2006 CHEVROLET SILVERADO 2500 Service Brakes Problems

THE REAR BRAKES FAILED WITH LITTLE OR NO WARNING. THE BRAKES WENT FROM GOOD TO MUSHY WITHOUT WARNING LIGHT. I ADDED BRAKE FLUID TO TEST IN DRIVE WAY. PUMPED THE BRAKES AND THE WARNING LIGHT CAME ON. THE REAR LINE FAILED. I HAD THE TRUCK INSPECTED AT A GENERAL MOTORS DEALER IN JANUARY OF 2018 AND ALSO AT THE END OF FEBRUARY. THE SAID MY VEHICLE IS MAINTAINED IN EXCELLENT CONDITION. IF THIS COULD HAPPEN TO ME....ALL GM VEHICLES WITH THESE BRAKE LINES ARE AT RISK. I READ THEIR WAS A SAFETY BULLETIN 13-05-22-001. TODAY IS 4/12/2018...BECAUSE I TOW A BOAT TO FLORIDA I HAD THE TRUCK CHECKED 2 TIMES IN THE LAST 12 WEEKS....IF THE DEALERS CAN'T DETECT FAULTY LINES....A RECALL IS NEEDED.

Mileage: 110,000

THE RIGHT FRONT BRAKE LINE ON MY TRUCK RUSTED THROUGH. I LOST BRAKING WHEN LOADING MY 10 FT CAMPER IN THE DRIVEWAY. I TOOK THE TRUCK TO DEALERSHIP AND IT WAS FOUND THAT ALL THE BRAKE LINES ARE RUSTED AND IN DANGER OF FAILURE AT ANY TIME. ALL OF THE BRAKE LINES ON THE TRUCK ARE BARE METAL AND PRONE TO RUST. NEW BRAKE LINES ARE PAINTED TO PREVENT THIS FROM HAPPENING. HAD TO BUY COMPLETE BRAKE LINE KIT TO GET RIGHT FRONT LINE FOR REPLACEMENT BY DEALERSHIP FOR $452.85 . THEY RECOMMEND THAT I REPLACE ALL OF THE LINES. I CALLED CHEVROLET CUSTOMER SERVICE, COMPLAINT # 8-3176545196. I HAVE GOTTEN NO COOPERATION, THEY HAVE TOLD ME THERE IS NOTHING THAT THEY CAN DO. BECAUSE OF THIS POTENTIALLY CAUSING A CATASTROPHIC FATAL ACCIDENT DUE TO COMPLETE OR PARTIAL LOSS OF BRAKING POWER - IT GIVES NO WARNING UNTIL FAILURE OCCURS. I TOLD THEM THEY NEEDED TO PUT OUT AN ALERT TO OTHER DRIVERS AND THEY DECLINED STATING THAT THEY DID NOT HAVE ENOUGH COMPLAINTS. THIS TRUCK ONLY HAS 99546 MILES ON IT AND IN ALL OF MY YEARS WORKING WITH AUTOMOBILES I HAVE NEVER SEEN A BREAK LINE RUST THROUGH.

Mileage: 99,456

SUDDEN FAILURE OF BRAKES DURING LOW SPEED STOP, BRAKE LINE FAILED NEAR FRAME UNDERSIDE IN DRIVER SEAT AREA. WAS ABLE TO QUICKLY STOP VEHICLE WITH EMERGENCY BRAKE JUST SHORT OF GOING INTO HEAVY TRAFFIC. THIS TRUCK IS METICULOUSLY MAINTAINED INCLUDING UNDERSIDE WASHES, NO BODY RUST ANYWHERE AND WAS UNDERCOAT PROTECTED FROM NEW. SHOCKED A LEVEL OF RUST ON WHAT ARE APPARENTLY HIGH CARBON STEEL LINES, THESE SHOULD BE STAINLESS STEEL.

WHEN NORMAL STOPPING ABS ACTIVATES AND KEEPS ACTIVATING UNTIL PEDAL GOES TO FLOOR AND BRAKES DO NO FUNCTION, THERE ARE NO WARNING LITES AND NO INDICATION OF A PROBLEM.I WAS UNDER THE IMPRESSION THAT ANY ABS FAILURE WOULD REVERT SYSTEM TO REGULAR BRAKE SYSTEM. THIS IS VERY DANGEROUS.

