2006 CHEVROLET HHR Power Train Problems

The contact owns a 2006 Chevrolet HHR. The contact stated that while driving at various speeds, the vehicle lost motive power and would not properly accelerate. Additionally, the front passenger’s side door would not open while using the interior door latch. The contact stated while using the cigarette lighter, the vehicle shut off, and smoke filled the cabin of the vehicle. The cause of the failure was not yet determined. The local dealer and manufacturer were not contacted. The failure mileage was 92,000.

Mileage: 92,000

THE SHIFT LEVER SHOWS THE VEHICLE IN PARK BUT THE ACTUAL GEAR IS REVERSE BECAUSE THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP HAS BECOME DISLODGED FROM ITS POSITION AND WILL NOT ENGAGE TO THE PROPER GEAR. AS A RESULT THE VEHICLE WILL NOT START AND IT WILL ALSO ROLL BACKWARDS WITHOUT ENGAGING THE PARKING BRAKE. IT WAS STATIONARY WHEN I WAS ATTEMPTING TO PARK IT BUT IT THEN ROLLED BACKWARDS DOWN A HILL BECAUSE IT WAS NOT ENGAGING IN PARK AND ALMOST HIT ANOTHER VEHICLE BEFORE I COULD APPLY THE PARKING BRAKE. THIS ISSUE IS THE SAME ISSUE THAT IS PART OF A RECALL 09V073000 FOR MY SPECIFIC VEHICLE; HOWEVER IT DOESN'T INCLUDE MY YEAR OR VIN SO THE DEALERS ARE NOT TRYING TO REPAIR IT FOR ME WITHOUT COST.

MY AIR BAG SERVICE LIGHT COMES ON AND MY POWER STEERING DONT WORK WHILE THIS AIR BAG SERVICE LIGHT IS ON. MY HEAT DONT WORK EITHER WHILE MY AIR BAG SERVICE LIGHT IS ON. I CAN DRIVE IT FOR AWHILE AND WHEN MY AIR BAG LIGHT GOES OFF MY POWER STEERING STARTS TO WORK AND MY HEAT DOES TOO.

Mileage: 193,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT INDICATED THAT THERE HAD BEEN NO FAILURES WITH THE VEHICLE UNTIL THE MANUFACTURER HAD THE DEALER COMPLETE A MANUFACTURER RECALL REPAIR FOR THE IGNITION SWITCH. THE REPAIR CAUSED SEVERAL FAILURES AND DID NOT PROVIDE A PERMANENT REPAIR SOLUTION. WITHIN WEEKS OF THE DEALER'S REPAIR, THE KEY WAS DIFFICULT TO REMOVE FROM THE IGNITION SWITCH AND THE CONTACT HAD TO CONSTANTLY MANEUVER THE GEAR SHIFT, WHICH HAD ALSO BEEN AN ISSUE. IN ADDITION, THE SPEEDOMETER FAILED TO PROVIDE A READING AND THE INSTRUMENT CLUSTER GAUGES FAILED TO FULLY FUNCTION AFTER THE REPAIR. THE CONTACT WAS UNABLE TO DETERMINE WHAT THE SOLUTION WOULD BE TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 147,000.

Mileage: 147,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE VEHICLE JERKED WHENEVER THE CONTACT SHIFTED GEARS. THE FAILURE OCCURRED WHETHER THE VEHICLE WERE IN DRIVE, NEUTRAL, OR REVERSE. THE CONTACT RECEIVED A NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM). THE CONTACT ADHERED TO THE RECALL; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 181,732.

Mileage: 181,732

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 7 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE CONTACT MENTIONED THAT THE VEHICLE JERKED FORWARD AND STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 169,350.

Mileage: 169,350

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE STALLED AND WAS NOT ABLE TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER WHO REPROGRAMMED THE COMPUTER, PROVIDED THE CONTACT WITH A NEW SET OF KEYS, AND REPAIRED THE VEHICLE ACCORDING TO NHTSA CAMPAIGN NUMBER: 14E021000 (ELECTRICAL SYSTEM). THE FAILURE RECURRED AND THE KEY REMAINED STUCK IN THE IGNITION. THE VEHICLE ALSO FAILED TO SHIFT OUT OF PARK, THE STEERING WHEEL WAS DIFFICULT TO MANEUVER, AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MOTOR, THE GEAR BOX, AND SHIFTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Mileage: 160,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEAR SHIFT FAILED TO LOCK IN THE PARK POSITION. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE GEAR SHIFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 144,000.

Mileage: 144,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. AFTER THE CONTACT RETURNED TO THE VEHICLE SHORTLY AFTER IT HAD BEEN PARKED, SHE FOUND IT HAD ROLLED AWAY THREE HOUSES DOWNHILL. THE VEHICLE HAD DRIVEN OVER A CURB, SIDESWIPED A TREE, AND CRASHED INTO CINDER BLOCKS. THE VEHICLE WAS TOWED TO THE DEALER AND REPAIRED. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 115,000. UPDATED 8/28/14*CN THE CONSUMER STATED THE DEALER ADVISED THAT THE COVER INTERLOCK WAS REMOVED. THE SHIFTER DID NOT LOCK INTO GEAR. THE LOCK WAS MISSING. THE CONSUMER WAS NOT GIVEN ANY PAPERWORK TO EXPLAIN THE ISSUES. THE CONSUMER WAS ADVISED BY MULTIPLE MECHANICS THE VEHICLE WOULD NOT DRIVE WITH THESE DEFECTS. UPDATED 11/25/2014 *JS

Mileage: 115,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE KEY SEIZED IN THE IGNITION AND THE VEHICLE FAILED TO SHIFT TO PARK. THE VEHICLE WAS TAKEN TO THE DEALER AND THE IGNITION SWITCH CYLINDER WAS REPLACED ALONG WITH THE BATTERY. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 132,441.

Mileage: 132,441

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEARS WERE ABLE TO BE CHANGED WITHOUT USING THE BUTTON. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 67,144.

Mileage: 67,144

GOOD DAY. I'LL KEEP THIS BRIEF. TO BE CLEAR, I WENT TO THE DEALER (AUTONATION USA) WITH THE RECALL ISSUE SHORTLY AFTER IT OCCURRED THE FIRST TIME, AND A COUPLE OF OTHER TIMES AFTER THAT. I WAS TOLD THAT I WAS TOO SHORT, FAT, AND MY KNEE WAS KNOCKING THE KEY OUT OF THE IGNITION. MY KEY NEVER FELL OUT OF THE IGNITION, BUT THE CAR DID SHUT OFF, LOSING CONTROL OF ALL ELECTRICAL SYSTEMS WHILE AT 70+ MPH. SECONDLY, I HAVE GONE IN TO THE DEALER FOR MY TRANSMISSION AS WELL. THE CAR BEGAN TO SLIGHTLY JERK AT AROUND 60K MILES. I WAS TOLD THEY DIDN'T NOTICE ANYTHING, HOWEVER, THEY NEVER CHECKED THE TRANSMISSION, AND I WAS TOLD THEY COULD DO NOTHING. WHEN THE MATTER GOT REALLY BAD, THE MILEAGE WAS OVER 100K, AND OUT OF WARRANTY. I HAVE BROUGHT IT TO THEIR ATTENTION THAT I ATTEMPTED TO CLEAR THIS UP PRIOR, AND WAS TOLD THEY WOULD HAVE TO TREAT IT AS A NEW ISSUE. I'LL MAKE IT EASY. WHEN I HAVE HAD THE IGNITION ISSUES NEARLY KILL MY FAMILY AND MYSELF ON MORE THAN 30 OCCURRENCES, THE DEALER FIXING A SMALL, INEXPENSIVE ITEM, BECAUSE THEY HAVE BEEN EXPOSED, DOES LITTLE TO QUELL THE ANGER I HAVE REGARDING THE VARIOUS OTHER ISSUES I HAVE REGARDING WARRANTY MAINTENANCE THEY COULD HAVE COMPLETED WHILE UNDER WARRANTY, AND INSTEAD CHOSE TO BELITTLE ME AND NOW WISH TO CHARGE ME OBSCENE AMOUNTS OF MONEY TO REPAIR. GM SHOULD OFFER TO COMPLETE THE MAINTENANCE AT NO COST CONSIDERING I HAVE GONE TO THEM PRIOR TO THE CLOSE OF THE WARRANTY AND WAS RIDICULED AND FURTHER, MADE TO HAVE MY FAMILY'S LIFE IN DANGER 30-40 TIMES SO THEY COULD SAVE SOME MONEY. FURTHER, I UNDERSTAND IT IS NOT LEGALLY REQUIRED FOR THEM TO DO ANYTHING, HOWEVER, DOING THE RIGHT THING GOES A LONG WAY. I HAVE SPOKEN TO GM ABOUT THE ISSUES A COUPLE OF TIMES NOW ONLY JUST SIMPLY BE TOLD THEY WERE SORRY AND I SHOULD HAVE THE SITUATION DIAGNOSED (NEEDLESSLY). THIS IS THE FIRST I'VE HEARD OF THIS WEBSITE SO I'M TRYING NOW. THANKS. *TR

Mileage: 15,000

2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE. *SMD THE CONSUMER STATED THE STEERING WHEEL AND FRONT END WERE SHAKING, AND THERE WAS A NOISE COMING FROM THE VEHICLE. THE TECHNICIAN FOUND A WORN OUT BEARING, THE STEERING SHAFT HAD AN INTERNAL FAILURE AND THE SWAY BAR LINKS WERE WORN. THE STEERING COLUMN, INTERMEDIATE SHAFT AND SWAY BAR LINKS WERE REPLACED. ALSO, IT WAS DIFFICULT TO SHIFT OUT OF PARK AT TIMES. IT WAS DETERMINED A LIQUID HAD BEEN SPILLED IN THE SHIFTER. ALSO, THE CONSUMER WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. *JB

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEAR LEVER FAILED TO SHIFT FROM PARK OR INTO ANY GEAR UNTIL AFTER NUMEROUS ATTEMPTS. ADDITIONALLY, THE VEHICLE WOULD JERK AND SURGE ONCE THE GEAR SHIFT WAS MOVED OUT OF THE PARK POSITION. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

Mileage: 97,000

RIGHT FRONT DRIVE SHAFT FAILED WHILE STOPPED AT A RED LIGHT. VEHICLE UNABLE TO MOVE. VERY DANGEROUS !!! *TR

Mileage: 43,163

LEFT FRONT DRIVE SHAFT FAILED WHILE PARKED IN MY GARAGE. CAR WOULD NOT MOVE,HAD TO BE TOWED TO DEALER FOR WARRANTY REPAIR. THIS IS THE FIRST OF TWO DRIVE SHAFT FAILURES ON THIS HHR. *TR ATTENTION !!! PLEASE PAY ATTENTION TO THIS VERY DANGEROUS ISSUE !!!

