2003 CHEVROLET SILVERADO 2500 Electrical System Problems

BEEN HAVING PROBLEMS SLOWLY WITH THE BATTERY RUNNING OUT BECAUSE SOMETHING IS STILL RUNNING IN THE VEHICLE BUT EVERYTHING IS OFF. THE GAS GAUGE GEAR CONTROL LIGHTING ON THE PANEL DOOR ON THE PASSENGER SIDE WILL NOT LOCK SPEEDOMETER IS NOT WORKING GAS GAUGE IS NOT WORKING WAS CHECKED BY A MECHANIC AND HE ADDRESS THAT SOMETHING IS NOT CONSTANT RUNNING EVEN THOUGH EVERYTHING IS TURNED OFF THAT CAUSE THE BATTERY TO RUN DOWN WHEN IT IS OFF. ALSO THE LIGHTS DON'T LIGHT ON THE RIGHT SIDE STAYS ON AND NEVER GOES OFF WHEN RUNNING THE VEHICLE. I NOTICED THIS ON A LOT OF 2500 CHEVY TRUCKS. WE HAVE TAKEN THIS VEHICLE IN TO BE CHECK. PLEASE HELP US TO RESOLVE THIS PROBLEM AS SOON AS POSSIBLE. THANK YOU FOR YOUR TIME. LOOKING FORWARD TO HEARING BACK FROM YOU SUN.

TAILGATES CABLES NEEDS TO BE REPLACE IT....

INSTRUMENT CLUSTER PANEL OF ALL GAUGES INCLUDING SPEEDOMETER AND GEAR SELECTION ' GAUGES CAN QUIT WORKING WITH NO WARNING , LEAVING THE DRIVER UNAWARE OF SPEED OR DISTANCE TRAVELED. ALSO NOT KNOWING WHAT POSITION THE GEAR SELECTOR IS IN . ( PARK, NEUTRAL , DRIVE ETC. ) COULD ALLOW THE VEHICLE TO DRIFT AWAY ON IT OWN WITH NO ONE BEHIND THE WHEEL WHEN NOT BEING DRIVEN . CAN HAPPEN AT ANY MOMENT , ANY PLACE !

Mileage: 72,000

THE ISSUE I'M REPORTING TOOK PLACE IN MY 2003 CHEVY SILVERADO 2500HD VIN: [XXX] BUT THE VEHICLE ITSELF WAS NOT AT FAULT. THE PROBLEM WAS FROM A EVERSTART MAXX BATTERY SERIAL# JCH1600480782 MANUFACTURED BY JOHNSON CONTROLS INC, SOLD BY WALMART. I NOTICED A PROBLEM ON 7/25/2017 AFTER DRIVING MY VEHICLE ON THE HIGHWAY WHEN NEEDING TO USE THE WINDSHIELD WASHER TO CLEAN INSECTS OFF TO IMPROVE VISIBILITY. WHEN I USED THE CONTROL TO ACTIVATE THE WINDSHIELD WASHER NOTHING HAPPENED. AFTER ARRIVING HOME I ATTEMPTED TO FILL THE WASHER FLUID BUT IT WAS ALREADY HALF FULL. I LOOKED UNDERNEATH THE TRUCK AND NOTICED LEAKING WASHER FLUID. I THOUGHT MAYBE THERE WAS A LEAK SOMEWHERE SO I INVESTIGATED IT. TO GET TO THE WASHER BOTTLE THE BATTERY MUST BE REMOVED AND WHEN REMOVED IT WAS EVIDENT THAT THE BATTERY WAS LEAKING ACID EVERYWHERE. SOME ACID DID GET ON MY CLOTHING AND ATE THROUGH IT BUT THANKFULLY NONE MADE CONTACT WITH MY SKIN. THE BATTERY SITS ABOVE THE WASHER BOTTLE, PUMP, LINES, AND BATTERY TRAY - ALL OF THESE COMPONENTS WERE DESTROYED BY LEAKING ACID. I HAVE BEEN IN CONTACT WITH JOHNSON CONTROLS INC, THE MAKER OF THE BATTERY AND THEY SEEM DISINTERESTED IN WHAT HAPPENED. I HAVE SAVED ALL DAMAGED PARTS, RECEIPTS, AND CORRESPONDENCE SO FAR. IN THE FOLLOWING PICTURES YOU WILL SEE THE WHITE CORROSION FROM THE ACID LEAK AND THE PARTS THAT WERE DESTROYED LEAVING THE WINDSHIELD WASHER INOPERABLE WHILE DRIVING AND REDUCING VISIBILITY. I'LL ALSO INCLUDE A PICTURE OF THE SHIRT THAT CAME INTO CONTACT WITH ACID WHEN LIFTING THE BATTERY OUT AND THE HOLES IT ATE THROUGH THE FABRIC. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 334,000

GAUGE CLUSTER MALFUNCTION REDUCED ENGINE POWER

THE SPEEDOMETER AND TACHOMETER WERE ACTING ERRATICALLY, SPEEDOMETER WOULD READ 110 MPH AT NORMAL HIGHWAY SPEED, THE TACHOMETER WOULD READ 0- 1000 RPM AT NORMAL HIGHWAY SPEEDS, HAD TO SEND CLUSTER FOR REPAIR. MAIN GROUNDING STRAP WAS BROKEN DUE TO EXCESSIVE CORROSION AND REPLACED AFTER BEING TOWED TO DEALER. AIR BAG SERVICE LIGHT IS ON INTERMITTENTLY WHILE DRIVING, PROBLEM TO BE RESOLVED.

Mileage: 95,000

TRAVELING ON HIGHWAY WHEN SMOKE STARTED COMING FROM THE DASHBOARD. PULLED OVER AND WITHIN SEVERAL MINUTES THE WHOLE TRUCK WAS ON FIRE.

Mileage: 107,000

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE BLOWER MOTOR MALFUNCTIONED AND WOULD NOT OPERATE USING THE FIRST THREE SETTINGS. THE BLOWER WOULD ONLY OPERATE IN THE NUMBER FOUR AND FIVE SETTINGS DUE TO AN ELECTRICAL SHORTAGE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 65,500.

Mileage: 65,500

AT ABOUT 80,000 MILES BRAKE FAILURE DUE TO RUSTED THROUGH BRAKE LINES.A LEAKING FUEL LINE WAS REPLACED DUE TO RUST. GROUNDING CABLE TO THE ENGINE BLOCK NEEDED TO BE REPLACED DUE TO EXCESSIVE CORROSION. EXHAUST SYSTEM FROM ENGINE BLOCK TO TAIL PIPE HAS BEEN REPLACED, INCLUDING BOTH MANIFOLDS, DUE TO RUST. THE FRONT AND REAR BUMPERS ARE RUSTING THROUGH. NONE OF THESE DEFECTS HAVE RESULTED IN ANY ACCIDENTS.

Mileage: 80,000

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. WHILE DRIVING 40 MPH, THE REDUCED ENGINE POWER LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED IN THE MIDDLE OF THE HIGHWAY, BUT THE CONTACT WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED, BUT NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 195,000.

Mileage: 195,000

WHEN I TURN THE LEFT TURN SIGNAL ON, IT SOMETIMES WORKS AND SOMETIMES IT DOESN'T. SOMETIMES IT TURNS BOTH TURN SIGNALS ON LIKE THE HAZARDS. IF I HAVE MY CRUISE SET AND USE THE LEFT TURN SIGNAL, IT SHUTS THE CRUISE OFF. TR

Mileage: 103,000

IGNITION SWITCH LOCKS UP OCCASIONALLY AND MAKES THE ABS SERVICE BRAKE LIGHT COME ON. *TR

Mileage: 62,000

I WAS TRAVELING ON THE INTERSTATE WITH MY FAMILY ABOARD AT THE SPEED AROUND 75+ MPH AND SUDDENLY THE VEHICLE LOOSES SPEED WHILE TRAVELING AMONG OTHERS AT AROUND THE SAME SPEED OR HIGHER WHEN SUDDENLY THE SPEED DECREASES TO NO SPEED, AND A THIS WARNING COMES ACROSS THE DASH PANEL, THAT SAYS REDUCED SPEED AND ALL THESE 18 WHEELERS ARE BEHIND ME AND AROUND ME. THE MORE I PRESS THE ACCELERATOR IT WOULD DO NOTHING BUT ALMOST COST MY WIFE A HEART ATTACK FROM THE BIG TRUCKS BLOWING THERE HORN AND FEARING THE DAY LIGHTS OUT OF MY FAMILY. THEN A WEEK LATER THE CLUSTER STARTS ACTING ALL CRAZY WITH THE LIGHTS GOING OUT AND ON, AND NOW THEY AREN'T WORKING AT ALL. THE GAUGES STOPPED WORKING THE SPEED ALONG WITH GAS GAUGES ETC... WHILE I HAVE NEVER OWNED ANYTHING OTHER THAN "CHEVY'S", TRUCKS AND CARS I HAVE SERIOUSLY BEEN CONSIDERING ANOTHER NAME & MAKE IN MY NEXT CHOICE OF PURCHASE.... SO A LOYAL FRIEND ADVISED ME TO SEND GM A E-MAIL EXPLAINING MY ISSUES... *TR