Mileage: 49,952

I WAS DRIVING MY TRUCK ON 3/30/16 ANOTHER VEHICLE PULLED OUT IN FRONT OF ME. I SLAMMED ON MY BRAKES TO AVOID A WRECK. AT THE NEXT RED LIGHT I NOTICED MY BRAKES WERE SOFT. I PULLED OVER TO CHECK MY FLUID. IT WAS DOWN ABOUT AN INCH. I DECIDED TO TRY TO MAKE IT HOME. THEN A SERVICE BRAKE LIGHT CAME ON. I DID MAKE IT HOME. I CRAWLED UNDER THE TRUCK AND BRAKE FLUID WAS FROM THE FRONT TO THE BACK OF THE TRUCK. I NOTICED TWO COMPROMISED METAL BRAKE LINES ON THE DRIVER SIDE FRAME RAIL THAT WERE RUSTED THROUGH. I TOUCHED THE LINES AND THEY WERE FALLING APART AND FLAKING OFF METAL AT THE TOUCH. I CONTACTED CHEVROLET AND IT WAS TOWED TO THE DEALER. THEY QUOTED ME $1,100 TO REPAIR THE PROBLEM. MY TRUCK IS A 2006 I BOUGHT IT BRAND NEW IT HAS 59,500 MILES ON IT AND I PAID RIGHT AT $50,000 FOR MY TRUCK. IT IS UNACCEPTABLE FOR THIS TO HAPPEN IN LESS THAN 10 YEARS OF OWNERSHIP. THIS IS A HUGE SAFETY ISSUE SINCE CHEVROLET USED INFERIOR AND CHEAP PRODUCTS IN THEIR TRUCKS. THERE SHOULD BE A RECALL ON THIS. SOMEONE COULD HAVE BEEN SERIOUSLY INJURED OR KILLED THE OTHER DAY WHEN I WAS DRIVING. I REPLACED ALL OF THE ROTORS AND BRAKE PADS AND ONE CALIPER NOT 9 MONTHS AGO. I NEVER THOUGHT THAT MY METAL LINES WERE COMPROMISED UNTIL I HAD A FAILURE. I HAVE LOST ALOT OF FAITH IN GM DUE TO THIS ISSUE. I AM STILL WORKING WITH GM AND THE DEALER TO GET THE PROBLEM RESOLVED, BUT IT IS NOT LOOKING GOOD. I AM WONDERING HOW MANY OTHER VEHICLES ARE COMPROMISED. I WAS TALKING TO MY UNCLE THE OTHER DAY AND A GENTLEMAN OVERHEARD MY CONVERSATION. HE TOLD ME THAT HE HAD A 2003 2500 CHEVROLET THE BRAKES ALSO FAILED ON. HE WAS TOWING A TRAILER AND TOATLED HIS TRUCK. I AM COMPLETELY OUT OF WARRANTY AS OF NEXT MONTH. GM SAYS TO KEEP MY BILL FOR THE REPLACEMENT OF THE LINES THAT I MAY GET PAID BACK. I DONT THINK THAT IS LIKELY AT ALL. THIS SHOULD BE A RECALL BECAUSE SAFETY IS COMPROMISED.

Mileage: 59,500

BREAK LINES ARE COMPLETELY RUSTED AND I AM AFRAID THEY WILL GO OUT WITHOUT WARNING. TRUCK ONLY HAS 67,000 MILES ON IT.

BRAKE LINE FAILURE DUE TO EXCESSIVE CORROSION AS THE LINES LAY ON THE FRAME. LUCKILY, THE BREAK WAS AT HOME AND I WAS ABLE TO GET IT INTO THE SHOP FOR REPAIR. LESS THAN A MONTH LATER, ANOTHER LINE BROKE AS I WAS PULLING INTO MY DRIVE.

Mileage: 138,000

LOST BRAKES WHILE DRIVING IN RESIDENTIAL NEIGHBORHOOD DUE TO RUSTED BRAKE LINE. HAD IT TOWED TO MY MECHANIC WHO DID AN INSPECTION AND SAID ALL THE BRAKE LINES WERE RUSTED AT THE BRACKETS HOLDING THE LINES. MY MECHANIC IS IN THE PROCESS OF REPLACING THE BRAKE LINES. I TALKED TO SEVERAL OTHER PEOPLE WITH THE SAME YEAR TRUCK AND BOTH HAD ALSO EXPERIENCED BRAKE LINE FAILURE FROM RUST. TRUCK HAS ONLY 20K MILES AND HAS ONLY BEEN IN THE SALT TWICE AS I HAD AN OLDER VEHICLE I USED WHEN IT SNOWED. GM NEEDS TO CORRECT THIS SAFETY DEFECT.

Mileage: 20,000

ONE BRAKE LINE BURST FROM BEING RUSTED OUT AND THE REMAINING 4 FRONT BRAKE LINES ARE IN BAD SHAPE AND NEED TO BE REPLACED. THE BRAKE LINE BURST WHILE I WAS PULLING MY BOAT TRAILER AND I NARROWLY AVOIDED AN ACCIDENT. I WAS IN A RESIDENTIAL AREA AND WAS ONLY GOING ABOUT 15MPH.AND WAS ABLE TO APPLY THE EMERGENCY BRAKE TO STOP THE TRUCK.

Mileage: 110,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE PULLING INTO THE DRIVEWAY AT APPROXIMATELY 7 MPH, THE BRAKE PEDAL WAS DEPRESSED TO THE FLOOR BUT THE VEHICLE DID NOT STOP. THE VEHICLE CRASHED INTO THE CONTACT'S PORCH. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE CONTACT OBSERVED BRAKE FLUID UNDER THE FRONT OF THE VEHICLE AND THE BRAKE LINES WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. MA 09/03/15 UPDATED 11/03/2017*CN

Mileage: 70,000

HOLE CAME IN BREAK LINE DUE TO RUST. ALL MOST RAN THRU A BUSY INTERSECTION. ALSO HAD A BREAK LINE TO RUST INTO ON 4/10/15.

Mileage: 54,908

WE WERE GETTING READY FOR A LONG TRIP (MARYLAND TO FLORIDA). WE HITCHED OUR TRAILER TO OUR TRUCK AND WERE TESTING LIGHTS, BRAKES, ETC. AT THE CAMPGROUND BEFORE WE LEFT. AS WE TESTED THE BRAKES AT A LOW SPEED, WE REALIZED THE BRAKES DID NOT WORK AT ALL. WE PARKED IT RIGHT THERE ON THE ROAD IN THE CAMPGROUND AND CALLED A TOW TRUCK TO TAKE US TO OUR MECHANIC'S SHOP. WHEN HE LOOKED AT IT, HE FOUND HE HAD TO REPLACE ALL THE BRAKE TUBING BECAUSE THEY WERE ALL RUSTED OUT. HAD WE BEEN ON THE ROAD WITH OUR TRAILER, WE WOULD HAVE HAD A CRASH AND COULD HAVE BEEN KILLED OR SEVERELY HURT.

