2005 CHEVROLET SUBURBAN 1500 Electrical System Problems

I NOTICED CORRODED AND WHAT I WOULD CALL CHARRED OR BURNT WIRING ON THE WIRING HARNESS FOR THE REAR LIFT GATE OF MY SUBURBAN. I NOTICED IT WHEN I OPENED THE LIFT GATE TO GAIN ACCESS TO THE REAR OF THE SUBURBAN. IT APPEARS THAT THE RUBBER GROMMET MATERIAL PROTECTING THE WIRING HARNESS, WAS BURNT OR MELTED AWAY. THE RUBBER HOSE THAT SUPPLIES WATER TO THE REAR WINDOW WASHER/WIPER HAD A HOLE IN IT, AND MAY HAVE BEEN LEAKING WINDSHIELD WASHER FLUID ONTO THE WIRES FOR A TIME. THE WIRES WERE BARE IN SOME SPOTS, SOME OF THE WIRE INSULATION LOOKED MELTED/BURNT AWAY, AND THEY LOOKED CORRODED/WITH A GREEN COLOR TO THEM. THE CONNECTOR THAT CONNECTS THE HARNESS, TO THE REST OF THE ELECTRICAL SYSTEM, LOOKED LIKE IT HAS SOME BLACK/ POSSIBLY BURNT RESIDUE ON IT. I CAN TAKE A GUESS AT BEST, THAT BECAUSE OF THE HOLE IN THE RUBBER HOSE, WATER MAY HAVE BEEN LEAKING ONTO THE ELECTRICAL WIRING/CONNECTIONS WHEN I USED THIS FEATURE TO CLEAR DIRT FROM THE LIFT GATE WINDOW, BUT I DON'T REALLY KNOW FOR SURE IF THAT IS HOW THE DAMAGE TO THE WIRING HARNESS HAS OCCURED! THANKS!

Mileage: 158,724

2005 CHEVROLET SUBURBAN 1500 4X4 FLEX FUEL, 5.3L. THIS VEHICLE'S INSTRUMENT CLUSTER DOES NOT WORK. TACHOMETER PEGS AND STICKS. THE SPEEDOMETER IS STUCK AT ZERO. THIS IS A VERY SERIOUS SAFETY CONCERN THAT GENERAL MOTORS/GM SHOULD DO A FREE RECALL FOR AS MANY OWNERS OF THIS VEHICLE HAVE THE SAME PROBLEMS. MY ABS SENSOR LIGHT COMES ON AND OFF NUMEROUS TIMES A DAY, AND CLUSTER STATES SERVICE AIR BAG. GENERAL MOTORS SHOULD ALSO FIX THIS FOR FREE UNDER A RECALL AS OTHERS HAVE THE SAME ISSUE WITH THIS VEHICLE. MY THIRD MAJOR COMPLAINT, IS THE VEHICLE STARTING PROBLEM/HARD START. IT TAKES TWO TURNS OF THE ENGINE FOR THE VEHICLE TO TURN ON AND STAY RUNNING. I HAVE RESEARCHED THIS ON VARIOUS SEARCH ENGINES, FORUMS, AND INCLUDING RECALL.GOV. GENERAL MOTORS SHOULD ADDRESS THIS ISSUES AS WELL UNDER A RECALL. GM INSTALLED FAULTY FUEL PUMPS OR FUEL PUMPS WITH FAULTY COMPONENTS IN THEM. A VEHICLE SHOULD START WITH ONE TRY. I SHOULD NOT HAVE TO GET THE FUEL PRESSURE GOING IN THE ON POSITION, OR CRANK IT TWICE FOR MY TRUCK TO START.