Mileage: 33,568

CAN SHIFT WITH OUT PUSHING BRAKE OR SHIFT BOTTOM, ALSO KEY GET STUCK IN ON POSITION WHEN IN PARK. HAVE NOT FIXED IT YET DUE TO THE COST OF THE PARK AND LABOR. HAVE LOOKED ON LINE AND A LOT OF OTHER HHR OWNERS ARE HAVING THE SAME PROBLEM. ALSO BRAKE FLUID WARRING COME ON BUT FLUID IS FULL. *TR

Mileage: 117,130

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEAR SHIFTER COULD NOT BE ENGAGED INTO ANY GEAR. THE VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE GEAR SHIFTER. ADDITIONALLY, THE CONTACT STATED THAT THE FRONT TIRES WERE WEARING PREMATURELY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FRONT END WAS REBUILT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,000.

Mileage: 32,000

GEAR SHIFTER PIN BROKE & NOW WON'T LOCK IN GEAR. THE KEY CANNOT BE REMOVED EXCEPT BY REMOVING A CAP ON THE STEERING COLUMN & PRESSING A RELEASE BUTTON. DEFECTIVE GEAR SHIFTER PIN. ------------------------------------- I WENT HOME & TRIED TO TAKE MY KEY OUT BUT IT WOULD NOT RELEASE SO SINCE THE CAR WOULD NOT TURN COMPLETELY OFF THE BATTERY DIED. I FOUND OUT ON THE INTERNET THAT THIS HAS HAPPENED TO THOUSANDS OF PEOPLE. I FOUND OUT HOW TO REMOVE THE PLUG ON THE STEERING COLUMN TO PRESS THE RELEASE TO TAKE OUT THE KEY. THE GEAR SHIFTER WILL NOT LOCK SO IT IS EASY FOR IT TO SLIP INTO NEUTRAL OR OUT OF PARK & ROLL AWAY. I DON'T HAVE THE $500 THEY SAID IT WILL TAKE TO FIX IT SO I HAVE TO LIVE WITH IT. I ALWAYS HAVE TO MAKE SURE TO LOCK MY EMERGENCY BRAKE & HAVE TO HIT THE RELEASE TO TAKE MY KEY OUT. THIS IS DANGEROUS & SO WRONG OF GM NOT TO RECALL THIS WHEN SO MANY HAVE HAD THIS PROBLEM. THIS IS THEIR DEFECT & NOT THE CUSTOMERS. *TR

Mileage: 89,000

KEY GOT STUCK IN IGNITION. THIS APPARENTLY IS A COMMON KNOWN ISSUE WITH THIS VEHICLE. THEY DID A RECALL BUT ONLY ON THE 2009 MODELS. THE GEAR SHIFT ASSEMBLY GOES BAD AND THERE IS A PLASTIC PIECE THAT BREAKS CAUSING THE KEY TO GET STUCK. I HAD TO GO INTO THE STEERING COLUMN TO MANUALLY RELEASE THE KEY. THE GEAR SHIFT ALSO WILL GO INTO ANY POSITION WITHOUT HAVING TO PRESS THE BUTTON, WHICH IS A HUGE SAFETY ISSUE SINCE IT CAN BE PUT INTO REVERSE WHILE DRIVING, ETC. TRIED TO TAKE IT IN TO GET FIXED BUT WILL COST ABOUT $300. THIS SHOULD HAVE BEEN A RECALL SINCE IT HAS BEEN AN ISSUE WITH ALL THE EARLY HHR MODELS, NOT JUST THE 2009.

Mileage: 123,500

I HAVE A 2006 CHEVY HHR, I LOVE IT BUT, IT HAS ISSUES 1ST I BOUGHT IT USED 15,000 MILES. SINCE THEN I HAVE HAD 1. THE REAR LOGO REPLACED 4 TIMES, THEN, 2.THE KEY GET STUCK WHEN I TURN OFF THE CAR SO I USED THE PLUNGER AND 3. THE GEAR SHIFT MOVES WHEN THE CAR IS OFF OR ON. NOW, 4. THE KEY WON'T TURN TO START THE CAR I HAVE TO JIGGLE IT TILL IT WORKS. 5. MY POWER STEERING GOES OUT RANDOMLY, WHILE DRIVING IT SO I CAN'T TURN THE 6.-,7.-, AND 8.3 RECALLS, THEN, 9. THE WHEELS SHAKES AT 60 MPH, I HAVE 10. AND 11. REPLACED BOTH FRONT DOOR HANDLES WITH IN 2 WEEKS 12. I HEAR A LOUD CRACKLING OR STATIC SOUND FROM MY SPEAKERS AND THE RADIO IS OFF. OH AND 13. MY CHECK ENGINE LIGHT WON'T GO OFF PLUS 14. EVERY TIME I HAVE TO CHANGE THE BATTERY I HAVE TO GET MY REMOTE REPROGRAMMED FOR THE AUTO START... IT CAME WITH THE CAR. WHAT IS GOING ON? THERE ARE 14 ISSUES SOME SAFETY AND SOME COSMETIC BUT, CLEARLY AN ISSUE I AM ONLY MAKING MY VOICE HEARD BECAUSE I JUST STARTED RESEARCHING MY CAR. I AM A SINGLE MOTHER I CAN'T AFFORD TO FIX THE MAJOR IGNITION OR GEAR SHIFT, TRANSMISSION AND ELECTRICAL CAR SHAKING THESE HAVE BEEN REPORTED IN A LOT OF HHRS. PLEASE HELP. *TR

Mileage: 30,000

WHEN STARTING FROM A STOPPED POSITION IN A SIGNAL CONTROLLED LEFT TURN LANE, THE CLUTCH WAS DEPRESSED AS USUAL. THIS TIME IT MADE A POPPING NOISE AND THE PEDAL WENT TO THE FLOOR, RENDERING THE CAR INOPERABLE. THE DRIVER WAS LEFT STRANDED IN THE MIDDLE OF A ROADWAY. FORTUNATELY, THIS HAPPENED IN A LIGHT TRAFFIC AREA, BUT COULD HAVE EASILY OCCURRED ON THE FREEWAY OR WHEN ATTEMPTING TO PASS ANOTHER VEHICLE. THE MECHANIC FOUND THE CLUTCH MASTER CYLINDER HAD BROKEN OUT OF THE FIREWALL AND REPAIRED IT AS BEST HE COULD WITHOUT PULLING THE ENGINE. HE STATED THAT HE DISCOVERED SOME REPORTS OF CHEVROLET HAVING SIMILAR ISSUES IN THIS AND OTHER PRODUCTS; HOWEVER, THE DEALER WHERE WE PURCHASED THE VEHICLE HAD NO KNOWLEDGE. *TR

Mileage: 90,100

MY 2006 HHR HAS HAD TO HAVE THE FRONT AND REAR END STRUTS REPLACED AND NOW, THE POWER STEERING MOTOR AND DRIVE SHAFT. THE VEHICLE ONLY HAS 80K MILES ON IT. I DON'T DRIVE IT THAT MUCH SO IT SHOULDN'T BE HAVING ALL OF THESE ISSUES. WHY HASN'T GM ISSUED A RECALL ON THIS VEHICLE FOR ALL THE PROBLEMS IT HAS? I'VE READ COUNTLESS SIMILAR STORIES ON THE INTERNET. THIS VEHICLE NEEDS TO BE RECALLED TO ADDRESS THESE ISSUES. *TR

Mileage: 75,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE IGNITION FAILED AND THE KEY COULD NOT BE RELEASE FROM THE IGNITION SWITCH. THE CONTACT HAD TO MOVE GEAR SHIFTER LEVER SEVERAL TIMES IN ORDER TO SHUT THE ENGINE OFF. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE FAILURE WAS LOCATED AT THE GEAR SHIFTER AND THE DEALER REPLACED THE GEAR SHIFTER SYSTEM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 38,402. ..UPDATED 08-07-13 *BF

Mileage: 38,402

VEHICLE WILL STALL AND WE WILL CRASH OR BE HIT BY SOME ONE. WHEN THE VEHICLE STALLS YOU LOOSE ALL POWER THAT IS POWER STEERING,BRAKES,THE ABILITY TO MAINTAIN CONTROL OF MY VEHICLE .IT BEGAN WITH MY KEY GETTING STUCK IN THE IGNITION,WOULD HAVE TO TRY TO PLACE IN PARK MULTIPLE TIMES TO RELEASE THE KEY. FOUND THE PANEL IN THE STEERING COLUMN AND THE RELEASE BUTTON TO REMOVE KEY. NOW THE GEAR SHIFT BUTTON IS STUCK IN THE PRESSED POSITION, MAKING THE CAR VULNERABLE TO COMING OUT OF GEAR. THIS IS EXTREMELY UNSAFE AND COSTLY TO FIX. ADDITIONAL PERSONAL RESEARCH HAS INDICATED THIS IS A COMMON & KNOWN ISSUE WITH THE MANUFACTURER. *TR

