2006 CHEVROLET HHR Service Brakes, Hydraulic Problems

The contact owns a 2006 Chevrolet HHR. The contact stated while starting the vehicle, the low unknown fluid warning light was illuminated. The contact checked the fluid levels and the fluid levels were at full. After a couple of days the contact restarted the vehicle and the warning light was off. The contact was concerned that there might be an issue with brake fluid not flowing through the brake lines as designed which could cause the brakes to not work properly. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was 160,000.

Mileage: 160,000

2006 CHEVROLET HHR. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL AND POWER STEERING AND OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED TWO DAYS AFTER GETTING THE VEHICLE BACK FROM THE DEALER, THE VEHICLE HAD TO BE FLAT-BEDDED BACK TO THE DEALER, BECAUSE IT WOULDN'T START. IT WAS DETERMINED THE IGNITION SWITCH NEEDED TO BE REPLACED. ALSO, THE RIGHT PASSENGER OUTSIDE MIRROR FELL OFF, THE RIGHT PASSENGER WIPER ARM BROKE, THE ROTORS WERE REPLACED TWICE IN TWO YEARS, AND THE REAR SHOCKS WERE REPLACED.*JB

FUEL LEAK IN FRONT OF DRIVERS SIDE REAR WHEEL. THIS IS COMPLETELY UNACCEPTABLE IN AN 8 YEAR OLD VEHICLE. THE FUEL LINE CORRODED AND LEAKED HEAVILY, COST ME $254.22 TO REPLACE THIS FAULTY GAS LINE. I AM OBVIOUSLY NOT THE ONLY PERSON THIS HAS HAPPENED TO. I HAVE ALSO HAD ALL THE OTHER TYPICAL PROBLEMS SUCH AS THE KEY WILL NOT RELEASE FROM IGNITION, BAD ROTORS, LOOSE FRONT END BUSHINGS AND EXCESSIVE FRONT END VIBRATION OVER TYPICAL STREET CRACKS. BROKEN DRIVERS SIDE INTERIOR DOOR HANDLE, CRACKED WINDSHIELD...... *TR UPDATED 10/22/2014 *JS

Mileage: 180,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 55 MPH AND LIGHTLY DEPRESSING THE BRAKES, THE BRAKES DID NOT RESPOND. THE VEHICLE WOULD NOT STOP AND THE CONTACT STEERED THE VEHICLE ONTO GRASS AND CONTINUED TO DEPRESS THE BRAKES, BUT TO NO AVAIL. THE VEHICLE DID NOT COME TO A STOP UNTIL CRASHING INTO A TREE. THE CONTACT SUSTAINED A FRACTURED ANKLE AND THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGES WERE 44,000.

Mileage: 44,000

I BOUGHT MY HHR IN APRIL 1006. THE CAR HAD APPROXIMATELY 5,000 MILES WHEN I PURCHASED THE VEHICLE. THAT FALL, IN SEPTEMBER 2006, THE BRAKES BEGAN TO SHUDDER EVERY TIME I APPLIED THEM. I TOOK THE VEHICLE TO MY MECHANIC AND HE SAID THE ROTORS NEEDED TO BE GROUND AND TURNED. HE DID THIS AND THE VEHICLE WAS FINE UNTIL THE NEXT SUMMER (2007) WHEN IT BEGAN TO SHUDDER AGAIN. I TOOK THE VEHICLE IN AND HAD THE BRAKES CHECKED. THIS TIME I HAD TO HAVE BOTH THE PADS AND THE ROTORS REPLACED. IN FALL 2008, HE VEHICLE BEGAN TO SHUDDER AGAIN. I TOOK THE CAR IN AND THE ROTORS ONE AGAIN NEEDED TO BE GROUND AND TURNED AND ONE SHOCK WAS LEAKING. I STOPPED DRIVING THE CAR EVERY DAY AND ALTERNATELY DROVE MY PICKUP AND THE BRAKES LASTED BEYOND THE ONE YEAR MARK. HOWEVER, IN 2010, THE BRAKES BEGAN TO SHUDDER AGAIN AND I HAD TO TAKE THE CAR IN AND HAVE THE ROTORS GROUND AND TURNED AGAIN. IT IS NOW MARCH 2012 AND HE BRAKES ARE BAD AGAIN. I DO NOT DRIVE THE CAR IN THE SUMMER BECAUSE THE WARM WEATHER SEEMS TO MAKE THE PROBLEM WORSE. ALSO, BECAUSE OF THE BRAKE ISSUE, I HAVE HAD TO PUT TWO NEW SETS OF TIRES ON THE VEHICLE DUE TO ABNORMAL WEAR. I WOULD LIKE TO ADD THAT I DO NOT SPEED AND DO NOT BRAKE QUICKLY OR RIDE THE BRAKES. *TR

Mileage: 6,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT WAS EXCITING THE VEHICLE WHEN THE INTERIOR DRIVER'S SIDE DOOR HANDLE DETACHED. THE CONTACT ALSO STATED THAT ON A SEPARATE OCCASION WHILE DRIVING 40 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. IN ADDITION, THE FRONT END OF THE VEHICLE WOULD SHAKE ABNORMALLY WHEN THE BRAKES WERE DEPRESSED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO CONFIRMED THAT INSIDE DOOR ASSEMBLY FAILED AND NEEDED TO BE REPLACED ALONG WITH BOTH SIDE FRONT ROTORS. THE MANUFACTURER WAS CONTACTED AND CONFIRMED TO THE CONTACT THAT THE VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 08V046000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 46,000 AND THE CURRENT MILEAGE WAS 89,000.

Mileage: 46,000

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKES WAS DEPRESSED AND THE PEDAL WENT TO THE FLOORBOARD ABNORMALLY. THE FAILURE CAUSED THE DRIVER TO CRASH INTO ANOTHER VEHICLE FROM THE REAR. THE CONTACT STATED THAT THE AIR BAGS DID NOT DEPLOY AND THE DRIVER WAS INJURED. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND DEEMED AS DESTROYED. THE POLICE STATED THAT THE AIR BAGS SHOULD HAVE DEPLOYED AND THE INSURANCE COMPANY PLANNED TO INSPECT THE VEHICLE. THE FAILURE AND THE CURRENT MILEAGE WAS 106,000.

Mileage: 106,000

BRAKE PEDAL ASSEMBLY: AT THE UPPER BRAKE PEDAL, AT THE CROSS TUBE THERE WAS A DEFECTIVE WELD, ONLY WELDED ON ONE SIDE AND THE WELD DID NOT ADHERE TO CROSS BAR. THE WELD DID NOT PENETRATE METAL, CAUSING THE PEDAL TO SLIDE TO THE LEFT. *KB

