2005 CHEVROLET MALIBU Exterior Lighting Problems

The brake light stays on the whole time.

1st when got car from local dealer cruise control worked next day still hasn't, interior lights not working with new bulb, brake light on, leaking oil from pan, front end drifting, than at station no power steering, didn't know wtf, wheels didn't turn, shut off he later was there ignition switch will keep turning. Rins battery dead. I'm scared power steering will go out while driving. It's a scary thought, think I will sell .It's the worse recall I've heard of can they be fixed. Consumer has all 7 recalls.

STEERING WHEEL STARTED SHAKING SLIGHTLY IN AUGUST. NOW IT SHAKES AND THEN POWER STEERING GOES OUT. THIS HAPPENS ON THE HIGHWAY, CITY STREETS ANYWHERE GOING ANY SPEED. AS SOON AS THE CAR STARTS THE STEERING WHEEL SHAKES, OF YOU TURN THE WHEEL IN EITHER DIRECTION IT WILL CLAM IT A LITTLE. BREAK LIGHTS RANDOMLY STOP WORKING. REPLACED BREAK LIGHTS 6 TIMES IN THE PAST 2 YEARS. HEADLIGHTS MELT THE PLASTIC HAS BEEN GOING ON SINCE WE PURCHASED THE VEHICLE IN 2017. ALL OF THESE ISSUES HAVE BEEN RECALLED BUT NOT ON MY VIN.

Mileage: 99,000

MY PASSENGER SIDE HEADLAMP LIGHT (TURN SIGNAL) ASSEMBLY KEEPS BURNING OUT AND MELTING THE BULB HOUSING AND ORANGE LENS. IT BURNED A HOLE IN THE ORANGE TURN SIGNAL LENS. I REPLACE BULB AFTER BULB BUT IT KEEPS FAILING. PLEASE ISSUE A RECALL BECAUSE NO CAR OWNER SHOULD HAVE TO KEEP REPLACING BULBS CONSTANTLY ONLY FOR THEM TO FAIL OVER AND OVER AGAIN! THIS HAPPENS WHEN THE CAR IS STATIONARY, MOVING, ETC..

Mileage: 104,000

THE CAR IS HARD TO SHIFT OUT OF PARK, THE BREAK LIGHTS STAY ON WHILE DRIVING AND GO OFF WHEN PRESSED.

Mileage: 123,388

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE BRAKE LIGHTS INTERMITTENTLY FAILED TO ILLUMINATE WHEN DEPRESSING THE BRAKE PEDAL. ALSO, THE FRONT DRIVER SIDE WINDOW FAILED TO OPERATE AND WOULD NOT ROLL DOWN AND THE REAR PASSENGER DOOR COULD NOT BE UNLOCKED FROM INSIDE THE VEHICLE. FURTHERMORE, THE IGNITION KEY COULD BE REMOVED FROM THE IGNITION SWITCH WHILE DRIVING THE VEHICLE AND, AFTER STARTING THE ENGINE, THE VEHICLE SUDDENLY STALLED AND SHUT OFF. THE CAUSE OF THE FAILURES WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

REFERRED TO YOU BY GM AFTER DEALER REFUSED TO CONSIDER THIS A FREE REPAIR, AS MY VEHICLE IS NOT COVERED BY RECALL #13036D. VEHICLE IS EXHIBITING SAME CONDITIONS AS PER YOUR RECALL, BRAKE LIGHT REMAINS ILLUMINATED .PANIC-BRAKE ASSIST MALFUNCTIONED 2 WEEKS AGO; ALMOST RESULTING IN A REAR END COLLISION. THIS OCCURRED ON A 4 LANE HIGHWAY, AND VEHICLE BEGAN TO SKID. AT THAT POINT I RELEASED THE BRAKE, AND WAS FORCED TO PUMP THEM IN ORDER TO SLOW VEHICLE. PARK-BRAKE FEATURE ALSO MALFUNCTIONS RANDOMLY. THESE ARE ALL DUE TO VOLTAGE FLUCTUATIONS IN BODY CONTROL MODULE CONNECTION, REQUIRING A SPACER TO BE INSTALLED.

Mileage: 70,500

LOW BEAM HEADLIGHT CONTINUES TO SHORT OUT EVEN AFTER REPLACEMENT OF THE SOCKET ASSEMBLY.

Mileage: 158,331

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE EXTERIOR HEADLAMPS WOULD FUNCTION INTERMITTENTLY AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO SOUTHERN CHEVROLET (5845 COLISEUM BLVD, ALEXANDRIA, LA), BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT INDICATED THAT THE BULBS WERE PREVIOUSLY REPLACED AND THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 131,000. **TR *JS

Mileage: 131,000

THE FRONT TURNING SIGNALS HAVE NOT WORKED FOR 2 YEARS I HAVE HAD THE HEAD LIGHTS COMPLETELY REPLACE TWICE. THE SECOND TIME I HAD THEM REPLACED WHEN THE LIGHT HOUSING OF THE TURN SIGNALS WERE OPENED THE LIGHT BULB AND HOOK UPS WERE MELTED TOGETHER.

Mileage: 106,038

HEADLIGHTS AND TAIL LIGHTS ARE NOT WORKING THEY GO OUT ONCE A MONTH AND NOW THEY JUST OUT AND THIS CAR IS DEFIANTLY UNSAFE TO DRIVE. THE LOCKS GO UP AND DOWN WHILE DRIVING, AND AUTO LOCK IF LEFT RUNNING. GAS FUMES THROUGH OUT THE CAR. THESE ARE VERY SERIOUS PROBLEMS, ALSO I HAVE TWO TODDLERS THAT ARE FORCED TO RIDE IN THIS DEATH TRAP!!

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. ON SEVERAL OCCASIONS, THE DRIVER AND PASSENGER SIDE TURN SIGNAL BULBS FAILED TO OPERATE AS INTENDED. UPON INSPECTING THE BULB AND WIRING HARNESS, THE CONTACT BECAME AWARE THAT THE TURN LAMP HOUSING WAS MELTED, WHICH CAUSED THE TURN SIGNAL TO BECOME INOPERABLE. THE CONTACT STATED THAT THE BULB AND HOUSING WERE REPLACED ON THREE OCCASIONS; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO WHEELERS CHEVROLET GMC (2701 S MAPLE AVE, MARSHFIELD, WI 54449, (715) 502-4130) WHERE IT WAS DIAGNOSED THAT THE TURN SIGNAL HOUSING AND BULBS NEEDED TO BE REPLACED. THERE WAS NO REMEDY FOR THE FAILURE. THE CONTACT STATED THAT THE BULBS AND HOUSING WERE BEING REPLACED EVERY TWO MONTHS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. *TT *TR

Mileage: 85,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL). THE VEHICLE WAS TAKEN TO SMITH CHEVROLET CADILLAC AT (209) 632-3946 (1601 AUTO MALL DR, TURLOCK, CA 95380) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION SHIFT CABLE AND THE BRAKE LIGHTING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. LATER, WHILE PULLING IN THE DRIVEWAY, THE TRANSMISSION SHIFT CABLE FRACTURED WITHOUT WARNING AND THE BRAKE LIGHTS FAILED. THE VEHICLE WAS TAKEN BACK TO SMITH CHEVROLET CADILLAC, BUT THE DEALER REFUSED TO SERVICE THE VEHICLE. THE CONTACT STATED THAT THE REMEDY FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

Mileage: 87,000

HEADLIGHTS AND FRONT BLINKERS QUIT WORKING. WHEN I WENT TO CHANGE THENERGY-SAVING LIGHTS THE CONNECTORS WERE MELTED AND WIRES WERE EXPOSED. THE ORANGE LENSE ON THE DRIVERS SIDE HAS MELTED AND IS DISCONNECTED FROM THE FIXTURE AND IS LYING INSIDE THE LIGHT INCLOSURE. THE LIGHTS AND BLINKERS QUIT WORKING AS I WAS DRIVING THE VEHICLE. I CANNOT DRIVE THE VEHICLE AT NIGHT BECAUSE I AM AFRAID TO HAVE THE LIGHTS ON FOR FEAR OF POSSIBLE FIRST HAZARD. THE CRUISE CONTROL STOPPED WORKING AROUND THE END 2016

THE AMBER PLASTIC HOUSINGS ENCLOSING THE TURN-SIGNAL/DRL BULBS IN THE HEADLAMP ASSEMBLIES ON BOTH SIDES OF THE VEHICLE ARE MELTING, APPARENTLY DUE TO THE BULBS GETTING TOO HOT. THE MELTING PLASTIC HAS DRIPPED DOWN ONTO THE BULBS AND THE FUMES FROM THE MELTING PLASTIC HAVE FOGGED UP PART OF THE HEADLIGHT LENS. I AM VERY CONCERNED THAT THIS COULD CAUSE A FIRE. I PURCHASED THIS VEHICLE NEW. THE HEADLAMP ASSEMBLIES AND BULBS ARE ORIGINAL EQUIPMENT, SO THIS IS CLEARLY A DESIGN DEFECT.

Mileage: 57,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AND DEPRESSING THE BRAKE PEDAL, THE BRAKE LIGHTS FAILED TO ILLUMINATE. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE CONTACT ALSO STATED THAT ON A FEW OCCASIONS, THE BRAKE LIGHTS ILLUMINATED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE BRAKE STOP LAMP, BRAKE LAMP HARNESS AND BRAKE LIGHT POSITION SENSOR ALL NEEDED TO BE REPLACED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE RECURRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V252000 (SERVICE BRAKES, HYDRAULIC, ELECTRICAL SYSTEM, EXTERIOR LIGHTING, VEHICLE SPEED CONTROL, ELECTRONIC STABILITY CONTROL). THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.

Mileage: 152,000

THE TURN SIGNAL LIGHTS ARE BURNING OUT THE SOCKET AS WELL AS THE LIGHT COVERING. I HAVE TO REPLACE THE BULB IT SEEMS LIKE EVERY MONTH.

THE AMBER PLASTIC HOUSINGS ENCLOSING THE TURN-SIGNAL/DRL BULBS IN THE HEADLAMP ASSEMBLIES ON BOTH SIDES OF THE VEHICLE ARE MELTING, APPARENTLY DUE TO THE BULBS GETTING TOO HOT. THE MELTING PLASTIC HAS DRIPPED DOWN ONTO THE BULBS AND THE FUMES FROM THE MELTING PLASTIC HAVE FOGGED UP PART OF THE HEADLIGHT LENS. I AM VERY CONCERNED THAT THIS COULD CAUSE A FIRE. I PURCHASED THIS VEHICLE NEW. THE HEADLAMP ASSEMBLIES AND BULBS ARE ORIGINAL EQUIPMENT, SO THIS IS CLEARLY A DESIGN DEFECT. I HAVE READ MANY SIMILAR COMPLAINTS ABOUT OTHER 2005 MALIBUS IN VARIOUS INTERNET FORUMS, AND GM IS APPARENTLY NOT WILLING TO TAKE ANY RESPONSIBILITY FOR THE PROBLEM.

Mileage: 57,145

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKE LIGHTS STARTED TO FLASH. THE VEHICLE WAS REPAIRED BY THE DEALER IN AUGUST OF 2014 FOR THE SAME FAILURE. THE VEHICLE WAS DRIVEN HOME AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 02/03/17*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED TWICE, FOR THE SAME RECALL ISSUE. UPDATED 02/07/17.*JB

Mileage: 120,000

MY KEY WILL NOT TURN IN THE IGNITION AND I CHECKED FOR RECALLS. I CALLED THE DEALER TO FIX THE RECALL ON THE IGNITION, AND WAS NOTIFIED THAT THEY WOULD ONLY PUT A PIECE OF PLASTIC OVER KEY AND WOULD NOT FIX THE IGNITION TO TURN. I CAN HARDLY EVEN START MY CAR BECAUSE THE KEY WON'T TURN. THE KEY IS GOING TO BREAK OFF IN THE IGNITION. THE HORN AND RADIO DO NOT WORK EITHER. NOT HAVING A HORN FOR INCOMING TRAFFIC TOWARDS MY VEHICLE IS VERY DANGEROUS. THE TURN SIGNALS ONLY WORK AT RANDOM TIMES AND THAT IS VERY DANGEROUS WHEN SWITCHING LANES INTO TRAFFIC. ALSO, SOMETHING IN THE BACK OF THE CAR SQUEAKS FOR NO REASON WHEN GOING DOWN THE ROAD AT RANDOM AND WHEN GOING OVER SPEED BUMPS. THIS CAR ALSO DRAINS THE BATTERY WITH UNKNOWN ELECTRICAL PROBLEMS. THE DRIVERS SIDE BACK PASSENGER WINDOW WONT GO DOWN EITHER. THIS CAR HAS WAY TOO MANY SAFETY ISSUES FOR ONLY 137,000 MILES ON IT.

