2000 CHEVROLET SUBURBAN Service Brakes Problems

I STARTED MY SUBURBAN LIKE ANY OTHER DAY, STEP ON BRAKES TO RELEASE THE SHIFTER, PUT INTO DRIVE WITH NO PROBLEM, I WENT ONTO THE HIGHWAY AKA FREEWAY WITH NO PROBLEM, I NEEDED TO MAKE A PANIC STOP, AND THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR, TRYING TO USE THE EMERGENCY BRAKE PEDAL, THAT ALSO FAILED.. WHEN DID A AMERICAN MADE PRODUCT LIKE THE CHEVY SUBURBAN GAT SUCH A CHEAP MANUFACTURING OF BRAKE COMPONENTS... MY PREVIOUS CAR, 1987 VOLKSWAGEN VANAGON CAMPER NEVER NEEDED STEEL BRAKE LINES REPLACED. THE RUBBER HOSES I CAN UNDERSTAND... BUT STEEL BRAKES LINES SHOULD LAST LONGER THAN 25 YRS.

Mileage: 159,616

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT STARTED THE IGNITION AND THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WITHOUT WARNING WHEN IT WAS DEPRESSED. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE CABLE FAILED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 11,000.

Mileage: 11,000

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 4 MPH ON DRY ROAD SURFACES, THE ABS ENGAGED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE RECURRED WHENEVER COMING TO A STOP. IN 2005, THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC); HOWEVER, THE CONTACT HAD NOT EXPERIENCED A FAILURE AT THE TIME. THE REMEDY WAS INSUFFICIENT AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000. UPDATED 04/08/16*LJ *JS

Mileage: 106,000

WHILE DRIVING AT 30 MILES PER HOUR APPLIED THE BRAKES AND BRAKE PEDAL BECAME SOFT AND WENT TO THE FLOOR. THE VEHICLE BARELY CAME TO A STOP BEFORE I HIT ANYTHING. NO WARNING LIGHTS OR MESSAGES APPEARED BEFORE THIS HAPPENED. FOUND BRAKE FLUID LEAKING FROM RUSTED METAL TUBING ON FRAME JUST BEHIND DRIVER'S SIDE FRONT WHEEL.

Mileage: 179,380

BRAKES FAILED, HAD TO DRIVE OFF THE ROAD IN FEAR OF HITTING CAR IN FRONT OF ME. CORRODED REAR BRAKE LINES, REAR BRAKE LINE BLEW OUT. *TR

Mileage: 175,000

I WAS SITTING IN MY DRIVEWAY AND I PRESSED ON THE BRAKE TO ENGAGE REVERSE WHEN THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. THIS IS NOT A NORMAL BRAKING FOR OUR SUBURBAN. BRAKE FLUID WAS ADDED TO THE BRAKE FLUID COMPARTMENT AND BRAKES WERE RE-TESTED; BRAKE PEDAL CONTINUED TO GO TO FLOOR. FURTHER INVESTIGATION OF THE VEHICLE OUTSIDE THE SUBURBAN FOUND BRAKE FLUID LEAKING FROM BRAKE LINE WHEN BRAKE PEDAL WAS ENGAGED. *TR

Mileage: 210,000

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT STATED A ROUTINE MAINTENANCE HE WAS NOTIFIED THAT THE BRAKE LINE WAS CORRODED. THE TECHINICIAN STATED THAT THE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 146,000. UPDATED 11/7/14*CN UPDATED 7/27/2015*JS

Mileage: 146,000

MY FAMILY AND I (2 ADULTS AND 2 CHILDREN) ALONG WITH 2 OTHER BOYS (AGE 14) WERE DRIVING DOWN A HILL AND EXPERIENCED A COMPLETE BRAKE FAILURE. MY HUSBAND ATTEMPTED TO STOP AT A LIGHT AND DISCOVERED THAT THE BRAKES WERE INACTIVE. THE ROAD DECLINED STEEPLY FOR SOME TIME AND IT WAS A NIGHTMARE AS HE TRIED EVERYTHING (E.G., SHIFTING TO LOWER GEAR, EMERGENCY BRAKE, PARK) TO STOP THE CAR. AS WE WERE CLOSE TO A MAJOR HIGHWAY AND RIVER, MY HUSBAND HAD NO CHOICE BUT TO STOP THE CAR BY CRASHING INTO AN EMBANKMENT. GIVEN THE SPEED OF THE VEHICLE, IT WAS A HORRIFIC CRASH. I'M STILL RECOVERING FROM MULTIPLE BROKEN BONES. MY SON HAD TO HAVE EXTENSIVE SURGERY ON HIS FACE. WE ARE LUCKY TO BE ALIVE. IT APPEARS BRAKE FAILURE IN THIS AGE AND MODEL OF CHEVY IS NOT UNCOMMON AND THE COMPANY IS AWARE OF THIS PROBLEM. HOW CAN THEY STAND ASIDE AND RISK SO MANY LIVES? ONE MONTH PRIOR TO THE CRASH, OUR CAR HAD PASSED ITS ANNUAL INSPECTION AT A CHEVY DEALERSHIP. NO BRAKES ISSUES WERE IDENTIFIED. BETWEEN THE MENTAL AND PHYSICAL CHORES OF RECOVERING, IT HAS TAKEN ME THIS LONG TO GATHER THE ENERGY TO WRITE THIS COMPLAINT. OWNERS SHOULD BAND TOGETHER TO SUBMIT A CLASS ACTION LAWSUIT. CHEVY NEEDS TO BE HELD ACCOUNTABLE. OUR FAMILY IS LUCKY TO BE HERE. WE WILL NEVER PURCHASE ANOTHER CHEVY VEHICLE AGAIN. *TR

