE DRIVING - WAS GOING 55 MPH. AND THE POWER STEERING JUST WENT OFF.. PULLED TO THE SIDE WITH DIFFICULTY - SHUT THE CAR OFF. RESTARTED CAR - AND THE POWER STEERING WAS WORKING AGAIN. VERY DANGEROUS SITUATION.

Mileage: 72,000

2006 CHEVY HHR . THE DRIVERS SIDE DOOR INTERIOR DOOR HANDLE SNAPPED OFF IN MY HAND WHEN I TRIED TO OPEN THE DOOR, SMACKING INTO MY KNUCKLE AND ALMOST CAUSING MY HAND TO FLY BACK INTO MY FACE. THE DOOR MUST NOW BE OPENED BY ROLLING DOWN THE ELECTRIC WINDOW AND OPENING FROM THE OUTSIDE HANDLE. TWO DEALERS SO FAR REFUSE TO FIX THE ISSUE, TELLING ME THEY DON'T HAVE PARTS. *TR

Mileage: 45,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE ATTEMPTING TO OPEN THE DRIVERS DOOR, THE HANDLE WOULD NOT WORK AND THE DOOR WOULD NOT OPEN. THE VEHICLE WAS TAKEN TO THE DEALER FOR FURTHER INSPECTION. THE FAILURE AND CURRENT MILEAGES WERE 56,000.

Mileage: 56,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE EXITING THE VEHICLE, THE CONTACT NOTICED THAT THE INSIDE DRIVER DOOR HANDLE WAS BROKEN. THE DEALER ADVISED HIM THAT HE WOULD HAVE TO PAY OUT OF POCKET FOR THE REPAIRS. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE CURRENT MILEAGE WAS APPROXIMATELY 37,300. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.

Mileage: 37,000

IF MY BATTERY DIES I CAN NOT GET IN THE CAR NO MATTER WHAT. MY CAR IS EQUIPPED WITH ONE LOCK ON THE DRIVER SIDE. BECAUSE THE BATTERY IS DEAD THE CAR WILL NOT ENGAGE THE ACTUATOR ON THE LOCK EVEN WITH KEY ENTRY. I HAVE TO CALL A LOCKSMITH TO GET IN THE CAR. IF I ACCIDENTALLY LOCKED A BABY IN THE CAR AND THE BATTERY WAS NOT WORKING I CANNOT GET IN THE CAR. KEY, REMOTE WHATEVER. I HAVE TO CALL A LOCKSMITH. IN MY CASE THE ACTUATOR STOPPED WORKING. SO REGARDLESS IF I HAVE A KEY OR REMOTE I CANNOT GET IN. IF THIS ACTUATOR FAILS ON THE DRIVERSIDE I CANNOT GET IN, BUT MY BABY MAY BEEN THE CAR. *TR

Mileage: 65,000

IGNITION KEY DOES NOT COME OUT OF THE STEERING COLUMN IT IS STUCK IN THE IGNITION ,CAR STARTS AND SHUTS OFF BUT THE KEY CANNOT BE REMOVED. *TR

Mileage: 44,351

KEY GETS STUCK / CAN NOT TURN TO OFF POSITION AND REMOVE THE KEY. IF YOU CAN NOT REMOVE THE KEY WITHIN AN HOUR, YOUR BATTERY WILL BE DEPLETED. THERE IS AN ACTUATING ROD IN THE SHIFTER THAT PUSHES A MICRO SWITCH THAT COMPLETES A CIRCUIT TO PULL A SOLENOID IN THE STEERING COLUMN TO ALLOW THE IGNITION SWITCH TO BE TUNED TO THE OFF POSITION (AND REMOVE THE KEY) WHEN IN PARK. THE PLASTIC PART IN THE SHIFTER ASSEMBLY BREAKS AND ALLOWS THE ACTUATING ROD TO FALL OUT. THE FIX FOR THIS IS TO REPLACE THE SHIFTER ASSEMBLY. $185 NOT INCLUDING LABOR. THE QUICK FIX FOR THIS IS THERE IS A PLASTIC PLUG ON THE UNDER SIDE OF THE STEERING COLUMN. INSIDE YOU HAVE TO FEEL FOR THE END OF THAT SOLENOID AND DEPRESS IT TO RELEASE THE KEY. GM TSB #06-07-30-004F ACKNOWLEDGES THE COMMON OCCURRENCE OF THIS FAILURE FROM 2006 TO 2010 HHR, COBALT, AND PONTIAC G5 . ALTHOUGH, IF YOU ARE OUT OF WARRANTY, YOUR DEALER MAY BE RELUCTANT TO FIX THIS PROBLEM WITHOUT COST. TIRES, BALL JOINTS, BRAKES, WHAT HAVE YOU, FAIL AND ARE, NO DOUBT, A COMMON OCCURRENCE. IF FACT THAT IS TO BE EXPECTED. BUT THE SHIFTER IN AN AUTOMATIC? I WOULD THINK THAT THE SHIFTER IN AN AUTOMATIC SHOULD LAST THE LIFETIME OF THE CAR. IMO, THEY INSTALLED A POORLY MADE PART. TO ME, THIS IS OBVIOUS SINCE THEY ARE STATING IN THAT TSB, 2006 - 2010 SHIFTER ARE EXPECTED TO FALL APART AS MINE DID. I HAVE A 1965 PLYMOUTH BELVEDERE, THE OLDEST CAR IN MY POSSESSION, THAT THE SHIFTER NEVER NEEDED TO BE REPAIRED. IN FACT I'VE NEVER HAD AN AUTOMATIC SHIFTER PROBLEM WITH ANY CAR. IT WAS STATED IN A FORUM THAT GM SHOULD HAVE CONSIDERED A METAL COLLAR OR RING AROUND THE PLASTIC BIT THAT HOLDS THAT PIN TO REINFORCE IT AND THIS PROBLEM WOULD HAVE NEVER BECOME A NUISANCE. ALSO, WHEN THAT PIN FALLS OUT, THE SHIFT LEVER IS FREE TO MOVE WITHOUT PRESSING THE SHIFT BUTTON ON THE FRONT OF THE SHIFT LEVER, SO IT COULD ACCIDENTALLY BE MOVED TO ANOTHER GEAR WHILE DRIVING, EVEN REVERSE!! I GUESS THAT IS NOT ENOUGH OF A SAFETY ISSUE FOR GM TO WORRY ABOUT. *TR