THE DRIVER SIDE SEAT HEATER RANDOMLY TURNS ITSELF ON. WHEN YOU TURN IT OFF IT COMES BACK ON AGAIN AND RANDOMLY CYCLES THROUGH THE VARIOUS SETTINGS. IT'S ALMOST A CONSTANT BATTLE TRYING TO KEEP IT TURNED OFF WHICH CREATES A HAZARDOUS SITUATION EQUAL TO, OR WORSE, THEN TEXTING WHILE DRIVING AS YOU HAVE TO KEEP LOOKING DOWN TO PUSH THE BUTTON, ESPECIALLY HERE IN FLORIDA WHERE YOU DON'T NEED (OR WANT) SEAT HEAT IN THE SUMMER. I'VE FOUGHT THIS TO THE POINT THAT I'VE WORN THE PAINT OFF THE SWITCH. IF YOU SEARCH THE INTERNET THIS IS A VERY PREVALENT PROBLEM WITH GM VEHICLES DURING THESE MODEL YEARS. I ALSO HAVE A 2006 GMC SIERRA THAT DOES THE EXACT SAME THING. I'VE BEEN TO AT LEAST 5 DIFFERENT DEALERSHIPS AND EITHER THEY CAN'T FIX IT OR THEY CLAIM THEY'VE NEVER HEARD OF THE PROBLEM. THAT CAN'T BE TRUE SINCE GM ISSUED A TSB FOR THIS PROBLEM BUT THE RECOMMENDED FIX (REPROGRAMMING THE DRIVER DOOR SWITCH) ACTUALLY DOES NOT FIX THE PROBLEM. IN FACT, WHEN THE DEALER REPROGRAMMED MY GMC IT ACTUALLY MADE IT WORSE TO WHERE IT HAPPENS MUCH MORE FREQUENTLY. I CONTACTED GM AND EVEN THOUGH I TOOK IT TO A DEALER 4-5 MONTHS AGO WHERE THEY COULDN'T FIX IT, GM SAYS I HAVE TO TAKE IT BACK TO THE DEALER (PAY ANOTHER $100 DIAGNOSTIC FEE) TO MEET THEIR POLICY THAT THEY WILL ONLY ADDRESS THE ISSUE IF YOU'VE BEEN TO A DEALER WITHIN THE LAST 30 DAYS. SOME REPORTS ARE THE SEAT HEATER ELEMENTS ARE SHORTING OUT. EITHER WAY THIS CREATES A VERY UNSAFE SITUATION FOR DRIVERS. GM SAYS I CAN PULL THE FUSE FOR THE SEAT HEATERS. HOWEVER, WHEN YOU REMOVE THE FUSE LABELED "SEAT HEATER" IT ACTUALLY DOES NOTHING. THE SEATS ARE STILL POWERED AND THE PROBLEM PERSISTS. THIS CLEARLY INDICATES AN ELECTRICAL PROBLEM AND DESIGN FLAW. THE ONLY SURE CURE IS TO REMOVE THE 30 AMP BREAKER UNDER THE DASH RENDERING YOUR DRIVER/PASSENGER INOPERATIVE. GM MUST FIX THIS PROBLEM BEFORE SOMEONE GETS KILLED FROM BEING DISTRACTED. *TR

Mileage: 50,000

I WAS DRIVING ON A TRIP TO FLORIDA WHEN AT 65 MPH MY SPEEDOMETER KEPT INCREASING AND PEGGED OUT AT THE 120 MPH MARK. I PULLED OVER TO TRY AND RESOLVE THE ISSUE BUT TO NO AVAIL IT STAYED STUCK AT THE 120 MPH MARK. WHEN I RESTARTED THE VEHICLE ALL MY CLUSTER GAUGES WERE PEGGED OUT: OIL, BATTERY, TEMP, AND EVEN GAS GAUGE. I ALSO STARTED GETTING INFO THAT MY AIRBAG SYSTEM NEEDED ATTENTION. FOUR WHEEL DRIVE LIGHT CAME ON JUST A DIFFERENT ARRAY OF MALFUNCTIONS CAME FLYING ACROSS MY DISPLAY. TO THIS DATE MY BATTERY GAUGE IS STILL PEGGED OUT MY AIRBAG LIGHT IS ON, SERVICE FOUR WHEEL DRIVE LIGHT STILL FLASHES INADVERTENTLY AND NOW MY DRIVERS SIDE HEATER AND CONTROLS ARE NOT WORKING CORRECTLY. BROUGHT IN TO REPAIR SHOP & THEY SAID NO RECALL HAS BEEN ISSUED SO MY COST WOULD RUN WELL OVER $1500.00. RIDICULOUS. OWN UP CHEVY FIX THIS. *TR

Mileage: 108,000

ELECTRICAL CLUSTER SPEEDOMETER WENT HAYWIRE THEN QUIT ODOMETER DID THE SAME. *TR

SPEEDOMETER VERY ERRATIC, SHOWS EXCESSIVE SPEEDS (120MPH) OR DOESN'T REGISTER CORRECT SPEED AT ALL. CALLED DEALER NUMEROUS TIMES ABOUT PROBLEM AND NEVER TOLD ABOUT THE TSB ONLY THAT IT WOULD BE OVER $600 TO FIX. DID RESEARCH ONLINE AND FOUND TSB AND CALLED AGAIN. THIS IS A HUGE SAFETY HAZARD AND ONE THAT CHEVROLET SHOULD ADDRESS ACROSS THE BOARD WITH THE VEHICLES AFFECTED BY THIS. THEN WAS TOLD CAN'T FIX IT BECAUSE OF MILEAGE UNLESS I PAY OUT OF POCKET. NOW NEEDLE IS STUCK AT ZERO AND UNFORTUNATELY BEING MILITARY WE DON'T GET PAID ENOUGH TO JUST SHELL OUT $600+ ON A WHIM. SOMEONE NEEDS TO MAKE CHEVROLET TAKE CARE OF THEIR FAULTY PRODUCTS, IF YOU PAY FOR A PREMIUM PRODUCT YOU SHOULD GET ONE. *TR

