2006 CHEVROLET SILVERADO Service Brakes Problems

RUSTED BRAKE LINE RESULTING IN TOTAL BRAKE FAILURE WHILE DRIVING AND ATTEMPTING TO STOP

Mileage: 98,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING 35 MPH AND ATTEMPTING TO DECREASE IN SPEED, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,642.

Mileage: 86,642

THIS VEHICLE HAS HAD MULTIPLE BRAKE ISSUES SINCE NEW. FIRST OFF, IT GOES THROUGH FRONT BRAKE PADS AND ROTORS TOO FREQUENTLY. FIRST REPLACED AROUND 25K AND AGAIN AROUND 60K. THIS VEHICLE HAS MOSTLY BEEN USED FOR LONG HIGHWAY TRIPS, NY TO FL ETC., NOT AROUND TOWN. USED IN RURAL AREA. NEXT, SEVERAL BRAKES LINES HAVE BURST AND HAD TO BE REPLACED. THE LAST INCIDENT LUCKILY WAS IN MY DRIVEWAY. HAVING DUAL BRAKE CYLINDERS ON THESE TRUCKS DOES NOT SEEM TO HELP IF A BRAKE LINE BURSTS. I NEEDED THE EMERGENCY BRAKE TO STOP IT ON ALMOST FLAT GROUND. A RECURRING PROBLEM IS WITH THE ABS. EVIDENTLY THEY RUST EASILY, ESPECIALLY IN SALT BELT STATES, THEN CORROSION ON THE SENSOR AND HUB CAUSES IT TO ACTIVATE FOR NO REASON. IT DOES NOT ACTIVATE THE COMPUTER CONTROL OR GIVE WARNING. IT HAPPENS INTERMITTENTLY. I HAD TO HAVE ONE FRONT HUB REPLACED IN 2013 AND ANOTHER IN 2014. NOW I AM HAVING TO REPLACE ONE OF THOSE AGAIN WITH THE DEALER RECOMMENDING TO REPLACE BOTH. THE COST IS OVER $750 PER SIDE. THERE WERE RECALLS ON PREVIOUS YEAR MODELS BUT NOT 2006. THIS IS RIDICULOUS AND THE BRAKE LINE ISSUE HAS BEEN GOING ON WITH CHEVROLET FOR A VERY LONG TIME. I HAD TO REPLACE MOST LINES ON MY 1996 SILVERADO. I CAN'T BELIEVE THAT NHSTA ALLOWS THIS TO GO ON YEAR AFTER YEAR. NOTHING IS MORE IMPORTANT THAN BRAKING, NOTHING!

Mileage: 96,000

MY VEHICLE WITH 57,000 MILES HAD THE BRAKES GO OUT WHILE DRIVING WITHOUT WARNING. I TOOK IT TO A MECHANIC WHO SAID THE FRONT BRAKE LINES HAD RUSTED AND BROKE. I HAVE HAD THE WORK COMPLETED. I FEEL THIS IS A PRODUCT DEFECT FOR A LOW MILEAGE VEHICLE. IT IS VERY WELL TAKEN CARE OF AND HAS VERY FEW MILES ON IT, AND I HAVE OWNED IT SINCE IT WAS NEW. I HAVE BEEN IN CONTACT WITH CHEVROLET AND THEY WILL NOT PROVIDE ME WITH ANY ANSWERS. THEY KEEP TELLING ME TO TAKE IT TO A DEALERSHIP, HOWEVER THE DEALERSHIP HAS TOLD ME THERE IS NOTHING THEY CAN DO.

Mileage: 57,000

WHILE APPROACHING A TRAFFIC SIGNAL MY BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I DROVE MY VEHICLE SLOWLY HOME AND CHECKED BRAKE FLUID LEVEL. IT WAS LOW AND I TOPPED IT OFF. I TRIED THE BRAKES AGAIN AND ONCE AGAIN THE PEDAL WENT TO FLOOR. I WENT UNDER THE VEHICLE AND BRAKE FLUID WAS DRIPPING OFF THE CROSS MEMBER JUST BEHIND THE ENGINE. I COULD SEE THAT ALL THE BRAKE LINES WERE VERY RUSTY. I WAS ABLE TO GET THE VEHICLE TO BIG O TIRES. AFTER INSPECTION, IT WAS FOUND THAT THE BRAKE LINE HAD RUSTED THROUGH AND ALL THE OTHERS WERE IN VERY BAD SHAPE AND I HAD ALL THE LINES REPLACED. AFTER SOME RESEARCH I FOUND THIS WAS A KNOWN PROBLEM AND GM HAS REDESIGNED THE LINES BUT, REFUSED TO RECALL AND REPLACE THE LINES. YOU NEED TO RESEARCH THIS PROBLEM FURTHER AND INSIST ON A RECALL BEFORE SOMEONE IS KILLED. I AM THE ORIGINAL OWNER AND AS INDICATED BY THE MILEAGE THE VEHICLE IS NOT DRIVEN THAT MUCH AND VERY WELL TAKEN CARE OF.

Mileage: 24,905

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS COMING TO A STOP, THE ANTI-BRAKE SYSTEM ENGAGED INDEPENDENTLY AND CAUSED THE BRAKES TO FAIL. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 9,000.

Mileage: 9,000

I WAS DRIVING THE TRUCK AWAY FROM MY HOME , WHEN I STEPED ON THE BRAKE PEDAL IT WENT TO THE FLOOR. I GOT THE TRUCK STOPPED WITH THE PARKING BRAKE. WHEN I INSPECTED THE BRAKE LINES THEY WERE ALL EXTREMELY RUSTY AND ONE HAD BURST. FLUID LEAKED OUT AND THERE WAS NO PEDAL AT ALL. THE BRAKES WERE GONE WITH NO WARNING.

Mileage: 40,000

TRAVELING 60 MPH ON THE HIGHWAY AND APPROACHED A RED TRAFFIC LIGHT. APPLIED THE BRAKES TO STOP WITH OTHER TRAFFIC. BRAKE PEDAL WENT COMPLETELY TO THE FLOOR WITH APPROXIMATELY 10% BRAKING POWER. NO WARNING LIGHTS ON DASH. FORTUNATELY THE TRAFFIC LIGHT TURNED GREEN AND TRAFFIC MOVED PRIOR TO A CRASH. CRASH WAS GUARANTEED IF TRAFFIC LIGHT HAD NOT CHANGED. BRAKE FLUID LEVEL FINE. BRAKE LINE UNDER DRIVERS SIDE RUSTED AND BURST. NO WARNING SIGNS.

Mileage: 121,000

WHILE APPLYING BREAKS ON DRY SURFACES AND COMING TO A STOP THE ABS KICKS IN AND PEDAL GOES TO THE FLOOR. THIS CAUSES THE STOPPING DISTANCE TO INCREASE. I HAVE ALMOST REAR-ENDED STOPPED AND PARKED CARS AND RAN INTO MY GARAGE DOOR. THERE HAVE BEEN TO MANY CLOSE CALLS SO I HAVE PULLED THE FUSE TO SHUT OFF THE ABS.

