2000 CHEVROLET TAHOE Service Brakes Problems

The ABS caught on fire. Lost brakes and all brake fluid, no police reports because it was in my alley way as soon as I started moving, when it happened the ABS and brake lights both came on at the same time. No prior warning.

ABS/Traction Control wheel speed sensors corroded, causing the ABS to activate at low speeds and making it impossible to stop the car. This is the same issue as has been reported for other VIN numbers of the same vehicle; see Safety Recall 05068 Front Wheel Speed Sensor Corrosion, https://static.nhtsa.gov/odi/rcl/2005/RCRIT-05V379-8709.pdf. However, that recall was limited to vehicles registered in the "Rust Belt" states; it appears that as this vintage of vehicle has aged, vehicles outside the Rust Belt now are experiencing the same problem, suggesting that the recall should be broadened.

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHEN HIS DAUGHTER DROVE DOWN HILL AND THE BRAKE PEDAL WAS ENGAGED, THE BRAKE SYSTEM FAILED TO ENGAGE CAUSING THE DRIVER TO HIT A PERSON THAT WAS DRIVING A BICYCLE. THE VEHICLE WENT UP A HILL AND THE DRIVER PROCEEDED ATTEMPTING TO STOP THE VEHICLE BUT IT WENT UP A HILL, ROLLED BACKWARDS INTO BUSHES, AND CRASHED INTO A TREE WHERE IT CAME TO A STOP. THE POLICE WAS PRESENT AND A REPORT WAS FILED; THE POLICE REPORT NUMBER WAS NOT AVAILABLE. THE PERSON ON THE BICYCLE WAS TAKEN TO THE HOSPITAL AND SUFFERED UNKNOWN FRACTURES TO THE BODY. THE DRIVER DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS TOWED TO THE CONTACTS FATHER RESIDENCE AND HE NOTICED THAT THE BRAKE LINES WERE CORRODED AND BRAKE FLUID WAS ON THE GROUND. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CALLED HOWEVER THERE WAS A LONG WAIT TIME AND A REPRESENTATIVE WAS NOT AVAILABLE TO ANSWER THE CALL PROMPTLY. THE APPROXIMATE FAILURE MILEAGE WAS 166,000. THE VIN WAS NOT AVAILABLE.

Mileage: 166,000

WHILE DRIVING MY VEHICLE , I APPLIED THE BRAKES TO STOP AT A TRAFFIC LIGHT , AND THE BRAKE PEDAL TRAVELED ALL THE WAY TO THE FLOOR . THE TAHOE FINALLY STOPPED AFTER A MUCH LONGER THAN NORMAL DISTANCE . AFTER INSPECTING THE MASTER CYLINDER , THERE WAS HARDLY ANY BRAKE FLUID REMAINING . I FOUND THAT THE BRAKE LINES WERE VERY RUSTED , AND THAT THE LINE GOING TO THE REAR BRAKES WAS RUSTED THROUGH . THIS RUSTING OF THE BRAKE LINES SHOULD NEVER OCCUR !

Mileage: 119,000

IN 2011 MY ABS/BRAKE LIGHT STARTING COMING ON TOOK TO DEALERSHIP WAS TOLD HOW MUCH IT WOULD COST TO REPAIR. IN SEARCHING ONLINE HOW TO FIX, I SEE A RECALL WAS GIVEN TO SALT BELT STATES IN 2005. I OWN TRUCK SINCE 2002. TOLD BY GMC TODAY THE RECALL ALTHOUGH IT STATES SALT BELT STATES RECALL ONLY AFFECTED CERTAIN VIN #'S IS THIS CORRECT? FIRST OWNER LIVED IN SALT BELT STATE AND TRUCK MANUFACTURED IN SALT BELT. I SEE THERE ARE ADDITIONAL GMC PRODUCTS WITH SAME PROBLEM. WHY DON'T THEY REPAIR?

