2007 CHEVROLET SILVERADO 3500 Problems & Recalls

I purchased my new 2007 Chevy duramax diesel with an already installed fabtech lift kit. My pitman arm has snapped 3 times since I purchased my truck leaving me with complete steering loss. I have had to replace all steering components several times. My truck is unsafe due to a fabtech lift kit that...

Rattling noise in intermediate shaft of steering column and key tumbler is sticky

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE REFUELING, DIESEL FUEL SPRAYED BACK OUT OF THE FILLER NECK. THE CONTACT WAS CONCERNED THAT THE DESIGN OF THE FILLER NECK TO THE FUEL TANK WAS DEFECTIVE. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR R...

Mileage: 285,064

WHILE DRIVING AT ABOUT 35 MPH, I HAD TO STOP FOR A GARBAGE TRUCK DOING A TRASH PICKUP. WHEN I APPLIED THE BRAKES ON MY PICKUP, THE BRAKES TOTALLY FAILED AND I NEARLY DROVE ANOTHER CAR INTO THE BACK OF THE GARBAGE TRUCK. THAT AVERTED CRASH WOULD CERTAINLY HAVE KILLED THE CAR'S DRIVER. I AVOIDED A ...

Mileage: 150,000

WHILE DRIVING AT ANY SPEED, STEERING WHEEL SHAKES, SLIGHTLY, YET NOTICEABLY. ANY SPEED. THE SHAKE IS CONSISTENT, FEELS WORSE WHEN TURNING OR(DRIFTING) RIGHT I ON FREEWAY. HAVE HAD STEERING GEAR BOX, PITMAN ARM, AND ROAD FORCE BALANCING PERFORMED, TO NO RELIEF. UPON SELF INSPECTION, LEFT WHEEL SEEMS ...

Mileage: 5

TAKATA RECALL MY DASHBOARD HAS CRACKED IN THREE DIFFERENT SPOTS 2 AROUND PASSENGERS AIR BAG ONE OVER GAGE CLUSTER. NOT SURE IF CAR WAS IN MOTION OR SITTING WHEN IT HAPPEN.

Mileage: 230,000

"TAKATA RECALL" - I RECEIVED MY LETTER REGARDING THE PASSENGER SIDE AIRBAG RECALL DATED JULY 2015. I CONTACTED CORPORATE HEADQUARTERS AND THEY WERE NO HELP AND KEPT TELLING ME THE VEHICLE WAS "SAFE" TO DRIVE EVEN THOUGH THE LETTER SAYS DISCHARGE OF THE AIRBAG COULD CAUSE "INJURY OR DEATH TO OCCUPA...

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAI...

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAI...

TAKATA RECALL; RECEIVED THIS RECALL NOTICE JULY 2015 AND IT HAS BEEN OVER A YEAR AND NO FIX IN SIGHT. I WOULD REALLY LIKE TO KNOW WHAT AMERICA IS COMING TO. I AM STARTING TO BELIEVE WE ARE BECOMING A THIRD WORLD COUNTRY WITH GM GETTING AWAY THIS TYPE OF SAFETY RECALL AND NOW THERE SHOULD BE ANOTHER ...

Mileage: 25,000

TAKATA RECALL COME ON GM...MY HONDA DEALSHIP CONTACTED ME (AND I AM THE SECOND OWNER OF THIS CAR, NOT SURE HOW THEY FOUND ME) AND SCHEDULED AN APPT, AND FIXED MY AIRBAG...THIS ALL HAPPENED IN LESS THAN A WEEK AND LITTLE IF ANY INCONVENIENCE TO ME. GM GET YOUR ACT TOGETHER.

BRAKE LINE FAILURE FROM RUST ON A VEHICLE WITH LESS THAN 82,000 MILES ON IT. ALL THE LINES MUST BE REPLACED. FAILED IN MODERATE SPEED IN MAJOR TRAFFIC JAM. SECOND FAILURE ON SAME VEHICLE. AFTER FIRST FAILURE ALL LINE WERE INSPECTED AND NO PROBLEMS WERE NOTED. APPARENTLY WITHOUT PERFORMING AN UL...

Mileage: 82,000

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL RE...

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V3240200 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REP...

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPA...

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPA...

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V324000 (AIR BAGS); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE...

TL* THE CONTACT OWNS A 2007 CHEVROLET 3500. WHILE DRIVING 65 MPH, THE VEHICLE WOULD SLOW DOWN TO ABOUT 30 MPH WITHOUT WARNING. THE CONTACT STATED THAT IT FELT AS IF THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTORS NEEDED TO BE REPLACED. THE VE...