Mileage: 133,000

AT FREEWAY SPEEDS I NOTICED THE OIL PRESSURE HAD DROPPED TO ALMOST 2 OUT OF 10 ON THE PRESSURE GAUGE. I STOPPED AS SOON AS POSSIBLE AND LET THE ENGINE COOL FOR 20 MINUTES. I CHECKED THE OIL LEVEL AND COLOR. IT WAS OK IN BOTH RESPECTS. AFTER ANOTHER 30 MINUTES I RESTARTED THE ENGINE AND CONTINUED HOME. I WATCHED THE PRESSURE GAGE FOR ANOTHER HOUR AND SAW THE PRESSURE READING CONTINUE TO FALL TO A DANGEROUS LEVEL BUT THERE WAS NOTHING I COULD DO. THE NEXT DAY I TOOK THE TRUCK TO THE CHEVY DEALER IN EL CENTRO, CA 92243 FOR THEIR ANALYSIS. THEY SAID IT WAS ONLY POOR OIL AND NEEDED CHANGING. I LET THEM SERVICE THE TRUCK AS THEY WISHED. THEY ALSO SCANNED (SWEPT) THE GAUGES AND CHANGED THE OIL AND SENT ME ON MY WAY. THE NEXT DAY IT DID THE SAME THING. I DID NOT RETURN TO THE DEALER AS I WAS NOT PREPARED FOR AN ARGUMENT. *TR

Mileage: 86,800

INSTRUMENT CLUSTER JUST QUIT WORKING ALTOGETHER. THIS WILL BE THE THIRD TIME THE CLUSTER WILL HAVE BEEN REPLACED. THE FIRST TWO WERE ON GM; THIS ONE IS GOING TO BE ON ME. WHAT IN THE WORLD IS WRONG WITH GM OR THE MANUFACTURER OF THIS PART. WHY DO THEY KEEP PRODUCING CRAP? UNTIL THE CLUSTER IS REPLACED, I HAVE NO IDEA OF ENGINE FUNCTIONS AND IF IT WEREN'T FOR MY GPS, I'D HAVE NO IDEA OF MY SPEED. *TR

Mileage: 145,000

WHEN DRIVING THE TRUCK WHETHER ON A REGULAR STREET OR AT HIGH SPEEDS ON THE HIGHWAY, THE ENGINE SUDDENLY EITHER DIES, REDUCES DOWN TO IDLE SPEED OR IDLES VERY ROUGHLY. THE REDUCED POWER SIGNAL COMES ON, ALONG WITH THE ENGINE LIGHT. THIS HAS HAPPENED TO US, SEVERAL TIMES WHILE DRIVING ON THE HIGHWAY AND ON REGULAR STREETS. WE WERE EXTREMELY LUCKY NOT TO HAVE BEEN KILLED. I RESEARCHED THIS AND FOUND THAT MANY OWNERS OF THE 2003 CHEVY SILVERADO 2500HD HAD THE SAME PROBLEM. WE SPENT A LOT OF MONEY AT PENSKE CHEVROLET, AND ACCORDING TO THEM, THEY DON'T KNOW HOW TO FIX IT. WE BOUGHT THE TRUCK IN 8/2013, WITHOUT ANY WARRANTY AND THIS PROBLEM WAS NOT DISCLOSED TO US. SINCE 12/2013, THE PROBLEM HAS BECOME MORE FREQUENT AND NOW WE DON'T DRIVE THE VEHICLE BECAUSE IT IS JUST TOO DANGEROUS. THERE HAS TO BE SOME WAY TO FIX THIS PROBLEM AND THE CHEVROLET COMPANY HAS TO KNOW ABOUT THIS BECAUSE THERE ARE SO MANY COMPLAINTS OUT THERE. *TR

Mileage: 131,000

WHILE RETURNING HOME FROM A 2 WEEK VACATION (30 MILES FROM HOME) SLOWED DOWN TO MAKE A RIGHT TURN ON A CITY STREET IN WOODLAND, CA, THE TRUCK JUST SHUT DOWN, NO STEERING, NO BRAKES, NO ENGINE, TOTAL ELECTRICAL SHUTDOWN. IT WAS EVERYTHING I COULD DO TO MAKE THE TURN AND PULL TO THE RIGHT. AT THE TIME I WAS PULLING MY 2009 BIGHORN FIFTH WHEEL TRAILER. IT WAS A SCARY TIME. I FINALLY STOPPED, LUCKY THERE WAS NO CARS PARKED ON THE RIGHT NEAR THE CURB. I PUT THE TRANSMISSION IN NEUTRAL AND RESTARTED THE ENGINE. THEN WE CONTINUED THE TRIP HOME TO WINTERS, CA. I TOOK THE TRUCK TO IMLER DIESEL IN SACRAMENTO TO CHECK THE ENGINE OUT. THEY REPLACED THE INJECTORS WHICH WE HAD AGREED TO DO PRIOR TO MAKING THE TWO WEEK TRIP. THE NEXT TRIP WAS TO BODEGA BAY ON JANUARY 14, 2014. WE TRAVELED ABOUT 100 MILES. AGAIN WE WERE PULLING OUR FIFTH WHEEL TRAILER. SLOWING DOWN FROM 55 MPH TO 15 MPH, PREPARING TO MAKE A LEFT TURN IN DORAN BEACH PARK AT BODEGA BAY, THE TRUCK SHUT DOWN AGAIN.I CAME SO CLOSE TO HITTING A TREE. ONCOMING TRAFFIC STOPPED JUST IN TIME AS THE SPEED LIMIT AT 55 MPH SEEMED TO SEE WHAT WAS HAPPENING GIVING ME TIME TO RESTART AND MOVE OFF THE HIGHWAY. MY WIFE AND I WERE BOTH SHAKEN UP A BIT, BUT ALSO FEELING VERY LUCKY NOT HAVING A CRASH. WE CONTINUED HOME 4 DAYS LATER. WE PARKED THE TRUCK.THE MILEAGE WAS 143579 AT THE START OF THE TRIP AND 143819 AT END. I HAVE NOT USED THE TRUCK SINCE. I DO NOT FEEL IT IS SAFE TO DRIVE. I WAS LUCKY TWICE, DON'T KNOW IF I WANT TO RISK A THIRD TRY. LOOKING BACK, THE SHUTDOWN DID HAPPEN TWO OTHER TIMES BUT I WAS NOT PULLING THE FIFTH WHEEL TRAILER, I CAN'T REMEMBER THE DATES. CHEVROLET LT 2500 HD 4X4 DIESEL 2003 TRUCK. *TR

Mileage: 143,416

A FRIEND WAS DRIVING MY TRUCK IN A RESIDENTIAL NEIGHBORHOOD. HE WAS ONLY GOING 20 MPH WHEN THE GAS LIGHT CAME ON BUT THE NEEDLE SAID IT HAD HALF A TANK. ALL OF A SUDDEN THE RADIO LOCKED UP AND ALL THE NEEDLES ON THE DASH STARTED GOING CRAZY ALL THE EMBLEMS ON THE DASH LITE UP. WE PARKED AND TURNED OFF THE TRUCK. AS SOON AS WE WENT TO TURN BACK WE HAD JUST STARTED IT NOT EVEN 3 MINUTES LATER ALL OF THE GAUGES AND LIGHTS ON THE TRUCK IT STARTED FREAKING OUT AGAIN AND NOW THE DRIVER SIDE MIRROR AND WINDOW CONTROL WOULD NO LONGER WORK. EARLIER THAT DAY I HAD TAKEN IT IN A REPUTABLE SHOP TO GET THE TRUCK SMOGGED AND GET IT CHECKED OUT. THE TRUCK PASSED SMOG AND THEY SAID THE TRUCK HAD NO PROBLEMS. THIS WAS THE FIRST TIME IT HAD EVER DONE ANYTHING LIKE THIS. *TR

Mileage: 149,200

STARTED THE TRUCK AND PUT INTO REVERSE. THERE WAS NO BRAKE AND NO STEERING CONTROL. I HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. ALL FLUIDS WERE TOPPED OFF AS NORMAL AND I REGULARLY MAINTAIN THIS VEHICLE. AFTER REVIEWING THIS ISSUE IN THE DIESEL FORUM NUMEROUS DURAMAX OWNERS HAVE ENDURED THE SAME PROBLEM WITH SOME ENDING IN CRASHES. THIS IS A MAJOR SAFETY ISSUE!!!!!!!!!!!! SIMULTANEOUS BRAKE AND STEERING FAILURE. ARE YOU KIDDING ME? WOW! I TRIED CHATTING WITH GM AND WAS DUMPED DURING THE CHAT. NO HELP THERE! I'LL TRY AGAIN! *TR

