2005 CHEVROLET SILVERADO 1500 Service Brakes Problems

I have had brakes fail twice because of corroded brake lines now one of my fuel lines ruptured because of corrosion I have been told by mechanics that corroded failing lines is a common issue on Silverado's

Design flaw - Brake light switch- the end section of the internal spring is placed in a position that allows it to potentially slide down and block the space needed for when the plunger is depressed, jamming up the switches ability to properly function. I have not determined what happened to the switch on my truck, but noticed that this scenario was a possibility and felt obligated to report my opinion.

As I approached an intersection to make a left-hand turn, I stepped on my trucks brake pedal. I experienced a complete loss of braking power, with the trucks brake pedal going straight to the floor, after an instant of a firm, solid pedal. Pumped the pedal to try to regain brake operation to no avail. No hydraulic pressure was present. No warning lights or other indications of brake system failure occurred. Truck was driven home a very short distance using e-brake. Brake fluid was seen dripping from the rear axle area in large amounts. Truck was towed to my local garage which found a burst steel brake line at the junction with the rear hydraulic flex hose. Other brake lines were heavily rusted. Rest of the undercarriage was not similarly rust like the brake lines. The garage stated this was not the first Silverado they saw with this problem. All steel lines were replaced with stainless steel lines, and as a precaution we replaced all brake hoses as well. The bleeder screws on the front disk brake calipers, and on the rear wheel cylinders were also found heavily rusted and frozen, so those components were replaced as well. The shop stated this issue of severe corrosion of brake lines and bleeders is very common on this generation of Silverado’s . They have repaired quite a few like mine after similar brake failures. If you research the issue on-line, there certainly is a problem with these trucks. In my 45 years as a mechanic and practicing mechanical engineer, I have never seen brake system components so severely corroded as the ones removed from my truck. I was lucky I wasn’t towing anything, or was at highway speed when the failure occurred. The next owner may not be that lucky if it happens to them.

The contact owns a 2005 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the vehicle started to leak fuel and the brake line would leak causing the brakes to lose power whenever the brake pedal was depressed. The contact also stated that the fuel tank strap fractured due to rust causing the fuel tank to detach from the vehicle. The contact stated that the rear leaf spring fractured due to rust as well. The contact also stated that the entire sub-frame of the vehicle was rusted causing pieces of metal to fall off from the frame while driving. The brake warning light was illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the brake lines, fuel lines, the rear leaf shackle, and the fuel tank needed to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 58,000.

Mileage: 58,000

SON WAS DRIVING TRUCK AND BRAKES WENT TO THE FLOOR. ALMOST HIT THE CAR IN FRONT OF HIM. ONCE I WAS ABLE TO GET THE TRUCK HOME, I FOUND A LEAK IN THE BRAKE LINE UNDER THE DRIVERS SIDE DOOR THAT APPEARS TO BE DUE TO RUST.

Mileage: 75,000

THIS IS 3RD TIME MY BRAKES BLOW A LINE IN 2 YEARS AND THE FIRST 2 TIMES ONE TIME I WAS HOLDING MY BRAKES WHILE BACKING UP A HILL ON MY PROPERTY WITH A TRAILER ATTACHED, THE SECOND COMING TO A STOP SIGN AND THIS LAST TIME GOING DOWN A STEEP HILL COMING TO AN INTERSECTION. I JUST CHANGED THE LINE THAT WAS BROKEN THE FIRST TWO TIMES. I HAD FILED A COMPLAINT WITH YOU LAST YEAR BUT I CANNOT FIND THE INFO. THIS TIME I CHANGED ALL OF THE LINES AS IT SCARED ME BAD THIS TIME AS I LIVE IN THE MOUNTAINS AND DID NOT WISH TO PUSH MY LUCK ANY FURTHER. CHEVROLET WANTED OVER $1,200 TO CHANGE THEM OUT USING THE SAME MATERIALS THAT FAILED IN THE FIRST PLACE. I HAD THEM CHANGED AT NAPA FOR $680 USING COPPER/NICKEL WHICH IS A SUPERIOR PRODUCT. GM'S EXCUSE FOR THE LINES RUSTING OUT WAS THE CUSTOMER DID NOT WASH THE LINES OFF WHEN SALT GOT ON THEM. YOU CANNOT GET TO MOST OF THE LINES TO WASH THEM OFF. THE AMOUNT OF BRAKE LINE FAILURES IS OVERWHELMING AND TO SAY THE LEAST DANGEROUS AS HELL. I AM SENDING SOME PHOTOS OF SOME OF THE LINES AND WILL MAIL PIECES OF THE LINE TO YOU IF IT WILL DO ANY GOOD. PLEASE LET ME KNOW IF I SHOULD SEND THE PIECES OF LINE. THANKS [XXX] PS: IT SEEMS THAT I CAN ONLY SEND ONE PHOTO PLEASE LET ME KNOW HOW TO SEND MORE... ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).')*JB

Mileage: 86,000

WHILE TRAVELING IN TRAFFIC ON THE HIGHWAY AT LESS THAN 30 MILES PER HOUR WHEN I WENT TO APPLY MY BRAKES THE ABS CAME ON IMMEDIATELY SHORTENING MY SAFE STOPPING DISTANCE ENOUGH SO THE END RESULT WAS A COLLISION.

Mileage: 160,000

HI MY NAME IS [XXX] MY EMAIL IS [XXX]. I'VE HAD MY 2005 CHEVROLET SILVERADO SS TRUCK WITH THE 6.0 ENGINE FOR FIVE YEARS. IN THOSE 5 YEARS I HAVE HAD TO CHANGE THE WHEEL HUB ASSEMBLY'S AND THE FRONT ROTORS 7 TIMES. I'M PRETTY SICK OF THIS RECURRING ISSUE I SEE THAT THERE WAS A RECALL ON THE REGULAR SILVERADOS FOR MY YEAR BUT NOT ON THE 6.0 ENGINE I'M NOT SURE WHAT GIVES BUT I NEED THIS PROBLEM TO BE RECTIFIED. THIS IS A NORMAL EVERYDAY DRIVING VEHICLE TO AND FROM WORK NOTHING SPECTACULAR AND THERE SHOULDN'T BE THAT MUCH WEAR AND TEAR ON THOSE PARTS IN THAT LITTLE BIT OF TIME I'VE OWNED TONS OF OTHER VEHICLES FOR THAT AMOUNT OF TIME AND LONGER AND I'VE NEVER HAD TO CHANGE THAT PART ONCE I'VE HAD TO CHANGE IT 7 TIMES ON THIS VEHICLE I REALLY LOVE MY VEHICLE AND DON'T WANT TO SELL IT SO I'M TRYING TO FIGURE OUT IF THERE IS A PERMANENT FIX FOR IT OR A RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 97,000

WHILE DRIVING APPROX 50MPH ON 2-LANE HIGHWAY A BRAKE LINE BURST UNDER HARD BRAKING (VEHICLE IN FRONT OF ME SUDDENLY SLOWED TO MAKE A TURN OFF THE HIGHWAY) DUE TO RUST. PEDAL WENT ALL THE WAY TO THE FLOOR AND I LOST SIGNIFICANT BRAKING POWER. THIS RESULTED IN A MINOR ACCIDENT WHERE I DENTED THE BUMPER OF THE TRUCK THAT WAS TURNING AND SIGNIFICANTLY BENT THE RIGHT END OF MY FRONT BUMPER. WAS ABLE TO CONTINUE THE TRIP THE LAST 50 MILES TO MY DESTINATION BUT BRAKING DISTANCES WERE CONSIDERABLY LONGER THAN NORMAL. TOOK IT TO A LOCAL MECHANIC WHO SAID ALL THE BRAKE LINES WERE RUSTED AND HAD TO BE REPLACED.

Mileage: 213,300

WHEN BRAKES ARE APPLIED WHILE DRIVING AND THE ANTI-LOCK BRAKE FEATURE ENGAGES BECAUSE OF SLICK CONDITIONS, THE BRAKES LOCK UP AND REMAIN THAT WAY EVEN WHEN THE BRAKE PEDAL IS RELEASED. THIS CAUSES THE TRUCK TO GO INTO A SLIDE. IT HAPPENS AT ALL SPEEDS BUT ONLY WHEN THE ABS IS ENGAGING.