Mileage: 136

BOUGHT CAR USED AT 136,000 MILES. CAR RADIO DOES NOT LIGHT UP OR WORK, AND HORN DOESN'T WORK. DRIVERS SIDE BACK WINDOW WON'T GO DOWN. FIRST DAY DRIVING THE CAR, TURN SIGNALS STOPPED BLINKING AND THEN STARTED BLINKING AGAIN. SUSPENSION IN THE BACK SQUEAKS BADLY WHEN DRIVING AT RANDOM AND GOING OVER SPEED BUMPS. DID NOT DRIVE THE CAR FOR MORE THAN ONE DAY AND NOW CAR WON'T START AT ALL (NO CRANK, NO START). THESE ARE MAJOR SAFETY ISSUES INCLUDING SERIOUS ELECTRICAL PROBLEMS. THE BATTERY IS ONLY ONE YEAR OLD ON THE CAR WHEN PURCHASED, SO SHOULD BE GOOD. THESE ELECTRICAL ISSUES NEED TO BE RECALLED. NOW I AM STUCK WITH A CAR THAT HAS SO MANY PROBLEMS AND WON'T START AND IS DEFINITELY NOT SAFE TO DRIVE.

Mileage: 136,000

I'M HAVING AN ISSUE WHERE'S I'M SCARED I WILL BE IN A CAR ACCIDENT. MY ENGINE LIGHT COMES ON THEN MY TC LIGHT THEN MY CAR SAY ENGINE POWER REDUCE IN THE CAR WILL JUST SHUT OFF.

Mileage: 223,600

TAKATA RECALL. STEERING LOCKED UP WHILE DRIVING GOING AROUND A CORNER AND TOOK A FEW MINUTES TO GET IT TO UNLOCK. HAPPENED TO MY WIFE WITH OUR SON IN THE CAR. THIS HAPPENED BEFORE WE GOT THE RECALL. GOT THE RECALL FIXED AND NOW THE POWER STEERING WARNING LIGHT IS COMING ON. HEADLIGHT ARE CONSTANTLY BLOWING BULBS. THE HEADLIGHT WILL GO OUT SO I WILL GO TO REPLACE THE BUILD AND THEN IT COMES BACK ON. FRONT RIGHT TURN SIGNAL GOES OUT A LOT AND IF I TAP ON IT THEN IT COMES BACK ON. THE SAME WITH THE REAR TAIL LIGHT GOES OUT OFTEN. THIS SUMMER THE TRACTION CONTROL WOULD DING AND THE BUTTON WOULD NOT TURN IT ON OR OFF. WHEN DID THIS HAPPEN QUESTION DOESN'T MAKE SENSE. IT IS A ON GOING EVENTS.

Mileage: 220,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING AT LOW SPEEDS AND DEPRESSING THE BRAKE PEDAL, THE BRAKE LIGHTS WOULD NOT ILLUMINATE AND THE CRUISE CONTROL SEIZED WITHOUT WARNING. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, SERVICE BRAKES, VEHICLE SPEED CONTROL), BUT THE REPAIR DID NOT REMEDY THE FAILURES. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000.

Mileage: 54,000

I BOUGHT MY CAR IN 2013 AND IT'S BEEN A DECENT CAR. HOWEVER IT IS THE 2ND MALIBU THAT I'VE OWNED AND IT'S GOT THE SAME ISSUES. THE RUNNING LIGHTS HAVE AN ELECTRICAL ERROR WHERE THEY SHORT OUT AND MELT THE ACTUAL LIGHTS. I'M CONSTANTLY HAVING TO REPLACE THE BULBS. I'VE GOTTEN TO WHERE I JUST TURN THEM OFF. THE 2ND THING HAPPENED TODAY. MY FIRST MALIBU DIDN'T HAVE A SUNROOF BUT THIS ONE DOES. I WAS DRIVING ON THE INTERSTATE WHEN ALL THE SUDDEN I HEARD THIS LOUD EXPLOSION, LIKE A GUNSHOT OR A SEMI TRUCK TIRE BLOWING UP. I LOOK ALL AROUND ME AND WHEN I LOOKED UP, GLASS WAS FALLING ON MY HEAD. MY SUNROOF RANDOMLY EXPLODED. AND ACCORDING TO SEVERAL MECHANICAL ENGINEERS, IT'S PHYSICALLY IMPOSSIBLE FOR AN OBJECT FLUNG BY ANOTHER VEHICLE TO SHATTER A SUNROOF. APPARENTLY MANUFACTURERS HAVE STARTED GETTING LAZY WITH SUNROOFS WHEN MAKING CARS, SO IF I WERE YOU, I WOULDN'T BUY A CAR WITH A SUNROOF.

Mileage: 85,000

THE PARK LIGHT/DAYTIME RUNNING LIGHTS ARE CONSTANTLY MELTING THE AMBER LENS. THE BULB SOCKET MELTS CAUSING THE TURN SIGNAL NOT TO WORK. EVERY FEW MONTHS I HAVE TO REMOVE HEADLIGHT LAMP AND FIX BULB SO IT WILL WORK. I HAVE SEEN A NUMBER OF PEOPLE WITH THE SAME PROBLEM WITH THEIR MALIBUS. CHEVROLET NEEDS TO FIX THIS PROBLEM. THIS SHOULD BE A RECALL AS MANY AS ARE HAVING THIS PROBLEM.

Mileage: 194,000

THE FRONT DRIVER TURN SIGNAL DOES NOT WORK, IT HAS MELTED THE PLASTIC INSIDE. I HAVE CHANGED THE BULB SEVERAL TIMES AND IT CONTINUES TO BURN OUT. THE PASSENGER TURN SIGNAL IS NOW BLINKING VERY FAST AND THEN SLOW SO I'M GUESSING IT WON'T BE LONG BEFORE THAT ONE DOESN'T WORK. ALSO THE DRIVERS SIDE REAR BLINKER AND BRAKE LIGHT DO NOT WORK. ALL OF THIS IS A HAZARD WHEN DRIVING AND COULD EASILY CAUSE AN ACCIDENT. I HAVE HEARD OF NUMEROUS PEOPLE HAVING THESE SAME ISSUES AND THIS NEEDS TO BE RESOLVED. CLEARLY THIS IS A MANUFACTURER PROBLEM. I WOULD APPRECIATE YOUR PROMPT RESPONSE AND RESOLUTION. THANK YOU. *TR

TL* THE CONTACT OWNED A 2005 CHEVROLET MALIBU. WHILE TRAVELING APPROXIMATELY 35 MPH, THE LOW BEAM HEADLAMP ASSEMBLY FAILED TO WORK. THE CONTACT APPLIED THE BRAKE PEDAL, WHICH DID NOT RESPOND AND EXTENDED TO THE FLOORBOARD. THE CONTACT STATED THAT THE VEHICLE SPUN AROUND AND CRASHED INTO A GUARDRAIL. THE CONTACT WAS UNABLE TO CONFIRM IF THE AIR BAGS DEPLOYED. THE CONTACT WAS UNCONSCIOUS AND WAS TRANSPORTED TO THE HOSPITAL. THE DRIVER SUSTAINED HEAD INJURIES, BROKEN WRISTS, A PUNCTURED AND COLLAPSED LUNG, AND ADDITIONAL INTERNAL INJURIES THAT REQUIRED MEDICAL TREATMENT. THE CONTACT ALSO STATED THAT HIS TEETH WERE FRACTURED FROM HIS MOUTH DUE TO THE IMPACT OF THE CRASH. A POLICE REPORT WAS FILED. THE CONTACT ALSO RECEIVED SEVERAL RECALL NOTIFICATIONS PERTAINING TO NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

DRIVER SIDE FRONT TURN SIGNAL LAMPS ARE BURNING OUT IN ONE TO TWO WEEKS EVEN WHEN REPLACED WITH GM PARTS. BOTH REAR TURN SIGNALS LAMPS ARE ALSO BURNING OUT QUICKLY.

Mileage: 137,000

THE TURN SIGNAL BULBS GET TOO HOT AND MELTS INTO THE SOCKET WHICH MAKES THE CONNECTION GO BAD. EVEN IF YOU CHANGE THE BULB THE CONNECTION IS BAD SO THE SOCKET HAS TO BE CHANGED. THIS HAS HAPPENED ON BOTH OF THE FRONT BULBS

HEAD LAMP BULBS AND TURN SIGNAL BULBS HAVE REPEATEDLY BURNT OUT. BULBS HAVE BEEN REPLACED BY CERTIFIED GM SHOP ONLY TO BURN OUT AGAIN.

Mileage: 118,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ENGAGED, THE CRUISE CONTROL DEACTIVATED AND THE BRAKE LIGHTS ILLUMINATED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE BRAKE LIGHTS TURNED OFF. THE CONTACT POWERED THE VEHICLE OFF AND BACK ON AND THE BRAKE LIGHTS RESUMED NORMAL OPERATION. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LIGHT SWITCH WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 199,000.

Mileage: 199,000

AFTER A FEW DAYS OF OWNING THIS CAR I NOTICED THERE WAS AN ISSUE WITH THE BRAKE LIGHTS TURNING ON WHILE DRIVING. WHEN THIS HAPPENS IT ALSO SHUTS OFF THE CRUSE CONTROL TOO. WHEN YOU FIRST PRESS THE BRAKES THE LIGHTS SHUT OFF. PRESS THEM AGAIN AND THEY WORK FOR A FEW MINUTES. I SEARCHED THE INTERNET FOR HELP, AND NOTICED GM POSTED A SERVICE BULLETIN ON THIS ISSUE. GM ADVISED TO CLEAN, AND GREASE CONTACTS FOR BCM. I DID JUST THAT. THE CLEANING WAS ONLY A TEMPORARY FIX BECAUSE THE ISSUE RETURNED DAYS LATER. AROUND MAY OF 2014 I RECEIVED NOTICE THAT GM ISSUED SEVERAL RECALLS. THE CAR HAD BEEN BROKE DOWN UNTIL FEBRUARY OF 20015, AND IN APRIL IT WAS SENT TO MY LOCAL CHEVROLET DEALER TO HAVE THE RECALLS FIXED. SHORTLY AFTER FIXING THE RECALL ISSUES THE BRAKE LIGHT ISSUES RETURNED. I CONTACTED GM/ CHEVROLET AND THEY CONTACTED MY LOCAL DEALER WHO AGREED TO LOOK AT THE CAR AGAIN FOR FREE. AFTER THEY INSPECTED IT I WAS TOLD THE BRAKE SWITCH NEEDED REPLACED. ON MAY 28, 2015 MY LOCAL CHEVY DEALER REPLACED THE SWITCH. ON MAY 30, 2015 THE BRAKE LIGHT ISSUE RETURNED. THIS IS A FAMILY CAR AND IM AFRAID THAT SOMEONE WILL END UP HITTING US. CAN YOU PLEASE HELP.

Mileage: 201,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT BLINKER BULBS WERE BURNING THE BULB COVERS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000. UPDATED 8/27/15*CN UPDATED 10/4/2017*CN

Mileage: 75,000

PASSENGER SIDE FRONT TURN SIGNAL BULB BURNS OUT FREQUENTLY. IT ALSO WILL WORK ONE DAY AND SUDDENLY STOP WORKING THE NEXT DAY, THEN WORK AGAIN LATER WITHOUT HAVING DONE ANY INTERVENTION AT ALL. IF I WIGGLE THE BULB JUST RIGHT WITHIN THE SOCKET, I CAN GET IT TO WORK. SOMETHING AS SIMPLE AS RUNNING INTO A POTHOLE CAN MAKE THE BULB UNIT WORK OR CEASE WORKING. *TR

Mileage: 200,000

2005 CHEVROLET MAILBU. THE CONSUMER WAS DISSATISFIED WITH THE SERVICES OF THE RECALL. UPDATED 02/12/15*BF THE CONSUMER RECEIVED TWO RECALL NOTICES. RECALL# 14V252000 AND 14V224000. *JB

I HAD TO BUY A TRANSMISSION FOR MY MALIBU AND NOW I AM RECEIVING RECALLS (MULTIPLE) # 14152 & #13036 FOR THE SAME CAR. HOWEVER, ON THE FREEWAY COMING HOME FROM TEMECULA, CA, SOUTH BOUND ON THE 15 HIGHWAY, MY TRANSMISSION WAS NOT ENGAGING. NO LOUD SOUNDS, OR EXCESS ACCELERATION, NOR TOO MUCH WEIGHT (DRIVER AND PASSENGER ONLY CARGO.) THE ENGINE WAS ON AND AS I ACCELERATED THE ENGINE WAS GOING BUT NOTHING WAS PROPELLING US FORWARD. I HAD TO BUY A NEW TRANSMISSION AND PAY FOR LABOR WHICH CAME OUT TO A HEFTY EXPENSE. WITH EVERYTHING I HAVE READ ONLINE AND FORUMS FOR THESE RECALLS I FEEL LIKE A REIMBURSEMENT SHOULD BE IN ORDER IF THE MANUFACTURE EVEN HAD A SLIGHT HESITATION OF A POSSIBLE DEFECT. *TR

Mileage: 90,000

2005 CHEVROLET MALIBU. CONSUMER RECEIVED A RECALL NOTICE STATING THE PARTS FOR THE VEHICLE ARE NOT IN STOCK. CONSUMER WOULD LIKE TO KNOW IF THEY SHOULD WAIT FOR THE PARTS OR WILL THEY BE REWARDED A NEW VEHICLE. RECALL # 14V252000. *JB

MY FRONT BLINKER LIGHTS HAVE MELTED THE BLINKER LIGHT HOUSING (THE INDIVIDUAL PLASTIC GLOBE THE BULB RESIDES IN). THEY HAVE TO BE REPLACED AT A RATE OF APPROXIMATELY 6 MONTHS AND I BELIEVE IT IS THE CAR NOT THE LIGHTS AS I HAVE TRIED DIFFERENT BRANDS TO SEE IF THE PROBLEM IS WITH THE BULBS. **NOTE: AS I HAVE NOT KEPT A RECORD OF THE INCIDENTS, I HAVE LISTED THE LAST TIME AS PRECISE DATE. *TR

Mileage: 116,603

BULB DESIGN FLAW: IT BURNS HOT AND MELTS THROUGH BULB SOCKET. ORIGINAL BULB 3157 BURNS PLASTIC HOUSING ON FRONT DIRECTIONAL TURN SIGNALS ON MALIBU. IT IS A LIABILITY ISSUE - FAULTY DESIGN MADE FOR FAILURE AND POSSIBLE MAJOR FIRE HAZARD ISSUES. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HORN AND SIGNAL LIGHTS FAILED TO OPERATE. IN ADDITION, THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

Mileage: 130,000

2005 CHEVROLET MALIBU. CUSTOMER DOES NOT OWN VEHICLE ANYMORE. WOULD LIKE TO STOP RECEIVING RECALL NOTICES. *TA

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING), AND NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE CONTACT STATED THAT THE PARTS NEEDED WERE UNAVAILABLE TO REPAIR THE VEHICLE UNDER THE RECALLS. THE DEALER WAS UNABLE TO INFORM WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHTS ILLUMINATED WHEN THE BRAKE PEDAL WAS NOT DEPRESSED. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, A BURNING ODOR WAS PRESENT INSIDE THE VEHICLE. AFTER EXAMINING THE VEHICLE THE CONTACT DISCOVERED THAT THE BURNING ODOR WAS COMING FROM THE HEAD LIGHTS. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE HEAD LIGHT WIRE HARNESS WAS FAULTY. THE VEHICLE WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000.