Mileage: 94,000

DRIVING DOWN HIGHWAY GAUGES FLUCTUATED,STOPPED WORKING AS WELL AS SPEEDOMETER. CALLED GM THEY SAID IT IS OUT OF WARRANTY,COST APROX 600.00 TO REPAIR. *TR

Mileage: 68,420

MY SPEEDOMETER NEVER GOES BELOW 20MPH EVEN SETTING STILL AND WHEN I'M MOVING IT READS 90 PLUS EVEN IF I'M GOING 40 MPH. WHEN THE TRUCK IS TURNED OFF IT STILL READS 20 MPH. *TR

Mileage: 130,000

SPEEDOMETER RANDOMLY INCREASES, DECREASE OR WILL NOT WORK AT ALL. OIL GAUGE FLUCTUATES ALSO THE HEATER RESISTORS BURNED UP. *TR

Mileage: 70,000

I BOUGHT THE TRUCK IN NOVEMBER IN 2007, I HAD THE TRUCK APPROXIMATELY A MONTH AND THE SPEEDOMETER STARTED BOUNCING AROUND AND IN ABOUT A WEEK LATER IT STUCK AT 117 MPH AND HAS NOT MOVED SINCE. THEN AT ABOUT 110,000 MILES THE ENTIRE INSTRUMENT PANEL WOULD GO OUT, ALL THE GAUGES AND THE ODOMETER, THE SIGNAL LIGHTS AND THE BACK LIGHTING STILL WORKS, BUT NOTHING ELSE THE FUEL GAUGE, OIL GAUGE, TRANSMISSION TEMP GAUGE, TACHOMETER NONE OF THESE WILL WORK NOW. I WOULD JUST LIKE TO KNOW HOW IT IS THAT THIS IS A HUGE OVER ALL PROBLEM OF THE VEHICLES IN THE CERTAIN YEAR, AND MODEL. BUT THE VEHICLE DOES NOT HAVE LESS THAN 70,000 MILES THE MANUFACTURER WILL NOT STAND UP TO THE MISTAKE AND FIX IT, I UNDERSTAND THAT I BOUGHT IT USED BUT ITS AND ON GOING PROBLEM IN THE CLUSTER FOR HUNDREDS OF THOUSANDS OF VEHICLES, I THINK IT SHOULD BE HANDLED BY GMC. I HAVE OWNED 8 GMC VEHICLES AND USE TO THINK I WOULD NOT BY ANYTHING ELSE, BUT MY MIND IS ABOUT TO CHANGE OVER THIS ISSUE. BECAUSE OF THE ATTITUDE I HAVE GOTTEN FROM THE DEALERSHIPS AND EMPLOYEES ABOUT THE ISSUE. *TR

Mileage: 97,000

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT WAS DRIVING 45 MPH AND APPLIED THE BRAKES BUT THE VEHICLE FAILED TO IMMEDIATELY DECELERATE, INCREASING STOPPING DISTANCE AND TIME. THE ABS WARNING LIGHT WAS ILLUMINATED SPORADICALLY PRIOR TO THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE INSTRUMENT PANEL WAS REPLACED. THE BRAKE LINE WAS ALSO REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 26,000 AND THE CURRENT MILEAGE WAS 41,500.

Mileage: 26,000

TL* THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE CONTACT STATED THAT THE ENTIRE INSTRUMENT PANEL AND GAUGES FAILED TO OPERATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE INSTRUMENT PANEL CLUSTER WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.

Mileage: 171,000

I'VE HAD IT LESS THAN 1 YEAR, AND HAS UNDER 90,000 MILES. I LEFT MY HOUSE AND GOT 1/4 MILE DOWN THE STREET AND THE ENTIRE CAB OF THE TRUCK FILLED WITH SMOKE. HAD TO CALL 911 AND HAVE THE FIRE DEPARTMENT COME TO THE SCENE. AN ELECTRICAL FIRE ABOVE THE HEAD LINER KILLED THE ELECTRONICS IN THE ENTIRE VEHICLE. NO LIGHTS, POWER SEATS, RADIO, DASH CLUSTER, EXTERNAL LIGHTS AND SIGNALS, HORN, WINDOWS,NOTHING WORKS, ENGINE WONT START. THE FIRE APPEARS TO HAVE STARTED NEXT TO THE ON STAR SPEAKER IN THE HEADLINER. *TR

Mileage: 89,900

ALL GAUGES QUIT WORKING. THEY WILL WORK EVERY NO AND THEN. *TR

Mileage: 169,000

NEEDLE ON SPEEDOMETER FREEZES IN WINTER. I DO NOT KNOW MY SPEED! *TR

Mileage: 100,000

I HAVE A CHEVY SILVERADO 03, 2500HD AND I BELIEVE THERE IS A DEFECT IN THE HEATER BLOWER MOTOR RESISTOR AND WIRE HARNESS THAT CONNECTS TO IT. I RECENTLY CHANGED A BLOWER MOTOR RESISTER BACK IN SEPTEMBER, NOW HERE IS DECEMBER AND THE SAME RESISTOR HAD BLOWN AGAIN. SO I REPLACED WITH NEW ONE, AND NOW THE WIRE HARNESS THAT CONNECTS TO IT IS HEATING UP TO APPOINT THAT YOU CAN SMELL BURNING WIRES. I HAD CALLED MY LOCAL DEALERSHIP AND THEY TELL ME THAT THEY SEEN THIS PROBLEM ON A LOT OF GM VEHICLES AND WANT TO CHARGE ME $160 TO CHANGE THE BAD WIRE HARNESS AND BLOWER MOTOR RESISTOR. I DON'T UNDER STAND WHY THIS IS NOT RECALLED FOR POSSIBLE BEING ABLE TO START A FIRE UNDERNEATH THE DASHBOARD. PLEASE LOOK INTO THIS BEFORE A SERIOUS ACCIDENT OCCURS. THANK YOU *TR

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING APPROXIMATELY 40 MPH THE SPEEDOMETER BEGAN TO DISPLAY A SPEED OF 10 MPH. AS A RESULT THE VEHICLE WAS INVOLVED IN A CRASH. A POLICE REPORT WAS FILED. A PASSENGER IN THE OTHER VEHICLE WAS INJURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHERE THE BODY DAMAGES WERE REPAIRED BUT THE FAILURE WAS NOT DIAGNOSED. THE CONTACT ALSO STATED THAT THE FUEL GAUGE AND THE SPEEDOMETER INTERMITTENTLY DISPLAYED AN IMPROPER READING. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 104,000. THE VIN WAS UNAVAILABLE.

Mileage: 90,000

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING APPROXIMATELY 55-60 MPH HE NOTICED THAT THE SPEEDOMETER WAS NO LONGER WORKING AND DISPLAYED ZERO. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO WAS DIAGNOSING THE FAILURE WHEN THE COMPLAINT WAS FILED. THE INSTRUMENT PANEL WAS REPLACED IN 2007. THE MANUFACTURER WAS CALLED AND STATED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST WITH THE REPAIR COST. THE FAILURE MILEAGE WAS 140,000. THE CURRENT MILEAGE WAS APPROXIMATELY 150,000. UPDATED 01/28/11*LJ UPDATED 02/07/11

Mileage: 140,000

INTERMITTENT FAILURE OF INSTRUMENT/GAUGES CLUSTER CAUSING UNKNOWN DRIVING SPEEDS AND UNABLE IDENTIFY POSSIBLE ENGINE PROBLEMS AND UN ABLE IDENTIFY FUEL LEVEL. INTERMITTENT FAILURE OCCURRED FOR TWO YEARS UNTIL TOTALLY FAILURE OCCURRED. *TR