Mileage: 69,000

THE KEY TO MY 2006 HHR WOULD NOT COME OUT OF THE IGNITION. AS A RESULT THE AUTOMATIC HEADLIGHTS WOULD NOT GO OUT AND THE VEHICLE COULD NOT BE LOCKED. THIS HAPPENED WHILE I WAS TRAVELING, WHICH PUT MY PERSONAL SAFETY AT RISK AND IF I LEFT MY VEHICLE FOR ANY REASON IT COULD HAVE EASILY BEEN STOLEN. I HAVE BEEN ONLINE AND FOUND THAT SEVERAL OTHER OWNERS HAVE EXPERIENCED THIS PROBLEM. *TR

Mileage: 40,000

THE KEY FOB BATTERY HOLDER BECAME DETACHED MAKING IT IMPOSSIBLE FOR THE LOCK/UNLOCK/REMOTE START/PANIC BUTTONS TO WORK. THIS HAPPENED TO BOTH KEY FOBS ISSUED TO ME BY GM. *TR

Mileage: 30,000

DRIVERS SIDE DOOR HANDLE BROKE OFF WHEN GETTING OUT OF VEHICLE. DEALER WILL NOT REPAIR UNLESS I PAY FOR THE REPAIR. THIS IS A SAFETY HAZARD BECAUSE YOU CANNOT EXIT THE VEHICLE UNLESS YOU LET THE WINDOW DOWN. *TR

FRONT PASSENGER DOOR ON 2006 CHEVROLET HHR WILL NOT OPEN FROM INSIDE OR OUTSIDE. FRONT DRIVERS SIDE DOOR DOES SAME SPORADICALLY. NO DAMAGE TO DOORS FROM PHYSICAL DAMAGE, THEY JUST STOPPED WORKING. *TR

Mileage: 50,959

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE DRIVER-SIDE DOOR CAN ONLY BE OPENED FROM THE OUTSIDE. A TECHNICIAN FROM THE DEALER STATED THAT THEY WOULD HAVE TO REPLACE THE ENTIRE DOOR PANEL AT AN EXPENSE OF $600.00. BASED UPON THE CONCLUSION OF THE MANUFACTURERS RESEARCH THEY MAY OFFER HER A DISCOUNT ON THE REPAIRS. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHEN EXITING THE VEHICLE THE DRIVERS SIDE DOOR HANDLE BROKE OFF. HE HAD TO ROLL THE WINDOW TO OPEN THE DOOR. THE CONTACT IS IN THE PROCESS OF TAKING THE VEHICLE TO THE DEALER FOR FURTHER INSPECTION AND NOTIFYING THE MANUFACTURER. THE FAILURE MILEAGE WAS 34,200 AND THE CURRENT MILEAGE WAS 34,210.