Mileage: 30,000

FRONT TURN SIGNAL SOCKETS MELTED. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN), NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING), AND NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 141V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I GOT AN IMPORTANT SAFETY RECALL MESSAGE IN THE MAIL. SO I NEED TO MAKE AN APPOINTMENT AND I WANT TO DO IT ONLINE. THE REASON FOR BEING RECALLED SHOULD BE IN YOUR RECORDS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HEADLIGHT COVERS BECAME FOGGY CAUSING VISIBILITY AT NIGHT TO BECOME DIFFICULT. THE VEHICLE WAS TAKEN TO A DEALER AND THE HEAD LIGHT COVERS WERE REPLACED. THE REPLACED HEADLIGHT COVERS BECAME FOGGY AFTER SOME TIME. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE MILEAGE WAS 10,000.

Mileage: 10,000

DAY TIME RUNNING LIGHTS IN HEADLIGHTS OVERHEAT MELTING BULB BASE AND SOCKET. HAVE BEEN REPLACED MULTIPLE TIMES AND KEEPS HAPPENING. AFRAID OF POTENTIAL ELECTRICAL FIRE OR BULBS BURN OUT AND BLINKERS WILL NOT WORK WHICH COULD CAUSE A WRECK. *TR

Mileage: 55,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BE AVAILABLE. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) AND NHTSA CAMPAIGN NUMBER: 14V224000 (POWER TRAIN). THE CONTACT MENTIONED THAT THE VEHICLE HAD EXHIBITED THE FAILURE RELATED TO THE STEERING MULTIPLE TIMES. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Mileage: 150,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED FOR THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE DEALER DID NOT KNOW WHEN THE PART WOULD ARRIVE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DRIVER'S SIDE-TURNING SIGNAL FAILED TO ACTIVATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHO STATED THAT THE LIGHT FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Mileage: 10,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DRIVER'S SIDE-TURNING SIGNAL FAILED TO ACTIVATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHO STATED THAT THE LIGHT FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Mileage: 10,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING FAILED INTERMITTENTLY. THE CONTACT STATED THAT THE VEHICLE RESUMED NORMAL FUNCTIONED IMMEDIATELY AFTER BEING RESTARTED. THE CONTACT MENTIONED THAT HE RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) AND NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED THE REASONABLE AMOUNT OF TIME FOR THE REPAIRS. THE DEALER STATED THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN FOR DIAGNOSTIC TEST. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 87,000. UPDATED 08/27/14*LJ UPDATED 09/18/2014 *JS

Mileage: 70,000

WHILE TRAVELING HOME I WAS PULLED OVER BY A STATE TROOPER. I WAS TOLD I WAS NOT USING MY SIGNAL LIGHTS AND MY BRAKE LIGHTS WERE NOT WORKING. FOR THE PAST FEW WEEKS MY ABS LIGHT HAS BEEN COMING ON BUT I JUST HAD BRAKES PUT ON MY CAR. WHEN I DRIVE IN THE RAIN MY BRAKE PETAL GOES ALMOST TO THE FLOOR BEFORE I CAN STOP AND MY CAR MAKES STRANGE SCRUBBING NOISES FROM TIME TO TIME. AS ADVISED I HAD MY LIGHTS CHECKED BY A PROFESSIONAL AND IT WAS FOUND MY LIGHTS SEEMED TO BE BURNED/MELTED AT THE BOTTOM WHERE THE BULBS CONNECT TO THE BASE. I HAVE REPLACED THEM SEVERAL TIMES AND DO NOT UNDERSTAND WHY THEY HAVE TO BE REPLACED SO OFTEN. DUE TO THESE ISSUES I AM AFRAID TO DRIVE IN THE RAIN AND CONSTANTLY CHECK MY BRAKE AND SIGNAL LIGHTS. *TR

Mileage: 156,350

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHTS FAILED TO ILLUMINATE WHEN BEING DEPRESSED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BULB NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V252000( ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL ). THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

Mileage: 155,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHTS FAILED TO ILLUMINATE WHEN BEING DEPRESSED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE BULB NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V252000( ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL , EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC , VEHICLE SPEED CONTROL ). THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

Mileage: 155,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TRAVELING 40 MPH, THE INSTRUMENT PANEL LIGHTS FAILED. THE CONTACT MENTIONED THAT THE DIRECTIONAL SIGNALS INDEPENDENTLY ACTIVATED WITHOUT BEING ENGAGED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 9,127.00.

Mileage: 9,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TRAVELING 40 MPH, THE INSTRUMENT PANEL LIGHTS FAILED. THE CONTACT MENTIONED THAT THE DIRECTIONAL SIGNALS INDEPENDENTLY ACTIVATED WITHOUT BEING ENGAGED. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 9,127.00.

Mileage: 9,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE DAY TIME RUNNING LIGHTS ON THE PASSENGER'S SIDE MALFUNCTIONED. THE LIGHT OVER HEATED AND MELTED THE BULB SOCKET. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT REPAIRED OR DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 23,000.

Mileage: 23,000

THE DRIVERS SIDE TURN SIGNAL BULB KEEPS BURNING OUT. I HAVE REPLACED THE BULB TWICE BUT IT CONTINUES TO BURN OUT. THERE ARE MANY OTHER COMPLAINTS ABOUT THIS ISSUE. *JS

THE CAR STOPS WHEN DRIVING ALSO THE EXTERIOR LIGHT HAVE BURNED OUT THE CASING THAT HOLDS THE BULBS ARE MELTED. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE PASSENGER SIDE TURN SIGNAL FAILED. THE CONTACT MENTIONED THAT AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE BULB HAD OVERHEATED AND CAUSED THE MATERIAL OF THE CASING TO MELT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 95,000.

Mileage: 95,000

WHILE TURNING LEFT THE ORANGE GLOBE IN THE HEADLIGHT ASSEMBLY MELTED AND CAUSED LIGHT BULB TO BURN PLASTIC. I CONTACTED THE COMPANY GENERAL MOTORS BEFORE ABOUT THE DISCOLORATION OF MY HEADLIGHT ASSEMBLY AND THEY SAID THEY HAD NOT RECEIVED ANY PRIOR COMPLAINTS. I WORK FOR A PARTS STORE AND I HAD NOTICED ALMOST EVERY (80%) 2005 THAT CAME IN FOR LIGHT BULB REPLACEMENT HAS THIS PROBLEM. MY DAUGHTER HAS A MALIBU MAX 2005. SHE HAD TO REPLACE HER ASSEMBLIES WHICH HAD BURNED WORSE, AFTER SHE WENT TO LOCAL CHEVROLET DEALER AND THEY WOULD NOT REPLACE THEM. SHE PURCHASED AFTER MARKET LIGHTS AT ABOUT $65 EACH VERSUS THEIR $165 PRICE NOT COUNTING LABOR THEY WOULD OF CHARGED. IT'S VIN #[XXX]. GM HAS A PROBLEM AND WILL NOT DO ANYTHING TO FIX IT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 10,143

WAS TOLD BY A DRIVER WHO HAD BEEN BEHIND ME COMING UP TO A TRAFFIC LIGHT THAT MY BRAKE LIGHTS WERE NOT WORKING. SHE SAID IT LOOKED AS THOUGH THEY WERE ON WHILE I WAS ACCELERATING AND WENT OFF WHEN I WAS STOPPING. I HAVE REPLACED THE BRAKE LIGHT DIAGNOSTIC RESISTOR AND IT HASN'T DONE ANYTHING. I ALSO HAVE HAD ISSUES WITH GETTING THE CAR OUT OF PARK AND WITH THE CRUISE CONTROL REFUSING TO ENGAGE OR DISENGAGING ITSELF. I UNDERSTAND NOW THAT THESE ARE REOCCURRING PROBLEMS FOR THIS CAR AND IT HAS SOMETHING TO WITH TERMINAL FRETTING CORROSION IN THE BODY CONTROL MODULE BUT THERE HAS BEEN NO RECALL FOR THIS PROBLEM. WHEN I BOUGHT THE CAR LESS THAN A YEAR AGO, THERE WAS NO MENTION OF THIS PROBLEM. I HAVE NO IDEA HOW LONG THE BRAKE LIGHT PROBLEM HAS EXISTED SINCE NO ONE HAS TOLD ME ABOUT IT BEFORE THIS BUT THE CRUISE CONTROL ACTED FUNNY EVEN WHEN I WAS TEST DRIVING THE VEHICLE BEFORE PURCHASE. I MENTIONED IT TO THE SALESPERSON AND HE SAID THEY WOULD CHECK IT OUT. IT WORKED THE NEXT TIME I TEST DROVE IT BUT HAS FREQUENTLY NOT WORKED AFTER I ACTUALLY BOUGHT IT. GETTING THE CAR OUT OF PARK HAS BEEN A PROBLEM ON SEVERAL OCCASIONS SINCE I BOUGHT IT.

Mileage: 92,800

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE BRAKE LIGHTS WERE ILLUMINATED INDEPENDENTLY WITHOUT THE BRAKES BEING APPLIED. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 153,000. *TR

Mileage: 153,000

I CAN'T GO A WEEK WITHOUT BOTH HEADLIGHT ASSEMBLIES BURNING TURN-SIGNAL BULBS. AFTER REPLACING THE BULBS NO MORE THAN A WEEK WILL GO BY AND THE BULB WILL TURN BLACK AND SOMETIMES BLOW UP INSIDE THE HEADLIGHT. RECENTLY THE BULBS ARE NOT BURNING OUT BUT WHAT SEEMS TO BE A BAD CONNECTION TO THE SOCKET, I WILL PRESS THE BULBS INTO THE SOCKET AND WITHIN 5 MINUTES THE TURN-SIGNALS WILL NOT WORK AGAIN. *TR

I HAVE HAD MY CAR SINCE 2009 AND IN 2010 I STARTED HAVE TO CHANGE MY TURN SIGNALS OUT AT LEAST ONCE A MONTH FOR BURNING OUT. THERE ARE TIME THAT THE BULB WILL GET SO HOT THAT IT BLOWS THE INSIDE OF THE BULB UP AND AROUND THE PLUG WHERE THE BULB GOES IN HAS DARK MARKS HAS TO IF THEY ARE BURN MARKS. I CALLED CHEVROLET AND THEY SAID THAT THERE WAS NOTHING THEY COULD DO BECAUSE THERE WAS NO RECALL ON THEM. THE BACK TURN SIGNALS DO THE SAME AND THERE HAVE BEEN MANY TIMES THAT I WOULD ALMOST GET HIT DUE TO THIS PROBLEM. I HAVE DONE RESEARCH AND HAVE FOUND THAT MY CAR IS NOT THE ONLY ONE HAVING THE SAME PROBLEM THAT ALOT OF 2005 MALIBUS ARE. I AM AFRAID AT THIS POINT THAT IT IS GOING TO CAUSE AN ELECTRICAL FIRE IN MY CAR. I FEEL THAT GM SHOULD HAVE A RECALL ON THE PROBLEM BEFORE SOMEONE REALLY GETS HURT. *TR

