High Severity Issue
This component has been associated with crashes, fires, or deaths.
This Problem Across All Years
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WHEN I BOUGHT THE TRUCK USED (85000 MLS)IT HAD A BAD FRONT END IDLER LINK AND A BAD A/C CLUTCH BEARING. NOT LONG AFTER I BOUGHT IT I HAD TO REPLACE THE ALTERNATOR. I ALSO NOTICED THAT THE BRAKES DIDN'T STOP THE VEHICLE LIKE THEY SHOULD AND I WAS SCARED TO LET MY WIFE DRIVE IT BECAUSE OF THE SPONGY BRAKES. I TOOK IT IN SEVERAL TIMES TO DIFFERENT SHOPS AND ALSO THE DEALER TO HAVE THEM LOOK AT THE BRAKES AND WAS ALWAYS TOLD THAT THE BRAKES ON THIS MODEL WERE JUST THAT WAY. I PUT NEW ROTORS AND PADS ON THE FRONT AND NEW REAR DRUMS AND SHOES AND REPEATEDLY BLED THE SYSTEM WITH SLIGHT IMPROVEMENT. IT ACTS AS THOUGH THERE IS A RESTRICTION IN THE BRAKE LINE TO BOTH FRONT AND REAR. IT ACTS AS THOUGH THEY DESIGNED THE THING NOT TO STOP QUICKLY. I UNPLUGGED THE MOTOR TO THE ABS SO THAT AT LEAST IT WOULD SQUEAL A TIRE. THE LACK OF SURE LOW SPEED STOPS HAS CAUSED 2 NEAR MISS ACCIDENTS AND 1 T BONE WHICH HAS RAISED OUR INSURANCE RATES. I HAVE LEARNED TO DRIVE THE THING ANTICIPATING STOPS AND PREBRAKING. I WENT TO THE DEALER AND JUST LIKE WITH THE WINDSHIELD WIPER CIRCUIT BOARD THAT SHORTED OUT WHEN IT GETS WET THEY TOLD ME THAT FOR MY SPECIFIC MODEL THERE WERE NO RECALLS AND THEY REFUSED TO LOOK AT IT. TO ADD INSULT TO INJURY LAST WEEK THEY SENT US A MAILER SAYING THAT THEY WOULD REPLACE MY BRAKE PEDAL WITH A DIFFERENT ONE TO GIVE ME A "BETTER FEEL". THAT WON'T DO ME MUCH GOOD IF I'M STUCK UNDER A BUS!!!!! I HAVE A VEHICLE WHICH HAS SUBSTANDARD BRAKES, WHICH WERE DESIGNED THAT WAY AND THEY WON'T DO A [XXX] THING ABOUT THEM. I LIKE A LOT OF THINGS ABOUT THE TRUCK BUT THE BRAKES SUCK BIG TIME.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
WHEN I BOUGHT THE TRUCK USED (85000 MLS)IT HAD A BAD FRONT END IDLER LINK AND A BAD A/C CLUTCH BEARING. NOT LONG AFTER I BOUGHT IT I HAD TO REPLACE THE ALTERNATOR. I ALSO NOTICED THAT THE BRAKES DIDN'T STOP THE VEHICLE LIKE THEY SHOULD AND I WAS SCARED TO LET MY WIFE DRIVE IT BECAUSE OF THE SPONGY BRAKES. I TOOK IT IN SEVERAL TIMES TO DIFFERENT SHOPS AND ALSO THE DEALER TO HAVE THEM LOOK AT THE BRAKES AND WAS ALWAYS TOLD THAT THE BRAKES ON THIS MODEL WERE JUST THAT WAY. I PUT NEW ROTORS AND PADS ON THE FRONT AND NEW REAR DRUMS AND SHOES AND REPEATEDLY BLED THE SYSTEM WITH SLIGHT IMPROVEMENT. IT ACTS AS THOUGH THERE IS A RESTRICTION IN THE BRAKE LINE TO BOTH FRONT AND REAR. IT ACTS AS THOUGH THEY DESIGNED THE THING NOT TO STOP QUICKLY. I UNPLUGGED THE MOTOR TO THE ABS SO THAT AT LEAST IT WOULD SQUEAL A TIRE. THE LACK OF SURE LOW SPEED STOPS HAS CAUSED 2 NEAR MISS ACCIDENTS AND 1 T BONE WHICH HAS RAISED OUR INSURANCE RATES. I HAVE LEARNED TO DRIVE THE THING ANTICIPATING STOPS AND PREBRAKING. I WENT TO THE DEALER AND JUST LIKE WITH THE WINDSHIELD WIPER CIRCUIT BOARD THAT SHORTED OUT WHEN IT GETS WET THEY TOLD ME THAT FOR MY SPECIFIC MODEL THERE WERE NO RECALLS AND THEY REFUSED TO LOOK AT IT. TO ADD INSULT TO INJURY LAST WEEK THEY SENT US A MAILER SAYING THAT THEY WOULD REPLACE MY BRAKE PEDAL WITH A DIFFERENT ONE TO GIVE ME A "BETTER FEEL". THAT WON'T DO ME MUCH GOOD IF I'M STUCK UNDER A BUS!!!!! I HAVE A VEHICLE WHICH HAS SUBSTANDARD BRAKES, WHICH WERE DESIGNED THAT WAY AND THEY WON'T DO A [XXX] THING ABOUT THEM. I LIKE A LOT OF THINGS ABOUT THE TRUCK BUT THE BRAKES SUCK BIG TIME.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
THE BRAKES HAVE ALWAYS BEEN MUSHY. I UNDERSTSAND THAT ABS WILL RESPOND DIFFERENTLY TO EMERGENCY BRAKEING THAN "NORMAL" BRAKES BUT THIS THING IS A REAL ADVENTURE TO DRIVE WHEN YOU'VE GOT TO MAKE PANIC STOPS.IT SEEMS TO RESIST YOUR FOOT THE HARDER YOU PUSH THE LESS BRAKING YOU FEEL.THE FRONT LEFT WHEEL BEARING MODULE WENT OUT WHICH CAUSED THE DISK BRAKE TO GRAB AND BOTH FRONT TIRES TO WEAR VERY BADLY. THE ELECTRIC WIPER CONTROL WENT OUT BECAUSET THE CONTROL BOX IS IN THE ENGINE COMPARTMENT AND GOT WET. DAH! THE DRAG LINK BUSHING RUSTED OUT BECAUSE THE GREASE FITTING WAS APPARENTLY INACCESSABLE TO SERVICE AND NEVER GOT ANY GREASE. THE RADIATOR BEGAN LEAKING AT 90000 MLS. AT WHICH TIME I RAN A STOP LEAK PRODUCT IN IT WHICH STOPPED IT SO FAR. THE WATERPUMP WENT OUT AT 110,000 MLS AND THE ALTERNATOR AT 95000 MLS. BRAKES ARE BIGGEST CONCERN!!!!!
