2005 CHEVROLET MALIBU MAXX Exterior Lighting Problems

TL* THE CONTACT OWNS A 2005 MALIBU MAXX. WHILE OPERATING THE VEHICLE, THE PASSENGER AND DRIVER SIDE TURN SIGNALS MALFUNCTIONED AND WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO LEWIS CHEVROLET OF GARDEN CITY (1903 US 50 BUS E., GARDEN CITY , KS) WHERE IT WAS DIAGNOSED THAT THE HEADLIGHT BULB SOCKETS HAD MELTED AND DAMAGED THE BULBS. THE DEALER STATED THAT THE BULBS COULD NOT BE SCREWED OUT OF THE LIGHT BULB SOCKETS AND THE ENTIRE HEADLIGHT BULB ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT INDICATED THAT THE FAILURE OCCURRED TO BOTH THE DRIVER AND PASSENGER SIDE ASSEMBLIES ON MULTIPLE OCCASIONS. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

Mileage: 160,000

IGNITION STAYING STUCK ALOWING STARTER TO CONTINUE TO TURN, DAY TIME NO BREAK LIGHTS , NIGHT TIME BREAK LIGHTS STAY LIT UP OR FLASH ON AND OFF , FUEL GAUGE DROPS TO EMPTY EVEN WHEN FULL BOUNCES BACK AND FORTH EMPTY FULL , SERVICE AIR BAG AND CHECK ENGINE LIGHTS KEEP COMING ON EVEN AFTER THEY HAVE BEEN RESET, CRUISE CONTROL WILL NOT ENGAGE , HARD TIME TO TAKE CAR OUT OF PARK EVEN WITH BRAKE DEPRESSED, LOWER GEARS ON TRANSMISSION WILL NOT ENGAGE INTO 3,2,1 SPEED, DRIVER SEAT BRACKET BROKE IN WELD CAUSING SEAT TO BE UNSTABLE, FAULTY IGNITION SWITCH AND MORE THIS CAR HAS LESS THAN 150 K ON IT 148 AND SOME CHANGE,,, AIR BAG SERVICE LIGHT KEEPS COMING ON AS WELL AS CHECK ENGINE LIGHT, THIS CAR WILL NOT PASS ANY STATE INSPECTION , AND EVEN STATES WITH OUT INSPECTION WOULD ADVISE THAT THE CAR BE RECALLED

Mileage: 148,795

THE FRONT AND REAR TURN SIGNAL BULBS CONTINUALLY BURN OUT. THEY GET SO HOT THAT BOTH FRONT ORANGE BULB COVERS HAVE HOLES BURNT IN THEM AND THE SOCKET HAS DISCOLORED BECAUSE OF THE HEAT. THIS BEGAN SHORTLY AFTER I PURCHASED THE CAR IN 2005 BUT DID NOT NOTICE THE HOLES UNTIL RECENTLY.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHEN THE STEERING WHEEL WAS TURNED TO THE LEFT AND WHEN STARTING THE VEHICLE, AN ABNORMAL NOISE EMERGED FROM THE STEERING WHEEL. THE DEALER WAS NOTIFIED OF THE FAILURE AND INDICATED THAT IT WAS DUE TO A SAFETY FEATURE. IN ADDITION, THE BRAKE LIGHTS REMAINED ILLUMINATED WHEN THE BRAKES HAD NOT BEEN APPLIED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHILE DRIVING 35 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT ALSO STATED THAT BOTH TURN SIGNALS FAILED TO FUNCTION. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

Mileage: 98,000

TOOK CAR TO THE CHEVROLET DEALERSHIP, FOR NHTSA ID: 14V252000/GM SAFETY RECALL: 13036, TO CORRECT THE ISSUES IN THE BODY CONTROL MODULE WHICH IMPACTED THE BRAKE APPLY SENSOR. NOW REAR TOP BRAKE LIGHTS NO LONGER ILLUMINATE WHEN THE BRAKE PEDAL IS BEING PUSHED. FRONT LOW-BEAM HEADLIGHTS GOES ON AND OFF WHILE DRIVING. REPLACED BOTH LOW-BEAM LIGHTS ON 12/6/2014. FRONT LOW BEAM HEADLIGHTS STILL GOES OFF AND ON INTERMITTENTLY. ALSO UPON VISUAL INSPECTION, THE TURN SIGNAL BLINKERS HAVE MELTED THE YELLOW PLASTIC INSIDE THE HEADLIGHT. BROUGHT BACK TO THE SAME CHEVROLET DEALERSHIP ON 1/2/2015, FOR VEHICLE RECALL NHTSA ID: 14V224000/GM SAFETY RECALL 14152 TO HAVE THE SHIFT CABLE ASSEMBLY AND MOUNTING BRACKET INSTALLED. I NOTIFIED THE DEALERSHIP THAT I WAS HAVING ISSUES WITH THE ELECTRICAL SYSTEM TIED TO THE EXTERIOR LIGHTING SYSTEM. THEY COULD NOT PROVIDE ME THE REASON FOR THE FAULT. *TR

