This Problem Across All Years
There is a common and very dangerous electrical wire routing problem on my vehicle, along with 3 dozen others and my dads (separate but same truck) i confirmed with (FB group for owners of 17-19 L5P GMC diesel trucks) where the alternator positive wire from the alternator to the battery is run right along and across a rather sharp part of molding from the air intake tube. This routing location and rough intake plastic molding rubs through the alternator wire creating a possible electrical short/ corrosion problems that can lead to battery and electrical system compromise, as well as fire risk! A short-circuit condition can cause damage to engine components and, in rare cases, start a fire in the engine compartment. I have 92,000 miles on this 2019, my father has the problem starting on his at only 40,000 miles and may others have issues as well to very degrees of severity between 25 and 150k miles. I discovered this issue while performing routine air filter maintenance and happened to see the rub damage. no modifications have been done, this is the way the wire is routed from the factory. IMO and estimations This issue far supercedes the danger and severity of the recall that currently exists for the engine block heater cord for these models of trucks. 2 of the photos show the damage and exposed wire as soon as i found it. The last shows the location and the part that caused the rub damage along with a temporary mitigation method: electrical tape with a rubber hose installed as a buffer until a permanent fix can be installed.
There is a common and very dangerous electrical wire routing problem on my vehicle, along with 3 dozen others and my dads (separate but same truck) i confirmed with (FB group for owners of 17-19 L5P GMC diesel trucks) where the alternator positive wire from the alternator to the battery is run right along and across a rather sharp part of molding from the air intake tube. This routing location and rough intake plastic molding rubs through the alternator wire creating a possible electrical short/ corrosion problems that can lead to battery and electrical system compromise, as well as fire risk! A short-circuit condition can cause damage to engine components and, in rare cases, start a fire in the engine compartment. I have 92,000 miles on this 2019, my father has the problem starting on his at only 40,000 miles and may others have issues as well to very degrees of severity between 25 and 150k miles. I discovered this issue while performing routine air filter maintenance and happened to see the rub damage. no modifications have been done, this is the way the wire is routed from the factory. IMO and estimations This issue far supercedes the danger and severity of the recall that currently exists for the engine block heater cord for these models of trucks. 2 of the photos show the damage and exposed wire as soon as i found it. The last shows the location and the part that caused the rub damage along with a temporary mitigation method: electrical tape with a rubber hose installed as a buffer until a permanent fix can be installed.
1st incident: When driving the vehicle dashboard shut off, no indicators working such as speedometer, gauges etc and brakes were not working, luckily I was in a 60 miles an hour zone so I had to just let the vehicle come to a gravity stop. To turn off the engine and start it back up again. 2nd incident: when driving the dash lights turned off and on like flickering on and off and all the gauges mentioned above did not work, and brakes did not work. This is very scary! All power in the truck is lost while driving and braking issue!
1st incident: When driving the vehicle dashboard shut off, no indicators working such as speedometer, gauges etc and brakes were not working, luckily I was in a 60 miles an hour zone so I had to just let the vehicle come to a gravity stop. To turn off the engine and start it back up again. 2nd incident: when driving the dash lights turned off and on like flickering on and off and all the gauges mentioned above did not work, and brakes did not work. This is very scary! All power in the truck is lost while driving and braking issue!
Service trailer brake system appears and my trailer brake information doesn’t show up on the dashboard when I try to manually engage the electric trailer brakes.
Service trailer brake system appears and my trailer brake information doesn’t show up on the dashboard when I try to manually engage the electric trailer brakes.
Service trailer brake system appears and my trailer brake information doesn’t show up on the dashboard when I try to manually engage the electric trailer brakes.
Service trailer brake system appears and my trailer brake information doesn’t show up on the dashboard when I try to manually engage the electric trailer brakes.
The electrical connector vibrated loose at the injector. The mechanic said he has seen this happen before and GM said its because those motors vibrate excessively. It caused my vehicle to run in reduced power mode. In that mode it was lurching forward uncontrollably and it felt like the transmission was banging. What damage will that alone cause in the future? Also, if GM knows there is an issue, why isn't it fixed? Why is the consumer responsible for poor engineering or design flaws? It isn't normal wear and tear or neglect on my part. The repairs including the part and the rental car cost me $640.45! Oddly enough it wasn't covered under any extended warranty or recall so I had to pay out of pocket. Very dangerous and expensive!
The electrical connector vibrated loose at the injector. The mechanic said he has seen this happen before and GM said its because those motors vibrate excessively. It caused my vehicle to run in reduced power mode. In that mode it was lurching forward uncontrollably and it felt like the transmission was banging. What damage will that alone cause in the future? Also, if GM knows there is an issue, why isn't it fixed? Why is the consumer responsible for poor engineering or design flaws? It isn't normal wear and tear or neglect on my part. The repairs including the part and the rental car cost me $640.45! Oddly enough it wasn't covered under any extended warranty or recall so I had to pay out of pocket. Very dangerous and expensive!