This Problem Across All Years
TL*THE CONTACT OWNS A 1999 CHEVROLET C3500 DIESEL TRUCK. WHILE DRIVING APPROXIMATELY 30 MPH THE VEHICLE STALLED. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD. THE CONTACT STATED THAT SHE WAITED APPROXIMATELY 15 MINUTES AND THE VEHICLE STARTED. THE FAILURE WAS INTERMITTENT. CHEVROLET REPLACED THE ENGINE IN MAY OF 2002 AT 63,000 MILES. IN JULY 2003, THE DEALER REPLACED THE FUEL INJECTIONS AT 67,000 MILES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES FOR OF THE FAILURE. THE VEHICLE WAS AT AN AUTHORIZED DEALER WHEN THE REPORT WAS FILED. THE DEALER ORDERED A FUEL PUMP FOR THE VEHICLE BUT THE MANUFACTURER WOULD NOT PAY FOR IT. THE FAILURE MILEAGE WAS 62,000 AND THE CURRENT MILEAGE WAS 75,000 MILES.
TL*THE CONTACT OWNS A 1999 CHEVROLET C3500 DIESEL TRUCK. WHILE DRIVING APPROXIMATELY 30 MPH THE VEHICLE STALLED. THE VEHICLE WAS PUSHED TO THE SIDE OF THE ROAD. THE CONTACT STATED THAT SHE WAITED APPROXIMATELY 15 MINUTES AND THE VEHICLE STARTED. THE FAILURE WAS INTERMITTENT. CHEVROLET REPLACED THE ENGINE IN MAY OF 2002 AT 63,000 MILES. IN JULY 2003, THE DEALER REPLACED THE FUEL INJECTIONS AT 67,000 MILES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SEVERAL TIMES FOR OF THE FAILURE. THE VEHICLE WAS AT AN AUTHORIZED DEALER WHEN THE REPORT WAS FILED. THE DEALER ORDERED A FUEL PUMP FOR THE VEHICLE BUT THE MANUFACTURER WOULD NOT PAY FOR IT. THE FAILURE MILEAGE WAS 62,000 AND THE CURRENT MILEAGE WAS 75,000 MILES.
CHASSIS ENGINE FAILED ON SINGLE LANE HIGHWAY HILL CLIMB. SEEMED LIKE ENGINE CUT OFF ALLOWING DRIVER TO QUICKLY TURN INTO" HOLE IN THE WALL "QUICK STOP STORE PARKING AREA. ENGINE TURNED OVER BUT WOULD NOT RUN. *TR THE CONSUMER STATED HE EXPERIENCED TWO PARKING BRAKE FAILURES WITHIN 3,000 MILES OF TRAVEL. EACH REPAIR, CONSISTED OF REPLACING SWITCHES AND ADJUSTMENTS. THE LAST REPAIR CONSISTED OF THE REPLACEMENT OF THE DRUM ASSOCIATED WITH THE BRAKE PADS, SWITCHES AND WHEEL BRAKE DISC. IT WAS ALSO DISCOVERED THAT THE PARK ASSEMBLY HAD BURNED UP, WHEN THE BRAKE ASSEMBLY FAILED TO RELEASE. IN ADDITION, A 10 AMP FUSE HAD BLOWN WHEN A SHORT WAS DISCOVERED IN A PRESSURE SWITCH. THE PARK BRAKE ASSEMBLY AND BOTH PRESSURE SWITCHES WERE REPLACED. UPDATED IVOQ 12/19/12 THE CONSUMER STATED WHILE FILLING RE-FUELING THE MOTOR HOME, A PASSERBY INFORMED HIM GASOLINE WAS DRAINING FROM THE MOTOR HOME. HE QUICKLY REMOVED THE HOSE AND SAW A LARGE PUDDLE OF FUEL UNDER THE GAS TANK. THE CONSUMER WAS NOT SURE, WHERE IT WAS COMING FROM, BUT IT DID APPEAR TO FLOW FROM A CONNECTING PIPE AT THE VERY REAR OF THE MOTOR HOME FILLING SECTION AND ABOUT 4 INCHES AT THE TANK INTERFACE. THE CONSUMER STATED THE MOTOR HOME IS CURRENTLY IN STORAGE. UPDATED 04/30/13