Mileage: 97,000

REAR BRAKE LINES NEEDED TO BE REPLACE DUE TO CORROSION IN JUNE 2012. NOW THE FRONT BRAKE LINES NEED TO BE REPLACED DUE TO CORROSION JULY 2013. I PURCHASED THIS VEHICLE NEW IN 2000. *TR

Mileage: 59,638

TL* THE CONTACT OWNS A 2000 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE ENTERING A PARKING SPOT AT AN UNKNOWN SPEED, SMOKE EMITTED FROM THE FRONT PASSENGER TIRE. THE CONTACT ALSO MENTIONED THAT THERE WAS A BRAKE FLUID LEAK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS FOUND THAT THE BRAKE LINES WERE CORRODED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 238,000. THE VIN WAS NOT AVAILABLE.

Mileage: 238,000

THE BRAKE PEDAL WENT ALL OF THE WAY TO THE FLOOR WHILE I WAS IN TRAFFIC GOING ABOUT 20 MPH. I WAS ABLE TO STOP MY SUBURBAN WITHOUT HITTING THE CAR IN FRONT OF ME BY PUTTING THE CAR IN 2ND GEAR AND USING THE EMERGENCY BRAKE. THERE WERE NO WARNINGS LIGHTS OR MESSAGES IN THE MESSAGE CENTER BEFORE OR AFTER THIS HAPPENED. THE BRAKE LINE BURST ALONG THE FRAME RAIL AT A SPOT APPROXIMATELY BETWEEN THE FRONT AND REAR DRIVER'S SIDE DOOR. *TR

Mileage: 203,458

I WAS DRIVING ON YORK ROAD IN MARYLAND GOING ABOUT 35 MILES PER HOUR WHEN THE CAR IN FRONT OF ME SUDDENLY STOPPED. I PRESSED ON THE BRAKE PEDAL BUT IT WENT STRAIGHT TO THE FLOOR. FORTUNATELY I HAD KEPT A GOOD DISTANCE BETWEEN MY CAR AND THE CAR IN FRONT OF ME. MY VEHICLE CAME TO A STOP ABOUT HALF AND INCH AWAY FROM THE CAR IN FRONT. AFTER THIS I HAD TO PULL OVER AND TAKE THE VEHICLE TO THE DEALER. DEALER FOUND THAT THE BRAKE LINES HAD RUSTED AND BRAKE FLUID WAS LEAKING HENCE THE REASON FOR THE CAR NOT BRAKING PROPERLY. *TR

Mileage: 175,000

STEEL BRAKE LINES ALONG REAR DIFFERENTIAL CORRODED AND FAILED RESULTING IN LOSS OF BRAKE FLUID AND BRAKING ACTIONS. *TR

Mileage: 187,000

STEEL BRAKE LINE ALONG RIGHT REAR FRAME MEMBER CORRODED AND FAILED RESULTING IN LOSS OF BRAKE FLUID AND BRAKING ACTION. INSPECTION OF OTHER STEEL BRAKE LINES SHOW EXTENSIVE CORROSION, DRAWING REASONABLE CONCLUSION THAT OTHER LINES WILL FAIL. ALL STEEL BRAKE LINES NEED TO BE REPLACED TO MAKE VEHICLE SAFE TO DRIVE. *TR

Mileage: 194,000

WHEN APPROACHING AN INTERSECTION TODAY THE TRAFFIC LIGHT TURNED RED AND WHEN I DEPRESSED THE BRAKE PEDAL IT COLLAPSED TO THE FLOOR CAUSING ME TO RUN THE LIGHT AND PASS INTO THE INTERSECTION. I THANK MY LUCKY STARS THAT NOBODY WAS INJURED. MY WIFE AND CHILD WERE TERRIFIED, AS WAS I, BUT WE MANAGED TO PASS THROUGH UNHARMED. *TR