Mileage: 106,061

ENGINE IDLER PULLEY SEIZED CAUSING SERPENTINE BELT TO BREAK WHICH RESULTED IN LOSS OF POWER STEERING AND LOSS OF POWER BRAKES..2 LOCAL GM DEALER PARTS DEPARTMENT'S STATED THIS IS COMMON ON THE DURAMAX DIESEL ENGINE. *TR

Mileage: 52,601

I WAS POSITIONING MY CHEVY SILVERADO 2500 YEAR 2006 TO HOOK UP MY TRAVEL TRAILER RV. AS I WAS BACKING UP TO LINE UP THE HITCH TO THE RV BALL THE BRAKE PEDAL WENT TO THE FLOOR AND I LOST ALL BRAKING. I HAD TO PUT THE GEAR SHIFT IN PARK TO STOP THE SLIGHT ROLL. I LOOKED UNDER THE TRUCK AND THERE WAS BRAKE FLUID ALL OVER MY DRIVEWAY WHERE IT HAD COME OUT OF A CORRODED BRAKE LINE UNDER THE DRIVERS SEAT. THIS TRUCK ONLY HAS 97,797 MILE ON IT. I AM VERY FORTUNATE THAT THE CORRODED BRAKE LINE FAILED BEFORE I WAS ABLE TO HOOK UP THE RV AND START DRIVING, I COULD HAVE HAD A SERIOUS ACCIDENT THAT MIGHT HAVE KILLED SOMEONE. *TR

Mileage: 97,797

WHILE I WAS DRIVING DOWN THE STREET MY BRAKES WHEN OUT. I WAS ABLE TO MAKE IT TO MY DRIVEWAY TO DISCOVER MY BRAKE LINE RUTSTED AND THERE WAS A 1 CM HOLE IN THE BRAKE LINE. *TR

Mileage: 88,981

I HAD A BRAKE LINE BRAKE DRIVING MY BABY TO THE DOC, TOWED IF TO THE SHOP & FOUND OUT ALL THE BRAKE LINES & HARDWARE WERE RUSTED BEYOND REPAIR & EVERYTHING NEEDED REPLACED, WE FOUND THAT GM HAD USED BAD PRODUCTS ON THEIR CHEVY TRUCKS FROM 99-07 BUT ONLY RECALLED 99-03, APPARENTLY THERE'S NOT ENOUGH DEATHS IN MODEL YEARS 04-07 TO RECALL, WELL IF WE WERE GOING FASTER IT PROB WOULDN'T HAVE ENDED WELL FOR US, THE COST OF THE REPAIRS WERE AROUND $700. *TR

Mileage: 199,999

DURING A NORMAL STOP AT A LIGHT, JUST AS THE VEHICLE WAS GETTING CLOSE TO A COMPLETE STOP THERE WAS A NOTICEABLE BUMP FELT IN THE BRAKE PEDAL AND RELEASE OF BRAKE APPLICATION ON ITS OWN WHILE STILL PUSHING ON THE BRAKE PEDAL. THIS OCCURRED AS VEHICLE WAS SLOWING, JUST BEFORE A COMPLETE STOP WAS ACHIEVED . AFTER RESEARCHING THE PROBLEM WHICH SEEMS TO BE WELL KNOWN IN AUTOMOTIVE FORUMS AND BY GM. I REMOVED THE FRONT WHEEL SPEED SENSORS, CLEANED THE CORROSION FROM THE MOUNTING PADS AND REASSEMBLED. BEFORE CLEANING THE SENSOR MOUNTING THE PROBLEM WOULD OCCUR 80-90% OF THE TIME BRAKES WERE APPLIED. AFTER CLEANING IT HAS NOT HAPPENED AGAIN. THERE IS A RECALL ON THIS VERY ISSUE ON EARLIER YEAR MODELS, CLEARLY THIS NEEDS TO BE EXPANDED TO MORE MODEL YEARS. IF SOMEONE HAD BEEN IN FRONT OF ME WHEN THIS OCCURRED THERE IS A VERY GOOD POSSIBILITY I WOULD HAVE HIT THE BACK OF THEIR VEHICLE. *TR

Mileage: 52,000

DRIVING ON HIGHWAY AT 60MPH TRAFFIC SLOWED SUDDENLY WHILE PRESSING DOWN ON BRAKES WHEN TO FLOOR I SWERVED TO AVOID SLOWING TRAFFIC AND RAN OFF SHOULDER IN TO GRASS AND SMALL TREES TO COME TO A STOP HAD TRUCK TOWED TO MY HOUSE FOUND LINE OVER GAS TANK SPLIT OPEN THEIR WAS NO PEDAL AT ALL AND NO WARNING LIGHT FOR BRAKES UNTIL ALL THE FLUID DRIPPED OUT IN TO MY DRIVEWAY. *TR