Mileage: 163,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE AMBER LIGHTS BURNED OUT AND MELTED THE PLASTIC SHIELD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,370. UPDATED 10/10/14*CN THE CONSUMER STATED THE LIGHTS WERE NOT BURNED OUT. THE PLASTIC COVE OVER THE RUNNING LIGHTS MELTED AND THE RIGHT TURN SIGNAL FAILED. THE TECHNICIAN ADVISED ALL LIGHT S NEEDED TO BE REPLACED BUT, WOULD NOT ASSIST WITH THE REPAIRS DUE TO THE AGE OF THE VEHICLE. UPDATED 05/18/2015 *JS

Mileage: 124,370

I PURCHASED THIS VEHICLE USED AND HAVE HAD AN ELECTRICAL PROBLEM WITH THE PASSENGER HEADLIGHTS.GOING ON AND OFF.I HAVE REPLACED THE WIRE HARNESS 7 TIMES IN 2 YEARS.IS THEIR A RECALL ON THESE CARS FOR THE HEADLIGHT ISSUES.IF SO I NEED TO BE NOTIFIED ASAP BEFORE THEIR IS A FIRE IN MY CAR.I AM A HANDICAP MOTHER THAT NEEDS HER CAR. *TR

A 2005 CHEVROLET MALIBU MAXX LS. 156964 MILEAGE. THE STEERING WHEEL EMITTED A CLUCKING AND A CREAKING NOISE WHILE MAKING A TURN. A CLAPPING REPEATED NOISE SOMEWHERE IN THE WHEELS HAS APPEARED ALSO. BLINKERS BURNED OUT TOO OFTEN AND THE PLASTICS THAT COVER THEM ARE MELT DOWN. IF IT STAYS MORE THAN 10 MINUTES STOPPED AFTER DRIVING A WHILE, THE TEMPERATURE GAUGE START RISING TO THE OVERHEAT POINT, BUT IF YOU TURN ON THE AIR CONDITIONING IT COMES BACK TO THE MEDIUM READING MEASUREMENT GAUGE. *TR

Mileage: 129,831

I PURCHASED THIS VEHICLE YESTERDAY AND UPON INSPECTION LAST NIGHT I REALIZED THAT THE ORANGE PLASTIC DOME THAT FITS OVER THE LAMP FOR THE PASSENGER SIDE BLINKER IS UNATTACHED, WHEN MY FATHER LOOKED FURTHER INTO IT HE BECAME AWARE THAT THE WIRES ARE MELTED AND SO IS THE PART OF THE ORANGE PIECE THAT ATTACHES, UPON FURTHER RESEARCH IT SEEMS THAT THIS IS A PROBLEM THAT MANY OWNERS OF THIS MODEL HAVE ENCOUNTERED, IS THERE A RECALL OR SOMETHING ON THIS TO HAVE IT REPLACED? *JS

THE DRIVER SIDE HEADLIGHT ORANGE GLASS IN SIDE OF HEAD LAMP IT HAS A HOLE MELTED THE TOP OF THE ORANGE LENS. HAS A HOLE ON TOP WHAT CAN YOU DO TO FIX THAT PROBLEM, IT'S SEAMS TO BE ONLY ON THE DRIVER SIDE OF THE CAR. IT'S ON A 2005 MALIBU MAXX. CAN YOU REPLACE IT UNDER A FACTORY WARRANTY FOR US THANKS. THAT'S HAS TO BE A DEFECTIVE PART ON THEM CARS PLEASE LET ME KNOW WHAT YOU CAN DO FOR ME THANKS AGAIN. *TR

I PURCHASED MY CHEVY MALIBU MAXX JANUARY OF JUST LAST YEAR AND I HAD TO REPLACE MY FRONT LEFT HEAD LIGHT THINKING NOTHING OF JUST NORMAL MAINTENANCE AND THIS WAS RIGHT AROUND AUGUST OF LAST YEAR AND IT IS NOW MARCH OF 2013 AND I JUST HAD TO DO IT AGAIN BUT THIS GO ROUND IT SEEMED MORE LIKE A SHORT BECAUSE IT STOPPED WORKING ONE NIGHT DRIVING HOME FROM WORK WHICH I DRIVE A VERY BUSY HIGHWAY AT NIGHT AND THAT NEXT MORNING IT WAS WORKING JUST FINE SO ME BEING THE NORMAL AMERICAN PERSON I THINK NOTHING OF IT BUT THE FOLLOWING DAY IT GOES OUT FULLY AND WHEN I WENT TO GO CHANGE THE LIGHT THIS TIME I NOTICED IT HAD ACTUALLY BURNED THROUGH THE AMBER COLOR COVER OF THE BULB AND ALSO BURNED THE SOCKET UP IN THE VEHICLE. BUT NOW GET THIS ABOUT THE SAME TIME LAST YEAR MY AUX FUSE BEGAN TO BLOW OVER AND OVER NOT THINKING ANYTHING ABOUT IT BUT NOW AFTER READING ALL OF THESE DIFFERENT SITUATIONS I KINDA WONDER IF THE TWO SITUATIONS COULD HAVE ANYTHING TO DO WITH ONE ANOTHER. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT WHILE PARKED, HE NOTICED THAT A HOLE WAS MELTED INTO THE AMBER TURN SIGNAL HEADLIGHT LENS, EXPOSING THE HOUSING UNIT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. UPDATED 04/30/13*LJ THE CONSUMER STATED THE AMBER LENSES ON THE LEFT AND FRONT TURN SIGNALS SHOWED BLACK BURN MARKS; SIGNS OF OVERHEATING OR LACK OF VENTILATION FROM HEAT GENERATED BY THE LAMPS

