1998 CHEVROLET S10 Structure Problems

WATER LEAK IN COWL AREA ALLOWED RAIN WATER TO COLLECT UNDETECTED UNDER CARPET MOISTURE BARRIER CAUSING ACCESSORY HANDICAPPED ACCELERATOR PEDAL ASSEMBLY TO CORRODE. CORROSION OF THE PEDAL ARM PIVOT SHAFT EVENTUALLY CAUSED PEDAL TO FREEZE IN A PART THROTTLE POSITION IN TRAFFIC. EVASIVE MANEUVER REQUIRED TO AVOID COLLISION WHILE APPROACHING INTERSECTION. *TR

Mileage: 92,000

TL* THE CONTACT OWNS A 1998 CHEVROLET S-10. THE CONTACT STATED THAT THERE WAS A CRACK IN THE FRAME, BEHIND THE DRIVER'S SIDE LOWER CONTROL ARM. THE VEHICLE WAS TAKEN TO A DEALER, WHO STATED THAT THERE WAS NO CORROSION OR IMPACT THAT COULD HAVE CAUSED THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER, WHO REFUSED TO PROVIDE ASSISTANCE FOR THE REPAIR. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 47,000. THE CURRENT MILEAGE WAS 48,000.

Mileage: 47,000

TL*THE CONTACT OWNS A 1998 CHEVROLET S10 EXTENDED CAB. THE THIRD DOOR HANDLE ON THE DRIVER SIDE BROKE AS THE CONTACT ATTEMPTED TO OPEN THE DOOR. THE HANDLE BROKE AT LEAST FIVE TIMES AND HAD TO BE REPLACED THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 86,000. UPDATED 03/16/11 *BF

Mileage: 86,000

TL*THE CONTACT OWNS A 1998 CHEVROLET S-10. THE CONTACT TOOK THE VEHICLE TO HIS MECHANIC AND WAS INFORMED THAT THE MAINFRAME WAS RUSTED VERY BADLY. THE DEALER WANTS TO CHARGE $100 FOR DIAGNOSTIC TESTING. THE CONTACT INFORMED THE DEALER THAT HIS MECHANIC ALREADY DIAGNOSED THE ISSUE AND WILL NOT PAY FOR A DIAGNOSIS. THE FAILURE MILEAGE WAS 70,000. UPDATED 03/09/09. *LJ UPDATED 3/5/09 *CN UPDATED 03/12/09. *JB

Mileage: 70,000

OPENING OF TAILGATE ON 1998 CHEVY S10 AND WHEN SITTING DOWN ON TAILGATE A SNAP SOUND OCCURRED AND THE TAILGATE DROPPED SLIGHTLY INDICATING THE SUPPORT CABLE SNAPPED ON PASSENGER SIDE. PART IS ON ORDER. *TR

Mileage: 121,000

ON MY 1998 CHEVY S-10 BOTH OF THE TAILGATE CABLE BROKE. THE CABLES BROKE AND THE WOOD I WAS LOADING SLID OFF AND HIT MY FOOT IT DID HURT IT, BUT LUCKILY IT WAS NOT BAD. IT ALSO DAMAGE MY TAILGATE ON MY TRUCK. I HAVE SEE ON THE INTERNET AND FROM OTHER PEOPLE ABOUT THERE TAILGATE CABLES BREAKING. I HAVE SEEN IT ON 1995, 1998 AND 2000 S-10 TRUCKS. I THINK THAT GM NEEDS TO MAKE REPLACEMENT CABLES THIS VERY DANGEROUS AND IF YOU WERE LOADING SOMETHING IT COULD SLID OFF THE TAILGATE AND HURT THEMSELVES LIKE I DID. THANK YOU, [XXX]. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 118,000

BOTH CABLES ON MY 1998 CHEVY S-10 PICK-UP HAVE SNAPPED. MY DOG WAS USING A RAMP THAT RESTED ON THE TAILGATE WHEN IT HAPPENED. IT CAUSED THE RAMP TO FALL A FEW INCHES LUCKILY THE DOG WAS UNINJURED HOWEVER HE IS VERY FRIGHTENED TO USE THE RAMP NOW. HE WEIGHS OVER 150S SO I CAN'T LIFT HIM. I WENT TO THE LOCAL AUTO PARTS STORE TO GET NEW CABLE WHEN I WAS TOLD ABOUT THE RECALL ON OTHER SIMILAR VEHICLES. I HAVE PUT OFF REPAIRING THIS IN ANTICIPATION OF A RECALL. *JB