CHASSIS ENGINE FAILED ON SINGLE LANE HIGHWAY HILL CLIMB. SEEMED LIKE ENGINE CUT OFF ALLOWING DRIVER TO QUICKLY TURN INTO" HOLE IN THE WALL "QUICK STOP STORE PARKING AREA. ENGINE TURNED OVER BUT WOULD NOT RUN. *TR THE CONSUMER STATED HE EXPERIENCED TWO PARKING BRAKE FAILURES WITHIN 3,000 MILES OF TRAVEL. EACH REPAIR, CONSISTED OF REPLACING SWITCHES AND ADJUSTMENTS. THE LAST REPAIR CONSISTED OF THE REPLACEMENT OF THE DRUM ASSOCIATED WITH THE BRAKE PADS, SWITCHES AND WHEEL BRAKE DISC. IT WAS ALSO DISCOVERED THAT THE PARK ASSEMBLY HAD BURNED UP, WHEN THE BRAKE ASSEMBLY FAILED TO RELEASE. IN ADDITION, A 10 AMP FUSE HAD BLOWN WHEN A SHORT WAS DISCOVERED IN A PRESSURE SWITCH. THE PARK BRAKE ASSEMBLY AND BOTH PRESSURE SWITCHES WERE REPLACED. UPDATED IVOQ 12/19/12 THE CONSUMER STATED WHILE FILLING RE-FUELING THE MOTOR HOME, A PASSERBY INFORMED HIM GASOLINE WAS DRAINING FROM THE MOTOR HOME. HE QUICKLY REMOVED THE HOSE AND SAW A LARGE PUDDLE OF FUEL UNDER THE GAS TANK. THE CONSUMER WAS NOT SURE, WHERE IT WAS COMING FROM, BUT IT DID APPEAR TO FLOW FROM A CONNECTING PIPE AT THE VERY REAR OF THE MOTOR HOME FILLING SECTION AND ABOUT 4 INCHES AT THE TANK INTERFACE. THE CONSUMER STATED THE MOTOR HOME IS CURRENTLY IN STORAGE. UPDATED 04/30/13
11/09/04 I HAD TO REPLACE DIFFERENTIAL ASSEMBLY: OVERHAUL/REBUILD FRONT, REPLACE BRAKE PAD (BENDIX)3/10/05 REPLACED IDLER ARM. 3/23/05 REPLACED PITMAN ARM. 10/25/05 6.5 LITER DIESEL ELECTRONIC PUMP (PMD) FAILURE. TRUCK WAS MOVING ON IT'S ON, JERKING, BLACK SMOKE CAME FROM TAIL PIPE AND TIRES WOULD SPIN THEN IT CUT OFF AND WOULDN'T START. CALLED WRECKER AND HAD IT TAKEN TO AUTO SHOP. HE REPLACED PMD MODULE KIT WITH A NOTE TO LEAVE PLASTIC COVER OFF ENGINE BECAUSE OF HEAT BUILD UP. 6/25/06 SAME THING HAPPENED. CALLED WRECKER AND HAD IT TAKEN TO AUTO SHOP. THIS TIME HE REPLACED FUEL PUMP ON FRAME RAIL. 6/29/06 FUEL FILTER RINGS BLEW OFF, IT STARTED POURING FUEL ONTO HIGHWAY, JERKING,TRUCK MOVING ON IT'S ON, BLACK SMOKE COMING FROM TAIL PIPE WOULDN'T STOP HAD TO HOLD BREAK TO FLOOR UNTIL IT STALLED. ALMOST HIT A BUILDING. *JB