Mileage: 65,000

TURN SIGNALS BURNING SO HOT THEY EXPLODE, AND MELT NOT ONLY HOUSING FOR BULB, BUT ALSO THE SOCKET IN ORDER TO REPLACE BULB IS MELTED TOO. THERE NEEDS TO BE A RECALL ON THIS AS I HAVE FOUND OVER 200 OTHER COMPLAINTS OF PEOPLE HAVING THE SAME ISSUE! *TR

Mileage: 162,000

BOTH THE FRONT TURN SIGNAL AMBER BULB HOUSING KEEPS MELTING TO THE BULB AND ALSO THE LIGHT SOCKETS , OEM AND AFTER MARKET ONES. *TR

Mileage: 125,000

MY 2005 MALIBU MAXX INDICATED THAT A TURN SIGNAL BULB WAS OUT AND WHEN I WENT TO REPLACE THE BULB I NOTICED, NOT ONLY THAT THE BULB ITSELF WAS SIGNIFICANTLY BURNED AT THE SOCKET, BUT ALSO THAT THE BLINKER PLASTIC WAS SUBSTANTIALLY MELTED. I CHECKED THE OTHER SIDE OF THE CAR AND EVEN THOUGH THAT BULB IS STILL FUNCTIONING, THE PLASTIC BLINKER HOUSING IS STARTING TO MELT ON THAT SIDE AS WELL. CLEARLY THE BULBS ARE BURNING WAY TO HOT TO BE MELTING THE PLASTIC HOUSING AND I WOULD ASSUME SINCE THE BULB ITSELF WAS BURNED THAT THIS IS A LARGER ISSUE OF BOTH POTENTIAL FIRE RISK AND NOW WATER DAMAGE SINCE THE BLINKER HOUSING IS COMPROMISED. *TR

Mileage: 87,000

MY CARS HEADLIGHTS ARE DIM AT NIGHT AND TAKE A WHILE TO GET BRIGHTER EVEN THOUGH I HAVE HAD THE BULB REPLACED AND THE LIGHTING COMPONENTS CHECKED OUT. THE WINDOWS WON'T ROLL DOWN FROM ANY SIDE OF THE CAR, A RECURRENCE FROM TWO YEARS AGO. ALSO MY DOORS WON'T UNLOCK FROM THE AUTO-UNLOCK BUTTON THAT SITS ON THE DRIVERS SIDE, THIS HAS BEEN AN ISSUE FOR THE PAST 2 YEARS OF MY CHEVROLET CAR OWNERSHIP. *TR

Mileage: 80,038

2005 CHEVY MALIBU MAXX FRONT HEADLIGHT TURN SIGNAL BULB MELTED THE HOUSING SURROUNDING THE BULB WITH CORRECT BULB REPLACEMENT. BULB KEEPS BURNING OUT AND AM CONCERNED THAT THIS MELTING WILL RESULT IN SAFETY ISSUES OR FURTHER DAMAGES TO THE HEADLIGHT HOUSING. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE TURN SIGNALS FAILED. THE CONTACT STATED THAT THE LENSES WERE MELTED ON BOTH SIDES. THE CONTACT REPLACED THE LENSES THREE TIMES IN THE LAST NINE MONTHS. THE CONTACT STATED THAT THE CONNECTION FOR THE LIGHT BULBS WERE BURNED OUT BUT THE LIGHT ITSELF CONTINUED WORKING. THE FUSE FOR THE LIGHT BULB HAD NOT FAILED. THE FAILURE MILEAGE WAS 84,000 AND THE CURRENT MILEAGE WAS 100,000.

Mileage: 84,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE HEADLIGHT BULBS MELTED AND THE HEADLIGHT ASSEMBLIES FILLED WITH SMOKE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THERE WERE NO RECALLS OR WARRANTIES ADDRESSING THE FAILURE. THE CONTACT HAD TO PURCHASE FOUR DIFFERENT HEADLIGHT ASSEMBLIES AND PERFORM THE REPAIRS HIMSELF. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 103,000 AND THE CURRENT MILEAGE WAS 130,000.

Mileage: 103,000

I HAVE OWNED MY 2005 MALIBU MAXX FOR JUST OVER A YEAR AND HAVE HAD TO REPLACE THE FRONT TURN SIGNAL SOCKETS, BOTH DRIVER AND PASSENGER SIDES, THREE TIMES NOW DUE TO MELTED SOCKETS AND AMBER COVERS MELTING DOWN TO THE BULBS. EVEN THOUGH THEY ARE VENTED THEY DO NOT STAY COOL ENOUGH TO PREVENT SEVERE ELECTRICAL DAMAGE TO THE COMPONENTS. IN REPLACING THESE COMPONENTS I HAVE TO WAIT A WEEK UNTIL THE PARTS ARE SHIPPED OUT AND AM FORCED TO DRIVE WITH FAULTY EQUIPMENT. I AM UNABLE TO JUST REPLACE THE BULBS AND HAVE TO CONSTANTLY CHANGE THE BULBS OUT BEFORE THEY MELT TO THE SOCKETS. THIS IS A HUGE HAZARD AS THEY CAN GO OUT ON ME IN THE MIDDLE OF DRIVING IN RUSH HOUR TRAFFIC PUTTING ME AT A GREATER RISK OF INJURY. PLEASE FORCE GM TO ISSUE AN ACTUAL RECALL ON THIS ISSUE AND NOT JUST SKATE FREE ON THE SERVICE BULLETIN THAT HAS BEEN ISSUED. THANK YOU, *TR

Mileage: 95,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE TURN SIGNALS FAILED INTERMITTENTLY. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REPLACED THE BULBS HOWEVER, THE FAILURE CONTINUED TO RECUR. THE CURRENT MILEAGE WAS 138,000 AND THE FAILURE MILEAGE WAS 108,000.