A/C SYSTEM WOULD RANDOMLY BLOW HOT AIR; THEN FAN WOULD RUN WITH IGNITION OFF; THEN FAN SPEEDS WOULD QUIT WORKING; FINALLY BLOWER QUIT ALTOGETHER. GM HAS 2 SERVICE BULLETINS OUT WITH EXACT PROBLEM DESCRIPTION, BUT THEY CLAIM MY VEHICLE NOT COVERED. *JS

I HAVE A CHEVY SUBURBAN 2005 MY SPEEDOMETER HAS STOPPED WORKING. I ALSO HAVE A 2005 DURAMAX THAT THIS HAS HAPPENED TO. I WOULD LIKE TO SEE A FULL BLOWN RECALL PLACED ON ALL GMC/CHEVY VEHICLES. APPARENTLY THESE ARE HUNDREDS OF THOUSANDS PEOPLE WITH THIS ISSUE ACROSS THE U.S./ WORLD ACCORDING TO FORUMS I HAVE BEEN ON. WHILE THERE IS A CLASS ACTION LAWSUIT OUT THERE FOR A VERY LIMITED GROUP OF GMC VEHICLES, MAKING LAWYERS RICH. INSTEAD OF TAKING CARE OF THE PEOPLE WHOM MAKE THIS WORLD ACTUALLY RUN. THIS ISSUE NEEDS TO SERIOUSLY LOOKED INTO. MY NEXT STEP IS TO GET THE MEDIA INVOLVED SHOWING HOW AGAIN THE AVERAGE CONSUMER CAN GET SCREWED BY THE BIG COMPANIES. I AM NOT KEEPING MY MOUTH SHUT ABOUT THIS. THANK YOU *TR

Mileage: 88,422

2005 CHEVY SUBURBAN ODOMETER IS FAULTY. IT STOP WORKING PROPERLY ON MY CHEVY TRUCK. IT OVERSHOOT THE SPEED ALL THE WAY TO MORE THAN 120MILES/HR WHEN I DO NOT GO OVER 30MILES/HR. GM NEEDS TO TAKE OWNERSHIP OF IT. NEEDS TO HAVE RECALL. IT IS SAFETY OF GENERAL PUBLIC. PLEASE FORCE THEM TO RECALL FOR THE ODOMETER. *TR

Mileage: 25,000

SPEEDOMETER STOPPED WORKING ON OUR 2005 CHEVY SUBURBAN. STARTED OUT GOING FROM 20 TO 100 AND NOT REGISTERING THE PROPER SPEED. NOW IS STUCK AT 120 MPH. COST RANGES FROM 300 TO 1000 DOLLARS TO FIX. HAVING TO USE GPS FOR SPEED WHICH IS A DISTRACTION AND SAFETY CONCERN. *TR

Mileage: 62,000

AT 99K MILES THE SPEEDOMETER STARTED ACTING ERRATIC. THERE ARE TIMES IT IS CORRECT AND TIMES WHEN IT READS 5 TO 25 MILES MORE THAN MY TRAVELING SPEED. IT IS DEFINITELY HIT OR MISS AS TO WHEN THIS WILL OCCUR. NOW THE OIL PRESSURE GAUGE AND THE RPM GAUGE ARE ACTING FAULTY AS WELL. I HAVE NOT TAKEN ANY MEASURES TO CORRECT THE SPEEDOMETER BUT IT WILL RESET ITSELF AFTER SEVERAL TIMES OF TURNING THE CAR ON AN OFF. THIS IS DEFINITELY A SAFETY HAZARD WHEN THE SPEEDOMETER READS ERRANTLY WHILE DRIVING ON THE INTERSTATE. *TR

Mileage: 99,350

SPEEDOMETER ON OUR 2005 SURBURBAN HAS BEEN MALFUNCTIONING LIKE ALL OTHERS REPORTED ON THIS SITE - OURS FOR WELL OVER TWO YEARS: SOMETIMES READS ZERO WHEN DRIVING AT HIGHWAY SPEEDS, OTHER TIMES IS TACKED AT OVER 120 MPH. WE CAN BE AT A STOP AND IT READS 90. AFRAID TO USE CRUISE CONTROL - WHO KNOWS WHAT WILL HAPPEN! WAITING FOR NHTSA TO DEMAND A RECALL THESE VEHICLES: WHAT WILL IT TAKE? SOMEONE DYING BECAUSE THEY HYDROPLANE, OR ROLL, OR REAR END SOMEONE BECAUSE THEY HAVE NO CLUE HOW FAST THEY ARE GOING? *TR