Mileage: 60,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING AT APPROXIMATELY 50 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. AFTER THE BRAKES WERE APPLIED CONTINUOUSLY, THE SPEED REDUCED TO 10 MPH. THE VEHICLE CAME TO A COMPLETE STOP WHEN THE EMERGENCY BRAKE WAS APPLIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

Mileage: 103,000

WHILE TRAVELING ON THE EXPRESSWAY IN MY 2006 CHEVROLET SILVERADO WITH 26,000 MILES ON THE ODOMETER, I ATTEMPTED A TRANSIENT LANE CHANGE WHILE TAKING EVASIVE ACTION IN ORDER TO AVOID A HAZARDOUS SITUATION. WHEN COUPLED WITH THE BRAKES I NOTICED LONGER THAN USUAL ENGAGEMENT. AS A RESULT, I WAS FORCED ONTO THE SHOULDER AND HAD TO USE MULTIPLE DOWNSHIFTS IN CONCERT WITH THE EMERGENCY BRAKE TO BRING THE VEHICLE TO A HALT. IT SOUNDED LIKE A TRAIN STOPPING ON RAILS. I PROCEEDED TO DRIVE HOME WITH HAZARDS ON,U NEVER EXCEEDING THIRD GEAR. THE FOLLOWING MORNING I NOTICED CLEAR OIL UNDERNEATH THE FRONT END OF THE VEHICLE. I BELIEVE THIS IS AN EXTREMELY DANGEROUS VEHICLE AND A LESS EXPERIENCED DRIVER WOULD HAVE BEEN KILLED OR EXTREMELY INJURED. LASTLY, I HAVE ALSO BEEN NOTICING INCONSISTENCY WITH STEERING RESISTANCE. SOMETIMES THE STEERING IS CONSIDERABLY LOOSER THAN AT OTHER TIMES. I HAVE DISMISSED THIS DISCONCERTING SENSATION BY ASSUMING IT IS WEATHER/HUMIDITY RELATED.

Mileage: 26,000

MY LEFT FRONT WHEEL HUB ASSEMBLY FAILED WHILE DRIVING. BRAKE SYSTEM WAS COMPROMISED. I WAS ABLE TO PULL OVER AND STOP SAFELY, BUT BRAKES DID NOT RESPOND AS THEY SHOULD. MOREOVER, THERE WAS NO INDICATION THAT THE WHEEL BEARING WAS FAILING, AND I AM QUITE AWARE OF WHAT THIS SOUNDS LIKE BECAUSE THIS WILL BE THE FOURTH TIME I HAVE REPLACED THE WHEEL HUB ASSEMBLY ON THE LEFT SIDE. I HAVE REPLACED THE RIGHT HUB ASSEMBLY TWICE. IN ALL PREVIOUS TIMES, I HEARD A SLIGHT WHIRLING NOISE OR AT WORSE SLIGHT GRINDING, WHICH WOULD LEAD ME TO INSPECTION AND REPLACEMENT BEFORE FAILURE. THIS TIME IT FAILED WITHOUT ANY WARNING. I BELIEVE GM HAS MADE A SERIOUS DESIGN AND/OR QUALITY ERROR IN THIS TRUCK. THIS SHOULD BE INVESTIGATED BECAUSE THIS IS A COMMON PROBLEM.

Mileage: 107,000

FOR THE THIRD TIME A BRAKE LINE HAS RUSTED COMPLETELY THROUGH AND CAUSED COMPLETE LOSS OF CONTROL. IT WAS LOCATED UNDER THE DRIVERS SEAT ABOVE THE FRAME. I HAD ABSOLUTELY NO BRAKES AT 70 MPH ON HWY 5. I TOOK IT TO A CHEVY DEALERSHIP AND THEY TOLD ME IT WAS NOT THEIR PROBLEM. I AM EXTREMELY CONCERNED ABOUT THE FORTH BRAKE LINE THAT IS COMPLEXLY COVERED IN RUST. THIS IS GOING TO KILL SOMEONE WHEN IT RUSTS THROUGH. *TR

Mileage: 59,857

BRAKE LINE RUPTURE RESULTING IN IMMEDIATE BRAKE FAILURE WITHOUT WARNING. PARALLEL PARKING A 2006 SILVERADO WHEN WE ENCOUNTERED A COMPLETE BRAKE FAILURE AND NEARLY STRUCK ANOTHER PARKED VEHICLE. BRAKE PETAL DEPRESSED COMPLETELY TO THE FLOOR WITHOUT WARNING. STEERED TRUCK TOWARD CURB TO FULLY STOP BEFORE STRIKING OTHER VEHICLE. IMMEDIATE INSPECTION REVEALED BRAKE LINE RUPTURE ON DRIVERS SIDE OF VEHICLE IN UNDERCARRIAGE AREA NEAR BACK OF DRIVERS SEAT. SIGNIFICANT LOSS OF BRAKE FLUID AND COMPLETE BRAKE FAILURE. FORTUNATELY TRAVELING LESS THAN 5 MPH - FIVE MINUTES EARLIER WE WERE TRAVELING AT SPEEDS OF 70 MPH ON INTERSTATE HIGHWAY. THIS COULD HAVE BEEN A CATASTROPHIC EVENT HAD IT OCCURRED ON THE INTERSTATE OR THE OFFRAMP. VEHICLE PASSED A VIRGINIA STATE SAFETY INSPECTION THREE WEEKS EARLIER. GM OR NHTSA SHOULD WARN GM OWNERS TO CHECK THEIR BRAKE LINES AND ALSO CONSIDER A RECALL. *TR

Mileage: 100,553

ON APPROX. 28 APRIL 2013 AFTER A 200 MILE TRIP I WAS PARKING MY TRUCK WHEN THE BRAKE LINE BROKE. I THEN USED THE EMERGENCY BRAKE TO STOP THE TRUCK. AT THIS TIME I MADE THE NECESSARY REPAIRS TO GET US BACK HOME. ONCE THERE I RESPONDED TO LEN STOLER CHEVEROLET IN WESTMINSTER MD. WHERE I PURCHASED THE VEHICLE. I ASKED THEM IF THEY COULD BLEED THE BRAKES, BECAUSE I DID NOT THINK I GOT ALL THE AIR OUT OF LINES. AT THIS TIME I WAS WAITING IN THE WAITING ROOM WHEN A SERVICE ADVISOR CAME IN AND ASK ME TO GO INTO THE SHOP BECAUSE THEY WANTED TO SHOW ME SOMETHING. WHEN I ARRIVED AT MY TRUCK (WHICH WAS ON THE LIFT) THEY STATED THE ENTIRE BRAKE LINES WERE SO CORRODED THAT THEY NEEDED TO BE REPLACED AT A PRICE OF $1610.80. I STATED THAT THE SO CALL METAL USED HAD TO BE DEFECTED TO ALLOW THE WHOLE SYSTEM OF LINES TO RUST TO THIS POINT IN ONLY SEVEN YEARS. SHE THEN REPLIED THAT IT WAS NOT CAUSE BY THE METAL USED, IT WAS THE NEW SALT THAT THE STATES USES NOW. WHEN THEY REPLACED THE OLD LINES WITH THE NEW,I ASK THE SERVICE ADVISOR IS THE METAL BRAKE LINES BEING INSTALLED , WERE THEY USING THE SAME KIND OF METAL AND SHE REPLIED, NO THEY ARE USING ZINK COATED LINES NOW. MY QUESTION DID ANY OTHER TRUCKS LIKE MINE HAVE THE SAME PROBLEM AND WHY DID THEY USE A NEW METAL IF THERE WAS NOTHING WRONG WITH ORIGINAL METAL. *TR

Mileage: 55,400

I WAS BACKING UP THE TRUCK WHEN A CAR CAME UP BEHIND ME AND HAD TO HIT THE BRAKES HARD. THE PEDDLE WENT ALL THE WAY TO THE FLOOR, NO BRAKES AT ALL. HAD TO STEER THE TRUCK INTO A SNOW BANK TO AVOID AN ACCIDENT. THE CAB OF THE TRUCK IMMEDIATELY SMELLED LIKE BRAKE FLUID. TOOK THE TRUCK TO THE SHOP AND DISCOVERED THE BRAKE LINES ARE RUSTED AT EVERY POINT WHERE THEY CONNECT TO THE FRAME. REPAIRED THE FIRST LEAK AND ANOTHER LEAK STARTED IN ANOTHER LINE IN THE SAME AREA THE LINES ATTACHED TO THE FRAME BEHIND THE DRIVERS SIDE FRONT WHEEL. REPAIRED THE SECOND LEAK AND A 3RD LEAK APPEARED INSIDE THE FRAME RAIL BEHIND THE CAB WHERE THE LINE ATTACHES TO THE FRAME. THE LINES CAN NOT BE SAFELY REPAIRED. ALL NEW LINES MUST BE INSTALLED. THE TRUCK ONLY HAS 10,250 MILES ON IT AND IS ALWAYS WASHED INCLUDING THE UNDER CARRIAGE AFTER DRIVING ON SALTED ROADS. *TR

Mileage: 10,250

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING 10 MPH, THE BRAKE PEDAL SHOOK WHEN IT WAS DEPRESSED. THE FAILURE RECURRED SEVERAL TIMES. THE DEALER STATED THAT THE SENSOR WAS RUSTED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WITHOUT WARNING AND IT BECAME DIFFICULT TO STOP THE VEHICLE. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND LEAKING. THE FUEL LINES WERE ALSO RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,900.