Mileage: 60,000

WE BOUGHT THIS CAR 4 YRS AGO IN AUG 2008 AT ONLY A FEW YRS OLD WE WERE VERY OPTIMISTIC THAT THE $ WE WERE SPENDING ON IT WOULD BE WORTH THE LESS UPKEEP THAN THAT OF THE 1994 CROWN VIC THAT WE TRADED IN (& MY HUSBANDS 78 OLDS THAT HAS ALWAYS REQUIRED MORE WORK THAN IT PUT OUT SINCE HE PURCHASED IT WHEN WE MET BACK IN 06). SINCE IT WAS A FEW YRS OLD WE THOUGHT THAT EVEN THOUGH THERE WAS NO WARRANTY ON OUR NEW "USED" CAR, WE WOULD BE OK. WE WERE WRONG. THE FIRST PROBLEM WE NOTICED WAS THE ALIGNMENT WHICH MAKES THE CAR SHAKE/VIBRATE AT SPEEDS 60+ & OUR FIRST VACATION WE TOOK IT ON WHICH WE ONLY DROVE 4-5 HRS THERE & WE ENDED UP WITH 2 FLAT TIRES ON THE WAY. THEN THE HEADLIGHTS & BLINKERS HAD TO BE REPLACED (FULL UNITS) BC BOTH OF THEM KEPT GIVING OUT & THE BULBS WEREN'T THE PROBLEMS & I KEPT GETTING TRAFFIC TICKETS BC I WASN'T ALWAYS AWARE WHEN ONE WOULD GO OUT. OUR 2 BIGGEST PROBLEMS TO DATE HAVE BEEN OUR FUEL SENSOR/ELECTRICAL PROBLEMS WHICH QUIT WORKING AFTER 1 YR & I HAVE RUN OUT OF GAS 10 TIMES BC IT ISN'T EASY TO KEEP UP WITH MILES/DATES & I HAVE KIDS SO FILLING UP EVERY DAY ISN'T EASY EITHER AS WELL AS THE LOCKS/BUTTONS ON THE DRIVERS DOOR THAT DO NOT WORK & I HAVE TO OPEN MY TRUNK WITH A KEY & HAD TO PAY $ TO GET AUTO LOCK SO THAT I DON'T HAVE TO MANUALLY LOCK THE DOORS W/ THE KEYS & THE TRANSMISSION/MOTOR WE HAD TO PAY $2750 TO REPLACE BC THE LAST ONE COMPLETELY GAVE OUT RESULTING IN THE CAR NOT BEING ABLE TO RUN WHATSOEVER & MY HUSBAND HAVING TO LITERALLY PUSH MY NEUTRAL CAR WITH HIS BC WE DIDN'T HAVE THE $ AT THE TIME TO FIX IT.. BESIDES THESE PROBLEMS THERE ARE THE SEATS (PLASTIC PANELS) FALLING/CRACKING APART, WE HAD TO REPLACE THE WINDSHIELD BC ANYTIME IT RAINED OUR SEATS WOULD BE COMPLETELY SOAKED.. & MANY OTHER PROBLEMS I STILL DEAL WITH. KEEP IN MIND FOR THE 4 YRS I HAVE OWNED THIS CAR I HAVEN'T WRECKED IT & MY HUSBAND KEEPS IT UP (CHANGES OIL, BRAKES,ETC). *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT BOTH HEADLIGHTS STOPPED ILLUMINATING. THE CONTACT EXAMINED THE HEADLIGHTS AND NOTICED THAT THE BULBS BURNED OUT AND MELTED THE HOUSING ASSEMBLY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE TURN SIGNALS CONTINUED TO BURN OUT. THE CONTACT STATED THE TURN SIGNAL BULBS WOULD FAIL IMMEDIATELY AFTER THEY WERE REPLACED. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR A DIAGNOSTIC TEST. THE TEST RESULTS SHOWED A DEFECTIVE HEADLIGHT ASSEMBLY. THE DEALER SUGGESTED THAT BOTH HEADLIGHT ASSEMBLIES BE REPLACED. THE CONTACT DID NOT HAVE THE HEADLIGHT ASSEMBLIES REPLACED. THE FAILURE MILEAGE WAS 86,987. UPDATED 9/13/12 *CN THE CONSUMER STATED THE LACK OF THE FRONT TURN SIGNALS FAILED TO WARN ONCOMING TRAFFIC, THAT HE WAS IN THE PROCESS OF TURNING AND COULD RESULT IN A HEAD ON COLLISION. UPDATED 09/20/12

Mileage: 86,987

BRAKE LIGHTS REMAIN ON WITH NO CONTACT WITH BRAKE PEDAL. WHEN PEDAL IS DEPRESSED THE BRAKE LIGHTS GO OFF. THIS HAS CAUSED NUMEROUS 'ROAD RAGE' INCIDENTS AND NEAR-MISS REAR-END COLLISIONS. *TR

Mileage: 102,000

FRONT TURN SIGNAL BULBS (LEFT AND RIGHT) HAVE MELTED THE PLASTIC HOUSING SURROUNDING THEM. BULBS BURNOUT EASILY. EVIDENCE OF MELTED PLASTIC IS A CONCERN FOR OTHER ELECTRICAL PROBLEMS. *TR

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT NOTICED THAT BOTH HEAD LIGHT CASINGS WERE MELTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 91,000.

Mileage: 80,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE APPLYING THE EMERGENCY BRAKE, THE EMERGENCY BRAKE CABLE FRACTURED. THE CONTACT ALSO STATED THAT THE DAYTIME RUNNING LIGHTS WERE BECOMING EXTREMELY HOT AND MELTING THE HEADLIGHT LENS. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR INSPECTION OR REPAIRS. THE FAILURE MILEAGE WAS 88,000. UPDATED 03/05/12*LJ THE CONSUMER STATED THE DAY TIME RUNNING LIGHTS KEPT MALFUNCTIONING, BECAUSE THEY WERE GETTING TOO HOT. THE CONSUMER NOTICED IT, BECAUSE THE TURN SIGNALS KEPT MALFUNCTIONING. HE THOUGHT THE BULB BURNED OUT, BUT SOON DISCOVERED IT WASN'T BURNED OUT. THE CONSUMER NOTICED THE PLASTIC CLEAR LENS HAD MELTED. UPDATED 03/08/12

Mileage: 88,000

THE FRONT DRIVING LIGHTS AND TURN SIGNALS BLOW OUT CONSISTENTLY, USUALLY DAMAGING THE SOCKET IN THE PROCESS. *TT

Mileage: 135,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HEADLIGHTS WERE CONSTANTLY OVERHEATING AND BURNING OUT, CAUSING THEIR PLASTIC COVERS TO MELT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 147,000.

Mileage: 147,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT DRIVER SIDE TURN SIGNAL WAS NOT FUNCTIONING. THE CONTACT REPLACED THE HEADLIGHT BULB APPROXIMATELY FIVE TIMES. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE BULB BECAME EXTREMELY HOT, CAUSING THE AMBER HOUSING UNIT WIRES TO MELT. THE CONTACT REPLACED THE AMBER HOUSING UNIT. AFTER THE REPAIR, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

Mileage: 90,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT DRIVER SIDE TURN SIGNAL HAD MALFUNCTIONED AND WOULD NOT ACTIVATE WHEN ENGAGED. THE CONTACT CHANGED THE BULB BUT THE FAILURE WAS NOT REPAIRED. THE CONTACT STATED THE WIRING WAS FAULTY AND NEEDED TO BE DIAGNOSED. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE FAILURE MILEAGE WAS 46,000. UPDATED 11/16/11 *BF THE CONSUMER STATED THE PROBLEM WAS FIXED DUE TO A SERVICE BULLETIN THAT WAS ISSUED. IT REQUIRED CUTTING OUT THE TURN SIGNAL BULB SOCKET AND SPLICING IN A NEW SOCKET, BECAUSE THE OLD ONE OVERHEATED. THE CONSUMER ALSO STATED THE ELECTRICAL POWER STEERING WAS AN ISSUE ON THE VEHICLE AS WELL. UPDATED 11/18/11*JB

Mileage: 46,000

IN BOTH FRONT HEADLIGHT ASSEMBLIES, THERE IS AN AMBER PLASTIC COVER WHICH COVERS THE BULB THAT IS ALWAYS ON, AS PART OF THE REGULAR RUNNING LIGHTS, AND ALSO FOR TURN SIGNALS. THE LIGHT HAS BURNED A HOLE, ABOUT 1 1/4 INCH IN DIAMETER, IN THE TOP OF THE AMBER LENS. THE EDGE OF THE LENS IS BLACK ALL AROUND FROM THE BURNING. IS MY CAR UNIQUE? HAVE THERE BEEN ANY OTHER COMPLAINTS? AND MOST IMPORTANT, IS THERE ANY DANGER OF A FIRE STARTING?

Mileage: 55,000

I PURCHASED THIS 2005 CHEVY MALIBU USED. SHORTLY AFTER HAD THE RIGHT TURN SIGNAL BULB BLOW, THEN LEFT TURN AND BOTH HEADLIGHTS AT THE SAME TIME. WHILE REPLACING THE BULBS, I NOTICED THAT THE PLASTIC SURROUNDING THE TURN SIGNAL BULB HAD A LARGE HOLE IN IT FROM MELTING. THE OTHER ASSEMBLY HAD THE SAME HOLE BURNT IN THE TURN SIGNAL LIGHT BULB COVER. I HAVE REPLACED THE BULBS AT LEAST 2 MORE TIMES THIS YEAR. THE PROBLEMS WITH BULBS FAILING SEEMS TO HAPPEN IN WET WEATHER MORE FREQUENTLY THAN DRY WEATHER. SO I BELIEVE WATER IS GETTING INTO THE HEADLAMPS THROUGH THESE HOLES. THE EXTREME HEAT IS CAUSING THE HEADLIGHT TO BECOME EXTREMELY CLOUDY. REPLACING THE HEADLIGHT ASSEMBLY DOES NOT FIX THE PROBLEM BECAUSE OTHERS HAVE SAID IT SOON STARTS TO MELT AGAIN. PLEASE NHTSA THESE LIGHTING SYSTEMS THAT ARE FAILING ARE VITAL FOR NIGHTTIME DRIVING, PLEASE GET CHEVY TO DO THE RIGHT THING AND FIX THIS DANGEROUS ISSUE. *TR

Mileage: 60,000

I HAD MY FIRST PROBLEM WHEN I PURCHASED THE CAR. IT WOULD JERK & FELT IT WAS MOVING ON IT'S OWN. THEN THE LAMPS WOULD GO OUT AND I WAS REPLACING THE BULBS EVERY MONTH. THEN MY KEY STARTER HAS FAILED TWO TIMES AFTER REPLACING THEM. THE DRIVER SEAT HAS CALAPSED ON THE LEFT HAND SIDE. THE REAR SEAT HANDLE TO RAISE THE SEATS UP AND DOWN HAS BROKEN ON BOTH PASSENGER SIDE. MY LIGHTS HAVE BURNED OUT ON THE FRONT DRIVER'S SIDE YOU CAN SEE THE RESIDUE ON THE COVER. THE CHAIRS WAS NOT SCOTCH GUARD PROTECTED AS STATED THEY ARE VERY STAINED EVEN WHEN I TRIED TO WAS THEM. IN READY SOME OF THE OTHERS IT APPEAR AS THOUGH MU CARE HAD ALL THE DEFECTS OF MY COUNTER PARTS. *TR

Mileage: 50,000

FRONT LEFT TURN SIGNAL REPEATEDLY BURNS OUT, AMBER CASING HAS MELTED HOLE, CHANGING BULBS DOES NOT FIX PROBLEM. *TT

Mileage: 70,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURN SIGNALS WERE IN OPERATIVE. THE WIRES ALSO BEGAN TO MELT THE BULB, CAUSING THE LEFT AND RIGHT TURN SIGNALS TO FAIL. THE DEALER WAS NOTIFIED BUT DENIED ANY ASSISTANCE WITH REPAIRING THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS UNAVAILABLE. THE VIN WAS UNAVAILABLE.

THE LEFT FRONT TURN SIGNAL LAMP CONTINUES TO BURN OUT. HAVE REPLACED THE LAMP NOW 4 TIMES SINCE MARCH 2011. THE AMBER COVER SEEMS TO BE MELTING DUE TO THE EXTREME HEAT AS THE BULB IS ALSO THE RUNNING LIGHTS WHEN THE CAR IS PUT INTO DRIVE ON THE TRANSMISSION. I HAVE REPLACED WITH THE RECOMMENDED BULB AND ALSO THE LONG LIFE BULB. THE RECOMMEND BULB WILL LAST ABOUT 2 WEEKS, THE LONG LIFE I GET ABOUT 2 OR 3 MONTHS ON IT. THIS IS ONLY HAPPENING ON THE LEFT FRONT, NOT ON THE RIGHT FRONT. *TR

Mileage: 74,323

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURN SIGNAL BULBS MELTED THE LENS COVER, CAUSING A HOLE. WITH THE HOLE IN THE COVER, WATER WAS ABLE TO ENTER CAUSING ELECTRICAL FAILURES WITH THE TURN SIGNALS. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HIM THAT THE FRONT LAMPS HAD FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 64,000.

