2016 CHEVROLET SPARK Problems & Recalls

While driving in early 2025, my 2016 Chevrolet Spark EV suddenly lost all ability to accelerate. The vehicle remained powered on but would not respond to the accelerator, and I was unable to fully shut it off. This created a safety hazard because I could not properly control or secure the vehicle, a...

While driving in early 2025, my 2016 Chevrolet Spark EV suddenly lost all ability to accelerate. The vehicle remained powered on but would not respond to the accelerator, and I was unable to fully shut it off. This created a safety hazard because I could not properly control or secure the vehicle, a...

I am the owner of a 2016 Spark EV, and the driver was my family member. The vehicle was charged and had a remaining driving range of 51 miles when the vehicle suddenly shut down on a major city road without any prior warning or symptoms of a problem. The vehicle did not restart immediately, and othe...

I am the owner of a 2016 Spark EV, and the driver was my family member. The vehicle was charged and had a remaining driving range of 51 miles when the vehicle suddenly shut down on a major city road without any prior warning or symptoms of a problem. The vehicle did not restart immediately, and othe...

The contact owned a 2016 Chevrolet Spark. The contact stated that while driving approximately 35 MPH, the vehicle was T-bone crashed into on the driver's side by a second vehicle. During the crash, the driver-side curtain air bags did not immediately deploy. The contact indicated that the air bag de...

Mileage: 44,813

I was driving downhill with the car in L on a highway and brakes failed. I could not engage the brakes at all but somehow the car slowed to a stop and I managed to pull into a parking spot and park. Two lights came on: Service Intellitrak and Service Brake Assist. The car has been inspected by the C...

The contact owns a 2016 Chevrolet Spark. The contact stated while driving 60 MPH, the transmission was slipping, and the cruise control was not operating correctly. Additionally, the RPM was elevated with the check engine warning light illuminated. The vehicle was taken to the local dealer and diagn...

Mileage: 85,000

Both Brake Assist and stabilitrack go out in conjunction with failure lights (no fore-warning). The vehicle was repaired by a Chevrolet dealership with qualified EV tech. Within two weeks that same brake system failures occurred. The issue greatly increases the force needed to press the brake pedal ...

I have had my 2016 Chevrolet Spark EV in for repairs to three Chevy dealers for issues regarding random brake stuttering and complete brake failure resulting in running stop lights and stop signs going 30> MPH. Failure and issues are intermittent, but it appears to be an overly sensitive ABS/ regene...

RANDOMLY WHEN I GET INTO MY CAR AND CRANK THE LIGHTS ON MY DASH,SCREEN WILL APPEAR- OTHER TIMES THEY WILL NOT. RANDOMLY WHEN DRIVING SHE WILL JUST BE DRIVING NORMAL AND IMMEDIATELY SHE SHUTS DOWN AND OFF WITH NO WARNING SIGNS AND NO WARNING LIGHTS ON DASH. THIS ISSUE HAS BEEN ONGOING SINCE THE PURC...

Mileage: 96,777

RANDOMLY WHEN I GET INTO MY CAR AND CRANK THE LIGHTS ON MY DASH,SCREEN WILL APPEAR- OTHER TIMES THEY WILL NOT. RANDOMLY WHEN DRIVING SHE WILL JUST BE DRIVING NORMAL AND IMMEDIATELY SHE SHUTS DOWN AND OFF WITH NO WARNING SIGNS AND NO WARNING LIGHTS ON DASH. THIS ISSUE HAS BEEN ONGOING SINCE THE PURC...

Mileage: 96,777

RANDOMLY WHEN I GET INTO MY CAR AND CRANK THE LIGHTS ON MY DASH,SCREEN WILL APPEAR- OTHER TIMES THEY WILL NOT. RANDOMLY WHEN DRIVING SHE WILL JUST BE DRIVING NORMAL AND IMMEDIATELY SHE SHUTS DOWN AND OFF WITH NO WARNING SIGNS AND NO WARNING LIGHTS ON DASH. THIS ISSUE HAS BEEN ONGOING SINCE THE PURC...

Mileage: 96,777

WHILE DRIVING THE VEHICLE EITHER A 'SERVICE STABILITRAK' OR 'SERVICE BRAKE ASSIST' WARNING LIGHT GOES ON ALONG WITH THE EMERGENCY BRAKE LIGHT AND THE BRAKES LOSE THEIR POWER. IT FEELS LIKE THE POWER STEERING HAS GONE OUT ONLY IT'S THE BRAKES. YOU HAVE TO PUSH WITH ALL OF YOUR POWER TO GET THE CAR TO...