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE ATTEMPTING TO COME TO A COMPLETE STOP, THE ABS SYSTEM DISENGAGED CAUSING THE VEHICLE TO LUNGE FORWARD. THE CONTACT STATED THAT THE ABS SYSTEM WOULD RE-ENGAGE IF THE BRAKE PEDAL WAS RELEASED AND THEN DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WOULD BE AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE WOULD VEER TO THE LEFT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HUB BEARING ASSEMBLY ON THE DRIVERS SIDE OF THE VEHICLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE RECURRED ON THREE SEPARATE OCCASIONS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS FOR A PERIOD OF TIME AND THEN TURNING OFF THE VEHICLE, A BURNING OIL ODOR WOULD COME FROM THE VEHICLE. THE CONTACT STATED THAT WHILE HAVING THE VEHICLE SERVICED BY AN INDEPENDENT MECHANIC, IT WAS INFORMED THAT THERE WAS ENGINE OIL LEAKING FROM THE MAIN SEAL AND NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT THE ABS WARNING LIGHT ILLUMINATED WHEN ATTEMPTING TO PARK OR MAKING A TURN. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 05V379000 (SERVICE BRAKES, HYDRAULIC) AND 00V345000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Mileage: 150,000

WENT TO STOP AT STOP SIGN AT APPROXIMATELY 4MPH AND NO BRAKES. THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR WITHOUT ANY RESISTANCE OR HESITATION. AS A RESULT OF THE BRAKE MALFUNCTION I REAR ENDED AN ELDERLY COUPLE IN A LEXUS. RESULTING IN DAMAGE TO THEIR REAR BUMPER PLASTIC COVER AND MORE DAMAGE WAS DONE TO MY FRONT END OF THE DEFECTIVE 200 CHEVROLET TAHOE Z71 I WAS DRIVING

Mileage: 155,073

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. WHILE APPROACHING A STOP SIGN, THE BRAKES FAILED. THE CONTACT HAD TO APPLY EXCESSIVE FORCE IN ORDER TO STOP THE VEHICLE. AS A RESULT, THE CONTACT CRASHED THE VEHICLE INTO A POLE. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 256,345.

Mileage: 256,345

HELLO I AM EXPERIENCING THE EXACT SYMPTOMS DESCRIBED IN GM RECALL 05068C "THESE VEHICLES MAY HAVE A CONDITION PERMITTING CORROSION TO OCCUR BETWEEN THE FRONT HUB/BEARING ASSEMBLY AND THE WHEEL SPEED SENSOR. IF THE BRAKES ARE APPLIED WHILE THE VEHICLE IS TRAVELING AT A SPEED OF GREATER THAN 6 KM/H (3.7 MPH) BUT LESS THAN 16 KM/H (10 MPH), THE CORROSION MAY CAUSE AN UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. IF THIS CONDITION OCCURRED WHERE STOPPING DISTANCE IS LIMITED, A CRASH COULD OCCUR. " HOWEVER, MY VIN IS NOT INCLUDED IN THE BREAKPOINTS, EVEN THOUGH I HAVE A 2000 CHEVROLET TAHOE. I CAN DEMONSTRATE THAT THIS IS THE PROBLEM IN TWO WAYS, FIRST BY REPRODUCING WITH A SCAN TOOL THAT SHOWS UNEXPECTED ABS ACTIVATION DURING STOPPING AT THIS LOW SPEED, AND SECOND AFTER PULLING THE ABS FUSE THIS PROBLEM DOES NOT HAPPEN. THIS CLEARLY POINTS TO THE ABS ISSUE MENTIONED IN THE RECALL. I HAVE CONTACTED TWO LOCAL DEALERSHIPS, AND AFTER I ASKED ABOUT RECALLS THEY SAID MY VIN WAS INVALID. THEN I CONTACTED THE CHEVY CONTACT CENTER AND THEY SAID THERE ARE NO RECALLS FOR MY VEHICLE. SO NOW WHAT - SHOULD I JUST REPLACE THE ABS SENSORS AND MOVE ON, OR IS THERE ANY CHANCE OF GETTING THIS ACKNOWLEDGED BY GM AS PART OF THE RECALL?