Mileage: 82,000

I AM SCARED, FOR MY FAMILY'S SAFETY FEAR THAT THIS VEHICLE WILL STALL AND WE WILL CRASH OR BE HIT BY SOME ONE...WHEN A VEHICLE STALLS YOU LOOSE ALL POWER...THAT IS POWER STEERING, BRAKES.....THE ABILITY TO MAINTAIN CONTROL OF YOUR VEHICLE I AM ATTACHING A LINK THAT GM SHOULD REVIEW.....DANGER THIS VEHICLE IS AN ACCIDENT WAITING TO HAPPEN !!!!!!!!!!!!! COPY THIS LINK TO YOUR WEB BROWSER HTTP-//ABCLOCAL.GO.COM/WTVD/STORY?SECTION=NEWS/ABC11_INVESTIGATES&ID=6811236 IF YOU WOULD PREFER I CAN SEND A TYPED TRANSCRIPT (WORD FOR WORD) OF THIS NEWS BROADCAST? I WILL NOT ALLOW MY WIFE AND KIDS LIFE TO BE PUT IN DANGER, BY LETTING THEM RIDE IN THIS VEHICLE THIS VEHICLE IS UNSAFE AND SHOULD BE RECALLED THE LINK I AM ATTACHING SHOWS A NEWS BROADCAST IN RALEIGH NC. ON CHANNEL 11 NEWS !!!!! INVOLVING NUMBER 12 ISSUE ON MY LONG LIST BELOW WITH THE CHEVY HHR STALLING WHILE DRIVING..... I PURCHASED A 2006 CHEVY HHR LT, IN 2007. SINCE I HAVE PURCHASED THIS VEHICLE THE FOLLOWING ISSUES HAVE OCCURRED. MILEAGE ON CAR 33,346 1) THE KEY LOCKED UP IN IGNITION..9/06/07 2) SHIFTER FROZE UP AND WOULD NOT COME OUT OF PARK. . 9/06/07 3) HEADLINER TRIM ? ENERGY ABSORPTION CAPABILITY 4) FRONT END AND WHOLE CAR STARTED TO SHAKE WHEN APPLYING BRAKE..9/06/07 DEALER TURNED ROTORS( BUT DID NOT FIX ISSUE) 5) REPLACED DRIVER SIDE RUNNING BOARD..9/06/07. 6) GOT IN VEHICLE ONE MORNING TRIED TO TAKE KIDS TO SCHOOL, VEHICLE WOULD NOT GO OVER 15 MPH, HAD TOWED BACK TO LAWSON CHEVROLET. WORKING ON GETTING DATE/MILEAGE..THIS ISSUE OCCURRED TWICE BEFORE. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC BECAUSE OF A VIBRATION AND SHAKING THAT OCCURRED WHENEVER THE BRAKES WERE APPLIED. THE MECHANIC TURNED THE ROTORS AND REPLACED THE BRAKE PADS. THE FAILURE RECURRED WITHIN SIX MONTHS IN ADDITION TO AN ABNORMAL GRINDING NOISE EXHIBITED BY THE BRAKES. THE VEHICLE WAS NOT INSPECTED OF FURTHER REPAIRED. THE FAILURE MILEAGE WAS 79,000 AND THE CURRENT MILEAGE WAS 85,000. UPDATED 06/17/11*LJ UPDATED 06/21/11

Mileage: 79,000

2006 CHEVROLET HHR. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE *TGW THE CONSUMER STATED HIS SONS VEHICLE HAD A SEVERE SHIMMY IN THE STEERING WHEEL AND BECAME PROGRESSIVELY WORSE WHEN THE BRAKE WAS APPLIED. THE PADS AND ROTORS WERE REPLACED TWICE AND THE THIRD TIME THE ROTORS WERE MACHINED, BUT THE PROBLEM CONTINUED. THERE WAS ALSO A STRANGE NOISE COMING FROM THE FRONT SUSPENSION, BUT THE DEALER WAS UNABLE TO PINPOINT THE PROBLEM. AT 42,000 MILES THE AIR CONDITION MADE A LOUD SCREECHING NOISE FOR 2 MINUTES, THEN STOPPED WORKING. AT 68,000 MILES, A METAL SKID PLATE HAD FALLEN FROM UNDERNEATH THE VEHICLE. SOON AFTER, THE EXHAUST WAS VERY LOUD. THE VEHICLE WAS TAKEN TO THE REPAIR SHOP AND THE CONSUMER WAS INFORMED THE CATALYTIC CONVERTER HAD CRACKED. THE VEHICLE LOST POWER AND A CYLINDER HAD TO BE REPLACED, THE CHECK ENGINE LIGHT WOULD COME ON AND THEN GO OFF, THE TEMPERATURE GAUGE DID NOT WORK, SO THE AIR CONDITION ONLY WORKED IF THE CHECK ENGINE LIGHT WAS OFF. THE DOOR LOCKS DID NOT WORK, THE RADIO WORKED INTERMITTENTLY, THE SUN VISOR WOULD FALL DOWN AT RANDOM TIMES. THERE WERE TIMES WHEN THE VEHICLE WOULD NOT START. THE CONSUMER STATED EVEN WITH AN ALIGNMENT, NEW STRUTS, SHOCKS AND GOOD TIRES, THE VEHICLE CONTINUALLY PULLED TO THE RIGHT. *JB

Mileage: 38,000

I HAVE A 2006 CHEVY HHR LT WITH JUST 30K. DROVE IT OFF THE LOT WITH 3 MILES AND AT 200 MILES IT HAD THE ROTORS TURNED FOR THE FIRST OF ABOUT 30 TIMES. THE STEERING WHEEL SHUDDERS WHEN BREAKING OR AT SPEEDS ABOVE 45 MPH SO MUCH SO THAT AT TIMES THE CAR IS HARD TO CONTROL. THE ANSWER TO THIS VERY DANGEROUS PROBLEM IS..TURN THE ROTORS. "NORMAL WEAR AND TEAR" THIS IS NOT ACCEPTABLE TO ME ANYMORE. MY CAR HAS HAD ISSUES WITH THE SHOCKS,THE STRUTS, THE CONTINUED ROTOR PROBLEM, THE STEERING WHEEL THAT SHUDDERS, AND AS OF TODAY, THE POWER STEERING IS GOING AS WELL AS THE STEERING RACK. THE POTENTIAL OF ME KILLING MYSELF,MY CHILDREN, OR THE PERSON NEXT TO ME HAS BECOME A REALITY. I HAVE COMPLAINED SINCE PRACTICALLY DRIVING IT OFF THE LOT. GM JUST REFUSES TO PAY, OR DO ANYTHING ABOUT THIS. I HAVE BEEN IN TOUCH WITH THE CEO OF GM AS WELL AS THE NORTH AMERICA PRESIDENT MARK REUSS I HAVE EXPRESSED MY CONCERNS WITH THE SAFETY OF THE HHR. AND I HAVE SAID THAT THE ANSWER IS NOT TO "JUST TURN THE ROTORS FOR THE 35TH TIME". THERE IS SOMETHING VERY WRONG WITH THIS CAR, AND IT SEEMS AS THOUGH EVERYONE THAT DRIVES ONE HAS THE SAME POWER STEERING,ROTOR,AT THE SHUDDER OF THE STEERING WHEEL. I HAVE PLUNKED NEARLY 2K INTO A CAR THAT GM NEEDS TO BE RESPONSIBLE FOR. AN URGENT RECALL NEEDS TO BE ISSUED OR I SEE THE POTENTIAL OF A TOYOTA PROBLEM ON THE HORIZON FOR GM AND THEIR CHEVY HHR. I REALLY BELIEVE IT IS GOING TO TAKE SOMEONE OR MAYBE MANY TO BE INJURED OR WORSE YET DEAD BEFORE GM WILL LOOK INTO THIS FURTHER. THE WORLD HEADQUARTERS TOLD ME YESTERDAY THAT THERE ARE NO OTHER COMPLAINTS LIKE MINE AND I SHOULDN'T BELIEVE WHAT I READ. THEY HAVE CLOSED MY CASE AND REFUSE TO LISTEN ANY LONGER. I KNOW THIS IS NOT MY DRIVING, I AM NOT HARD ON THE BRAKES, NOR HAVE I CAUSED THE ROTORS NEEDING TO BE TURNED SO MANY TIMES ON THE LATHE THAT THEY ARE LIKE PUTTING BICYCLE BRAKES ON A FREIGHT TRAIN. CAR IS A BIT TOO HEAVY TO STOP WHEN YOU HAVE ROTORS THAT ARE DANGEROUSLY THIN. *TR

Mileage: 200

TL* THE CONTACT OWNS A 2006 CHEVROLET HHR. THE CONTACT STATED UPON INITIAL START, THE BRAKE PEDAL WOULD FALL FURTHER INTO THE FLOORBOARD THAN NORMAL. WHEN THE FAILURE WOULD OCCUR, THE ABS AND TRACTION WARNING LIGHT WOULD ILLUMINATE. THE DEALER ADVISED THE FAILURE WAS ATTRIBUTABLE TO THE STEERING AND REPLACED THE STEERING COLUMN BEARING. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO A SECOND DEALER WHERE THE FRONT HUB BEARING ASSEMBLY WAS REPLACED. THE FAILURE SEEMED TO HAVE BEEN REPAIRED HOWEVER, THE WARNING LIGHTS WOULD CONTINUE TO ILLUMINATE INTERMITTENTLY. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 75,084 AND THE CURRENT MILEAGE WAS 80,000.