Mileage: 38,028

BRAKE LINES HAVE RUSTED OUT. ABS WARNING LIGHT CAME ON, THEN SOON AFTER ABS SERVICE LIGHT CAME ON. HAD TO REPLACE ALL OF THE LINES AND 3 CALIPERS WHERE LINES HAD RUSTED TO THE CALIPER. VEHICLE ONLY HAS 41200 MILES ON IT. COST ME $861 TO HAVE THEM REPLACED. SERVICE TECHNICIAN SAID HE HAD NEVER SEEN LINES THAT WERE THAT BAD FOR A VEHICLE WITH SUCH LOW MILEAGE. ONE OF THE LINES CRUMBLED AT THE TOUCH WHEN IT WAS REMOVED. *TR

Mileage: 41,200

BRAKE LINES BLEW FRONT AND REAR WHEN A MOTORCYCLE IN FRONT OF ME SLAMMED HIS BRAKES IN AN EMERGENCY STOP. LUCKILY HE WAS TOWARDS THE SIDE OF THE ROAD, I SLAMMED MY BRAKES AND MY PEDAL WENT TO THE FLOOR, I QUICKLY SWERVED AND DOWNSHIFTED AND EBRAKED AND MIRACULOUSLY WAS ABLE TO COME TO A SWERVING STOP AVOIDING COLLISION BUT IT COULD HAVE BEEN MUCH WORSE IF I HADN'T BEEN ABLE TO REACT SO QUICKLY. MY TRUCK IS VERY LOW MILEAGE AND METICULOUSLY MAINTAINED, I HAVE OWNED IT SINCE 2009. THERE AREN'T ANY OTHER CARS OUT THERE THAT WOULD HAVE A BRAKE LINE FAILURE WITHIN 8 YEARS AND ONLY 64K MILES, I'M VERY UPSET OVER WHAT HAPPENED. *TR

Mileage: 64,000

BRAKES LINES RUSTY PRESSED BRAKE PEDAL BRAKES FAILED. *TR

Mileage: 127,357

BRAKE LINES FAILED, CAUSING ME TO RUN OFF THE ROAD WHEN TRYING TO AVOID HITTING A DEER. HAD TO REPLACE ALL THE LINES DUE TO CORROSION ON MANY OF THEM. *TR

Mileage: 120,101

MY WIFE WHILE DRIVING THE ABOVE TRUCK STATED THAT THE BRAKE PEDDLE "FELT FUNNY" AND CONTINUED TO DRIVE IT. SHE STATED THAT SHE HAD ALMOST COMPLETELY LOST THE ABILITY TO STOP. WHEN I WAS ABLE TO INSPECT THE TRUCK I FOUND A RUPTURED BRAKE LINE THAT LEAD TO THE REAR BRAKES. ALSO ALL THE BRAKE FLUID HAD LEAKED OUT OF THE RUPTURED LINE. I HAVE SINCE HAVE HAD ALL THE BRAKE LINES REPLACED WITH STAINLESS STEEL LINES. I AM LEARNING THAT THIS IS AN ON GOING ISSUE WITH THIS MODEL OF TRUCK AND MY CONCERN SHOULD BE OBVIOUS. MY WIFE COULD HAVE SERIOUSLY INJURED HERSELF OR OTHERS. *TR

Mileage: 81,000

I WAS IN FAST LANE ON HIGHWAY APPROACHING SOME CONSTRUCTION AND WAS CUT OFF BY SOMEONE WHO PASSED ME ON THE RIGHT . I STEPPED HARD ON MY BRAKES AND THE PEDAL WENT ALL THE WAY TO THE FLOOR . . I HIT THE PERSON IN FRONT OF ME AND RUINED MY FRONT BUMPER. UPON INSPECTION OF MY VEHICLE I NOTICED BRAKE FLUID DRIPPING FROM FRAME RAIL . .I LOOKED AND NOTICED A LINE RUPTURED DUE TO RUST / ROT AND ALL THE BRAKE LINES WHERE IN BAD CONDITION . I WAS ABLE TO CRUTCH THE TRUCK TO A REPAIR SHOP AND THE REPAIRED THE STEEL LINE. MECHANIC MADE ME AWARE OF THE TERRIBLE CONDITION ALL THE STEEL LINES WERE IN ( FUEL LINES, TRANSMISSION LINES,ECT) AND THAT THE BRAKE BLEEDERS ON FRONT CALIPERS WHERE ALSO ROTTED BEYOND SAVING . . I BELIEVE ALL THESE LINES SHOULD HAVE BEEN STAINLESS STEEL AS THEY ARE EXPOSED TO THE ELEMENTS AND I'M LUCKY TO HAVE NOT TOTALED THE TRUCK , INJURED SOMEONE ELSE AND OR MYSELF. *TR

Mileage: 110,000

RUSTED BRAKE LINES 1 HAS RUPTURED. *TR

Mileage: 104,000

MASTER CYLINDER RESERVOIR FLUID LEVEL DROPPED FROM FULL TO ACTIVATION OF BRAKE SERVICE LIGHT. INVESTIGATION OF THE CAUSE LED TO THE DISCOVERY A LEAK IN THE BRAKE LINE FROM THE ANTI LOCK BRAKE ACTUATOR TO THE RIGHT FRONT BRAKE CALIPER. ALL THE BRAKE LINES APPEAR TO BE EXTENSIVELY CORRODED. *TR

Mileage: 47,850

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE BRAKES FAILED AND THE EMERGENCY BRAKE HAD TO BE USED TO STOP THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC, WHO ADVISED THAT THE BRAKE LINES WERE RUSTED. THE MECHANIC REPLACED ONE OF THE FUEL LINES. THE CONTACT DID NOT CALL THE MANUFACTURER. THE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