Mileage: 102,000

TRIED TO STOP AND BRAKES FAILED DUE TO RUSTED THRU REAR LEFT STEEL BRAKE LINE. NOW HAVE 2 OTHERS RUSTED THRU. CAR IS AT MECHANIC SHOP NOW MECHANIC IS REPLACING ALL BRAKE LINES BECAUSE HE WOULD NOT TOUCH IT OTHER WISE .HESAID I CAN EXPECT AT LEAST A $1200.00 DOLLAR BILL OR MORE. *TR

Mileage: 123,000

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS, THE ABS ACTIVATED INDEPENDENTLY. THE DEALER STATED THAT THE VEHICLE HAD UNWANTED ABS ACTIVATION. THE DEALER CLEANED THE GROUNDS, CALIPERS, AND ROTORS, LUBED THE WHEEL SPEED SENSOR MOUNTS, AND CHECKED AND CLEANED THE HUBS. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,250. UPDATED 03/17/15*LJ

Mileage: 148,250

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT AND THE REAR BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS UNAVAILABLE.

Mileage: 120,000

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. WHILE DRIVING 10 MPH, THE VEHICLE FAILED TO RESPOND WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT CRASHED INTO A PARKED VEHICLE. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 183,000.

Mileage: 183,000

DRIVING TO GAS STATION PRIOR TO GOING ON VACATION, APPLIED BRAKES AND PEDDLE WENT TO THE FLOOR WITH NO WARNING LIGHTS ON TO INDICATE FAILURE OF THE BRAKE SYSTEM. I FOUND BRAKE TUBING FAILURE ON REAR DRIVERS SIDE. THE TUBING IS SO RUSTED THAT IT CAN NOT BE REPAIRED AND MUST BE REPLACED AT A DEALER THE COST IS AROUND $3000.00 FOR ALL NEW BRAKE TUBING, PROBABLY WHY GM HAS NOT FIXED THE PROBLEM IT'S A BIG MONEY MAKER. *TR

Mileage: 200,100

TRIED TO STOP AND BRAKES FAILED DUE TO RUSTED THRU REAR LEFT STEEL BRAKE LINE. NOW HAVE 2 OTHERS RUSTED THRU. *TR

Mileage: 160,000

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 45 MPH, THE REAR BRAKES MALFUNCTIONED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURE CAUSED THE STOPPING DISTANCE TO INCREASE. THE CONTACT DISCOVERED A PUNCTURE IN THE BRAKE LINE DUE TO THE BRAKE LINE MAKING CONTACT WITH THE FRAME OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 148,000.

Mileage: 148,000

IT WASN'T AN ACCIDENT, I WAS DRIVING MY TAHOE AND STOPPED AND GOT OUT WHEN I GOT BACK IN AND STARTED DRIVING I PUT MY FOOT ON BRAKE AND IT WENT TO THE FLOOR, AT THE TIME I DID NOT KNOW MY BRAKE LINE HAD BUSTED. IT WAS VERY SCARY FOR ME. NO WARNING LIGHT WENT ON TILL I WAS ALMOST HOME.. WE TOOK IT TO A SHOP TO HEAR THE BRAKE LINE HAD RUSTED THROUGH. I SENDING THIS COMPLAINT DO THE FACT I HEARD ON THE NEWS THAT THIS HAS BECOME A PROBLEM WITH THIS TAHOE. WE WERE PLANNING ON LEAVING THAT EVENING WITH OUR CAMPER. ITS A GOOD THING IT HAPPENED BEFORE WE LEFT OTHERWISE THERE COULD OF BEEN A SERIOUS ACCIDENT PULLING THE CAMPER AND NOT BEING ABLE TO STOP. PLEASE LOOK INTO THIS MATTER. *TR

AS I STOPPED MY TAHOE AT MY APARTMENT, MY FRONT BRAKE LINE BURST DUE TO CORROSION. I LOST ALL BRAKE POWER, AND BRAKE FLUID IS LEAKING OUT FROM THE BURST LINE. *TR

Mileage: 191,000

DRIVING AT LOW SPEED AND TRIED TO STOP AT STOP SIGN BUT BRAKE LINE BURST AND VEHICLE WOULD NOT STOP AT ALL. AS A RESULT CAR WENT THRU STOP SIGN BUT LUCKY NO OTHER CAR WAS PRESENT. CAR EVENTUALLY ROLLED TO A STOP. MECHANIC SAID BRAKE LINE RUSTED THRU AND REPLACED IT AND SEVERAL OTHER LINES THAT HAD SEVER RUST GOING ON. *TR