Mileage: 108,000

TL- THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. WHILE PARKED, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE HEADLIGHT WAS BURNED OUT. THE CONTACT REPLACED THE BULB BUT THE HEADLIGHT BURNED OUT A SECOND TIME. THE CONTACT LATER NOTICED THAT THE TURN SIGNAL LIGHT WIRES WERE MELTED INTO THE BULB SOCKET. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE THE MECHANIC ADVISED THE CONTACT THAT THE HEAD LAMP ASSEMBLY WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 89,000. KMJ

Mileage: 89,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE YELLOW PLASTIC COVER FOR THE HEADLIGHTS WAS FOUND BURNED ON BOTH THE DRIVER AND PASSENGER SIDES. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THERE WERE NO RECALLS OR FOR THE FAILURE. THE DEALER ADVISED THAT THE FRONT HEADLIGHT ASSEMBLY WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 82,000.

Mileage: 82,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THE HEADLIGHT WIRING HARNESS MELTED CAUSING THE LIGHT BULB PLASTIC COVERING TO MELT AND THE LIGHT BULB TO FAIL. A LOCAL MECHANIC REPLACED THE PASSENGER HEADLIGHT ASSEMBLY, BUT THE DRIVER HEADLIGHT ALSO FAILED. THE DRIVERS HEADLIGHT ASSEMBLY WAS NOT REPLACED. THE FAILURE MILEAGE WAS 86,000 AND THE CURRENT MILEAGE WAS 92,000. UPDATED 10/14/11 *BF UPDATED 10/28/11

Mileage: 86,000

DRIVER SIDE DAY TIME RUNNING LIGHT/TURN SIGNAL BULB SOCKET CAUSES BULB BASE TO MELT AND CAUSE A SHORTAGE. IN ONE YEAR BULB HAS HAD TO BE REPLACED 4 TIMES. BULB MANUFACTURER SENT ME HEAVY DUTY REPLACEMENT BULBS TO HELP SOLVE THE PROBLEM THEY SUGGEST THAT GM IS AWARE OF. TWO HEAVY DUTY BULBS HAVE ALSO GONE BAD WITH MOST RECENT MELTING THE BASE WITHIN TWO DAYS. PROBLEM IS NO DAY TIME RUNNING LIGHT OR TURN SIGNAL. PASSENGER SIDE BULB WAS REPLACED ONCE, LIKELY UNDER NORMAL WEAR. *TR

COMPLETE AND TOTAL LOCK UP OF POWER STEERING; BATTERY LIGHT FLICKS ON AND THEN EVERYTHING LOCKS UP UNTIL YOU REPLACE THE GAS PEDDLE FOR ABOUT 3 SECONDS. MY LIGHTS RANDOMLY FLASH AND REAR BULBS ON THE DRIVER SIDE BLOW EVERY 3 DAYS. MY TURN SIGNALS WILL SPORADICALLY BLINK AND THE WIPER BLADES GO OFF WITH OUT WARNING OR BEING PROMPTED. EVEN WITH NO KEYS NEAR OR IN THE CAR IT WILL NOT TURN OVER TO START THE CAR UNTIL YOU FLOOR THE GAS PEDDLE AND HOLD IT THERE FOR 3-5 SECONDS. MY RADIO READS AT -19* ALL THE TIME AND THE CD PLAYER HAS NEVER WORKED CORRECTLY. WHEN GOING FROM 0 TO 50 GETTING ON THE PARKWAY (HIGHWAY) THE WHOLE CAR LOCKS UP AND LOSES POWER INCLUDING THE STEERING RADIO AND LIGHTS UNLESS YOU COMPLETELY RELEASE THE GAS THEN START TO GO AGAIN. IM SO HIGHLY FRUSTRATED AND CHEVY REFUSES TO FIX IT EVEN THOUGH THESE ARE ALL RECALLED PROBLEMS BUT MY VIN DOESN'T FALL IN THERE "BRACKET". *TR

