2005 CHEVROLET SILVERADO 2500 Power Train Problems

NO SEPTEMBER 3RD 2016 I WAS AT STUTZ EXCAVATING DRIVING FOR THEM AND WENT I GOT OFF AND WALKED TO MY PICKUP I GOT IN THE TURNED THE KEY AND THE HOUR METER WAS ON 00.0 AND THE MILES HAD 127300 OR SO I HAD JUST CHANGE THE OIL AND HAD OVER 4000 HRS ON MY TRUCK SOMEONE BROKE IN AND HACKED MY PICKUP IN STUTZ EXC LOT AND ON DEC 20TH I WAS LEAVING DR BUGERS LOT AT 5:10 PM AND MY HEAD LIGHT WOULD NOT WORK I GOT HOME AND THE HEADLIGHTS WORKED FINE I SINCE THEY READ ABOUT CAR HACKS AND PULLED THE RADIO FUSE AND AND TRUCK HAD NO MORE PROBLEMS INFILL APRIL 28 MY TRUCK WOULD NOT GO I REVERS AND THE DOOR LOCKS LOCKS THEMSELF AND THE HRS WERE GOING UP WITH DRIVING IT THE DEALER SAID YOU CAN NOT EARESE THE HOUR ON THAT TRUCK THEY ARE BURNED IN THE COMPUTER. SO IF STUTZ CAN REMOVE THE HOUR THEY CAN REMOVE THE MILES FROM THE TRUCK I GOT POLICE REPORTS ON THE VW JETTA BUT NONE ON THE PICKUP THE PICKUP AND CAR WAS MOVING THREW EDWARDSVILLE WHEN THE HEADLIGHTS WENT OUT I GOT HOME WITH MY FOG LIGHTS AND AGAIN THE EDWARDSVILLE POLICE ARE FRIENDS WITH STUTZ AND TOLD ME IT CAN'T HAPPEN SO NOW I LIVE IN FEAR THAT STUTZ CAN SHUT MY LIGHTS OFF ON A RAINY NIGHT ON A DARK ROAD MIKE WEBER AT 3832 RAMOND RD IS CHRIS STUTZ FATHER IN LAW SO MOST OF THE BRACK IN HAVE BEEN HAPPING AT HOME AND AGAIN COPS REFUSE TO BELIEVE ME

Mileage: 128,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE DRIVING APPROXIMATELY 41 MPH, THE SHIFT LEVER POSITION INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V055000 (POWER TRAIN). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

Mileage: 105,000

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE SHIFTED OUT OF GEAR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE U-JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS THEN TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSFER CASE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 91,708.

Mileage: 91,708

AS I WAS DRIVING SOMEONE PULLED OUT IN FRONT OF ME SO CLOSE I HAD TO PRESS ON THE BRAKE PEDAL PRETTY FIRMLY AS I DID THE BRAKES WENT TO THE FLOOR, LUCKILY I HAVE A MANUAL TRANSMISSION I DOWNSHIFTED IN TIME TO MISS THE OTHER CAR AND PULL OVER ONLY TO SEE THE INTERMEDIATE BRAKE LINE RUSTED THROUGH ALONG THE FRAME RAIL. *TR

Mileage: 99,433

THIS VEHICLE IS A DURAMAX 2500 (DIESEL), THE FIRST THING THAT HAPPENED WAS THE ENGINE HOURS RESET ITSELF TO ZERO THE DEALER SAID IT NEEDED A NEW INSTRUMENT CLUSTER THEN THE GEAR SHIFT INDICATOR QUIT WORKING SO YOU HAVE TO COUNT EACH TIME YOU MOVE IT TO KNOW WHAT GEAR YOU ARE IN I FEEL THIS PRESENTS A SAFETY HAZARD AND SHOULD BE FIXED BY THE MANUFACTURER. THANK YOU . *TR

Mileage: 110,000

THE ENTIRE BRAKE LINE SYSTEM IS RUSTED, AS WELL THE DRIVE SHAFTS AND U-JOINTS. THIS TRUCK IS WELL MAINTAINED AND THESE RUSTED PARTS MAY CAUSE SEVERE PERSONAL DAMAGE. *TR