Mileage: 75,084

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING AT 35 MPH, THE CONTACT STATED THAT THE BRAKES WOULD NOT ENGAGE, CAUSING THE STEERING WHEEL TO SHAKE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT CALLED THE AUTHORIZED DEALERSHIP AND WAS ADVISED THAT THEY WOULD REPAIR THE VEHICLE. THE CURRENT MILEAGE WAS APPROXIMATELY 67,000. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

Mileage: 60,000

I OWN A 2006 CHEVY HHR LT2, IT HAS APPROX. 52K MILES, AND A RATTLE, VIBRATION IN THE STEERING COLUMN HAS BEEN OCCURRING AT SPEEDS BELOW 45MPH. ALSO, THE DRIVER SIDE FLOOR IS CONTINUING TO FLOOD WITH WATER, AND THE HEATER/AC BLOWER HAS FAILED OR SHORTED OUT. LASTLY, I HAVE HAD THE BRAKE ROTORS WORKED ON 4 TIMES BY CHEVY, AND THEY ARE NOW ONCE AGAIN IN NEED OF REPAIR. I RECENTLY TOOK MY VEHICLE BACK TO THE DEALER FOR THE RATTLE IN THE STEERING AND THE WATER LEAK. I FOUND NUMEROUS TSB ARTICLES FOR THE ISSUES, BUT THE DEALER AND GM ARE CLAIMING THE TSBS DO NOT EXIST. THE REPAIRS WILL TOTAL MORE THAN $1100. I WAS TOLD THE BUSHINGS, AND TENSION RODS ARE THE PROBLEM WITH MY STEERING, AND THEY WOULD NEED TO BE REPLACED. AT 52K MILES I FIND IT HARD TO BELIEVE THESE ITEMS WOULD FAIL.. MY MAJOR CONCERN IS MY SAFETY RELATED TO THE STEERING AS WELL AS ANY POSSIBLE ELECTRICAL ISSUE STEMMING FROM THE WATER LEAK.. I DO NOT UNDERSTAND WHY GM HAS NOT ISSUED A RECALL FOR THE STEERING ISSUE AS WELL AS FOR THE BRAKE ROTORS. IF YOU GO TO ANY VEHICLE COMPLAINT WEB SITE FOR THE HHR YOU WILL SEE 100'S OF POSTINGS RELATED TO BAD BRAKES. THERE ARE ALSO SIMILAR COMPLAINTS PERTAINING TO THE STEERING. THE DEALERSHIP REFUSED TO HONOR OR COMPROMISE WITH REGARDS TO PERFORMING THE REPAIRS FOR FREE OR FOR A REDUCED FEE. I CONTACTED GM CORPORATE AND FILED A COMPLAINT. I WAS TOLD THE GM DISTRICT MANAGER WOULD CONTACT ME. I AM STILL WAITING. *TR

Mileage: 52,000

MY 2006 HHR VIBRATES VIOLENTLY WHEN THE BRAKES ARE APPLIED. I'VE HAD THIS PROBLEM CHECKED NUMEROUS TIMES FROM APPROXIMATELY 12000 MILES ON. I AM CURRENTLY AT 55000. AFTER INSPECTIONS I WAS ADVISED NOTHING WAS WRONG WITH MY BRAKES. I WAS TOLD THE MATERIALS USED FOR THE BRAKES HEATS SO RAPIDLY THAT IT COULD CAUSE IT. I QUESTIONED ABOUT THE MATERIALS USED AND IT WAS EXPLAINED TO ME THAT IT WAS TO KEEP THE WEIGHT LOW ON THE VEHICLE FOR GAS MILEAGE. YESTERDAY I WAS RETURNING HOME FROM WORK WHICH I HAVE TO TRAVEL A LONG GRADE. I SHIFTED TO A LOWER GEAR TO REDUCE SPEED GOING DOWN THE GRADE, I PRESSED ON THE BREAKS AND THE VEHICLE SHOOK SO VIOLENTLY I ENDED UP TRYING TO USE THE EMERGENCY HAND BREAK IN ORDER TO GAIN CONTROL OF THE VEHICLE. MY SPEED WAS APPROXIMATELY 52 MILES PER HOUR. I HAVE HAD NUMEROUS PROBLEMS WITH THIS VEHICLE AND HAVE AN EXTENSIVE WARRANTY REPAIR RECORD ON IT INCLUDING A FIRE. I FIND THIS VEHICLE IS EXTREMELY UNSAFE ESPECIALLY WITH THE BRAKING PROBLEMS. *TR

Mileage: 12,000

2006 CHEVY HHR LT 2.4 LITER - RATTLE WHEN GOING OVER BUMPS AND VIBRATION WHEN BRAKING. JUST PAST 36000 MILE WARRANTY. CONTACTED CHEVY CUSTOMER SERVICE-REQUESTED TAKING VEHICLE TO DEALER. DEALER STATES PROBLEMS WITH LOWER CONTROL ARM, STRUT STABILIZERS, BRAKE ROTORS. DEALER WAITING ON AUTHORIZATION FROM CHEVY CUSTOMER SERVICE. CHEVY CUSTOMER SERVICE SAYS CONTACT THEM IF DEALER WON'T COMPLETE REPAIRS UNDER WARRANTY. AT PRESENT VEHICLE IS STILL AT DEALER AND NO ONE HAS CONTACTED ME WITH ANY TYPE OF RESOLUTION. NOTE - VEHICLE RIDES WELL AND TIRES SHOW NO UNUSUAL OR UNEVEN WEAR. *TR

Mileage: 36,420

2006 CHEVY HHR. AT 30,000 THE FRONT END SHAKES WHILE BRAKING. REPLACED ROTORS AND BRAKE PADS WITH NEW FROM NATIONAL AUTO PARTS RETAILER. SHAKING STILL OCCURS. DANGEROUS, AFFECTS STEERING AND ABILITY TO STOP. ROTORS CHECKED FOR TRUENESS AND THEY ARE PERFECT WITH NO WARPAGE. DEALERSHIP IS NO HELP. THIS IS WORSE AT SPEEDS ABOVE 40 MPH, COLD OR HOT BRAKES. *TR

Mileage: 30,000

I BOUGHT MY HHR EXACTLY ONE YEAR AGO. THIS IS MY FIRST CAR SO I HAVE NO GENERAL KNOWLEDGE ABOUT VEHICLES. I BOUGHT THE VEHICLE USED WITH 31,000 MILES ON IT. IT CURRENTLY HAS 58,000 MILES ON IT SO I AM NOT COVERED FOR A WARRANTY. AT FIRST I NOTICED A VIBRATING WHEN EXITING A HIGHWAY OR DECELERATING WITH MY BRAKES. THE STEERING SHOOK VIOLENTLY. ALSO WHEN DRIVING THE STEERING WHEEL IS HARD TO CONTROL AND THE CAR SEEMS TO VEER SEVERELY TO THE RIGHT AND WITH SHEER FORCE I HAVE TO USE BOTH HANDS TO CONTROL IT. RECENTLY THAT HAS INCREASED DRAMATICALLY, EVEN AT SPEEDS OF 30MPH. I TOOK THE CAR TO GET THE BRAKES INSPECTED AND THEY TOLD ME THE BRAKES NEEDED TO BE REPLACED AND THE ROTORS WERE WARPED AND NEEDED TO BE REPLACED, NOT RESURFACED WHICH OTHERS HAVE SAID THAT IS UNUSUAL SINCE THE VEHICLE IS STILL FAIRLY NEW. THE MECHANIC ALSO TOLD ME THAT MY FRONT STRUTS ARE LEAKING AND NEED TO BE REPLACED. I HAVE ALSO NOTICED THAT WHEN I AM DRIVING THE CAR TENDS TO SHAKE/VIBRATE AND MAKE STRANGE NOISES. THE KEY GETS STUCK IN THE IGNITION UPON TURNING THE ENGINE OFF. THERE ARE TIMES I HAVE HAD TO RESTART MY CAR UP TO 8 TIMES JUST TO GET THE KEY OUT OF THE IGNITION. *TR