Mileage: 142,225

SHORTAGE IN TURN SIGNALS. *TR

Mileage: 95,000

THE STEERING HAS A HEAVY CLUNK SOUND WHEN TURNING LEFT IN REVERSE, NO SOUND WHEN GOING TO THE RIGHT. THEN AT JUST OVER 50K MILES, THE STEERING ON THE VEHICLE STARTED HAVING ISSUES WITH POWER WHILE TURNING TO THE RIGHT UNDER POWER, TO THE LEFT WAS JUST FINE. THE HEAD LAMPS ALSO HAVE GOTTEN SEVERELY CLOUDY WHICH LIMITS VISIBILITY DURING NIGHT TIME DRIVING. FRONT TURN INDICATOR LIGHTS ALSO HAD A PROBLEM WITH LOOSE SOCKETS, CAUSING THE LIGHTS TO SHORT OUT AND EVENTUALLY FAIL BECAUSE OF SPARKING RESIDUE ON THE CONTACTS. ALSO, FOR SOME REASON THE REAR WINDOW WIPER RANDOMLY TURNS ON FOR NO APPARENT REASON. THE VEHICLE ALSO HAS A STARTING PROBLEM WHERE AT TIMES, THE VEHICLE WILL CRANK AND NOT START. LOOKING AROUND, QUITE A FEW FOLKS HAVE THAT PROBLEM AS WELL, WHERE SOME PEOPLE HAVE HAD TO SHORT OUT THE HOOD SAFETY SWITCH TO MAKE THE CAR WORK... NOW THAT IS CRAZY TO HAVE TO SHORT OUT SOMETHING TO START YOUR CAR. APPARENTLY THOUGH, THE ELECTRICAL SYSTEM IS SEVERELY SENSITIVE TO VOLTAGE ISSUES IN GENERAL, MORE SO THEN MOST VEHICLES ON THE ROAD.

Mileage: 24,547

2005 MAILBU MAXX. CONSUMER STATES INTERMITTENT PROBLEMS WITH BRAKE LIGHTS *TGW THE CONSUMER STATED THE BRAKE LIGHTS WOULD ILLUMINATE WHEN THE BRAKE WASN'T APPLIED AND WOULD NOT ILLUMINATE WHEN THE BRAKE WAS APPLIED. THE DEALER REPLACED THE BRAKE LAMP, BUT THE PROBLEM CONTINUED. *JB

THE DRIVERS SIDE TURN SIGNAL (INSIDE THE HARNESS IN THE HEADLIGHT) KEEPS MELTING THE PLASTIC SNAP IN BASE OF THE TURN SIGNAL LIGHT BULB AND CAUSES IT TO BECOME INOPERATIVE. ALMOST CAUSING OTHER VEHICLES TO CRASH IN TO ME AT 4 WAY STOP SIGNS. THE HARNESS ASSEMBLY GETS VERY HOT. MAY ONE DAY CAUSE A FIRE. I HAVE REPLACED LIGHT BULBS 4 TIMES IN THE LAST MONTH. WILL HAVE TO GET SERVICED. THIS IS BECOMING A REAL SAFETY ISSUE IN THE MIDWEST BECAUSE I HAVE TO STICK MY HAND OUT WHEN IT -30 TO USE AS A SIGNAL. THE DEALER CHARGES $267 FOR REPLACEMENT. 3 TIME SO FAR AND I AM NOT SURE WHAT IS NEXT. I BELIEVE GM SHOULD OWN TO THIS PROBLEM AND FIX AS A RECALL. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT STATED THAT THE FRONT RUNNING LIGHTS WERE OVERHEATING AND MELTING THE PLASTIC COVERS. THE FAILURE FIRST STARTED ON THE PASSENGER SIDE BUT PROGRESSED TO BOTH LIGHTS. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE CONTACT STATED THE AMBER COVER ON THE DRIVER SIDE WAS MELTING AND LOOKED AS IF IT WAS STARTING TO MELT ON THE PASSENGER SIDE AS WELL. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 73,000. UPDATED 02/15/12*BF THE CONSUMER STATED INITIALLY, HE NOTICED THE FRONT SIGNAL LIGHTS WERE BURNING OUT AT AN ALARMING RATE. EVENTUALLY, SMOKE BEGAN EMITTING FROM THE PLASTIC COVER, FOLLOWED BY MELTING OF THE LIGHT AND COVER. A MECHANIC INFORMED THE CONSUMER, THAT THE BULBS OR SOCKETS WERE PERHAPS LOOSE. AFTER THE BULB HOUSING MELTED, BOTH HEADLIGHT ASSEMBLIES WERE REPLACED. TO DATE, THE BULBS CONTINUE TO FUNCTION, WITH NO BURN OUTS. HOWEVER, THE LIGHTS SEEMED TO BOUNCE WHILE DRIVING. UPDATED 04/26/12

Mileage: 70,000

THE DRIVERS SIDE TURN SIGNAL (INSIDE THE HARNESS IN THE HEADLIGHT) KEEPS MELTING THE PLASTIC SNAP IN BASE OF THE TURN SIGNAL LIGHT BULB AND CAUSES IT TO BECOME INOPERATIVE. ALMOST CAUSING OTHER VEHICLES TO CRASH IN TO ME AT 4 WAY STOP SIGNS. THE HARNESS ASSEMBLY GETS VERY HOT. MAY ONE DAY CAUSE A FIRE. I HAVE REPLACED LIGHT BULBS 4 TIMES IN THE LAST MONTH. WILL HAVE TO GET SERVICED. *TR

Mileage: 43,447

TL* THE CONTACT OWNS 2005 CHEVROLET MALIBU MAX. THE CONTACT STATED THE AMBER LIGHT REFLECTOR WOULD BECOME ABNORMALLY HOT AND BURN THE PLASTIC HOUSING, CAUSING THE HEADLIGHTS TO FAIL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND THE DEALER ADVISED THE CONTACT THAT THE LIGHT BULB AND SOCKET WOULD NEED TO BE REPLACED. THE CONTACT DID NOT REPLACE THE LIGHT BULB OR THE LIGHT SOCKET. THE CONTACT STATED THERE WERE NUMEROUS COMPLAINTS ONLINE REGARDING THE LIGHT BULBS BURNING THROUGH THE HOUSING AND A RECALL SHOULD BE ISSUE. THE FAILURE MILEAGE WAS 34,000.