Mileage: 36,900

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS APPLIED AND TRAVELED ABNORMALLY TO THE FLOORBOARD. THE CONTACT MENTIONED THAT THE VEHICLE HESITATED TO STOP. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS INFORMED THAT THE FRONT AND REAR BRAKE LINES NEEDED TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL SANK TO THE FLOORBOARD WITHOUT WARNING AND THE VEHICLE FAILED TO STOP. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND CONTAINED LEAKS. ALSO, THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 36,900. UPDATED 3/31/15*CN UPDATED 9/7/2017*CN

Mileage: 36,900

VEHICLE LOST BRAKES DUE TO CORRODED STEEL BRAKE LINES. *TR

Mileage: 111,233

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE RIGHT AND LEFT WHEEL HUB ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000. THE VIN WAS UNAVAILABLE.

Mileage: 45,000

AS I WAS PROCEDIN TOWARDS A YIELD SIGN, MY BRAKES SEEMED TO HAVE GIVEN OUT. THE VEHICLE WOULD STOP BUT SLOWLY AND NEARLY CAUSED ME TO GET SIDESWIPED BY AN ONCOMING VEHICLE. UPON RETURNING HOME I SAW A MASSIVE POL OF BRAKE FLUID UNDERNEATH THE VEHICLE. HAVING ANOTHER PERSON HIT THE BRAKES I SAW THAT THE FLUID WAS ESCAPING FROM THE METAL BRAKE LINE RUNNING UNDERNEATH THE COOLING FANS. THE LINE WAS SEVERELY CORRODED BY RUST. *TR

Mileage: 110,000

BRAKE LINE RUSTED THROUGH. GM KNOWS THIS IS A PROBLEM WITH THESE TRUCKS, BUT WON'T RECALL. *TR

Mileage: 86,000

I WAS COMING HOME FROM MY DAUGHTERS SOCCER GAME WITH HER AND MY EX-WIFE AS PASSENGERS.WE WERE APPROXIMATELY 50 MILES FROM HOME TRAVELING ON THE INTERSTATE WHEN I APPLIED MY BRAKES AND PEDDLE WENT SLOWLY TO THE FLOOR. I MANAGED TO GET SLOWED DOWN AND BY QUICKLY PUMPING MY BRAKES I COULD GET ENOUGH PRESSURE TO STOP THE TRUCK. I PHONED A FRIEND AND HE BROUGHT A TRAILER AND WE HAULED IT HOME. I DO A LOT OF MY MECHANIC WORK BECAUSE OF GARAGE COST. I REPLACED THE ONE LINE, HAD ANOTHER ONE RUST OUT SO REPLACED ALL 4 OF THEM. THEN JUST THIS PAST WEEK I WAS GOING DOWN MY STEEP DRIVEWAY APPROXIMATELY 1/8 MILE LONG AND BRAKE LINE UNDER RADIATOR BROKE AND HAD TO USE EMERGENCY BRAKE TO GET STOPPED. I KEEP MY TRUCK CLEAN UNDERNEATH AND ON TOP AND THE FRAME IS RUSTING SO BAD IT'S SHAMEFUL!! THE BUMPERS AND CAB CORNERS ARE RUSTING TOO. *TR

Mileage: 75,000

DRIVING ON THE ROAD AT APPROX. 35 MPH AND HAD TO MAKE A ABRUPT STOP. AFTER MAKING THE ABRUPT STOP, I PROCEEDED DOWN THE ROAD. THE NEXT TIME I PUSHED THE BRAKES THE PEDAL FELT SOFT. AFTER PULLING TO THE SIDE OF THE ROAD AND CHECKING THE VEHICLE THERE WAS A LARGE AMOUNT OF BRAKE FLUID COMING FROM THE REAR OF THE VEHICLE. AFTER FUTHER INSPECTION, I FOUND THAT THE REAR METAL BRAKE LINE HAD RUSTED AND BUSTED OPEN. *TR

Mileage: 115,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE ATTEMPTING TO COME TO A COMPLETE STOP, THE BRAKES FAILED TO STOP THE VEHICLE AND THE EMERGENCY BRAKE HAD TO BE ENGAGED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT ALL OF THE BRAKE LINES AND FUEL LINES NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 21,000.

Mileage: 21,000

BACKING UP SMALL GRADE, APPLIED BRAKES AND THE PEDAL FELT SOFT, PUMPED BRAKE SECOND TIME AND PEDAL WENT ALL THE WAY TO THE EXTENT OF ITS TRAVEL. DRIFTED TO LEVEL AREA CHECKED BRAKE FLUID WHICH WAS NEAR EMPTY. THE BRAKE LINE UNDER DRIVER SIDE FLOOR AREA ALONG FRAME RAIL HAD BURST. THE LINES ARE RUSTED AND FLAKING. HAD VEHICLE TOWED TO INDEPENDENT REPAIR SHOP AS I DID NOT FIND A RECALL ON THIS. REPAIR SHOP INDICATED THAT THIS IS A NORMAL PROBLEM FOR THIS MAKE/ MODEL VEHICLE. *TR

Mileage: 53,765

I WAS GETTING READY TO PULL OUT ON THE MAIN HWY. WHEN HITTING MY BRAKES TO STOP BEFORE ENTERING, THE BRAKE PEDAL WENT TO FLOOR, I,M GLAD NO ONE GOT HURT AND I PARKED THE TRUCK SAFELY. AFTER PARKING IT THERE WAS A PUDDLE OF BRAKE FLUID ON THE ROAD. ALL THE FOUR LINES WERE RUSTED AND ONE OR TWO BROKE. I'VE BOUGHT 4 NEW CHEV. THIS 2006 HAS HAD RUSTY BRAKE LINES SINCE 2008 OR 2009 WHEN I BOUGHT IT. THESE LINES HAVE RUSTED ON A LOT OF THESE 2006 CHEV. TRUCKS I'VE HEARD. I THINK GM SHOULD DO SOMETHING ABOUT THEM, BEFORE WE HAVE ANOTHER COBALT TRAGIC. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 150,000

COMPLETE LOSS OF BRAKES WHILE ATTENDING A REENACTING CEREMONY AT THE ECKLEY MINERS VILLAGE AND DELIVERING SUPPLIES - ALL BRAKE LINES WERE COMPLETELY RUSTED OUT. *TR

Mileage: 15,000

I HAVE FOUND THAT THE STEEL LINES RUNNING ALONG THE FRAME RAILS ARE RUSTING AND FOUND A PATCH IN ONE PLACE AND THE POSSIBILITY OF MORE LEAKS HAPPENING. *TR

Mileage: 54,000

TL* THE CONTACT OWNS 2006 CHEVROLET SILVERADO. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 2 MPH IN REVERSE THE VEHICLE FAILED TO RESPOND TO DECELERATION ATTEMPTS. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE MECHANIC STATED THAT THE BRAKE LINES WERE COVERED WITH RUST. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