PULLED INTO GARAGE, PLACED SHIFTER IN PARK, IGNITION KEY WOULD NOT ROTATE TO LAST DETENT POSITION AND KEY COULD NOT BE REMOVED, LEAVING SOME ELECTRICAL ITEMS ON. SHIFTER BUTTON WAS DEPRESSED AND WOULD NOT UNLOCK BUT SHIFT COULD BE PUT IN ANY GEAR. I SEARCHED INTERNET FOR PROBLEM AND LEARNED HOW TO REMOVE COVER UNDER IGNITION SWITCH AND MANIPULATE A BUTTON INSIDE THE COLUMN TO ALLOW KEY TO BE RELEASED. CAR CAN BE STARTED AGAIN BUT TO SHUT OFF AND REMOVE KEY, SAME PROCESS REQUIRED. A BIG PROBLEM I HAVE FOUND ON INTERNET FROM OTHER OWNERS IS THAT INSTEAD OF PAYING THE OUTRAGEOUS COST TO FIX, MANY DRIVERS ARE DOING THE ABOVE, WHICH IS A DANGEROUS SITUATION BECAUSE THE SHIFT LEVER CAN EASILY, ACCIDENTALLY BE SHIFTED INTO ANOTHER GEAR WHILE IN MOTION ! THIS PROBLEM IS CAUSED BE A METAL PIN, MOUNTED IN AN INFERIOR PLASTIC PIECE, WHICH BREAKS OR OTHERWISE ALLOWS THE METAL PIN TO FALL OUT OF POSITION. THIS IS REPORTED IN ALL YEAR MODELS, AT ALL MILEAGES. MY CAR IS A 2006 WITH 11000 MILES- 7 YEARS OLD, AND OBVIOUSLY HARDLY USED, LET ALONE ABUSED, AND OF COURSE, OUT OF WARRANTY ! GM HAS UPGRADED THE REPLACEMENT PART WITH A SHROUD OF METAL REINFORCING THE PLASTIC, AND HAS REPAIRED AND REPLACED UNDER WARRANTY ON MODELS FROM 2009 TO DATE. THIS IS OBVIOUSLY A DESIGN DEFECT, AND ALSO A SAFETY ISSUE. GM NEEDS TO RECALL ALL MODELS WITH THIS DEFECT ! THEY ARE NOT OFFERING ANY SOLUTION FOR A REPAIR THAT MANY OWNERS HAVE PAID UP TO $600 OF THEIR OWN MONEY, AND I FOR ONE AM GOING TO FIGHT THIS IN ALL WAYS POSSIBLE. GOV.'T, MEDIA, BBB,SOCIAL MEDIA, ETC ! REVIEW THE INTERNET BY SEARCHING " CHEVY HHR IGNITION KEY STUCK" . THIS ALSO AFFECTS CHEVY COBALT AND PONTIAC G5. *TR

Mileage: 11,000

THE POWER STEERING LIGHT COMES ON FREQUENTLY. I HAVE NO POWER STEERING AND HAVE TO DO IT MANUALLY WHICH MAKES IS VERY DIFFICULT TO STEER. THIS HAS BEEN HAPPENING MORE AND MORE. SOMETIMES I CAN ONLY BACK OUT OF THE DRIVEWAY WHEN THIS HAPPENS. AS THERE ARE NUMEROUS COMPLAINTS ON THIS ISSUE, I AM WONDERING WAY CHEVY DOESN'T DO A RECALL. *TR

Mileage: 90,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE IGNITION KEY COULD NOT BE TURNED TO ENGAGE THE ENGINE AND THE VEHICLE ALSO COULD NOT BE SHIFTED FROM PARK. THE VEHICLE HAD NOT BEEN DIAGNOSED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 116,000.

Mileage: 116,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEAR SHIFTER BECAME STUCK AND HE WAS UNABLE TO POWER OFF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE SHIFTER PANEL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 95,000. THE VIN WAS NOT AVAILABLE.

Mileage: 95,000

I DROVE MY VEHICLE TO NEW JERSEY FOR VACATION BUT CAME BACK TO VIRGINIA WITHIN TWO DAYS. UPON MY ARRIVAL IN VIRGINIA, I REPACKED MY BAGS AND HEADED TO CHARLOTTE, NC. ALL THE DRIVING THAT I WAS DOING WAS HIGHWAY DRIVING. TO NEW JERSEY I DROVE I-81 NORTH AND I-78 EAST. TO CHARLOTTE, NC I DROVE 220 SOUTH AND I-85 SOUTH. AFTER I GOT OFF ON I-85 SOUTH TO GO BACK TO THE HOTEL ON THE WAY UP THE HILL TOWARDS THE HOTEL THE CAR STOPPED MOVING FORWARD. IT WOULD REV UP WHEN PUSHING ON THE ACCELERATOR BUT WOULD NOT MOVE FORWARD. THE CAR HOWEVER WOULD SHIFT GEARS AND GO IN REVERSE. I PARKED THE CAR IN A PARKING LOT AND HAD CALLED MY INSURANCE COMPANY TO HAVE THE CAR TOWED TO THE LOCAL CHEVROLET DEALERSHIP.THE DEALERSHIP DETERMINED THAT THE TRANSMISSION FAILED BUT COULD NOT GIVE ME A DETERMINATION AS TO WHY IT FAILED. HAD THE TRANSMISSION FAILED AS I WAS SPEEDING DOWN I-85 SOUTH THERE WOULD HAVE BEEN A SERIOUS ACCIDENT. ADDITIONALLY, THIS MORNING (AUGUST 22ND , 2012) THE CAR WOULD NOT START. THE LIGHTS INSIDE THE CAR WOULD COME ON SUCH AS THE GAUGE LIGHTS, RADIO, ETC BUT THE ENGINE WOULD NOT TURN OVER. I HAD THE CAR TOWED TO THE MIDPOINT CHEVROLET DEALERSHIP AND IT WAS DETERMINED THAT THE STARTER WAS BAD AND THUS HAD TO BE REPLACED. ALSO, THE MORNING OF NOVEMBER 24TH UPON RETURNING TO MY CAR FROM A NIGHT OUT THE CAR WOULD NOT START AGAIN. THIS TIME NO LIGHTS WOULD COME ON. THE ONLY INDICATION THAT THERE WAS AT LEAST SOME POWER WAS THE INDICATOR LIGHT ON MY CAR CHARGER. I CONTACTED MY INSURANCE COMPANY AND RECEIVED A JUMP START FROM A LOCAL TOW SERVICE AND THE VEHICLE HAS BEEN RUNNING SMOOTHLY EVER SINCE. THIS HAS OCCURRED TWICE IN THE LAST FEW MONTHS BUT THERE IS NO INDICATION AS TO WHAT MAY BE DRAINING THE BATTERY'S POWER. I HAVE HAD THE BATTERY CHECKED TWICE AND ON THESE TWO OCCASIONS AND IS DEEMED TO STILL BE GOOD. *TR

Mileage: 146,217

I HAD CAME BACK HOME AND PUT THE CAR INTO PARK, I TURNED THE ENGINE OFF, AND TRIED TO PULL OUT THE KEY AND THE KEY WAS STUCK IN THE ON POSITION. *TR

POWER STEERING MESSAGE ON DASH; SECURITY LIGHT COMES ON; RPM, SPEED, AND GAS GAUGES JUMP, TRANSMISSION JERKS, CLICKING IN CENTER CONSOLE UNDER SHIFTER. AFTER TURNING ENGINE OFF FOR PERIOD OF TIME RUNS LIKE NORMAL, RESTART AN DRIVE FOR PERIOD OF TIME AND POWER STEERING GOES OUT WHILE DRIVING. *TR

Mileage: 65,000

AFTER TRAVELING BACK AND FORTH FROM ONE COUNTY TO ANOTHER (APPROX 130 MILES ROUNDTRIP) AS I EXITED THE FWY THE CAR WAS DRIVING NORMAL EXCEPT FOR I WAS ON EMPTY AT THIS POINT. I CAME TO A COMPLETE STOP WHEN LIGHT TURNED GREEN I BEGAN TO ACCELERATE. UPON ACCELERATION AT APPROX. 10-15MPH THE CAR MADE A HARD JERKING MOTION AS THOUGH IT WAS HAVING A HARD TIME SHIFTING GEARS HOWEVER MY 06 HHR IS AN AUTOMATIC. AT THIS POINT I ALSO NOTICED THAT THE CHECK ENGINE LIGHT HAD NOW ILLUMINATED ON THE INSTRUMENT PANEL. I TOOK THE CAR STRAIGHT HOME AND DID NOT ATTEMPT TO DRIVE AGAIN FOR 3-4 DAYS. THEN ONE DAY I DROVE IT APPROX 15 MILES ALL WAS GOOD. I WENT SHOPPING UPON LEAVING THE CAR STILL APPEARED TO BE NORMAL. THEN WHILE ON THE FWY APPROX 70MPH I NOTICED THE CHECK ENGINE LIGHT ON AGAIN AS WELL AS THE T/C LIGHT (TRACTION CONTROL) THE CAR CONTINUED TO DRIVE "NORMAL" BUT ONCE I CAME TO A STOP ON THE OFFRAMP AND BEGAN TO ACCELERATE THE JERKING MOTION HAPPENED AGAIN. I'VE NOTICED THAT ON A FEW OCCASIONS THIS HAPPENS ONCE THE GAS IS ON EMPTY. I ALSO NOTICED ON ONE OCCASION THAT ONCE I HAD PUT A LITTLE OVER HALF A TANK OF GAS IN AS WELL AS A BOTTLE OF FUEL INJECTOR CLEANER THAT THE INDICATOR LIGHTS SHUT OFF AS WELL AS THE JERKING HAD DISAPPEARS. WE HAVE HAD THE TRANSMISSION FLUSHED AND STILL THE PROBLEM PERSISTS. ASIDE FROM THAT WHEN YOU TRY TO REMOTE START THE ENGINE ONCE THE CHECK ENGINE LIGHT HAS COME ON THE REMOTE START NO LONGER WORKS. YOU HEAR THE ELECTRICAL ALL COME ON BUT THAT'S IT. THEN ALL OF A SUDDEN THE OTHER NIGHT I ATTEMPT TO EXIT MY CAR AND THE DRIVER DOOR HANDLE SNAPPED RIGHT OFF. MY HUSBAND CONTACTED THE LOCAL DEALERSHIP REQUESTING PRICE FOR THE PART AND WAS TOLD $300+. I JUST FOUND THE PIECE FOR $63.00 ONLINE. ..UNBELIEVABLE! BUT THE HANDLE BROKE SO EASILY. I DIDN'T PULL HARD. IF I HAD THE DOOR WOULD'VE AT LEAST POPPED OPEN A LIL. BUT IT DIDN'T BUDGE. *TR