Mileage: 30,000

TL* THE CONTACT OWNS A 2007 CHEVROLET 3500. WHILE DRIVING 65 MPH, THE VEHICLE WOULD SLOW DOWN TO ABOUT 30 MPH WITHOUT WARNING. THE CONTACT STATED THAT IT FELT AS IF THE BRAKES WERE APPLIED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTORS NEEDED TO BE REPLACED. THE VE...

Mileage: 30,000

TRAVELING AT 60 MPH WHILE TOWING A 35' FIFTH WHEEL THE ENGINE STARTED TO SHUDDER A BIT. WHEN WE PULLED OVER AND PUT THE ENGINE INTO NEUTRAL THE ENGINE STOPPED RUNNING. WE TRIED TO START THE TRUCK BUT IT WOULD NOT TURN OVER BUT THERE WAS JUICE TO THE BATTERY TO RUN THE LIGHTS AND WINDOWS. AFTER BEING...

Mileage: 55,325

2007 CHEVROLET SILVERADO 3500. CONSUMER STATED WHEN HE BACKED THE VEHICLE OUT OF THE DRIVEWAY, HE DISCOVERED HE DID NOT HAVE BRAKES NOR POWER STEERING. *TA THE POWER STEERING PUMP, PULLEY AND SERPENTINE BELT WERE REPLACED. UPDATED 02/23/15. *JB UPDATED 04/15/15*JB

2007 CHEVROLET SILVERADO 3500. CONSUMER STATED WHEN HE BACKED THE VEHICLE OUT OF THE DRIVEWAY, HE DISCOVERED HE DID NOT HAVE BRAKES NOR POWER STEERING. *TA THE POWER STEERING PUMP, PULLEY AND SERPENTINE BELT WERE REPLACED. UPDATED 02/23/15. *JB UPDATED 04/15/15*JB

ON DECEMBER 17TH, I BROUGHT MY VEHICLE IN FOR A KEY/IGNITION RECALL.THEY INSTALLED A KEY INSERT AND KEY RINGS ON BOTH THE KEYS. ON MONDAY, DECEMBER 22ND, MY DAUGHTER INSERTED THE KEY INTO THE IGNITION AND IT AUTOMATICALLY LOCKED ON HER AND SHE COULD NOT TURN THE KEY NOR COULD SHE TAKE THE KEY OUT. ...

SITTING AT A TRAFFIC LIGHT, AND THE BRAKE PEDAL WENT TO THE FLOOR, ALLOWING THE TRUCK TO ROLL INTO THE INTERSECTION. THE ONLY WAY I STOPPED IT WAS SHIFT THE TRANSMISSION INTO NEUTRAL. I NURSED THE TRUCK BACK HOME AND FOUND ALL OF THE BRAKE LINES ARE CORRODED WITH ONE BLOWN OUT. THE MASTER CYLINDER ...

Mileage: 28,350

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT TRANSMISSION FLUID WAS LEAKING FROM THE VEHICLE. THE CONTACT REPLACED BOTH TRANSMISSION LINES AT THERE EXPENSE. THE MANUFACTURER WAS CONTACTED AND STATED THAT THAT THEY WERE UNWILLING TO REPAIR THE FAILURE. THE APPROXIMATE...

Mileage: 41,000

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, HE CRASHED INTO A DEER AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED MINOR BRUISING. THE POLICE WERE CONTACTED. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. ...

Mileage: 8,625

THE DRIVER'S SEAT BELT WOULD NOT LATCH.

Mileage: 54,338

OUR 2007 CHEVROLET 3500 4 X 4 WITH A 6.0 GAS ENGINE HAS FAILURE IN THE EXHAUST MANIFOLD BOLTS AND IS CAUSING NOISE AND EMISSION ISSUES IN AND OUTSIDE THE CABIN AND IS AFFECTING HORSE POWER. OUR TRUCK HAS NOW 13,000 MILES ON IT! THIRTEEN THOUSAND. IT IS WELL CARED FOR AND LITTLE USED, THERE IS NO EXC...

Mileage: 7,000

EXHAUST MANIFOLD BOLTS ON THE 6.0L BREAK OFF AT THE HEAD CAUSING EXHAUST GAS TO LEAK INTO PASSENGER COMPARTMENT AND POTENTIAL FOR A FIRE. WE HAVE 10 TRUCKS AROUND THIS YEAR AND MOST OR ALL HAVE HAD ALL EXHAUST STUDS REPLACED. MY LOCAL DEALER IS AWARE OF THIS THE SERVICE MANAGER TOLD ME IT HAPPENS TO...

Mileage: 23,130

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED WHILE DRIVING 70 MPH THE VEHICLE STALLED. THE CONTACT STATED THE FAILURE OCCURRED AT LEAST FOUR TIMES SINCE HE OWNED IT AND FEARED THE VEHICLE COULD STALL WHILE TOWING AND CAUSE A CRASH. THE CONTACT TOOK THE VEHICLE TO THE D...