ANOTHER VEHICLE RAN A RED LIGHT IN FRONT OF ME AND I HAD TO APPLY BRAKES QUICKLY. THE BRAKE LINE RUPTURED , I SWERVED, AND BARELY MISSED THE OTHER CAR. THEY WOULD HAVE BEEN KILLED IF I WAS NOT ABLE TO MOVE INTO THE OPPOSITE LANE. LATTER FOUND THAT THE RUPTURE WAS CAUSED BY EXCESSIVE RUST. HAD THAT SECTION REPLACED BUT ITS TOO EXPENSIVE TO REPLACE ALL THE LINES - WAITING FOR ANOTHER FAILURE. *TR

Mileage: 20,000

I WAS MOVING MY TRAVEL TRAILER IN MY DRIVEWAY, IN PREPARATION FOR A VACATION TRIP. WHEN I STEPPED ON THE BRAKE, A RUSTED BRAKE LINE FAILED AND THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO STOP THE VEHICLE SAFELY. FURTHER INSPECTION REVEALS THAT ALL THE BRAKE LINES ON THE TRUCK ARE BADLY RUSTED AND WILL HAVE TO BE REPLACED. *JS

Mileage: 72,000

BRAKE LINES HAD HOLES IN THEM CAUSED BY CORROSION,FUEL LINE ALSO. NOTICED PROBLEM BEFORE ANYTHING SERIOUS HAPPENED. COST OVER 1000.00 TO REPLACE BRAKE AND FUEL LINES. *TR

Mileage: 52,760

AS I WAS BACKING OUT OF MY DRIVEWAY MY BRAKE PEDAL WENT TO THE FLOOR. I STOPPED JUST IN TIME TO AVOID BEING HIT BY ON COMING TRAFFIC. TOOK IT TO A DEALER LATER THAT DAY AND WAS TOLD THAT THE BRAKE LINES WERE RUSTED THROUGH AND WOULD COST OVER $700 TO REPAIR. *TR

Mileage: 73,000

STARTED THE VEHICLE FASTEN SEAT BELT EXITED THE CARPORT STARTED TO LEAVE MY YARD HAD TO STOP A GO BACK IN HOUSE TURNED THE VEHICLE OFF REMOVED THE KEY WENT BACK IN THE HOUSE CAME BACK GOT IN THE VEHICLE FASTEN SEAT BELT STARTED THE VEHICLE PUT IT IN DRIVE AND THE SERVICE AIR BAG LIGHT FLASHED SEVERAL TIME WE OUT AND CAME BACK AND WILL NOT GO BACK OUT IT WILL FLASH SEVERAL TIME GO OUT AND COME BACK ON AND STAY. *TR

Mileage: 174,789

SAW WET SPOT UNDER DRIVER'S SIDE OF TRUCK, JUST BEHIND ENGINE COMPARTMENT. KNEW IT WASN'T GOOD AS THE AC IS ON THE OTHER SIDE. FIGURED I'D CHECK IT LATER. STARTED TRUCK AND AS SOON AS I PUT MY FOOT ON THE BRAKE PEDAL, I COULD FEEL SOMETHING WAS WRONG. STOPPED TRUCK, POPPED HOOD AND CHECKED BRAKE FLUID LEVEL IN MASTER CYLINDER. SAW IT WAS LOW. ADDED A PINT OF FLUID AND LOOKED UNDER THE TRUCK. SAW IT LEAKING FROM A RUSTED OUT BRAKE LINE NEAR THE ABS MODULE. ALL LINES ARE RUSTED AND IN NEED OF REPLACEMENT. *TR

Mileage: 65,230

BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. LATER ON, THE INFORMATION CONSOLE DISPLAYED A SERVICE BRAKE SYSTEM MESSAGE. THE BRAKE LINES ARE SO RUSTED OUT THAT THEY ARE NOW LEAKING BRAKE FLUID. *TR

Mileage: 76,000

I APPLIED THE BRAKES. THE BRAKE PEDAL WENT TO THE FLOOR WITH LITTLE RESISTANCE. I GOT THE TRUCK HOME AND NOTICED BRAKE FLUID DRAINING FROM THE DRIVERS SIDE METAL BRAKE LINE JUST FORWARD OF THE REAR AXLE. *TR

Mileage: 71,500

LEFT REAR BRAKE LINE BLEW OUT AND RUSTED THROUGH. DO NOT TRUST ANY OTHER BRAKE LINE ON THIS TRUCK NOW. *TR

Mileage: 60,000

BRAKE PEDAL WENT TO THE FLOOR WITH NO BRAKING AVAILABLE. THIS WAS JUST AFTER A 300 + MILE TRIP HAULING A HORSE TRAILER AND TWO HORSES. SERVICE INVESTIGATION REVEALED RUPTURED HYDRAULIC BRAKE LINES. ALL BRAKE LINES ARE SEVERELY CORRODED AND ALL MUST BE REPLACED. WORST PORTION IS JUST UNDER THE DRIVERS SEAT AREA WHERE THREE LINES RUN TOGETHER. CALLED DEALER AND GM, IT APPEARS TO BE A COMMON PROBLEM SINCE GM NOW OFFERS A DISCOUNTED BRAKE LINE KIT. MAY POSTS ON CHEVY FORUMS REVEAL THE EXACT PROBLEM. SOMETHING SHOULD BE DONE AS THIS APPEARS TO BE A BAD DESIGN. FORTUNATE THAT THIS DID NOT HAPPEN WHILE ON THE TURNPIKE. *JS

Mileage: 84,700

BRAKELINES HAVE CORRODED,ROTTED OUT. *TR

Mileage: 69,000

WHEN I BACKED OUT OF MY DRIVEWAY , WHICH IS ON AN INCLINE , THE BRAKE PEDAL WENT TO THE FLOOR AND I JUST MISSED BACKING OUT INTO A BUSY ROAD. I TOOK THE TRUCK IN FOR REPAIRS IMMEDIATELY FOLLOWING THE INCIDENT. THE REPAIRS COST NEARLY $750. THEY SAID THAT MOST ALL OF THE BRAKE LINES WERE RUSTED AND THE ONE ON THE REAR DRIVERS SIDE HAD A HOLE RUSTED THROUGH. *TR

Mileage: 75,500

I BOUGHT MY CHEVY 3500 DUALLY 4X4 TO DRIVE WHEN I NEEDED IT TO HAUL THINGS OR FOR THE 4WD . I TOLD MY DAUGHTER IT WAS GOING TO SNOW AND MAKE THE ROADS DANGEROUS SO I WOULD TAKE HER TO WORK AND PICK HER UP WHEN SHE WAS DONE EVERYTHING WENT WELL NO SIGNS OF ANY PROBLEMS BEFORE AND AFTER I HAD TAKEN HER TO WORK SO WHEN SHE CALLED I WENT TO PICK HER UP AT WORK AND HAD TO WAIT A LITTLE WHILE FOR HER TO FINISH UP AFTER I HAD GOTTEN TO HER WORK THEN I DROVE HER HOME AND JUST AFTER GETTING OFF THE INTERSTATE WE PULLED INTO THE DRIVEWAY AND I PULLED UP TO THE HOUSE AND ALMOST WENT THROUGH MY GARAGE DOOR WHEN MY BRAKE PEDAL WENT TO THE FLOOR AT ABOUT 10-15 MPH WITH ABSOLUTLY NO WARNING WHAT SO EVER I WOULD HAVE NEVER USED THE TRUCK IF I HAD REMOTELY THOUGHT SOMETHING WAS WRONG WITH THE BRAKES I DRIVE SEMI TRUCKS FOR A LIVING AND ALWAYS CHECK THINGS AROUND MY VEHICLES BY SECOND NATURE SINCE I AM RESPONSIBLE FOR THE SAFE OPERATION OF THE VEHICLES I DRIVE. I HAD MY TRUCK TOWED TO THE DEALER WHERE I PURCHASED IT NEW AND TOLD THEM I HAD CONTACTED GM ABOUT THE PROBLEM AND THAT I TOLD THEM I EXPECTED IT TO BE REPAIRED FREE OF CHARGE AND GM RESPONSE WAS THAT THEY WANTED THE DEALER TO EVALUATE IT AND THE EVALUATION WOULD BE FREE OF CHARGE THEY DID AND THEY FOUND THE BRAKE LINES RUSTED IN HALF AND ALSO BUSTED AT THE RUBBER HOSE CONNECTIONS SO GM SAID THAT THEY WOULD COVER 30% OF THE REPAIR OF THE BRAKE LINES IN WHICH THEY DID BUT IT STILL COST ME $1800 . GM INSISTED THAT MY BRAKE LINES RUSTED IN HALF BECAUSE MY TRUCK SITS A LOT I TOLD THEM I HAVE A 1990 MAZDA I BOUGHT NEW THAT SITS BESIDE IT THAT I HAVE NEVER HAD ANY SAFETY PROBLEMS OUT OF . GM ALSO HAS CHANGED THE BRAKE LINES TO A PLASTIC COATED LINE . I HAD ALSO TOLD THEM THAT IT WAS A POOR DESIGN WHERE THE WATER RAN OFF THE WINDSHIELD AND DOWN ONTO THE BRAKE LINES RIGHT WHERE THEY RUSTED AND BROKE GM NEEDS TO STAND BEHIND ITS PRODUCT. *TR