Mileage: 120,000

SOME PORTION OF THE SHIFTER MECHANISM FAILED. IT ALLOWS THE VEHICLE TO SHIFT GEARS AT WILL, WITH OR WITHOUT A KEY AND WITH OR WITHOUT THE ENGINE RUNNING. IT ALSO ALLOWS THE VEHICLE TO BE PUT INTO GEAR WITHOUT DEPRESSING THE BRAKE PEDAL. THE VEHICLE CAN 'BUMP' FROM 'PARK' INTO ANY GEAR AND FROM ANY GEAR TO ANY OTHER GEAR, INCLUDING "REVERSE". WHILE DRIVING, ONE BUMP CAUSED IT TO SHIFT INTO 'NEUTRAL'. ANOTHER CAUSED A DOWNSHIFT. ONE CAN LEAVE TURN OFF THE IGNITION & LEAVE THE CAR WITHOUT PUTTING IT SECURELY INTO 'PARK'. I AM NOT POSITIVE, BUT I BELIEVE I COULD ALSO MAKE THE STEERING COLUMN LOCK WHILE THE IGNITION WAS ON. I TRIED THIS WHILE ATTEMPTING TO REMOVE THE KEY. I DID NTO WANT TO TRY AGAIN, FEARING I WOULD MAKE THE SITUATION WORSE. ADDITIONALLY, THE KEY IS NOW RETAINED IN THE IGNITION AND CAN NOT BE REMOVED. THE CAR CAN BE MORE EASILY STOLEN. (ON MINE, I FOUND OUT HOW TO FORCE THE KEY OUT OF THE IGNITION. BUT THE GEAR SHIFTER CAN STILL BUMP AROUND.) THE MENTIONED CRASH WAS FROM EXITING THE CAR EITHER WITHOUT IT BEING SECURELY IN 'PARK' OR FROM HAVING IT FALLOUT OF 'PARK'. IT ROLLED INTO A PARKED VEHICLE. I ENTERED "0 MPH" BECAUSE I WASN'T THERE TO SEE THE CAR ROLL. IT WAS ON A SMALL ENOUGH INCLINE THAT NO DAMAGE WAS DONE OTHER THAN SCRATCHES. *TR

Mileage: 21,706

FOR ABOUT A MONTH MY KEY KEPT GETTING STUCK IN THE IGNITION BUT I COULD ALWAYS GET IT OUT MYSELF. I WOULD SHIFT FROM "PARK" TO "DRIVE" AND THEN BACK TO "PARK" TO REMOVE IT. FINALLY ONE DAY I COULD NOT REMOVE IT. I BROUGHT IT TO THE DEALERSHIP AND HAD TO HAVE A PART IN THE SHIFTER REPLACED TO FIX THE PROBLEM. APPARENTLY THE "CAR" COULD NO LONGER RECOGNIZE IT WAS IN PARK AND SAFE TO REMOVE THE KEYS. THE COST WAS $250.00 AND NOW THE KEY STILL STICKS. IT SEEMS LIKE THIS IS A REAL PROBLEM AND CHEVY SHOULD TAKE RESPONSIBILITY FOR IT. *JB

Mileage: 69,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT SHE SHIFTED INTO PARK AND THE KEY WOULD NOT REMOVE FROM THE IGNITION. THE CONTACT ALSO STATED THAT THE BUTTON LOCATED ON THE GEAR SHIFT WAS JAMMED INSIDE OF THE SHIFTER ITSELF. DUE TO THE JAMMING OF THAT BUTTON, THE GEAR SHIFT MOVED FREELY BETWEEN GEARS EVEN THOUGH THE BRAKE PEDAL WAS NOT DEPRESSED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 82,000.

Mileage: 82,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THAT THE GEAR SHIFTER WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 64,186.

Mileage: 64,186

DISPLAY SHOWED POWER STEERING ERROR AND TRANSMISSION BOX WAS CLICKING. CAR STARTED BUCKING AS IF TRANSMISSION WAS GOING OUT. TOOK TO DEALER WHO COULD NOT REPLICATE ERROR AFTER THREE DAYS. PICKED UP CAR AND NOW CD PLAYER SHOWS ERR O. THIS IS FRUSTRATING AS HECK! DEALER DID SAY THAT THERE WAS A BULLETIN THAT 2006 HHR'S DID HAVE THIS TYPE OF PROBLEM. DEALER REP. OWNS 2007 HHR AND HOPED HE DID NOT HAVE THE SAME ISSUE. SPENT OVER $700 TOTAL AND PROBLEM STILL THERE? CHEVROLET / GM WHERE IS YOUR LOYALTY TO YOUR LOYAL CUSTOMERS? ISSUE A RECALL AND FIX THESE ISSUES BEFORE THERE ARE DEATHS BECAUSE OF THEM AND YOU ARE FORCED TO DO WHAT IS RIGHT BY THE GOV.'T. *TR

Mileage: 154,000

MY GEAR SHIFTER IS MALFUNCTIONING. IT IS STUCK IN PARK. I DO NOT HAVE RELIABLE TRANSPORTATION AND WOULD LIKE THIS REPAIR TO BE ON THE RECALL LIST WITH CHEVY BEING THAT THERE ARE A MULTITUDE OF COMPLAINTS ABOUT THE GEAR SHIFTER. *TR

Mileage: 100,000

I PUT MY CAR IN PARK AND WHEN I WENT TO TAKE THE KEY OUT OF THE IGNITION IT WOULD NOT COME OUT. I REALIZED THAT THE KEY WOULD NOT COME OUT BECAUSE THE GEAR SHIFTER PIECE WAS PUSHED ALL THE WAY IN, IT WAS BROKE. THIS MEANT THAT MY CAR WAS LEFT ON AND THE BATTERY WAS DRAINED BECAUSE I COULD NOT TURN MY CAR OFF. NOW MY CAR WILL NOT START AT ALL THE BATTERY IS CHARGED BUT THE CAR WILL NOT TURNOVER. I HAVE LOOKED ONLINE AND HAVE FOUND THAT THERE ARE MANY COMPLAINTS CONCERNING THE SAME PROBLEM WITH THIS VEHICLE. I AM TOLD BY THE DEALERSHIP THAT I HAVE TO PAY $710 TO HAVE THIS PROBLEM FIXED. CAN YOU PLEASE LOOK INTO THIS BECAUSE THIS SEEMS TO BE A BIG PROBLEM. *TR

Mileage: 97,000

I AM SCARED, FOR MY FAMILY'S SAFETY FEAR THAT THIS VEHICLE WILL STALL AND WE WILL CRASH OR BE HIT BY SOME ONE...WHEN A VEHICLE STALLS YOU LOOSE ALL POWER...THAT IS POWER STEERING, BRAKES.....THE ABILITY TO MAINTAIN CONTROL OF YOUR VEHICLE I AM ATTACHING A LINK THAT GM SHOULD REVIEW.....DANGER THIS VEHICLE IS AN ACCIDENT WAITING TO HAPPEN !!!!!!!!!!!!! COPY THIS LINK TO YOUR WEB BROWSER HTTP-//ABCLOCAL.GO.COM/WTVD/STORY?SECTION=NEWS/ABC11_INVESTIGATES&ID=6811236 IF YOU WOULD PREFER I CAN SEND A TYPED TRANSCRIPT (WORD FOR WORD) OF THIS NEWS BROADCAST? I WILL NOT ALLOW MY WIFE AND KIDS LIFE TO BE PUT IN DANGER, BY LETTING THEM RIDE IN THIS VEHICLE THIS VEHICLE IS UNSAFE AND SHOULD BE RECALLED THE LINK I AM ATTACHING SHOWS A NEWS BROADCAST IN RALEIGH NC. ON CHANNEL 11 NEWS !!!!! INVOLVING NUMBER 12 ISSUE ON MY LONG LIST BELOW WITH THE CHEVY HHR STALLING WHILE DRIVING..... I PURCHASED A 2006 CHEVY HHR LT, IN 2007. SINCE I HAVE PURCHASED THIS VEHICLE THE FOLLOWING ISSUES HAVE OCCURRED. MILEAGE ON CAR 33,346 1) THE KEY LOCKED UP IN IGNITION..9/06/07 2) SHIFTER FROZE UP AND WOULD NOT COME OUT OF PARK. . 9/06/07 3) HEADLINER TRIM ? ENERGY ABSORPTION CAPABILITY 4) FRONT END AND WHOLE CAR STARTED TO SHAKE WHEN APPLYING BRAKE..9/06/07 DEALER TURNED ROTORS( BUT DID NOT FIX ISSUE) 5) REPLACED DRIVER SIDE RUNNING BOARD..9/06/07. 6) GOT IN VEHICLE ONE MORNING TRIED TO TAKE KIDS TO SCHOOL, VEHICLE WOULD NOT GO OVER 15 MPH, HAD TOWED BACK TO LAWSON CHEVROLET. WORKING ON GETTING DATE/MILEAGE..THIS ISSUE OCCURRED TWICE BEFORE. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHEN THE VEHICLE WAS SHIFTED INTO PARK, THE GEAR SHIFTER BECAME STUCK AND IT WAS VERY DIFFICULT TO REMOVE THE KEY FROM THE IGNITION. THE CONTACT HAD TO SHAKE THE GEAR SHIFTER IN ORDER TO REMOVE THE KEY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED, BUT THE CONTACT FELT THE GEAR SHIFT ACTUATOR WAS FAILING. THE FAILURE AND CURRENT MILEAGES WERE 55,000.