Mileage: 31,000

THE WINDSHIELD WIPERS STOPPED OPERATING WHILE DRIVING ON A HIGHWAY IN THE RAIN. THE CAR WAS AT HIGHWAY SPEED. EXTREMELY DANGEROUS. THE MECHANIC FOUND THE WIPER MOTOR WAS DEFECTIVE AND PULLED TOO MUCH AMPERAGE THAT IT BURNED INTERNAL FUSE BOX RELAY. WIPER MOTOR AND FUSE BOX HAD TO BE REPLACED.

Mileage: 49,500

FEB 2018 I RECEIVED AN ERROR MESSAGE WHILE DRIVING FOR A CODE 95. AFTER REVIEW I DETERMINED IT WAS AN AIR BAG ERROR MESSAGE. I TOOK IT TO MK SMITH IN CHINO, CA AND THEY REPLACED THE PASSENGER AIR BAG MODULE. JULY 2020 I RECEIVED THE SAME CODE 95 AIR BAG WARNING MESSAGE. I TOOK IT BACK TO MK SMITH IN...

Mileage: 53,500

I OWN A 2016 CHEVY SPARK BOUGHT ON JANUARY 2020. OVER THE LAST WEEK (JULY 15) AT 36,569 MILES MY BRAKES HAVE BECOME SIGNIFICANTLY WEAKER WHERE I'M PUSHING MY FOOT ALL THE WAY TO THE FLOOR TO STOP THE VEHICLE. BACKING OUT OF MY DRIVEWAY WHICH IS FAIRLY STEEP, MY BRAKES WON'T STOP MY CAR UNLESS PRESS...

Mileage: 36,569

STEERING WENT OUT WHILE DRIVING AT AROUND 50 MPH. NO WARNING WAS GIVEN BY THE CAR'S MONITORING SYSTEMS UNTIL THE EVENT HAPPEN AND THERE WAS NO OTHER PREVIOUS STEERING ISSUES PRIOR TO THIS EVENT. ERROR CODES DID ILLUMINATE ONLY AFTER STEERING WAS GONE AND SHOWED A P 68 ERROR CODE. THE VEHICLE HA...

Mileage: 32,328

TRANSMISSION. *TR

Mileage: 119,000

TRANSMISSION. *TR

Mileage: 119,000

I DID MY RECALL FOR TRANSMISSION CONTROL MODULE BY CHEVEROLET DEALERSHIP AND ALL OF SUDDEN MY CAR SHUT OFF WHILE DRIVING IN BUSY TRAFFIC ON A BUSY ROAD. WOULD NOT TURN ON AT ALL, WOULD NOT GO OUT OF GEAR AT ALL. HAD TO HAVE TOAD BACK TO THE DEALERSHIP. BUT BC GM IS ON STRIKE RECEIVED NO LOANER CAR. ...

Mileage: 57,000

2016 CHEVY SPARK EV - 35,233 MILES. DRIVING STRAIGHT ON DOWNHILL CITY STREET. STABILITRAK FAILURE MESSAGE APPEARED, THEN BRAKES STOPPED RESPONDING. STEERED CAR INTO CURB TO FORCE IT TO STOP. BRAKE ALARM SYMBOL DISPLAYED ON SCREEN. CAR TOWED TO DEALERSHIP. DEALERSHIP SAID BRAKE ELECTRONIC CONTROL MO...

Mileage: 35,233

2016 CHEVY SPARK EV - 35,233 MILES. DRIVING STRAIGHT ON DOWNHILL CITY STREET. STABILITRAK FAILURE MESSAGE APPEARED, THEN BRAKES STOPPED RESPONDING. STEERED CAR INTO CURB TO FORCE IT TO STOP. BRAKE ALARM SYMBOL DISPLAYED ON SCREEN. CAR TOWED TO DEALERSHIP. DEALERSHIP SAID BRAKE ELECTRONIC CONTROL MO...

Mileage: 35,233

I HAD JUST LEFT THE HOUSE AND THE CAR WAS FINE. I GOT TO A DANGEROUS INTERSECTION WHERE WRECKS HAPPEN ALL THE TIME AND I PRESSED ON MY BREAKS AND MY CAR DID NOT WANT TO STOP SO I KEPT PRESSING HARDER AND HARDER FINALLY I STOPPED. WHEN I DID THE CAR CUT OFF. IT CONTINUED TO DO THIS FOR THE 15 MINUTE ...

Mileage: 42,000

THERE WERE TWO INCIDENTS INVOLVING THE SAME PROBLEM. WHILE DRIVING THE VEHICLE ON THE HIGHWAY AND THEN ON A MAIN ROAD THE BRAKES LOCKED AND I HAD TO USE THE EMERGENCY BRAKE TO BRING THE VEHICLE TO COMPLETE STOP. MY MECHANIC REPLACED THE ENGINE BRAKE VACUUM PUMP AFTER BOTH INCIDENTS. THE PUMP WAS BRO...