Mileage: 50,000

WHILE DRIVING THE SPEEDOMETER JUMPED TO 20 MPH AND NEVER DROPPED BACK DOWN. *TR

Mileage: 115,000

WE OWN A 2005 CHEVY SUBURBAN, AND THE SPEEDOMETER BEGAN TO JUMP AROUND AND ACT ERRATICALLY. IT NOW SHOWS ABOUT 60 MPH, EVEN THOUGH THE VEHICLE IS AT A STOP. GOES UP ABOVE 120 MPH WHILE DRIVING THROUGH TOWN. WE CALLED THE DEALERSHIP, AND JUST LIKE OTHERS REPORTED, WAS TOLD WE WERE GOING TO BE TAKEN FOR OVER $600 FOR A REPAIR THAT IS OCCURRING IN VIRTUALLY EVERY 2005 GM TRUCK (ALONG WITH OTHER YEARS). WE CAN NO LONGER TELL WHAT SPEED WE ARE DRIVING, WHICH IS A SERIOUS SAFETY HAZARD, ESPECIALLY FOR MY TEENAGE DRIVERS THAT DRIVE THIS VEHICLE. *TR

Mileage: 121,000

2005 CHEVY SUBURBAN THE SPEEDOMETER JUST WENT OUT @ 42,600K MILES. *TR

Mileage: 42,600

TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED HE NOTICED WHILE DRIVING 30 TO 40 MPH THAT THE SPEEDOMETER READ 120 MPH, AND WHEN DRIVING 70MPH THE SPEEDOMETER READ 0 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED. THE DEALER ADVISED THE CONTACT THAT THE INSTRUMENTAL CLUSTER PANEL FAILED. THE MANUFACTURER ADVISED THAT BECAUSE THE VEHICLE WAS OVER THE EXTENDED WARRANTY COVERAGE, THEY WOULD NOT ASSIST WITH THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 68,000 AND THE CURRENT MILEAGE WAS 69,000.

Mileage: 68,000

SPEEDOMETER NOT WORKING PROPERLY, EVEN WHEN THE CAR IS STOP IT SHOW 70 MPH. *TR

Mileage: 46,000

SPEEDOMETER FOR CHEVROLET SUBURBAN 2005 NO WORKING PROPERLY, EVEN WHEN THE CAR IS STOP THE SPEEDOMETER SHOW 70 MPH. *TR

Mileage: 46,000

2005 CHEVY SUBURBAN SPEEDOMETER FAILURE. WHILE DRIVING HIGHWAY SPEED SPEEDOMETER STOPPED INDICATING CORRECT SPEED, INDICATED 120 MILES PER HOUR. SPEEDOMETER IS NOT WORKING AT ALL. *TR

Mileage: 83,500

ON A HIGHWAY TRIP HOME, THE SPEEDOMETER GOT STUCK AT 73MPH AND STEADILY INCREASED IN SPEED UNTIL IT JUST POINTS DIRECTLY DOWNWARD. IT STAYS FACING DOWNWARD AND DOESN'T MOVE AT ALL NO. THE CHEVY DEALERS ALSO SAY THAT THERE IS A RECALL BUT OUR CARS VIN NUMBER DOESN'T MEET THE RECALL. THEY AGREE CHEVY SHOULD REPAIR THE VEHICLE. WHEN I CONTACTED CHEVY, THEY TOLD ME THE WOULD OFFER NO ASSISTANCE AND TO STOP CONTACTING THEM REGARDING THE PROBLEM. *TR

I HAVE A 2005 CHEVROLET SUBURBAN Z71 WITH 59,799 MILES. THE SPEEDOMETER ON IT RECENTLY STOPPED WORKING CORRECTLY. THE DAY THE SPEEDOMETER STOPPED WORKING CORRECTLY I WAS ON AN HOUR LONG TRIP ON THE HIGHWAY. DURING THE TRIP I NOTICED THE SPEEDOMETER SHOWED I WAS GOING 95 MPH. THE SPEEDOMETER CONTINUED TO INCREASE EVEN WHEN I SLOWED DOWN, UNTIL IT PASSED 120 MPH WHERE IT WAS STUCK FOR SEVERAL DAYS. IT STARTED TO SLOWLY GO BACK DOWN. SINCE THAT DAY THEN THE SPEEDOMETER CONTINUES TO SHOW THE INCORRECT SPEED OF THE VEHICLE. THE SPEEDOMETER SOMETIMES READS AS HIGH AS 120 MPH WHEN THE VEHICLE IS NOT MOVING, AND AT OTHER TIMES DISPLAYS THE VEHICLE GOING 10 MPH WHEN THE VEHICLE IS NOT MOVING, AND OTHER TIMES SHOWS CORRECTLY AT 0 MPH. THE PROBLEM SEEMS TO GET WORSE WHEN I DRIVE THE VEHICLE ON LONGER TRIPS. I HAVE CONTACTED THE LOCAL DEALERSHIP AND WAS TOLD THERE IS A RECALL TO CORRECT THIS PROBLEM BUT THAT MY VIN NUMBER IS NOT INCLUDED IN THE RECALL. *JB *TR