Mileage: 62,000

MY 2005 CHEVROLET SILVERADO 2500HD HAD BROKEN EXHAUST MANIFOLD BOLTS. REPAIRED AT 87,000 MILES. WENT TO DEALERSHIP TODAY BECAUSE OF EXHAUST LEAK AND WAS TOLD THERE ARE MORE BROKEN BOLTS AT 136,000. OBVIOUSLY THERE IS A DEFECT. UNSAFE/RAW EXHAUST LEAKING INTO AIR AND CAB. *TT

Mileage: 87,782

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500HD. THE CONTACT STARTED THE VEHICLE AND SHIFTED THE GEAR SELECTOR INTO THE "DRIVE" POSITION; HOWEVER, THE PARK INDICATOR REMAINED ILLUMINATED FOR TEN SECONDS. IN ADDITION, THE AUTOMATIC DOOR LOCKS BECAME INOPERATIVE AND FAILED TO LOCK WHEN THE GEAR WAS PLACED IN "DRIVE". THE DOORS WOULD LOCK ONLY MANUALLY. ALSO, THE REAR BACK UP LIGHTS WOULD NOT FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TCM TRANSMISSION MODULE WAS REPLACED. THE VEHICLE OPERATED NORMALLY AFTER THE REPAIR. THE FAILURE MILEAGE WAS APPROXIMATELY 24,416.

Mileage: 24,416

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500 DIESEL. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT NOTICED THAT THE LIGHTS ON THE SHIFTER LEVEL WERE NO LONGER ILLUMINATED. THE CONTACT ALSO STATED THAT HIS TAIL LIGHTS AND THE DOOR LOCKS WOULD NO LONGER FUNCTION. THE CONTACT STATED THAT BECAUSE OF THE FAILURE, HE WAS UNABLE TO DETERMINE WHAT GEAR HE WAS DRIVING IN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND WAS REPAIRED. THE FAILURE MILEAGE WAS 21,010 AND THE CURRENT MILEAGE WAS 21,060. THE CONSUMER ALSO STATED THE BACK-UP LIGHTS WERE NOT WORKING. UPDATED 04/15/11

Mileage: 21,010

TL*THE CONTACT OWNS A 2005 CHEVROLET K2500 PICKUP TRUCK. WHILE DRIVING 5 MPH THE VEHICLE SHIFTED INTO NEUTRAL GEAR WHILE IT WAS IN DRIVE. HE THEN TRIED TO SHIFT GEARS AND WAS UNABLE TO DO SO. THE ENGINE WAS REVVING AFTER HE TRIED TO CHANGE GEARS AND WITHIN A FEW MINUTES, HE WAS ABLE TO CONTINUE DRIVING NORMALLY. THE DEALER WAS CONTACTED AND STATED THAT THE WARRANTY EXPIRED AND MADE NO REPAIRS TO THE VEHICLE. THE VEHICLE WAS REPAIRED BY ANOTHER MECHANIC AT THE OWNERS EXPENSE. THE FAILURE MILEAGE WAS 52,000 AND THE CURRENT MILEAGE WAS 54,000. UPDATED 04/01/10. *LJ