MY BRAKES SHIMMIED/ VIBRATED BADLY WHEN MY HHR HAD 14300 MILES, FERRIS CHEVROLET DEALERSHIP TURNED, GROUND, THE ROTORS TO REPAIR THE PROBLEM ON 07/30/07 AT THE SAME TIME THE HEATER/AC FAN SWITCH WAS REPAIRED ON 9/28/08 WITH 28365 MILES ON MY HHR THE SAME PROBLEM WAS REPAIRED AT THE DEALERSHIP, THE BRAKES SHOULD NOT SHIMMY AND NEED REPAIRING EVERY 14000 MILES, THIS NEED TO BE CORRECTED WITH NEW IMPROVED ROTORS BEFORE THEIR IS A TOTAL BRAKE FAILURE WE PLAN ON KEEPING THIS CAR FOR A LONG TIME, WHO IS GOING TO PAY TO FIX THIS!AT THE SAME TIME THE HEATER/AC FAN SWITCH WAS REPAIRED AND THE FAN MOTOR WAS REPLACED, WE WERE TOLD WATER LEAKS ON THE FAN, WE HAVE HAD WATER LEAK THRU THE HEATER VENTS BEFORE. *TR

Mileage: 14,300

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING APPROXIMATELY 35 MPH IN RAINY CONDITIONS, THE STEERING WHEEL VIBRATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE ALSO PULLED EXCESSIVELY TOWARDS THE LEFT. THE ABS WAS NOT OPERATING NORMALLY AND LOCKED UP. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE FAILURE RECURRED ON A SEPARATE OCCASION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE ROTORS OVERHEATED. THE VEHICLE WAS REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 8,900 AND CURRENT MILEAGE WAS 11,260.

Mileage: 8,900

WITHIN THE FIRST 2,000 MILES OF DELIVERY THIS CAR DEVELOPED A SHIMMY IN THE FRONT END OF THE CAR. THIS OCCURRED WHEN DECELERATING AND COASTING AND WHEN ONE APPLIED THE BRAKE AS WELL. THERE WAS ALSO A HESITATION IN THE CAR AT THE SAME TIME AND THIS MAY HAVE BEEN RELATED, BUT THAT PROBLEM EVENTUALLY DISAPPEARED. I DID HAVE THE TIRES REBALANCED BUT THIS DID NOT CHANGE THE VIBRATION PROBLEM AND I TOOK THE CAR BACK TO THE DEALER MANY TIMES TO TRY TO DETERMINE THE CAUSE OF THIS PROBLEM. EVERY TIME THE SERVICE AREA CONCENTRATED ON BRAKES. THEY RE-GROUND THE ROTORS, REPLACED BRAKE PADS, CALIPERS AND SOMETIMES THIS DID IMPROVE THE SITUATION FOR PERHAPS 30 DAYS BUT WITHIN A SHORT PERIOD OF TIME THE SAME PROBLEM WOULD REDEVELOP. THEY COMPLAINED THAT THE TIRES SHOULD BE REBALANCED AGAIN...I DID THAT AT THE DEALERSHIP SO THE SERVICE PEOPLE COULD NOT OFF-LOAD THE RESPONSIBILITY OF THE WORK. NO HELP. AT THE MOST RECENT SERVICE REPLACED THE BRAKES AGAIN, NOT OUT OF CONCERN FOR THE REPETITIVE PROBLEM, BUT JUST CHARGED ME THE NORMAL SERVICING AS A WEAR ITEM. WHEN I GOT THE CAR BACK, AGAIN, THE SHIMMY PROBLEM WAS GONE...ALMOST. THERE IS STILL EVIDENCE OF A MINOR SHIMMY IN THE FRONT END AND THIS IS HOW IT ALWAYS DEVELOPS. I WENT BACK TO THE DEALER AND NOTED THAT WE WERE TAKING THE CAR ON VACATION BUT THAT I WANTED TO DOCUMENT THE PROBLEM AGAIN IN THE EVENT WE HAD TO HAVE SERVICE IN A REMOTE LOCATION. THE DEALER AGAIN SERVICED THE BRAKES AND I LEFT ON VACATION TO SAN DIEGO. THE PROBLEM AGAIN APPEARED AND WE DECIDED TO NOT DRIVE THIS CAR BACK CROSS-COUNTRY AND IT REMAINS IN SAN DIEGO AND NO USE TO ME WHATEVER. MY SPOUSE WILL NOT ENTER THE CAR BECAUSE SHE FEARS THE FRONT-END WILL COLLAPSE. I AGREE WITH HER. *TR

Mileage: 2,485

BOUGHT CHEVY HHR W/ @23,000 MILES AT @32,000 EXPERIENCED SEVERE FRONT END SHAKING WHILE BRAKING. DEALER ACKNOWLEDGE ISSUE AS WARRANTY REPAIR AND SURFACED ROTORS. CAR EXHIBITED SAME ISSUE AT @45,000 MILES. IT IS OBVIOUS BY REVIEWING THESE FEW SOURCES (THERE MANY MORE) THAT CHEVY IS DENYING THE USE OF INFERIOR ROTORS. HTTP://WWW.CHEVYHHR.NET/FORUMS/ARCHIVE/INDEX.PHP?T-2768.HTML HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F113FCD HTTP://BLOGS.CARS.COM/KICKINGTIRES/2008/02/RECALL-ALERT--1.HTML NTSB COMPLAINT 10229961 NTSB COMPLAINT 10229818 NTSB COMPLAINT 10223434 NTSB COMPLAINT 10222711. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET HHR. THE CONTACT STATED THAT THE VEHICLE VIBRATES EXCESSIVELY WHEN THE BRAKE PEDAL IS DEPRESSED. HE TOOK THE VEHICLE TO THE DEALER ON FOUR OCCASIONS AND HAD THE BRAKE ROTORS REPAIRED. SECONDLY, THE AIR CONDITIONING PUMP FAILED AND CAUSED NUMEROUS FAILURES ON VARIOUS COMPONENTS. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT HE HAD TO HAVE MAJOR REPAIRS MADE TO THE VEHICLE, INCLUDING REPLACEMENT OF THE BRAKE ROTORS, CALIPERS, PADS, IGNITION CYLINDER, SHIFTER, BATTERY, AND THE AIR COMPRESSOR. THE REPAIR COSTS WOULD EXCEED $2,000. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT HAS COPIES OF THE VEHICLE'S REPAIR HISTORY. THE FAILURE MILEAGE WAS 500 AND CURRENT MILEAGE WAS 59,000.

