1997 CHEVROLET MONTE CARLO Steering Problems

TL* THE CONTACT OWNS A 1997 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT WHILE DRIVING 85 MPH, THE STEERING WHEEL BECAME LOOSE AND CAUSED THE CONTACT TO TEMPORARILY LOSE CONTROL OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE LOWER PINION BEARING FOR THE STEERING RACK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 03V527000 (STEERING:RACK AND PINION) HOWEVER, THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 220,000.

Mileage: 220,000

MY 97 CHEVY MONTE CARLO HAS HAD NO LOWER BRAKE LIGHTS FOR SOME TIME . I HAD MY CAR CHECKED BY AN AUTO ELECTRICIAN AND WAS TOLD THAT THE PROBLEM WAS SO SEVERE AND IT WOULD PROBABLY NEVER FIND THE SOURCE OF THE PROBLEM. I AM VERY CONCERNED WITH THIS ISSUE BEING IT MAY CAUSE SERIOUS INJURY TO MY SELF/FAMILY OR OTHERS. AS I DRIVE ON THE ROAD I NOTICE MANY AUTOS OF THE SAME YEAR AND TYPE HAVE THE SAME PROBLEM SO I KNOW ITS NOT ONLY MY VEHICLE .I THOUGHT IT COULD OF BEEN THE FACTORY INSTALLED SECURITY SYSTEM SO I HAD IT UNINSTALLED TO COME TO THE FACT THAT IT WAS NOT THE SECURITY SYSTEM AFTER ALL. PLEASE HELP WITH THIS ISSUE . THIS IS MY ONLY SOURCE OF TRANSPORTATION AS I AM DISABLED AND CANNOT AFFORD ANOTHER VEHICLE . I HAVE PUT CONSTANT REPAIRS ON THIS CAR , FUEL INJ TANK, ETC. AGAIN PLEASE ADDRESS THIS URGENT ISSUE. *TR

DT: CONSUMER HAD RECALL 03V527000 REPAIRS DONE IN FEBRUARY WHICH WAS SUPPOSE TO BE PREVENTIVE RECALL WORK. VEHICLE WAS STILL EXPERIENCING LOSS OF POWER STEERING. CONSUMER SAID WHEN SHE TURNED LEFT THE VEHICLE DEMONSTRATED HIGH RESISTANCE. TOOK VEHICLE TO DEALER AFTER MANUFACTURER ADVISED HER TO TAKE IT TO ANY DEALER. THE DEALER INSISTED THAT SHE GO BACK TO DEALER WHO DID THE ORIGINAL RECALL REPAIRS. DEALER CHECKED VEHICLE AFTER SHE AGREED TO PAY FOR THE LABOR. MECHANIC CHECKED VEHICLE AND CLAIMED IT WAS RACK AND PINION PROBLEM. *AK

Mileage: 127,000

WHILE MAKING A RIGHT TURN AT 5 MPH, THE VEHICLE LOST POWER, CAUSING THE CONSUMER'S VEHICLE TO HIT A POLE. *AK THE CONSUMER STATED THE PROBLEM WAS DUE TO STEERING RACK FAILURE. *JB

Mileage: 121,000

RECALL 03V527000 CONCERNING STEERING GEAR BEARINGS. CONSUMER HAD A CONCERN WHILE MAKING A LEFT TURN THE VEHICLE LOST STEERING CONTROL. ALSO, AIR CONDITIONER/ HAZARD LIGHTS, AND DRIVER'S SIDE POWER WINDOW FAILED TO OPERATE. DEALER WAS NOT NOTIFIED. *AK

Mileage: 120,000

VEHICLE'S STEERING WENT OUT ALL OF A SUDDEN WHILE DRIVING. *MR RECALL #750283. THE CONSUMER REQUESTED HER MONEY BACK. *SC IN JAN. 2004 A RECALL WAS ISSUED ON THE STEERING RACK AND PINION. THE CONSUMER WAS TOLD TO SEND IN HER PAPERWORK AND A REIMBURSEMENT CHECK WOULD BE SENT TO HER, BUT INSTEAD THE CONSUMER RECEIVED A DENIAL LETTER. THE MANUFACTURER STATED THE REASON FOR THE DENIAL OF REIMBURSEMENT WAS BECAUSE THE CONSUMER DID NOT HAVE THE VEHICLE SERVICED AT A GM DEALER. *JB