Mileage: 153,750

DT*: THE CONTACT STATED DURING ROUTINE INSPECTION OF THE SPARE TIRE, THE CABLE THAT HELD THE TIRE FRACTURED AND RELEASED THE TIRE. THE FAILURE WAS NOT NOTICED UNTIL RECENTLY. THE CONTACT FOUND A SIMILAR PROBLEMS AT OTHER S10 TRUCKS. UPDATED 06/07/2006. *AK *TS

Mileage: 216,000

THE UPPER HINGE ON THE DRIVERS DOOR IS SO WORN AWAY THAT IT HAS CAUSED A DOOR SEAL LEAK AND RAIN GETS IN. NOTHING HAS BEEN DONE TO CORRECT IT YET. *JB

I HAVE A 1998 CHEVY S-10 AND THE LEFT TAILGATE CABLE BROKE. IT BROKE WHEN I OPENED THE TAILGATE AND SAT DOWN ON IT. I DID NOT GET HURT BUT I THINK A CABLE NEEDS TO BE ABLE TO HOLD SOME WEIGHT. I HAVE HEARD THAT THE CABLES RETAIN MOISTURE WHICH CAUSES THEM TO RUST OUT AND MINE WAS RUSTED. I LEFT THE CABLE ON AND IT DAMAGED THE TAILGATE BY PUTTING A DENT IN IT AND CRACKING THE PAINT. I CUT THE CABLE SO IT WOULD NOT DAMAGE THE TAILGATE ANY MORE. MY BROTHER TOLD ME I COULD USE HIS CABLE FROM HIS TAILGATE AND I AM. I THINK THAT IT SHOULD BE RECALLED AS THIS IS A SAFETY PROBLEM. I HEARD THEY MIGHT RECALL THIS SO I DECIDED TO PUT MY INPUT BECAUSE SOMEONE COULD GET HURT. I ALSO BOUGHT REPLACEMENT CABLES, BUT THERE IS NO WAY TO PUT THEM ON BECAUSE GM USES A BIG RIVET. I HAVE HEARD OF OTHER PEOPLE'S CABLES ON THEIR 95-2003 S-10'S. THANKS.*JB

Mileage: 112,000

ON MY 1998 CHEVROLET S-10, THE TAILGATE SUPPORT CABLE BROKE DUE TO INTERNAL CORROSION. THIS HAPPENED TWO YEARS AGO. THERE WERE NO INJURIES. I REPLACED THAT CABLE AT SIGNIFICANT COST. NOW THE SECOND TAILGATE SUPPORT CABLE IS BULGING DUE TO INTERNAL CORROSION AND I EXPECT IT WILL SOON BREAK. *NM

Mileage: 85,000

I OWN A 1998 CHEVROLET S-10. THE CABLES THAT HOLD UP THE TAILGATE BROKE ON ME WHILE I WAS LOADING CARGO INTO THE BED. THE BROKEN STRAPS HAS SINCE CAUSED MY TAILGATE TO FALL OFF WHILE GOING DOWN A ROUGH ROAD. THE TAILGATE IS NOW SCRATCHED AND DENTED FROM THE INITIAL BREAKING AND FROM FALLING OFF. I HAVE NOT MADE ANY ATTEMPT TO FIX THIS PROBLEM AS OF YET. *NM

Mileage: 90,000

DT: THE CONTACT STATED THE EMERGENCY RELEASE FOR THE TAILGATE HATCHBACK/LIFTGATE OPENING FAILED TO OPERATE. HE CONTACTED THE DEALERSHIP, THEY WANTED TO DO A DIAGNOSTIC CHECK. ALSO, HE CONTACTED THE MANUFACTURER; THEY SUGGESTED THE DIAGNOSTIC CHECK BE DONE. *AK

DT: THE CONTACT STATED THE EMERGENCY RELEASE FOR THE TAILGATE HATCHBACK/LIFTGATE OPENING FAILED TO OPERATE. HE CONTACTED THE DEALERSHIP, THEY WANTED TO DO A DIAGNOSTIC CHECK. ALSO, HE CONTACTED THE MANUFACTURER; THEY SUGGESTED THE DIAGNOSTIC CHECK BE DONE. *AK

THE EXTENDED CUB 3RD DOOR HANDLES CONTINUES TO BREAK EVERY 6 MONTHS. IT IS MADE OF PLASTIC. I PURCHASED THE 1998 S10 IN MARCH, 04, IN JULY THE HANDLE BROKE. THIS SAME NEW HANDLE BROKE WAS REPLACED IN DECEMBER, 04. FINALLY, THE 2 NEW HANDLE BROKE IN AUGUST, 05. THE BREAK IS ALWAYS IN THE SAME AREA. THE DEALER HAS COMMENTED THAT HE HAS NUMEROUS COMPLAINTS TO HIM FOR THIS PART, BUT TO CHEV HAS MADE NO EFFORT TO RECALL OR ASSIST IN ANY WAY. CAN I HAVE YOUR REVIEW AND ASSISTANCE? *NM