Mileage: 250,000

I WAS DRIVING AT ROUGHLY 45 MPH ON A PUBLIC ROAD WHEN I WAS CUTOFF BY ANOTHER VEHICLE WHO ALSO NEARLY CAME TO A STOP. I QUICKLY BRAKE AND WHILE THE BRAKES DID MOMENTARILY WORK THE PEDAL THEN BECAME VERY SOFT AND FELL TO THE FLOORBOARD. THE OFFENDING VEHICLE THEN MADE ITS TURN OR I WOULD HAVE HIT THEM. I LIMPED THE VEHICLE HOME WHERE I FOUND A BUSTED BRAKE LINE DUE TO BAD RUST. THIS IS A VERY DANGEROUS SITUATION. *TR

Mileage: 192,000

THIS IS THE SECOND BRAKE INCIDENT I HAVE HAD WITH OUR TAHOE WITHIN THE PAST YEAR. IN OCTOBER 2012, I WAS DRIVING THE TAHOE TO AN AUTO SHOP FOR THE YEARLY INSPECTION. UPON ARRIVAL, ONE OF THE BRAKE LINES BLEW. AT THAT TIME, WE HAD ALL OF THE SOFT BRAKE LINES REPLACED DUE TO CORROSION. WE WERE LIVING IN THE NORTHEAST AT THAT TIME. THAT REPAIR WAS $800. ON JANUARY 6, 2014, I WENT TO DO SOME ERRANDS. AS I ARRIVED HOME AND PULLED INTO MY GARAGE, THE BRAKE PEDAL WENT TO THE FLOOR AND THE CAR MADE A HISSING SOUND FROM THE BACK. I TURNED THE CAR OFF AND THERE WAS FLUID LEAKING FROM BEHIND THE DRIVER'S REAR TIRE. UNBELIEVABLE! WE HAD THE TAHOE TOWED THE NEXT DAY TO AN AUTO SHOP AND WERE TOLD THAT THE "HARD" LINE IN THE BRAKING SYSTEM IS RUSTED AND CORRODED. WE WERE QUOTED BETWEEN $1500-2000. WE ALSO CALLED THE DEALER FOR AN ESTIMATE AND WERE QUOTED $3000+. THIS IS RIDICULOUS! I'VE HAD MORE THAN ONE MECHANIC TELL ME THAT THIS IS A KNOWN PROBLEM WITH THE TAHOES AND THE RUST. BOTH OF THESE INCIDENTS WE WERE VERY LUCKY NOT TO HAVE HAD AN ACCIDENT. WHY THEY ARE NOT DOING ON A RECALL ON THIS IS BEYOND ME. HOW MANY CARS DOES IT TAKE TO HAVE THIS FAILURE BEFORE THEY DO??? OR GOD FORBID, THEY ARE WAITING FOR A CERTAIN NUMBER OF INJURIES OR DEATHS BEFORE THAT SPARKS A RECALL. I AM TIRED OF SHELLING OUT MONEY FOR THIS MATTER OVER AND OVER. WE HAVEN'T DECIDED ON WHETHER IT'S WORTH REPAIRING BUT IF WE DECIDE TO BUY, IT WON'T BE CHEVY. THEY OBVIOUSLY DON'T CARE. *TR

Mileage: 130,000

TL* THE CONTACT OWNS A 2000 CHEVROLET TAHOE. THE CONTACT STATED THAT THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 204,419.