CONSUMER'S CLAIM WAS DENIED FOR REIMBURSEMENT SINCE THE REPAIRS WERE DONE PRIOR TO RECEIVING THE RECALL NOTICE. *PH

Mileage: 64,897

STEERING WHEEL DID NOT TURN UPON STARTING THE VEHICLE. CONSUMER TOOK VEHICLE TO A MECHANIC, AND HE DETERMINED THE RACK AND PINION STEERING NEEDED TO BE REPLACED. *AK

WHILE DRIVING 55 MPH STEERING WHEEL LOCKED UP. CONSUMER TRIED TO UNLOCK IT BUT WAS UNABLE TO DO SO. CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. CONSUMER LOST CONTROL OF THE VEHICLE, AND HIT A MEDIAN STEEL BARRIER. THEN, VEHICLE ROLLED THREE TIMES AND LANDED UPSIDE DOWN ON THE HIGHWAY. UPON IMPACT, BOTH FRONTAL AIRBAG DID NOT DEPLOY. DRIVER SUSTAINED NECK AND BACK INJURIES AND WAS TRANSPORTED BY AMBULANCE, TO THE HOSPITAL. VEHICLE WAS TOTALED. *AK

NHTSA RECALL# 03V527000 SUBJECT:STEERING GEAR BEARINGS. CONSUMER RECEIVED THE NOTICE FOR THE RECALL THE FIRST PART OF FEBRUARY. CONSUMER CALLED THE DEALER SIX TIMES. DEALER DID NOT HAVE THE TOOLS TO FIX THE RECALLED PART, AND TOLD THE CONSUMER TO CALL BACK IN APRIL. THE VEHICLE WAS HAVING STEERING PROBLEMS.*AK

CONSUMER DISSATISFIED WITH THE WORK DONE ON HER VEHICLE. *PH THE DEALER TOLD THE CONSUMER THAT THE STEERING PROBLEM SHE EXPERIENCED HAD NOTHING TO DO WITH RECALL 03V-527000. THE CONSUMER DISAGREES AND BELIEVES THAT THE DEALER REFUSED TO REPAIR THE VEHICLE UNDER RECALL BECAUSE SHE REFUSED TO LET THEM REPLACE OTHER ITEMS ON THE VEHICLE. *NM

WHEN MAKING A LEFT TURN, THE STEERING WHEEL LOCKED UP. THE DEALER HAS BEEN CONTACTED. THE DEALER IS REPLACED THE RACK AND PINION. *JB *NM

Mileage: 63,167

HEARD A LOUD RUMBLING NOISE WHILE BACKING OUT OF THE DRIVEWAY. TOOK VEHICLE TO DEALER, AND DEALER DETERMINED THAT RACK AND PINION STEERING NEEDED TO BE REPLACED. *AK

WHEN TURNING THE STEERING WHEEL TOWARDS THE LEFT, THE STEERING LOCKED UP, WHICH CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. *AK THE RACK AND PINION WAS REPLACED *JB *NM

Mileage: 65,000

I AM HAVING PROBLEMS WITH MY 1997 MONTE CARLO. THE POWER STEERING INTERMITTENTLY LOCKS UP AND/OR BECOMES VERY DIFFICULT TO OPERATE. PROBLEM ALWAYS OCCURS WHEN TURNING TO THE LEFT, USUALLY AT LOW SPEEDS. PROBLEM BECOMING PROGRESSIVELY WORSE TO THE POINT WHERE VEHICLE IS NOT DRIVABLE.*AK

Mileage: 70,122

LEFT REAR BOLT THAT HELD THE CONTROL ARM ON TO THE AXLE BROKE OFF. IT WAS NOTICED WHEN VEHICLE WAS BEING BACKED OUT OF THE GARAGE. VEHICLE WAS CHECKED AT THE DEALER. AND NO EVIDENCE OF PREVIOUS DAMAGE WAS FOUND.*AK

WHILE DRIVING APPROXIMATELY 15 MPH, THE STEERING FAILED WITHOUT WARNING, WHICH CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE AND CRASHED INTO THE CURB. DEALER DIAGNOSED THAT THE RACK AND PINION SYSTEM WAS DEFECTIVE. *AK GM STATED THAT THERE WAS A DEFECT IN THE RACK AND PINION BUT NOT THIS VEHICLE. *SCC *JB

