2002 CHEVROLET SILVERADO 3500 Service Brakes, Hydraulic Problems

TL* THE CONTACT OWNS A 2002 CHEVROLET C3500. THE CONTACT WAS DRIVING APPROXIMATLEY 25 MPH WHEN THE BRAKES WERE APPLIED AND THE PEDAL WENT TO THE FLOORBOARD WITHOUT THE VEHICLE STOPPING. THE CONTACT WAS ABLE TO COAST TO THE SIDE OF THE ROAD WITHOUT A CRASH. THE CONTACT CHECKED THE MASTER CYLINDER AND FOUND THAT THE BRAKE FLUID WAS DEPLETED AND HE COULD SEE BRAKE FLUID LEAKING FROM UNDER THE VEHICLE. THE FAILURE WAS CAUSED BY A RUPTURE OF ONE OF THE MASTER CYLINDER BRAKE LINES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 41,500.

Mileage: 41,500

S10 APPROPRIATE HANDLING -COPY OF A LETTER TO THE PRESIDENT RE THE DANGERS OF RUPTURING BRAKE LINES ON A 2002 CHEVROLET SILVERADO 3500. *TGW THE CONSUMER STATED THE VEHICLE NEEDED FRONT BRAKE PADS, ROTORS WHICH WERE MORE RUSTED OUT THAN WORN AND ONE CALIPER. AS THE CONSUMER WAS BLEEDING THE AIR FROM THE HYDRAULIC CIRCUIT, HE NOTICED BRAKE FLUID POURING OUT OF THREE LOCATIONS ON THE DRIVER'S SIDE. THE STEEL BRAKE LINES HAD RUPTURED ON BOTH HYDRAULIC CIRCUITS DUE TO THE STEEL LINES RUSTING OUT. THE CONSUMER REPLACED ALL OF THE STEEL LINES, AS SOME OF THE RUST WAS HIDDEN FROM VIEW WITHIN PLASTIC RETAINERS. *JB

S10 APPROPRIATE HANDLING -COPY OF A LETTER TO THE PRESIDENT RE THE DANGERS OF RUPTURING BRAKE LINES ON A 2002 CHEVROLET SILVERADO 3500. *TGW THE CONSUMER STATED THE VEHICLE NEEDED FRONT BRAKE PADS, ROTORS WHICH WERE MORE RUSTED OUT THAN WORN AND ONE CALIPER. AS THE CONSUMER WAS BLEEDING THE AIR FROM THE HYDRAULIC CIRCUIT, HE NOTICED BRAKE FLUID POURING OUT OF THREE LOCATIONS ON THE DRIVER'S SIDE. THE STEEL BRAKE LINES HAD RUPTURED ON BOTH HYDRAULIC CIRCUITS DUE TO THE STEEL LINES RUSTING OUT. THE CONSUMER REPLACED ALL OF THE STEEL LINES, AS SOME OF THE RUST WAS HIDDEN FROM VIEW WITHIN PLASTIC RETAINERS. *JB

HUSBAND PERFORMED OIL CHANGE ON TRUCK. TRUCK IS DRIVEN INFREQUENTLY, ONLY USED FOR TOWING MY HORSE TRAILER, SO OIL IS ONLY CHANGED ABOUT ONCE A YEAR, AND TRUCK IS GARAGE KEPT. WHEN UNDERNEATH TRUCK, HUSBAND NOTICED THAT ALL BRAKE LINES FEEDING INTO THE ABS UNIT ARE SEVERELY CORRODED AND COULD FAIL AT ANY TIME. BASED ON CONDITION OF BRAKE LINES, HUSBAND (A MECHANIC) FEELS ABS UNIT IS PROBABLY FULL OF RUST AS WELL. ENTIRE BRAKING SYSTEM MAY BE COMPROMISED AND FULL OF RUST. TRUCK WILL NOT BE SAFE TO DRIVE UNTIL BRAKE LINES ARE REPLACED, AND POTENTIALLY ENTIRE BRAKING SYSTEM IS OVERHAULED. CALLED DEALERSHIP, THEY REFUSED TO DO ANYTHING BECAUSE THE TRUCK IS OUT OF WARRANTY. WE HAVE CONTACTED CHEVROLET DIRECTLY AND ARE AWAITING A RETURN PHONE CALL. MY HUSBAND HAS 30 AND 40 YEAR OLD CARS AT HOME THAT HAVE CLEANER ORIGINAL BRAKE LINES THAN OUR 10 YEAR OLD TRUCK DOES.