11/09/04 I HAD TO REPLACE DIFFERENTIAL ASSEMBLY: OVERHAUL/REBUILD FRONT, REPLACE BRAKE PAD (BENDIX)3/10/05 REPLACED IDLER ARM. 3/23/05 REPLACED PITMAN ARM. 10/25/05 6.5 LITER DIESEL ELECTRONIC PUMP (PMD) FAILURE. TRUCK WAS MOVING ON IT'S ON, JERKING, BLACK SMOKE CAME FROM TAIL PIPE AND TIRES WOULD SPIN THEN IT CUT OFF AND WOULDN'T START. CALLED WRECKER AND HAD IT TAKEN TO AUTO SHOP. HE REPLACED PMD MODULE KIT WITH A NOTE TO LEAVE PLASTIC COVER OFF ENGINE BECAUSE OF HEAT BUILD UP. 6/25/06 SAME THING HAPPENED. CALLED WRECKER AND HAD IT TAKEN TO AUTO SHOP. THIS TIME HE REPLACED FUEL PUMP ON FRAME RAIL. 6/29/06 FUEL FILTER RINGS BLEW OFF, IT STARTED POURING FUEL ONTO HIGHWAY, JERKING,TRUCK MOVING ON IT'S ON, BLACK SMOKE COMING FROM TAIL PIPE WOULDN'T STOP HAD TO HOLD BREAK TO FLOOR UNTIL IT STALLED. ALMOST HIT A BUILDING. *JB
2002 -COOLANT LEAKING FROM ENGINE AT APPROX 33,000 MILES. DIAGNOSED AS INTAKE MANIFOLD GASKET AND CORRECTED BY CHEVROLET DEALER UNDER WARRANTY. 2005 64000 MILES -COOLANT LEAKING FROM ENGINE COMPARTMENT, DISCOVERED CRACKED RADIATOR, REPLACED AT MY EXPENSE. 2005 66,000 MILES -COOLANT LEAKING FROM ENGINE COMPARTMENT, REPLACED WATER PUMP. MY EXPENSE. 2005 70,000 MILES-COOLANT LEAKING FROM ENGINE COMPARTMENT, DIAGNOSED INTAKE MANIFOLD GASKET AGAIN, REPLACED AT MY EXPENSE. SINCE PURCHASE I HAVE DONE EVERYTHING I CAN TO PROPERLY MAINTAIN VEHICLE. COOLING SYSTEM WAS SUPPOSED TO REMAIN SEALED FOR 5 YEARS OR 150,000 MILES PER DEALERS INSTRUCTIONS. *JB
2002 -COOLANT LEAKING FROM ENGINE AT APPROX 33,000 MILES. DIAGNOSED AS INTAKE MANIFOLD GASKET AND CORRECTED BY CHEVROLET DEALER UNDER WARRANTY. 2005 64000 MILES -COOLANT LEAKING FROM ENGINE COMPARTMENT, DISCOVERED CRACKED RADIATOR, REPLACED AT MY EXPENSE. 2005 66,000 MILES -COOLANT LEAKING FROM ENGINE COMPARTMENT, REPLACED WATER PUMP. MY EXPENSE. 2005 70,000 MILES-COOLANT LEAKING FROM ENGINE COMPARTMENT, DIAGNOSED INTAKE MANIFOLD GASKET AGAIN, REPLACED AT MY EXPENSE. SINCE PURCHASE I HAVE DONE EVERYTHING I CAN TO PROPERLY MAINTAIN VEHICLE. COOLING SYSTEM WAS SUPPOSED TO REMAIN SEALED FOR 5 YEARS OR 150,000 MILES PER DEALERS INSTRUCTIONS. *JB
I HAVE AN APPOINTMENT TO SERVICE THE TRUCK BUT I DON'T KNOW I F THE PROBLEMS WILL WE SOLVED. NO SAFETY DEFECT LISTED IN SUMMARY. *AK
I HAVE AN APPOINTMENT TO SERVICE THE TRUCK BUT I DON'T KNOW I F THE PROBLEMS WILL WE SOLVED. NO SAFETY DEFECT LISTED IN SUMMARY. *AK
EXHAUST WHICH IS TOO CLOSE TO FLOOR BOARDS GETS OVERHEATED ON PASSENGER'S SIDE. THIS CAUSES THE PASSENGER TO PUT FEET ON DASHBOARD DUE TO HOT FLOOR BOARDS. BEEN TO DEALER & INFORMED BY MECHANIC THE PROBLEM CAN NOT BE SOLVED. *AK
EXHAUST WHICH IS TOO CLOSE TO FLOOR BOARDS GETS OVERHEATED ON PASSENGER'S SIDE. THIS CAUSES THE PASSENGER TO PUT FEET ON DASHBOARD DUE TO HOT FLOOR BOARDS. BEEN TO DEALER & INFORMED BY MECHANIC THE PROBLEM CAN NOT BE SOLVED. *AK