Mileage: 26,500

I HAVE A 2006 CHEVROLET SILVERADO 2500HD ALL OF THE BRAKE LININGS HAD RUSTED. MY BRAKES FAILED WHILE I WAS DRIVING. FORTUNATELY I CONTROLLED THE VEHICLE AND WAS ABLE TO STOP, SAW THE LEAK AND WAS TOWED .A PRIVATE COMPANY REPLACED ALL LINES. I EMAILED MY CONCERN TO CHEVROLET, ASKED TO HAVE MY COMMENTS FORWARDED TO CEO-PRODUCT IMPROVEMENT. SUBSEQUENTLY HAD A PHONE CONVERSATION (866-790-5600) [XXX]WITH [XXX] COULD NOT SEND THIS INFORMATION TO CEO PRODUCT IMPROVEMENT. IF THE BRAKE LININGS FAIL YOU HAVE NO BRAKES. MY SERVICE REQUEST[XXX] I SPOKE TO PRIVATE MECHANICS THEY SAID THIS WAS SYSTEMIC ISSUE TO CHEVROLET. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 120,000

ABS ENGAGES AT SLOW SPEEDS - EVIDENTLY THERE IS A KNOWN PROBLEM WITH THE ABS SENSORS ENGAGING AT LOW SPEEDS. THIS IS A POTENTIALLY DANGEROUS DEFECT. IT IS SCARY WHEN YOU APPROACH A STOP AND THE BRAKES RELEASE. GM HAS KNOWN ABOUT THIS PROBLEM AND HAS ISSUED A SERVICE BULLETIN. THERE WAS A RECALL ON PREVIOUS YEARS BUT STOPPED IN 06 EVEN THOUGH THEY NEVER FIXED THE PROBLEMS. THEY SHOULD REINSTATE THE RECALL AND FIX THE REMAINING VEHICLES. WE HAVE NOT BEEN INVOLVED IN AN ACCIDENT BECAUSE OF THE DEFECTIVE SENSORS BUT I CONSIDER US FORTUNATE. *TR

Mileage: 61,000

HAPPENED IN THE DRIVEWAY, THANKFULLY. BRAKE PEDAL SPONGY, PUSHED AGAIN AND WENT TO THE FLOOR. GOT OUT OF THE TRUCK AND FOUND A PUDDLE OF BRAKE FLUID UNDER THE DRIVER'S SIDE. FURTHER INSPECTION, THE BRAKE LINE HAS RUSTED THROUGH AND WAS SPRAYING FLUID WHEN THE PEDAL WAS PUSHED. COMPLETE FAILURE OF BRAKES. THANK GOODNESS FOR THE E BRAKE. *TR

Mileage: 96,956

WHILE TRAVELING ALONG RT 80 IN NEW JERSEY AT 65 MPH, TRAFFIC BEGAN TO SLOW IN ALL LANES. I HIT MY BRAKES ONLY TO FIND THAT MY FOOT WENT COMPLETELY TO THE FLOOR AND HAD POSSIBLY 10% BRAKING ABILITY REMAINING TO STOP THE TRUCK. I WAS ONLY ABLE TO AVOID CONTACTING THE VEHICLES IN FRONT OF ME BY DOWNSHIFTING, USING THE EMERGENCY BRAKE AND RUNNING ONTO THE HIGHWAY SHOULDER AND OFF THE ROAD TO AVOID AN ACCIDENT. I WAS ABLE TO DRIVE SLOWLY TO THE CLOSEST REPAIR SHOP WHERE I WAS INFORMED THAT THE BRAKE LINES WERE CORRODED AND LEAKING BRAKE FLUID. AS A RESULT, WHEN I HIT MY BRAKES, THE BRAKE FLUID LEAKED CAUSING THE LACK OF PEDDLE PRESSURE AND DID NOT OPERATE THE BRAKES PROPERLY. I HAD NO PREVIOUS WARNING THAT THERE WAS ANY BRAKE PROBLEMS. ADDITIONALLY, THE GAS LINES WERE CORRODED AND REQUIRED REPLACEMENT. THIS IS AN ADDITIONAL HAZARD THAT COULD CAUSE A FIRE. THE CORRODED BRAKE LINE ISSUE IS A WELL KNOWN (EXCEPT TO ME PRIOR TO THE INCIDENT) AND DOCUMENTED PROBLEM OF WHICH CHEVROLET REFUSES TO NOTIFY VEHICLE OWNERS. THE FIRST TIME OWNERS ARE AWARE OF THE BRAKE LINE PROBLEM IS WHEN THEY TRY TO STOP THE TRUCK AND BY THAT POINT, IT IS TOO LATE. *TR

Mileage: 74,255

THE BRAKE LINES RUSTED OUT AND THE FLUID LEAKED OUT CAUSING BRAKE FAILURE. *TR

Mileage: 39,000

SERVICE BRAKELINES ROTTED AND CAUSED A COMPLETE LOSS OF SERVICE BRAKES - WHILE DRIVING AND CLOSE TO HOME - USED EMERGENCY BRAKES AND LOW GEAR TO GET TO HOME. SPOKE TO FRIEND AT CHEVY DEALER. THEY ARE HAVING PROBLEMS WITH THIS TRUCK SERIES DUE TO CORROSION AND PREMATURE RUSTING. TRUCK IS CURRENTLY IN GARAGE DUE TO FAILURE (CORROSION) OF TRANSMISSION COOLING LINES. CURRENT MILEAGE 15,211. LOST BOTH ANTI-LOCK BRAKE MODULES AND ALTERNATOR AND TEMPERATURE SENSORS. *TR