WHILE TRAVELING AT ABOUT 5 MPH, I EXPERIENCE A TOTAL BRAKE FAILURE. THE PETAL DROPPED TO THE FLOOR. I WAS UNABLE TO STOP THE VEHICLE RESULTING IN A REAR END COLLISION WITH THE STOPPED VEHICLE IN FRONT OF ME. IT WAS DETERMINED THAT A BRAKE LINE RUPTURED. I WAS UNDER THE IMPRESSION THAT IT WAS A LAW THAT VEHICLES OF THIS YEAR HAD A DUAL BRAKING SYSTEM TO AVOID THIS SITUATION. IF THIS VEHICLE DOES HAVE SUCH A SYSTEM IT DID NOT FUNCTION.THE VEHICLE HAD TO BE TOWED FROM THE SCENE SINCE IT HAD NO BRAKES.

Mileage: 212,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE THE VEHICLE WAS ON AN INCLINE, THE BRAKES FAILED TO ENGAGE WITHOUT WARNING. AFTER DEPRESSING THE BRAKE PEDAL SEVERAL TIMES, THE BRAKES WERE ABLE TO ENGAGE. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 85,349.

Mileage: 85,349

BRAKES FAILED. LEAK FROM CORRODED BRAKE LINE

Mileage: 150,000

TOTAL BRAKE FAILURE DUE TO A RUPTURED METAL BRAKE LINE/PIPE. FAILURE OCCURRED IN MY DRIVEWAY WHILE ATTEMPTING TO MOVE THE TRUCK FORWARD. I UNDERSTAND THAT A RECALL FOR THIS FAILURE WAS DENIED FOR GENERAL MOTORS TRUCKS UP TO THE 2003 MODEL YEAR BUT MY TRUCK IS A 2005 MODEL, AND BASED ON WHAT I HAVE LEARNED, THIS FAILURE CONTINUES WITH NEWER MODELS. THIS RECALL NEEDS TO BE RE-OPENED AND RE-INVESTIGATED BY PROFESSIONAL ENGINEERS AND MECHANICS. I'VE WORKED ON MOTOR VEHICLES ALL MY ADULT LIFE, FOR A TIME AS A CERTIFIED NEW YORK STATE INSPECTOR EVEN, AND NEVER SAW A CORROSION RELATED BRAKE FAILURE OF THIS NATURE. MY TRUCK IS NOT A WORK TRUCK. THIS TYPE OF BRAKE FAILURE CAN, AND LIKELY HAS BEEN THE RESULT OF FATAL ACCIDENTS. THERE ARE NOW WELL OVER 3.5K COMPLAINTS AND HUNDREDS OF ACCIDENTS RELATING TO THIS SPECIFIC BRAKE FAILURE ON GM TRUCKS.

Mileage: 53,500

COMPLETE AND SUDDEN BRAKE FAILURE WHILE PRESSING ON BRAKE PEDAL TO SLOW VEHICLE TO AVOID COLLIDING WITH VEHICLE AHEAD -VEHICLE WAS IN MOTION _OPERATOR PRESSED BRAKE PEDAL -BRAKE PEDAL TRAVELLED TO FLOOR AND VEHICLE DID NOT SLOW CERTIFIED MECHANIC DIAGNOSED PROBLEM AS BURST BRAKE LINE

Mileage: 96,000

ALL BRAKE LINES RUSTED . BRAKE LINES LEAKING FLUID . LOW BRAKE FLUID. WAS DRIVING ON HIGHWAY HAD PAY LOAD400 POUNDS.

Mileage: 89,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING LESS THAN 5 MPH, THE BRAKE PEDAL WOULD UNEXPECTEDLY STOP WORKING. THE CONTACT STATED THAT THE ANTI-LOCK BRAKE SYSTEM WAS NOT FUNCTIONING PROPERLY. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL SEVERAL TIMES TO GET IT TO WORK. THE STEERING WHEEL WOULD ALSO STOP FUNCTIONING WHEN THE BRAKES EXPERIENCED THE FAILURE. THERE WERE NO WARNING INDICATORS ILLUMINATED AT THE TIME OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIRED. THE MANUFACTURER WAS CALLED, BUT THE CONTACT DID NOT SPEAK WITH A LIVE REPRESENTATIVE. THE FAILURE MILEAGE WAS 220,000.

Mileage: 220,000

I WAS DRIVING DOWN A HILL ABOUT 25 MPH ON A CITY STREET WHEN A WARNING NOTICE APPEARED " SERVICE STEERING SYSTEM" AND " SERVICE BRAKE SYSTEM". ALMOST IMMEDIATELY I COULD NOT STEER OR BRAKE. I ALMOST HIT A PEDESTRIAN TRYING TO STEER AND STOP. I FINALLY WAS ABLE TO TURN A CORNER AND STOPPED. I SLOWLY DROVE TWO BLOCKS TO MY HOUSE AT ABOUT 5 MPH. I AM A STRONG MAN AND IF MY WIFE OR A LESS STRONG INDIVIDUAL HAD BEEN DRIVING, OR IF I HAD BEEN GOING MORE THAN THE 25 MPH OR IF I WAS DRIVING AT NIGHT, I AM SURE I WOULDN'T HAVE BEEN ABLE TO AVOID HITTING THE PEDESTRIAN AND / OR GOING OFF THE ROAD AND WRECKING. THIS SEEMS LIKE A MAJOR ACCIDENT WAITING TO HAPPEN. MY VEHICLE HAS BEEN TOWED TO THE GMC REPAIR SHOP IN BEAVERTON, OREGON AWAITING DIAGNOSIS.

Mileage: 85,000

I WAS COMING HOME ON A STATE HIGHWAY TRAVELING 45 MPH I TURNED ONTO MY HOME STREET AND I HAD NO BRAKES. LUCKILY I WAS 200 FEET FROM MY DRIVEWAY AND I COASTED AND TURNED INTO MY DRIVEWAY AND WAS ABLE TO STOP. I HAD IT TOWED TO A GM DEALER AND FOUND OUT ALL MY BRAKE LINES HAD RUSTED OUT. THE MECHANIC COULD NOT GET THE BLEEDER SCREWS OFF THE CALLIPHERS BECAUSE THE SCREWS WERE ALSO RUSTED OUT. WE ALWAYS UNDERCOAT OUR VEHICLES WHEN WE BUY THEM BRAND NEW SO NOTHING WOULD RUST OUT UNDER THERE. IN 2005 WE WERE TOLD BY OUR DEALER THAT IF WE UNDERCOAT WE WOULD LOSE OUR WARRANTY. THE MECHANIC ALSO TOLD US THAT THE NEW BRAKE LINES ARE ALL POLY COATED NOW, SO THEY WON'T RUST OUT ANYMORE. WHY WEREN'T THEY POLY COATED TO BEGIN WITH . THE EXPENSE WAS 1200.00 TO REPLACE THE BRAKE LINES PLUS THE TOWING FEE. THE MECHANIC TOLD US HE SEEN THIS IN 2002,2003,2004,2005 AND 2006 TRUCKS. 2007 HASN'T COME IN YET.

Mileage: 95,125

BACKED OUT OF DRIVEWAY BRAKE PEDAL WENT TO FLOOR.REPAIR SHOP SAID BRAKE LINES ALL RUSTED.