Mileage: 58,754

SPEEDOMETER DOES NOT WORK ON MY 2005 CHEVROLET SUBURBAN 1500. STOPPED WORKING AT ABOUT 60,000 MILES - THERE SHOULD BE A RECALL AS THIS IS A COMMON PROBLEM ON THIS VEHICLE AND IT COSTS APPROX. $500 TO FIX AND IT IS A SAFETY HAZARD. *TR

Mileage: 60,000

WE BOUGHT A 2005 CHEVROLET SUBURBAN IN EARLY 2006. IN EARLY 2008 THE SPEEDOMETER STARTED TO ACT UP (BOUNCING, STEADILY DECREASING UNTIL ZERO) WE HAVE JUST COMPLETED A LONG TRIP AND THE SPEEDOMETER WAS NOT WORKING FOR 4 HOURS. *TR

Mileage: 44,000

JUST GOT INTO MY 2005 CHEVY SUBURBAN 1500. THE SPEEDOMETER STOP WORKING. REGISTERING 100MPH WHILE I WAS AT A STOP LIGHT, NOT WORKING AT ALL WHILE I DROVE BACK TO THE HOUSE. THERE IS A LAWSUIT FOR 2004 MODELS AND ONLY UP TO 70,000MILES. THIS IS A CLUSTER FAILURE AFFECTING THOUSANDS OF SUBURBAN,TAHOE, AND SIMILAR MODEL OWNERS. THE DEALERSHIPS ARE CHARGING AN AVERAGE OF $450.00 TO REPAIR THIS DEFECT THAT, JUDGING FROM THE LAWSUIT IS A COMMON PROBLEM. IT AFFECTS MY MONITORING OF MY SPEED AND ENDANGERS THE PUBLIC AND ALSO PUTS DRIVERS IN A BAD POSITION WITH LAW ENFORCEMENT. GM IS OBLIGATED TO REPAIR A PROBLEM THAT THEY HAD KNOWLEDGE OF. THERE ARE TOO MANY OF THESE VEHICLES ON THE ROAD TO ALLOW THIS DEFECT AND POTENTIAL SAFETY ISSUE TO GO UNCHECKED. *TR

Mileage: 178,371

WE HAVE A 2005 CHEVROLET SUBURBAN WITH 50,000 MILES. OUR INSTRUMENT CLUSTER IS NOT WORKING PROPERLY. SPEEDOMETER IS STUCK, OTHER GAUGES (I.E. FUEL, OIL, TEMP) WORK INTERMITTENTLY. I BELIEVE THIS IS A HUGE SAFETY ISSUE FOR OBVIOUS REASONS! THE COST TO FIX THIS IS $650 AND AFTER MUCH RESEARCH I SEE MANY COMPLAINTS OF THE SAME NATURE! CHEVROLET HAS EVEN RECALLED THE 2003/2004 MODELS FOR THIS REASON! WHY NOT 2005? *TR

Mileage: 50,000

I HAVE A 2005 1500 CHEVY SUBURBAN THAT THE SPEEDOMETER READS ERRATIC. IT GOES 120+ WHILE AT A RED LIGHT OR 25 CRUISING DOWN THE INTERSTATE. THIS HAS BEEN GOING ON FOR ABOUT 5 MONTHS NOW. I TALK TO THE DEALERS AND THEY SAY THERE IS NOTHING THEY CAN DO THAT I WILL HAVE TO PAY THE 600-900 DOLLARS FOR THE REPAIRS. NOT KNOWING HOW FAST OR SLOW YOU ARE GOING ONLY GUESTAMATING IS VERY DANGEROUS FOR MYSELF ALONG WITH EVERYONE ELSE I SHARE THE ROAD WITH. *TR

Mileage: 35,000

SPEEDOMETER SHOWS 110 MPH WHEN CARS ARE PASSING ME. I BELIEVE AM GOING ABOUT 55 OR 60 MPH. I UNDERSTAND THE PROBLEM IS WITH THE INSTRUMENT CLUSTER IN THE DASHBOARD. *TR

Mileage: 42,200

IN NOVEMBER, MY SPEEDOMETER ON MY 2005 SUBURBAN 1500 STARTED FLUCTUATING ALL OVER THE PLACE. SOMETIMES IT DOESN'T EVEN READ ON THE NUMBERS. CALLED DEALER AND THEY SAID THEIR WAS A RECALL ONLY UP TO 2004. I READ ON LINE THAT ALOT OF PEOPLE WERE HAVING TROUBLE WITH THE CLUSTER. NOW IN BEGINNING OF FEBRUARY MY GAS GAGE IS READING WRONG. THINGS ON THE INSTRUMENT PANEL ARE NOT WORKING RIGHT. THIS ALL STARTED HAPPENING UNDER 50,000 MILES. MY HUSBAND IS LAID OFF AND WE JUST DON'T HAVE THE MONEY TO FIX IT. PLEASE HELP!! *TR