Mileage: 34,000

TURN SIGNAL ON MY 2005 CHEVY MALIBU MAXX. JUST LIKE SEVERAL OTHER COMPLAINT ON THIS SITE I HAVE HAD TO REPLACE BULBS MONTHLY IF NOT WEEKLY. I HAVE DISCOLERATION ON THE RIGHT FRONT LIGHT HOUSING FROM HEAT AND SOMETIMES SMELL THE SMELL OF SOMETHING ELECTRIC BURNING ALWAYS COMING FROM THE RECENTLY BURNED OUT BULB. DEALER WILL DO NOTHING BECAUSE CAR IS NO LONGER COVERED UNDER THE WARRANTY. *TR

Mileage: 105,000

2005 CHEVY MALIBU MAXX FRONT TURN SIGNALS BURNED OUT, BUT BEFORE THAT, THEY BURNED/MELTED THE PLASTIC GLOBE AROUND THE BULB. HAVE REPLACED BULBS NUMEROUS TIMES BEFORE, AND REPLACED BULB SOCKET (MELTED AND SHORTED) THIS TIME AROUND TOO. THIS MELTING AND SHORTING IS CERTAINLY A MFR. DEFECT AND SHOULD BE REPLACED OR FIXED BY CHEVROLET. CURRENTLY I'M TRYING TO FIND A WAY TO RUN LED BULBS TO AVOID THE HEAT, BUT CAN'T FIND AN ECONOMICAL WAY DUE TO THE NEED FOR RESISTORS (CREATING HEAT) OR NEW FLASHERS IN THE LINE IN ADDITION TO THE NEW BULBS. *TR

Mileage: 118,500

THE LIGHT BULBS NUMBER 3057 IN 2 OF MY CARS HAVE MELTED THE BASE AND DAMAGED THE LIGHT SOCKETS. AS A RESULT THE LIGHT WILL NOT ILLUMINATE PROPERLY. ONE VEHICLE IS A 2006 DODGE RAM 3500. THE BULB IS USED IN THE BRAKE LIGHT. WHEN IT FAILS YOU GET THE RUNNING LIGHTS BUT NOT THE BRAKE LIGHT. THERE IS NO WAY TO TELL INSIDE THE VEHICLE THAT THE BRAKE LIGHT IS NOT LIGHTING. THIS HAS A SERIOUS RISK OF BEING HIT FROM BEHIND. THE SECOND VEHICLE IS A 2005 CHEVROLET MALIBU MAX. BULB 3057 IS USED IN THE FRONT TURN SIGNALS WHICH DOUBLE AS THE DAYTIME RUNNING LIGHTS. ON THIS VEHICLE NOT ONLY DOES THE BASE OF THE BULB MELT BREAKING THE ELECTRICAL CONTACT THE PLASTIC LENS OF THE LIGHT IS MELTING. ONCE FAILURE OCCURS YOU MAY OR MAY NOT GET THE EXTRA FAST TURN SIGNAL INDICATOR. ON THE DRIVER SIDE OF THE VEHICLE THE BULB HAD TO BE REPLACED 4 TIMES IN SIX MONTHS. BOTH THE FACTORY BULBS MELTED AND THE SYLVANIA REPLACEMENT LONG LIFE BULBS FAILED. *TR

TURN SIGNALS STOPPED WORKING FOR SEVERAL WEEKS THAN BEGAN WORKING AGAIN. I'M REPLACING TURN SIGNAL BULBS EVERY YEAR. THE BULB WORKS INFREQUENTLY. *TR

Mileage: 164,400

2005 MALIBU MAXX LS- TICKING NOISE SHAFT WENT ROD TIRE ELECTRICAL PROBLEMS ENGINE ON BUT NOTHING IS REGISTERING CAR SEEM TO LOCK UP, SAME BRAKE LIGHT GOES OUT, CAR HESITATES,REPLACED BRAKES AFTER ONLY 2YR, NEW TIRE. I FILED A COMPLAIN WITH ATTORNEY GENERAL BILL MCCOLLUM. I HAVE INVOICES OF HOW MANY TIME MY CAR HAS GONE IN TO THE SHOP FOR MAJOR PROBLEMS AND EVER SINCE IT LOCK UP AND HESITATE I DON'T FEEL SAFE DRIVING IT. I DID FOUND OTHER CONSUMER WITH THE SAME COMPLAINS THAT I HAVE. THEY HAVE HAD TO REPAIR TIRE RODS, SHAFT AND MOST DANGEROUS IS THE STEERING COLUMN IS LOCKING UP. I DON'T FEEL SAFE DRIVING LONG DISTANCE OR ON THE HIGHWAY. PLEASE HELP ME. I WROTE TO GMAC VP TIMOTHY LEE WITH OUT NO RESPOND. MR. LEE PASSED MY COMPLAINT TO A CUSTOMER SERVICE REP THAT REPEATS HIMSELF AND WONT LET YOU SPEAK. PLEASE IF YOU WANT CONTACT ATTORNEY OFFICE THEY HAVE MY COMPLAINT ON FILE. I DON'T WANT TO HURT MYSELF OR SOMEONE ELSE SHOULD MY CAR LOCK UP. *TR

