2007 CHEVROLET MONTE CARLO Electrical System Problems

The cable harness in question runs from the fuse box under hood through firewall to the passenger side foot area. At this point it connects to another harness that connects to various items at the rear of the vehicle. One circuit in particular the rear window defogger is burning wiring and socket and plug of the two wiring harness. Either the wiring or connectors burned apart without the circuit fuse blowing. The circuit has a 40amp fuse. The wiring harness for this circuit is 12 Garage. I can't find any manufacturer who recommends using 12 gauge wire on a 40 Amp circuit. This isn't even close to being correct. This is so agreegessly out of specification it would appear GM knew they had an issue with the circuit and fixed it By over fusing the circuit. This same issue on multiple models over several years.

I am having issues with my engine unintentionally turning off because of my ignition key and I sent it to the shop for recall repair but they said they didn’t have the part and couldn’t find it because it’s not available.

TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. WHILE STARTING THE VEHICLE, THE KEY REMAINED STUCK IN THE IGNITION SWITCH. ONCE THE KEY WAS REMOVED, THE IGNITON DID NOT CUT OFF. IN ADDITION, THE FRONT OF THE VEHICLE WAS LEAKING OIL. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED AND THE OIL LEAKAGE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

Mileage: 160,000

WHEN I ATTEMPT TO TURN OFF MY VEHICLE, THE KEY WILL NOT ROTATE TO THE OFF POSITION..THEREFORE, THE KEY IS STUCK IN THE IGNITION AND THE CAR IS STILL ON, DRAINING THE BATTERY. I TOOK THE CAR TO A DEALERSHIP IN 2013 AND TOLD NOTHING WAS WRONG WITH IT BUT THEY CHARGED ME $165.00 TO PUT IN A NEW IGNITION. THE PROBLEM WAS INTERMITTENT UNTIL DECEMBER 2014 AND NOW THE KEY IS PERMANENTLY STUCK IN THE IGNITION AND IF I WANT TO DRIVE MY CAR, I HAVE TO CHARGE THE BATTERY EVERY TIME I DRIVE IT. GM JUST RECALLED THE COBALT AND HHR FOR THE SAME ISSUE. WHY NOT EXPAND THE RECALL TO INCLUDE ALL GM PRODUCTS WITH THIS ISSUE. *TR

Mileage: 90,000

TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM) HOWEVER, THE VIN WAS NOT INCLUDED. THE CONTACT STATED THAT THE KEY BECAME DIFFICULT TO REMOVE FROM THE IGNITION AND THE TRANSMISSION FAILED INTERMITTENTLY. THE CONTACT MENTIONED THAT THE BATTERY NEEDED TO BE REPLACED EVERY YEAR. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

JULY 7,2014 MY MOTHER ([XXX]) WAS CROSSING DIXIE HWY. IN LOUISVILLE, KENTUCKY. MOTORCYCLE HIT HER ON THE RIGHT SIDE OF THE CAR. MOTORCYCLIST DIED AT THE SEEN OF ACCIDENT. MY MOTHER HAS BEEN SUFFERING FROM POST TRAUMA. THE CAR WAS TAKEN TO LMPD IMPOUND LOT AND WAS ON LOCK DOWN FOR A INVESTIGATION TO TAKE PLACE. I WAS ALLOWED PICK CAR UP AT IMPOUND APPROXIMATELY 9/30/2014. WHEN I CHECKED TO SEE IF IT WOULD START THE IGNITION WAS NOT COMPLETELY OFF THE KEY WAS TURNED BACK ENOUGH TO TURN MOTOR OFF BUT NOT ENOUGH TO TAKE KEYS OUT OF THE IGNITION. [XXX] SAYS MOTORCYLIST WAS FAR ENOUGH AWAY TO STOP IF THE CAR WAS STILL ROLLING. SHE NOT SURE WHAT HAPPENED FOR HIM TO HIT HER THAT HARD. PLEASE REPLY TO THIS CLAIM ASAP. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 65,189

TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE KEY WAS DIFFICULT TO REMOVE FROM THE IGNITION ON SEVERAL OCCASIONS AND THE KEY BECAME LODGED IN THE IGNITION SWITCH MORE THAN ONCE. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM); HOWEVER, THE PARTS NEEDED WERE NOT AVAILABLE. THE DEALER WAS UNABLE TO PROVIDE A SPECIFIC DATE WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. THE CONTACT STATED THAT THE VEHICLE FAILED TO RESTART AFTER BEING SHUT OFF. THE VEHICLE RESTARTED AFTER APPROXIMATELY FORTY MINUTES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM). THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

Mileage: 118,000

TL* THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM) AND STATED THAT THE PART NEEDED FOR THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

THE KEY WON'T TURN THE SWITCH TO OFF POSITION. THE KEY DON'T UNLOCK THE DRIVER DOOR WHEN THIS HAPPENS. *TR

Mileage: 113,128

LETTER FROM CONGRESSMAN FORBES ON BEHALF OF CONSTITUENT RE: VEHICLE RECALL ON 2007 CHEVROLET MONTE CARLO (MAIL REPLY TO CHESTERFIELD, VA OFFICE). *SMD THE CONSUMER STATED THE DEALER TOLD HIS WIFE, THEY KNEW NOTHING ABOUT A RECALL.

WHEN WE PUT THE VEHICLE IN PARK TO EXIT IT, THE KEY GETS STUCK. AS A RESULT WE HAVE TO HIT THE GEAR SHIFT A COUPLE OF TIMES TO REMOVE KEY. DOESN'T HAPPEN EACH TIME BUT DOES HAPPEN OFTEN. *TR

2007 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO A DEFECTIVE TRUNK LIGHT MECHANISM THAT IGNITED A FIRE IN VEHICLE BURNING IT BEYOND REPAIR. *SMD THE CONSUMER STATED THE VEHICLE WAS PARKED, AT THE TIME OF THE INCIDENT.

2007 CHEVROLET MONTE CARLO. CONSUMER WRITES IN REGARDS TO A DEFECTIVE TRUNK LIGHT MECHANISM THAT IGNITED A FIRE IN VEHICLE BURNING IT BEYOND REPAIR. *SMD THE CONSUMER STATED THE VEHICLE WAS PARKED, AT THE TIME OF THE INCIDENT.

CAR WILL NOT SHIFT OUT OF PARK INTERMITTENTLY. DEALER FOUND WIRES TO BE BROKEN AND WIRES THAT WERE FRAYED AT THE SHIFT SOLENOID. THEY REMOVED CONSOLE TO SPLICE AND FIX THE WIRES. DEALER DEEMED WEAR AND TEAR? AT 32,000 MILES? (CONSOLE WOULD HAVE COVERED THESE WIRES TOTALLY SO NOT SURE WHERE THE WEAR AND TEAR WOULD BE FROM). FROM PUTTING THE CAR IN PARK? DRIVE? REVERSE? I DOUBT IT WAS WEAR AND TEAR. *TR

Mileage: 32,130

TL*THE CONTACT OWNS A 2007 CHEVROLET MONTE CARLO. AT LOW SPEEDS SUCH AS 25 MPH, THE CONTACT CANNOT READ THE SPEEDOMETER GAUGE WHEN THE WEATHER IS CLOUDY OR OVERCAST. HE FELT THAT THIS WAS A SAFETY ISSUE BECAUSE HE CANNOT DETERMINE HOW FAST HE IS DRIVING. HE CALLED THE MANUFACTURER AND DEALER AND WAS INFORMED THAT THEY COULD INSTALL AN AFTERMARKET SPEEDOMETER, BUT IT WOULD NOT BE GUARANTEED. THE CONTACT REFUSED THIS OPTION. THE FAILURE MILEAGE WAS 150 AND CURRENT MILEAGE WAS 1,500. UPDATED 01/02/08.*LJ UPDATED 12/12/07

Mileage: 150