2001 CHEVROLET TAHOE Service Brakes Problems

In the past I have sent several emails to Chevrolet corporate office re the ABS brake system on my Tahoe which first failed with only 130 miles on the vehicle. Vehicle almost tipped over but I recovered the braking system and stopped vehicle only inches from going off a cliff and into the ravine below. I love my Tahoe which now has 109000+ miles on it but the ABS brake system has never worked and on several occasions almost wiped out myself and a passenger because brakes failed to engage. I filed several complaints with the Chevrolet dealer in Austin, TX where I bought my Tahoe and also here in Taos, NM where I currently live. Recently I had the Chevrolet dealer here in Taos run a diagnostic on my ABS brakes. Result was that the brake system was defective and would cost $2000 to repair! I feel Chevrolet should pay for the repair since my Tahoe was delivered from the factory with defective ABS brakes. As it is, my Tahoe cannot be resold since the system as is could kill anyone in this vehicle if they did not know how to recover when pedal is all the way to the floor and vehicle is picking up speed rather than slowing down. Certainly even I could hit an elk standing in middle of highway because I would not be able to recover brake system in time.

EMERGENCY BRAKE WEARS ITSELF WITHOUT BEING ENGAGED TO THE POINT WHEN YOU NEED IT, IT DOES NOT WORK. *TR

Mileage: 180,000

REAR STEEL BRAKE LINES RUSTED OUT. I WAS DRIVING ON THE HIGHWAY AT ABOUT 50 MILES PER HOUR AND THE BRAKE PEDAL WENT TO FLOOR & HAD TO PUMP BRAKES. HAD TO TURN OFF TO BERM OF ROAD TO KEEP FROM HITTING CAR IN FRONT OF ME. HAD TO HAVE REAR BRAKE LINES REPLACED AND THE MECHANIC SUGGESTED ALL BRAKE LINES BE REPLACED BECAUSE OF THE RUST. I HAD ALL THE BRAKE LINES REPLACED FOR OVER $600 DOLLARS. THE TAHOE HAS ONLY 41000 MILES ON IT AND ALMOST CAUSED AN ACCIDENT. IT HAPPENS ALL OF A SUDDEN & IT TAKE A FEW SECONDS BEFORE YOU CAN FIGURE OUT WHAT TO DO, TAKING MUCH LONGER DISTANCE TO STOP. THEY NEED TO RECALL THESE BRAKES AS SOON AS POSSIBLE BEFORE MORE ACCIDENTS HAPPEN.

Mileage: 41,000

TWO RUSTED BRAKE LINES FROM THE MASTER CYLINDER TO MASTER DISTRIBUTION BLOCK UNDER THE TRUCK CAUSED THE BRAKE PEDAL TO GO TO THE FLOOR AT 50 MPH AND RAN THRU A 4 WAY STOP INTERSECTION IN A RURAL AREA, THANK YOU JESUS I'M ALIVE, LOT'S OF RUST ON THE LOWER ROCKERS ETC. ON BOTH SIDES

Mileage: 208,586

MY ABS LIGHT IN ON AND WHEN I PUSH DOWN ON IT MAKES NOISE PLUS IT PUSH BACK A LITTLE

THE STEEL BRAKE LINE FROM THE ABS UNIT TO THE REAR BRAKES HAS CORRODED AND IS LEAKING FROM ABOVE THE STEEL FRAME FORWARD FROM THE LEFT REAR TIRE. FORTUNATELY THIS OCCURRED AS I PULLED INTO MY GARAGE AFTER DRIVING OVER 150 MILES ROUND TRIP AT HIGHWAY SPEEDS AND IN CITY TRAFFIC. THIS COULD HAVE BEEN DISASTERIOUS, CAUSING SERIOUS INJURIES, DEATH, AND/OR PROPERTY DAMAGE IF THE LINE WOULD HAVE FAILED DURING THE TRIP! AFTER SEARCHING THE INTERNET, THIS BRAKE LINE FAILURE LOOKS LIKE IT'S A COMMON PROBLEM!

Mileage: 160,000

METAL BRAKE LINES RUSTED AND CORRODED. LINES PLACED IN AN AREA OF THE VEHICLE WHERE THEY WILL RUST AND CORRODE THEN CAUSING THEM TO BURST AT VERY UN-OPPORTUNE MOMENTS. CAUSING WRECKAGE. MY VEHICLE LOST ITS BRAKES ON A HIGHWAY WHEN THE VEHICLE IN FRONT OF ME CAME TO A STOP TO TURN OFF THE HIGHWAY, WAITING FOR ANOTHER VEHICLE TO CLEAR. I STARTED BRAKING AND LOST MY BRAKES, SO I TOOK THE SIDE OF THE ROAD TO AVOID AN ACCIDENT. I GOT MYSELF HOME AND LOOKED UNDER THE VEHICLE

Mileage: 205,000

ANTI LOCK BRAKES ARE JERKING AND MAKE A NOISE AT SLOW SPEEDS.

Mileage: 89,000

ABS LOW SPEED ACTIVATION. ANY TIME COMING TO A STOP OR SLOWING THE ABS WILL ACTIVATE AT LOW SPEEDS AROUND AND UNDER 10MPH. VERY UNSAFE AND DANGEROUS TO HAVE YOUR BRAKES LOCKING UP WHEN SIMPLY TRYING TO COME TO A STOP.