Mileage: 70,000

WHILE DRIVING ON A HIGHWAY AT 55MPH, I PRESSED ON THE BRAKE TO SLOW MY SPEED AS I WAS ENTERING A CONGESTED AREA NEARING A TOWN. THE PEDAL WENT TO THE FLOOR. I GEARED IT DOWN MANUALLY WITH MY GEARSHIFT AND TURNED OFF THE HIGHWAY INTO A SELF-CAR WASH. AFTER LOOKING UNDER VEHICLE, I NOTICED BRAKE FLUID ALL AROUND DRIVERS SIDE REAR WHEEL. AFTER FURTHER DETAILED INSPECTION, THE BRAKE LINE THAT RUNS FROM THE MASTER CYL TO REAR OF VEHICLE TO A UNION MOUNTED ON FRAME THAT CONVERTS SOLID LINE TO FLEX HOSE TYPE HAD CORRODED AND CRACKED. TRUCK WAS JUST INSPECTED 6 MONTHS PRIOR AT DEALER. IN MY 45 YEARS OF DRIVING PROFESSIONALLY, I HAVE NEVER HAD A BRAKE LINE FAIL FOR NO REASON, AS IT WAS UNTOUCHED AND SECURED JUST AS IT WAS WHEN IT LEFT FACTORY. ITS OBVIOUS TO ME AND EVERYONE I TALK TO THAT THE BREAK LINE IS MADE OF A LOWER QUALITY STEEL OR NOT AS THICK AS ONES PRODUCED IN THE PAST BY GM. I HAVE HEARD THAT THRU THE GRAPEVINE THAT A CERTAIN SOMEONE WHO DECIDES FAULTS IN THESE CASES SUGGESTED THAT SALT PUT ON THE ROADS IN THE WINTER COULD HAVE CAUSED THIS IF THE TRUCKS UNDERSIDE WERE NOT WASHED OFF AFTER WINTER DRIVING TO REMOVE THE CORROSIVE SALT. WHILE I WOULD AGREE TO THAT TO SOME EXTENT, BECAUSE I AM ONE WHO DOES TAKE PRIDE IN MY $ 32,000 VEHICLE, I NOT ONLY POWER WASH THE UNDERSIDE SEVERAL TIMES A WINTER, BUT ALSO UNDERCOAT IT AS WELL. WHAT MAKES THIS SO DANGEROUS, IS THAT BRAKE FLUID THAT LEAKS CAUSES MAJOR DAMAGE TO EVERYTHING IT COMES IN CONTACT WITH. MY FUEL TANK, WIRING, INSULATION AROUND WIRE, PAINT THAT PEELS OFF EVERYTHING WHICH MEANS FRAME RUST NOW. THE WORST AND MOST DANGEROUS OF ALL IS THAT THE LEAKING BRAKE FLUID TURNS PAVEMENT MADE WITH ASPHALT INTO A OIL SLICK ON THE ROAD THAT IS NOT NOTICED BY THE EVERYDAY DRIVER. AND THERE IS NO STOPPING WHATSOEVER WHEN YOU START TO SLIDE. I WANT GM TO FIX AND INSTALL THE SAFE AND CORRECT ONES, STAINLESS STEEL. THANK YOU *TR

Mileage: 15

I WAS GOING DOWN MY DRIVEWAY, PULLING A 16 FT STOCK TRAILER AND THE BRAKE LINE TO THE REAR PASSENGER SIDE WHEEL RUPTURED. I WAS ABLE TO STOP, BUT COULD NOT HAVE IF I'D BEEN AT HIGHWAY SPEED. THE ELECTRIC BRAKES ON THE TRAILER HELPED. TOOK TO CHEVY SERVICE AND ALL BRAKE LINES WERE CORRODED AND EATEN THROUGH. PISTONS CORRODED AND STUCK ON BOTH FRONT CALIPERS. ALL LINES WERE REPLACED ALONG WITH THE CALIPERS. TOTAL COST WAS $1647.94 PARTS WERE $484, THE REST WAS LABOR. TRUCK HAD TO BE TOWED TO DEALER. THEY WANTED TO REPLACE REAR PADS AND DRUMS BECAUSE THEY WERE EXPOSED TO BRAKE FLUID, BUT WE CAN'T AFFORD THAT RIGHT NOW.

Mileage: 61,500

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 45 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE BRAKES FAILED TO OPERATE. THE CONTACT CRASHED INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

ON JULY 23RD I WAS DRIVING ON A LOCAL HIGHWAY AT 55 MPH. WHEN I ATTEMPTED TO BREAK FOR A TURN THE PEDDLE WENT ALL THE WAY TO THE FLOOR. I HAD TO COAST TO A STOP. A RUSTY BREAK LINE BLEW OUT IN THE ENGINE COMPARTMENT ON THE DRIVERS SIDE. I AM LUCKY NO OTHER VEHICLES WERE ON THE ROAD WITH ME.

Mileage: 64,000

BRAKE PEDAL GOES ALL THE WAY TO THE FLOOR NO PRESSURE. LOST ALL PRESSURE DURING SNOWSTORM. LUCKY TO PULL OVER INTO DRIFTED SNOW TO PREVENT CRASH. 61000 MILES AND WELL MAINTAINED. MARYLAND AREA. UPON INSPECTION ALL BRAKE SUPPLY LINES ARE RUSTED AND BLOWN OUT. VERY DIFFICULT TO REPAIR ONESELF. VERY COSTLY REPAIR AT DEALERSHIP. THIS SHOULD BE A SFETY RECALL. RIDICULOUS!

Mileage: 61,000

BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WHEN APPLIED. THE PICKUP HAS ABOUT 62000 MILES ON IT IS WELL MAINTAINED. LOCATED IN VIRGINIA AND DURING THE WINTER I TAKE THE PICKUP TO THE CARWASH SEVERAL TIME PURPOSELY TO HAVE THE UNDERCARRIAGE WASHED. WHEN MY MECHANIC CHECKED IT OUT HIS RESPONSE WAS "I HAVE NEVER SEEN ANYTHING LIKE THIS. THE BRAKE AND FUEL LINES ARE PAPER THIN FROM RUST. I AM FORTUNATE IN NO ONE WAS HURT WHEN THIS HAPPENED AS I WAS TRAVELING DOWN THE A COUNTRY ROAD ABOUT 45 MILES PER HOUR.

Mileage: 62,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. AFTER A RECENT TRIP, THE CONTACT NOTICED THAT THE BRAKE LINE HAD BLOWN OUT. THE VEHICLE WAS TOWED TO A LOCAL DEALER AND THE BRAKE LINES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000. UPDATED 02/12/16*LJ UPDATED 05/09/18*JB *CN

Mileage: 48,000

RUSTING BRAKE LINES IN HARD TO REACH AREAS OF THE VEHICLE THAT NORMAL WASHING DOESN'T CLEAN. I WAS SLOWING DOWN FOR TRAFFIC GETTING OF THE HIGHWAY WHEN MY BRAKE PEDAL WENT TO THE FLOOR. I USED THE E-BRAKE TO GET HOME AND WHEN I ARRIVED HOME I CRAWLED UNDERNEATH THE TRUCK AND FOUND WHERE THE HARD LINE GOES TO THE FLEX LINE OVER THE REAR END IT HAD SPLIT. I REPAIRED THAT AND NOW RIGHT NEXT TO THE GAS TANK IN SPLIT AGAIN 3 WEEKS LATER PULLING INTO THE DRIVEWAY AT MY HOME.

Mileage: 95,000

THIS MORNING ON THE WAY TO WORK I APPROACHED A T INTERSECTION TRAFFIC LIGHT. THE LIGHT CHANGED FROM GREEN TO YELLOW AS I APPROACHED IT. I PRESSED AND THE BRAKES AND THE PEDAL WENT STRAIGHT TO THE FLOOR, "NO BRAKES". THE TRAFFIC LIGHT TURNED RED AND I HAD TO TRY TO MANEUVER THROUGH THE CORNER AT TO MUCH SPEED, ALMOST ROLLING THE TRUCK. ONCE I SLOWED TO A STOP. I INSPECTED THE TRUCK, AND SURE ENOUGH THERE IS A PUDDLE UNDER THE DRIVERSIDE DOOR WHERE ALL THE RUSTED BRAKE LINES RUN ALONG THE OUTSIDE OF THE FRAME RAIL. THIS IS UNACCEPTABLE FOR GM TO NOT HONOR THEIR VEHICLES OR RESPECT THE BUYERS OF THOSE VEHICLES ENOUGH TO PUT STAINLESS STEEL BRAKE LINES ON THEM. HOW DOES GM EXPECT TO GET PEOPLE TO BUY GM PRODUCTS WHEN WE ARE KILLED IN A TRAFFIC ACCIDENT BECAUSE OF RUSTED,RUPTURED BRAKE LINES. I EXPECT THE LOCAL STEALERSHIP TO QUOTE ME SEVERAL THOUSAND DOLLARS TO FIX THE MANUFACTURERS ERROR. I TELL YOU ONE THING I HAVE PRAISED GM ABOUT MY TRUCK, BUT IF THIS DOESNT GET RECALLED OR FIXED I WONT BUY ANOTHER GM PRODUCT AGAIN.

Mileage: 135,000

WHILE DRIVING, I HIT THE BRAKES AND THE PEDDLE WENT TO THE FLOOR. NARROWLY MISSING 2 CARS IN FRONT OF ME. UPON REVIEW AFTER TOWING HOME, ALL 4 FRONT BRAKE LINES HAVE CONSIDERABLE "FLAKING CORROSION", WITH ONE BLOWN LINE AND ONE LINE SEEPING. I USED THE E-BRAKE TO GET OFF THE ROAD AS IT HAD ABSOLUTELY NO BRAKES WHATSOEVER. REAR BRAKE LINES ARE RUSTED AS WELL. GOT AHOLD OF GM DEALER AND WAS QUOTED $1100 TIME AND MATERIAL TO "FIX". I CHOSE TO FIX MYSELF WITH STAINLESS STEEL LINE. THIS IS THE LAST GM PRODUCT I WILL EVER OWN.