HAD TO REPLACE TAIL LAMPS AFTER CAR WAS 1 YEAR OLD AND 10,000 MILES ON IT. *TR

Mileage: 10,000

2005 CHEVROLET MALIBU MAXX (1) FRONT PARK/TURN/DRL LAMP INOPERATIVE AND OVERHEATING PROBLEMS. (2) REAR STOP/TURN/TAIL LAMP INOPERATIVE PROBLEMS. THIS CAR CURRENTLY HAS 41,000 MILES. THE LAMPS FOR THE LEFT FRONT (DRIVER SIDE)HAS BEEN REPLACED 5 TIMES AND RIGHT FRONT 3 TIMES. THE REAR LAMPS HAS BEEN REPLACED 3 TIMES EACH SIDE. MY MAJOR CONCERN AND CAUSE FOR THIS COMPLAINT IS THE OVERHEATING OF THE FRONT LAMPS (ITEM #1 ABOVE). THE UPPER SIDE AMBER PLASTIC HOUSING FOR THE LAMPS ON BOTH RIGHT AND LEFT HAS MELTED THROUGH AT THIS TIME. WHEN THE PROBLEM WAS FIRST DETECTED, THE AMBER HOUSING SHOWED SOME DISCOLORATION, BUBBLED PLASTIC. THIS SUGGESTED THE OVERHEATING PROBLEM EITHER HAS INTENSIFIED AND/OR THE PLASTIC HAS DEGRADATED OVER TIME. VISUAL INSPECTION SHOWED THE CHARRED/BURNT THROUGH AREAS ARE ADJACENT TO THE LAMP SOCKET. THIS INDICATES EXTREME SOCKET TEMPERATURE AND ALSO THE RISING HOT AIR AFFECT THE CEILING OF THE AMBER HOUSING. ALL THE BURNT OUT LIGHT BULBS SHOWED VARIOUS DEGREES OF CHARRING/MELTING/DEFORMATION ON THE PLASTIC BASE. THIS COULD HAVE BEEN CAUSED BY THE EXTREME HIGH TEMPERATURE AND ELECTRICAL ARCING. THE REAR IS NOT AS SEVERE AS THE FRONT BUT NEVERTHELESS, SLIGHT ARCING CAN STILL BE OBSERVED ON THE BASE OF THE BURNT OUT BULBS. THE LEFT FRONT LAMP WAS SERVICED BY A LOCAL CHEVROLET DEALER ONCE ON DEC. 16 2009 UNDER TECHNICAL SERVICE BULLETIN 06-08-42-004. DEALER DEEMED ONLY THE BULB NEEDS TO BE REPLACED BUT NOT THE SOCKET. PRIOR TO THIS, THE PROBLEM ALREADY EXISTED AND BOTH FRONT AND BACK BULBS REPLACED. THE FREQUENCY OF THE BULB REPLACEMENT AND SIGNS OF ARCING TRIGGERED THIS VISIT TO THE DEALER. THIS REPAIR BY THE DEALER HAS NOT FIXED THE PROBLEM. SIGNS OF OVERHEATING AS EVIDENCED BY THE MELTING PLASTIC SHOWED THE PROBLEM HAS WORSENED. FEARING THE EXTREME HIGH TEMP CAN CAUSE FIRE, I VISITED THE DEALER YESTERDAY FOR REPAIR UNDER GOOD WILL REPAIR WAS DENIED. THEY SIMPLY SAID THE CAR WAS OUT OF WARRANTY AND THIS IS NOT A FIRE HAZARD. *TR

Mileage: 6,500

LEFT FRONT SIGNAL LIGHT KEEPS BURNING OUT. HAS BEEN REPLACED 5 TIMES IN 6 MONTHS. BULBS LAST ONLY 2 WEEKS AT MOST. HAD SIGNAL LIGHT SOCKET REPLACED AND PROBLEMS STILL HAPPENED WITHIN TWO WEEKS. LIGHT BULBS TURN BLACK. TOOK CAR BACK AGAIN TODAY. STILL WAITING TO HEAR WHAT THEY SAY THIS TIME. LAST REPAIR 8/28/09 - 92.89 FOR THE LIGHT SOCKET, $1.50 BULB, $70.00 LABOR. NO LONGER HAVE PARTS. AFRAID I WILL GET IN ACCIDENT - SINCE LEFT SIGNAL LIGHT AND RUNNING LIGHT DO NOT WORK. KEEP HAVING TO GO BACK FOR NEW BULBS, AND IN FOR REPAIRS AGAIN TODAY 9/23/09. *TR

Mileage: 46,911

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE FRONT PASSENGER SIDE TURN SIGNAL BULB FAILED. ONE WEEK LATER, THE FRONT DRIVER'S SIDE TURN SIGNAL BULB ALSO FAILED. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE FAILURE CAUSED THE LIGHT HOUSING ASSEMBLY TO MELT. THE ESTIMATED COST FOR REPAIR WAS $1,000. THE CURRENT AND FAILURE MILEAGES WERE 78,000.