Mileage: 49,200

I HAVE A 2005 CHEVY SUBURBAN WITH ABOUT 55,000 MILES ON IT. FOR THE PAST 6-8 MONTHS, MY SPEEDOMETER AND OTHER GAUGES (OIL, ETC.) WILL STICK CAUSING INACCURATE READINGS. AT TIMES MY SPEEDOMETER IS ABOUT 30 MPH OFF FROM THE REAL SPEED, AND FOR THE MONTHS THE OIL GAUGE HAS READ OFF THE CHARTS. *TR

Mileage: 50,000

2005 CHEVROLET SUBURBAN APPROX. 64,000 MILES I HAVE A FAULTY READING SPEEDOMETER, WHICH I FEEL IS A SAFETY HAZARD. I NEVER KNOW HOW FAST I AM GOING. THANKFULLY I HAVE NOT HAD A ACCIDENT OR GOTTEN A SPEEDING TICKET YET. I TOOK IT IN TO MY MECHANIC, WHO TRIED REPLACING THE SPEED SENSOR IN THE TRANSMISSION, TO NO AVAIL. I KNOW THERE IS A RECALL FOR 2003 & 2004 MODELS. I TRIED CALLING THE GM HOTLINE AND WAS TOLD THERE ARE NO RECALLS FOR 2005. I CALLED A LOCAL DEALER WHO TOLD ME THE SAME THING. I DON'T KNOW WHERE TO GO FROM HERE. I WOULD LIKE TO GET IT FIXED BEFORE IT REACHES 70,000 MILES. THE DEALER DID ASK IF I WAS THE ORIGINAL OWNER. I ASSUME THEY WOULD SAY IF I WASN'T, THEY WOULD NOT FIX IT. I DON'T KNOW WHAT THAT SHOULD HAVE TO DO WITH ANYTHING. WHAT OR WHERE DO I GO FROM HERE? *TR

Mileage: 63,000

DEFECTIVE SPEEDOMETER, HAVE CONTACTED CHEVY ON SEVERAL OCCASIONS AND THEY REFUSE TO PAY FOR COST. GM RECALLED SAME DEFECT ON OTHER MODELS EXCEPT MINE WHICH IS A 2005 CHEVY SUBURBAN. CHEVY TOLD ME MY CAR EXCEEDED ALL WARRANTY DUE TO MILEAGE WHICH IS IN THE 80K RANGE. THIS IS A DEFECTIVE PART AND SHOULD BE REPLACED NO MATTER WHAT MILES I HAVE ON THE CAR. CURRENTLY THIS PROBLEM IS INTERMITTENT SO I'M NEVER SURE IF SPEEDOMETER IS RIGHT OR WRONG. MY TEENAGER DRIVES MY CAR AND IS UNABLE TO KNOW WHAT ACTUAL SPEED HE'S DRIVING. THIS IS POTENTIALLY DANGEROUS AND I CANNOT AFFORD TO REPAIR MYSELF. *TR

Mileage: 80,000

MY DAUGHTER WAS DRIVING DOWN THE ROAD AND SPEEDOMETER BEGAN ACTING ERRATICALLY. AT A STOP LIGHT SPEEDOMETER READS 25 MPH. IGNITION WAS TURNED ON/OFF WITH NO RESULTS. *TR

Mileage: 59,800

I HAVE A COMPLAINT ABOUT THERE NOT BEING A RECALL ON MY 2005 CHEVY SUBURBAN ON THE INSTRUMENT PANEL AND ELECTRICAL COMPONENTS. SOMETIME EARLIER THIS YEAR MY SPEEDOMETER STARTED JUMPING TO HIGHER SPEEDS AS I WAS DRIVING AND THEN GOT TO THE POINT IT WAS GOING ALL THE WAY PAST 120MPH. SOMETIMES IT WOULD RESET TO 0 AFTER THE VEHICLE WAS TURNED OFF. MOST RECENTLY IT HAS GONE PAST 120 AND WILL NOT RETURN TO THE NORMAL FUNCTIONS IT SHOULD HAVE. IT IS VERY DANGEROUS NOT TO KNOW HOW FAST YOU ARE GOING, HOWEVER, LIKE EVERYONE ELSE I CANNOT AFFORD THE $400-$600 TO PAY FOR SOMETHING THAT IS A MANUFACTURES DEFECT OBVIOUSLY! WITH SO MANY COMPLAINTS LISTED EXACTLY THE SAME ON THIS SITE, IT HAS TO BE A MANUFACTURES DEFECT. BESIDES THE SPEEDOMETER NOT WORKING PROPERLY, ALL THE INSTRUMENT LIGHTS ARE STARTING TO GO OUT OR NOT WORK. SUCH AS THE RADIO ON/OFF SWITCH NO LONGER LIGHTS UP. SOME OF THE OTHER RADIO LIGHTS DO NOT LIGHT UP. ON THE STEERING WHEEL, SOME OF THE CONTROLS DO NOT LIGHT UP. I CANNOT BELIEVE THAT I HAVE RECEIVED A LETTER LETTING ME KNOW OTHERS ARE ALSO EXPERIENCING PROBLEMS WITH THEIR CHEVY VEHICLES AND THEY HAVE STARTED A LAW SUITE. MY VEHICLE IS A 2005 MODEL, BUT SINCE I BOUGHT IT IN MARCH 2005, SO IT MUST HAVE BEEN MANUFACTURED BEFORE JAN 2005. THE LETTER SAYS IT COVERS UP TO 2004 MODELS AND MAY LATER INCLUDE THE 2005 MODELS. AS I SEE IT MINE IS DOING EXACTLY THE SAME AS EVERYONE ELSE AND NOTHING IS BEING DONE. COULD SOMEONE EXPLAIN WHAT HAPPENS NEXT? AND WHEN WILL CHEVY BE RESPONSIBLE FOR ALL THESE COMPLAINTS? *TR