Mileage: 188,000

I WAS TRAVELING DOWN A CITY STREET IN PHILADELPHIA TAKING MY YOUNG KIDS TO DAYCARE, WHEN I HAD TO COME TO AN ABRUPT STOP TO AVOID A VEHICLE MAKING AN ILLEGAL U-TURN. THE TRUCK WOULD NOT STOP THE BRAKE PEDAL WENT TO THE FLOOR THEN SLOWLY BROUGHT THE VEHICLE TO A STOP. I HAD THE TRUCK TOWED INTO A REPAIR FACILITY AND WAS TOLD BY THE MECHANIC MY SUBURBAN WAS THE THIRD IN TWO DAY PERIOD TO COME IN WITH RUPTURED BRAKE LINES DUE TO CORROSION. THIS MATTER NEEDS TO BE ADDRESSED BEFORE SOMEONE IS SERIOUSLY HURT OR KILLED. I JUST ARRIVED HOME A WEEK PRIOR FROM VACATIONING WITH MY ENTIRE FAMILY IN THIS VEHICLE. MY VEHICLE HAS BEEN ROUTINELY CHECKED AND SERVICED BY BRYNER CHEVY IN JENKIN TOWN PA. I WAS NEVER INFORMED MY BRAKE LINES WERE CORRODED. *TR

Mileage: 143,000

WAS SLOWING DOWN FOR A LIGHT AT AN INTERSECTION. WAS TRAVELING AROUND 15 MPH WHEN I STARTED TO BRAKE THEN THE PEDAL "POPPED" AND WENT TO THE FLOOR. IT DID COME TO A STOP ABOUT 20 FEET INTO THE INTERSECTION, LUCKY FOR THE 7 PASSENGERS THAT WHERE WITH ME NO ONE WAS COMING THROUGH THE INTERSECTION. I CANNOT BELIEVE THAT MY BREAK LINES ARE IN THIS CONDITION AT THIS AGE. I OWNED A 78 CHEVY FOR ABOUT 12 YEARS, THE BRAKE LINES LOOKED AS GOOD AS NEW THE DAY I SOLD IT. LOOKING FOR A GARAGE THAT CAN REPLACE ALL THE LINES WITH NON-GM PARTS. UNLIKE GM I VALUE THE LIFE OF MY FAMILY. GM JUST LOST ANOTHER CUSTOMER. *TR

Mileage: 180,118

MY HUSBAND WAS BACKING OUR SUBURBAN DOWN THE DRIVEWAY (A HILL) WHEN HE COMPLETELY LOST BRAKING. PEDAL WENT TO THE FLOOR AND VEHICLE WASN'T SLOWING. EMERGENCY BRAKE WAS INEFFECTIVE. HE TURNED INTO A BUSH AT THE BOTTOM OF THE HILL AND RAN IT OVER, AND THAT PLUS LEVEL ROAD SLOWED HIM ENOUGH THAT HE WAS ABLE TO STOP AND DRIVE BACK UP THE DRIVEWAY. THERE IS A TRAIL OF BRAKE FLUID ALL THE WAY UP ON THE LEFT SIDE. FRONT BRAKE LINES WERE REPLACED 2-1/2 YEARS AGO DUE TO CORROSION. *TR

Mileage: 149,700

THE BRAKE LINE ON THE DRIVER SIDE HAS CORRODED AND CAUSED A LOSS OF BRAKE FLUID. AS A RESULT, THE VEHICLE HAS LOST SIGNIFICANT BRAKING ABILITY. UPON EXAMINATION OF THE OTHER LINES, IT IS APPARENT THAT CORROSION HAS AFFECTED ALL VISIBLE BRAKE LINES. THE METAL HAS BEGUN TO FLAKE OFF ON ALL THE LINES DUE TO CORROSION. THERE IS A VISIBLE LEAK IN THE BRAKE LINE, BELOW THE DRIVER SIDE PASSENGER DOOR. THE VEHICLE IS NOT DRIVABLE IN THIS CONDITION. *TR

Mileage: 186,000

I WAS TRAVELING AT 40 MPH WHEN TRAFFIC STOPPED AHEAD. APPLIED BRAKES BUT BRAKE PEDAL DEPRESSED TO THE FLOOR WITH ONLY VERY MINOR BRAKING. AVOIDED ACCIDENT BY USING EMERGENCY BRAKE AND SWERVING ON TO THE RIGHT SHOULDER. THERE WAS NO WARNING ON THE INSTRUMENT PANEL OF LOW BRAKE FLUID, LACK OF BRAKING CAPACITY OR ANY OTHER PENDING BRAKE MALFUNCTION. AFTER GETTING VEHICLE SAFELY HOME A VISUAL INSPECTION REVEALED A MAJOR LOSS OF BRAKE FLUID FROM THE MASTER CYLINDER AND BRAKE FLUID LEAKING FROM ABOVE THE VEHICLE FRAME, BELOW THE DRIVERS SIDE FLOOR BOARD. MAJOR CORROSION HAS OCCURRED IN THE VICINITY OF THE LEAK. ALTHOUGH THIS IS A 2000 VEHICLE, IT ONLY HAS 74,480 MILE OF USE. AN INTERNET SEARCH REVEALS THAT AN NHTSA ACTION NUMBER : EA11001 HAS BEEN ESTABLISHED FOR SIMILAR COMPLAINTS. *TR

Mileage: 74,480