Mileage: 34,200

2006 CHEVROLET HHR - DOOR HANDLE BROKE NOT ALLOWING ME TO EXIT VEHICLE. *TR

Mileage: 52,239

2006 CHEVROLET HHR INSIDE DRIVER'S DOOR HANDLE BROKE OFF. *NJ THE CONSUMER WAS INFORMED HE COULD NOT PURCHASE JUST THE DOOR HANDLE, BUT HE WOULD HAVE TO PURCHASE THE ENTIRE DOOR PANEL. THE CONSUMER STATED THE DOOR HANDLE WAS MADE OF PLASTIC. *JB

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE INTERIOR DOOR HANDLE FAILED ON THE FRONT PASSENGER SIDE. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE ENTIRE DOOR PANEL NEEDED TO BE REPLACED AT THE COST OF $413. THE PART NUMBER FOR THE REPAIR WAS 15787576. THE CONTACT DOES NOT WANT TO PAY FOR THE REPLACEMENT. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS FOR THIS ISSUE. THE FAILURE MILEAGE WAS 78,000.

Mileage: 78,000

CONSUMER WANTS TO KNOW IF THERE IS A RECALL ON THE FRONT BUMPER OF HER 2006 CHEVROLET HHR. *NJ THE CONSUMER STATED THERE WAS A PROBLEM WITH THE GEAR SHIFT AND THE DOOR LATCHES BEGAN TO MOVE UP AND DOWN. ALSO, THE VEHICLE STARTED ACTING ERRATIC WHILE DRIVING. UPDATED 09/13/10

2006 CHEVROLET HHR. CONSUMER IS REQUESTING A REFUND FOR THE CONSOLE LATCH THAT WAS REPLACED PRIOR TO THE RECALL. *NJ

INTERIOR DOOR HANDLE BROKEN. DOOR MUST BE OPENED USING OUTSIDE HANDLE. HANDLE IS PLASTIC. ENTIRE INTERIOR DOOR PANEL MUST BE REPLACED. PART COSTS $325.00 PLUS LABOR. CAR IS 2 1/2 YEARS OLD WITH LESS THAN 47,000 MILES. *TR

Mileage: 46,500

INITIALLY, I HAD INTERMITTENT PROBLEMS WITH MY 2006 CHEVY HHR. THE KEY SWITCH WOULDN'T TURN ALL THE WAY OFF TO RELEASE THE KEY. I TOOK IT TO THE DEALERSHIP WHILE IT WAS UNDER WARRANTY, AND THEY INFORMED ME THAT THEY "COULDN'T MAKE IT DO IT" (FOR WHICH THEY HAVE A RECORD). AFTER ABOUT A YEAR-AND-A HALF OF THIS INTERMITTENT PROBLEM, MY KEY WOULD NOT COME OUT OF THE IGNITION AT ALL. I WAS OUT OF TOWN, STAYING AT A HOTEL AND HAD TO LEAVE THE KEY IN THE IGNITION OVERNIGHT. I READ MY OWNERS MANUAL AND FOUND THE HIDDEN RELEASE BUTTON IN THE STEERING COLUMN. I TOOK IT BACK TO THE DEALERSHIP, AND BECAUSE I AM OUT OF WARRANTY, I HAVE TO PAY FOR THIS REPAIR THAT IS DUE TO POOR CRAFTSMANSHIP. AFTER RESEARCHING THIS TO SEE IF WAS RECALLED, I HAVE UNCOVERED NUMEROUS CHEVROLET HHR OWNERS THAT HAVE EXPERIENCED THE SAME PROBLEM, AND IT IS A FAULTY SHIFT LINKAGE. THIS ITEM NEEDS TO BE ON THE RECALL LIST. *TR

Mileage: 26,000

I NEED YOUR HELP, 1ST,COMPUTER BROKE,THEN 2ND GEAR SHIFT, THEN 3RD SUNROOF, THEN 4TH BACK DOOR WON'T OPEN-SON CAN'T GET OUT, THEN 5TH POWER STEERING, TRIED TO REPLACE POWER STEERING WITH A USED ONE THAT WE COULD AFFORD,, NOW CAR IS LOCKED AND WON'T CRANK, DID WHAT MECHANIC SAID TO REPROGRAM AND IT STILL DOESN'T WORK, GM REPLACED 1ST COMPUTER, I PAID FOR GEARS , TRIED TO GET GM TO FIX ELECTRIC STEERING, SAID THEY WOULD BUY PARTS BUT NOT LABOR >1000, RIGHT BEFORE WE TRIED TO REPLACE THE POWER STEERING THE CRANK STARTED HANGING, 06 CHEVROLET HHR-NO CAR, HELP, ITS SO BROKE, HURT MYSELF TRYING TO DRIVE IT, AND HAVE BEEN TRYING TO GET FIXED FOR OVER 2 MONTHS, ITS A BOMB, NOW I HAVE NO CAR TO DRIVE. GM STATES ITS OVER MILEAGE, THOUGHT I BOUGHT ALL WARRANTIES, DEALER WENT OUT OF BUSINESS, PALM BAY CHEVROLET, FL, I NEED SOME HELP, MULTIPLE TIMES HAVE ALL BUT CRASHED RELATED TO CAN'T HARDLY STEER IT, TURN IT, I THINK I'VE BROKE MY SHOULDER WITH THIS THING. NOW I CATCH A RIDE WITH 4 YEARS TO PAY LEFT ON THIS CAR, HELP! ITS A HAZARD, I DON'T HAVE GOLIATHS STRENGTH ANY MORE! *TR