Mileage: 14,285

COMPLETE BRAKE FAILURE DUE TO BRAKE LINE DEFECT / LEAK. REPAIR ESTIMATE FROM DEALERSHIP $2800.00+. *TR

Mileage: 61,000

CHEVROLET SILVERADO 2500 HD (2006) WAS PURCHASED NEW, FROM GENGRAS CHEVROLET-585 CONNECTICUT BLVD.- EAST HARTFORD, CT. 06108- TELEPHONE # 860-528-2575. BRAKE LINE RUPTURED DUE TO CORROSION, FORTUNATELY, VEHICLE WAS BEING OPERATED AT A SLOW SPEED (25) MPH. UPON INSPECTION OF UNDER THE VEHICLE, I WAS APPALLED AT THE CONDITION OF BRAKE LINES,FITTINGS,BRACKETS AND RELATED COMPONENTS. THE RUST ON THE UNDERSIDE INCLUDING THE FRAME WAS SUCH THAT IT COULD BE FLAKED OFF IN 1/16" THICK CHUNKS. THIS TRUCK HAS ONLY 9028 MILES, WHAT KIND OF AUTO INDUSTRY DO WE HAVE !!!!! ? I WAS MADE AWARE OF THIS CORROSION PROBLEM (THAT CHEVROLET IS AWARE OF) BY A LOCAL AUTO MECHANIC THAT THIS CORROSION PROBLEM WAS IN PRIMARILY (2004-2005-2006) SILVERADOS. THE MATERIALS GM IS USING TO CAUSE THESE PROBLEMS IS A DISGUSTING SAMPLE OF OUR MANUFACTURING SYSTEM. THIS VEHICLE WAS PARKED OUTDOORS (ON A ASPHALT DRIVEWAY). THE REPAIRS FOR THIS SITUATION ARE IN LINE WITH THE POOR QUALITY MATERIALS THAT WERE USED, I WAS INFORMED THAT THE BODY OF THE TRUCK BED HAD TO BE REMOVED (LIFTED-OFF) TO ACCESS BRAKE LINES AND GET THIS, THE FUEL LINE IS ALSO IN THE SAME LOCATION, MIGHT BE SUSPECT TO CORROSION. THE COST OF THESE REPAIRS IS OFF THE CHARTS. (WHO IS RESPONSIBLE FOR THESE DESIGN FLAWS). AS AN AMERICAN, WHO ADVOCATES BUYING DOMESTIC VEHICLES, I WONDER WHO IS WATCHING WHAT IS GOING ON. I HOPE SOMEONE OF AUTHORITY READS THIS AND ACTS ON IT, BEFORE IT IS TO LATE FOR ALL OF US. REMEMBER, THIS VEHICLE HAS (9028) MILES ON IT, AND EXPERIENCING THESE PROBLEMS. YES, THAT IS CORRECT (9028) MILES !!!!!!!!!! *TR

Mileage: 9,028

MY TRUCK HAS A SERIOUS RUST PROBLEM. I WAS DRIVING FROM PENNSYLVANIA TO BUFFALO WHEN MY BRAKE LINE SNAPPED "SPEWING BRAKE FLUID ALL OVER"ON THE HIGHWAY WHILE DRIVING AT 65MPH. AT THE DEALER I WAS SHOWED THAT NOT ONLY WHERE MY BRAKE LINES ROTTED BUT EVERYTHING INVOLVING THE BRAKES "CALIPERS,ROTORS, PADS " FUEL LINES, FRAME CONTROL ARMS, EVERYTHING UNDER THE TRUCK, WHICH WAS BOUGHT NEW. THE BRAKE PADS, CALIPERS & ROTORS WERE REPLACED BY MY MECHANIC AT 25,000 WITH PARTS BOUGHT BY GM. MY TRUCK IS IN EXCELLENT SHAPE FROM WHAT YOU CAN SEE & IS GARAGE KEPT.FROM WHAT I SEE THIS IS A COMMON PROBLEM WITH GM TRUCKS FROM 2000-2012. *TR

Mileage: 46,917

I WAS GOING BACK TO MY JOB LOCATION AFTER LEAVING A TRAINING CLASS. APPLIED BRAKES AS I APPROACHED A STOP SIGN. BRAKE PEDAL HAD NO RESISTANCE AND WENT TO THE FLOOR. LUCKILY, I WAS ON SCHOOL DISTRICT PROPERTY SO THE SPEED LIMIT WAS 15. WAS ABLE TO GET TO MY LOCAL MECHANIC WHO FOUND A RUPTURED BRAKE LINE. HE ALSO INFORMED ME THAT ALL BRAKE LINES WERE RUSTED AND WHILE HE COULD NOT SAY ANOTHER ONE WILL RUPTURE TOMORROW, HE FELT TO BE SAFE THEY SHOULD ALL BE REPLACED. WE TOW A CAMPER WITH THIS TRUCK AND WHILE I KNOW THE CAMPER'S BRAKES WILL STOP THE TRUCK, SOME OF THE CAMPGROUND WE VISIT ARE MOUNTAIN CAMPGROUNDS WITH STEEP GRADES AND WHEN WE LEAVE THE CAMPGROUND TO DO SOMETHING (EXAMPLE: GO OUT TO EAT), NOT KNOWING IF THE TRUCK BRAKES WILL WORK IS NOT VERY COMFORTING. *TR

Mileage: 26,026

UPON DRIVING HOME ON MY STREET MY BRAKE PEDAL WENT TO THE FLOOR. HAVE BREAK LINE CORRODED AND LEAKING BELOW DRIVER SIDE DOOR. WAS ABLE TO STOP SAFELY AS I WAS ON A RESIDENTIAL ROAD WITH A LOW SPEED LIMIT. *TR

Mileage: 83,000

WHILE DRIVING AT 10 MPH THE REAR BRAKES FAILED. UPON INVESTIGATION IT WAS FOUND THAT THE REAR BRAKE LINE HAD RUSTED OUT AT THE CONNECTION TO THE SPLITTER LOCATED ON FRAME ABOVE THE REAR AXLE. *TR

Mileage: 62,500

EVERY BRAKE GAS AND COOLING LINE RUSTED. I HAVE LOOKED AT OTHER VEHICLES OF SAME YEAR AND MILES DIFFERENT MAKES. NO WHERE AS RUSTED AS MY 06 SILVERADO. *TR

Mileage: 80,466

WHILE DRIVING I WENT TO STOP AT INTERSECTION AND THE BRAKE PEDAL WENT TO THE FLOOR,AND I USED PARKING BRAKE TO STOP.I GOT OUT AND THERE WAS BRAKE FLUID ALL OVER,I CAREFULLY DROVE HOME ,1/2 MILE AND CHECKED OUT TRUCK AND THE BRAKE LINES WERE ALL RUSTED AND LEAKING. I TRIED TO FIX WITH NEW PARTS BUT AFTER FIXING IT WOULD LEAK IN ANOTHER SPOT. I HAVE TO REPLACE ALL BRAKE LINES TO BE SAFE. I THINK THAT GM SHOULD HAVE TO HAVE A RECALL ON THESE BRAKE LINES. THANKS *TR

Mileage: 53,200

RETURNING HOME, I APPROACHED A 4-WAY STOP AT ABOUT 40 MPH. ATTEMPTED TO STOP, ONLY LIMITED BRAKES. GEARING DOWN AND DEFENSIVE DRIVING NECESSARY TO AVOID ACCIDENT AT INTERSECTION. ABLE TO COMPLETE SHORT DISTANCE HOME WHERE I INSPECTED BRAKES AND UNCOVERED RUSTED AND LEAKING BREAK LINES. VEHICLE WITH LESS THAN 90,000 MILES. EXTREMELY DANGEROUS AND GM/NHTSA SHOULD BE ASHAMED THAT A RECALL HAS NOT BEEN INITIATED. ONLY A MATTER OF TIME BEFORE SOMEONE IS NOT AS LUCKY AS ME AND OTHER COMPLAINANTS. *JB

Mileage: 86,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING, THE BRAKES FAILED TO STOP IN A TIMELY MANNER. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

Mileage: 21,000

ALL FRONT BRAKE LINES BELOW THE DRIVERS SEAT RUSTED THROUGH. A COMPLETE LOSS OF BRAKES WAS EXPERIENCED. *TR

Mileage: 55,687

MY WIFE WAS DRIVING MY TRUCK A 2006 SILVERADO AND SAID THE BRAKE LIGHT CAME ON SO I FILLED IT UP DIDN'T THINK MUCH OF IT DID A QUICK LOOK DIDN'T SEE ANYTHING 2 WEEKS LATER SHE SAID IT WAS ON AGAIN SO I FILLED IT UP AGAIN AND THIS TIME DID A THOROUGH INSPECTION CHECKED THE MASTER CYLINDER, BOOSTER STARTED CHECKED EACH CALIPER AND NOTHING SO I GOT UNDER THE TRUCK AND ITS LEAKING FROM THE MIDDLE OF THE TRUCK UNDER THE DRIVERS SEAT THE BRAKE LINES ARE ALL RUSTY. I DO ALL OF MY WORK ON MY CARS BUT THIS LOOKS RIDICULOUS WHERE DO YOU START RIP THEM ALL OUT AND REPLACE ALL? THEY ARE ON TOP OF THE FRAME RAIL WHICH LOOK IMPOSSIBLE TO GET TO IT LOOKS LIKE ITS GOING TO BE A LOT OF MONEY IS THERE A RECALL FOR THIS? I HOPE SOME CAN HELP ME OUT THE TRUCK IS VERY CLEAN ESPECIALLY UNDERNEATH THAT'S THE ONLY THING RUSTED OUT OF EVERYTHING. *LN