Mileage: 59,150

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING AT 35 MPH, THE BRAKE PEDAL WAS DEPRESSED TO THE FLOOR IN ORDER TO BRING THE VEHICLE TO A COMPLETE STOP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

Mileage: 92,000

IT WAS EARLY IN THE MORNING , MY BROTHER AND I WERE BACKING UP THE TRUCK TO ATTACH THE BOAT FOR TOWING. HE WAS BACKING UP MY TRUCK WHILE I GUIDED HIM BACK TOWARDS THE HITCH OF THE BOAT. WE GOT THE BOAT HITCH ATTACHED TO THE TRUCK AND I ASKED HIM IF HE WANTED TO DRIVE . THANK GOD HE REFUSED TO DRIVE, ONCE I GOT IN THE TRUCK , I APPLIED MY BRAKES BEFORE PUTTING THE TRUCK IN DRIVE AND NOTICED THAT THE BRAKE PEDDLE WENT ALL THE WAY TO THE GROUND WITHOUT ANY RESISTANCE. I LOOKED UNDERNEATH MY TRUCK AND NOTICED BRAKE FLUID LEAKING OUT FROM A RUSTED BRAKE LINE GOING TO THE REAR TIRE . I WOULD HATE TO THINK OF WHAT COULD HAVE HAPPENED ON THE HIGHWAY WITH A BOAT BEHIND ME????? I HAVE PHOTOS OF THE RUSTED BRAKE LINE THAT BROKE . I ALSO HAVE SEEN SOME RUST ON THE REMAINING BRAKE LINES NOW AND AM WORRIED ABOUT THE THE CONDITION OF THOSE LINES.

Mileage: 72,000

BRAKES GOT PROGRESSIVELY "SOFT" ON THE WAY HOME, UNTIL EVENTUALLY THE PEDAL WENT TO THE FLOOR. MADE HOME BY GOING SLOW AND DOWNSHIFTING TO DECELERATE WITHOUT USING THE BRAKES. PROBLEM DIAGNOSED TO BE THE MASTER CYLINDER.

Mileage: 77,430

MY FAMILY AND I WERE DRIVING HOME PULLING OUR TRAVEL TRAILER FROM A WEEKEND OF CAMPING. THERE WAS APPROXIMATELY 2 CAR LENGTHS BETWEEN MY SELF AND THE VEHICLE IN FRONT OF US. BOTH LANES OF VEHICLES CAME TO A QUICK STOP. I APPLIED THE BRAKES THE ABS STARTED TO KICK IN, I LET OF THE BRAKES AND REAPPLIED AGAIN THE ABS KICKED IN AND THE PEDDLE WENT TO THE FLOOR. I WAS ABLE TO HOP THE CURB WITH THE TRUCK AND TRAIL TO AVOID HITTING THE CARS IN FRONT OF ME. IT TOOK 5 OR MORE VEHICLE LENGTHS TO GET COMPLETELY STOPPED. I WAS ABLE TO SLOWLY DRIVE THE 6 OR SO MILES HOME USING THE TRAILER BRAKES ONLY. ONCE THE TRAILER WAS UNHOOKED I WAS ABLE TO PULL THE TRUCK IN TO MY DRIVE WAY TO WORK ON IT. THE BRAKES WOULD HOLD THE TRUCK, THE PEDDLE WAS TO THE FLOOR BUT I'M DOUBTFUL THEY WOULD STOP IT AT ANY SPEED.

Mileage: 145,000

WHEN SLOWING DOWN AND COMING TO A STOP THE ABS BRAKES KICK IN MAKING IT TAKE LONGER THAN NORMAL TO STOP. IT STARTED HAPPENING A COUPLE OF WEEKS AGO PULLING INTO MY DRIVEWAY AND IT IS GETTING WORSE. IT HAPPENS AT SLOW OR AS I AM SLOWING DOWN TO COME TO A STOP, THEN THE ABS KICKS IN AND INCREASES THE STOPPING DISTANCE. THAT NORMAL STOPPING DISTANCE YOU THINK YOU HAVE UNDER NORMAL CONDITIONS IS NOT THERE. THIS PROBLEM IS IN PERFECTLY DRY CONDITIONS. IT IS NOT WEATHER RELATED AT ALL. I HAVE HAD TO STAND ON THE BRAKES TO STOP. IT'S BEEN SOMEWHAT INTERMITTENT BUT IT ALMOST CAUSED ME TO GET INTO AN ACCIDENT TODAY. TURNING WHILE STOPPING USUALLY CAUSES THE ISSUE TO HAPPEN THE MOST, THAT'S WHAT HAPPENED TODAY. COMING TO A STRAIGHT STOP DOESN'T ALWAYS CAUSE THE ISSUE. APPARENTLY THERE WAS THIS SAME ISSUE WITH THE 1999 - 2002 CHEVY TRUCKS AND THEY WERE RECALLED. APPARENTLY CHEVY HAS NOT FIXED THE ISSUE SO WE ARE SEEING IT AGAIN, I WONDER HOW MANY PEOPLE HAVE TO GET INTO ACCIDENTS OR DIE BEFORE SOMETHING IS DONE ABOUT THIS ISSUE. IS THERE A DEATH TOLL WE NEED TO HIT? I'VE GOOGLED THIS ISSUE AND A LOT OF PEOPLE ARE HAVING THIS PROBLEM. I SUSPECT THAT BECAUSE FEW HAVE BEEN KILLED AS THIS IS HAPPENING AT LOWER SPEEDS ONLY INSURANCE ISSUES HAVE ARISEN AND THE CONSUMERS WIND UP PAYING FOR THOSE IN THE END. ONE WOULD HATE TO DIP INTO CHEVY'S YEAR END BONUS MONEY. *TR

Mileage: 105,452

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE BRAKING SYSTEM WAS SLOW TO RESPOND. ALSO, WHILE DRIVING AT LOW SPEEDS, THE ABS WARNING LAMP ILLUMINATED MULTIPLE TIMES. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE ROTORS AND THE BRAKE PADS; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 30 MPH AND APPROACHING A STOP LIGHT, THE BRAKES FAILED AND WENT TO THE FLOORBOARD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT NOTICED THAT THE BRAKE LINES WERE RUSTED TO THE POINT OF CORROSION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. UPDATED 10/26/17*LJ *JS

Mileage: 60,000

I WAS DRIVING DOWN THE STREET AND WENT TO PRESS THE BRAKES AND THE PEDAL WENT TO THE FLOOR. I NEEDED TO DOWNSHIFT AND COAST TO GET THE TRUCK TO STOP. MY TRUCK IS A 2005 CHEVY SILVERADO 1500, EXT CAB, 4X4. TRUCK IS NOW IN SHOP GETTING FIXED. $1000 TO REPAIR SOMETHING THAT SHOULD NOT HAVE FAILED IN THE FIRST PLACE. STAINLESS STEEL LINES ($40 MORE FOR GM) WOULD HAVE PREVENTED THE ISSUE. I AM GLAD I WAS NOT IN A HIGH TRAFFIC AREA WHERE OTHER CARS COULD HAVE BEEN INVOLVED. *TR

Mileage: 118,000

MY WIFE AND I WERE LEAVING HOME TO GO IN TO TOWN TO PICK UP SOME ITEMS WITH THE TRUCK. WHEN APPROACHING THE ROADWAY SHE APPLIED THE FOOT BRAKE, THE BRAKE PEDAL WENT TO THE FLOOR, THERE WAS NO STOPPING. THE EMERGENCY MECHANICAL BRAKE WAS USED SO WE WOULD NOT GET HIT. AFTER GETTING OUT AND SEEING FLUID DRIP, I OPENED THE HOOD TO FIND A CRACKED AND RUSTED BRAKE LINE THAT WAS LEAKING A LARGE AMOUNT OF BRAKE FLUID. RESEARCHING THIS VEHICLE IT SEEMS THIS IS A COMMON PROBLEM WITH THIS VEHICLE, NOTHING HAS BEEN DONE ABOUT IT. THIS TRUCK SPENT MANY YEARS IN WISCONSIN BEFORE WE LOCATED LAST FALL TO WASHINGTON STATE. IT SEEMS TO ME THAT A RECALL NEEDS TO BE DONE FOR THIS FAILURE DOES NOT CONTINUE TO HAPPEN. BRAKE FAILURE IS A VERY SERIOUS ISSUE. *TR