Mileage: 500

BOLT FELL OUT OF THE LOWER RIGHT STEERING ARM, CAUSING THE ENTIRE WHEEL ASSEMBLY TO MOVE BACKWARD UPON BRAKING AND FORWARD ON ACCELERATION. *TR

Mileage: 12,600

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. AT LESS THAN 25,000 MILES, THE BRAKES WOULD OCCASIONALLY ROLL WHEN THE BRAKE PEDAL WAS DEPRESSED. THE DEALER STATED THAT THE ROTORS DID NOT NEED TO BE REPLACED AT THAT TIME, BUT ADVISED THE CONTACT TO KEEP AN EYE OUT. CURRENTLY, THE FAILURE HAS WORSENED AND THE CONTACT HAS SCHEDULED AN APPOINTMENT TO SEE THE DEALER. THE INSTRUMENT PANEL LIGHTS, WHICH INDICATE HOW MANY MILES THE VEHICLE HAS OR HOW MUCH OIL IS REMAINING, ILLUMINATE ON AND OFF INTERMITTENTLY. OCCASIONALLY, WHEN THE KEY IS TURNED IN THE IGNITION, THE ENGINE TURNS OVER BUT THE VEHICLE DOES NOT START. THE CURRENT MILEAGE WAS 30,000 AND FAILURE MILEAGE WAS 22,000.

Mileage: 22,000

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 20 MPH OVER A HOLE OR DIP IN THE ROAD, THE ENTIRE VEHICLE STALLED AND SHUT OFF. THE WEATHER WAS NOT A FACTOR. THE STALLING OCCURRED AT LEAST THREE TIMES WITHIN ONE WEEK. THE VEHICLE CANNOT BE RESTARTED ONCE IT SHUT OFF. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE DEALER DOES NOT KNOW THE CAUSE OF THE FAILURE OR THE REMEDY. THE FAILURE MILEAGE WAS 53,000. THE CONSUMER STATED THE VEHICLE WAS HAVING SEVERAL ISSUES WITH THE CAM SENSOR, WHEELS, A BROKEN HUB BEARING, BENT ROTORS AND AN ISSUE WITH REMOVING THE KEY FROM THE IGNITION, DUE TO THE SHIFT CABLE NOT STAYING SECURED. THE CHECK ENGINE LIGHT ILLUMINATED, THE INSIDE DRIVER DOOR HANDLE WOULD NOT OPEN THE DOOR, THE PASSENGER SIDE BACK WOULD NOT STAY SECURED. UPDATED 06/25/08

Mileage: 30,000

MY HHR HAD THE ROTORS TURNED AT LESS THAN 12K MILES, NOW AT 29K MILES IT NEEDS IT AGAIN. WE DO NOT DRIVE THE VEHICLE HARD AND BRAKE FAST. IT IS FAR FROM NORMAL WEAR. ALSO, NO LARGE HILLS TO DRIVE UP/DOWN. *TR

Mileage: 29,000

IN FEBRUARY 2007 I WAS IN AN AUTOMOBILE ACCIDENT WHILE I WAS DRIVING A 2006 CHEVROLET HHR. I WAS DRIVING ON INTERSTATE 95 SOUTHBOUND NEAR WILMINGTON, DELAWARE. SOMEONE ENTERING THE HIGHWAY FROM AND ON RAMP PULLED DIRECTLY IN FRONT OF ME WHILE I WAS DRIVING. WHEN I HIT THE BRAKES ON THE HHR, THE CAR PULLED SHARPLY TO THE RIGHT. THE MORE I BRAKED, THE MORE THE CAR PULLED TO THE RIGHT. I LOST CONTROL OF THE CAR AND I ENDED UP DRIVING ACROSS TWO LANE PERPENDICULAR TO THE TRAFFIC AND I HIT A VAN HEAD ON. NO ONE WAS INJURED BUT MY HHR WAS TOTALED. I FEEL THAT THE BRAKES ON THE HHR WERE DEFECTIVE AND THE WAY THEY PULLED TO ONE SIDE INSTEAD OF STOPPING STRAIGHT CAUSED ME TO CRASH. I REPORTED THIS TO CHEVROLET AFTER THE CRASH BUT NOTHING WAS DONE AS FAR A A RECALL OR ANYTHING. IN FACT, I READ ABOUT A SIMILAR PROBLEM WHEN THE 2006 HHR WAS RECEIVED ON EDMONDS.COM. THE AUTHOR OF THE REVIEW EXPRESSED THAT HE THOUGHT THAT THE HHR'S BRAKING WAS DANGEROUS. *TR

Mileage: 17,000

WHEN COMING TO A STOP DOING 40 OR HIGHER THE STEERING WHEEL VIBRATES. HAD TO HAVE THE ROTOR TURN AGAIN JUST HAD THEM TURNED AT 17,511 MILES AND NOW AT 25,124 MILES THAT IS ON 7613 SINCE THE FIRST TIME. IT IS NOT MY DRIVING EITHER! *TR

Mileage: 25,124

BRAKES DEFECTIVE HAVE 65,000 MILES ON 06 UNIT AND BRAKES AND / OR ROTORS WORKED ON 5 SEPARATE TIMES BRAKES WORKED ON JAN 07, MAY 07, JULY 07, OCT 07 AND JAN 08. *TR

Mileage: 18,000

BRAKES DEFECTIVE HAVE 65,000 MILES ON 06 UNIT AND BRAKES AND / OR ROTORS WORKED ON 5 SEPARATE TIMES BRAKES WORKED ON JAN 07, MAY 07, JULY 07, OCT 07 AND JAN 08. *TR

Mileage: 18,000

BRAKES DEFECTIVE HAVE 65,000 MILES ON 06 UNIT AND BRAKES AND / OR ROTORS WORKED ON 5 SEPARATE TIMES BRAKES WORKED ON JAN 07, MAY 07, JULY 07, OCT 07 AND JAN 08. *TR

Mileage: 18,000

FRONT BRAKE ROTORS WARPING. HAD THEM CUT TWICE AT DEALER. OUT OF WARRANTY KNOW, I WAITED TO LONG FOR THE 3 RD. FIX ( FAMILY EMG.) KNOW I HAVE TO PAY. *TR

Mileage: 5,000

**VEHICLE HAS A VIBRATION AT SPEEDS OVER 35 MPH, HAS BEEN INTO FOUR DIFFERENT CHEVY DEALERS NUMEROUS TIMES THEY CAN NOT FIND THE PROBLEM(THEY HAVE ROTATED TIRES MANY TIMES,BALANCED TIRES MANY TIMES,CHANGED TIRES AND REPLACED ALL FOUR TIRES)..PROBLEM STILL NOT SOLVED. ** BRAKES PULSATE SOMETIMES AND SMELL LIKE THEY ARE BURNING (THEY HAVE CLEANED AND ADJUSTED BRAKES AT LEAST 6 TIMES,PLUS THEY HAVE CUT ROTORS TWICE (THEY SAID THEY ARE WARPED, THEY ALSO CUT THE REAR DRUMS)..PROBLEM STILL NOT SOLVED. ** VEHICLE HAS A KLUNKING NOISE WHEN YOU HIT A BUMP (THEY HAVE REPLACED STEERING COLUMN, THE NEXT TIME THEY REPLACED STABLIZER PINS)..PROBLEM STILL NOT SOLVED. ** OTHER PROBLEMS THAT MOST HAVE BEEN SOLVED INCLUDE :* : *: *: *CLOTHES HANGER REPLACED TWICE**REAR WIPER REPLACED NEVER WORKED PROPERLY**LEAK IN THE FIRE WALL PUDDLES IN CAR**WEATHER STRIPPING WAS DEFECTIVE PUDDLES" INSIDE" DOORS CAUSING SEVERE WET SEATBELTS**KEY STUCK IN IGNITION REPLACED IGNITION**TRANSMISION JUMPING, GEAR SHIFT REPLACED**LOCKS NOT WORKING HAD TO UPDATE COMPUTER CODES** *TR