THE SPEEDOMETER IN MY 2005 CHEVROLET SUBURBAN HAS DEVELOPED A TICKING NOISE IN THE PAST FEW DAYS. THE VEHICLE HAS 83, 300 MILES. IT STARTED AS A LOW CLICKING NOISE AND HAS CONTINUED TO BECOME LOUDER. I HAVE CONTACTED THE LOCAL CHEVROLET DEALERSHIP, WHICH GAVE ME NO SATISFACTION FOR REPAIRS. *TR

Mileage: 83,300

INSTRUMENT CLUSTER FAILURE. GAUGES NOT ACCURATE. I WAS TOLD INSTRUMENT CLUSTER WOULD NEED TO BE REPLACED AT MY COST. *TR

Mileage: 34,788

I RECEIVED A LETTER STATING THAT THE SPEEDOMETER OF MY MODEL VEHICLE HAD A RECALL (2005 SUBURBAN). I MISPLACED THE LETTER BUT DECIDED TO TAKE MY VEHICLE IN TO THE DEALERSHIP BUT WAS TOLD THAT I HAD TO PAY $100 DEDUCTIBLE. I'M NOT UNDERSTANDING WHY THE SPEEDOMETER CAN NOT BE REPLACED WITHOUT PRESENTING THE LETTER. *TR

Mileage: 61,000

2005 CHEVROLET SUBURBAN 48,500 MILES SPEEDOMETER QUIT WORKING FROM WHAT I HAVE READ ONLINE THIS IS A PROBLEM WITH MANY 2005 CHEVY VEHICLES. *TR

Mileage: 48,500

I HAVE A 2005 CHEVY SUBURBAN. AT A LITTLE OVER 49,000 MILES MY SPEEDOMETER NEEDLE BEGAN TO REPORT INACCURATE READINGS WHILE THE TRUCK WAS IN MOTION. AFTER A COUPLE OF DAYS THE NEEDLE FELL ALL THE WAY TO THE RIGHT OF THE PANEL AND WOULDN'T MOVE. AFTER GETTING QUOTE FROM THE DEALERSHIP TO REPLACE NEW AND CHECKING WITH SOME AREA JUNK YARDS I LEARNED THERE WERE POSSIBLE RECALLS ON OTHER CHEVY TRUCKS AND SUV'S. ONCE I CHECK ON THE INTERNET AND FOUND NUMEROUS PEOPLE EXPERIENCING THE SAME PROBLEM. ON TONIGHT I CALLED AND LEARNED THAT THE 2004 SUBURBAN HAS A RECALL BUT NOT THE 2005 SO I OPENED A CASE WITH CHEVEROLET CONSUMER ASSISTANCE TO SEE ABOUT GETTING MY TRUCK FIXED AS I CAN'T AFFORD $500 TO FIX A MECHANICAL DEFECT WHICH SHOULD BE COVERED CHEVROLET EXPENSE AND NOT THE CONSUMER. I'M NOW DRIVING AROUND NOT KNOWING WHAT SPEED I'M DRIVING AND RISKING GETTING A SPEEDING TICKET WHICH IS ANOTHER EXPENSE. I'M A SINGLE MOTHER WITH 2 KIDS AND THIS IS MY ONLY MEANS OF TRANSPORTATION.