Mileage: 64,000

RIGHT TURN SIGNAL KEEPS GOING OUT,HAVE REPLACED BULBS A FEW TIME AND STILL HAVE SAME PROBLEM. *TT

Mileage: 90,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FRONT SIGNAL INDICATOR WAS MALFUNCTIONING. THE CONTACT MENTIONED THAT HE CHANGED THE BULBS WHICH FAILED TO REMEDY THE PROBLEM. THE VEHICLE WAS NOT TAKEN TO THE DEALER, THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 80,000.

Mileage: 78,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURNING LIGHTS BURNED OUT AND ALSO CAUSED THE HEADLIGHTS TO BURN OUT. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FAILURE WAS A KNOWN ISSUE WITH HIS PARTICULAR YEAR VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 140,000. HAVE REPLACED LIGHTS 3 TIMES SINCE OWNED CAR. SOMETHING IS WRONG TO MAKE IT BURN OUT TURN SIGNAL AND MELT THE LENS AND CONNECTORS. UPDATED 09/14/2011 *LN THE TURN SIGNAL LIGHTS WERE REPLACED THREE TIMES. UPDATED 12/13/11

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE TURNING LIGHTS BURNED OUT AND ALSO CAUSED THE HEADLIGHTS TO BURN OUT. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FAILURE WAS A KNOWN ISSUE WITH HIS PARTICULAR YEAR VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 140,000. HAVE REPLACED LIGHTS 3 TIMES SINCE OWNED CAR. SOMETHING IS WRONG TO MAKE IT BURN OUT TURN SIGNAL AND MELT THE LENS AND CONNECTORS. UPDATED 09/14/2011 *LN THE TURN SIGNAL LIGHTS WERE REPLACED THREE TIMES. UPDATED 12/13/11

THE TURN SIGNAL BULB GETS TOO HOT AND MELTS THE ORANGE PLASTIC COVERING THE TURN SIGNAL BULB. I REPLACED THE HEADLAMP ASSEMBLIES BECAUSE THE ORANGE PLASTIC COVERINGS HAD HOLES MELTED INTO THEM, AND WERE UNREPAIRABLE. I ALSO REPLACED THE TURN SIGNAL BULB WITH THE BULB SPECIFIED IN TSB #06-08-42-004B WHICH SPECIFIES USE OF THE OSRAM 3157 LCP BULB, GM PART NUMBER 13502322. THIS DID NOT CORRECT THE PROBLEM, AND I AM SCHEDULED TO HAVE THE HEADLAMPS REPLACED AGAIN FOR A SECOND TIME, BECAUSE THE ORANGE PLASTIC COVERING THE TURN SIGNAL BULBS HAVE HOLES IN IT AGAIN. I FIRST HAD MY HEADLAMPS REPLACED ON 07/20/2010, AND TODAY IS 07/18/2011, SO IT HAS BEEN LESS THAN A YEAR AND THE PROBLEM IS REOCCURRING. *KB

Mileage: 119,291

THE TURN SIGNAL BULB GETS TOO HOT AND MELTS THE ORANGE PLASTIC COVERING THE TURN SIGNAL BULB. I REPLACED THE HEADLAMP ASSEMBLIES BECAUSE THE ORANGE PLASTIC COVERINGS HAD HOLES MELTED INTO THEM, AND WERE UNREPAIRABLE. I ALSO REPLACED THE TURN SIGNAL BULB WITH THE BULB SPECIFIED IN TSB #06-08-42-004B WHICH SPECIFIES USE OF THE OSRAM 3157 LCP BULB, GM PART NUMBER 13502322. THIS DID NOT CORRECT THE PROBLEM, AND I AM SCHEDULED TO HAVE THE HEADLAMPS REPLACED AGAIN FOR A SECOND TIME, BECAUSE THE ORANGE PLASTIC COVERING THE TURN SIGNAL BULBS HAVE HOLES IN IT AGAIN. I FIRST HAD MY HEADLAMPS REPLACED ON 07/20/2010, AND TODAY IS 07/18/2011, SO IT HAS BEEN LESS THAN A YEAR AND THE PROBLEM IS REOCCURRING. *KB

Mileage: 119,291

MY PROBLEM IS WITH MY 2005 CHEVORLET MALIBU FRONT PARKING LIGHTS. THE PARKING LIGHTS BULB SOCKET HAS MELTED THROUGH THE SOCKET AND MELTED THE PLASTIC ORANGE RELFECTOR AROUND THE BULB. THIS IS A HUGE FIRE HAZARD THAT WAS LUCKILY FOUND EARLY ENOUGH BEFORE ANY MAJOR ACCIDENT OCCURRED. THIS HAS CAUSED MY LIGHT HOUSING TO BECOME DISCOLORED AND HAS MADE MY HEADLIGHTS LESS BRIGHT. THIS HAS OCCURRED ON BOTH DRIVER AND PASSENGER SIDES. I HAVE TRIED DIFFERENT BRANDS OF BULBS AND I HAVE NOW REPLACED BOTH HEADLIGHT ASSEMBLIES. I DO STILL HAVE THE DRIVER SIDE HEADLIGHT AS WELL TO SHOW FOR REFERENCE OF HOW MUCH THE LIGHT HAS MELTED THE SOCKET AND THE PLASTIC ORANGE HOUSING AROUND THE BULB. *TR

Mileage: 99,950

2005 CHEVY MALIBU FRONT PARKING LIGHT LENS MELT ONTO BULB, PROBABLY CAUSED BY PARKING LIGHTS USED AS DAYTIME RUNNING LIGHTS. ALSO SHOWS HEAT DISCOLORATION ON REFLECTIVE MATERIAL IN LIGHT ASSEMBLY. I'VE PERSONALLY INSPECTED OVER 15 2005 CHEVY MALIBU, ALL HAVE SAME ISSUE. VEHICLES WITH MORE MILES SHOWED MORE DAMAGE. POSSIBLE FIRE HAZARD AND ONCE MELTED ENOUGH VIOLATES LIGHTING REQUIREMENTS. TRIED WORKING WITH CHEVY CUSTOMER SERVICE WHO REFUSED TO ACKNOWLEDGE THE PROBLEM. *TR

Mileage: 44,500

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE HEADLIGHTS HAD OVERHEATED AND BURNED THROUGH THE PLASTIC BECAUSE OF THE BULBS BECOMING TOO HOT. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 111,000.

Mileage: 111,000

WHILE CLEANING PLASTIC HEAD/DAYTIME RUNNING LIGHT COVER ON LEFT AND RIGHT SIDE, I NOTICED BOTH AMBER DAYTIME RUNNING LIGHT/TURN SIGNAL LENS ARE MELTED AT THE TOP AND BURNED FROM THE HEAT OF THE BULBS, WHICH MAY LEAD TO A FIRE.

Mileage: 59,850

HEADLIGHTS ARE DULL. PASSENGER BLINKER DOES NOT WORK. CHANGED THE BULB A COUPLE TIMES. AMBER COVER INSIDE THE HEADLIGHT IS MELTED. HARDLY ANY LIGHT WHILE DRIVING AT NIGHT. THIS IS AN ACCIDENT WAITING TO HAPPEN. WENT TO DEALER AND THEY COULDN'T FIGURE OUT WHAT WAS WRONG. TOLD ME TO GO SEE SOMEONE WHO KNOWS ABOUT HEAD LIGHTS! REALLY? *TR

Mileage: 75,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU LS. THE CONTACT STATED THE REAR BRAKE LIGHTS WERE NOT WORKING. HE THEN REALIZED THE BRAKE LIGHT BULB ELEMENT WAS USED NOT ONLY FOR THE BRAKES, BUT ALSO THE INDICATORS AND EMERGENCY FLASHERS. THE CONSUMER STATED IF AN EMERGENCY OCCURRED ALL OF THE REAR INDICATORS AND SIGNALS WOULD BE INOPERATIVE. THE CONSUMER STATED HE WOULD BE UNABLE TO WARN ANY TRAFFIC THAT THERE WAS A PROBLEM AND WISHED TO GET OVER TO THE EMERGENCY LANE. NOR CAN HE WARN AN APPROACHING VEHICLE COMING FROM BEHIND THAT HE IS BRAKING WHICH COULD RESULT IN A REAR END COLLISION. THE FAILURE MILEAGE WAS 87,095 AND THE CURRENT MILEAGE IS 87,180. UPDATED EVOQ 02/10/11 UPDATED 02/18/11 *BF THE CONSUMER STATED THE ONLY INDICATION ON THE VEHICLE THAT THERE IS ANYTHING WRONG IS A QUICK FLASH OF THE DISPLAY SIGNAL INDICATOR SYMBOL. IN MOST CASES IT INFERS THAT THE SIGNAL LIGHT CIRCUIT HAS ONE BULB FAILURE. UPDATED 03/09/11

Mileage: 87,095

THE DAYLIGHT - SIGNAL BULB MELTED THE PLASTIC ENCLOSURE AND SMOKED THE HEADLIGHTS LENSES REDUCING THE VISIBILITY ON NIGHT TIME AT LESS THAN HALF.I NOTICE THIS MATERIAL-DESIGN DEFENT ON MANY CARS IN PARKING LOTS.THIS HAPPEN OVER THE TIME, IS NOT AN INSTANT FAILURE AND USUAL AFTER LONG TRIPS ON NIGHT WITH THE LONG BEAM ON.. *TR

Mileage: 50,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING AT AN UNKNOWN SPEED THE CONTACT TURNED ON THE FRONT TURN SIGNAL AND IT DID NOT WORK. HE CHANGED THE LIGHT BULB WHICH CORRECTED TEMPORARILY CORRECTED THE FAILURE. HE REPLACED THE BULB 6 TO 8 TIMES PER THE MANUFACTURERS RECOMMENDATION AND THE FAILURE CONTINUED TO OCCUR. THE GLOBE WAS HOT ENOUGH TO MELT THE BULB. HE REPLACED A BULB ON NOVEMBER 18,2010 AND THE FOLLOWING DAY THAT BULB BURNED OUT. THE LAST BULB WAS NOT REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THERE WAS NO RECALL RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000. THE CURRENT MILEAGE WAS 105,000.

Mileage: 50

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU LT CONTACT STATED THAT THE HEADLIGHT SOCKET WAS BURNT. THE CONTACT ALSO STATED THAT THE TURN SIGNAL HOUSING WAS MELTED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD CONTACT THE DEALER. THE CURRENT MILEAGE WAS APPROXIMATELY 93,000. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

Mileage: 50,000

TAIL LIGHTS HAVE FILLED UP WITH WATER AND CONDENSATION EVERY TIME IT RAINS. STEERING POPS AND MAKES NOISES WHEN I MAKE A TURN . *TR

FRONT BLINKERS ON 2005 CHEVY MALIBU, ONE OF THE BULBS BLOW ABOUT ONCE A MONTH. I HAVE TO REPLACE BULB EVERY TIME. *TR

Mileage: 90,000

FRONT RIGHT DRL BULB KEEPS GOING OUT.. WHEN REPLACED I NOTICED THE SOCKET APPEARS TO BE BAD AND THE AMBER CASING IS MELTED. THE LIGHT HAS BEEN REPLACED 3 TIMES IN THE LAST 3 MONTHS. *TR

Mileage: 75,000

FRONT TURN SIGNALS AND HEADLIGHTS BURN OUR REGULARLY HAVE REPLACE APPROXIMATELY 18 TO DATE. THE AMBER LENS ARE MELTED. GM STATES ESTIMATED $700 TO REPAIR. PLEASE NOTE NUMEROUS COMPLAINTS POST ON SEVERAL WEB SITES. THIS DOES NOT APPEAR TO ISOLATED INCIDENT IS A SAFETY CONCERN. I NOTICED MAY BE ON OTHER RECALL FOR SAME ISSUE, DIFFERENT MODEL YEAR?? TIRED OF REPLACING BULBS MAY BE A SOCKET FAILURE AND CIRCUIT BOARD FAILURE. GM REPORTEDLY HAS ISSUED TECH. BULLETIN BUT, HAVE NOT RECEIVED NOTICE OF ITS PUBLICATION. AGAIN OTHER OWNERS HAVING SAME ISSUE REPORTEDLY. REPORTEDLY, GM IS AWARE OF THE ISSUE. THIS ISSUE STARTED JUST OUT OF WARRANTY. ON MY WAY TO THE STORE TO BUY MORE BULBS. TIRED OF BUYING BULBS. *TR

Mileage: 64,400

SINCE THE NEW PURCHASE OF MY 2005 CHEVROLET MALIBU, THE TURN-SIGNAL AND BRAKE-LIGHT BULBS HAVE FAILED 30+ TIMES. MOST FAILURES HAVE BEEN AT THE BASE OF BULB WHERE WIRES CONTACT BULB SOCKET CONDUCTORS. WHEN THE DEALER WAS ASKED TO REPAIR THIS PROBLEM, THEY SAID IT WAS NOT COVERED UNDER WARRANTY AND HAD NO SERVICE BULLETIN PERTAINING TO THIS PROBLEM! I HAVE BEEN STOPPED BY POLICE MULTIPLE TIMES AND HAVE HAD NEAR-MISS INCIDENTS DUE TO OTHER DRIVERS NOT SEEING MY TURN SIGNAL OR BRAKE LIGHT. UPON APPROACHING MY VEHICLE AFTER USING REMOTE UNLOCK, THERE WERE FLAMES VISIBLE IN THE HEADLAMP HOUSING AT THE AMBER LENS AREA. TWO YEARS AGO I FOUND AN OBSCURE GM SERVICE NOTICE PERTAINING TO REPLACING THE TURN SIGNAL BULB SOCKET. I PURCHACED THE SPECIFIED PARTS AND REPLACED THEM AS INSTRUCTED IN THIS BULLETIN. ( I AM A CERTIFIED MASTER MECHANIC) I CURRENTLY CARRY THE NECESSARY TOOLS AND BULBS TO REPLACE THESE BULBS AS IT IS A REGULAR OCCURRENCE, BUT MY WIFE IS THE PRIMARY DRIVER OF THIS VEHICLE.