Mileage: 52,000

2005 CHEVROLET SILVERADO 2500 HD 4X4 LT 52,000 MILES TRANSFER CASE REPLACED DUE TO "PUMP RUB". *TR

Mileage: 52,000

BOUGHT 2005- 2500 4X4 CHEVY. SILVERADO 4 DOOR TRUCK NEW FROM HERNDONS CHEVY. IN ORANGE,VA. SEVERAL MONTHS AFTER I BOUGHT IT I STARTED HEARING A KNOCK WHEN I STOP OR TAKE OFF OR ACCELERATE AFTER SLOWING DOWN. IT SOUNDS LIKE IT IS SOMEWHERE IN THE TRANSMISSION AREA. IT DID NOT DO IT ALL THE TIME AND THE KNOCK WAS NOT REAL LOUD. HERNDONS HAS CHECKED IT SEVERAL TIMES AND SAYS IT IS A SLIPPAGE AND IS NORMAL. IT NOW HAS GOTTEN MUCH LOUDER. IT IS NON STOP NOW. EVERYTIME YOU ACCELERATE FROM A SLOWED DOWN OR STOPPED POSITION AND IT CAN BE HEARD FROM PEOPLE STANDING OUT AWAY FROM THE TRUCK. I AM VERY FRUSTRATED. I AM GOING TO TAKE IT BACK TO HERNDONS NEXT WEEK BUT I BOUGHT THEY WILL SAY IT IS ANYTHING WRONG AS BEFORE. I HAVE NEVER HEARD A VEHICLE SOUND LIKE THIS. IT IS EMBARRASSING TO DRIVE. IT HAS APPROX. 34000 MILES ON IT NOW,BUT THE PROBLEM BEGAN A FEW YEARS BACK. HERNDON SHOULD HAVE IT DOCUMENTED. VIN# IS . ALSO RIGHT AFTER I GOT THE TRUCK I STARTED IT UP AND BACKED IT TO MY SHOP CUT IT OFF. STARTED IT BACK UP PUT IT IN DRIVE AND IT WENT BACKWARDS. CUT IT OFF-RESTARTED IT PUT IT IN DRIVE WOULD NOT MOVE-PUT IT IN REVERSE-WOULD NOT MOVE. CUT IT OFF-CALLED HERNDONS THEY CAME OUT -I STARTED IT BACK UP AND IT MOVED LIKE IT WAS SUPPOSE TOO. IT DID IT ONCE AFTER THAT WAS A GOOD WHILE LONGER. BUT INSTEAD OF NOT MOVING IT HESITATED FOR A FEW MINUTES BEFORE IT MOVED. HERNDONS CHECKED IT BUT COULD NOT FIND ANYTHING WRONG. SO FAR IT HASN'T HAPPENED AGAIN. I KNOW SOMETHING IS WRONG WITH THIS TRUCK. THE LOUD KNOCK IS NOT NORMAL FOR ANY VEHICLE. I AM AFRAID THAT SOMETHING IS GOING TO BREAK LOOSE AND I AM GOING TO HAVE AN ACCIDENT WHILE DRIVING. PLEASE INVESTIGATE THIS PROBLEM AND SEE IF THERE HAS BEEN ANY OTHER COMPLAINTS LIKE MINE. *TR

Mileage: 13,000

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE ACCELERATING TO 10 MPH, THE CONTACT HEARD A LOUD VIBRATING NOISE. AFTER HAVING THE VEHICLE INSPECTED BY A REPAIR SHOP, HE WAS ADVISED THAT THE BRACKET IN THE TRANSFER CASE FAILED. AS A RESULT, THE SPRINGS IN THE FOUR WHEEL DRIVE TRANSFER CASE PUNCTURED A HOLE IN THE ALUMINUM HOUSING. THE DEALER STATED THAT THE CONTACT WOULD HAVE TO PAY $1,463 TO REPLACE THE TRANSFER CASE BECAUSE IT WAS OUT OF WARRANTY. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 82,000. UPDATED 12/11/08. *LJ UPDATED 12/11/08. *JB

Mileage: 82,000

THE ENGINE OIL COOLER LINES AND THE TRANSMISSION COOLER LINES LEAK AT THE CRIMP WHERE THE RUBBER HOSE AND METAL LINES CONNECT. AFTER DOING RESEARCH ONLINE ABOUT THIS I HAVE DISCOVERED IT IS A VERY COMMON PROBLEM. SOME PEOPLE HAVE REPLACED THESE LINES MULTIPLE TIMES ONLY TO HAVE THEM LEAK A SHORT WHILE LATER. FOR THOSE OF US WHOSE VEHICLES ARE OUT OF WARRANTY THIS CAN BE VERY COSTLY. I WOULD ALSO THINK THAT TRANSMISSION FLUID AND MOTOR OIL CONTACTING HOT SURFACES LIKE AN EXHAUST POSE A FIRE HAZARD. AT THE VERY LEAST THE LEAKING OIL IS AN ENVIRONMENTAL HAZARD. I HAVE PURCHASED OIL COOLER LINES AND AM REPLACING THEM TOMORROW BUT I AM HAVING TROUBLE FINDING TRANSMISSION LINES. *TR