Mileage: 70,000

PROBLEM WITH TRANSMISSION COOLER LINES FOR THE ALLISON TRANSMISSION. 123,000KM'S ON MY 3500 AND THE TRANSMISSION LINES HAVE BEEN REPLACED 3 TIMES. 2 TIMES WERE ON WARRANTY AND THE 3RD I HAD TO PAY FOR MYSELF. I HAVE EXTENDED WARRANTY BUT IS NOT COVERED, BUNCH OF BS. COST ME 850 DOLLARS TO FIX. SHOUL...

Mileage: 123,000

TL*THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE TRANS COOLER LINES WERE LEAKING TRANSMISSION FLUID. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE IT WAS REPAIRED; THE TRANSCOOLER LINES AND TRANSMISSION FLUID WERE REPLACED. THE FAIL...

Mileage: 28,890

TL*THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. WHILE DRIVING APPROXIMATELY 20 MPH BOTH FRONT AIR BAGS INVOLUNTARILY DEPLOYED. HE SUFFERED INJURIES BUT WAS ABLE TO DRIVE HIMSELF TO THE HOSPITAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE A...

Mileage: 39,000

TL*THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT THE AIR POLLUTION SYSTEM SENSOR BURNED FUEL WHEN IT BECAME FULL. THE FAILURE ALSO CAUSED THE VEHICLE TO USE FUEL FASTER THAN NORMAL. THE WARNING LIGHT ILLUMINATED DISPLAYED REFER TO THE OWNERS MANUAL. THE OWNERS MANUAL STAT...

Mileage: 48,000

TL*THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHEN DRIVING AT ANY SPEED WITH AN RV TRAILER HOOKED ON, THE VEHICLE WOULD LOSE POWER. THE VEHICLE WOULD GO FROM 60 MPH TO 10 MPH. THE FUEL RAIL PRESSURE WAS TOO LOW, THE ENGINE POWER REDUCED AND WARNING LIGHTS ILLUMINATED ...

Mileage: 50,000

2007 CHEVROLET K3500 DURAMAX POWER PROBLEM:ON TWO OCCASIONS I HAVE HAD A NEAR TOTAL LOSS OF POWER PROBLEM WITH MY 2007 K3500 DURAMAX. BOTH OCCURRENCES WERE IDENTICAL. THERE WAS A LOSS OF POWER THAT SEVERELY LIMITED ACCELERATION AND TOP SPEED. THE DETAILS OF THE CONDITIONS ARE AS FOLLOWS: ...

Mileage: 7,779

TL*THE CONTACT OWNS A 2007 CHEVROLET SILVERADO 3500 DURAMAX DIESEL TRUCK. WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND WOULD NOT ACCELERATE ABOVE FIRST GEAR. THE FAILURE OCCURRED ON TWO SEPARATE OCCASIONS. THE COMPUTER HAS BEEN RESET A TOTAL OF THREE TIMES. RECALL NUMBER 08142 (ENGINE CONTRO...

Mileage: 500

WE PURCHASED A 2007 CHEVROLET 1 TON NEW IN AUGUST OF 2007. ON JANUARY 23, 2008 MY EMPLOYEE WAS DELIVERING TRAFFIC CONTROL. THE ENGINE WAS RUNNING AS HE WAS DOING HIS PAPER WORK. HE NOTICED SMOKE FROM UNDER THE ENGINE COMPARTMENT. HE OPENED THE HOOD AND OBSERVED FLAMES AND SMOKE. HE USED THE FIR...

Mileage: 5,000

2007.5 CHEVY 3500 DIESEL PICKUP: WHEN THE EXHAUST RE-GEN CYCLE IS INTERRUPTED, EXHAUST FUMES ENTER THE PASSENGER COMPARTMENT. GM HAS STATED THE SYSTEM IS OPERATING AS DESIGNED THEY WILL DO NOTHING FURTHER. *TR

Mileage: 2

2007.5 CHEVY 3500 DIESEL PICKUP: WHEN THE EXHAUST RE-GEN CYCLE IS INTERRUPTED, EXHAUST FUMES ENTER THE PASSENGER COMPARTMENT. GM HAS STATED THE SYSTEM IS OPERATING AS DESIGNED THEY WILL DO NOTHING FURTHER. *TR

Mileage: 2

THERE IS A SAFETY DEFECT THAT COULD CAUSE SERIOUS INJURY OR DEATH TO PEDESTRIANS. I HAVE PURCHASED A NEW 2007 CHEVROLET 3500HD, LTZ PICKUP TRUCK. THIS TRUCK WAS PURCHASED WITH THE FACTORY INSTALLED ULTRASONIC BACKUP SENSOR SYSTEM. MY SYSTEM WORKS JUST LIKE IT IS DESCRIBED IN THE OWNER'S MANUAL, B...

Mileage: 25