Mileage: 68,000

WE OWN TWO CHEVROLET VEHICLES THAT ARE EXPERIENCING THE ALL TOO COMMON PROBLEM WITH DEFECTIVE AND/ OR ERRATIC OPERATION OF SPEEDOMETERS. ONE IS A 2003 SILVERADO K-2500 H-D WITH APPROX 87,000 MILES. WE HAVE OWNED THIS VEHICLE FOR 2 YEARS THIS MONTH, AND THE PROBLEM STARTED JUST AFTER BRINGING IT HOME. IT WAS BOUGHT USED, SO PROBLEM MAY HAVE BEEN AROUND FOR MUCH LONGER. THE SECOND IS A 2003 TAHOE LT WITH APPROX. 67,000 MILES. THIS VEHICLE WAS PURCHASED USED ALSO; IN MAY 2008. THE SPEEDOMETER BEGAN MALFUNCTIONING IN FALL 2009. THIS IS APPARENTLY A VERY COMMON, AND POTENTIALLY SERIOUSLY DANGEROUS PROBLEM. WE FEEL THIS IS A MANUFACTURER DEFECT IN MATERIAL AND WORKMANSHIP, AND NOT AN EXPENSE TO REPAIR THAT SHOULD BE WHOLLY THE RESPONSIBILITY OF LOYAL VEHICLE OWNERS. WHO SHOULD BE RESPONSIBLE IF THIS CAUSES, AT BEST ONLY EXPENSIVE CITATIONS, AND AT WORST POSSIBLE FATAL OR SERIOUS ACCIDENTS? *TR

Mileage: 80,000

INSTRUMENT CLUSTER FAILURE. *TR

Mileage: 100,000

I HAVE HAD SPEEDO PROBLEMS FOR OVER A 1 YEAR. NOW IT HAS BECOME REGULAR. THIS IS A SAFETY ISSUE. CHEVY TOLD ME TO GO AWAY BECAUSE I AM OVER MILEAGE REQUIREMENTS. I SEE I AM NOT ALONE. THERE ARE THOUSANDS OF WACKY SPEEDOMETERS OUT THERE. THIS KIND OF SERVICE HAS CONVINCED ME THAT CHEVY DOESN'T DESERVE TO BE IN BUSINESS ANYMORE. THE JOKES WILL NO LONGER BE ABOUT FIX OR REPAIR DAILY (FORD). *TR

Mileage: 90,000

I HAVE A 2003 CHEVY SILVERADO 2500 HD THAT HAS PROBLEMS WITH THE SPEEDOMETER, BATTERY, FUEL, AND TEMP. GAUGES. IF THAT'S NOT A SAFETY PROBLEM, WHAT IS. THERE ARE THOUSANDS OF PEOPLE LIKE MY SELF THAT CANNOT AFFORD THE REPAIRS. THINK ABOUT IT THOUSANDS COMPLAINING OF THE SAME PROBLEM BUT NOTHING IS DONE. THATS THOUSANDS OF PEOPLE ON THE ROAD THAT DO NOT KNOW HOW FAST THEY ARE GOING AND WHEN THERE CAR IS GOING IS GOING TO RUN OUT OF GAS OR WORST EXPLODE. *TR

Mileage: 40,000

THE 2003 CHEVROLET SILVERADO 2500 HD "REDUCED ENGINE POWER" DISPLAYS ON THE DASH. THIS CAUSES THE VEHICLE TO LOSE POWER AT ANY TIME. THIS HAPPENED BACK IN FEBRUARY, TOOK IT INTO THE DEALERSHIP FOR SERVICE, AND THEY REPLACED THE THROTTLE BODY HOUSING. I WAS DRIVING THE VEHICLE AFTER THE HOUSING WAS REPLACED, AND LOST POWER 2 MORE TIMES BEFORE I COULD GET IT IN FOR SERVICE. TOOK IT BACK TO THE DEALER, AND THEY REPLACED THE ELECTRONIC THROTTLE COMPONENT. I RECEIVED THE MESSAGE 2 MORE TIMES. TOOK THE TRUCK BACK, AND THEY REPLACED THE COMPUTER. SAME PROBLEM. THE TRUCK IS AT THE DEALER NOW. *TR

Mileage: 147,000

INSTRUMENT CLUSTER SUDDENLY LOSING POWER AND GOING OFF AND ON. RESEARCH ON RECALL STATES RECALL IS ONLY GOOD UP TO 70,000 MILES AND 2003 CHEVY 2500HD HAS 82,000 MILES ON IT. *TR

Mileage: 82,000

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. WHEN THE CONTACT STARTED THE VEHICLE, SHE NOTICED THAT THE ABS WARNING INDICATOR WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE INSTRUMENT PANEL BECAME INOPERABLE AND SHE COULD NOT READ THE SPEEDOMETER AND OTHER GAUGES. THE DEALER REPLACED THE INSTRUMENT CLUSTER PANEL AT THE COST OF $1,383. ON A SEPARATE OCCASION, THE INSTRUMENT PANEL FAILED AGAIN, INCLUDING THE FUEL GAUGE, SPEEDOMETER, AND WARNING LIGHTS. THE DEALER STATED THAT THE INSTRUMENT CLUSTER PANEL FAILED A SECOND TIME. THE REPAIR WOULD COST OVER $1,800. NO REPAIRS HAVE BEEN PERFORMED ON THE VEHICLE. THE FAILURE MILEAGE WAS 74,417 AND CURRENT MILEAGE WAS 128,880.

Mileage: 74,417

ENGINE DOES NOT IDLE AND SHUTS OFF. ACCORDING TO INTERNET SITES, ITS A WIRE FAILURE IN THE THROTTLE BODY CONNECTOR. CAN BE A MAJOR ISSUE WHEN YOU COME TO A STOP. SOME TIMES WILL NOT RESTART RIGHT AWAY. *TR

Mileage: 60,000

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THE TRANSFER CASE WAS DESIGNED WITH A DEFECT. AS A RESULT, THE PUMP IN THE TRANSFER CASE WORE A HOLE FROM THE INSIDE TO THE OUTSIDE OF THE TRANSFER CASE. THIS ALLOWED THE OIL IN THE TRANSFER CASE TO PUMP OUT THE HOLE AND CAUSED THE TRANSFER CASE TO RUN DRIVE. THE DEALER STATED THAT THE VEHICLE WAS OUT OF WARRANTY AND THE CONTACT WOULD HAVE TO PAY FOR THE REPAIR. THE FAILURE MILEAGE WAS 130,000. UPDATED 3/16/09 *CN THE POWER STEERING STARTED LEAKING FLUID. THE DEALER INFORMED THE CONSUMER THE POWER STEERING FLUID LEAK WAS COMING FROM THE HYDRO BOOSTER ONTO THE POWER STEERING GEAR. THE CONSUMER LOST HIS BRAKES. IT WAS DISCOVERED THE BOOSTER ROD WAS MISSING. THE PARKING BRAKE DID NOT WORK AND THE INSTRUMENT CLUSTER FAILED AS WELL. THE SPEEDOMETER DID NOT WORK IT WAS READING 60 MPH EVEN WHEN THE VEHICLE WAS PARKED. UPDATED 03/18/09. *JB

Mileage: 130,000

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING APPROXIMATELY 65 MPH, THE DRIVER'S SIDE AIR BAG SUDDENLY DEPLOYED. THE SUDDEN DEPLOYMENT HINDERED THE CONTACT'S VISIBILITY, ALONG WITH THE SMOKE AND POWDER THAT EMITTED FROM THE AIR BAG. HE ATTEMPTED TO OPEN THE WINDOWS AND NOTICED THAT ALL ELECTRICITY IN THE VEHICLE WAS LOST. HE COULD NOT UNLOCK THE DOORS OR ROLL DOWN THE WINDOWS. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE AND STATED THAT IT WAS NOT COVERED UNDER WARRANTY. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 162,462.

Mileage: 162,462

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT HE MUST DISCONNECT HIS BATTERY IN ORDER FOR THE SPEEDOMETER TO WORK. THE SPEEDOMETER IS STUCK ON 45 MPH AND DOES NOT MOVE UP OR DOWN. THE DEALER STATED THAT THERE WAS NO RECALL; HOWEVER, A TSB STATED THAT WITHIN SEVEN YEARS OR 70,000 MILES THE GAUGE CLUSTERS COULD BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN THE TSB. THE FAILURE MILEAGE WAS 97,400. UPDATED 03/23/09. *LJ THE CONSUMER STATED HE NEVER KNOWS HOW FAST HE IS DRIVING. UPDATED 03/24/09*JB