I WAS PREPARING TO SLOW DOWN AS I APPROACHED MY DRIVEWAY. WHEN I APPLIED MY VEHICLE'S BRAKES, THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR. MY VEHICLE DID NOT SLOW DOWN AND I HAD TO UTILIZE ME EMERGENCY BRAKE AND ALSO SHIFT INTO A LOWER GEAR IN ORDER TO SLOW DOWN. I WAS UNABLE TO SLOW DOWN ENOUGH TO SAFELY MAKE A TURN AND SUBSEQUENTLY MY VEHICLE TRAVELLED THRU A DITCH AREA AND CAME TO A STOP IN MY FRONT YARD. COMPLETING A CHECK OF MY VEHICLE'S BRAKE SYSTEM, I LEARNED THAT MY MASTER CYLINDER WAS COMPLETELY EMPTY. I HAD MY VEHICLE TOWED TO A LOCAL GARAGE WHERE I WAS TOLD THE VEHICLE'S COMPLETE BRAKING SYSTEM LINES HAD RUSTED AWAY CAUSING ALL BRAKE FLUID LOSS AND NEEDED TO BE REPLACED. ALL BRAKES LINES WERE REPLACED FROM THE MASTER CYLINDER TO THE ABS MODULE AND THEN TO EACH BRAKE SYSTEM AT THE WHEEL. THE COST OF THE WORK WAS $598.00. MY VEHICLE IS A 2006 MODEL YEAR AND IS IN EXCELLENT SHAPE, HOWEVER I'M VERY UNHAPPY WITH THE BRAKING FLUID LINES FAILING WITH ONLY 52,500 MILES ON MY VEHICLE. I DON'T UNDERSTAND WHY THERE HAS BEEN NO SAFETY RECALL NOTICE ON THE PART OF GENERAL MOTORS. THE LOCAL DEALERSHIP REFUSED TO ASSIST ME WITH THE MATTER AND AT THIS TIME I'M COMPLETING THIS COMPLAINT. THE NATIONAL HIGHWAY TRANSPORTATION SAFETY ADMINISTRATION NEEDS TO TAKE IMMEDIATE ACTION UPON GENERAL MOTORS TO ENSURE HIGHER QUALITY OF BRAKE LINES ARE INSTALLED INSTEAD OF SUBSTANDARD BRAKE LINES. I WAS LUCKY THAT I WAS NOT INVOLVED IN A MORE SERIOUS ACCIDENT/INCIDENT WITH THE BRAKES FAILING. I WOULD ALSO LIKE TO SEE GENERAL MOTORS REIMBURSE ME IN FULL FOR THE COST OF THE REPAIRS. *TR

Mileage: 52,500

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED WHILE DRIVING 20 MPH, HE DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE DID NOT STOP IMMEDIATELY. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000. THE VIN WAS UNAVAILABLE.

Mileage: 52,000

WHILE STOPPING FOR TRAFFIC LIGHT, BRAKES WERE WEAK AND REQUIRED EXCESSIVE PRESSURE TO ACTIVATE ENOUGH TO STOP VEHICLE. PULLED INTO NEAREST PARKING LOT AND FOUND BRAKE FLUID DRIPPING FROM CHASSIS UNDER DRIVER DOOR AREA. CALLED TOW TRUCK TO TAKE VEHICLE TO DEALER. TRIED TO MOVE VEHICLE TO MAKE IT EASIER FOR TOW TRUCK OPERATOR TO HOOK UP AND PEDAL WENT COMPLETELY TO FLOOR WITH NO BRAKING EFFECT. USED PARKING BRAKE TO STOP. DEALER SAID ENTIRE BRAKE SYSTEM NEEDS TO BE REPLACED DUE TO CORROSION. *TR

Mileage: 47,000

BRAKE LINE FAILURE. RUSTY BRAKE LINES. LEAVING FLUID ON GROUND ALMOST HITTING BUILDING. *TR

Mileage: 81,263

DRIVING HOME FROM STORE ONLY TO HAVE A VEHICLE STOP SHORT IN FRONT OF ME. APPLIED BRAKES AND TO MY SURPRISE THE PEDAL WENT TO THE FLOOR. LUCKILY I HAD ROOM TO MANEUVER AROUND TRAFFIC AND AVOID AN ACCIDENT. VEHICLE WAS TOWED TO REPAIR SHOP AND I WAS TOLD LEFT FRONT BREAK LINE RUSTED OUT. I PURCHASED THIS VEHICLE NEW AND I CAN ATTEST THAT NO UNUSUAL CIRCUMSTANCES OCCURRED TO WARRANT BRAKE LINE RUSTING OUT. MOVING FORWARD 16 MONTHS I WAS LEAVING THE HOUSE ONLY TO HAVE BRAKES GO TO THE FLOOR. VEHICLE TOWED TO CHEVY DEALER. DEALER TELLS ME ALL BRAKE LINES RUSTED BADLY (EXCEPT ONE PREVIOUSLY REPLACED) AND IN NEED OF REPLACEMENT TO THE TUNE OF $2700.00. GOOD THING I WAS NOT DRIVING OR WORSE YET PULLING MY 8000 POUND CAMPER. IS IT GOING TO TAKE SOME ONE GETTING KILLED BEFORE CHEVY IS MADE TO ADMIT THEY HAVE A SERIOUS SAFETY ISSUE WITH THESE BRAKE LINES. *JS