Mileage: 55,000

2006 CHEVY HHR :: PROBLEM :: POWER STEERING MESSAGE ON DASH AND HARD TO STEER, ABS LIGHT ON, TRANSMISSION MAKING CAR BUCK WHILE DRIVING, AND SPEEDOMETER IS BOUNCING. THIS IS THE SECOND TIME IT HAS HAPPENED, LAST TIME DEALER FOUND ONLY "COMMUNICATION CODES" AND DID NOT FIX ANYTHING SO NOTHING WAS COVERED BY THE EXTENDED WARRANTY. THAT WAS 9 MONTHS AGO AT 50140 MILES. *KB

Mileage: 58,255

I PURCHASED A 2006 CHEVROLET HHR FOR MY DAUGHTER WITH A 72 MONTHS /100,000 MILES EXTENDED WARRANTY (WHICH HAS ONE YEAR AND SIX MONTHS LEFT). SHE BROUGHT HER CAR HOME FROM SCHOOL ON SUMMER VACATION SAYING THAT HER CAR WAS SHIFTING FUNNY. WE TOOK IT TARR CHEVROLET SERVICE DEPARTMENT BELIEVING THAT WITH OUR EXTENDED WARRANTY THEY WOULD BE ABLE TO FIGURE OUT THE PROBLEM, REPAIR IT, AND ALL WOULD BE GOOD. HOWEVER, THAT WAS NOT THE CASE. IT TOOK THEM TWO WEEKS TO FIGURE OUT THE TRANSMISSION WAS BLOWN. I WAS CALLED TODAY AND HAD WITH A VERY CONFUSING CONVERSATION WITH THE SERVICE MANAGER. I WAS TOLD THAT I HAD TWO OPTIONS FOR GETTING MY CAR REPAIRED. IT WAS EXPLAINED TO ME THAT I COULD EITHER GET A USED TRANSMISSION WITH 33,000 MILES ON IT ALREADY AND IT WOULD BE COVERED BY A ONE YEAR WARRANTY (THE TRANSMISSION THAT JUST BROKE DOWN WITH ONLY 55,000 MILES ON IT). OR I COULD GET A NEW TRANSMISSION AND PAY THE DIFFERENCE OF 1,500.00 DOLLARS WHICH SEEMS UNFAIR TO ME. THIS IS A SHORT SUMMARY OF WHAT HAS TRANSPIRED AND IT IS VERY DISCOURAGING TO MY DAUGHTER AND I. WE WERE WONDERING IF YOU HAD ANY INSIGHT INTO OUR PREDICAMENT. *TR

Mileage: 55,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHEN DRIVING AT ANY SPEED, THE POWER STEERING WOULD FAIL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE POWER STEERING MOTOR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS 43,000 AND THE APPROXIMATE FAILURE MILEAGE WAS 42,000. UPDATED 9/27/11 *CN ALSO, THE CONSUMER WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION WHEN THE VEHICLE WAS PLACED IN PARK. THE SHIFTER WAS REPLACED. UPDATED 02/01/12

Mileage: 42,000

KEY STUCK IN IGNITION. UNABLE TO REMOVE WITHOUT USING THE RELEASE BUTTON UNDER THE STEERING COLUMN. TAKEN TO REPAIR SHOP TO SEE WHAT THE PROBLEM WAS. WAS ADVISED THAT THE GEAR SHIFT IS NOT GOING COMPLETELY INTO PARK, THEREFORE THE KEY WILL NOT RELEASE. WAS ALSO ADVISED THAT MY CAR IS NOT LOCKED IN ANY ONE POSITION, SO WHILE DRIVING THE SHIFTER WILL SWITCH FROM DRIVE TO NATURAL. NO WORK DONE TO FOSTLY, CONTACTED DEALER WHO ADVISED SAME ISSUE ON 2009 HHR'S AND THEY ARE BEING RECALLED, BUT MO OPEN RECALL ON 2006 AT THIS TIME. *TT

Mileage: 70,000

POWER STEERING FAILURE WHILE DRIVING MY VEHICLE WITH CHILDREN. *TR

Mileage: 40,000

KEY WILL NOT COME OUT OF THE IGNITION WHEN IN PARK DUE TO A PLASTIC PART IN THE SHIFTER BREAKING. THIS WILL NOT ALLOW THE SHIFT LOCK ACTUATOR TO ENGAGE AND RELEASE THE KEYS. THERE IS AN IGNITION UNLOCKING MECHANISM UNDER THE STEERING COLUMN BUT THAT LEAVES THE GEAR SHIFTER ABLE TO MOVE FREELY FROM GEAR AT ALL TIMES, EVEN WHILE DRIVING. THIS IS OCCURS EVERYDAY. THE DEALER REPLACES AT THE OWNER'S EXPENSE WITH THE SAME DEFECTIVE PART. *TR

FEW ISSUES THAT SEVERAL PEOPLE ALSO HAVE DISCUSSED ON THE WEB: **TRANSMISSION HARD SHIFTING. STILL AN ISSUE, GARAGES AND DEALER HAVE NOT BEEN ABLE TO RESOLVE **KEY NOT COMING OUT OF IGNITION. RECENT ISSUE NOT FIXED YET. MAY BE TRANSMISSION INTERLOCK ISSUE BASED ON INTERNET DISCUSSIONS **LEAK AND WATER GETS IN CAR. GETS MY HEAT BLOWER WET AND BLOWS OUT A PART AND I ONLY HAVE OFF AND HIGH FAN SETTINGS. ONGOING ISSUE AS WELL. *TR

Mileage: 60,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEAR SHIFT SELECTOR WOULD SHIFT INDEPENDENTLY WHILE DRIVING AT ANY SPEED, CAUSING THE KEY TO REMAIN STUCK IN THE IGNITION. THE DEALER WAS CONTACTED WHO OFFERED NO ASSISTANCE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT TO REPAIR THE VEHICLE AT HER OWN RISK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 7,800 AND THE CURRENT MILEAGE WAS APPROXIMATELY 9,100.

Mileage: 7,800

2006 CHEVY HHR. GEAR SHIFT CONTROL PIN FALLS OUT OF PLASTIC RETAINMENT PIECE RESULTING IN GEAR SHIFT BUTTON STICKING IN THE INWARD POSITION AND THE KEY REMAINING LOCKED IN STEERING COLUMN. DUE TO A DEFECT IN MANUFACTURING, THE PLASTIC CRACKS AROUND THE PIN RETAINMENT HOLE. THE CONTROL PIN THEN BECOMES LOOSE, THUS RESULTING IN THE CONTROL PIN EITHER MOVING OUT OF IT'S INTENDED POSITION AND JAMMING THE GEAR SELECTOR, OR FALLING OUT COMPLETELY AND ALLOWING THE GEAR SELECTOR TO MOVE IN ANY GEAR AT ANY TIME, WEATHER THE CAR IS RUNNING OR SHUT OFF. ONCE CONTROL PIN MOVES OUT OF POSITION OR FALLS OUT, THE MICRO SWITCH CANNOT BE ACTIVATED TO RELEASE THE KEY FROM THE IGNITION, THUS RESULTING IN A DEAD BATTERY VERY DANGEROUS. THE DEALERSHIPS ARE AWARE OF THIS PROBLEM BUT INSIST THERE IS NO T.S.B. OR RECALL. THEY COULD EASILY REPLACE THE PLASTIC RETAINMENT PART WITH THE NEWER VERSION USED IN LATER MODELS, BUT CLAIM THEY CAN'T GET IT. THERE REMEDY IS TO REPLACE THE ENTIRE SHIFTER ASSEMBLY AT A COST OF $150.00 PLUS LABOR. THE NEWER RETAINMENT PART CAN'T COST MORE THAN 15 DOLLARS,(NARROW PIECE OF PLASTIC ~ THE SIZE OF A PENCIL WITH A SMALL HOLE IN IT). THIS PART GOES FROM THE TOP OF THE SHIFTER TO THE BOTTOM OF THE GEAR SELECTOR AND HOLDS THE CONTROL PIN IN POSITION, WHICH IN TURN, ACTIVATES THE MICRO SWITCH TO RELEASE THE KEYS. WITH THE AMOUNT OF OCCURRENCES LISTED ONLINE SINCE 2006. THIS, WITHOUT A DOUBT, SHOULD BE A RECALL. *TR

Mileage: 65,000

I HAVE HAD MY 2006 HHR IN DEALERSHIP 3 TIMES FOR A HARD SHIFTING TRANSMISSION. THEY REBUILT THE TRANSMISSION AND I AM HAVING THE SAME PROBLEM AGAIN. I TOOK IT BACK THEY DROVE IT AND IT WAS FINE. THIS HARD SHIFTING HAPPENS MAYBE 25PER CENT OF THE TIME BUT WHEN IT DOES IT SHIFTS VERY HARD AND CONTINUES. I AM AFRAID IT WILL PUT ME DOWN WHAT CAN I DO? *TR

2006 HHR WITH AUTOMATIC TRANSMISSION. REPAIR LIGHT LIT WITH CODES INDICATING INTERNAL TRANSMISSION PROBLEMS AND BAD CONNECTIONS IN ELECTRICAL SYSTEM. SEVERAL TRIPS TO MECHANIC LOCALIZED PROBLEM TO CONNECTOR PLUG ON TRANSMISSION. HARNESS WIRE IS TOO SHORT AND DRIVETRAIN FLEX CAUSES STRAIN ON PLUG RESULTING IN FAILURE OF CONNECTOR PINS IN PLUG. *TR