THE BRAKES HAVE ALWAYS BEEN MUSHY. I UNDERSTSAND THAT ABS WILL RESPOND DIFFERENTLY TO EMERGENCY BRAKEING THAN "NORMAL" BRAKES BUT THIS THING IS A REAL ADVENTURE TO DRIVE WHEN YOU'VE GOT TO MAKE PANIC STOPS.IT SEEMS TO RESIST YOUR FOOT THE HARDER YOU PUSH THE LESS BRAKING YOU FEEL.THE FRONT LEFT WHEEL BEARING MODULE WENT OUT WHICH CAUSED THE DISK BRAKE TO GRAB AND BOTH FRONT TIRES TO WEAR VERY BADLY. THE ELECTRIC WIPER CONTROL WENT OUT BECAUSET THE CONTROL BOX IS IN THE ENGINE COMPARTMENT AND GOT WET. DAH! THE DRAG LINK BUSHING RUSTED OUT BECAUSE THE GREASE FITTING WAS APPARENTLY INACCESSABLE TO SERVICE AND NEVER GOT ANY GREASE. THE RADIATOR BEGAN LEAKING AT 90000 MLS. AT WHICH TIME I RAN A STOP LEAK PRODUCT IN IT WHICH STOPPED IT SO FAR. THE WATERPUMP WENT OUT AT 110,000 MLS AND THE ALTERNATOR AT 95000 MLS. BRAKES ARE BIGGEST CONCERN!!!!!
VEHICLE WILL STALL WHEN DRIVING LONG DISTANCES, ALSO ANTI-LOCK BRAKES FAILED, PEDAL WENT LOW TO THE FLOOR, REAREND ANOTHER VEHICLE. *AK
VEHICLE WILL STALL WHEN DRIVING LONG DISTANCES, ALSO ANTI-LOCK BRAKES FAILED, PEDAL WENT LOW TO THE FLOOR, REAREND ANOTHER VEHICLE. *AK
AN ALLEGED MALFUNCTION IN THE ALTERNATOR, RESULTING IN AN ENGINE COMPARTMENT FIRE EA94-029A. *AK
AN ALLEGED MALFUNCTION IN THE ALTERNATOR, RESULTING IN AN ENGINE COMPARTMENT FIRE EA94-029A. *AK
BATTERY FLUID LEAKED FROM THE SIDE POSITIVE POST, DOWN THE BATTERY CABLE, CAUSING CABLE TO CORRODE AND SEPARATE, RESULTING IN A TOTAL ELECTRICAL FAILURE. TT
BATTERY FLUID LEAKED FROM THE SIDE POSITIVE POST, DOWN THE BATTERY CABLE, CAUSING CABLE TO CORRODE AND SEPARATE, RESULTING IN A TOTAL ELECTRICAL FAILURE. TT
VEHICLE SURGES BETWEEN 30 TO 40 MPH LITTLE RESPONSE FROM BRAKES. DIAGNOSIS DEFECTIVE PIECE IN STARTER MOTOR. TT
VEHICLE SURGES BETWEEN 30 TO 40 MPH LITTLE RESPONSE FROM BRAKES. DIAGNOSIS DEFECTIVE PIECE IN STARTER MOTOR. TT
ELECTRICAL SHORT CAUSED FUSE FOR REAR DEFOGGER/CLOCK/RADIO/COURTESY LIGHTS TO BLOW OUT. *AK
ELECTRICAL SHORT CAUSED FUSE FOR REAR DEFOGGER/CLOCK/RADIO/COURTESY LIGHTS TO BLOW OUT. *AK
ALTERNATOR SEIZED AND CAUGHT FIRE UNDER THE HOOD DUE TO INADEQUATE SIZE BEARING AND FRICTION FROM BELT THAT IGNITED THE INTERNAL WIRING. *AK
ALTERNATOR SEIZED AND CAUGHT FIRE UNDER THE HOOD DUE TO INADEQUATE SIZE BEARING AND FRICTION FROM BELT THAT IGNITED THE INTERNAL WIRING. *AK