Mileage: 45,448

WE HAD JUST GOTTEN TO THE BOTTOM OF A HILL WHEN WE APPLIED THE BRAKES THE PEDAL FELT NORMAL THEN INSTANTLY IT WENT TO THE FLOOR. WE ATTEMPTED TO PUMP THE BRAKES BUT THE PEDAL WAS COMPLETELY TO THE FLOOR. WHEN WE FINALLY WERE ABLE TO STOP WE JUMPED OUT AND SAW BRAKE FLUID PUDDLE ON THE GROUND AND ALL UNDERNEATH THE CAB OF THE TRUCK. AFTER THE FLUID WAS GONE THERE WAS ABSOLUTELY NO BRAKES TO EVEN PANIC STOP. THERE IS ALSO EXTENSIVE RUST UNDER THE TRUCK EVEN THOUGH UNDERCOATING WAS APPLIED IN THE FACTORY. *TR

Mileage: 31,000

TOWING TRAILER, WHILE PARKING TRAILER, BRAKE PEDAL GOT SPONGY, THEN WENT TO FLOOR, TOTAL BRAKE LOSS. RUSTED BRAKE LINE RUPTURED UNDER DRIVERS SEAT BY ABS MODULE, ALL BRAKE LINES WILL NEED REPLACEMENT. *TR

Mileage: 63,000

VEHICLE UNDER CARRIAGE LOOKS MORE LIKE A 30 YEAR OLD VEHICLE. BRAKES LINES HAVE FAILED CAUSING EXTENDED STOPPING DISTANCE OR SWERVING OFF ROAD TO AVOID COLLISION. OIL COOLER LINED RUPTURED AND LEAKED OIL ON EXHAUST MANIFOLD, A POTENTIAL FIRE HAZARD, ESPECIALLY WHEN ALL THE EXHAUST MANIFOLDS ROTTED AS WELL SO HOT EXHAUST GASES ARE NOT DIRECTED OUT THE EXHAUST, ALSO A CONCERN FOR POISONING OCCUPANTS WITH TOXIC EXHAUST GASES . POWER STEERING FITTINGS ROTTED CAUSING LOSS OF STEERING. GM IS USELESS, WHEN I CONTACTED THEM THEY SAID IT IS THE ENVIRONMENT. I ASKED THEM WHY A TOYOTA AND ACURA, BOTH 8 YEARS OLDER SHOWED NO SUCH FAILURES OR EVEN SIGNS OF RUST ON CRITICAL COMPONENTS. GM RESPONDED THAT THEY COULDN'T ANSWER THAT QUESTION. HMMM, I WONDER WHY. IN 39 YEARS OF DRIVING, IT IS THE MOST I EVER PAID FOR A VEHICLE, 48,000 DOLLARS, AND THE MANUFACTURER REFUSES ANY ASSISTANCE. THAT'S THE THANKS FOR BAILING THEM OUT. IT HAS ALSO HAD WIRES TO BLOWER MOTOR BURN, REAR BRAKE ROTORS ROTTED AWAY AT 22,000 MILES, GROUND WIRES UNDER HOOD HAVE ROTTED AND FALLEN OF... MORE POTENTIAL HAZARDS, A/C COMPRESSOR SEIZED A CAME APART. I COULD GO ON AND ON. THERE NEEDS TO BE A SERIOUS INVESTIGATION INTO GM AND.THE POOR QUALITY AND LACK OF CONCERN FOR THE SAFETY OF THE PUBLIC. IT IS BY FAR THE WORST VEHICLE I HAVE OWNED, EVER. *TR

Mileage: 32,320

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE SHIFTING INTO DRIVE, THE BRAKES AND THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 89,000. *TR

Mileage: 89,000

AT THE WORST POSSIBLE TIME WITH ICY ROADS AND SNOW. I WAS ON MY DRIVEWAY TRYING TO GET TO THE TOP OFF IT WHEN I LOST TRACTION. I STOPPED AND APPLIED THE BRAKES. I STARTED TO BACK DOWN THE DRIVE WHEN THE PEDDLE FELL TO THE FLOOR CAUSING THE TRUCK TO GO VIOLENTLY OUT OF CONTROL AND CRASH DOWN OVER AN EMBANKMENT. THERE WAS NO WARNING, JUST TOTAL LOSS OF BRAKES BOTH FRONT AND REAR. MECHANIC SAYS THE LINES BLEW APART FROM RUST. *TR

Mileage: 65,500

BRAKE PEDAL WENT ALMOST TO FLOOR. AFTER INSPECTION METAL BRAKE LINE WAS RUSTED AND HAS HOLE IN LINE RESULTING IN LOSS OF FLUID. *TR

Mileage: 25,866

FIRST TIME BRAKE LINE BROKE AT DEALERS PARKING LOT. LINE REPAIRED TWO WEEKS LATER WHILE STOPPING FOR RED LIGHT ANOTHER BRAKE LINE RUPTURED MONTH LATER WHILE ATTEMPTING TO STOP FOR VEHICLE STOPPED IN FRONT ANOTHER BRAKE LINE BURST MINOR COLLISION NO DAMAGE. DEALER AT THIS TIME REPLACED ALL BRAKE LINES IN VEHICLE AS I REFUSED TO OPERATE THE VEHICLE WITHOUT EVERY LINE REPLACED PERIOD. *TR