WE HAVE A CHEVY HHR '06. HAD IT FOR ABOUT A YEAR AND THE CAR STARTED TO SHAKE WHEN I PUT ON THE BRAKES. MY WIFE THEN BROUGHT IT TO THE DEALERSHIP AND THEY SAID THE ROTORS WERE WARPED...INSTEAD OF PUTTING NEW ROTORS ON THEY RESURFACED THE EXISTING ONES...PROBABLY CHEAPER TO WARRANTY. WE'LL, 2-3 MONTHS LATER THE CAR IS SHAKING AGAIN AND NOW THE CAR IS OUT OF WARRANTY. THIS IS A WELL DOCUMENTED PROBLEM FOR THIS MAKE&MODEL. GM NEEDS TO HAVE AN IMMEDIATE RECALL FOR THE 2006 CHEVY HHR SO THEY CAN FIX THE ROTOR PROBLEM. ME AND MY FAMILY WOULD FEEL SAFER ON THE ROAD. *TR

I HAVE HAD SEVERAL ISSUES WITH MY HHR SINCE PURCHASED IN SEPTEMBER 2005. FIRST INCIDENT WAS THE LOCK ON THE HATCH BROKE AFTER ONLY OWNING THE CAR FOR A FEW MONTHS. NEXT WAS WITH THE BRAKES. AT FIRST I NOTICED A NOISE WHEN I APPLIED MY BRAKES IT SOUNDED LIKE SOMETHING WAS LOOSE. THIS NOSE WOULD COME AND GO. AFTER A FEW MONTHS I STARTED TO NOTICE A SLIGHT VIBRATION IN MY STEERING WHEEL WHEN BRAKING A FEW DAYS LATER THAT VIBRATION TURNED TO VIOLENT SHAKING AND RESISTANCE WHEN BRAKING. I TOOK IT TO THE DEALER WHO INFORMED ME THE ROTORS WERE WARPED AND NEEDED TO BE REPAIRED. THIS WAS ROUGHLY AROUND 13000 MI. THE DEALER DID REPAIR THE ROTORS UNDER WARRANTY AND DIDN'T GIVE ME THE "IT'S NORMAL WEAR & TEAR" MUMBO. NEXT IS THE CHECK ENGINE LIGHT KEEPS COMING ON. IT WILL STAY ON FOR A FEW DAYS AND THEN GO OFF. THIS HAS HAPPENED 3 TIMES ALREADY AND THE DEALER HAS REPLACED THE SENSOR EACH TIME. NOW WE ARE UP TO THE 4TH TIME AS IT CAME BACK ON AGAIN YESTERDAY. I HAVE ALSO HAD ISSUES WITH THE RADIO. THE RADIO HAS HAD POWER TO IT AND NO VOLUME. THIS HAPPENED 3-4 TIMES B/4 I TOOK IT TO THE DEALER WHO HAD TO RESET & REPROGRAM SOMETHING ON THE RADIO. *TR

Mileage: 13,000

A LOUD CLUNKING NOISE HAS BEEN NOTICEABLE UNDER THE FRONT OF THE CAR FOR 3 TO 4 WEEKS PREVIOUS. IN ROUTE TO BILLINGS, MT. WE HEARD A THUD AND CAR BECAME HARD TO STEER, HIT THE BRAKES TO SLOW DOWN AND STOP. WHEN STOPPED THE RIGHT FRONT WHEEL COMPLETELY LOCKED UP. WE DISCOVERED THE REAR BLOT ON THE BRAKE CALIPER ON THE WHEEL HAD FALLEN OUT. WE WERE ABLE TO PULL OF THE ROAD AS THERE WAS NO TRAFFIC, HOWEVER ONCE THE CAR WAS STOPPED I COULD NOT GO FORWARD DUE TO THE BRAKE CALIPER BEING LOCKED INTO THE RIGHT WHEEL. HAD THE CAR TOWED TO THE GMC DEALERSHIP IN POWELL, WY WHERE THEY REPLACED THE BOLT AND REPAIRED THE CAR UNDER WARRANTY. *TR

Mileage: 19,990

I'VE HAD CHRONIC PROBLEMS WITH THE FRONT BRAKES, ROTORS, ALIGNMENT AND TIRES ON THE FRONT END OF MY 06 CHEVY HHR. THE VEHICLE BEGAN SHAKING VIOLENTLY WHEN THE BRAKES ARE APPLIED. I TOOK THE VEHICLE BACK TO THE DEALERSHIP AT 2000 MILES AND 12000 MILES AND EACH TIME THEY HAD TO TURN THE ROTORS AND IT SEEMED TO TEMPORARILY RESOLVE THE PROBLEM. NOW I'M AT 29000 MILES, THE PROBLEM HAS STARTED AGAIN. THE DEALERSHIP SAYS THE ROTORS AND FRONT BRAKE PADS HAVE TO BE REPLACED. I'VE OWNED MANY NEW VEHICLES IN MY LIFE SINCE MY FATHER IS RETIRED FROM GENERAL MOTORS, AND I'VE NEVER EVER HAD TO REPLACE THE BRAKES OR HAVE THE ROTORS TURNED FOR THAT MATTER. THE DEALERSHIP HAS TRIED TELLING ME THAT THE PROBLEM IS A RESULT OF MY DRIVING HABITS AND FAILURE TO SERVICE THE CALIPERS. I'VE HAD THE CAR IN THE DEALERSHIP REPEATEDLY FOR THIS AND OTHER CHRONIC PROBLEMS AND THEY'VE NEVER MENTION THAT THE CALIPERS NEED ANY SERVICING. ADDITIONALLY, I'M 40 YEARS OLD AND THE CAR IS DRIVEN ABOUT 3/4 OF A MILE BACK AND FORTH TO WORK AND NOT MUCH MORE. TO MAKE MATTERS WORSE, SINCE MY LAST TIRE ROTATION THE LEFT FRONT TIRE HAS BECOME ALMOST COMPLETELY BALD. THIS IS BIZARRE BECAUSE I'VE BEEN VIGILANT ABOUT ROTATING MY TIRES EVERY 6000 MILES AS RECOMMENDED. THE DEALERSHIP HAS AGREED TO REPLACE THE ROTORS AT THEIR COST, BUT THIS PROBLEM NEEDS TO BE COVERED AND REPAIRED 100% AT GMS EXPENSE. IT'S A RESULT OF POOR DESIGN. THEY NEED TO ADMIT THAT THERE IS A HUGE PROBLEM AND PAY FOR THE NECESSARY REPAIRS. *JB

Mileage: 2,000

STEERING WHEEL SHAKES LEFT & RIGHT WHEN STOPPING SPEED 40 MILES PER HOUR AND UP. THE 1ST TIME THE HHR WAS IN FOR THIS PROBLEM WAS 3 MONTHS AGO 15,550 MILES. DEALER SAID THEY COULD NOT FIND ANY THING THAT IT COULD BE THE ROAD AS I WAS DRIVING ON. TOOK IT IN AGAIN AT 17,500 THIS TIME IT WAS THE ROTORS WHERE WARPED. DEALER MACHINED THE ROTORS. *JB

Mileage: 15,550

STEERING WHEEL AND FRONT END SHAKING VIOLENTLY WHEN BRAKING. BROUGHT INTO DEALERSHIP @ APPROX 27,000MI AND TOLD ROTORS NEEDED TO BE RESURFACED BECAUSE THEY WERE WARPED. MANAGER SAID THEY WERE WARPED DUE TO "DRIVING HABITS", BRAKES GETTING WET-THEN USED, AND/OR HARD STOPS. THIS HAS NEVER BEEN THE CASE WITH ANY OTHER VEHICLE I'VE DRIVEN FOR A COMPARABLE AMOUNT OF TIME. *TR