Mileage: 97,400

2003 CHEVY 2500HD SPEEDOMETER FAILURE. *TR

DROVE VEHICLE AND NOTICED FAN BLOWER WAS NOT WORKING, LOCATED FUSE FOR BLOWER, PULLED AND VERIFIED FUSE IS OK. PUT FUSE BACK IN CHECKED BLOWER AND FAN WAS WORKING. THE NEXT DAY MY HUSBAND DROVE THE VEHICLE FOR APPROX.10 MIN AND SMOKE STARTED BILLOWING OUT FROM UNDER THE DASH (PASS. SIDE). HE TURNED AROUND, CAME HOME AND WE USED A FIRE EXTINGUISHER TO PUT OUT THE FIRE UNDER THE GLOVE BOX AND ALSO COVERED BY A PLASTIC COVERING NOT QUICKLY ABLE TO BE REMOVED. DISCONNECTED THE BATTERIES AND REMOVED THE COVER EXPOSING THE WIRING. WE CAN SEE THE WIRING AND RELAY THAT HAVE MELTED. CALLED GM (11/3, 9 - 10 BUS. DAYS TO RESPOND), THE VEHICLE IS OVER WARRANTY COVERAGE, BECAUSE I DON'T FEEL THAT A 5YR VEHICLE SHOULD JUST CATCH ON FIRE. GM RESPONDED WITH A DENIAL BECAUSE OF MA LAWS BUT I LIVE IN ME SO THEY ARE LOOKING INTO IT AGAIN WITH THE CS REP THAT HANDLES ME. MEANWHILE I DO NOT HAVE A VEHICLE TO DRIVE. HAVE AN ISSUE WITH TAILLIGHT BURNING HOUSING AND DAYTIME RUNNING LIGHT COMES ON AND OFF. SOCKET LOOKS BURNT, LIGHT BULB IS FINE BUT DOES NOT CONSISTENTLY WORK. HAVE ALSO HAD THE SPEEDO ISSUE - GM FIXED, REPLACED FRONT HUBS MY COST, & REPLACED GLOW PLUGS. NOW TRYING TO DETERMINE IF I'M HAVING SAME TRANNY ISSUES OTHERS HAVE REPORTED. SO FAR NOT SO IMPRESSED. HAVE REPORTED FIRE ISSUE TO MY INSURANCE CO. TO DOCUMENT PROBLEM. UNTIL TRUCK IS PLUGGED IN IT IS IMPOSSIBLE TO DETERMINE EXTENT OF DAMAGE. *TR

Mileage: 94,000

SPEEDOMETER READING WAY OFF BOUNCES UP AND DOWN. *TR

Mileage: 40,000

IT WAS FIRST IN WINTER OF 2006 THAT IT FIRST HAPPEN, THE SPEEDOMETER SHOWED THAT I WAS GOING 20 MPH WHEN I STOPPED THE TRUCK, BUT IT RESET ITSELF WHEN I WENT AND STARTED IT THE NEXT TIME, AND I THOUGHT THAT WAS STRANGE I HAD ABOUT 60K ON THE TRUCK. IN THE SUMMER OF 2007 GOT LETTER SAYING THAT IF INTERMENT PANEL GAUGES BECOME INOPERATIVE TO BRING IT IN, AS LONG AS THE MILEAGE IS LESS THAT 70K, I CHECKED AND MINE WAS 77K SO DIDN?T BRING IT IN. THIS MALFUNCTION DIDN?T HAPPEN AGAIN TILL THE WINTER OF 2007 WHEN IT HAPPENED ABOUT A DOZEN TIME, THIS TIME TOOK IT IN TO SEE IF THEY WOULD REPLACE IT, BUT THEY SAID IT WAS OVER THE LIMIT, (70K) AND IT WOULD COST ME $550 TO REPLACE. I BELIEVE THAT IT IS A DANGER FOR GM TO HAVE VEHICLE BEING DRIVEN ON THE HIGHWAY THAT ARE NOT OPERATING SAFELY. *RED. *TR

Mileage: 60,000

1. MY SILVERADO 2500HD, 2003 SPEEDOMETER STOPPED WORKING AROUND 70K MILES, 3 YEARS AGO. 2. AT THE TIME I WAS TOLD IT WOULD BE $525 TO FIX IT - REPLACING A SMALL PLASTIC GEAR IN THE DASH. I DECIDED NOT TO WASTE THE MONEY AND LIVED WITH IT. 3. IN JANUARY 2008, I RECEIVED A LETTER FROM GM SAYING THE BROKEN SPEEDOMETER FOR MY TRUCK WAS A DEFECT AND IT WOULD BE FIXED AT NO CHARGE IF I WAS WITH IN 7 YEARS OLD AND 70K MILES. 4. I TOOK MY TRUCK INTO ESINGER CHEVROLET IN KALISPELL, MONTANA ON MAY 28, 2008. THEY REPAIRED THE SPEEDOMETER AND BILLED ME $414.85, ON 5. MY TRUCK HAD 118,735 MILES ON IT SO ESINGER WOULD NOT COVER IT UNDER THE RECALL PROGRAM. I WOULD LIKE TO REQUEST THAT GM RECONSIDER THIS DECISION SINCE THE SPEEDOMETER BROKE 3 YEARS EARLIER AND IT WAS AROUND 70K MILES. IT IS KNOWN THERE IS A PROBLEM WITH THE SPEEDOMETER AND I FEEL IT SHOULD HAVE BEEN REPAIRED AT NO CHARGE. YOUR CONSIDERATION OF CREDITING ME THE $414.85 WOULD BE MUCH APPRECIATED. I HAVE BEEN A LONG TIME OWNER AND BUYER OF NEW CHEVY TRUCKS FOR THE LAST 20 YEARS. SINCERELY, RANDY WILSON *TR

Mileage: 70,000

2003 CHEVROLET SILVERADO 2500 HD 4X4 6.0L HAS A SPEEDOMETER THAT MALFUNCTIONS. GENERAL MOTORS IS SAYING THE PROBLEM LIES IN THE STEPPER MOTORS IN THE SPEEDOMETER CLUSTER ITSELF. GENERAL MOTORS IS NOT FIXING THIS PROBLEM ON THEIR VEHICLES FOR FREE. *TR

Mileage: 54,000

WE WERE DRIVING HOME FROM A FOOTBALL GAME WHEN WE NOTICED WE WERE APPARENTLY DRIVING FASTER THAN THE SPEEDOMETER STATED, IT READ 65MPH,BUT THE RPM'S DID NOT MATCH AND WE WERE BLOWING PAST OTHER VEHICLES ON THE HIGHWAY AND FROM THAT POINT HAD TO GUESS HOW FAST WE WERE TRAVELING. THIS HAS HAPPEN A FEW TIMES AND NOW THE SPEEDOMETER DOES NOT WORK AT ALL. GM SENT OUT LETTERS STATING A POSSIBLE INSTRUMENT PANEL GAUGE NEEDLES MAY STICK,FLUTTER OR BECOME INOPERATIVE & MAY CAUSE INACCURATE READINGS. GM REFUSES TO RECALL OR FIX OUR VEHICLE/TRUCK FOR FREE-THEY CLAIM TOO MANY MILES, I HAVE PROOF THIS HAS HAPPEN TO OTHER TRUCKS WITH MILES AT ON OR ABOUT 40,000, 90,000 AND OUR VEHICLE AT OR ABOUT 147,000 AT THE TIME IT MALFUNCTIONED. IT IS APPARENT THAT THIS IS A SAFETY ISSUE AND THE MALFUNCTIONS OCCUR AT VARIOUS MILEAGES ON THESE TRUCKS AND GM WILL NOT REPAIR OUR VEHICLE AT THEIR COST. THE TRUCKS IN QUESTION ARE YEAR(S) 2003,2004 & 2002 CHEVY SILVERADO. IT IS VERY DANGEROUS TO DRIVE OUR TRUCK AND NOT KNOW HOW FAST WE ARE TRAVELING. *TR