Mileage: 68,000

THERE WERE TWO INCIDENTS INVOLVING THE SAME PROBLEM. WHILE DRIVING THE VEHICLE ON THE HIGHWAY AND THEN ON A MAIN ROAD THE BRAKES LOCKED AND I HAD TO USE THE EMERGENCY BRAKE TO BRING THE VEHICLE TO COMPLETE STOP. MY MECHANIC REPLACED THE ENGINE BRAKE VACUUM PUMP AFTER BOTH INCIDENTS. THE PUMP WAS BRO...

Mileage: 68,000

AS I WAS DRIVING MY BRAKES GOT HARD PREVENTING ME FROM STOPPING ,I WAS DRIVING ON MY WAY TO PICK MY SISTER UP AND AS I WENT TO STOP TO TURN INTO HER DRIVEWAY MY BRAKES ARE SUPER HARD AND I WAS UNABLE TO COME TO A COMPLETE STOP FOR ABOUT A QUARTER OF A MILE WHEN I TOOK MY CAR IN TO GET IT INSPECTED T...

Mileage: 85,000

THE FRONT LIGHTS APPEAR TO HAVE A DEFECT IN THEM. WHEN I HAVE A BULB REPLACE IT GOES RIGHT OUT. I JUST PURCHASED THIS CAR ON 11/19/2018. I HAD THE OIL CHANGED TWICE ALREADY AND THE OIL INDICATOR CONTINUES TO COME ON.

THE FRONT LIGHTS APPEAR TO HAVE A DEFECT IN THEM. WHEN I HAVE A BULB REPLACE IT GOES RIGHT OUT. I JUST PURCHASED THIS CAR ON 11/19/2018. I HAD THE OIL CHANGED TWICE ALREADY AND THE OIL INDICATOR CONTINUES TO COME ON.

TL* THE CONTACT OWNS A 2016 CHEVROLET SPARK. WHILE BEING OPERATED AT A LOW SPEED, THE BRAKES MADE AN ABNORMAL NOISE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO CLASSIC CHEVROLET (LOCATED AT 1101 W STATE HIGHWAY 114, GRAPEVINE, TX) WHERE IT WAS DIAGNOSED THAT THE BRAKES NEEDED TO BE ADJUSTED AND THE BR...

Mileage: 9,659

TL* THE CONTACT OWNED A 2016 CHEVROLET SPARK. WHILE DRIVING APPROXIMATELY 45-50 MPH, THERE WAS AN ABNORMAL SMOKE ODOR IN THE CABIN OF THE VEHICLE. SUDDENLY, THE VEHICLE CAUGHT FIRE. THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE CONTACT STATED THAT THE FIR...

Mileage: 44,000

CLUTCH WORE OUT ON 2016 CHEVROLET SPARK LS IN LESS THAN 11,000 MILES (JUST OVER 1 YEAR OLD). I AM AN EXPERIENCED MANUAL TRANSMISSION DRIVER WHO HAS DRIVEN OTHER CARS TO OVER 125,000 MILES WITHOUT NEEDING A NEW CLUTCH. CLEARLY DEFECTIVE CLUTCH BUT THEY WOULDN'T COVER IT UNDER WARRANTY BECAUSE IT WAS ...

Mileage: 10,950

TL-

Mileage: 100

2016 SPARK VEHICLES BUILD WITH CONVEX MIRROR IN THE DRIVER SIDE. THIS GIVE YOU A FALSE IMAGE OF VEHICLES, AND WHEN YOU SWITCH LANE VEHICLES ARE CLOSER THAT THEY APPEAR. ALSO PASSENGER SIDE MIRROR DON'T HAVE THE LEGEND: "OBJECTS IN MIRROR ARE CLOSER THAN THEY APPEAR".

Mileage: 5

TL* THE CONTACT OWNS A 2016 CHEVROLET SPARK. WHILE DRIVING APPROXIMATELY 30 MPH, THE ENTERTAINMENT SCREEN AND INSTRUMENT PANEL LIGHTING FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE...

Mileage: 7,000

ON THE WAY BACK TO MY SAN FRANCISCO HOME FROM THE NOVATO CHEVROLET DEALER WHERE I HAD JUST PURCHASED A NEW BLACK 2016 CHEVROLET SPARK EV MY BRAKES STOPPED FUNCTIONING. JUST COMING OFF THE GOLDEN GATE BRIDGE, ON A SIGNIFICANT DOWNHILL GRADE, MY BRAKES STOPPED FUNCTIONING PROPERLY. AT FIRST THE BRAKES...

Mileage: 37

THE HEAD RESTRAINTS ARE TOO FAR FORWARD. IF I ADJUST THE SEAT TO SIT UP STRAIGHT, THEN MY HEAD IS TOO FAR FORWARD. SO I HAVE TO LEAN BACK IN MY SEAT IN ORDER FOR MY HEAD TO BE STRAIGHT. AFTER ONLY ONE MONTH OF DRIVING, MY BACK IS KILLING ME!

Mileage: 2,000