Mileage: 75,000

AS I APPROACHED A STOP SIGN, I APPLIED THE BRAKES AND THE BRAKE PEDAL WENT SOFT AND THEN TO THE FLOOR. IMMEDIATELY FOLLOWED BY A BRAKE SYSTEM WARNING AND A BRAKE LIGHT ON THE INSTRUMENT PANEL. I GOT THE VEHICLE STOPPED ON THE SIDE OF THE ROAD AND CHECKED THE BRAKE FLUID RESERVOIR. IT WAS EMPTY. IT HAD BEEN SNOWING THAT DAY AND I NOTICED A PUDDLE OF FLUID HAD FORMED IN THE FRESH SNOW UNDER THE DRIVER'S SIDE OF THE VEHICLE, JUST INBOARD AND AFT OF THE FRONT LEFT WHEEL. WHEN I CRAWLED UNDERNEATH AND LOOKED I FOUND WHAT APPEARS TO BE SEVERELY ROTTED BRAKE LINES. I HAVE NEVER HAD A SOLID BRAKE LINE FAIL ON ME BEFORE AND WAS QUITE SHOCKED AT HOW PROGRESSED THE CORROSION WAS. I TAKE CARE OF MY TRUCK AND IT GETS WASHED AND SERVICED REGULARLY. WITH THAT IT GETS USED AS A TRUCK AS WELL. I FEEL THAT THE CORROSION WAS EXCESSIVE AND PERHAPS IS THE RESULT OF A MATERIAL FLAW/CHEAP MATERIALS USED. I SHUDDER TO THINK WHAT THE OUTCOME WOULD HAVE BEEN HAD I BEEN TOWING MY HORSE TRAILER OR MY CAMPER THAT DAY. *TR

Mileage: 75,862

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 HD. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN FOR ROUTINE MAINTENANCE WHEN HE WAS ADVISED THAT THE BRAKE LINES WERE RUSTED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOTIFIED AND STATED THAT THE FAILURE WAS A COMMON PROBLEM IN THE PARTICULAR MODEL HOWEVER, A RECALL HAD NOT BEEN ISSUED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 71,000.

Mileage: 71,000

WHEN COMING TO A STOP A SPEEDS OF 10 MPH OR LESS, BRAKE PEDAL GOES TOWARDS THE FLOOR AS IF THE ABS IS ACTIVATING, CAUSING LOSS OF BRAKING. IT OCCURS ON ALL TYPES OF DRIVING SURFACES AND IN ALL WEATHER CONDITIONS. PROBLEM HAS GOTTEN WORSE WITH TIME. DEALERSHIP SAYS THERE IS NO KNOWN PROBLEM... HOWEVER THE INTERNET SAYS DIFFERENTLY! PROBLEM OCCURS ALMOST EVERY TIME YOU ARE MAKING A SLOW APPROACH TO A STOP, WHICH IS USUALLY WHEN OTHER VEHICLES OR PEDESTRIANS ARE IN FRONT OF YOU. *TR

Mileage: 30,000

REAR BRAKE LINE FAILED DUE TO HEAVY CORROSION CAUSING LOSS OF BRAKE FLUID AND EXTREMELY REDUCED BRAKE PERFORMANCE. *TR

Mileage: 73,000

I PURCHASED 2006 SILVERADO NEW AND AFTER THE 1ST YEAR NOTICED RUSTING. JUST BEFORE IT CAME OFF WARRANTY (2009) THE COOLANT LINE FROM THE RADIATOR AND THE BRAKE ROTORS (FRONT AND REAR) HAD RUSTED THROUGH. HAVE SINCE REPLACED THE ROTORS AGAIN AND NOW MY BRAKE LINE BURST OPEN AS I WAS DRIVING HOME. ENTIRE UNDERCARRIAGE IS RUSTED (FRAME IS PEELING UP IN LAYERS), THERE IS RUST COMING THROUGH THE BUMPERS, ON THE WHEELS, IN THE BED, INSIDE THE DRIVER'S DOOR - BASICALLY EVERYWHERE I LOOK (I FILED A COMPLAINT WITH CHEVROLET IN 2010 ABOUT THE EXCESSIVE RUSTING AND WAS TOLD, AFTER INSPECTION BY LOCAL DEALER, THAT THERE WAS "NO ABNORMAL RUSTING FOUND"). I BABY THIS TRUCK (IT ONLY HAS 26,000 MILES AND IS NOT DRIVEN ON THE ROADS WHEN THEY ARE SALTED) AND KEEP IT VERY CLEAN. I AM AFRAID FOR MY SAFETY AS I DO NOT KNOW WHAT IS GOING TO FAIL NEXT. TODAY I SPOKE WITH CHEVROLET AGAIN ABOUT THE BRAKE LINES, AGAIN INSPECTED AT THE LOCAL DEALER, AND WAS TOLD THAT IT WAS "NORMAL WEAR AND TEAR" AND CAUSED BY ENVIRONMENTAL CONDITIONS. IN ADDITION, I WAS TOLD THAT THE ROTORS AND CALIPERS ARE RUSTED THROUGH AND MUST BE REPLACED. HOW IS IT POSSIBLE TO CONCLUDE THAT THE CORROSION IS DUE SOLELY TO ENVIRONMENTAL FACTORS AND NOT AT ALL DUE TO MATERIAL CHOICE AND LACK OF APPROPRIATE COATING? I AM ONLY ASKING THAT THEY COVER THE REPLACEMENT OF THE BRAKE LINES AND THEY DO NOT FEEL OBLIGATED TO DO SO. THEY DO NOT BELIEVE IT IS POOR DESIGN OR SUBPAR MATERIALS. (NEITHER OF MY OTHER TWO VEHICLES, 1993 TOYOTA PICKUP AND 2004 VOLVO, SHOW RUSTING OF THE UNDERCARRIAGE TO THE SAME DEGREE AS THE SILVERADO AND THE BRAKE LINES OF BOTH OTHER VEHICLES ARE COMPLETELY INTACT. ALL THREE VEHICLES HAVE BEEN SUBJECTED TO THE SAME ENVIRONMENTAL CONDITIONS.) *TR