Mileage: 80,000

ANTI-LOCK BRAKING SYSTEM CONSISTENTLY ENGAGES WHEN AT SLOW-SPEED STOPPING (5-8 MPH). PROBLEM STARTED AT THE 40,000 MILE MARK. DEALER INFORMED THAT THERE IS A RECALL ON THE ISSUE BUT MY VIN DOES NOT QUALIFY. *TR

Mileage: 40,000

HYDRAULIC:ANTILOCK DURING LOW-SPEED BRAKE APPLICATIONS THE BRAKES PUSH BACK AND DON'T NOT STOP THE TRUCK THE POWER STEERING ALSO CUTS OUT WHEN THIS HAPPENS. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 3500. THE FRONT BRAKE SENSOR HAS FAILED BECAUSE OF CORROSION. THE VEHICLE WAS TAKEN TO THE DEALER AND HE WAS ADVISED THAT SINCE THE WARRANTY EXPIRED NO ASSISTANCE WOULD BE PROVIDED. THE FAILURE MILEAGE WAS 135,000.

Mileage: 135,000

UNDER NORMAL BRAKING CONDITIONS THE ANTI LOCK BRAKING SYSTEM WILL ACTIVATE AT LOW SPEED, AROUND 7-10 MILES PER HOUR. CONTACTED LOCAL DEALER AND THEY TOLD ME IT WAS TYPICALLY THE WHEEL SPEED SENSOR THAT CAUSES THIS PROBLEM. THERE WAS A RECALL ISSUED BY GM BUT MY TRUCK DID NOT FALL IN THIS RECALL DUE TO THE VIN NUMBER. WHEEL SPEED SENSORS WERE REPLACED TO FIX THIS ISSUE. *JB

Mileage: 56,000

TL*- THE CONTACT STATED THAT WHEN THE PARKING BRAKE ON THE 2002 CHEVROLET SILVERADO 3500 WAS ENGAGED IT WOULD ONLY HOLD THE VEHICLE FOR A FEW SECONDS. THE CONTACT STATED THAT ONCE HE EXITED THE VEHICLE IT WOULD ROLL AWAY. THE CONTACT STATED THIS HAPPENED WHEN VEHICLE WAS PARKED ON A FLAT SURFACE OR A HILL. THIS CONTACT STATED THIS RESULTED IN NUMEROUS CRASHES. THE CURRENT AND FAILURE MILEAGE WAS 30000. THERE WAS A RECALL REPAIR COMPLETED FOR THIS PROBLEM; HOWEVER, THE PROBLEM RECURRED. THE CONTACT STATED THE ROTORS WERE PITTED AND RUSTED, WHICH MADE IT DIFFICULT TO STOP THE VEHICLE. THE DEALERSHIP INSPECTED VEHICLE. HOWEVER, DID NOT COME TO ANY CONCLUSION AS TO WHAT CAUSES THIS TO HAPPEN. THE DEALERSHIP REFUSED TO PERFORM ANY SERVICE ON THE VEHICLE. THE VEHICLE CURRENTLY HAS 30000 MILES. *AK

Mileage: 30,000

DT*: THE CONTACT STATED WHILE DRIVING 7 MPH ON NORMAL ROAD CONDITIONS, THERE WAS NO BRAKING ACTION WHEN TRYING TO STOP. NO WARNING LIGHTS WERE ILLUMINATED TO ALERT THE DRIVER. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO INDICATED THE ANTILOCK BRAKE SYSTEM (ABS) HAD A RECALL # 05V379000 REGARDING SERVICE BRAKES, HYDRAULIC:ANTILOCK, FOR THOSE VEHICLES DUE TO A SPEED SENSOR FAILURE. ALL VEHICLES OPERATED IN SALT BELT STATES MAY BE AFFECTED. THE MANUFACTURER WAS CONTACTED, AND INDICATED THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN, AND THE COMPANY WAS NOT RESPONSIBLE FOR THE REPAIR COST. THE SPEED SENSOR, WHICH WAS THE AFFECTED COMPONENT OF THE ABS, WAS MANUFACTURED IN THE SAME PLANT FOR ALL GENERAL MOTORS VEHICLES. THE CONTACT EXPRESSED CONCERN BECAUSE A COPY OF THE COMPLAINT TAKEN BACK IN AUGUST WAS NEVER RECEIVED.