Mileage: 163,000

MY TRUCKS BRAKES CATASTROPHICALLY FAILED FOR THE THIRD TIME TWO WEEKS AGO. LUCKILY THESE FAILURES HAPPENED IN A DRIVEWAY OR LOW SPEED WITH NO ACCIDENT RESULTS. THE LATEST BRAKE FAILURE HAPPENED WITHOUT WARNING, JUST A WEEK AFTER HAULING MY LOADED HORSE TRAILER THROUGH THE MOUNTAINS. WE COULD HAVE BEEN KILLED OR KILLED SOMEONE IF THIS BRAKE FAILURE HAPPENED A WEEK EARLIER. WHILE BACKING UP, ABOUT 6 INCHES FROM HITCHING THE TRAILER, THE BRAKE PEDAL WENT TO THE FLOOR AND BRAKE FLUID POURED OUT. THE SAME THING HAPPENED AUG. 2014. I HAVE SPENT THOUSANDS OF DOLLARS IN THE PAST FIXING ISSUES WITH THE ABS SENSORS, BRAKE LINES, ET AL. THIS TRUCK JUST TURNED 100,000 MILES. THIS SHOULD NOT HAPPEN, EVER! I LIVE IN THE NORTHEAST, LOTS OF SALTED ROADS BUT THESE PARTS MUST BE JUNK. I HAVE NEVER HAD ANOTHER VEHICLE WITH PROBLEMS LIKE THIS. THIS IS A MAJOR SAFETY ISSUE AND GM HAS TO REMEDY THIS PROBLEM ASAP. IT HAS BEEN HAPPENING FOR A LONG TIME AND THEY ARE DRAGGING THEIR FEET IN RECALLING THE '05 AND NEWER TRUCKS. *TR

Mileage: 50,000

BRAKE LINES CORRODED THRU CAUSING ACUTE BRAKE FAILURE. ALMOST CAUSED BAD WRECK. AFTER RESEARCHING THE HUGE NUMBER OF SIMILAR COMPLAINTS AND GMS UNWILLINGNESS TO CORRECT I WILL BE SURE TO NEVER PURCHASE ANOTHER GM VEHICLE EVER. *TR

I JUST GOT HOME AFTER DRIVING 100 MILES ON THE PARKWAY, AND I WAS JUST GETTING READY TO PICK UP MY FIANC KIDS FROM SCHOOL WHEN I STARTED MY TRUCK AND APPLIED THE SERVICE BRAKE TO SHIFT INTO DRIVE AND THEN THE BRAKE PEDAL WENT TO THE FLOOR. I GOT OUT OF THE TRUCK AND SAW BRAKE FLUID LEAKING BEHIND THE DRIVERS SIDE WHEEL. I CRAWLED UNDER TO TAKE A LOOK AND THE LEAK APPEARED TO BE WHERE THE PLASTIC BRACKET WAS HOLDING THE BRAKE LINES TO THE FRAME. THE BRAKE LINES APPEAR TO BE SEVERELY RUSTED AND BRITTLE AND JUST BY TOUCHING THEM THE RUST FLAKES OFF. THANK GOD THIS HAPPENED AT HOME AND NO ONE GOT HURT OR KILLED. I LIVE ON A MOUNTAIN AND THE ROAD DOWN IT IS A 25% INCLINE. SOMETHING NEEDS TO BE DONE ABOUT THIS BEFORE SOMETHING FATAL OR SERIOUS HAPPENS. IF YOU HAVE A BRAKE PROBLEM SIMILAR TO THIS PLEASE FILE A COMPLAINT SO THIS GETS RECALLED. I DON'T UNDERSTAND WHY SO MANY PEOPLE COMPLAINED ABOUT THIS SAME PROBLEM AND NOTHING IS BEING DONE. IS GM THIS POWERFUL AND WILL NOT FESS UP TO THIS EVEN THOUGH THIS COULD BE FATAL?? PLEASE JOIN ME AND SPEAK UP... *TR

Mileage: 155,021

ON 1/8/2015 AT ABOUT 5MPH MY BRAKES FAILED. I TOOK MY TRUCK TO A CAR MECHANIC AND HE REPLACED THE BRAKE LINES .I HAD THE BRAKE PAD AND ROTOR, DRUMS AND SHOES REPLACED. THE COST WAS 1200 DOLLARS. *TR

Mileage: 144,255

WHILE SLOWING DOWN AND LETTING OFF THE GAS WHILE MAKING A TURN THE TRUCK STARTED SPEEDING BACK UP, BRAKING DID STOP THE TRUCK AND NO REVVING OCCURRED. AFTER BREAKING TO A COMPLETE STOP AND LETTING OF THE GAS THE TRUCK WOULD START MOVING FORWARD AS IF THE GAS IS BEING APPLIED-SPEEDING UP GRADUALLY. PUT THE TRUCK IN REVERSE AND SAME THING HAPPENED. TURNED TRUCK OFF AND BACK ON THE PROBLEM DID NOT PERSIST. *TR

THIS COMPLAINT IS TO DOCUMENT BRAKE LINE FAILURES ON 3 SEPARATE OCCASIONS FOR MY 2005 CHEVROLET SILVERADO 1500. WHILE BLEEDING MY BRAKES IN JUNE OF 2011, ONE OF THE REAR BRAKE LINES BURST AND THE PEDAL WENT COMPLETELY TO THE FLOOR. THANKFULLY, THIS HAPPENED IN MY DRIVEWAY AND THE BURST WAS IN A SECTION OF THE LINE ACCESSIBLE FOR ME TO REPLACE. THEN, IN AUGUST OF 2013, MY BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WHILE ATTEMPTING TO STOP SUDDENLY AFTER SOMEONE PULLED OUT IN FRONT OF ME. I WAS TRAVELING 25 TO 30 MPH. WITH SOME MANEUVERING, I WAS ABLE TO AVOID HITTING THE PERSON BUT DRIFTED WELL THROUGH THE INTERSECTION BEFORE COMING TO A SLOW STOP. THANKFULLY NO ONE ELSE WAS THERE. FORTUNATELY, I COULD LITERALLY SEE MY HOUSE (AND MY CHILDREN WHO WERE WAITING FOR ME TO RETURN FROM WORK), AND WAS ABLE TO PULL INTO THE DRIVEWAY AND HAVE MY TRUCK TOWED TO A SERVICE SHOP THE NEXT DAY. THE SHOP REPLACED A SECTION OF THE REAR BRAKE LINES AND FELT THE REMAINDER OF THE LINES WERE STILL SAFE. IT SHOULD BE NOTED THAT THE BREAK WAS IN A DIFFERENT PLACE THAN THE FIRST BRAKE LINE FAILURE. THE THIRD BRAKE LINE FAILURE OCCURRED ON DECEMBER 5TH, 2014 WHEN MY BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WHEN I ATTEMPTED TO COME TO A SUDDEN STOP WHEN ANOTHER DRIVER CAME INTO MY LANE WITHOUT WARNING. AGAIN I WAS TRAVELING 25 TO 30 MPH AND NEARLY RAN HEAD ON INTO ANOTHER DRIVER AFTER MY TRUCK DRIFTED SLOWLY TO A STOP (PROBABLY TOOK 3 TIMES THE DISTANCE IT WOULD HAVE NORMALLY TAKEN TO STOP). AT THE TIME OF THE INCIDENT, MY VEHICLE HAD ROUGHLY 67,100 MILES ON IT. ROUGHLY TWO-THIRDS OF THE TOTAL BRAKE LINE SYSTEM WAS COMPLETELY RUSTED AND NEEDED TO BE REPLACED. SEEING THE OTHER COMPLAINTS FILED FOR CHEVROLET SILVERADO?S AND GMC SIERRA'S, I SINCERELY HOPE THAT SOMETHING IS DONE TO ADDRESS THIS ISSUE BEFORE SOMEONE IS SERIOUSLY HURT OR KILLED BY THESE FAILING BRAKE LINES. *TR

Mileage: 45,396

WHILE COMING TO A STOP, VEHICLE KEEPS GOING. ROLLS ABOUT 5 FEET FARTHER THAN EXPECTED. SEEMS THE BRAKES JUST QUIT BEFORE IT FINALLY STOPS. ABS? *TR