Mileage: 90,000

COMING UP TO TRAFFIC SIGNAL AND BRAKE PEDAL WENT TO THE FLOOR. BRAKE LINE RUSTED OUT. STOPPED BY SLAMMING IT INTO 1ST GEAR AND USING THE PARKING BRAKE. VERY DANGEROUS! *TR

Mileage: 135,000

BRAKE LINE HAS COMPLETELY DETERIORATED AND LEAKING AND SHOULD BE RECALLED. RECENTLY HAD TO REPLACE WHEEL SPEED SENSORS AS WELL. *TR

Mileage: 80,000

PULLING TRUCK OUT OF GARAGE THE BRAKE PEDAL WENT TO THE FLOOR. UPON EXAMINATION THE BRAKE LINE HAD BLOWN A HOLE THRU THE RUSTED BRAKE LINES. ALL OF THE BRAKE LINES THAT ARE NOT COATED ARE RUSTED AND INTEGRITY OF THE METAL IS POOR. HAD TO HAVE ALL BRAKE LINES REPLACED FOR A SUM OF $900.. *TR

Mileage: 69,269

VEHICLE WAS TAKEN TO HAVE 4 NEW TIRES INSTALLED. AS PART OF THIS PROCESS THE VEHICLE WAS LIFTED OFF THE GROUND AND THE STEERING COMPONENTS AND SUSPENSION SYSTEM WAS CHECKED FOR WEAR. AS THIS PROCESS WAS TAKING PLACE ONE OF THE MECHANICS NOTICED THE RUSTED BRAKE LINES AND CALLED ME OVER TO SHOW HOW BAD THE LINES WERE RUSTED. *TR

Mileage: 80,375

THE VEHICLE WAS PARKED AND I ENTERED IT TO START IT. WHEN I APPLIED MY FOOT TO THE BRAKE PEDAL I HEARD A LOUD POP (LIKE A BALLOON POPPING) AND A RECOIL IN THE BRAKE PEDAL. COME TO FIND OUT, THE DIAPHRAGM IN THE BRAKE BOOSTER BROKE THUS LEAVING ME WITH VERY LITTLE BRAKES. I AM JUST GLAD I WAS THE ONE BEHIND THE WHEEL AND THE VEHICLE WAS IN PARK. I CAN ONLY IMAGINE IF THIS HAD HAPPENED WHILE DRIVING THROUGH TOWN. OR IF SOMEONE LIKE MY 18 YEAR OLD SON HAD BEEN DRIVING. AFTER SPEAKING WITH MULTIPLE MECHANICS, IT WAS BROUGHT TO MY ATTENTION THAT THIS IS ONE OF THOSE THINGS THAT "NEVER HAPPENS"...ESPECIALLY ON A 2006 WITH ONLY 63K MILES ON IT. WHEN I CALLED CHEVROLET THEY TOLD ME THAT IT WOULD BE NOTED BUT THEY COULD NOT HELP COVER THE COST OF REPAIR AS IT WAS NOT UNDER WARRANTY. ALTHOUGH I DO KNOW IT'S OUT OF WARRANTY, I THOUGHT THEY MIGHT COVER IT AS IT IS NOT A WEAR AND TEAR ISSUE...IT IS A MECHANICAL DEFECT AND A MAJOR SAFETY ISSUE. IT HAS BEEN REPAIRED AND I'M JUST HOPING IT DOES NOT OCCUR AGAIN. UNFORTUNATELY THERE IS ABSOLUTELY NO WAY AT ALL TO PREDICT IF AND WHEN THIS WILL EVER OCCUR ON ANY OTHER VEHICLE. I JUST HOPE IT DOESN'T HAPPEN TO MINE AGAIN. *TR

Mileage: 62,368

BRAKE LINES RUSTED OUT. THIS IS THE SECOND TIME I HAVE HAD THIS PROBLEM WITH THIS VEHICLE. A HOLE DEVELOPED IN A BRAKE LINE WHICH RESULTED IN NO BRAKES AT ALL. I HAD TO SPEND $1400 AT THE CHEVY DEALERSHIP TO HAVE ALL OF MY BRAKE LINES AND FRONT CALIPERS REPLACED. *TR

Mileage: 63,330

DRIVING MY 2006 SILVERADO 3500 HD WHEN THE CAR AHEAD DECIDED ON A SUDDEN LEFT TURN. WENT TO APPLY MY BRAKES AND HAD TO STAND ON THE PEDAL WHILE SWERVING, NARROWLY MISSING THE COMPACT CAR. AFTER EVALUATION AT THE GM CERTIFIED DEALERSHIP WE USE FOR INSPECTION AND REPAIR ON ALL 8 OF OUR GM BUSINESS AND PERSONAL VEHICLES, WE WERE INFORMED THAT THE BRAKE EROSION/RUSTING WAS A COMMON DEFECT IN THE BRAKE LINES USED. CONTACTED GM AND THEY OFFERED TO PAY HALF OF THE $1400.00 BILL AND STATED THAT THERE IS NO RECALL FOR THIS ISSUE. THERE NEEDS TO BE A RECALL FOR THE SAFETY OF EVERYONE ON THE ROAD! *TR

Mileage: 54,000

DRIVING MY 2006 SILVERADO 3500 HD WHEN THE CAR AHEAD DECIDED ON A SUDDEN LEFT TURN. WENT TO APPLY MY BRAKES AND HAD TO STAND ON THE PEDAL WHILE SWERVING, NARROWLY MISSING THE COMPACT CAR. AFTER EVALUATION AT THE GM CERTIFIED DEALERSHIP THAT WE USE FOR INSPECTION AND REPAIR ON ALL 8 OF OUR GM BUSINESS AND PERSONAL VEHICLES, WE WERE INFORMED THAT THE BRAKE EROSION/RUSTING WAS A COMMON DEFECT IN THE BRAKE LINES USED. CONTACTED GM AND THEY OFFERED TO PAY HALF OF THE $1400.00 BILL AND STATED THAT THERE IS NO RECALL FOR THIS ISSUE. THERE NEEDS TO BE A RECALL FOR THE SAFETY OF EVERYONE ON THE ROAD! *TR

Mileage: 54,000

ABS KICK IN AT LOW SPEEDS INCREASING STOPPING DISTANCE BY SEVERAL FEET. *TR

Mileage: 45,000

2006 SILVERADO 1500 IN OCTOBER 2012, AS I APPROACHED A STOP LIGHT, MY BRAKE PEDAL LOST PRESSURE AND WENT TO THE FLOOR. I WAS ABLE TO PULL INTO A PARKING LOT AND STOP BY PUMPING THE PEDAL AND USING THE PARKING BRAKE. THE CAUSE WAS A RUSTED OUT BRAKE LINE, WHICH I PAID THE SHOP TO REPLACE. IN FEBRUARY 2013, I PRESSED THE BRAKE PEDAL TO SHIFT INTO DRIVE IN MY DRIVEWAY AND THE BRAKE PEDAL AGAIN LOST PRESSURE AND WENT TO THE FLOOR. I HAD THE TRUCK TOWED TO A MECHANIC AND UPON INSPECTION LEARNED THAT ALL OF THE BRAKE LINES ARE RUSTED OUT INCLUDING AT THE ABS MODULE CONNECTION POINT. THE ONLY REPAIR OPTION IS A $2000 JOB TO REMOVE THE BODY FROM THE TRUCK TO REPLACE EVERY SINGLE BRAKE LINE. THROUGH INTERNET SEARCHES AND BY MY MECHANIC'S EXPERIENCE, THIS IS CLEARLY A KNOWN PROBLEM THAT GM SHOULD BE RECALLING SILVERADOS FOR. *TR