Mileage: 19,000

DT*: THE CONTACT STATED WHILE APPLYING BRAKE PRESSURE AT 10 MPH, THE ANTILOCK BRAKES ACTIVATED UNDER NORMAL CONDITIONS AND THERE WAS AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE WHEEL SPEED SENSORS WERE CORROSIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS EXPOSED TO EXCESSIVE ROADS SALTS DURING THE WINTER MONTHS. THERE WAS A NHTSA RECALL, # 05V379000, REGARDING THE ANTILOCK BRAKES. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE MANUFACTURER WAS ALERTED.

Mileage: 19,500

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 05379000 CONCERNING THE ANTI LOCK BRAKES . THIS VEHICLE MANIFESTS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT REPAIRED THE VEHICLE AT HIS OWN EXPENSE.*AK

Mileage: 50,000

UNDER NORMAL BRAKING JUST BEFORE STOPPING THE ABS ACTIVATES. *JB

Mileage: 39,000

DT: THE CONTACT OWNS 2002 CHEVROLET DUMP TRUCK. WHEN HE FIRST BOUGHT IT THE BRAKES WERE BAD. HE TOOK IT BACK TO THE DEALER, AND THEY PUT NEW ROTORS ON THE FRONT. HE WAS STILL HAVING PROBLEMS WITH THE BRAKES, AND HE TOOK IT BACK, AND THEY SAID THE BRAKES WERE FINE. HE TOOK IT TO MIDAS, AND THE BACK ROTORS WERE SHOT. THEY PUT NEW BRAKES AND ROTORS ON THE BACK. ALSO, THE FUEL GAUGE SENSOR WAS DEFECTIVE. THEY REPLACED THE SENSOR. THE REAR END WAS BAD. THEY REBUILT THE REAR END. THEN THE EXHAUST SYSTEM MALFUNCTIONED, *AK AND THEY PUT NEW MANIFOLDS ON IT. *AK

Mileage: 26,000

THE VEHICLE HAD SEVERAL MECHANICAL PROBLEMS TO INCLUDE THE EMERGENCY BRAKE, TRANSMISSION AND 4-WHEEL DRIVE. *NM THE CONSUMERS VEHICLE WAS PARKED ON A HILL AND THE EMERGENCY BRAKE FAILED CAUSING THE TRUCK TO ROLL OFF THE HILL. THE VEHICLE SUSTAINED 15000.00 DOLLARS WORTH OF DAMAGE. CONSUMER CONTACTED THE DEALER AND CONTACTED CHEVROLET BUT TO NO AVAIL BECAUSE THEY WILL NOT TAKE RESPONSIBILITY FOR THE DAMAGES. THE MECHANICS AT CHEVROLET STATED THAT THE EMERGENCY BRAKE IS DEFECTIVE BUT NO MECHANICAL DEFECTS. THE CONSUMERS VEHICLE IS UNDRIVABLE. *TC

ON OUR 2002 CHEVROLET C3500 LIGHT TRUCK I NOTICED A DETERIORATION IN BRAKE PERFORMANCE OVER TIME. WE PULLED THE REAR WHEELS AT 37,000 MILES AND FOUND THAT THE REAR BRAKE CALIPERS HAVE NOT BEEN ENGAGING THE BRAKE PADS WITH THE REAR ROTORS. THE REAR ROTORS HAVE SEVERELY CORRODED AND NOW THE CORROSION IS TEARING THE PADS APART. WE HAVE COME TO FIND OUT THAT THIS IS AN ONGOING PROBLEM WITH GM VEHICLES OF THIS TYPE AND POSES A SERIOUS THREAT TO LIFE AND SAFETY.

Mileage: 37,290