Mileage: 62,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE BRAKE LINES WERE RUSTED AND CORRODED. THE CONTACT REPLACED THE BRAKE LINES, BUT THE FAILURE RECURRED. IN ADDITION, WHILE DRIVING APPROXIMATELY 50 MPH, THE BRAKE LINES FRACTURED. THE VEHICLE WAS TAKEN TO PRIVATE MECHANIC, WHO DIAGNOSED THAT THE DRIVER AND PASSENGER FRONT BRAKE LINES AND THE REAR DRIVER AND PASSENGER BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

Mileage: 112,000

NOTICED A NEED TO TOP OFF BRAKE RESERVOIR DUE TO DASH WARNING LIGHT. BRAKE LINES FAILING DUE TO CORROSION, FORTUNATELY NO ACCIDENT HAS BEEN THE RESULT SO FAR. *TR

Mileage: 58,000

AS I WAS LEAVING MY HOME THERE WAS A COMPLETE LOSS OF BRAKES IN MY DRIVEWAY. AFTER CHECKING I DISCOVERED THAT THE BRAKE LINE HAD BURST DUE TO CORROSION. I HAD A HARD TIME TRYING TO UNDERSTAND HOW THERE COULD BE A COMPLETE LOSS AS ALL VEHICLES NOW HAVE A DUAL LINE MASTER CYLINDER. I THEN REMEMBERED I HAD SEEN A OILY SPILL AND TRAIL UP THE SHARED GRAVEL DRIVE SEVERAL MONTHS AGO. APPARENTLY I HAD LOST HALF THE BRAKE SYSTEM MONTHS AGO. THERE WAS NO WARNING LIGHT OR DIFFERENT FEEL TO THE BRAKES DURING THIS TIME. I MANAGED TO GET THE TRUCK IN THE GARAGE AND WHILE CHECKING WHAT WAS NEEDED FOR REPAIR I DISCOVERED THAT EVERY SINGLE BRAKE LINE ON THE VEHICLE NEEDS TO BE REPLACED. I HAVE ANOTHER CHEVROLET PICKUP THAT I BOUGHT NEW IN 1989 AND THE BRAKE LINES ARE IN BETTER SHAPE THAN THE 2005'S. *TR

Mileage: 132,000

PUT MY FOOT ON BRAKE TO PUT VEHICLE IN GEAR AND PEDAL WENT STRAIGHT TO FLOOR. THE BRAKE LINE BURST. IF I GOT OUT OF THE DRIVEWAY AND HEADED DOWN THE HILL TO THE STOP SIGN AND THE BRAKES FAILED, I WOULD FIND MYSELF IN ONCOMING TRAFFIC DOING 40MPH+ DURING RUSH HOUR. THERE WAS NO WARNING, AND NO BRAKES AT ALL!!! THIS VEHICLE ONLY HAS 51,000 MILES AND IS ALWAYS GARAGED, WASHED AND VERY WELL MAINTAINED. I HAVE NO DOUBT THAT IF THE BRAKES FAILED ON THE ROAD INSTEAD OF IN THE DRIVEWAY, I WOULD HAVE BEEN INVOLVED IN A VERY SERIOUS ACCIDENT. YOU NEED TO DO SOMETHING BEFORE MULTIPLE DEATHS AND/OR INJURIES. AT LEAST A LETTER TO OWNERS TO INSPECT THE BRAKE LINES. *TR

Mileage: 51,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO RESPOND WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE AND SHIFT INTO THE PARK POSITION IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,600.

Mileage: 45,600

BRAKE LINE BROKE IN MY DRIVEWAY AS I WAS PUTTING THE TRUCK IN GEAR. THERE IS NO RUST ON TRUCK EXCEPT BRAKE LINES. *TR

Mileage: 44,300

REAR BRAKE LINE RUPTURED WHILE BRAKING FOR A HIGHWAY EXIT. ALL THE BRAKE FLUID LEAKED OUT WHEN I ATTEMPTED TO PUMP THE BRAKES TO STOP. I WAS ABLE TO USE THE EMERGENCY BRAKE TO COME TO A COMPLETE AND SAFE STOP. WHEN I LOOKED TO FIND THE PROBLEM, I FOUND THE REAR BRAKE LINE DIRECTLY UNDER THE DRIVER DOOR WAS COMPLETELY RUSTED AND BLOWN OUT. *TR

Mileage: 123,456

BRAKE LINES RUPTURED. BRAKE PEDAL WENT TO FLOOR.

Mileage: 56,345

BRAKE LINES RUSTED; BRAKE LINE LEAK; TRUCK WOULD NOT BRAKE/STOP IN DRIVEWAY; HAD TRUCK TOWED TO REPAIR SHOP TO REPLACE BRAKE LINES COMPLETELY RUSTED. *TR

Mileage: 80,800

BRAKE LINES BURSTING DUE TO FAULTY (CHEAP) MATERIAL. I HAVE OWNED SEVERAL CHEVY TRUCKS WITHOUT ANY PROBLEMS BUT THIS IS THE WORST I HAVE EVER SEEN. LOOKS LIKE ALL LINES WILL NEED TO BE REPLACED. THEY ARE MADE FROM CHEAP MATERIAL. *TR

Mileage: 78,000

WHILE DRIVING I LOST ALL BRAKE PRESSURE AND WAS UNABLE TO CONTROL THE SPEED OF MY TRUCK, AT THE SERVICE SHOP I WAS SHOWN THAT THE BRAKE LINES WERE EXTREMELY CORRODED AND HAD FAILED. *TR

Mileage: 163,100

I BOUGHT THE TRUCK NEW IN 2005, IT HAS BEEN A PIECE OF JUNK FROM THE START, I HAVE HAD MULTIPLE PROBLEMS WITH THIS TRUCK, REPLACED BOTH FRONT ROTORS & HUBS, THE DEALERSHIP SAID THIS WAS NORMAL BUT I THINK THAT IT IS JUST NORMAL FOR A JUNKY CHEVROLET, THE MAIN POWER SUPPLY PLUG ON THE HEATER MOTOR MELTED OFF AND WOULD NO LONGER WORK, FRONT SPEAKERS QUITE WORKING, FRONT BRAKE LINES RUSTED AWAY AND THE RESERVOIR WAS DRY AND THE BRAKE LIGHT ON THE DASH NEVER CAME ON FOR A WARNING, HAD TO REPLACE ALL BRAKE LINES ON THE FRONT END OF THE VEHICLE, BRAKES ARE VERY WEAK AND MOST OF THE TIME THE PEDAL IS VERY SOFT AND GOES TO THE FLOOR AND SCARES ME TO DEATH, YOU DON'T THINK THAT THE TRUCK IS GOING TO STOP, THIS BRAKE ISSUE IS A VERY BIG PROBLEM !!!, SEVERAL PEOPLE THAT I KNOW HAVE THE SAME MODEL TRUCK HAVE THE SAVE EXACT ISSUES, I WILL NEVER IN MY LIFE TIME BUY ANOTHER CHEVROLET PRODUCT AS LONG AS I LIVE AND I SPREAD THIS INFO WITH ANYONE WHO MIGHT EVEN THINK OF BUYING A CHEVROLET, DON'T DO IT, THEY ARE JUNK !!!!!!!!!!!! *TR

Mileage: 12,500

ON 7/1/2011, MY 2005 CHEVY SILVERADO LOST BRAKES. THE LOSS OF BRAKES WAS CAUSED BY A LEAK FROM A CORRODED SECTION OF BRAKE LINE. I HAD THAT SECTION OF THE LINE REPLACED AND CONTINUED TO DRIVE. ON 6/12/2012, THE SAME THING HAPPENED TO ANOTHER SECTION OF THE BRAKE LINE. THE CORRODED LINE SPLIT AND BRAKE FLUID WAS GUSHING OUT. LUCKILY, ON BOTH OCCASIONS I WAS ABLE TO STOP MY VEHICLE BEFORE CRASHING INTO SOMEONE OR SOMETHING. WHEN I HAD MY VEHICLE TOWED TO MY MECHANIC, HE SAID THAT THE BRAKE LINES WERE SO CORRODED THAT HE WOULD RECOMMEND REPLACING THE ENTIRE LINE FOR SAFETY. I ALSO HAD AN OPPORTUNITY TO LOOK AT THE LINES AND WAS IN COMPLETE AGREEMENT WITH THE MECHANIC. MY VEHICLE AT THE TIME OF THE FIRST INCIDENT WAS 6 YEARS OLD AND HAD 57,751 MILES ON IT. THE SECOND INCIDENT OCCURRED ABOUT A YEAR LATER AND THE MILEAGE WAS 62,719. *TR