Mileage: 75,000

2006 CHEVY HHR LT WITH AUTOMATIC TRANSMISSION. METAL PIN MECHANISM LOCATED IN LOWER SHIFTER HANDLE WHICH ACTIVATES TRANSMISSION INTERLOCK SLIDES OUT OF SHIFTER UNIT DUE TO EXCESSIVE WEAR ON THE PLASTIC CARRIER BRACKET. SHIFTER HANDLE IS THEN ABLE TO BE PULLED OUT OF PARK WHEN KEY IS IN "OFF" OR "LOCK" POSITION AND KEY CANNOT BE REMOVED FROM IGNITION WITHOUT DISASSEMBLING THE CONSOLE TO ACTIVATE THE MICROSWITCH INTERLOCK. ANECDOTAL EVIDENCE INDICATES THIS PROBLEM OCCURS ACROSS HHR AND COBALT PLATFORMS. *TR

Mileage: 65,000

THE BUTTON ON THE SHIFT LEVER ON THE AUTOMATIC TRANSMISSION OF MY 2006 CHEVY HHR STICKS IN THE IN POSITION ALLOWING THE TRANSMISSION TO BE SHIFTED INTO ANY GEAR INCLUDING PARK AND REVERSE AS I AM DRIVING. THIS PROBLEM IS INTERMITTENT BUT RECURS FROM TIME TO TIME, VERY UNPREDICTABLE. AT THIS TIME I HAVE NOT FIXED IT BECAUSE I WAS DEBATING TRADING THE CAR IN. *TR

Mileage: 79,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THE GEAR SHIFT WOULD NOT MOVE FROM GEAR TO GEAR WHILE THE VEHICLE WAS IN OPERATION. IN ADDITION, THE CONTACT STATED THAT THE KEY WOULD COME OUT OF THE IGNITION WITHOUT THE VEHICLE BEING LOCKED IN THE PARK POSITION. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE AND CURRENT MILEAGES WERE 43,000. UPDATED 10/27/10. *LJ

Mileage: 43,000

2006 CHEVY HHR - AUTOMATIC TRANSMISSION DOES NOT LOCK INTO POSITION, CAN FREELY SLIP TRANSMISSION SHIFTER FROM PARK, REVERSE, NEUTRAL, DRIVE AND LOWER GEARS WITH LITTLE PRESSURE AND WITHOUT DEPRESSING THE SHIFTER LOCKING LATCH. GM HAS RECALLED 2010 MODELS WITH SIMILAR ISSUES BUT NONE OF THE PREVIOUS YEAR MODEL HHRS DEALERSHIP WANTS $150.00 TO TRY NEW BATTERY TO SEE IF IT WILL FIX THE PROBLEM. IF THIS SOLUTION DOES NOT WORK THEN THEY WANT ANOTHER $160.00 FOR NEW SHIFTER UNIT... LABOR FOR BOTH THESE ITEMS ARE NOT INCLUDED, JUST COST OF PARTS. I BELIEVE GM RECOGNIZES ISSUE: GM TSB #06-07-30-004F. *TR

Mileage: 39,000

I OWN A 2006 CHEVY HHR, AND WITHIN THE PAST TWO WEEKS HAVE EXPERIENCED A PROBLEM (WHICH APPARENTLY, AFTER LOOKING ONLINE, SEVERAL OTHER OWNERS HAVE EXPERIENCED). WHEN I PUT MY CAR IN PARK, AND GO TO TURN OFF THE IGNITION, IT WON'T LET ME TAKE OUT MY KEY, AND MY STEERING WHEEL WON'T LOCK. THIS HAPPENS EVERYTHIME THAT I TRY TO TURN OFF MY CAR NOW, WHICH IS AT LEAST ABOUT TEN TIMES DAILY. I HAVE TO "SLAM" IT INTO PARK TO GET THE KEY OUT. I AM NOT SURE THOUGH THAT WHEN THIS IS DONE IF MY CAR IS TRULY IN PARK. I WENT TO MY CAR REPAIRMAN, WHO SAID THAT THIS DEFINITELY NEEDS TO BE LOOKED AT BECAUSE IF I CONTINUE TO "SLAM" IT IN PARK, I COULD EVENTUALLY BREAK THE SHIFTER- WHICH IN MY MIND COULD DEFINITELY CAUSE AN ACCIDENT/ OR PROPERTY DAMAGE. I AM TAKING MY CAR IN ON WEDNESDAY FOR THIS PURPOSE, NOT SURE YET WHAT THE COST WILL BE, BUT I STRONGLY BELIEVE THAT THIS PROBLEM SHOULD BE LOOKED AT BY DOT. *DT

Mileage: 45,000

2006 HHR KEY STICKS IN IGNITION. BUTTON THAT IGNITES SHIFTER BROKEN AND STICKS IN PLACE CAUSING THE SHIFTER TO BE EASILY ENGAGED AT ANY TIME. CAR IS AT 70,822 MILES. CAR DEALER STATES IT IS NOT COVERED BY TRANSFERABLE MANUFACTURERS 5 YR/100,000 POWERTRAIN WARRANTY. CAR WAS PURCHASED USED 05/2007. COST TO COVER REPLACEMENT IS OVER 300.00. IF OPERATORS DO NOT GET THIS REPLACED I AM SURE IT WILL CAUSE PROPERTY DEATH, INJURY, AND ACCIDENTS AS THE SHIFTER CAN BE ENGAGED BY A SLIGHT BUMP TO PARK, REVERSE, NEUTRAL, ETC. *TR

Mileage: 70,822

SHIFTER REFUSES TO GO FULLY INTO PARK RESULTING IN INABILITY TO REMOVE KEY FROM STEERING COLUMN. SHIFTER DOES NOT LOCK INTO GEAR AND CAN MOVE FREELY BETWEEN GEARS WITHOUT BRAKE PEDAL DEPRESSED. *TR

Mileage: 103,000

2006 CHEVY HHR LS PERMANENT FAILURE. GEAR SHIFT STOPPED LOCKING. GEAR SHIFT MOVES FREELY INTO ANY POSITION WHILE DRIVING OR STOPPED. CAR MAY ROLL. WILL NOT RELEASE KEY FROM IGNITION. *TR

Mileage: 50,000

COULD NOT REMOVE KEY FROM IGNITION WITH GEAR SELECTOR IN PARK. THIS CONDITION WAS REMEDIED BY PUSHING THE GEAR SELECTOR HARD INTO PARK FOR A WHILE. THEN TOTAL FAILURE CAME WHEN NO AMOUNT OF PUSHING THE GEAR SELECTOR HARD INTO PARK WOULD ALLOW THE KEY TO BE REMOVED. I REMOVED THE GEAR SHIFT COVER AND REACHED IN AND FOUND A MICRO SWITCH THAT WHEN TRIPPED ALLOWED ME TO REMOVE KEY. I CALLED LOCAL DEALER AND CHEVROLET FACTORY TOLL FREE LINE AND THEY DID NOT SAY THIS WAS A KNOWN DEFECT. I PURCHASED REPLACEMENT PART # 25864102. I PERSONALLY INSTALLED THIS AND IT FIXED THE PROBLEM. THERE IS A STEEL PIN IN THE GEAR SELECTOR PLASTIC SHIFT ROD. THE PLASTIC IS WEEK AND ALLOWED THE PIN TO DRIFT APPROX 1/2" TO LEFT WHICH WOULD NOT ALLOW THE KEY REMOVAL MICRO SWITCH TO BE TRIPPED AS IT SHOULD BE TO ALLOW THE KEY TO BE REMOVED FROM THE IGNITION LOCK CYLINDER. I CALLED CHEVROLET BACK (TEL # 1-866-790-5600) AND THEY SET UP CASE # 71-781779261. THEY TOLD ME TO TAKE DEFECTIVE PART TO THE DEALER AND THEY WOULD CONTACT THE DEALER TO ANALYZE THE PART FOR REASON OF FAILURE. I TOOK THE PART TO THE DEALER SERVICE MANAGER12/4/09. I CALLED CHEVROLET SEVERAL WEEKS LATER AND THEY SAID THE DEALER THREW THE PART AWAY SINCE CHEVROLET DID NOT CONTACT THEM PROMPTLY. I HAD ASK FOR CHEVROLET TO REFUND THE COST OF THE PART ONLY (NO LABOR) BUT CHEVROLET SAYS THEY CAN'T HELP SINCE THE PART IS NOW GONE. I LATER SEARCHED ON THE INTERNET HTTP://WWW.MYCARSTATS.COM/ AND FOUND MANY CASES LIKE MINE (APPARENTLY CHEVY COBALT SHARES GEAR SHIFT MECHANISM BASIC INTERNAL DESIGN STYLE). I CALLED CHEVROLET BACK, THEY STILL DENY THIS IS A RECURRING PROBLEM. THIS IS A SAFETY PROBLEM BECAUSE YOU HAVE TO LEAVE YOUR CAR WITH THE KEY IN IT WHEN THE FAILURE OCCURS. APPARENTLY THIS MAY ALSO DRAIN THE BATTERY BECAUSE ALL CIRCUITS ARE NOT SHUTOFF WHEN YOU CANNOT ROTATE THE KEY FAR ENOUGH TO REMOVE THE KEY. I FEAR THAT MY REPLACEMENT PART MAY NOT LAST EITHER. THE CAR WAS ~ 48 MO OLD AND ~ 47,000 MILES WHEN TOTAL FAILURE OCCURRED. *TR

Mileage: 47,000

2006 NEW VEHICLE PURCHASE SERVICED 8 TIMES FOR MULTIPLE FAILURES RELATED TO EITHER ELECTRICAL/BRAKING/ABS/ WHEELS/EMISSIONS/ TRACTION CONTROL/COMPUTER/POWER STEERING AND OR COMPUTER ISSUES/ALL REPAIRED/AND RESOLVED AT GM DEALER/VEHICLE CAN NOT BE DRIVEN SAFELY WHEN ISSUE OCCURS THE FAILED SYSTEM IN QUESTION OVERRIDES DRIVER LAST INCIDENT FAILURE OCCURRED IN HEAVY TRAFFIC RESULTING IN REMOVAL FROM SERVICE WHICH TOOK 3 WEEKS TO REPAIR/HAD THE CONDITIONS BEEN DIFFERENT THIS MAY HAVE RESULTED IN A CRASH. *TR