Mileage: 26,000

WE BROUGHT OUR 2006 CHEVROLET SILVERADO WITH AROUND 73,000 MILES ON IT TO A REPAIR SHOP FOR A TUNE UP AND WE WERE TOLD THE FOLLOWING: 'THE FUEL LINES ARE VERY RUSTED (STARTING TO SEEP BACK BY THE TANK AREA) THE BRAKE LINES ARE VERY RUSTED, THE TRUCK WILL NEED REAR BRAKES VERY SOON, ALL BRAKE HOSES WILL NEED TO BE REPLACED, THE BLEEDERS ON CALIPERS ARE RUSTED OUT, THE SHIMMY SHOCK IN THE FRONT END IS BLOWN APART, HAS A LOT OF PLAY IN THE IDLER ARM, FRONT SHOCKS RUSTED & LEAKING, REAR SHOCKS RUSTED, REAR END COVER RUSTED, THE TRANSFER CASE TAIL SHAFT IS LEAKING, THE FRAME IS RUSTED & GETTING THIN IN SPOTS, HAS AT LEAST THREE BROKEN EXHAUST MANIFOLD STUDS' WE UNDERSTAND THAT BRAKE PADS AND CALIPERS ARE USUAL REPAIRS AND MAINTENANCE. HOWEVER, THE VEHICLE IS ONLY SIX YEARS OLD AND THE TRUCK SHOULD NOT BE VERY RUSTED. WE CALLED CHEVROLET AND OPENED A CASE TO REVIEW THE RUST ISSUES. WE BROUGHT THE TRUCK TO A DEALERSHIP AS REQUESTED BY CHEVROLET FOR A VISUAL INSPECTION. USING DOCUMENT ID #2758961, THE TECHNICIANS DETERMINED 'NO REPAIR OR CONSIDERATION SHOULD BE GIVEN FOR THIS CONCERN - SURFACE CORROSION ON UNPROTECTED COMPONENTS WILL VARY WITH AGE AND EXPOSURE. CORROSION ON THESE COMPONENTS WILL VARY WITH AGE AND EXPOSURE. CORROSION ON THESE COMPONENTS HAS NO DETRIMENTAL IMPACTS, EITHER IN SHORT OR LONG TERM DURABILITY." HOWEVER, THEY EXPLAINED THAT IF THEY WERE US, THEY WOULD REPLACE THE BRAKE AND FUEL LINES. THE CHEVROLET CASE WORKER CALLED THE DEALER AND CONFIRMED THE FINDINGS. HE EXPLAINED TO US THAT THE RUST WAS DUE TO ENVIRONMENTAL FACTORS AND NORMAL WEAR AND TEAR. WE TRIED TO GET A DEFINITION OF ENVIRONMENTAL FACTORS, HOWEVER THE WORKER WOULD NOT EXPLAIN FURTHER. . THE TRUCK RESIDES IN THE NORTH EAST; IT IS SUBJECTED, AS ALL VEHICLES ARE, TO MANY ENVIRONMENTAL FACTORS EVERY DAY. *TT

Mileage: 73,298

I WAS LEAVING THE DOWNTOWN AREA OF CLEVELAND, OHIO, AND I WAS IN THE LANE TO GET ONTO 77 SOUTH. THE LIGHT TURNED GREEN, THE 4-5 VEHICLES IN FRONT OF ME STARTED GOING THROUGH THE INTERSECTION, THE FIRST ACCELERATED INTO THE ADJACENT LANE TO REVEAL CONSTRUCTION CONES IN OUR LANE. THE REMAINING VEHICLES IN FRONT OF ME SLAMMED ON THEIR BRAKES AND I SLAMMED ON MINE. AT THAT INSTANT, MY BRAKE PEDAL SUNK TO THE FLOOR. I REACTED QUICKLY (THANK GOD) AND SWERVED LEFT TO AVOID THE COLLISION. MY TRUCK CAME TO REST ABOUT 10 FEET PAST THE SMALL SEDAN IN FRONT OF ME. I WOULD HAVE WRECKED THE BACK OF THAT CAR AND CAUSED A CHAIN REACTION IN FRONT AND BACK OF ME HAD I NOT BEEN ABLE TO REACT AS QUICKLY AS I HAD. THE REPLACEMENT OF ALL THE BRAKE LINES (THE ONE LEAKING IS AS CORRODED AS THE OTHERS) PLUS FRONT BRAKE WORK IS GOING TO COST ME AROUND $3800. NOT SOMETHING I WAS EXPECTING FROM A 6 YEAR OLD TRUCK, NOR ANYTHING I CAN AFFORD RIGHT NOW. IT IS MY WORK TRUCK, I DON'T HAVE A CHOICE, AND IT'S MORE OF A REPAIR THAN I FEEL COMFORTABLE TACKLING ON MY OWN. CHEVY NEEDS TO STEP UP AND SHOULDER SOME RESPONSIBILITY. I HAVE HAD TWO OTHER TRUCKS IN THIS CLIMATE AND NEVER SAW THE LINES CORRODE LIKE THIS. *TT

Mileage: 65,000