Mileage: 26,000

DRIVING HOME FROM OUT OF STATE, APPLIED BRAKES AND STEERING WHEEL SHUDDERED VIOLENTLY, WITH REDUCED BRAKING ABILITY. TOOK TO DEALER, DIAGNOSED WARPED ROTORS. THE SAME PROBLEM HAD OCCURRED THREE MONTHS EARLIER, AT 20,000 MILES. VEHICLE NOW HAS 24,000 MILES. ROTORS WERE RESURFACED BOTH TIMES. *JB

Mileage: 24,350

TL*THE CONTACT OWNS A 2006 CHEVROLET HHR. WHILE DRIVING 50 MPH ON A MISTY DAY THE CONTACT EXPERIENCED BRAKE FAILURE WHILE ATTEMPTING TO STOP THE VEHICLE. THE CONTACT BEGAN PUMPING THE BRAKES, BUT THE VEHICLE REMAINED IN MOTION. THE CONTACT VEERED OFF THE ROAD AND THE VEHICLE STOPPED AUTOMATICALLY. THIS WAS NOT THE FIRST TIME THE CONTACT'S VEHICLE HAD BRAKE FAILURE. THE VEHICLE WAS BROUGHT TO THE DEALER ON TWO SEPARATE OCCASIONS. ON ONE OCCASION, THE DEALER FILED THE ROTORS DOWN AND TURNED THEM. THE CONTACT HAS POSSESSION OF ALL REPAIR ORDERS. THE FAILURE MILEAGE WAS 2,000.*AK THE ROTORS WERE SURFACED. UPDATED 05/04/07. *JB

Mileage: 2,000

2006 HHR LT. HISTORY OF ABS/BRAKE/FRONT END COMPONENT FAILURES AND ELECTRONIC MALFUNCTIONS SINCE PURCHASE IN WINTER OF 2005. WHEN APPLYING BRAKES STEERING WHEEL SHOOK HARD FROM L TO R AND BRAKES GRABBED/RELEASED. DEALER FOUND ROTORS WARPED AT LESS THAN 10K MILES. WARRANTY REPAIR/RESURFACE. PROBLEMS CONTINUED: ABS ENGAGED ON DRY PAVEMENT UNDER 10 MPH BUT WOULD NOT ENGAGE AT ROAD SPEEDS WITH BRAKES HEAVILY APPLIED. AT SAME TIME, PEDAL WENT TO FLOOR. ASE CERTIFIED GM MECHANICS TOLD ME THIS WAS IMPOSSIBLE - UNTIL SERVICE MANAGER TEST DROVE AND CONCLUDED PEDAL GOES TO FLOOR; CAR IS UNSAFE TO DRIVE. CLAIM OPENED/RESOLVED WITH GM. DEALER FOUND DEFECTIVE WHEEL HUB ASSEMBLY (LEFT) THAT CAUSED ABS FAILURE BELOW 8K MILES. (NO ACCIDENT) NEXT FAILURE OCCURRED IN THE RIGHT WHEEL HUB ASSEMBLY AND AN ACCIDENT RESULTED. GM AND THE DEALER CLAIM NO DEFECT BUT ONLY ERROR CODE IS RIGHT FRONT ABS FAILURE WITH PRIOR 7 PAGES HISTORY OF ABS/BRAKE/ELECTRONIC PROBLEMS (SUBMITTED TO INS COMPANY AND GM AND IN POSSESSION OF THE DEALER). THIS FAILURE RESULTED IN AN ACCIDENT WITH SUBSTANTIAL DAMAGE TO THE WHEELS/RIMS/UNDERCARRIAGE OF THE VEHICLE. GM AND THE DEALER CONCLUDED - WITHOUT BENCH TESTING THE RIGHT WHEEL HUB ASSEMBLY - THAT THERE WAS NO DEFECT; HOWEVER, THE ONLY ERROR CODE RECORDED IS AN ABS FAILURE (CLAIM OPENED WITH GM). GM AND DEALER HAVE CALLED TO SEE HOW THE VEHICLE IS DOING - I DECLINED TO COMMIT SAYING THAT I WOULD BE MAKING A DETERMINATION AS TO THE VEHICLE'S PERFORMANCE SHORTLY. GOOD THING - THE STEERING WHEEL SHAKES FROM LEFT TO RIGHT ON APPLICATION OF THE BRAKES AND THE BRAKES PULSE AS IF THE WHEELS ARE NO LONGER ROUND (GRAB AND RELEASE). THESE ARE THE SAME SYMPTOMS THAT OCCURRED WHEN THE ROTORS WHEN OUT OF SPEC. IT IS MY SUSPICION THAT THE ROTORS HAVE AGAIN GONE OUT OF SPEC AND THAT THE ABS/BRAKING COMPONENT FAILURES ARE CONTINUING WITH THIS VEHICLE. I AM ABOUT TO TAKE THE CAR TO AN INDEPENDENT MECHANIC FOR EVALUATION. *JB

2006 HHR LT. HISTORY OF ABS/BRAKE/FRONT END COMPONENT FAILURES AND ELECTRONIC MALFUNCTIONS SINCE PURCHASE IN WINTER OF 2005. WHEN APPLYING BRAKES STEERING WHEEL SHOOK HARD FROM L TO R AND BRAKES GRABBED/RELEASED. DEALER FOUND ROTORS WARPED AT LESS THAN 10K MILES. WARRANTY REPAIR/RESURFACE. PROBLEMS CONTINUED: ABS ENGAGED ON DRY PAVEMENT UNDER 10 MPH BUT WOULD NOT ENGAGE AT ROAD SPEEDS WITH BRAKES HEAVILY APPLIED. AT SAME TIME, PEDAL WENT TO FLOOR. ASE CERTIFIED GM MECHANICS TOLD ME THIS WAS IMPOSSIBLE - UNTIL SERVICE MANAGER TEST DROVE AND CONCLUDED PEDAL GOES TO FLOOR; CAR IS UNSAFE TO DRIVE. CLAIM OPENED/RESOLVED WITH GM. DEALER FOUND DEFECTIVE WHEEL HUB ASSEMBLY (LEFT) THAT CAUSED ABS FAILURE BELOW 8K MILES. (NO ACCIDENT) NEXT FAILURE OCCURRED IN THE RIGHT WHEEL HUB ASSEMBLY AND AN ACCIDENT RESULTED. GM AND THE DEALER CLAIM NO DEFECT BUT ONLY ERROR CODE IS RIGHT FRONT ABS FAILURE WITH PRIOR 7 PAGES HISTORY OF ABS/BRAKE/ELECTRONIC PROBLEMS (SUBMITTED TO INS COMPANY AND GM AND IN POSSESSION OF THE DEALER). THIS FAILURE RESULTED IN AN ACCIDENT WITH SUBSTANTIAL DAMAGE TO THE WHEELS/RIMS/UNDERCARRIAGE OF THE VEHICLE. GM AND THE DEALER CONCLUDED - WITHOUT BENCH TESTING THE RIGHT WHEEL HUB ASSEMBLY - THAT THERE WAS NO DEFECT; HOWEVER, THE ONLY ERROR CODE RECORDED IS AN ABS FAILURE (CLAIM OPENED WITH GM). GM AND DEALER HAVE CALLED TO SEE HOW THE VEHICLE IS DOING - I DECLINED TO COMMIT SAYING THAT I WOULD BE MAKING A DETERMINATION AS TO THE VEHICLE'S PERFORMANCE SHORTLY. GOOD THING - THE STEERING WHEEL SHAKES FROM LEFT TO RIGHT ON APPLICATION OF THE BRAKES AND THE BRAKES PULSE AS IF THE WHEELS ARE NO LONGER ROUND (GRAB AND RELEASE). THESE ARE THE SAME SYMPTOMS THAT OCCURRED WHEN THE ROTORS WHEN OUT OF SPEC. IT IS MY SUSPICION THAT THE ROTORS HAVE AGAIN GONE OUT OF SPEC AND THAT THE ABS/BRAKING COMPONENT FAILURES ARE CONTINUING WITH THIS VEHICLE. I AM ABOUT TO TAKE THE CAR TO AN INDEPENDENT MECHANIC FOR EVALUATION. *JB