Mileage: 57,751

AFTER I BACKED OUT OF MY DRIVEWAY I STARTED DOWN THE STREET AND WHEN I APPLIED THE BRAKES THE BRAKE PEDAL STARTED TO PULSE AND I HAD TO REALLY PUSH HARD TO GET THE TRUCK TO SLOW DOWN. ABOVE 35 MPH THE BRAKES WORKED FINE. THIS IS THE SECOND TIME THIS VEHICLE HAS BEEN FOR THIS SAME TROUBLE. IT HAPPENED AROUND 20,000 MILES AND THE DEALER TOOK CARE OF THE PROBLEM. THE PROBLEM IS THE ABS SENSOR. IT GETS DIRTY AND EITHER HAS TO BE CLEANED OR REPLACED. THIS CAN BE VERY DANGEROUS AT SLOW SPEEDS, UNDER 35 MPH. I WAS TOLD THERE ARE NO RECALLS. IT WAS REPAIRED AT A CHEVROLET DEALER. *TR

Mileage: 44,537

WHEN I APPLYING THE BRAKES THE PEDDLE WENT TO THE FLOOR. UPON HAVING IT TOWED TO COVER CHEVROLET WINDBER PA. 15963 I WAS INFORMED THAT THE BRAKE LINES WERE ROTTED AND WOULD NEED REPLACED. *TR

Mileage: 75,000

I BOUGHT A 2005 SILVERADO FROM MY MOTHER, AND SHE BOUGHT THE TRUCK OFF OF A USED DEALER LOT PURCHASING FOR 12,500 FOUR YEARS AGO. SINCE THEN THE TRUCK HAS HAD AN AIR BAG SENSOR REPLACED AND IT ONCE AGAIN SHOWING THE AIR BAG NEEDS SERVICED, WHICH CAN BE VERY DANGEROUS TO TRUCK OWNERS IN SITUATIONS OF A CRASH. WAS TOLD THEY GO OUT COMMONLY. THE TRUCK HAS ALSO HAD AN ABS ISSUE SINCE IT WAS PURCHASED ON THE LOT, WE SENT IT BACK TO BE FIXED, AND THE ISSUE WAS NEVER SOLVED, IT HAS BEEN LOOKED AT BY THREE TECHNICIANS. THIS IS ALSO A PUBLIC SAFETY HAZARD IF THE ABS CAUSES THE BRAKES TO FAIL. THE TRUCK ALSO HAS NUMEROUS ELECTRICAL ISSUES, SUCH AS THE GEAR SELECTOR DOES NOT ILLUMINATE, IN WHICH CASE SOMEONE MAY NOT BE ABLE TO DETERMINE WHAT GEAR THEY ARE IN AND CAUSE AN INCIDENT, THE HEADLIGHT, TAIL LIGHT, BRAKE LIGHT, AND MARKER LIGHTS ARE ALWAYS BLOWING BULBS, THE DASH CLUSTER DOESN'T ALWAYS WANT TO ILLUMINATE EITHER, THIS COULD CAUSE A CRASH ESPECIALLY AT DARK WHEN YOU CANNOT SEE THE RPM, SPEEDO, OIL PRESS, TEMP, OR ANY OTHER GAGE PRESENT. *TR

Mileage: 176,000

HAD JUST MADE A LEFT TURN ONTO MY STREET, APPROXIMATE SPEED ABOUT 5 MPH. AFTER THE LEFT TURN WAS MADE, I PROCEEDED ABOUT 200 FEET TO MY DRIVEWAY. UPON PULLING IN, I ATTEMPTED TO STOP AND THE PEDAL WENT TO THE FLOOR. THE BRAKES WERE NOT HIT ABRUPTLY HOWEVER THERE WAS SNOW ON THE GROUND. MOVING AT 10 MPH WHEN COMING TO A STOP, THE TRUCK DID NOT SLIDE BUT EVENTUALLY STOPPED, WITHOUT INCIDENT. AFTER PARKING THE TRUCK, 20 MINUTES LATER I DECIDED TO SEE IF IT WAS STILL THE SAME OR IF THIS WAS JUST A "FLUKE" (NO THE ABS LIGHT DID NOT COME ON WHEN PARKING). SO AS I OPENED THE DRIVERS SIDE DOOR, I LOOKED DOWN AND NOTICED THE SNOW WAS A GOLDEN/BLUISH COLOR. I LOOKED UNDERNEATH THE TRUCK AND SAW BRAKE FLUID DRIPPING SLOWLY ONTO THE GROUND. THE LEAK IS COMING FROM UNDER THE DRIVERS SIDE DOOR, NEAR WHERE THE GROUP OF BRAKE LINES IS LOCATED. I CHECKED OUT POSSIBLE FIXES ONLINE AND NOTICED I AM NOT THE ONLY ONE WITH THIS COMPLAINT. IT WAS SUGGESTED I FILE THIS COMPLAINT, WHICH I AM GLAD I DID SO. THIS NEEDS TO BE ADDRESSED BEFORE SOMEONE IS NOT AS LUCKY AS I WAS (PULLING INTO MY DRIVEWAY AT A SLOW SPEED). THANK YOU. *TR

Mileage: 107,021

BRAKE LINES FAILED DUE TO CORROSION. *TR

Mileage: 156,700

HIT THE BRAKES, LINE BUSTED....NO BRAKES. LUCKILY NOBODY WAS HURT. VERY DANGEROUS SITUATION. *TR

Mileage: 194,500

INSTRUMENT CLUSTER PANEL (SHIFT INDICATOR) STOPPED ILLUMINATING. ALL OTHER ITEMS WORK IN CLUSTER. ITS SO DIM YOU CANT TELL WHICH GEAR YOUR IN. (THERE IS A RECALL BUT WE WERE TOLD WE WERE NOT COVERED). THE ENTIRE CLUSTER MUST BE REPLACED. AND YOU CAN ONLY GET THE PART AT THE DEALER BECAUSE THEY NEED TO THE VIN AND MILEAGE ON THE VEHICLE. 2. ONE OF THE MAIN BRAKE LINES BURST..YESTERDAY 10-16-2013 WHILE MY WIFE WAS DRIVING WITH MY SON. I AM TOLD ALL THE LINES MUST BE REPLACED BECAUSE THEY ARE ALL CORRODED. *TR

Mileage: 100,000

I WENT TO MOVE THIS TRUCK IN MY DRIVEWAY, WHEN I PUT IT IN REVERSE, THE BRAKE PEDAL WENT TO THE FLOOR, NEARLY HITTING MY CAR WHICH WAS BEHIND ME. I GOT OUT AND OPENED THE HOOD AND NOTICED THAT THE BRAKE FLUID RESERVOIR WAS VERY LOW, AND THAT BRAKE FLUID HAD SQUIRTED ALL OVER THE FRONT OF THE ENGINE AND WAS ALSO LEAKING FROM A SECOND PLACE JUST UNDER THE MASTER CYLINDER ALONG THE FRAME. THE BRAKE LINES WERE WET AND ARE VERY RUSTY, TO THE POINT OF SCALING. NOW, I CAN'T USE MY TRUCK, WHICH I VERY MUCH NEEDED ON 09/14/2013. THIS IS VERY DISGUSTING!

Mileage: 200,321

WHILE SLOWING DOWN AT A STOP LIGHT I PRESSED THE BRAKE PEDAL ONLY TO HAVE IT FALL ALL THE WAY TO THE FLOOR. I WAS CRUISING TO A STOP LIGHT WITH CROSSING TRAFFIC AND WAS COMPLETELY TERRIFIED AT THE LOSS OF BRAKING POWER. I HAD THE IDEA TO PUT THE TRUCK INTO NEUTRAL AND JAM THE EMERGENCY BRAKE WHILE HONKING MY HORN. THE TRUCK SLOWLY CAME TO A STOP WELL WITHIN THE INTERSECTION NARROWLY MISSING TRAFFIC. I LOOKED UNDER THE TRUCK AND FOUND BRAKE FLUID LEAKING FROM THE REAR NEAR THE AXLE. A MECHANIC HAS CONFIRMED THIS WAS A BURST BRAKE LINE DUE TO RUST AND THAT HE SEE THIS BRAKE LINE FAIL AT THE SAME SPOT ON CHEVROLET/GMC TRUCKS FREQUENTLY. THIS VEHICLE HAS FREQUENT CAR WASHES WITH UNDERCARRIAGE RINSING YEAR ROUND. *TR