Mileage: 100,000

BRAKE LINE RUST THROUGH. DRIVING DOWN THE ROAD HIT BRAKES WENT TO FLOOR. STILL HAD FRONT BRAKES AND WAS ABLE TO STOP. HAVING THE TRUCK TOWED TO HAVE LINES REPLACED. *TR

Mileage: 64,888

WHILE DRIVING 2006 CHEVY SILVERADO PICK UP TRUCK, MY WIFE EXPERIENCED SUDDEN AND TOTAL BRAKE FAILURE. WHEN SHE PRESSED ON BRAKES TO SLOW VEHICLE, PEDAL FELL TO FLOOR AND BRAKES WERE UNRESPONSIVE. MY WIFE BARELY AVOIDED AN ACCIDENT AND PULLED INTO SHOPPING CENTER. AFTER ARRIVING AT SCENE TO RETRIEVE MY WIFE, I CHECKED BRAKE FLUID LEVEL, WHICH WAS BELOW "MINIMUM". I ADDED A FULL CAN OF BRAKE FLUID, AND HAD HER PRESS BRAKES WHILE VEHICLE WAS STATIONARY. I COULD HEAR HISSING, AND SAW LIQUID SPRAY ESCAPE UNDER PRESSURE FROM UNDER HOOD. MECHANIC LATER INFORMED ME THAT BRAKE LINE FOR FRONT BRAKES WAS RUSTED THROUGH AND BRAKES FAILED WHEN SYSTEM PRESSURE FROM APPLYING BRAKES BURST THE RUSTED LINE. HE SAID MY WIFE WAS LUCKY SHE DIDN'T CRASH OR WORSE. HE ADVISED ME THAT ENTIRE UNDERCARRIAGE WAS VERY RUSTED AND OTHER PARTS WERE SO RUSTED THAT IN ORDER TO BLEED AIR FROM BRAKE SYSTEM, THEY HAD TO REPLACE RUSTED CALIPERS. I AM CONCERNED ABOUT SAFETY OF THIS VEHICLE AND BASED ON MY REVIEW OF OTHER DRIVERS' COMPLAINTS AND INTERNET FORUMS, IT APPEARS CATASTROPHIC BRAKE FAILURE IS A WIDESPREAD AND PERVASIVE PROBLEM FOR GM SILVERADO VEHICLES. SEE HTTPS://SITES.GOOGLE.COM/SITE/GMBADBRAKES/ PLEASE INVESTIGATE THIS AS A MATTER OF PUBLIC SAFETY. *TR

Mileage: 60,500

THE BRAKES ON THIS VEHICLE FAIL AT LOW SPEEDS (APPROX. 5 MPH). THIS IS A KNOWN PROBLEM FOR THIS VEHICLE. CHEVY HAS ISSUED A TECHNICAL BULLETIN ON THIS PROBLEM (LOW SPEED ABS ACTIVATION, BULLETIN #03-05-25-007C). I HAD THIS PROBLEM REPAIRED IN OCTOBER 2010. NOW THE SAME PROBLEM IS OCCURRING AGAIN, ROUGHLY 10,000 MILES LATER. INFORMATION ABOUT THIS PROBLEM IS READILY AVAILABLE ONLINE. MANY SILVERADO OWNERS HAVE COMPLAINED ABOUT IT. PLEASE ADVISE IF THERE HAS BEEN ANY RECALL ACTION ON THIS ISSUE. I BELIEVE THERE WAS A RECALL ON PRIOR MODELS, BUT NOT 2006 AND BEYOND MODELS, ALTHOUGH IT IS CLEARLY STILL A PROBLEM. *TR

Mileage: 98,000

LEFT MY DRIVEWAY AT 5AM TO GO TO WORK. AT THE END OF THE BLOCK IS A STOP SIGN. APPLIED MY BRAKES AND THE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR. COULD NOT STOP AND WENT THRU THE STOP SIGN. THERE WAS NOT LIGHTS OR WARNING CONCERNING THE BRAKES. AT FURTHER INSPECTION I SAW THAT THE REAR BRAKE LINE WAS RUSTED THRU. NOTICED THAT ALL THE OTHER BRAKE LINES ARE ON THE VERGE OF RUSTING THRU AS WELL. A VERY SCARY SIGHT. *TR

Mileage: 135,000

I WAS DRIVING MY TRUCK AT SLOW SPEED TO A STOP SIGN WHEN THE PEDDLE WENT TO THE FLOOR I WAS BARELY ABLE TO STOP ALMOST HIT THE CAR IN FRONT OF ME GOT OUT AND SAW BRAKE FLUID FLOWING TO THE GROUND . THE REAR BRAKE LINE RUSTED OUT WHERE IT SPLITS TO THE REAR AXLE THIS SHOULD NEVER HAPPEN THIS TRUCK HAS LOW MILES UPON FURTHER EXAMINATION ALL THE METAL BRAKE LINES HAVE SOME SORT OFF CORROSION . AND NEED TO BE REPLACE THIS IS A SERIOUS SAFETY ISSUE THESE PARTS WERE MADE WITH INFERIOR METAL . DID SOME RESEARCH AND THIS SEEMS LIKE A VERY COMMON PROBLEM WITH THESE TRUCKS. *TR

Mileage: 47,690

BRAKE LINES RUSTED THROUGH, LEAKING FLUID. *TR

Mileage: 36,000

ABS APPLIES FOR NO REASON AT 10 TO 5 MPH. MAKING TRUCK TRAVEL 6 TO 15 FEET BEYOND EXPECTED STOPPING DISTANCE. I THINK THIS IS VERY DANGEROUS. *TR

Mileage: 66,000

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 35 MPH THE BRAKE WARNING LIGHT ILLUMINATED. THE CONTACT DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE WOULD NOT RESPOND. THE CONTACT WAS ABLE TO PARK THE VEHICLE AND UPON EXITING, NOTICED OIL LEAKING FROM UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN ADVISED THE CONTACT THAT THE BRAKE LINES WERE CORRODED AND WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 72,000.

Mileage: 72,000

TESTING NEW FRONT BRAKES AND REAR BRAKE LINES RUPTURED. LIMPED HOME, PARKED TRUCK CALLED GM. NEVER HAD THIS ISSUE IN THE PAST. GM SEEMS NOT VERY CONCERNED AND MAY GET BACK TO ME. I FEEL FORTUNATE TO HAVE ESCAPED SERIOUS INJURY TO MY FAMILY AND SELF. I THINK THAT IT IS UNCONSCIONABLE FOR GM TO USE INFERIOR PRODUCTS AND PLAY RUSSIAN ROULETTE WITH OUR SAFETY. PLEASE UTILIZE THIS INFORMATION TO RAISE THE SAFETY STANDARDS BY WHICH THESE COMPANIES HAVE COMPROMISED FOR THE SAKE OF THEIR PROFIT MARGINS. WHEN I NOTIFIED GM, MY CALL WAS PUT THROUGH TO SOMEONE([XXX]) IN THE PHILIPPINES. WHY WOULD THEY CARE ABOUT US? AMERICAN COMPANIES HAVE SOLD OUT AND FARMED OUT THEIR GOODS AND SERVICES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 77,000

HAD SOFT BRAKE PEDAL. NO WARNING LIGHT. PULL OVER TO SIDE OF ROAD. FOUND ROTTEN BRAKE LINES AT FRAME RAIL WHERE LINES CROSS OVER AT PLASTIC BLOCK THAT HOLDS LINES TO FRAME. FLUID LEAKED OUT. *TR

Mileage: 61,160