Mileage: 5,600

I PULLED MY CAR INTO THE DRIVEWAY AT HOME AND SHIFTED INTO PARK AND WHEN I ATTEMPTED TO REMOVE THE KEY IT WOULD NOT TURN ALL THE WAY TO THE REMOVAL POSITION. SO I MOVED THE SHIFT LEVER AGAIN AND NOTED THAT THE SHIFT BUTTON DIDN'T POP OUT WHEN I PUT IT INTO PARK. I KNEW THEN THAT THE KEY WOULD NOT COME OUT UNTIL THE VEHICLE WAS PUT INTO PARK WHICH THE SHIFT LEVER WAS NOT ALLOWING. I TOOK THE VEHICLE STRAIGHT TO MY GM DEALER SERVICE MANAGER WHO STATED THAT I WAS THE SIXTH OR SEVENTH CUSTOMER WHO HAD HAD THIS PROBLEM IN THE LAST 12 MONTHS. THE MANAGER CALLED ME BACK AND TOLD ME THAT MY CAR WAS OUT OF WARRANTY AND THE COST WOULD BE $215.04. I WAS CONCERNED THAT THIS WAS NOT A RECALL ITEM SINCE HE HAD DONE SO MANY IN A TOWN OF 4500 PEOPLE AND THAT IN MY OPINION IT WOULD PUT SOMEONE IN AN EMERGENCY SITUATION AT RISK OF HAVING THEIR CAR STOLEN IF THE COULDN'T TAKE THEIR KEYS OUT IN A LARGE CITY. I CONTACTED CUSTOMER SERVICE AT GM BUT WAS TOLD THAT THEY COULDN'T DO ANYTHING FOR ME, EVEN THOUGHT A SERVICE BULLETIN ON HOW TO DO THE REPAIR HAD BEEN SENT TO ALL GM SERVICE DEPARTMENTS. TO ME, THAT SOUNDS LIKE A RECALL SHOULD HAVE BEEN ISSUED. YES, I PAID TO HAVE THE PART REPLACED, BUT I STILL THANK IT IS THE MANUFACTURES FAULT AND NOT MINE. THE RECALL WOULD HAVE BEEN MADE BEFORE MY WARRANTY EXPIRED. ALSO THE SERVICE MANAGER REPORTED THAT THE CHEVROLET COBALT ALSO HAS THIS PROBLEM. *TR

Mileage: 48,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE WOULD NOT SHIFT FROM FIRST TO SECOND GEAR OR FROM THIRD TO FOURTH GEAR. THE VEHICLE APPEARED TO REMAIN IN SECOND GEAR NO MATTER HOW FAST THE VEHICLE WAS TRAVELING. SHE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE HUB ASSEMBLY NEEDED TO BE REPAIRED. THE ASSEMBLY WAS REPAIRED. THE CONTACT FILED A COMPLAINT WITH THE MANUFACTURER AND WAS ISSUED A CASE NUMBER. THE CURRENT MILEAGE WAS 59,196 AND FAILURE MILEAGE WAS APPROXIMATELY 59,000.

Mileage: 59,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 45 MPH, THE TOP SECTION OF THE KNOB ON THE GEAR SHIFTER SUDDENLY DETACHED. THE CONTACT CONTINUED TO DRIVE THE VEHICLE BY GRABBING THE MIDDLE PART OF THE SHIFTER. HE NOTICED THAT THE KNOB WAS INJECTION MOLDER PLASTIC, WHICH WAS SHIELDED OFF. THE VEHICLE HAS NOT BEEN INSPECTED, BUT THE CONTACT BELIEVED A RECALL SHOULD BE ISSUED FOR THIS DEFECT. THE CURRENT AND FAILURE MILEAGES WERE 52,900. UPDATED 8/10/09 *CN THE CONSUMER STATED THE INCIDENT HAPPENED WHEN HE SHIFTED FROM 3RD TO 4TH GEAR WHILE ACCELERATING. UPDATED 08/13/09.*JB

Mileage: 52,900

CONSUMER WANTS TO KNOW IF THERE IS A RECALL ON THE FRONT BUMPER OF HER 2006 CHEVROLET HHR. *NJ THE CONSUMER STATED THERE WAS A PROBLEM WITH THE GEAR SHIFT AND THE DOOR LATCHES BEGAN TO MOVE UP AND DOWN. ALSO, THE VEHICLE STARTED ACTING ERRATIC WHILE DRIVING. UPDATED 09/13/10

PUT VEHICLE IN PARK, KEY WOULD NOT COME OUT OF IGNITION AFTER TURNING VEHICLE OFF. STILL WOULD RE-START SO FOUND A DEALER AND DROPPED OFF VEHICLE. PER DEALER SHEET AT PICK-UP - 19373 SHIFTER ROD FELL OFF VERIFIED IGNITION KEY DOESN'T COME OUT OF IGNITION CYLINDER. NOTICED SHIFTER BUTTON STUCK IN/DEPRESSED. REMOVE POWER WINDOW SWITCH PANEL, SHIFTER COVER PANEL. DISCONNECT SHIFTER CABLE, REMOVE SHIFTER, FOUND SHIFTER ROD FELL OFF. SHIFTER B/O. ****** R&R SHIFTER, INSTALL SHIFTER CABLE, SHIFTER COVER PANEL, POWER WINDOW SWITCH PANEL, ROAD TEST VEHICLE, CHECK SHIFTER OPERATION, SHIFTER WORKING NORMALLY. TURN VEHICLE OFF, EASILY ABLE TO REMOVE KEY OUT OF IGNITION. *TR

Mileage: 19,373

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 75 MPH ON NORMAL ROAD CONDITIONS, THE TRACTION CONTROL SWITCH ACTIVATED. SUDDENLY, THE TRACTION CONTROL DISENGAGED WITHOUT ASSISTANCE. THERE WAS NO RESPONSE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE BEGAN TO IDLE EXCESSIVELY AND SURGED UNEXPECTEDLY. IMMEDIATELY, THE VEHICLE WAS DRIVEN TO AN AUTHORIZED DEALER FOR INSPECTION, BUT THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON THREE SEPARATE OCCASIONS FOR IDENTICAL FAILURES. THE REPAIRS CONSISTED OF INSTALLING A DATA RECORDER AND REPLACING THE BCM. IN ADDITION, THE STEERING COLUMN AND GEAR SHIFTER WERE REPLACED. THE VEHICLE WAS NOT BEING DRIVEN DUE TO THE SAFETY RISK INVOLVED. THE FAILURE MILEAGE WAS 13,456 AND CURRENT MILEAGE WAS 15,500.

Mileage: 13,456

AUTO DIMMER DOES NOT WORK ON REARVIEW MIRROR. UNABLE TO REMOVE KEY FROM CHEVY HHR 2006 MODEL. IT IS A SHIFT LEVER ISSUE. THE CAR IS OUT OF WARRANTY SO NEITHER OF THESE ITEMS ARE STILL COVERED. THESE ARE ITEMS THAT SHOULD LAST LONGER THAN THREE YEARS. CHEVY IS IGNORING THE ISSUE. *TR

Mileage: 60,000

KEY IN THE IGNITION IS SOMETIMES GETTING STUCK, ONE HAS TO POSITION THE AUTOMATIC GEAR SELECTOR OUT OF PARK AND BACK INTO PARK TO GET THE KEY TO RELEASE PROPERLY. POSSIBLE ITS THE INTERLOCK FEATURE OF THE AUTOMATIC GEAR SELECTOR POSITION BEING AFFECTED. *TR

Mileage: 39,000

I NEED YOUR HELP, 1ST,COMPUTER BROKE,THEN 2ND GEAR SHIFT, THEN 3RD SUNROOF, THEN 4TH BACK DOOR WON'T OPEN-SON CAN'T GET OUT, THEN 5TH POWER STEERING, TRIED TO REPLACE POWER STEERING WITH A USED ONE THAT WE COULD AFFORD,, NOW CAR IS LOCKED AND WON'T CRANK, DID WHAT MECHANIC SAID TO REPROGRAM AND IT STILL DOESN'T WORK, GM REPLACED 1ST COMPUTER, I PAID FOR GEARS , TRIED TO GET GM TO FIX ELECTRIC STEERING, SAID THEY WOULD BUY PARTS BUT NOT LABOR >1000, RIGHT BEFORE WE TRIED TO REPLACE THE POWER STEERING THE CRANK STARTED HANGING, 06 CHEVROLET HHR-NO CAR, HELP, ITS SO BROKE, HURT MYSELF TRYING TO DRIVE IT, AND HAVE BEEN TRYING TO GET FIXED FOR OVER 2 MONTHS, ITS A BOMB, NOW I HAVE NO CAR TO DRIVE. GM STATES ITS OVER MILEAGE, THOUGHT I BOUGHT ALL WARRANTIES, DEALER WENT OUT OF BUSINESS, PALM BAY CHEVROLET, FL, I NEED SOME HELP, MULTIPLE TIMES HAVE ALL BUT CRASHED RELATED TO CAN'T HARDLY STEER IT, TURN IT, I THINK I'VE BROKE MY SHOULDER WITH THIS THING. NOW I CATCH A RIDE WITH 4 YEARS TO PAY LEFT ON THIS CAR, HELP! ITS A HAZARD, I DON'T HAVE GOLIATHS STRENGTH ANY MORE! *TR

Mileage: 60,000

TRANSMISSION WOULD NOT LOCK WHEN PUT IN PARK AND COULD NOT GET KEY OUT OF IGNITION. LEFT CAR IN GARAGE OVERNIGHT AND NEXT MORNING BATTERY WAS DEAD. HAD TO JUMP START CAR AND DROVE IT TO GM DEALER. SERVICE TECH SAID SHIFTER NEEDED TO BE REPLACED AND THAT HE HAD SEEN THIS HAPPEN BEFORE. TECH SAID GM HAD REDESIGNED THE SHIFTER BECAUSE OF THIS PROBLEM. A FEW HOURS AND $241 LATER, CAR WAS REPAIRED AND BACK ON THE ROAD. *TR