Mileage: 147,000

SPEEDOMETER IS MALFUNCTIONING. *TR

Mileage: 49,450

I OWN A 2003 CHEVROLET SILVERADO 2500 HD. IN AUGUST 2006 MY OIL PRESSURE GAGE STARTED TO MALFUNCTION. IT WOULD INTERMITTENTLY READ NO OIL PRESSURE EVEN THOUGH THE OIL LEVEL WAS ADEQUATE. I TOOK THE VEHICLE FOR A FUEL SYSTEM SERVICING TO A GM DEALER IN SAN ANTONIO TX AND ASKED THEM TO CHECK THE OIL PRESSURE PROBLEM. THE SERVICE MANAGER STATED THE PROBLEM WAS A PRESSURE SWITCH. I ASKED IT TO BE REPAIRED ALONG WITH THE FUEL SYSTEM SERVICING. AT THE TIME MY VEHICLE HAD APPROXIMATELY 65,000 MILES. THE SERVICE DEPARTMENT FAILED TO ATTEMPT A REPAIR ON THE OIL PRESSURE GAGE EVEN THOUGH THE OTHER ITEMS WERE REPAIRED. I ELECTED NOT TO LET THEM KEEP MY VEHICLE LONGER TO AFFECT THE REPAIR. APPROXIMATELY 2 MONTHS LATER I TOOK THE VEHICLE TO ANOTHER DEALER AND ASKED IT TO BE REPAIRED. THE SERVICE MANAGER INFORMED ME THE ACTUAL PROBLEM WAS THE INSTRUMENT PANEL. IT WOULD COST APPROXIMATELY $700 TO REPLACE. I ELECTED NOT TO HAVE IT REPLACED DUE TO THE COST. AT THIS TIME MY VEHICLE HAD 71,000 MILES. IN THE SUMMER OF 2007 MY SPEEDOMETER STARTED TO MALFUNCTION BY DISPLAYING THE WRONG SPEED OR STICKING AT ZERO. I AGAIN TOOK THE VEHICLE TO THE DEALER WHO AGAIN SAID IT WAS THE INSTRUMENT CLUSTER. SHORTLY AFTER, I RECEIVED A LETTER FROM GM STATING THIS WAS A KNOWN ISSUE AND IT WOULD REPLACE OR REPAIR THE MALFUNCTION FREE OF CHARGE ON ANY VEHICLE WITH LESS THAN 70,000 MILES. I CONTACTED MY LOCAL GM DEALER TO SEE IF MY VEHICLE COULD BE REPAIRED UNDER THIS SINCE IT ORIGINALLY MALFUNCTIONED WHEN THERE WAS LESS THAN 70,000 MILES ON THE VEHICLE. THE SERVICE MANAGER CONTACTED GM AND THEN TOLD ME THEY WOULD NOT SINCE MY VEHICLE HAS MORE THAN 70,000 MILES AND GM DOES NOT CONSIDER THIS A SAFETY ISSUE. MY VEHICLE CURRENTLY WILL NOT PASS A STATE OF TEXAS SAFETY INSPECTION BECAUSE THE SPEEDOMETER DOES NOT WORK. I AM MAKING A COMPLAINT BECAUSE I BELIEVE THIS IS A SAFETY ISSUE AND SHOULD BE A FULL RECALL. *TR

Mileage: 65,000

TL*THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. WHILE DRIVING 70 MPH, THE SPEEDOMETER INCREASED TO 115 MPH AND REMAINED IN THAT POSITION. AS OF FEBRUARY 8, 2008, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 71,236.

Mileage: 71,236

2003 CHEVROLET SILVERADO 2500 INSTRUMENT PANEL GAUGE NEEDLE STICKING. CONSUMER STATES THAT GM SAID THEY WOULD NOT COVER IT BECAUSE THE VEHICLE HAS OVER 70,000 MILES ON IT. KB*

INTERMITTENT FAILURE OF INSTRUMENT/GAUGES CLUSTER CAUSING UNKNOWN DRIVING SPEEDS AND UNABLE IDENTIFY POSSIBLE ENGINE PROBLEMS AND UN ABLE IDENTIFY FUEL LEVEL. INTERMITTENT FAILURE OCCURRED FOR TWO YEARS UNTIL TOTALLY FAILURE OCCURRED. *TR

MY SPEEDO WENT OUT ON MY 2003 SHEVY 2500HD AT 116000 MILES.I WENT TO START IT ON A COLD DAY AND IT WAS READING 20MPH IN PARK.TODAY IT READS 70 MPH IN PARK AND IS READING OVER 70 MPH OVER THE SPEED THAT I AM DRIVING.*CN

Mileage: 120,000

2003 SILVERADO INSTRUMENT CLUSTER IS FAILING. FIRST, 2 YRS AGO, IT WAS THE TACH FAILING NOW IT IS THE SPEEDOMETER AND THE OTHERS ARE NOT FUNCTIONING CORRECTLY AT TIMES. I DID RECEIVE A LETTER FROM GM 2 WEEKS AGO WENT TO THE DEALER, THEY WOULD NOT DO ANYTHING BECAUSE I HAVE 87000 MI ON IT. CALL GM AND THEY SAID IT IS UP TO THE DEALER. THAT DOESN'T SOUND RIGHT! IS THERE ANYTHING THAT CAN BE DONE? DID GM PUT IT TO US AGAIN? *TR

Mileage: 48,000

ALL GAUGES STOPPED WORKING ON MY 2007 CHEVY SILVERADO. *TR

Mileage: 13,000

WHILE DRIVING DOWN THE INTERSTATE ON CRUISE CONTROL, THE SPEEDO WILL START TO CLIMB TO OVER 120MHP. AFTER SEVERAL IGNITION CYCLES THE SPEEDO WILL COME BACK DOWN AND WORK FINE FOR AWHILE. THIS PROBLEM USUALLY OCCURS WHILE DRIVING ON THE INTERSTATE. PROBLEM IS VERY INTERMITTENT-HAS HAPPENED SEVERAL TIMES AND ALWAYS CORRECTS ITSELF BEFORE I CAN GET IT IN FOR REPAIR- I HAVE TALKED TO SEVERAL OTHER OWNERS WITH THE EXACT SAME PROBLEM- THE FIRST TIME THIS PROBLEM OCCURRED THE TRUCK ONLY HAD 30,000 MILES ON IT. DANGEROUS PROBLEM---WHEN TOWING HEAVY LOADS. *TR

Mileage: 30,000

SPEEDOMETER DOES NOT INDICATE PROPER SPEED. CAN BE AT 0MPH WHEN TRAVELING AT 55MPH. OR CAN BE AT 30MPH WHEN TRAVELING AT 55MPH. *TR

Mileage: 72,259

I HAVE A 2003 CHEVY 2500 H.D. CREW CAB TRUCK. IN AUG OF 2007 MY SPEEDOMETER STARTED ACTING UP. IT WOULD STOP AT 20 MPH WHEN I WAS AT A DEAD STOP. I CAN START THE VEHICLE AND IT WILL GO DOWN 5 MPH FOR EVERY TIME I START THE VEHICLE. WHEN I HIT 0 IT WILL BE FINE FOR A WHILE. IT IS GETTING WORSE EVERY TIME I DO IT. FROM READING ON THE INTERNET I'M NOT THE ONLY ONE! *JB

Mileage: 53,500

THE INSTRUMENT PANEL ON MY 2003 CHEVROLET SILVERADO 2500HD HAS QUIT WORKING. THERE WAS NOT WARNING THAT IT WAS GOING TO FAIL. WHILE DRIVING ALL THE NEEDLES ACROSS THE PANEL WERE STUCK AT ZERO. NO SPEEDOMETER, GAS GAUGE, TACHOMETER, TEMPERATURE. I BELIEVE THIS COULD BE A VERY HAZARDOUS CONDITION AND SHOULD BE INVESTIGATED. *TR

Mileage: 116,600

SPEEDOMETER IN MY 2003 CHEVROLET SILVERADO 2500 HD IS ERRATIC. SOMETIME IT WORKS FINE, OTHER TIMES IT WILL REGISTER 30 MPH AT A STOP. OTHER TIMES IT SHOWS 120 MPH WHEN DRIVING 65 MPH. SOME TIMES IT DOESN'T WORK AT ALL. *JB

Mileage: 36,000

ONE DAY GAUGE CLUSTER ABRUPTLY STOPPED WORKING WHILE I WAS DRIVING ON THE FREEWAY. AND SPEEDOMETER SHOWED A READING OF 0.0 MPH. *AK

I HAVE A 2003 CHEVY SILVERADO 2500 HD DURAMAX 4-DR THAT THE SPEEDOMETER JUST STARTED GOING INTERMITTENTLY WHACKO ON WITH THE LAST YEAR (CONVENIENTLY JUST OUTSIDE OF NORMAL WARRANTY) JUDGING FROM ALL OF THE POSTS I SEE SCATTERED ACROSS THE INTERNET ABOUT THIS IT IS CLEARY A MANUFACTURERS DEFECT AND SHOULD BE RECALLED ASAP.

Mileage: 45,000

CLUNKING NOISE FROM STEERING COLUMN. 1ST FAILURE AT 25,000 MI AND DEALER REPLACED SHAFT. 2ND FAILURE AT 50,000 MI AND GM REFUSED TO REPLACE OR PAY. I HAD TO PAY FOR SOME NEW LUBE KIT TO PREVENT NOISE AND WEAR.