Mileage: 915,000

HIGH PRESSURE POWER STEERING HOSE FAILURE. NLM

Mileage: 67,035

POWER STEERING LOCKED UP WHEN MAKING A LEFT TURN. AT FIRST IT HAPPEN WITH MY SON DRIVING, WAS FINE ONE DAY, AND LIKE SOMETHING BROKE THE NEXT. I TOOK MY CAR TO MY MECHANIC, THEY SAID THEY HAVE SEEN 3 MONTO CARLO'S THAT MONTH HAVING THE SAME PROBLEM. I HAVE OWNED NUMEROUS VEHICLES IN MY LIFE AND HAVE NEVER HAD THIS KIND OF PROBLEM. IT IS A VERY DANGEROUS SITUATION. THEN WHEN DRIVING IT TO MY MECHANIC, THANK GOD MY SON WAS IN THE CAR WITH ME, AND HELPED ME MUSCLE THE CAR THROUGH THE TURN, OR THERE WOULD HAVE BEEN A SERIOUS ACCIDENT. ALSO THE GAS GAUGE HAS NEVER GIVEN A ACCURATE READING. WHEN MY MECHANIC TOLD ME THEY HAD BEEN SEEING A LOT OF MONTE CARLOS WITH THIS PROBLEM, IT ALERTED ME THAT THERE MUST BE A SERIOUS PROBLEM WITH THE POWER STEERING, AND I STARTING CHECKING THE RECALLS, AND SURE ENOUGH, GM HAS RECALLED 96 - 98'S CHEVROLET LUMINAS, WHICH IS A SISTER CAR TO THE MONTO CARLO, THE ONLY MAJOR DIFFERENCE BETWEEN THESE TWO CARS IS THE BODY STYLE COUPE (2 DOOR) TO SEDAN (FOUR DOOR). THEY HAVE THE SAME MECHANICAL WORKING PARTS. HOPEFULLY THEY'LL GET THE MONTE CARLO RECALLED SOON BEFORE THERE ARE SERIOUS CONSEQUENCES. *JB

Mileage: 118,000

WHEN TURNING THE STEERING WHEEL WILL NOT ROTATE BACK TO STANDARD POSITION. THE WHEEL CONTINUES TO ROTATE AROUND IN A CIRCLE. PH

CONSUMER CALLED COMPLAINING ABOUT THE RACK AN PINION STEERING BROKE. ALSO STATED THAT WHILE DRIVING THE VEHICLE THE RACK AND PINION STEERING BROKE WHICH IT COMPLETELY LEFT THE CONSUMER WITH NO CONTROL OF THE STEERING. DEALER AND MANUFACTURE WERE CONTACTED AND HAVE A RECALL AND THAT THEY DON'T KNOW WHAT TO DO. TS

WHILE DRIVING 15MPH, STEERING WHEEL LOCKED UP. *AK VEHICLE WOULD NOT TURN FROM LEFT TO RIGHT, CONSUMER HAD TO STOP TO UNLOCK STEERING. *JB

HAD NO POWER STEERING, HAD TO STOP AND BACK UP TO COMPLETE TURN, STEERING COME AND GO. STOPPED TO CHECK COULD NOT DETERMINE THE CAUSE, FOUND POWER STEERING PUMP EMPTY.

LOST PARTIAL STEERING ABILITY WHILE DRIVING 55 MPH. NO PREVIOUS WARNING OF A PROBLEM EXISTED. VERY SCARY TO HAVE THIS HAPPEN WHILE DRIVING. *AK

POWER STEERING FROZE DUE TO BROKEN RACK AND PINION ON THE XEPRESSWAY, WAS VERY DANGEROUS AND SCARY. *AK

CONSUMER WAS DRIVING AT APPROXIMATELY 15 MPH WHEN SHAFT THAT HOLDS PULLEY SNAPPED OFF INSIDE POWER STEERING PUMP, CAUSING LOSS OF STEERING, CONSUMER WAS ABLE TO CONTROL VEHICLE ENOUGH TO GET OFF ROAD. NO PRIOR WARNING.*AK

WHILE MAKING A TURN ALUMINUM RACK AND PINION RUBBED AGAINST AND SHAFED INTO STEERING PUMP, CAUSING IT TO BURN OUT, RESULTING IN STALLING. THERE IS A NEW DESIGN OF THE PART. PLEASE PROVIDE FURTHER INFORMATION. *AK

RACK AND PINION STEERING LOCKED UP WHILE VEHICLE WAS IN USE, CAUSING LOSS OF VEHICLE CONTROL. *AK

POWER STEERING RACK HAD CONSTANT LEAK. YH

STEERING COLUMN ASSEMBLY FAILED. *YC