Mileage: 82,000

BRAKE LIGHTS ARE REVERSED. THEY COME ON AND STAY ON THEN WHEN YOU BRAKE THE LIGHT GO OUT. SAFETY ISSUE FOR SURE. THIS HAS HAPPENED 4 TIMES ABOUT ONE YEAR APART EACH TIME. *TR

Mileage: 70,000

PURCHASED 2005 CHEVROLET MALIBU IN MAY, 2009. ONGOING PROBLEMS WITH BRAKE AND TURN SIGNAL LIGHTS NOT WORKING. ATTEMPTED REPLACEMENT AND REPAIR BY MECHANIC. LIGHTS REMAINED INOPERABLE AS DID FUEL GAUGE BY 80,000 MILES. WHILE PARKED, CAR IGNITED FROM UNDER CENTER CONSOLE, DOOR LOCKS ENGAGED, AND INTERIOR BURNED. TOTAL LOSS OF AUTO AND CONTENTS. *TR

Mileage: 110,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT A ROUND AMBER-COLORED GLOBE BECAME HOT AND MELTED ONTO THE TURN SIGNAL BULB. HE CALLED THE DEALER AND WAS TOLD THAT HE WOULD BE RESPONSIBLE FOR THE COST OF A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THEY WERE UNABLE TO OFFER HIM ANY ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 100,125. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

Mileage: 100,000

TL* THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT THE RUNNING LIGHTS AND BLINKER LIGHTS ARE BLOWING OUT ON THE VEHICLE EVERY15 DAYS. THE CONTACT IS WORRIED ABOUT THE VEHICLE CATCHING FIRE BECAUSE THE BULBS BLOWING OUT IS STARTING TO BURN THE COVER FOR THE LIGHTS. THE DEALER STATED THAT THIS IS A DESIGN FLAW ON THE VEHICLE. THE FAILURE MILEAGE 72500 AND CURRENT MILEAGE WAS 75600.

Mileage: 72,500

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE STEERING WHEEL BECAME EXTREMELY STIFF AND THE POWER STEERING WARNING LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS PULLED OVER AND UPON RESTART, THE VEHICLE OPERATED AS NORMAL FOR APPROXIMATELY ONE HALF MILE BEFORE THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT EXAMINED FOR THE CAUSE OF FAILURE. THE CONTACT ALSO STATED THAT SHE WAS EXPERIENCING A RECURRING FAILURE IN WHICH HER FRONT TURN SIGNAL WOULD NOT STOP WORKING AND SHE WOULD HAVE TO REPLACE THE BULBS APPROXIMATELY ONCE A MONTH. THE FAILURE AND CURRENT MILEAGES WERE 87,000. UPDATED 10/27/10. *LJ

Mileage: 87,000

CAR BLOWS THROUGH FUSES EVERY TIME I TURN AROUND. MECHANIC STATES HE HAD MALIBU THAT DID SAME THING, I HAVE REPLACED FUSES ABOUT 4 TIMES A YEAR, THAT ITS ABNORMAL. RT. SIGNAL THEN LT,SIGNAL, BACK AND FORTH. *TR

TURN SIGNAL HOUSING MELTED, DRIPPING ON TURN SIGNALS MAKING THEM LESS EFFECTIVE AND EVENTUALLY CAUSED THEM TO FAIL. *TR

Mileage: 101,000

LOST POWER STEERING WHILE GOING THROUGH ROUND ABOUT, WAS EMPTY AT THE TIME THANKFULLY. HAS HAPPENED 3 PREVIOUS TIMES ALL AT SLOW SPEEDS. I HAD TO PULL OVER AND TURN THE CAR OFF AND START IT TO GET POWER STEERING BACK. THE SIGNAL LIGHTS ARE CONSTANTLY BURNING OUT, HAVE REPLACED THE BULBS 6 TIMES IN 3 YEARS. *TR

Mileage: 80,000

2005 CHEVROLET MALIBU HEADLIGHTS GET TOO HOT AND HAVE MELTED WITH A HOLE IN THE ORANGE PLASTIC. THIS CAUSES THE BULBS TO BURN OUT FREQUENTLY. THE PROBLEM DIDN'T HAPPEN ORIGINALLY, BUT HAS STARTED HAPPENING WITHIN THE PAST 9-12 MONTHS. WE HAVE BROUGHT THE CAR TO THE CHEVROLET DEALERSHIP TODAY TO SEE ABOUT REPLACING THE HEADLIGHTS. I HAVE READ ON THE INTERNET THAT OTHERS HAVE HAD THE SAME PROBLEM, BUT THERE IS NOT YET A RECALL. THE HEAT OF THE HEADLIGHTS BURNING OUT THE PLASTIC IS A MAJOR CONCERN TO ME. *TR

Mileage: 68,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE TURN SIGNALS OVERHEATED AND BURNED, CAUSING THE PLASTIC AROUND THE BULB TO MELT. THE CONTACT CALLED THE DEALERSHIP BUT WAS INFORMED THAT HE WOULD BE CHARGED TO HAVE THE VEHICLE INSPECTED. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000. THE CURRENT MILEAGE WAS APPROXIMATELY 65,000.

Mileage: 55,000

I OWN A 2005 CHEVY MALIBU. AT ABOUT 40,000 MILES I BEGAN TO NOTICE A BURNING SMELL. IT SMELLED LIKE HOT, BURNING PLASTIC. WHILE TRYING TO FIND THE SOURCE OF THE SMELL, I NOTICED MY DAYTIME RUNNING LIGHTS (DRL) WERE MELTING AND CHARRED. THE HOUSING ALSO APPEARED TO HAVE SMOKE DAMAGE AND WAS VERY HAZY. IN THE TIME SINCE I NOTICED THE PROBLEM, VISIBILITY HAS GONE DONE SIGNIFICANTLY. THE PROBLEM SEEMS TO BE ON-GOING RATHER THAN A ONE TIME OCCURRENCE. I WENT TO A CHEVROLET DEALER AND THEY NO IDEA WHAT WOULD CAUSE THE PROBLEM. I HAVE NOT HAD IT REPAIRED SINCE, BECAUSE AFTER DOING INTERNET RESEARCH, IT SEEMS TO BE A PROBLEM WITH MANY '05 MALIBUS. I THEN CALLED THE GM HELP LINE WHERE THEY ASKED A BUNCH OF QUESTIONS ABOUT WHERE I HAD IT REPAIRED. THEY THEN TOLD THEY WERE NOT GOING TO DO ANYTHING ABOUT IT. I DECIDED AFTER THAT ( AT ABOUT 120,000) I WOULD REPLACE THE WHOLE HEADLIGHT ASSEMBLY, HOPING THIS WOULD SOLVE THE PROBLEM. ONE DAY AFTER INSTALLING THE NEW ASSEMBLY, THE SAME MELTING AND CHARRING BEGAN TO OCCUR. AT THIS POINT, I AM UNSURE AS TO WHAT TO DO NEXT. IT IS OBVIOUSLY MORE THAN JUST A PROBLEM WITH THE HEADLIGHT SINCE IT HAPPENED AFTER REPLACING THE WHOLE ASSEMBLY. IT ALSO SEEMS TO BE MORE THAN JUST AN ISOLATED INCIDENT WITH MY VEHICLE SINCE IT TOOK NO TIME TO FIND MANY MALIBUS WITH THE SAME PROBLEM. I BELIEVE THIS IS AN ISSUE THAT GM NEEDS TO INVESTIGATE GREATER AND PROVIDE A DESIRABLE SOLUTION FOR ALL MALIBU OWNERS. *TR

Mileage: 40,000

TL*THE CONTACT OWNS A 2007 CHEVROLET MALIBU MAXX. THE VEHICLE WAS PARKED IN A CARPORT. THE CONTACT OBSERVED THAT BOTH HEAD LAMPS EXHIBITED HEAT DAMAGE WITH A BLACK DISCOLORATION. THE EXTERIOR HEAD LAMP HOUSING COMPLETELY BURNED OUT WHICH RESULTED IN A HOLE. THE COLD WEATHER TEMPERATURES WERE NOT A FACTOR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE BULBS IN THE HEAD LAMPS REQUIRED REPLACEMENT AT THE OWNERS EXPENSE. THE FAILURE MILEAGE WAS 93,000. THE CURRENT MILEAGE WAS 93,000.

Mileage: 93,000

THIS IS RIDICULOUS. I HAVE BEEN READING ABOUT ALL THESE INCIDENTS WHERE PEOPLE'S HEADLIGHTS ARE MELTING. I HAVE REPLACED MY DRIVER'S SIDE HEADLIGHT TWICE NOW! THE TURN SIGNALS ARE GETTING SO HOT THEY ARE MELTING THE BASE, CAUSING THE BULBS TO BURN OUT AND THE CASING AROUND THE BULBS TO MELT. I ALSO HAVE PEOPLE FLASH THEIR BRIGHTS AT ME EVERY NIGHT BECAUSE MY HEADLIGHTS BURN SO BRIGHTLY. I'M AFRAID MY HEADLIGHT WILL EVENTUALLY CATCH FIRE. THE ENTIRE ASSEMBLY IS STARTING TO FOG AND MELT NOW...AND I CAN'T KEEP SPENDING THE MONEY TO BUY A NEW HEADLIGHT! *TR

LEFT DIRECTIONAL LIGHT BULB BURNS OUT, BECAUSE THE SOCKETS THAT HOLD THE BULB OVERHEAT AND MELT THE BULBS. OCCURS BECAUSE THE DAY TIME RUNNING LIGHTS OVERHEAT. HAVE BURNED OUT 4 BULBS IN THE LAST 12 MONTHS. OVERHEATING IS STARTING TO AFFECT THE RIGHT DIRECTIONAL AS WELL. WILL NEED TO REPLACE BOTH SOCKETS. *TR

Mileage: 30,000

THE HEADLIGHT COVERS ARE SHOWING FOGGING AND DISCOLORATION DUE TO HEAT DAMAGE AS A RESULT OF WHAT APPEARS TO BE THE FRONT TURN SIGNAL COVERS MELTING INSIDE THE HEADLIGHT COVERS. *TR

Mileage: 80,000

ABOUT EVERY TWO WEEKS I HAVE TO CHANGE THE LIGHT BULBS IN MY HEADLIGHTS BECAUSE IT IS BECOMING SO WARM THAT IT IS MELTING THE PLASTIC AROUND THE LIGHT BULB. IT IS BECOMING SO WARM THAT IT IS STARTING TO MELT TO HEADLIGHT COVER! *TR

Mileage: 60,000

MY HEADLIGHTS, SIGNAL LIGHTS AND PARKING LIGHTS WORK AS THEY WANT. I HAVE REPLACED THE BULBS MANY TIMES. THE LIGHT COVERS GET REALLY HOT AND I AM ASSUMING THAT IT IS A DEFECTIVE PART. THERE IS NO REASON THAT MY BULBS SHOULD HAVE BURNED OUT 8 TIMES IN THE LAST THREE MONTHS. I HAVE SEEN FOUR MALIBUS JUST LIKE MINE IN THE LAST TWO WEEKS WITH THE SAME LIGHTING PROBLEM AS I HAVE WHICH LEADS ME TO BELIEVE THAT THIS IS A PROBLEM WITH MANY OF THE MALIBUS. I AM GOING TO GET A TICKET SOON IF A RECALL IS NOT PLACED ON THIS PROBLEM. I DO SEE IT'S AN OPEN INVESTIGATION. *TR

Mileage: 85,000

MY 2005 CHEVROLET MALIBU LS TURNING SIGNAL LIGHT DOES NOT SEEM TO WORK PROPERLY AT TIMES CONSIDERING THE FACT THAT I ACTUALLY CHANGE THE BULB ABOUT 4 TIMES IN ONE YEAR. TO MY KNOWLEDGE I AM NOT THE ONLY ONE GOING THROUGH THIS PROBLEM WITH THIS VEHICLE. *TR