Mileage: 84,000

SLOWING DOWN FOR A STOP SIGN AND PEDAL WENT TO THE FLOOR AND WENT THROUGH THE INTERSECTION COULD NOT STOP. THE LEFT REAR BRAKE LINE WENT. *TR

Mileage: 92,000

THE REAR BRAKE LINE BURST WHILE DRIVING IN A PARKING LOT RESULTING IN A LOSS OF BRAKING. THE MECHANIC SHOWED ME WHERE IT BROKE AND IT APPEARED TO BE DUE TO CORROSION OF THE LINE. IT ALSO LOOKED LIKE THE FUEL LINE WAS SHOWING SIMILAR CORROSION. *TR

Mileage: 74,151

I STEPPED ON THE BRAKES AND THE PEDAL WENT TO THE FLOOR. I STEPPED ON THE MECHANICAL PARKING BRAKE TO STOP. BRAKE FLUID WAS ON THE GROUND.. I PULLED ALL THE WHEELS AND NO BRAKE CYLINDERS OR CALIPERS WERE LEAKING BUT AFTER TRACING THE OIL IT WAS FROM A BUNDLED OF BRAKE LINES UNDER THE DOOR. *TR

Mileage: 70,100

TRUCK HAS AN EXHAUST LEAK AT MANIFOLDS. 4 BOLTS HAVE BROKEN OFF OF THE MANIFOLD. MY MECHANIC SAID THIS IS VERY COMMON WITH THIS TRUCK AND COULD COST UP TO AND OVER $1,000.00 TO FIX. CHECK ENGINE LIGHT IS ON SO UNLESS I FIX IT I CAN'T GO TO STATE INSPECTION. ALSO THE BRAKE LINES ARE CORRODED AND ALSO NEED TO BE REPLACED. THESE ARE ALL DEFECTS NOT MAINTENANCE ISSUES. HTTP://WWW.YOUTUBE.COM/WATCH?V=0YG6WLBNZGI IT EXPLAINS THE PROBLEM BETTER. *TR

Mileage: 128,741

THE BRAKES FAILED ON MY TRUCK AND I HIT A PARKED DUMP TRAILER. UPON INSPECTION I FOUND THAT THE BRAKE LINES HAD SEVERLY RUSTED AND FAILED. I WAS UNABLE TO STOP SAFELY AND UNABLE TO PUMP THEM UP. THE BRAKE LINE FAILURE OCCURED UNDER THE DRIVERS DOOR. *TR

Mileage: 110,124

ALL 5 BRAKE LINES ARE BADLY CORRODED, 2 WERE LEAKING. FILLED THE RESERVOIR, AND DROVE IT TO LOCAL SHOP FOR REPAIR, {ABOUT 2 MILES}, USING WHAT LITTLE BRAKE I HAD, {PEDAL ON THE FLOOR}, AND EMERGENCY BRAKES. COULD HAVE BEEN VERY SERIOUS AND WAS VERY EXPENSIVE TO GET FIXED. TALKED TO LOCAL CHEVY DEALER WHO TOLD ME THEY REPLACE BRAKE LINES ON CUSTOMERS CARS AND TRUCKS ALMOST EVERY DAY. GM WILL NOT DO RECALL BECAUSE PROBLEM IS LOCALIZED TO THE "SALT AREA" OF NORTH EASTERN UNITED STATES. BUT GM DOES STATE THAT VEHICLE SHOULD STOP WITHOUT FLUID. THAT IS NOT TRUE! *TR

Mileage: 75,600

LUCKILY MY WIFE WAS IN HER PARKING LOT AT WORK. SHE APPLIED THE BRAKES AND THE PEDAL HEADED FOR THE FLOOR. THE LINE TO THE REAR BRAKES RUSTED THROUGH MID POINT BETWEEN THE FRONT AND BACK. THIS IS AN 8 YEAR OLD, WELL MAINTAINED TRUCK! INFERIOR MATERIAL FAILURE? *TR

Mileage: 95,000

RUSTED BRAKE LINE LET GO AND HAD TO USE EMERGENCY BRAKE TO STOP TO STOP. PEDAL WENT COMPLETLY TO FLOOR ,TRIED TO PUMP NO BRAKES. REPLACED ALL BRAKE LINES. *TR

Mileage: 65,000

WHEN COMING TO A STOP AND SUDDENLY WITHOUT WARNING, MY BRAKES BEGAN PULSATING RAPIDLY, EVENTUALLY STOPPING ABOUT 10 FEET BEYOND WHERE I INTENDED TO STOP. FORTUNATELY THERE WERE NO VEHICLES IN FRONT OF ME AN NONE COMING THROUGH THE INTERSECTION. SHORTLY AFTERWARDS, I HAD THE VEHICLES BRAKE SYSTEM EVALUATED ONLY TO FIND OUT THE ROOT CAUSE IS THE ANTI-LOCK BRAKE SENSORS ACTIVATING DUE TO CORROSION AND RUSTING. I WAS INFORMED THAT THIS ISSUE HAS BEEN TYPICAL WITH THESE MODELS OF VEHICLES FOR MANY YEARS. IN READING ONLINE POSTS, I SEEN THIS IS A COMMON AND KNOWN ISSUE, BUT THE DEALER DOES NOT RECOGNIZE IT, THEREFORE A RECALL SHOULD BE ISSUED BECAUSE THIS IS A SERIOUS SAFETY CONCERN WHICH COULD HAVE RESULTED IN BODILY INJURY OR DEATH! *TR

Mileage: 61,000

WHILE AT A STOP WITH FOOT ON BRAKES, THE PEDAL SUDDENLY DEPRESSED ALL THE WAY TO THE FLOOR. A CHECK REVEALED THAT THE RIGID BRAKE LINE FROM THE EHCU TO THE DRIVERS SIDE FRONT WHEEL HAD FAILED DUE TO CORROSION. *TR

Mileage: 111,200

THE BRAKE LINES ,FUEL LINES AND THE FRAME CROSSMEMBERS ARE ALL SEVERELY RUSTED. IT JUST IS A MATTER OF TIME BEFORE I LOOSE MY BRAKES, GO UP IN FLAMES OR DROP MY GAS TANK ONTO THE HIGHWAY. THE BODY ON THIS TRUCK IS NOT TOO BAD. IT HAS 92,000 MILES ON IT, AND IT IS CLEANED QUITE OFTEN. THE UNDERCARRIAGE IS RUSTED VERY BADLY. I EXPECTED MORE FROM SOMETHING THAT COSTS SO MUCH. CANT AFFORD A NEW ONE AND IF I COULD IT WOULDN'T BE A GM. HAVE ALWAYS OWNED GM IN THE PAST. *TR

Mileage: 92,000

SEVERELY RUSTED BRAKE LINES THROUGHOUT. LINE RUPTURED WHILE VEHICLE WAS TRAVELING AT APPROXIMATELY 30 MPH ON A RESIDENTIAL STREET. NO INJURIES OR DAMAGE BUT FOR A VEHICLE OF THIS AGE TO LOOK LIKE IT DOES UNDERNEATH IS DESPICABLE. I'VE LIVED IN NEW ENGLAND ALL OF MY LIFE AND HAVE OWNED AND WORKED ON SEVERAL OLDER VEHICLES THAN MY CURRENT TRUCK AND HAVE NEVER SEEN CORROSION THIS BAD UNDERNEATH. REPLACING ALL LINES WITH STAINLESS STEEL IMMEDIATELY. HOW THIS DIDN'T HAPPEN SOONER IS DIFFICULT TO BELIEVE. *TR

Mileage: 68,000

BRAKE LINES RUSTED AND BURST FRONT AND REAR, PRESSED THE PEDAL TO SHIFT FROM PARK TO DRIVE PEDAL WENT ALL THE WAY TO FLOOR, LUCKILY WAS SETTING IN PARKING LOT. *TR

Mileage: 31,440

I WAS DRIVING WHEN THE BRAKE PEDAL WENT SOFT. I CONTINUED AND THE SERVICE BRAKES WARNING LIGHT CAME ON. AS I WAS LESS THAN 1 MILE FROM HOME I CONTINUED CAREFULLY. WHEN I GOT HOME I FOUND THE BRAKE RESERVOIR ALMOST EMPTY. I DISCOVERED THE BRAKE HARD LINE TO THE REAR BRAKES WAS CORRODED. THIS IS THE LINE THAT RUNS ABOVE THE GAS TANK. IT WAS CORRODED THERE AND LEAKING FLUID. LUCKY I WASN'T KILLED OR STRANDED FAR FROM HOME ! *JS

Mileage: 18,000