Mileage: 204,419

WHILE COMING TO A STOP IN TRAFFIC MY BRAKE PEDAL SUDDENLY DROPPED TO THE FLOOR. I TRIED TO PUMP THE PEDAL TO GAIN SOME SORT OF PRESSURE AND STOPPING POWER BUT THE PEDAL WAS NOT RESPONDING. LUCKILY I WAS ALREADY SLOWED DOWN TO A SPEED THAT DID NOT CAUSE INJURY TO MYSELF, MY PASSENGERS OR THE VEHICLE THAT I HAD HIT IN THE REAR BUMPER. WHEN I EXITED MY VEHICLE I NOTICED BRAKE FLUID COMING FROM THE AREA WERE THE FENDER AND THE DOOR COME TOGETHER AND ALSO TOWARDS THE BACK OF THE DOOR WERE IT MEETS THE REAR DOOR JAM. UNDER INSPECTION IT APPEARS I HAD 2 FAILURES AT THE SAME TIME. THE FRONT BRAKE LINE FAILED AND SO DID THE REAR. THE CORROSION IS HORRIBLE AND HAS ALSO CONSUMED THE FUEL LINES. I BELIEVE THEY ARE THE NEXT TO GO. I DON'T UNDERSTAND HOW A COMPANY WILL SPEND THE MONEY TO INSTALL A STAINLESS EXHAUST SYSTEM THAT WILL SURVIVE ALMOST FOREVER BUT THEY WILL NOT INVEST THE MONEY ON THE BRAKE AND FUEL LINES TO BE MADE OUT OF STAINLESS STEEL. I AM VERY FORTUNATE THAT I WAS NOT TRAVELING AT A HIGH RATE OF SPEED, THE OUTCOME WOULD HAVE BEEN MUCH WORSE FOR EVERYBODY INVOLVED. *TR

IN 2011 AT A TRAFFIC LIGHT INTERSECTION BRAKES FAILED ON MY 2000 CHEVY TAHOE (60K MILES). BRAKE PEDAL FULLY DEPRESSED SLOWED THE VEHICLE ENOUGH TO SWERVE AND AVOID A COLLISION. REPAIR REVEALED EXTENSIVE CORROSION ON BRAKE LINE THAT CAUSED IT TO RUPTURE. THE REPAIR IS EXTREMELY COSTLY SINCE THESE LINES ARE DIFFICULT TO ACCESS, AND THEY MUST BE CUSTOM BENT AND FITTED. TO REPLACE ALL LINES WOULD HAVE COST $1500-$2000 TO REPAIR. AS A RESULT, LIKE MANY PEOPLE AFFECTED BY THIS DEFECT, WE OPTED TO ONLY REPAIR THE DAMAGED LINES. IN HINDSIGHT THIS WASN'T THE BEST CHOICE, BUT THE VEHICLE WAS UNDRIVEABLE AND WE DIDN'T HAVE THE MONEY TO REPAIR IT FULLY. PREDICTABLY THIS FAILURE HAPPENED AGAIN ABOUT A YEAR LATER IN A SIMILAR SITUATION. LUCKILY AGAIN IT WAS ON A RESIDENTIAL STREET AND WE WERE ABLE TO AVOID YET ANOTHER COLLISION. I CAN ONLY IMAGINE IF IT WAS ON THE HIGHWAY, ON A MOUNTAIN ROAD OR WHILE TRAILERING A BOAT ETC. SUBSEQUENT TO THE LATEST FAILURE WE SOLD THIS VEHICLE. GM HAS BEEN NEGLIGENT IN ADDRESSING THIS ISSUE. THE DEALERSHIP OFFERED NOTHING, STATING THAT WE LIVE IN THE "SALT BELT, AND THIS CAN HAPPEN". THIS STATEMENT IS ONLY A HALF TRUTH SINCE MILLIONS OF OTHER VEHICLES ALSO IN THE SALT BELT DON'T HAVE THEIR BRAKE LINES FAIL DURING THEIR USEFUL LIFE. GM IS HOPING THAT BY DELAYING THIS THEY WILL AVOID THE ENORMOUS EXPENSE OF RECALLING AND REPAIRING THESE VEHICLES. THIS IS SHAMEFUL BECAUSE THIS TYPE OF SAFETY ISSUE IS VERY DANGEROUS AND SNEAKY. IT CAN COME UP AT ANY TIME, ANYWHERE.