Mileage: 60,000

BOUGHT THE 2005 MALIBU USED IN AUGUST 2007. I HAVE REPLACED THE BOTH FRONT DIRECTIONAL BULBS AT LEAST 10 TIMES SINCE BUYING THE CAR. THE LIGHTS WORK INTERMITTENTLY OR NOT AT ALL. THE RIGHT BULB WAS OUT FOR ABOUT 3 MONTHS THEN THE LEFT BULB WENT OUT. I WENT TO REPLACE THE BULBS AGAIN YESTERDAY. I JIMMIED THE SOCKET THEY GO INTO AND NOW THEY BOTH APPEAR TO BE WORKING. HOWEVER, I NOTICED THE AMBER PLASTIC COVERING ON THE LEFT BULB WAS BURNED, THERE WAS A LARGE BURN HOLE IN IT, AND THE MELTED PLASTIC WAS DRIPPING INTO THE BOTTOM OF THE COVERING. I AM ALSO NOTICING, AND HAVE BEEN NOTICING, A LOUD THUMPING SOUND WHEN I HIT THE GAS AS IF SOMETHING HAS TO ROLL INTO PLACE. LATELY IT ALSO SEEMS AS THOUGH THE ANTI-LOCK BRAKES VERY, VERY SLIGHTLY KICK IN WHEN I AM BRAKING AND GO OVER A BUMP. AFTER READING THE OTHER COMMENTS I AM GOING TO MY MECHANIC TO HAVE HIM LOOK AT THE ISSUES AS SAFETY IS A LARGE CONCERN. *TR

Mileage: 108,400

HEADLIGHT LENS MELTED AND TAIL LIGHTS WENT OUT. *TR

EXTERIOR LIGHTING ON 2005 CHEVROLET MALIBU FAILS INTERMITTENTLY. *TR

Mileage: 15,000

2005 MALIBU PURCHASED NEW. DAYTIME RUNNING LIGHT/PARK/TURN SIGNAL MELTING THE AMBER BULB SURROUND AND DISCOLORING AND CRACKING THE OUTER HEADLIGHT LENSES. THIS CAR HAS NOT BEEN IN ANY ACCIDENT TO DATE. I HAVE REPLACED THE LEFT REAR TURN SIGNAL BULB TWICE OVER THE LIFE OF THE CAR. ALL FRONT LIGHTS ARE ORIGINAL AS PURCHASED. I'M CONCERNED THAT THE LIGHTS WILL CATCH FIRE AND SO NOW I TRY TO REMEMBER TO DISENGAGE THE DRL FEATURE WHILE DRIVING. I FEEL THIS IS A MANUFACTURING DESIGN PROBLEM AND SHOULD BE REPLACED WITH NO COST TO THE CONSUMER. I STARTED TO REPLACE THE LIGHTS ON MY OWN WITH "EAGLE EYES" REPLACEMENTS UNITS BUT I HAVE FOUND THAT THESE ARE SUBJECT TO A NHTSA RECALL AS WELL. I WILL HOLD OUT TO SE IF A RECALL IS ISSUED BY NHTSA FOR THIS SAFETY ISSUE. *TR

Mileage: 61,216

FRONT DAYTIME RUNNING LIGHTS ARE GETTING HOT MELTING THEM. THIS IS CAUSING TURN SIGNALS TO BURN OUT AND NOT WORK PROPERLY. GOT PULLED OVER BY A STATE TROOPER TODAY BECAUSE OF THIS. *TR

Mileage: 93,000

I AM WRITING TO COMPLAIN ABOUT THE EXTERIOR HEADLIGHTS MELTING. IT COULD CAUSE A FIRE. IT SEEMS THAT THE AMBER LIGHTS HAVE MELTED THE CASING. THIS PROBLEM SHOULD BE A RECALL AND THE DEALERS SHOULD REPLACE THE HOUSING FREE OF CHARGE. *TR

THE BULB IN THE FRONT LEFT TURN SIGNAL BECAME TOO HOT AND BURNED OUT WHILE MELTING THE AMBER COVER AROUND IT. AFTER REPLACING THE BULB, THE TURN SIGNAL AND HIGH LEVEL RUNNING LIGHT FUNCTION WOULD NOT WORK BUT THE LOW LEVEL LIGHT STILL OPERATES WHEN THE HEADLIGHTS ARE ON. I REPLACED THE BULB TWICE AND CLEANED THE CONNECTOR AND GET INTERMITTENT USE OF THE TURN SIGNAL, BUT I NEVER KNOW IF IT'S GOING TO WORK OR NOT. *TR

LOSS OF FUNCTION OF HEADLIGHTS, BRAKE LIGHTS, TURN SIGNALS AND TAIL LIGHTS ON 2005 CHEVY MALIBU LS MODEL. THE LIGHT BULBS IN THE SIGNAL ARE CONSTANTLY BLOWING OUT. I HAVE THE CHANGE THE BULBS AT LEAST EVERY MONTH. I HAVE NO USE OF MY TAIL LIGHTS AND TURN SIGNALS AS A RESULT OF THIS. FAILURE OF THE BULB HAS NOT RESULTED IN HEAT DAMAGE TO THE BULB SOCKET. *TR

Mileage: 53,514

AS OF THIS DATE, FEB. 17, 2009, THE PART IN QUESTION HAS NOT FAILED, CAUSING ANY CRASHES OR INJURIES. SHORTLY AFTER I PURCHASED THE VEHICLE, I NOTICED A THUMPING WHENEVER THE STEERING WHEEL WAS TURNED SHARPLY TO THE RIGHT OR TO THE LEFT. WHILE UNDER MANUFACTURER'S WARRANTY, I HAD IT CHECKED OUT AT LEAST 3 TIMES, AND EACH TIME THE DEALERSHIP SERVICE DEPARTMENT ASSURED ME THERE WAS NO RECALL ON THE PART, THE BOOT OF JOINT SOMEHOW CONNECTED TO THE STEERING. SINCE THAT TIME, I HAVE HAD MY PERSONAL MECHANIC CHECK OUT THE PROBLEM AND HE HAS DILIGENTLY CHECKED FOR A RECALL OR A CORRECTIVE MEASURE FROM CHEVROLET, BUT THERE HAS BEEN NONE. THE MECHANIC HAS GREASED THIS JOINT SEVERAL TIMES, AND IT HELPS THE THUMPING, BUT EVENTUALLY IT RETURNS OVER TIME. I HAVE READ WHERE OTHERS HAVE EXPERIENCED THEIR STEERING TOTALLY GOING OUT BECAUSE OF THIS ISSUE. I AM AFRAID FOR MY FAMILY'S SAFETY DUE TO THIS PROBLEM THAT CHEVROLET HAS CONSTANTLY REFUSED TO ADDRESS. COMPONENT #2: I WAS CONSTANTLY HAVING TO REPLACE THE FRONT TURN SIGNALS AS THE BULBS WERE CONSTANTLY BURNING OUT. COMPONENT #3 THE FAN WHICH CONTROLS THE INSIDE AIR FLOW HAS CONSTANTLY RATTLED UNLESS THE FAN IS TURNED ON THE HIGHEST SETTING. THE DEALERSHIP EVEN REPLACED THAT FAN, TELLING ME A BROKEN PART HAD FALLEN DOWN INTO IT. I RETURNED THE CAR TO THE DEALERSHIP AT LEAST 3 TIMES, BUT THEY FINALLY SAID THEY COULD NOT FIND ANYTHING ELSE. IT STILL RATTLES HORRIBLY. *TR

Mileage: 1,000

ON OUR 2005 CHEVY MALIBU WE HAVE CHANGED THE FRONT TURN SIGNAL LAMP NUMEROUS TIMES SINCE WE PURCHASED IT NEW IN 2005, THE FIRST TIME BEING ONLY A MONTH AFTER WE PURCHASED THE CAR. IN NOV. 2006 AT OUR EXPENSE WE HAD TO CHANGE THE TURN SIGNAL LAMP SOCKETS BECAUSE THE DEALER SAID THE REASON FOR THE LAMPS BURNING OUT WAS DUE TO THE SOCKETS BEING CORRODED. AFTER THAT WE HAVE STILL HAD TO CHANGE THE LAMPS AS FREQUENT. I WOULD SAY IN ALL WE HAVE REPLACED EITHER THE LEFT OR RIGHT LAMP ABOUT 12 TIMES SINCE THE PURCHASE DATE OF MARCH 2005. RECENTLY WE HAVE NOTICED THAT THE LAMP HOUSING HAS ACTUALLY MELTED ABOVE WHERE THE LAMPS ARE LOCATED. WE CURRENTLY HAVE THE LOCAL DEALER LOOKING INTO THE PROBLEM AGAIN. EVERY TIME I SEE A CHEVY MALIBU FROM THE YEAR MODEL OF 2005 TO 2007, MOST OFTEN ONE OF THE FRONT PARK/SIGNAL LAMPS IS BURNED OUT. I THINK THIS IS A SAFETY HAZARD DUE TO NOT HAVING A PROPERLY WORKING TURN SIGNAL COULD CAUSE AN ACCIDENT. ALSO IF THE HOUSING IS MELTING, THEN IT COULD RESULT IN THE CAR CATCHING ON FIRE I BELIEVE. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT PREVIOUSLY EXPERIENCED FAILURE WITH THE DRIVER'S SIDE HEADLIGHT BULB CONSTANTLY BURNING OUT. SIX MONTHS LATER, THE PLASTIC HEADLIGHT COVERS BURNED. THE STEERING SHAFT HAS BEEN REPLACED THREE TIMES. THE DEALER STATED THAT THE PLASTIC COVER FAILURE WAS A FACTORY DEFECT; THEREFORE, THEY WERE UNABLE TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 69,000 AND CURRENT MILEAGE WAS 78,400. UPDATED 02-23-09 *BF UPDATED 02/24/09. *JB

Mileage: 69,000

ON A 2005 CHEVY MALIBU OUR BRAKE LIGHTS, ON THE REAR OF THE VEHICLE, OFTEN WORK IN REVERSE. IN OTHER WORDS, THE BRAKE LIGHTS ARE ON WHEN YOU AREN'T HITTING THE BRAKES, AND THEY ARE OFF WHEN YOU ARE HITTING THE BRAKES. THIS SEEMS TO POSE A SAFETY CONCERN SINCE VEHICLES BEHIND YOU DO NOT KNOW WHEN YOU ARE HITTING THE BRAKES. I AM REPORTING THIS BECAUSE I HAVE SEEN ON MANY FORUMS THAT OTHER PEOPLE HAVE THE SAME PROBLEM SO THIS SHOULD BE A FACTORY RECALL INSTEAD OF SOMETHING WE HAVE TO PAY FOR TO GET IT FIXED. HERE ARE SOME LINKS THAT PROVE THIS PROBLEM ISN'T ISOLATED: HTTP://WWW.FIXYA.COM/CARS/T822542-BRAKE_LIGHTS_WONT_GO_OFF HTTP://WWW.2CARPROS.COM/FORUM/2005-CHEVY-MALIBU--BRAKE-LIGHTS-WILL-NOT-GO-OFF-VT181519.HTML HTTP://WWW.CARCOMPLAINTS.COM/CHEVROLET/MALIBU/2004/LIGHTS/BRAKE_LIGHTS_BLINK_ON_BY_THEMSELVES.SHTML HTTP://WWW.CARDEALERCHECK.COM/FORUM/THREAD15599.HTML. *TR

Mileage: 52,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT SMELLED SOMETHING BURNING. HE NOTICED A V-SHAPED BURNT PATTERN IN THE FRONT DRIVER'S SIDE HEADLIGHT. APPROXIMATELY ONE MONTH AGO, THE FRONT PASSENGER SIDE HEADLIGHT FAILED. THE CURRENT MILEAGE WAS 102,000 AND FAILURE MILEAGE WAS 101,000.

Mileage: 101,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WITHIN A SERIES OF MONTHS, BOTH THE FRONT AND REAR TURN SIGNAL BULBS HAVE ALL NEEDED TO BE REPLACED. THE DEALER FOUND THE VEHICLE TO BE OPERATING NORMALLY. THE FAILURE HAS OCCURRED EVER SINCE THE VEHICLE WAS PURCHASED. THE CURRENT MILEAGE WAS 27,000 AND FAILURE MILEAGE WAS 6.