Mileage: 97,000

DT: CONSUMER STATED THAT THE TAILGATE CABLE SNAPPED WITH VERY LIGHT WEIGHT ON IT. AT THE TIME THE CABLE SNAPPED THERE WAS A CHILD ON THE TAILGATE. THIS WAS ON THE RIGHT SIDE, BUT THE LEFT SIDE CARRIED THE WEIGHT. THE OWNER WAS CONCERNED THAT HE WILL NOT BE ABLE TO TRUST THE TAILGATE AT THIS POINT. THE OWNER WAS GOING TO REPLACE THE TAILGATE CABLES AND MAYBE THE WHOLE TAILGATE ITSELF. THE CABLES WERE FINE. THERE WERE NOT ANY WEAR AND TEAR ON THE CABLES. THE OWNER CALLED THE DEALER, AND THEY WERE UNABLE TO PROVIDE ANY ASSISTANCE. THE OWNER ALSO CALLED GM, AND THEY CONTACTED THE MANAGER, WHO RELAYED ANY ASSISTANCE IN THIS MATTER. THEY WERE NO INJURIES.*AK

Mileage: 49,000

1998, S10 PICKUP TAILGATE STRAPS RUSTED IN 2 PIECES. THESE WERE RECALLED ON MY 2002 1500 FULL SIZE. WHY NOT THE S10 ? *AK

EA 05 008/TAILGATE SUPPORT CABLES BREAK: WHILE STANDING ON THE TAILGATE AND LOADING A SINK ONTO THE REAR BED THE LEFT SIDE SUPPORT CABLE HAS BROKEN. NO INJURY TO REPORT. THE DEALER WAS NOTIFIED. *NM

Mileage: 96,200

WHILE OPENING THE TAILGATE THE CABLE BROKE ON BOTH SIDE BECAUSE THEY HAD RUSTED. *AK......*AK

Mileage: 48,000

(1) LOADING SMALL RIDING LAWNMOWER INTO BED OF MY S-10 PICKUP (2) BOTH TAILGATE CABLES BROKE WITH NO PRIOR SIGN OF WEAR (3) AWAITING REPLACEMENT CABLES AT EXPENSE OF CHEVROLET, BECAUSE THEY KNOW THE PROBLEM EXISTS ON CURRENT MODELS AND HAVE RECALLED THEM, BUT NOT MINE!. *AK

Mileage: 92,500

WHEN THE TAILGATE WAS IN USE BOTH OF THE TAILGATE SUPPORT STRAPS SNAPPED. THIS CAUSED THE TAILGATE TO FALL. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEMS. *AK

Mileage: 20,000

ON TWO SEPARATE OCCASIONS, THE CONSUMER HAD TO REPLACE THE TAILGATE SUPPORT CABLES DUE TO CORROSION/RUST. *JB *TC

Mileage: 84,000

CONSUMER NOTICED THAT THE TAILGATE CABLE CORRODED AND SNAPPED. THERE WAS A RECALL DEALING WITH THIS PROBLEM BUT DID NOT INCLUDE S10 MODEL. *AK

Mileage: 105,000

TAILGATE SUPPORT STRAPS FAILED. DEALERSHIP WAS NOTIFIED BUT DID NOT RESOLVE THE PROBLEM. *AK *NM

Mileage: 37,000

STEEL CABLES ON TAILGATE SNAPPED WHILE IN STORED (NO LOAD APPLIED) CONDITION. *AK

VEHICLE HAVING SERIES OF PROBLEMS AFTER AN ACCIDENT WITH A DEER. *MR THE HOOD LATCH HASN'T WORKED PROPERLY SINCE THE ACCIDENT, BOTH CHAIR LATCHES HAD BROKEN AFTER TWO TIMES OF USE, THE RIGHT FRONT OF THE VEHICLE MADE NOISE, THERE WAS NOISE IN THE STEERING, THE CENTRAL CONSOLE SNAPPED IN HALF, AND THE REAR WIPERS HAD GONE OUT. *SCC *JB