TL*- THE CONTACT STATED THAT THE 2006 CHEVROLET HHR LT WAS HAVING BRAKING SYSTEM PROBLEMS. THIS STARTED IN JANUARY 2007 WITH THE BRAKE LIGHT AND LOW BRAKE FLUID LIGHT TURNING ON. THE CONTACT CALLED THE DEALERSHIP, AND WAS TOLD TO BRING THE VEHICLE, THEY REPLACED THE MASTER CYLINDER, AND THEY REPAIRED THE WIRE HARNESS THAT SHORTED OUT. THE CONTACT STATED THAT THE DEALERSHIP INFORMED HIM THAT THE WIRE HARNESS FAILED BECAUSE OF A MISTAKE MADE BY THE SERVICE MECHANIC, AND THAT WAS WHY IT HAD TO BE REPAIRED. THE CONTACT STATED THAT HE GOT THE VEHICLE BACK AND DROVE IT FOR A WEEK, THEN THE RED BRAKE LIGHT TURNED ON AND A YELLOW LIGHT CAME ON FOR THE ABS. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALERSHIP ON 02/07/07,AND THEY STILL HAD THE VEHICLE. THE CONTACT WAS INFORMED BY THE DEALERSHIP THAT THEY THOUGHT ITWAS DUE TO THE WEATHER, BUT WERE NOT SURE WHAT WAS CAUSING THIS TO HAPPEN. THE CURRENT MILEAGE WAS 4100 AND THE FAILURE MILEAGE WAS 3700.*AK

Mileage: 3,700

TL*- THE CONTACT STATED THAT THE 2006 CHEVROLET HHR LT WAS HAVING BRAKING SYSTEM PROBLEMS. THIS STARTED IN JANUARY 2007 WITH THE BRAKE LIGHT AND LOW BRAKE FLUID LIGHT TURNING ON. THE CONTACT CALLED THE DEALERSHIP, AND WAS TOLD TO BRING THE VEHICLE, THEY REPLACED THE MASTER CYLINDER, AND THEY REPAIRED THE WIRE HARNESS THAT SHORTED OUT. THE CONTACT STATED THAT THE DEALERSHIP INFORMED HIM THAT THE WIRE HARNESS FAILED BECAUSE OF A MISTAKE MADE BY THE SERVICE MECHANIC, AND THAT WAS WHY IT HAD TO BE REPAIRED. THE CONTACT STATED THAT HE GOT THE VEHICLE BACK AND DROVE IT FOR A WEEK, THEN THE RED BRAKE LIGHT TURNED ON AND A YELLOW LIGHT CAME ON FOR THE ABS. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALERSHIP ON 02/07/07,AND THEY STILL HAD THE VEHICLE. THE CONTACT WAS INFORMED BY THE DEALERSHIP THAT THEY THOUGHT ITWAS DUE TO THE WEATHER, BUT WERE NOT SURE WHAT WAS CAUSING THIS TO HAPPEN. THE CURRENT MILEAGE WAS 4100 AND THE FAILURE MILEAGE WAS 3700.*AK

Mileage: 3,700

TL*- THE CONTACT STATED THAT THE 2006 CHEVROLET HHR LT WAS HAVING BRAKING SYSTEM PROBLEMS. THIS STARTED IN JANUARY 2007 WITH THE BRAKE LIGHT AND LOW BRAKE FLUID LIGHT TURNING ON. THE CONTACT CALLED THE DEALERSHIP, AND WAS TOLD TO BRING THE VEHICLE, THEY REPLACED THE MASTER CYLINDER, AND THEY REPAIRED THE WIRE HARNESS THAT SHORTED OUT. THE CONTACT STATED THAT THE DEALERSHIP INFORMED HIM THAT THE WIRE HARNESS FAILED BECAUSE OF A MISTAKE MADE BY THE SERVICE MECHANIC, AND THAT WAS WHY IT HAD TO BE REPAIRED. THE CONTACT STATED THAT HE GOT THE VEHICLE BACK AND DROVE IT FOR A WEEK, THEN THE RED BRAKE LIGHT TURNED ON AND A YELLOW LIGHT CAME ON FOR THE ABS. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALERSHIP ON 02/07/07,AND THEY STILL HAD THE VEHICLE. THE CONTACT WAS INFORMED BY THE DEALERSHIP THAT THEY THOUGHT ITWAS DUE TO THE WEATHER, BUT WERE NOT SURE WHAT WAS CAUSING THIS TO HAPPEN. THE CURRENT MILEAGE WAS 4100 AND THE FAILURE MILEAGE WAS 3700.*AK

Mileage: 3,700

2006 HHR 2LT WITH 5000+ MILES HAD NEAR MISS WHEN BRAKES FAILED WHILE TRAVELING AT ABOUT 45 MPH, I ATTEMPTED TO GENTLY BRAKE FOR A TRUCK TURNING 6-7 CARS AHEAD OF ME. I HEARD A LOUD GRINDING NOISE THAT REMINDED ME OF PLASTIC GEAR TEETH TURNING THE WRONG DIRECTION. MY PEDAL WOULD NOT DEPRESS AND THE CAR WOULD NOT EVEN SLOW. REFLEXIVELY, I PUMPED THE BRAKE TO SEE IF THE ABS HAD JUST LOCKED UP. THE BRAKE PEDAL FELT LIKE IT WAS LOCKED IN THE UP POSITION. LUCKILY I HAD BEEN ABOUT 6-7 CAR LENGTHS BEHIND AND BY THE TIME I GOT UP IN HIS REAR, MY BRAKE PEDAL RELEASED A LITTLE (STILL WITH RESISTANCE) AND I WAS ABLE TO SLOW ENOUGH NOT TO HIT HIM AS HE TURNED. I HAD TO AVOID HIM BY VEERING TO THE LEFT TO DRIVE AROUND HIM. THE BRAKE SEEMED TO RELEASE SEVERAL SECONDS LATER AFTER COMPLETELY REMOVING MY FOOT FROM THE PEDAL AND COASTING. MY AUTO DEALER SAID THEY TOOK IT FOR A DRIVE AND IT WAS BRAKING FINE. I??M CONCERNED BECAUSE THEY HAVE DISMISSED THIS NEAR COLLISION. ADDITIONAL INFO: OUTDOOR TEMP WAS BELOW 30 IN KY. IS POSSIBLE THERE WAS ICE ON THE ROAD, BUT HAVING LIVED IN BOTH OH AND MI I AM VERY FAMILIAR WITH ICE AND A CAR'S RESPONSE. ABS DID SOUND LIKE IT ATTEMPTED TO ENGAGE BEFORE THE GRINDING NOISE, BUT BRAKE PEDAL RESPONSE WAS NOT NORMAL. BRAKES DID NOT LOCK UP AS WITH ICY CONDITIONS. CAR DID NOT SLIDE. SPEED WAS MAINTAINED, DESPITE ATTEMPTING TO DEPRESS BRAKE PEDAL. PEDAL DIDN'T MOVE (LOWER) AS IT DOES WITH NORMAL BRAKING. *JB

Mileage: 5,450

THE ANTI LOCK BRAKES ON OUR CHEVY HHR LOCKED UP WHEN ATTEMPTING A NORMAL STOP, AND STAYED IN THE LOCKED POSITION EVEN AFTER FINALLY COMING TO A STOP. IF NOT FOR A TURNING LANE BEING OPEN A COLLISION WOULD HAVE OCCURRED. THE DEALER HAS NOT BEEN ABLE TO FIGURE OUT WHAT WENT WRONG, BUT I NEED TO POST THIS AND SEE IF OTHERS HAVE HAD THIS PROBLEM. *NM