Mileage: 25,000

TL* - THE CONTACT OWNS A 2003 CHEVROLET SILVERADO 2500 HD. THE SPEEDOMETER REGISTERED 120 MPH EVEN WHEN THE POWER HAD BEEN TURNED OFF. THE FAILURE MILEAGE WAS 60,000. THE CONTACT HAD AN APPOINTMENT WITH THE DEALER/MANUFACTURER TO HAVE THE PROBLEM DIAGNOSED. THE CURRENT MILEAGE WAS 63,000.*AK UPDATED 04/05/07*JB

Mileage: 60,000

2003 CHEVROLET SILVERADO 2500HD SPEEDOMETER DOESN'T RETURN TO ZERO WHEN STOPPED. REGISTERS INACCURATE READINGS AS MUCH AS 60 MPH OFF. *JB

Mileage: 42,000

SPEEDOMETER STICKS, DISPLAYS INCORRECT SPEED. UNABLE TO DETERMINE CORRECT SPEED. HAVE NOT FIXED YET. HAPPENED 1 WEEK AFTER WARRANTY EXPIRED. *JB

Mileage: 35,000

I FILED THE FORMAL REQUEST BELOW TO CHEVROLET / GM REGARDING A DEFECTIVE SPEEDOMETER IN MY 2003 CHEVROLET SILVERADO. THIS IS A WELL KNOWN AND A WELL DOCUMENTED PROBLEM, AND I BELIEVE IT TO BE A SEVERE NATIONWIDE SAFETY ISSUE WHICH NEEDS TO BE ADDRESSED TO AVOID POSSIBLE INJURY OR DEATH. GENERAL MOTORS WILL NOT REPAIR THE PROBLEM. SOME INFORMATION IS REMOVED TO MEET THE WORD LIMIT OF THIS COMPLAINT FORM. GM SERVICE REQUEST: 71-482347989 SILVERADO SAFETY HAZARD - A PROBLEM I AM EXPERIENCING WITH MY WIFE'S 2003 SILVERADO 2500 HD IS EXTENSIVE AND DANGEROUS. THE SPEEDOMETER IS OFTEN STUCK AT RANDOM SPEEDS WHEN AT REST, AND WHEN IN MOTION IS UNRELIABLE. INFORMATION THAT I HAVE REVIEWED ON SEVERAL SITES INDICATES THAT THERE IS A KNOWN PROBLEM WITH THE STEPPER MOTORS IN THE INSTRUMENT CLUSTER THAT HANDLE ALL GAUGES ON THIS VEHICLE, AND THAT THERE ARE SEVERAL TSBS THAT ARE RELATED TO THIS PROBLEM IN SEVERAL GM VEHICLES. NHTSA ALSO HAS SEVERAL DOZEN, IF NOT HUNDREDS OF REPORTS OF THIS PROBLEM. THERE ARE ALSO SEVERAL PETITIONS IN PROGRESS TO DEMAND RECALLS AND / OR MEDIA INVESTIGATIONS. ALTHOUGH MY VEHICLE IS OUT OF WARRANTY, THIS APPEARS TO BE A DEFECT WORTHY OF A RECALL. WE SPECIFICALLY TRADED UP TO THIS VEHICLE BECAUSE WIFE HAULS A HORSE TRAILER WITH TWO OR THREE HORSES THROUGH MOUNTAINOUS TERRAIN TO HORSE EVENTS FOR HER, MY DAUGHTER, AND MY DAUGHTER'S FRIENDS. THE SAFETY IMPLICATIONS OF UNRELIABLE GAUGES ARE MANY-FOLD, WHETHER IT IS GATHERING TOO MUCH DOWNHILL SPEED BECAUSE OF AN INCORRECT SPEEDOMETER, RUNNING OUT OF GAS WHILE TOWING A LOADED HORSE TRAILER DOWN A STEEP SLOPE BECAUSE OF AN INCORRECT GAUGE, OVERHEATING THE TRANSMISSION OR ENGINE BECAUSE OF AN INCORRECT TEMPERATURE READING, ETC. THERE ARE SEVERAL SOURCES OF INFORMATION DOCUMENTING THIS ISSUE. A FEW EXAMPLES ARE AS FOLLOWS: (MOST EXAMPLES REMOVED TO MEET WORD LIMIT): HTTP://WWW.TOPIX.NET/FORUM/AUTOS/CHEVROLET-SILVERADO-1500/TR5QAB2MN19BL1D2J/P4 *JB

Mileage: 58,500

SPEEDOMETER DISPLAYS ERRONEOUS SPEEDS, USUALLY TOO FAST. *JB

Mileage: 38,000

I HAVE A 2003 CHEV. 2500 4X4 EST. CAB LONG BOX. IT HAS 18000 MILES ON IT. I HAD TO REPLACE THE REAR BRAKES AND ROTORS AT 18000 MILES. THIS IS UNACCEPTABLE FOR A TRUCK OF THIS TYPE. (HEAVY DUTY). I ALSO HAD A DIM BRAKE LIGHT ON THE DASH, WHICH I HAD CHECKED OUT AT THE DEALER. THEY SAID IT WAS IN THE DASH BOARD AND WOULD COST 400.00+ TO FIX. THE DEALER ALSO SAID THE STEERING WAS LOOSE AND THIS WAS CAUSED BY THE FACTORY WHEN INSTALLED, 250.00+ TO FIX. WHAT KIND OF PRODUCT ARE THEY MAKING? *NM

Mileage: 17,992

DURING NORMAL HIGHWAY AND OR CITY DRIVING, THE SPEEDOMETER WILL REGISTER A RATE OF SPEED HIGHER THEN ACTUAL. THIS SPEED HAS BEEN RECORDED AS ANYWHERE FROM 5 TO 50 MPH HIGH. WHEN THE SPEEDOMETER IS READING HIGH, UPON STOPPING, THE SPEEDOMETER WILL REMAIN AT THE AMOUNT OF SPEED THAT IT IS REGISTERING HIGH. FOR EXAMPLE, IF TRAVELING AT 30 MPH AND THE SPEEDOMETER READS 50 MPH, WHEN THE VEHICLE IS STOPPED, THE SPEEDOMETER WILL STILL READ 20 MPH. ONCE THIS PROBLEM STARTS, IT IS VERY CONSISTENT ON ITS REGULARITY. A SIMPLE SOLUTION IS TO REPEATEDLY TURN THE VEHICLE OFF AND RESTART IT. THE SPEEDOMETER WILL DROP 5 MPH WITH EACH CYCLE UNTIL IT REACHES 0 MPH. HOWEVER, THE PROBLEM WILL LIKELY REOCCUR ON THE TRIP THAT I AM ABOUT TO MAKE. MY COWORKER IS HAVING THE EXACT SAME PROBLEM IN A VERY SIMILAR VEHICLE. UPON CONTACTING THE SERVICE DEPARTMENT AT MY LOCAL DEALERSHIP, I WAS TOLD THIS PROBLEM HAD BEEN SEEN ON OTHER OCCASIONS AND THE SOLUTION IS TO REPLACE THE INSTRUMENT CLUSTER AT AN APPROXIMATE COST OF $600.00. *JB

Mileage: 32,800

THE SPEEDOMETER IN MY 2003 SILVERADO HD CREWCAB 4X4 HAS BROKE. THE INDICATOR (NEEDLE) IS NOW ON THE EXTREME RIGHT OF THE GAUGE. AFTER DOING SOME RESEARCH I HAVE FOUND THAT THIS ISSUE IS COMMON AND THE STEPPER MOTOR WILL NEED TO BE REPLACED. TO DO THIS THE ENTIRE INSTRUMENT CLUSTER MAY HAVE TO BE REPLACED. *NM

Mileage: 610,005

ERRATIC SPEEDOMETER READINGS. DRIVING ON THE INTERSTATE AT 55 MPH WITH CRUISE CONTROL ENGAGED. POSTED SPEED LIMIT INCREASED TO 65. USED THE CRUISE CONTROL TO INCREMENT MY SPEED. SPEED INCREASED, SPEEDOMETER READING DID NOT INCREASE, BUT KEPT GETTING LOWER. STAYED WITH SPEED OF TRAFFIC BUT SPEEDOMETER READING SLOWLY FELL TO 35 MPH. STOPPED, SHUT OFF THE VEHICLE AND WAITED 5 MINUTES. UPON RESTART, SPEEDOMETER APPEARED TO BE FUNCTIONING CORRECTLY. GOT BACK ON THE INTERSTATE AND UP TO 65 MPH. WHEN I DECELERATED WHILE EXITING THE INTERSTATE, THE SPEEDOMETER REMAINED AT 65 MPH. PARKED IN MY DRIVEWAY, THE SPEEDOMETER READS 65 MPH. WHEN DRIVEN, SPEEDOMETER INCREASES IMMEDIATELY FROM 65 MPH AND HIGHER. *NM