Mileage: 49,024

THE SPEEDOMETER ON MY 2005 CHEVROLET SUBURBAN AT 50K MILES WITHOUT WARNING STARTED TO INDICATE INCORRECT SPEEDS. THE SPEED READINGS INITIALLY WERE SLOWER THAN MY ACTUAL SPEED AND LATER AS THE PROBLEM PROGRESSED MUCH HIGHER. THE INITIAL INCORRECT SPEEDS WERE ONLY NOTICED AFTER FRIENDS FOLLOWING ME QUESTIONED MY HIGH RATE OF SPEED. MY WIFE DRIVES MY 4 CHILDREN AROUND IN THIS VEHICLE. *TR

Mileage: 50,000

INSTRUMENT PANEL FAILURE. SPEEDOMETER STUCK BELOW 0 (ZERO). TIRE PRESSURE READINGS KEEP CHANGING IN MINUTES RANGING 20-46. SCHEDULE FOR REPLACEMENT OF THE INSTRUMENT PANEL CLUSTER AND WILL COST $450-600. *TR

Mileage: 52,780

WHILE DRIVING THE SPEEDOMETER BEGAN TO GIVE ERRATIC READINGS, THE NEEDLE BOUNCED AROUND AND GAVE INACCURATE INFORMATION. THIS INITIAL PROBLEM SEEMED TO RESOLVE ITSELF WHEN I STOPPED AND TURNED THE VEHICLE OFF AND THEN RESTARTED IT. SINCE THE INITIAL INCIDENT THE PROBLEM HAS BEEN SPORADIC BUT BECOMING MORE FREQUENT. THE VEHICLE IS CURRENTLY SCHEDULED FOR SERVICE. *TR

Mileage: 57,250

TL*THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN 1500. THE CONTACT STATED THAT THE INSTRUMENTAL PANEL CLUSTERS DO NOT OPERATE PROPERLY. WHILE IDLING AT A STOP LIGHT, THE SPEEDOMETER GAUGE DISPLAYED 10-20 MPH. THE MANUFACTURER ISSUED A TSB FOR THE 2001-2003 MODELS, BUT NOT THE 2005. THE MANUFACTURER AND DEALER WOULD NOT REPAIR THE VEHICLE UNDER THE TSB. THE INSTRUMENTAL PANEL WAS REPLACED IN JANUARY OF 2008 AND THE CONTACT PAID FOR THE REPAIR. HE WOULD LIKE TO BE REIMBURSED BY THE MANUFACTURER. THE CURRENT MILEAGE WAS 53,296 AND FAILURE MILEAGE WAS 53,250.UPDATED 04/16/08.*LJ

Mileage: 53,250

SPEEDOMETER STICK AT 65MPH, NEXT TIME I START MOVING IT MOVES UP TO 120 MPS. OTHER TIMES IT STUCK AT VARIOUS SPEEDS. I DEPEND ON MY SPEEDOMETER TO KEEP ME SAFE. THE FIRST TIME IT HAPPENED I ALMOST CRASHED. SINCE THEN I HAVE HAD A COUPLE OF CLOSE CALLS. IF YOU CAN'T RELY ON YOUR SPEEDOMETER IT IS VERY STRESSFUL AND DANGEROUS! " PLEASE HELP US FIX THIS DANGEROUS PROBLEM". THANK YOU, MICHAEL J. SANFILIPPO *TR

Mileage: 56,911

ISSUE WITH INSTRUMENT PANEL (INCLUDING STEREO, LIGHTS ON PANEL, INSTRUMENT GAUGES), POWER WINDOWS/LOCKS & SECURITY SYSTEM - RANDOMLY SHUTS OFF. SOMETIMES THE ODOMETER WORKS AND OTHER TIMES IT DOES NOT. THE INSTRUMENT PANEL GAUGES ALL MOVE TO THE LEFT WITH THE GAS LIGHT COMING ON. THE TIRE PRESSURE MONITOR IS ACTIVATED. PANEL INDICATORS COME ON (ENGINE LIGHT, SECURITY SYSTEM, SEAT BELTS, ETC.). STEREO SYSTEM IS COMPLETELY OFF WITH NO LIGHTS ON THE PANEL. THE HEATER/AC SYSTEM SOMETIMES GOES OFF ALSO. THE POWER WINDOWS AND LOCKS DO NOT WORK DURING THESE TIMES. *TR

SPEEDOMETER OPERATES ERRATICALLY, STICKS WHEN CHANGING SPEEDS, OR READS ERRONEOUSLY (E.G. 5 MPH ON THE FREEWAY DOING 70 OR 100 MPH WHEN PARKED). *TR

Mileage: 82,000

THE SPEEDOMETER NEEDLE BEGAN READING HIGHER AND HIGHER SPEEDS EVEN THOUGH THERE WAS NO ACCELERATION. WHEN SITTING STILL, THE SPEEDOMETER READ 70 MPH. THE NEEDLE WILL NOT RETURN TO ZERO, EVEN WHEN THE VEHICLE IS PARKED.I HAVE CONTACTED THE DEALER AND WAS TOLD IT WOULD COST $400.00 TO $500.00 TO REPAIR. I CANNOT DRIVE THE VEHICLE, NOT KNOWING HOW FAST I AM GOING. *JB

Mileage: 57,357