Mileage: 60,000

I ON 8/30/2013 NOTICED A VERY SOFT BRAKE PEDAL AND DROVE HOME CAREFULLY. I DID NOT DRIVE THE CAR THE NEXT DAY OUT OF CONCERN FOR THE BRAKES. I TESTED THE BRAKES ON SUNDAY AND FOUND I HAD NO BRAKES. THE TRUCK WAS TOWED TO A REPAIR FACILITY ON 9/2/2013. INSPECTION OF THE SYSTEM SHOWS ALL BRAKE LINES NEED REPLACEMENT. THREE HAVE FAILED AND THE OTHERS WHEN MOVED TO ALLOW REPLACEMENT OF THE BAD LINES WILL FAIL. THE BLEEDER VALVE IS RUSTED AND NEW CALIPERS MAY BE NEEDED. ESTIMATED TOTAL COST APPROX. $2000.00 PLUS. I HAVE OWNED MANY CARS AND NEVER ENCOUNTERED THIS PROBLEM BEFORE. I SUSPECT INFERIOR MATERIALS ARE BEING USED FOR BRAKE LINES. I AM TOLD THIS IS A VERY COMMON OCCURRENCE. I AM LUCKY THAT THERE WAS NO ACCIDENT CAUSED BY MY BRAKE FAILURE. I AM SURE MANY OTHERS ARE NOT SO LUCKY. THE PROBLEM SEEMS VERY COMMON AMONG CARS BUILT BY THE BIG THREE AND LESS SO AMONG EUROPEAN AUTO MAKERS. I SUSPECT BEAN COUNTERS ARE SAVING A FEW DOLLARS PER CAR AND TO HELL WITH SAFETY! *JB

Mileage: 79,221

WHILE DRIVING ON THE NJ GARDEN STATE PARKWAY VEHICLE WAS CUTOFF BY ANOTHER WHEN BRAKES WERE APPLIED A LOUD HISSING WAS HEARD BRAKE PEDAL WENT TO THE FLOOR COULD NOT STOP SUV. BRAKE LIGHT CAME ON AND CHECK ENGINE LIGHT. HAD TO SWERVE OUT OF THE WAY OF ANOTHER CAR. UPON INSPECTION OF BRAKES THE STEEL LINE TO THE BACK BRAKES RIGHT ABOVE THE GAS TANK WHERE YOU COULD NOT SEE IT WAS RUSTED OUT AND BURST ALL OF THE BRAKE FLUID EMPTIED OUT OF IT COVERING THE BOTTOM OF TAHOE. ALL METAL BRAKE LINES WERE HEAVILY RUSTED AND CORRODED. *TR

Mileage: 132,050

TOTAL BRAKE SYSTEM FAILURE. FORTUNATELY HAPPENED DRIVING IN NEIGHBORHOOD AND NOT ON HIGHWAY OR ANOTHER HIGHER SPEED ROAD. THERE WAS NO WARNING LIGHT OR INDICATION OF ANY SORT. JUST HIT THE BRAKES AND THEY WERE NOT THERE. THIS COULD HAVE BEEN A SERIOUS ACCIDENT AT ANYTHING OVER 20-25 MPH!!!!!!! *TR

Mileage: 145,040

I TOOK MY TAHOE IN FOR A STATE INSPECTION AND AS THE MECHANIC PULLED THE CAR INTO THE BAY, THE BRAKE LINE FAILED. HE COULD NOT STOP THE CAR. I HAVE SPOKEN WITH TWO DIFFERENT AUTO SHOPS WHO TOLD ME THIS IS A KNOWN PROBLEM WITH GM. SURE ENOUGH. I DID SOME RESEARCH ONLINE AND FOUND COMPLAINT AFTER COMPLAINT ABOUT THIS SAME EXACT ISSUE. SOME WERE EVEN INVOLVED IN CRASHES. I AM GRATEFUL THAT THIS DID NOT HAPPEN WHILE I WAS DRIVING WITH MY KIDS IN THE CAR. $800 LATER, I HAVE MY TAHOE BACK. WHY IS GM NOT DOING ANYTHING ABOUT THIS? THIS IS A RUST AND CORROSION PROBLEM WITH THE BRAKE LINES BEING OPEN AND EXPOSED UNDERNEATH THE CAR. (MODEL YEARS 1999-2003) IS GM WAITING FOR A FEW FATALITIES TO FINALLY DO SOMETHING???? *TR

Mileage: 118,000

BRAKE LINE FAILURE DUE TO CORROSION AROUND CLAMPS. *TR

Mileage: 118,000