Mileage: 57,000

THE SPEEDOMETER IN MY 2003 CHEVROLET SILVERADO 2500HD SUDDENLY STOPPED WORKING. THE NORMAL SPEED SHOWN NOW IS OVER 120 MPH WHILE MOVING OR STOPPED. ON RARE OCCASIONS THE SPEEDOMETER WILL REGISTER A LESSER SPEED FOR A SHORT PERIOD OF TIME BUT THE NORMAL SPEED SHOWN IS 120 MPH OR HIGHER. THE ODOMETER WORKS WITHOUT A PROBLEM AS WELL AS ALL OTHER ELECTRICAL FUNCTIONS OF THE SPEEDOMETER OTHER THAN ACTUAL SPEED. PER MY MOST RECENT CONTACT WITH A GENERAL MOTORS DEALER SERVICE DEPARTMENT (MR. GOODWRENCH) THAT DEALER IS SEEING AN AVERAGE OF ONE SIMILAR VEHICLE PER DAY WITH THE SAME PROBLEM. NOT KNOWING THE ACTUAL TRAVELING SPEED OF THE VEHICLE WILL CERTAINLY LEAD TO TRAFFIC ACCIDENTS AND INJURIES IF THIS HAS NOT ALREADY HAPPENED. I'VE NOW HAD TWO ESTIMATES TO REPAIR THE SPEEDOMETER. THE FIRST ESTIMATE WAS IN 12/2004 AND THE ESTIMATE WAS $1,000.00+ AND APPROXIMATELY 6 WEEKS IN THE SHOP. THE 2ND ESTIMATE WAS IN 12/2006 BY AN OUT OF STATE DEALER (WHO SAYS HE GETS ONE NEW REPAIR DAILY) AND THE COST WAS APPROXIMATELY $500 BUT IT WOULD TAKE SEVERAL DAYS TO DETERMINE WHAT COMPONENT PART WAS NEEDED AND SINCE I WAS TRAVELING INTERSTATE ON A YEAR END VACATION I COULDN'T WAIT FOR THE REPAIR. THIS DEALER SUGGESTED SOMEONE SHOULD CONTACT YOUR OFFICE BECAUSE THEY FELT A NON-OPERATIONAL SPEEDOMETER WAS A MAJOR SAFETY PROBLEM WITH THE POTENTIAL FOR SEVERE INJURY OR DEATH. *JB

Mileage: 45,000

SPEEDOMETER READS 42 MPH IN THE DRIVEWAY. 120+MPH ON THE HIGHWAY. 2003 2500 HD SILVERADO 47,000 MILES. *JB

2003 CHEVROLET SILVERADO GAUGE CLUSTER HANG UPS SPEEDO GETS HUNG UP AND GIVES FAULTY READINGS. *NM

Mileage: 86,500

1. CITY AND HIGHWAY DRIVING. 2. SPEEDO STICKS ALMOST ALWAYS NOW. 3. GM WANTS $700 TO FIX THE PROBLEM, BUT OTHERS ON WEB SAY IT IS TEMPORARY FIX. *NM

Mileage: 40,000

NORMAL 55-60 MPH DRIVE ON INTERSTATE TO WORK. SPEEDOMETER BEGAN TO STICK AT 45 MPH EVEN THOUGH VEHICLE WAS GOING FASTER. SPEEDOMETER NEEDLE NOW MOVES IN A JERKY FASHION SLOWLY UP & SLOWLY BACK DOWN. NOTICED ONLINE THAT SEEMS TO BE A RE-OCCURRING PROBLEM WITH 2003 CHEVROLET VEHICLES AND STILL NO RECALL. I WILL NOT PAY $1000 TO HAVE THIS PROBLEM FIXED. CHEVROLET NEEDS TO STEP UP AND ACKNOWLEDGE THEIR PROBLEM AND HAVE A RECALL. MY VEHICLE IS A 2003 CHEVROLET 2500HD CREW CAB 4X4. *NM

Mileage: 51,000

ENGINE WILL FAIL TO START. SECOND TIME WITH PROBLEM 10/21/06. REPLACED FUSE TO CRANK RELAY FUSE BLOWS IMMEDIATELY. MADE THE TRUCK USELESS FOR SEVERAL DAYS MAKING TRAVEL TO WORK HECTIC. SAME FUSE CONTROLS TURN SIGNALS AS WELL. *NM

Mileage: 43,000

2003 CHEVROLET 2500 HEADLIGHTS AND INSTRUMENT PANEL LIGHTS WILL ILLUMINATE WHILE VEHICLE IS PARKED AND TURNED OFF. MECHANIC IS UNABLE TO IDENTIFY THE PROBLEM. *KB *JB

CONSUMER COMPLAINT CONCERNING TRANSMISSION FAILURES ON 2003 SILVERADO. *TS THE TRANSMISSION FLUID WAS BURNT, THE REVERSE GEAR WAS INOPERABLE AND THE TRANSMISSION SHIFTER WAS LOOSE. THE POWER STEERING FLUID WAS LOW. FLUID WAS LEAKING FROM THE GEAR BOX. THE FRONT SEAL ON THE POWER STEERING PUMP WAS WORN AND LEAKING, AS WELL AS THE LOWER HOSE. THE WATER PUMP GASKET AND LOWER RADIATOR HOSE WAS LEAKING. THE BATTERY WAS REPLACED BECAUSE IT WOULD NOT HOLD A CHARGE. THE A/C WOULD ONLY BLOW OUT AIR FROM THE DEFROST VENTS. THE A/C HEATER MODE DOOR ACTUATOR WAS WORN. THE CHECK ENGINE LIGHT ILLUMINATED. THE FUEL FILTER WAS REPLACED. THE PANEL ON THE DRIVERS SEAT WAS WARPED. THE TIRES WERE REPLACED, HOWEVER MONTHS LATER ONE OF THE TIRES DEVELOPED A SLOW LEAK, DUE TO A PIN HOLE LOCATED IN THE SIDEWALL. THE REAR PADS AND ROTORS WERE REPLACED. THE FRONT AND REAR SHOCKS WERE REPLACED. THE TAIL GATE SUPPORT CABLES WERE REPLACED. THE REAR TIRE BLEW OUT WHILE DRIVING. THE SECOND ROW SEAT BELT WAS INOPERATIVE. *JB

Mileage: 54,385

DT: THE CONSUMER STATES THAT 2003 CHEVROLET C 2500 WAS HAVING A MESSAGE ON THE INSTRUMENT PANEL SHOWING REDUCED ENGINE POWER. THEN, THE ENGINE IMMEDIATELY DROPPED POWER. THE SPEED WILL DRAMATICALLY SLOW TO AROUND 15 MPH. THIS HAPPENED 5 TIMES CURRENTLY. THERE HAVE BEEN SEVERAL NEAR MISSES AS A RESULT OF THE POWER REDUCTION. THE VEHICLE HAS BEEN IN THE DEALERSHIP 5 TIMES FOR THE ENGINE POWER FAILURE. THE DEALER REPLACED THREE TIMES THE WIRING HARNESS TO THE THROTTLE POSITION SENSOR, THROTTLE BODY, POWER TRAIN CONTROL MODULE, THROTTLE ACTUATOR, CONTROL MODULE, ALSO, THE IGNITION SWITCH WAS REPLACED AND THE ENGINE WAS STILL LOSING POWER. THE MANUFACTURER HAS BEEN CONTACTED, AND THE CUSTOMER SERVICE DEPARTMENT WAS VERY UNWILLING TO HELP OR PROVIDE THE ADDRESS TO THE REGIONAL OFFICE. THE CUSTOMER SERVICE REPRESENTATIVE WAS VERY RUDE AND REFUSED TO TRANSFER THE CALL TO HIS SUPERVISOR UPON REQUEST OF THE CONSUMER. *AK

Mileage: 72,862

DT: 2003 CHEVROLET 2500 HD TRUCK EXPERIENCED AN ENGINE POWER REDUCTION. THE VEHICLE OPERATED AT A REDUCED SPEED. IT GOES AT A CRAWL. THIS OCCURRED AT SPEEDS OF 40-50 MPH IN THE MIDDLE OF TRAFFIC. HAS TO COAST OVER TO THE SIDE OF THE ROAD, ON AVERAGE ABOUT 10-15 SECONDS AFTER CUTTING OFF THEN THE ENGINE RESTARTED. THIS USUALLY HAPPENED AFTER VEHICLE HAS NOT RUN FOR AN EXTENDED PERIOD OF TIME SUCH AS BEING PARKED OVERNIGHT. TOOK TO A DEALER, WHO REPLACED THE ACCELERATOR PEDAL THAT RAN BY WIRE NOT CABLE. THIS WAS ELECTRIC AND COMPUTERIZED AND SOME SORT OF SIGNAL WENT THROUGH THE ACCELERATOR PEDAL AND CAUSED THIS FAILURE. THE VEHICLE WILL IDLE, BUT LOST POWER. THIS HAS BEEN A PROBLEM FOR THE LAST 3 MONTHS. THE PROBLEM RECURRED EVEN AFTER THE REPLACEMENT OF 2 ACCELERATOR PEDALS. *AK

Mileage: 110,000

INTERMITTENTLY DASH BOARD LIGHTS AND GAUGES WILL GO BLANK. WHEN THE DASH BOARD LIGHTS GO BLANK CONSUMER CANNOT DETERMINE HOW FAST THE VEHICLE IS GOING. THE DEALER EXAMINED THE VEHICLE FIVE TIMES.*AK

Mileage: 20,000