THE DRIVERS DOOR DID NOT STAY LATCH, WHICH CAUSED THE DRIVER TO FALL OUT OF THE VEHICLE, THE SPRINGS POPPED OUT.*JB

Mileage: 81,000

CHEAP HANDLES,BREAK WHILE TRYING TO ADJUST, PUTS PERSON IN UNSAFE POSITIONS WERE IT LOCKS WHEN IT BREAKS. *AK

CONSUMER TOOK VEHICLE TO HAVE A FRONT END ALIGNMENT DONE, AND MECHANIC STATED THAT FRAME WAS CRACKED. CONSUMER CALLED GMC, AND WAS TOLD TO TAKE VEHICLE TO AN AUTHORIZED DEALER. DEALER STATED VEHICLE WAS ABUSED AND AGGRESSIVELY TREATED. *AK

TAILGATE INTERMITTENTLY COMES OPEN WHENEVER A LOAD IS CARRIED. VEHICLE HAS BEEN IN DEALER'S SHOP ON SEVERAL OCCASIONS, AND PROBLEM IS REOCCURRING.*AK

FRAME AND BUMPER LEAN TO THE LEFT SIDE. DEALER HAS REPLACED THE LEAF SPRINGS AND PROBLEM STILL EXISTS. *AK

FRAME AND BUMPER LEAN TO THE LEFT SIDE. DEALER HAS REPLACED THE LEAF SPRINGS AND PROBLEM STILL EXISTS. *AK

THERE HAS BEEN A PERSISTENT PROBLEM WITH THE TAILGATE ON THIS TRUCK FROM DAY 1. DRIVING DOWN THE STREET AND FOR NO APPARENT REASON THE TAILGATE POPS OPEN. I HAVE HAD THIS HAPPEN SO OFTEN THAT I NOW USE BUNGEE CORDS TO KEEP THE TAILGATE SHUT IN CASE THE LATCH FAILS. I HAVE HAD DEALERS TWICE DO WARRANTY WORK ON THIS, BUT THEY HAVEN'T REALLY FOUND THE PROBLEM YET. THE LATCH LOOKS NORMAL, EVERYTHING SEEMS TO LINE UP, BUT YOU NEVER KNOW WHEN THE TAILGATE IS GOING TO FLOP OPEN. USUALLY WHEN I'M PULLING A TRAILER, BUT OFTEN NOT.. MY THEORY IS THAT THE FRAME AND BODY ARE SO FLEXIBLE THAT TOLERANCES OPEN UP AND POP, THE LATCH NO LONGER HOLDS. HOPE YOU GUYS HAVE SOME KIND OF A HANDLE ON THIS PROBLEM. THANKS-- JMS

VECHICLE HAS BEEN IN SHOP SEVERAL TIMES FOR THE SAME THING. LEANING DOWN 1-3/4INCH ON LEFT SIDE OF TRUCK.

THE HANDLE TO ADJUST THE SEAT BROKE OFF. YH

STEERING PULL TO THE RIGHT. GOT IT REPAIR BUT I THINK IT'LL HAPPEN AGAIN. 3RD DOOR HANDLE BROKE OFF.. LOOK LIKE THEY WERE MADE VERY CHEAP AND I THINK IT 'LL BROKE AGIAN. THEY SHOULD USE METAL TO MAKE DOOR HANDLES.

DRIVER'S SIDE DOOR DOES NOT CLOSE PROPERLY, SEVERAL REPAIR ATTEMPTS HOWEVER CONTINUES TO NOT CLOSE PROPERLY.

FRONT FENDER AND SIDE DOOR OUT OF ALIGNMENT CAUSING THUMPING NOISE.

FRONT FENDER AND SIDE DOOR OUT OF ALIGNMENT CAUSING THUMPING NOISE.

WEATHER STRIP COMING OFF PASSENGER DOOR.

PASSENGER SIDE DOOR HANDLE BROKE.

THE PICKUP TRUCK WAS GIVEN TO THE DEALER 2 TIMES ALREADY AND THE INTEROR LEAKAGE PROBLEM STILL EXISTS. ON THE FIRST ATTEMPT, THE DEALER CLAIMED THAT I LEFT THE DOOR OPEN AND IT WAS MY FAULT THE VEHICLE LEAKED. ON THE SECOND ATTEMPT AT TAKING IT TO THE DEALER, I SAT IN THEIR LOBBY FOR AN HOUR-AND-A-HALF WHILE THEY CLAIMED THEY WERE FIXING THE PROBLEM. THE NEXT DAY IT RAINED AND THE VEHICLE CONTINUED TO LEAK. I AM CONTACTING THE DEALER TOMORROW FOR A THIRD ATTEMPT AT REPAIR.

THE EXTENDED CAB DRIVER'S SIDE DOOR FRAME IS LOOSE, AND CAUSES THE DOOR NOT TO LATCH PROPERLY. THE DOOR LEAKS WHEN IT RAINS AND THE DOOR HAS OPENED UNEXPECTEDLY. PLEASE LIST MORE DETAILS. *AK