Mileage: 45

2006 CHEVY HHR, KEY WOULD NOT TURN OFF IN IGNITION SWITCH. READ OWNERS BOOK FOUND LITTLE DOORWAY TO OPEN WITH BUTTON TO BYPASS PARKING SWITCH. BOOK SAID LOW VOLTAGE, CHECKED VOLTAGE WAS FINE, BUT COULD WIGGLE GEAR SHIFT AND KEY WOULD TURN OFF. NOW BUTTON ON GEARSHIFT STAYS IN AND EVEN WITH KEY OUT OF IGNITION IF YOU BUMP THE GEARSHIFT IT FALLS OUT OF PARK. NOT A REAL SAFE FEATURE WITH REMOTE STARTING. HAVE CONTACTED CHEVROLET AND THEY SAY THEY ARE NOT AWARE OF THIS SAFETY PROBLEM. BUT IS RAMPANT ON THE INTERNET, AND MY PERSONAL DEALER SAID THEY HAVE HAD TO FIX A LOT OF HHR'S AND COBALT GEARSHIFTS. SO MANY IN FACT THAT THEY HAVE MADE A NEW AND IMPROVED PART BECAUSE OF THE ORIGINAL FAILING MULTIPLE TIMES. THAT IS FINE FOR THE VEHICLES IN WARRANTY, BUT THE OTHER THOUSANDS UPON THOUSANDS OF ONES THEY WONT FIX BECAUSE THEY SAID THERE IS NO RECALL AS OF NOW. THIS IS ABOUT LIKE THE FORDS OF THE SEVENTIES. I AM AFRAID SOMEONE WILL BE INJURED BEFORE IT IS RESOLVED. *TR

Mileage: 52,000

PLACED VEHICLE IN PARK AND THE KEY WOULD NOT TURN ALL THE WAY OFF AND YOU COULD NOT REMOVE THE KEY. IT HAPPENED TWICE AND I TOOK IT TO THE DEALER AND THEY REPLACED THE SHIFTER. THEY STATED THAT THEY HAVE HAD SEVERAL COMPLAINTS FROM OTHER OWNERS OF HHRS AND COLBALTS WITH THE SAME PROBLEM. *TR

Mileage: 49,252

WHILE DRIVING MY 2006 CHEVROLET HHR LS TRAVELING AT BETWEEN 25-30 MPH THE DRIVER INFORMATION CENTER DISPLAY FLASHED "REDUCED ENGINE POWER" FOR ABOUT FIVE SECONDS AND THEN CHANGED TO "ENGINE DISABLED" AND IMMEDIATELY SHUT THE CAR DOWN WHILE I WAS DRIVING IN THE MIDDLE OF THE ROAD. I TRIED TO RESTART THE ENGINE AND IT WOULD NOT INITIALLY START. AFTER SEVERAL MINUTES THE CAR DID START AND THE CHECK ENGINE LIGHT WAS ON. I PROCEEDED IMMEDIATELY TO MY SERVICE STATION WHERE THEY WERE ABLE TO FIND THE CHECK ENGINE CODE AS "PCM MEMORY ERROR" THEY SAID THE CODE WAS SOMETHING THEY HAD NEVER SEEN BEFORE AND DECIDED THAT IT WAS BEST TO CLEAR THE CODE AND SEE IF THE PROBLEM REPEATED ITSELF. I THEN TOOK THE CAR FOR SHORT DRIVE AND AGAIN THE CAR FLASHED THE SAME TWO MESSAGES ON THE DIC AND THEN STALLED BUT THIS TIME IN THE MIDDLE OF A ROTARY. I WAS ABLE TO PUSH THE CAR OFF TO THE SIDE AND WAITED SEVERAL MINUTES AGAIN BEFORE THE CAR WOULD RESTART. THIS TIME AT THE SERVICE STATION THEY DECIDED IT WOULD BE BEST IF I TOOK IT TO AN ACTUAL CHEVROLET GARAGE SINCE THEY HAD NEVER SEEN SUCH AN OBD-II ERROR CODE. THIS TIME HOWEVER AFTER CLEARING THE CODE IT WOULD NOT DRIVE MORE THAN A FEW YARDS BEFORE STALLING OUT. SO, THE DECISION WAS MADE TO HAVE THE CAR TOWED AFTER HAVE THE CAR FOR A FEW DAYS THEY DECIDED THAT IT WAS BEST TO REPLACE THE PCM SINCE THAT SEEMED TO BE WHAT WAS CAUSING THE ERROR. THE WAY THE CAR BEHAVED WITH THIS PCM ERROR I FELT WAS VERY DANGEROUS SO I CONTACTED CHEVROLET CUSTOMER SUPPORT ON JULY 21, 2008. THE CASE NUMBER IS 71-646640348 WITH CHEVROLET. THE INITIAL CONTACT PERSON WAS UNABLE TO ANSWER MY CONCERNS. LATER THAT AFTERNOON I WAS CALLED BY ANOTHER INDIVIDUAL ABOUT THE ISSUE AND THE OPINION THAT I GOT FROM HER WAS THAT "I SHOULD HAVE NOTHING TO COMPLAIN ABOUT, GM WAS REPAIRING THE CAR FOR FREE UNDER THE EPA MANDATED WARRANTY" SHE DID NOT UNDERSTAND THAT MY CONCERN WAS NOT THAT THE CAR DID HAVE A PART FAIL BUT HOW IT BEHAVED WHEN SUCH A MINOR PIECE OF EQUIPMENT DID FAIL. *TR

Mileage: 61,800

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 20 MPH OVER A HOLE OR DIP IN THE ROAD, THE ENTIRE VEHICLE STALLED AND SHUT OFF. THE WEATHER WAS NOT A FACTOR. THE STALLING OCCURRED AT LEAST THREE TIMES WITHIN ONE WEEK. THE VEHICLE CANNOT BE RESTARTED ONCE IT SHUT OFF. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE DEALER DOES NOT KNOW THE CAUSE OF THE FAILURE OR THE REMEDY. THE FAILURE MILEAGE WAS 53,000. THE CONSUMER STATED THE VEHICLE WAS HAVING SEVERAL ISSUES WITH THE CAM SENSOR, WHEELS, A BROKEN HUB BEARING, BENT ROTORS AND AN ISSUE WITH REMOVING THE KEY FROM THE IGNITION, DUE TO THE SHIFT CABLE NOT STAYING SECURED. THE CHECK ENGINE LIGHT ILLUMINATED, THE INSIDE DRIVER DOOR HANDLE WOULD NOT OPEN THE DOOR, THE PASSENGER SIDE BACK WOULD NOT STAY SECURED. UPDATED 06/25/08

Mileage: 30,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STARTED THE ENGINE TO WARM UP THE VEHICLE. APPROXIMATELY FIVE MINUTES LATER, SHE ATTEMPTED TO PLACE THE VEHICLE IN REVERSE, BUT THE SHIFTER WOULD NOT MOVE FROM PARK. SHE WAITED APPROXIMATELY TEN MINUTES AND THE FAILURE CONTINUED. APPROXIMATELY 15 MINUTES LATER, THE GEAR WAS ABLE TO SHIFT OUT OF PARK. THE CONTACT DROVE TO WORK AND WAS UNABLE TO SHUT OFF THE VEHICLE. AFTER SEVERAL ATTEMPTS, SHE WAS ABLE TO REMOVE THE KEY FROM THE IGNITION; HOWEVER, THE RADIO WAS STILL ON AND THE CHIME NOISES REMAINED ENGAGED. THE GEARS WERE ALSO ABLE TO BE MOVED WITHOUT THE KEY IN THE IGNITION. THE VEHICLE HAS NOT BEEN REPAIRED AND REMAINS IN HER POSSESSION. THE VIN, ENGINE SIZE, NUMBER OF CYLINDERS, AND TRANSMISSION TYPE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 36,000.

Mileage: 36,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT COULD NOT REMOVE THE KEY FROM THE IGNITION. SHE STATED THAT THE VEHICLE DID NOT SEEM TO PROPERLY SHIFT INTO PARK. THE VEHICLE HAS NOT BEEN TO THE DEALER OR REPAIRED. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE WAS 32,000 AND FAILURE MILEAGE WAS 31,000.

Mileage: 31,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. THE GEAR MECHANISM FAILED. HE HAS ATTEMPTED TO PLACE THE GEAR POSITION INDICATOR IN THE PARK POSITION AND THE ENGINE WILL NOT SHUT OFF. THIS FAILURE CAN CAUSE THE VEHICLE TO SHIFT OUT OF GEAR ON ITS ON WITH OR WITHOUT THE DRIVER PRESENT. THE DEALER STATED THAT IT WAS A COMMON PROBLEM. THE CURRENT AND FAILURE MILEAGES WERE 39000.****

Mileage: 39,000

TL*THE CONTACT'S SPOUSE OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE GEAR SHIFT WOULD OCCASIONALLY STICK OR SHIFT INTO ANY GEAR WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER AND THE NEW PART HAS BEEN ORDERED. THE CURRENT MILEAGE WAS 11,400 AND FAILURE MILEAGE WAS 11,000.

Mileage: 11,000

AT 5,00 MILES THE SEAL ON THE TRANSMISSION BLEW. CAR TAKEN TO DEALERSHIP FOR REPAIR. SINCE THAT TIME THERE HAS BEEN A NOISE WHEN ACCELERATING. DEALER TRIED REPLACING CATALYTIC CONVERTER, WAS NOT THE PROBLEM. MANUFACTURER NOTIFIED OF ON GOING PROBLEM, THEY SENT A REP WHO SAID THE NOISE WAS A USUAL NOISE. SERVICE MANAGER REQUESTED A SECOND OPINION FROM MANUFACTURE. CAR NOW HAS 14,500 MILES ON IT AND HAS BEEN BACK TO THE DEALER FOR THIS SAME PROBLEM NUMEROUS TIMES. AS OF THIS DATE WE ARE STILL WAITING FOR ANOTHER REP TO LOOK AT IT. *JB

Mileage: 5,000