Mileage: 6

HEADLIGHTS AND TAILLIGHTS KEEP BURNING OUT ON MY 2005 CHEVY MALIBU AT THE BASE OF THE BULB. THIS IS AN 05 AND THE DEALERS KEEP TELLING ME IT IS THE BULB I USE - THAT I NEED TO USE AN OEM BULB, WHEN I LET THEM CHANGE IT THEY USED THE SAME BULB AND THE BASE OF THE BULBS TURN BLACK AND ONLY LAST ABOUT A WEEK OR SO. *TR

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. SINCE PURCHASING THE VEHICLE, THE ANTI THEFT DEVICE HAS FAILED REPEATEDLY, THE ENGINE MAKES A TICKING SOUND, THE STEERING WHEEL IS SLIPPING OR LOOSE, AND OIL LEAKS FROM THE ENGINE. WHILE DRIVING 45 MPH, THE DASHBOARD . VIBRATES. THE CONTACT HEARS A NOISE IN THE RADIO WHEN THE VEHICLE IS TURNED ON, THE ENGINE SERVICE LIGHT IS ILLUMINATED ON THE INSTRUMENT PANEL, THE INTERIOR LIGHTS FAILED, THE REMOTE START WOULD NOT START THE VEHICLE, AND THE ENGINE SHAKES ROUGHLY. THE CURRENT MILEAGE WAS 12,030 AND FAILURE MILEAGE WAS 100. UPDATED 09/24/08. *LJ THE CONSUMER STATED THERE WAS A PROBLEM WITH THE ENTIRE SUSPENSION. THE SHOCKS AND BEARINGS MADE A NOISY. THE HAZARD LIGHTS FAILED. UPDATED 09/30/08.*JB

Mileage: 100

NOTICED BOTH FRONT TURN SIGNALS/DAYTIME RUNNING LAMPS YELLOW COVERS WERE MELTED. IT HAD DISCOLORED LIGHT LENS DUE TO APPARENT EXTREME HEAT. *TR

Mileage: 51,000

THE BLINKER WILL ALWAYS FAIL TO WORK. THE BULBS ARE JUST FINE AND INTACT, BUT THE BLINKER WILL STOP WORKING. THERE IS SOME ELECTRICAL PROBLEM WITH THE HEADLIGHTS. THIS HAS CAUSED OTHER VEHICLES TO GET IN CLOSE CONTACT WITH ME, AND ALMOST IN CRASHES. I HAVE HEARD MANY DIFFERENT CASES OF THIS PROBLEM WITH OTHER 2005 CHEVY MALIBU'S AS WELL. *TR

Mileage: 40,000

I JUST REPLACED THE FRONT DRIVER'S SIDE FLASHER LIGHT IN MY 2005 CHEVY MALIBU AND THE PLASTIC BASE OF THE BULB WAS MELTED. THIS APPEARS TO BE A POSSIBLE FIRE HAZARD. *TR

Mileage: 45,000

NOTICED HAZE IN DRIVERS SIDE HEADLIGHT , LOOKED FURTHER FOUND THAT TURN SIGNALS ON BOTH DRIVER AND PASSENGER SIDE WHERE STATING TO MELT , HAVE BEEN SMELLING SOMETHING BURNING WHEN I GET OUT OF CAR FOR A WEEK , NOTICED THIS WHEN ABOUT TO WASH CAR , TAKING TO DEALER TOMORROW , GLAD I NOTICED IT NOW , WHEN IT WAS NOT TO LATE. *TR

Mileage: 35,500

MY CAR'S LIGHTS ARE MELTING,SMOKE EVEN COMES OUT OF THEM.I'VE SEEN THIS ON OTHER 2005 CHEVY MALIBUS AND THEY ARE ALL DOING THE SAME THING,WHICH MEANS ITS A MANUFACTURES DEFECT.NO ONE AT GM WANTS TO HELP ME,AND IF MY CAR DOESN'T GET FIXED ITS GOING TO CAUSE A FIRE.IT HAS BURNED OUT MY BULBS VERY QUICKLY AND OFTEN.I TOOK MY CAR IN TO A GM GOODWRENCH SERVICE SHOP AT AMERICAN CHEVROLET IN MODESTO,CA.THE SERVICE CONSULTANT THERE SEEN MY CAR AND SAID THAT IT WAS NOT NORMAL,HE BROUGHT OUT ANOTHER 2005 CHEVY MALIBU THAT THEY HAD THERE AND ITS DOING THE SAME THING.HE TRIED TO PUT ME IN CONTACT WITH THE GM,BUT I GOT TOLD I WAS A LIAR,BY A REPRESENTATIVE.I NEED HELP BECUASE THERE HAS TO BE A RECALL ON THE LIGHTS,BEFORE IT CAUSES A FIRE.CHECK AND SEE ANY 2005 CHEVY MALIBUS AND YOU'LL SEE THAT ITS TRUE.THANK YOU FOR YOUR TIME. *CN

Mileage: 59,707

MY CAR'S LIGHTS ARE MELTING,SMOKE EVEN COMES OUT OF THEM.I'VE SEEN THIS ON OTHER 2005 CHEVY MALIBUS AND THEY ARE ALL DOING THE SAME THING,WHICH MEANS ITS A MANUFACTURES DEFECT.NO ONE AT GM WANTS TO HELP ME,AND IF MY CAR DOESN'T GET FIXED ITS GOING TO CAUSE A FIRE.IT HAS BURNED OUT MY BULBS VERY QUICKLY AND OFTEN.I TOOK MY CAR IN TO A GM GOODWRENCH SERVICE SHOP AT AMERICAN CHEVROLET IN MODESTO,CA.THE SERVICE CONSULTANT THERE SEEN MY CAR AND SAID THAT IT WAS NOT NORMAL,HE BROUGHT OUT ANOTHER 2005 CHEVY MALIBU THAT THEY HAD THERE AND ITS DOING THE SAME THING.HE TRIED TO PUT ME IN CONTACT WITH THE GM,BUT I GOT TOLD I WAS A LIAR,BY A REPRESENTATIVE.I NEED HELP BECUASE THERE HAS TO BE A RECALL ON THE LIGHTS,BEFORE IT CAUSES A FIRE.CHECK AND SEE ANY 2005 CHEVY MALIBUS AND YOU'LL SEE THAT ITS TRUE.THANK YOU FOR YOUR TIME. *CN

Mileage: 59,707

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. BOTH OF THE FRONT TURN SIGNAL LENSES HAVE A ONE HALF INCH HOLE BURNED INTO THE TOP OF THE PLASTIC. THE PLASTIC HAS COMPLETELY MELTED AND TURNED BROWN. THE SHINY MATERIAL HAS TURNED A DULL WHITE. THE DEALER STATED THAT NOTHING COULD BE DONE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 64,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 02-14-08. *KB THE CONSUMER STATED THE DEALER INFORMED HIM THE REPAIRS WOULD NOT BE COVERED BY THE DEALER. THE CONSUMER STATED WOULD HAVE TO PAY OUT OF POCKET FOR REPAIRS. UPDATED 02/14/08 *TR

Mileage: 50,000

TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHILE DRIVING 35 MPH, THE HEADLIGHT AREA BEGAN SMOKING. THE FAILURE OCCURRED ON THREE OCCASIONS. WHEN THE CONTACT SHUT THE ENGINE AND HEADLIGHTS OFF, THE SMOKING CEASED. NO FIRE OCCURRED. THE CHEVROLET SERVICE DEPARTMENT ADVISED HER TO HAVE THE DEALER DIAGNOSE THE FAILURE. THE DEALER STATED THAT THEY WOULD REPLACE BOTH LIGHTS FOR $275 EACH AT HER EXPENSE. THE BULBS HAVE MELTED THE HEADLIGHT LENS, BUT THE DEALER DID NOT RECOMMEND CHANGING THE BULBS. THE TAIL LIGHTS WERE OPERATING NORMALLY. THE FENDER AREA IS MUCH HOTTER THAN NORMAL DUE TO THE HEADLIGHTS OVERHEATING. THE WARNING LIGHTS ILLUMINATED ON THE DASHBOARD TO INDICATE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED. THE POWERTRAIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 79,000 AND CURRENT MILEAGE WAS 81,000.

Mileage: 79,000

I OWN A 2005 CHEVY MALIBU THAT FOR APPROXIMATELY A YEAR AND A HALF. DURING THIS TIME I HAVE NEED TO REPLACE THE BULBS IN THE RIGHT FRONT TURN SIGNAL TWICE AND THE REAR RIGHT TURN SIGNAL ONCE. *TR

I OWNED THE 2005 CHEVROLET MALIBU FOR ALMOST 2 YEARS. DURING THAT TIME I HAD TO REPLACE THE REAR TURN SIGNAL ONCE, AND THE FRONT TURN SIGNALS ABOUT 3 TIMES EACH. SOMETHINGWAS DEFINITELY WRONG WITH THE ELECTRICAL PART OF THIS VEHICLE. THE WARRANTY HAS NOW EXPIRED, SO I CAN GET NOTHING DONE ABOUT IT FROM GM OR CHEVROLET. *AK A SECOND COMPLAINT CONCERNS THE FAN FOR THE AIRCONDITIONER/HEATER. IT RATTLES CONSTANTLY. BEFORE THE WARRANTY EXPIRED I TOOK IT IN TWICE TO THE DEALERSHIP AND HAD REPAIRS DONE ON THE VEHICLE. ONCE THE MOTOR WAS REPLACED . . . WAS TOLD THEIR WAS SOMETHING LODGED IN THE FAN. A WEEK LATER THE SAME NOISE. NOTHING HAS BEEN RESOLVED.

I OWN A 2005 CHEVROLET MALIBU THAT JUST WENT OUT OF WARRANTY WHEN I HAPPENED TO BE FOLLOWING MY HUSBAND WHO WAS DRIVING ANOTHER VEHICLE. FOR 150 MILES MY HUSBAND COMPLAINED THAT THE HEADLIGHTS VIBRATED CONSTANTLY CAUSING A DISTRACTION FOR ANYONE DRIVING IN FRONT OF ME. UNTIL THAT TIME I HAD NO WAY OF KNOWING THAT THE HEADLIGHTS HAD A PROBLEM. HE CHECKED THEM WHEN WE GOT HOME AND FOUND THAT THERE WAS NO WAY TO TIGHTEN THEM. I HAVE CHECKED FOR RECALLS ON THIS PROBLEM AND FOUND NONE. I NEED TO KNOW WHAT COULD BE DONE TO RECTIFY THIS PROBLEM WITHOUT COST TO ME SINCE I WAS SURE THIS PROBLEM HAS BEEN THERE SINCE I GOT THE VEHICLE BECAUSE THERE WAS NO WAY TO FIX IT.AK

PULLS TO THE LEFT, BROKEN STRUTS, BROKEN BRAKE CALIPERS, REAR TURN SIGNAL BROKE! ANYTIME I MESS WITH TIRES OR BRAKES THE CAR PULLS MORE AND MORE TO THE LEFT, HAVEN'T HAD STEERING CHECKED BUT ITS DRIVING ME NUTS. I THOUGHT IT WAS FROM THE FRONT RIGHT STRUT BEING CRACKED AND BROKEN BUT THE DEALERSHIP SAYS IT SHOULDN'T EFFECT THE PULL TO THE LEFT. GOT NEW TIRES LAST WEEK AND NEW BRAKES, STILL PULLS. TAIL LIGHT QUIT WORKING, CHANGED BULBS THEN QUIT AGAIN. CAR IS DRIVING ME NUTS, WORRIED ABOUT DRIVING IT ACROSS COUNTRY THIS SUMMER! RECALL IT SOON - PLEASE!!! *JB

Mileage: 25,000

FRONT STRUTS ARE FRACTURED AND APPARENTLY HAVE BEEN EST. $400+ TO FIX, CAN'T AFFORD TO FIX! HAVE SEEN SEVERAL COMPLAINTS ONLINE REGARDING FRONT END RATTLES, I ALSO COMPLAINED SOON AFTER PURCHASING MY CAR W/25K ON IT, NOTHING WAS DONE THEN! REAR LEFT TAILLIGHT & BRAKE LIGHT KEEP FAILING EVEN AFTER REPLACING BULBS. *JB

Mileage: 42,000

EMAIL (IN) REQUESTING AN INVESTIGATION OF GENERAL MOTORS RE THEIR DANGEROUS & DEFECTIVE PRODUCTS. *TS *NM UPDATED 2/15/2007 - THE CONSUMER SMELLED ANTIFREEZE COMING THROUGH THE AIR VENTS. THE DRIVER'S SIDE HEADLIGHT HAD TO BE REPLACED. PROBLEM WITH BRAKES. A STEERING GEAR ASSOCIATED WITH THE RACK AND PINION WAS REPLACED. THE TRANSMISSION HESITATED. THE CONSUMER HEARD A KNOCKING NOISE WHEN TURNING THE STEERING WHEEL. PASSENGER SIDE FRONT TURN SIGNAL FAILED. THE DASH LIGHT AND TAIL LIGHT FAILED. *NM

SINCE PURCHASE OF 05 MALIBU I HAVE HAD BREAKING VIBRATION AND VIBRATION IN TURNS TO THE RIGHT. HAVE HAD 2 SETS OF PADS AND ROTORS TURNED ONCE. I AM ON THE THIRD SET OF TIRES WITH ROTATIONS EVERY 6000 MILES BUT STILL GET UNEVEN WEAR. 43,000+ MILES AND THE DEALER SAYS THERE IS NOTHING WRONG WITH THE BREAKING OR WHEELS. DRIVERS SIDE DAYTIME RUNNING LIGHT AND TURN SIGNAL HAS BLOWN 3 TIMES. *NM

VEHICLE PURCHASED DEC 31, 2004 AND IT IS NOW JULY AND GUESS WHAT? THE 2005 MALIBU CRUISE CONTROL STOPPED WORKING PLUS 1 DAYTIME DRIVING LIGHT!!! TOO EARLY FOR THE CRUISE CONTROL TO QUIT WORKING, NEVER HAD THIS PROBLEM IN ANY VEHICLE I HAVE HAD AND EVERYONE SAID SAME THING! THIS SHOULD BE A RECALL OF ALL MALIBU 2005'S WITH CRUISE CONTROL PROBLEMS BECAUSE OF SPEED SENSOR OR SOME ELECTRICIAL PROBLEM IN THE CAR THAT GM SHOULD BE THE RESPONSIBLITY OF PAYING FOR NOT CUSTOMERS BECAUSE EARLIER I HAD TO TAKE CAR IN FOR PROBLEMS WITH THE DOORS NOT UNLOCKING AND UNLOCKING BECAUSE OF THE REMOTE NOT WORKING AND EVEN A NEW BATTERY DID NOT SOLVE THE PROBLEM. THEY HAD TO FIX THE PROBLEM. *NM

Mileage: 35,720