Mileage: 78,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU MAXX. THE CONTACT NOTICED THAT THE PARKING LIGHT HAD BLOWN OUT. SHE ALSO FOUND THAT THE FRONT PARKING LIGHTS WERE MELTED DUE TO THE LIGHT BULBS. THE BULB WAS REPLACED WITH A SYLVANIA BULB. THE FRONT PASSENGER SIDE LIGHT HAD A LARGE HOLE IN THE ORANGE AREA OF THE FIXTURE. THE ENTIRE FRONT LIGHTING ASSEMBLY NEEDED TO BE REPLACED AT THE COST OF OVER $100. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 60,000. THE ORIGINAL BULB MELTED THE ORANGE COVER INSIDE THE HEADLIGHT ASSEMBLY FOR THE PARKING LIGHTS. HOT PLASTIC DRIPPED ON THE BULB AND BURNED A HOLE IN THE BULB. UPDATED 06/22/09.*JB

Mileage: 60,000

I HAVE A 05 MALIBU MAXX MY TURN SIGNAL HAVE MELTED I SEE MANY COMPLAINTS IS THIS A RECALL? *TR

AMBER LENS ON TURN SIGNALS AND DAYTIME RUNNING LIGHTS HAS MELTED AND BURNED DOWN ONTO BULB. THIS HAS HAPPENED TO BOTH RIGHT AND LEFT TURN SIGNALS. *TR

Mileage: 49,766

WE OWN A 2005 MALIBUMAX, RECENTLY THE RIGHT FRONT TURN SIGNAL BULB DIED SO I REPLACED IT IN ACCORDANCE WITH THE OWNERS MANUAL. WHEN I OPENED THE LIGHTING UNIT TO REMOVE THE BULB I FOUND THE BULB HAD MELTED THE AMBER PLASTIC ENCLOSURE THAT SURROUNDS THE BULB. I THOUGHT THIS WAS ODD HOWEVER I THOUGHT MAYBE THE BULB HAS SHORTED OUT AND BURNED SINCE THE GLASS WAS SHATTERED. I THAN CHECKED THE RIGHT FRONT TURN SIGNAL WHICH WAS FUNCTIONING, I FOUND THAT THE BULB HAD MELTED THE AMBER ENCLOSURE AS WELL. THIS SEEMS LIKE A DEFECTIVE DESIGN THAT COULD CAUSE A FIRE. *TR

Mileage: 56,340

REPLACE A C/S L/F PARKING LAMP BURNED AND MELTED L/F HEADLAMP ASSEMBLY B C/S R/F PARKING LAMP BURNED AND MELTED R/F HEADLAMP ASSEMBLY. *TR

2005 CHEVY MALIBU HEADLIGHT OVER HEATING. CONSUMER STATES THAT THE FRONT COVER OF THE DAYTIME RUNNING LIGHTS AND TURN SIGNALS MELT. WHEN THE COVER DRIPS ONTO THE LIGHT BULB IT PUTS A HOLE IN THE BULB. *KB THE CONSUMER STATED THE PLASTIC COVERINGS WERE DISCOLORED ABOVE THE BULB DUE TO EXTREME HEAT WHICH WAS AN OBVIOUS DEFECTIVE DESIGN AND /OR IMPROPER BULB. NOT ONLY DID THE HEADLIGHTS FAIL, BUT THE RIGHT FRONT PARK AND SIGNAL LIGHT HAD TO BE REPLACED AS WELL. *JB

MY VEHICLE IS A 2005 CHEVY MALIBU MAXX. THE VEHICLE DOESN'T ALWAYS TURN OVER. I HAVE HAD MY VEHICLE IN THE SHOP A COUPLE OF TIMES TO DETERMINE THE PROBLEM AND THE CHEVY DEALER CAN'T FIGURE IT OUT. I WILL TRY TO START MY VEHICLE BUT IT DOESN'T ALWAYS CRANK OVER. IT WILL CHUG A LOT AND THEN STALL OUT. OTHER TIMES IT WILL CHUG AND ACT LIKE IT WILL STALL AND THEN TURN OVER. SOMETIMES IT TAKES 2-3 TIMES FOR ME TO TRY AND GET THE VEHICLE TO START. I CALLED MY SERVICE DEPARTMENT AT THE CHEVY DEALER EVERY TIME IT HAPPENED AND THE ONLY COMMON FACTOR WAS THAT IT WAS HAPPENING EVERY 800-1000 MILES APPROXIMATELY. IT DIDN'T MATTER HOW COLD OR HOT IT WAS, WET OR DRY. IT HAS BEEN AWFUL! NOTHING HAS BEEN REPLACED ON THE VEHICLE TO TRY AND FIX THE PROBLEM WITH IT STARTING. MY CAN HAS JUST OVER 32500 MILES AND IS STILL UNDER WARRANTY. THE MOST RECENT TIME WAS LATE SEPTEMBER 2006. I AM NOT SURE ON THE EXACT DATE THAT I CALLED MY CAR DEALER. I ALSO TOOK MY VEHICLE IN ON 9-12-06 FOR A POPPING SOUND IN THE STEERING WHEN TURNING. WE FOUND OUT THAT THE CENTER STEERING SHAFT WAS BROKE. IT WAS REPLACED. THERE WAS A PROBLEM WITH THE INTERIOR FRONT BLINKER NOT WORKING BUT THE EXTERIOR DID. THEN SHORTLY AFTER THE LEFT FRONT BLINKER BLEW. *JB

THE TURN SIGNALS KEEP BURNING OUT. I TOOK IT BACK TO THE DEALERS BUT WAS TOLD THAT MY WARRANTY HAD RUN OUT. SO I AM STUCK BUYING LIGHTS ALMOST EVERY WEEK. *NM

Mileage: 29,999