Mileage: 60,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 20 MPH OVER A HOLE OR DIP IN THE ROAD, THE ENTIRE VEHICLE STALLED AND SHUT OFF. THE WEATHER WAS NOT A FACTOR. THE STALLING OCCURRED AT LEAST THREE TIMES WITHIN ONE WEEK. THE VEHICLE CANNOT BE RESTARTED ONCE IT SHUT OFF. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE DEALER DOES NOT KNOW THE CAUSE OF THE FAILURE OR THE REMEDY. THE FAILURE MILEAGE WAS 53,000. THE CONSUMER STATED THE VEHICLE WAS HAVING SEVERAL ISSUES WITH THE CAM SENSOR, WHEELS, A BROKEN HUB BEARING, BENT ROTORS AND AN ISSUE WITH REMOVING THE KEY FROM THE IGNITION, DUE TO THE SHIFT CABLE NOT STAYING SECURED. THE CHECK ENGINE LIGHT ILLUMINATED, THE INSIDE DRIVER DOOR HANDLE WOULD NOT OPEN THE DOOR, THE PASSENGER SIDE BACK WOULD NOT STAY SECURED. UPDATED 06/25/08

Mileage: 30,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. UPON READING THE OWNER'S MANUAL, THE CONTACT DISCOVERED THAT THERE WAS NO TRUNK RELEASE LATCH IN HIS VEHICLE. THE DEALER STATED THAT THE DEVICE WAS THERE, BUT IT COULD ONLY BE OPENED BY THE MECHANIC. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 64,000. UPDATED 03-04-08 *BF

I HAVE HAD SEVERAL ISSUES WITH MY HHR SINCE PURCHASED IN SEPTEMBER 2005. FIRST INCIDENT WAS THE LOCK ON THE HATCH BROKE AFTER ONLY OWNING THE CAR FOR A FEW MONTHS. NEXT WAS WITH THE BRAKES. AT FIRST I NOTICED A NOISE WHEN I APPLIED MY BRAKES IT SOUNDED LIKE SOMETHING WAS LOOSE. THIS NOSE WOULD COME AND GO. AFTER A FEW MONTHS I STARTED TO NOTICE A SLIGHT VIBRATION IN MY STEERING WHEEL WHEN BRAKING A FEW DAYS LATER THAT VIBRATION TURNED TO VIOLENT SHAKING AND RESISTANCE WHEN BRAKING. I TOOK IT TO THE DEALER WHO INFORMED ME THE ROTORS WERE WARPED AND NEEDED TO BE REPAIRED. THIS WAS ROUGHLY AROUND 13000 MI. THE DEALER DID REPAIR THE ROTORS UNDER WARRANTY AND DIDN'T GIVE ME THE "IT'S NORMAL WEAR & TEAR" MUMBO. NEXT IS THE CHECK ENGINE LIGHT KEEPS COMING ON. IT WILL STAY ON FOR A FEW DAYS AND THEN GO OFF. THIS HAS HAPPENED 3 TIMES ALREADY AND THE DEALER HAS REPLACED THE SENSOR EACH TIME. NOW WE ARE UP TO THE 4TH TIME AS IT CAME BACK ON AGAIN YESTERDAY. I HAVE ALSO HAD ISSUES WITH THE RADIO. THE RADIO HAS HAD POWER TO IT AND NO VOLUME. THIS HAPPENED 3-4 TIMES B/4 I TOOK IT TO THE DEALER WHO HAD TO RESET & REPROGRAM SOMETHING ON THE RADIO. *TR

Mileage: 13,000

DOOR AJAR WARNING DOES NOT SHOW UNTIL DOOR IS MORE THAN 3 INCHES OPEN. THIS IS ON ALL DOORS EXCEPT THE BACK HATCH. THE DOOR AJAR WARNING SHOULD COME ON ANYTIME THE DOOR IS NOT COMPLETELY CLOSED. SAFETY HAZARD. *NM

Mileage: 1

DOOR AJAR WARNING INADEQUATE, WHEN DOOR IS A COUPLE OF INCHES OPEN WARNING INSTITUTES, RATHER THAN WHEN DOOR IS ON FIRST SAFETY LATCH AS IT SHOULD BE WHEN AJAR, WHEN DOOR IS OPEN PRIOR TO LATCH DOOR IS OPEN NOT AJAR!SAFETY CONCERN! *NM