Mileage: 40,000

TL*THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE DRIVING 80 MPH, THE VEHICLE AUTOMATICALLY DOWNSHIFTED TO SECOND GEAR. THE CONTACT WAS UNABLE TO SHIFT GEARS. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THERE WAS NOTHING WRONG. THE VEHICLE DOWNSHIFTED AGAIN WHILE DRIVING AND THE DEALER REPEATED THAT NOTHING WAS WRONG WITH THE VEHICLE. ANOTHER DEALER STATED THAT THE TRANSMISSION WAS BURNED. IN APRIL OF 2007, THEY REPLACED THE TRANSMISSION AT 26,102 MILES. AFTER THE REPLACEMENT, THE FAILURE RECURRED ACCOMPANIED BY A SEVERE GRINDING AND SLAMMING NOISE. THE VEHICLE THEN SHIFTED INTO THIRD GEAR. SINCE THE TRANSMISSION WAS REPLACED, THE VEHICLE HAS BEEN TO THE DEALER AT LEAST TEN TIMES. AS A RESULT OF THE TRANSMISSION FAILURE, THE CONTACT ACCIDENTALLY STRUCK A DEER. A POLICE REPORT WAS FILED. GENERAL MOTORS DEVELOPED A CASE FILE ON NOVEMBER 13, 2007. THEY CALLED THE CONTACT THE FOLLOWING DAY AND STATED THAT THE INITIAL REPRESENTATIVE WORKING ON THE CASE WAS UNAVAILABLE. THE CONTACT HAS YET TO HEAR BACK FROM GENERAL MOTORS. THE FAILURE MILEAGE WAS 20,000 AND CURRENT MILEAGE WAS 34,700.

Mileage: 20,000

TL*THE CONTACTS OWNS A 2005 CHEVROLET SILVERADO 2500. WHILE DRIVING 25-45 MPH ON STEEP DOWNGRADES, THE TRANSMISSION SHIFTED INTO SECOND GEAR WHILE THE GEAR SHIFT INDICATOR WAS STILL IN FIRST. THE VEHICLE WAS TOWING A TRAILER AT THE TIME OF FAILURE. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE DEALER STATED THAT THEY WOULD NOT BE ABLE TO CORRECT THE FAILURE BECAUSE THAT IS HOW THE VEHICLE WAS DESIGNED TO PERFORM. THE CURRENT MILEAGE WAS 19,600 AND FAILURE MILEAGE WAS 19,000. UPDATED 02/01/08. *LJ

Mileage: 19,000

1. I BOUGHT A USED "CERTIFIED" 2500 HD SILVERADO WITH 33000 MILES ON IT. I HAVE OWNED IT ABUT THREE MONTHS. ON THREE SEPARATE OCCASIONS I HAVE NOTICED THE TRANSMISSION SLIP OR "HESITATE" WHEN ACCELERATING FROM A STOP. THE ENGINE WILL REV BUT THE CAR DOES NOT MOVE. WHEN I LET OFF THE GAS I CAN FEEL IT SHIFT SUDDENLY AND THE CAR WILL MOVE. 2. I NOTICED A WHINING SOUND IN THE TRANSMISSION WHEN IT IS IN GEAR. CHEVROLET SERVICE DEPARTMENT TELLS ME IT IS COMMON ON MY TRUCK AND THERE IS NOTHING THEY CAN DO ABOUT IT, IT IS THE PLENARY. THE SOUND IS LOUDER AND CONTINUES THROUGHOUT THE ENTIRE DRIVING RANGE. IT BEGAN AT ABOUT 35000 MILES. THE SERVICE REP STATED THEY HAD A SERVICE ANNOUNCEMENT ON IT, BUT I HAVE NOT SEEN THAT YET. 3. ABOUT THREE WEEKS AFTER I BOUGHT THE TRUCK, I NOTICED A CLICKING AND GRINDING SOUND WHEN THE BRAKES WERE APPLIED LIGHTLY. FIRST TIME IN THE DEALER COULD NOT FIND ANYTHING. SECOND TIME IN THEY FOUND THE LEFT REAR AXLE SEAL LEAKING AND REPLACED THAT. THE THIRD TIME IN THEY ADJUSTED THE BRAKES SO THAT IT WAS ALMOST IMPOSSIBLE TO APPLY LIGHT BREAK PRESSURE. AFTER A COUPLE OF DAYS OF USE THE BRAKES LOOSENED UP SOME AND NOW THE CLICKING AND GRINDING NOISE IS BACK AND IT IS MORE NOTICEABLE WITH EVEN A LITTLE HEAVIER PRESSURE ON THE BRAKES. I WILL BE SCHEDULING A RETURN TRIP FOR THIS AND THE WHINING SOUND IN THE TRANSMISSION, BUT GM SEEMS TO TAKE THE APPROACH THAT IF IT IS "FUNCTIONING" DON'T REPAIR IT. *JB

Mileage: 35,000

DRIVING 50 MPH ON ROAD, I STEPPED ON THE ACCELERATOR PEDAL TO ACCELERATE AND THE VEHICLE ENGINE LIGHT CAME ON. HOWEVER THE VEHICLE WOULD NOT ACCELERATE IT WAS SPITTING AND SPUTTERING AND SLOWED DOWN FOR A WHILE . I PULLED OVER TO THE SIDE OF THE ROAD AND SHUT IT OFF. AFTER TEN MINUTES, THE VEHICLE WAS RESTARTED, AND LIGHT WENT OUT AND IT RAN PERFECTLY. *JB

Mileage: 10,000

I PARKED MY PICKUP TRUCK 2005 CHEV. 2500 HD ON A HILL SIDE IN ORDER TO COLLECT ROCKS TO USE IN CREATING FLOWER BEDS AT HOME. MY WIFE AN I HAD PARKED THE VEHICLE FOR ABOUT 10-15 MINUTES. THE TRUCK WAS PLACED IN PARK WITH THE IGNITION OFF. WE WERE STANDING ABOUT 15 FT FROM THE TRUCK WHEN WE HEARD A LOUD POPPING METALLIC SOUND. THE TRUCK IMMEDIATELY BEGAN TO ROLLED BACK AND TRAVELED ABOUT 20 FEET OR SO BEFORE RUNNING UP AND ONTO A WOOD LOG. I HAVE CONTACTED CHEVROLET AND THEY MADE A COMPUTER CHECK OF THE VEHICLE AND FOUND NOTHING WRONG. I REQUESTED THAT CHEVROLET CHECK THE TRANSMISSION AND STEERING COLUMN. THEY DECLINED. MY WIFE AND I COULD HAVE BEEN SERIOUSLY INJURED BY THE FAILURE OF THE VEHICLE TO STAY IN THE PARKING GEAR POSITION (AUTOMATIC TRANSMISSION). WHAT CAN WE DO TO RECTIFY THIS SITUATION? *JB

Mileage: 34,000

PARKED ON BOAT RAMP, IN PARK WITH E BRAKE ON. BOAT WAS OFF TRAILER (AFLOAT). I WAS UNHOOKING AND WINDING UP FRONT STRAP WHEN I NOTICED TRUCK MOVING BACKWARD INTO LAKE. I WAS ABLE TO JUMP IN AND STOP VEHICLE BY APPLYING SERVICE BRAKES. A TOW CHAIN WAS ATTACHED, I PUT TRANSMISSION INTO DRIVE AND WAS SAFELY BE PULLED OUT. VEHICLE IS A TOTAL LOSS. SHIFT SELECTOR AND E-BRAKE FAILURES? *NM

Mileage: 26,329

AFTER A STOP IN THE PARKING LOT, WITH MY FOOT ON THE BRAKE, SHIFTING FROM DRIVE TO PARK THE VEHICLE WANTED TO JUMP BACKWARDS FOR A SECOND. THIS HAS OCCURRED ON SEVERAL OCCASIONS. IT FEELS LIKE IT WANTS TO GO INTO REVERSE INSTEAD OF PARK. *JB

Mileage: 16,800