Mileage: 145,000

LIVE IN MINNEAPOLIS, AND JUST LOST THE BRAKES ON MY 2001 CHEV TAHOE LT THIS WEEK. HAD BEEN GOING DOWN I-494 AT 65 MPH MINUTES BEFORE THIS. FOUR BLOCKS FROM MY HOUSE DRIVING ON A MAIN ROAD, SNOWY AND ICY, MADE A LEFT HAND TURN TO MY SIDE STREET, AND THE CAR KEPT GOING STRAIGHT. HIT THE BRAKES, THE ABS ACTIVATED, AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. VIRTUALLY NO BRAKES, BUT I MANAGED TO COMPLETE THE TURN WITHOUT HITTING ANYTHING, AND LIMP IT HOME. IN THE GARAGE NOW GETTING FIXED, ESTIMATED $500 - $1,000. WITH SOME GOOGLING AND TALKING TO 4 GARAGES, IT SEEMS TO BE A PRETTY COMMON PROBLEM. AMAZING TO ME THAT GM HAS NOT BEEN FORCED INTO A RECALL OVER THIS. THIS COULD BE FATAL, IF IT HASN'T BEEN ALREADY.

Mileage: 170,000

CORRODED/RUSTY BRAKE LINE RUPTURED CAUSING SUDDEN BRAKE LOSS IN HEAVY STOP AND GO TRAFFIC IN A WORK ZONE. USED THE PARKING BRAKE TO AVOID COLLISION.

Mileage: 185,000

MY DAUGHTER WAS RUNNING LESS THAN 35 MPH THROUGH TOWN WENT TO STOP AT A RED LIGHT, BRAKE PEDAL WENT TO THE FLOOR AND BOTH FRONT AND REAR BRAKE LINES FAILED LEADING TO ME REAR ENDING THE CAR IN FRONT OF ME. UPON INSPECTION BOTH FRONT AND REAR BRAKES WERE LEAKING FLUID DUE TO RUST AND CORROSION. I HAD TO HAVE MY CAR TOWED HOME AND HAVE BEEN UN ABLE TO DRIVE IT SINCE.

Mileage: 137,000

TL* THE CONTACT OWNS A 2001 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO RESPOND. THE CONTACT WAS ABLE TO SLOW THE VEHICLE DOWN BY PUMPING THE BRAKE PEDAL. THE ABS WARNING AND BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 100.

Mileage: 100

AT LOW SPEEDS COMING TO A STOP, MY ABS HAS BEEN ENGAGING AND NOT ALLOWING ME TO STOP WHEN APPROPRIATE. I HAVE AVOIDED SEVERAL REAR ENDING INCIDENTS, 3 TODAY. I HAVE SEEN THAT THER HAS BEEN A RECALL ON THIS ISSUE BUT MY VIN HASNT BEEN INCLUDED. I REALLY NEED THIS ISSUE TAKEN CARE OF. I HAVE FOUR CHILDREN THAT ARE WITH ME ON NORMAL OCCASIONS. THIS HAPPENS AT NEARLY EVERY STOP, STOP SIGN, LIGHT, PARKING ECT.

Mileage: 208,000

WHILE DRIVING MY CHEVY TAHOE I EXPERIENCED COMPLETE BRAKE FAILURE LUCKILY I WAS ABLE TO STOP THE VEHICLE WITH THE USE OF THE EMERGENCY BREAK AND I DID NOT HAVE AN ACCIDENT. I HAD NO INDICATION THAT THE BREAKS WERE GOING BAD UNTIL I LOST THEM COMPLETELY. I HAD THE VEHICLE TOWED TO A SHOP THE MECHANIC TOLD ME THAT TWO BREAK LINES WERE BUSTED AND THAT THE REST WERE CORRODED. HE TOLD ME THAT HE HAS DONE 5 CHEVY BREAK LINE SYSTEMS IN THE LAST 3 MONTHS AN APPARENTLY THIS IS A KNOW ISSUE WITH CHEVY TRUCKS. IT SEEMS LIKE THE BREAK LINES ONLY LAST A FEW YEARS BEFORE THEY ARE CORRODED AND RUSTED AND EVENTUALLY THE BREAK WITHOUT WARNING OR NOTICE THIS IS UNSAFE AND I THINK CHEVY NEEDS TO DO A RECALL ON THIS ISSUE. I HAVE NEVER HAD ANY BREAK LINE ISSUES WITH ANY OTHER MAKE OF VEHICLE.

Mileage: 70,000

WHILE DRIVING ON INTERSTATE 676 APPROACHING A TRAFFIC STOP I PUSHED ON THE BREAKS AND THE PEDAL WENT TO THE FLOOR FORCING ME TO TRY TO AVOID A COLLISION IN FRONT AS I TRIED TO TURN INTO THE MIDDLE LANE VEERING RIGHT I HIT THE DRIVERS SIDE DOOR OF ANOTHER CAR. I IMMEDIATELY TOOK THE TAHOE TO A REPAIR SHOP WHO SAID MY BREAK LINES WERE CORRODED ANT THE BREAK FLUID CAME OUT OF THEM ILVE IN NORTHEAST PA WHERE SALT ON THE ROADS IF USED A LOT IN THE WINTER.

Mileage: 183,320

STARTED CAR AND BRAKE FELT SQUISHY AND UNRESPONSIVE. NO BRAKING POWER AND FOOT COMPLETELY DEPRESSED TO FLOOR IN ORDER TO EVENTUALLY STOP WHEN TRAVELING JUST WITH FOOT OFF ACCELERATOR OR LESS THAN 10MPH. WAS REAR BRAKES. SAME THING HAPPENED TO FRONT BRAKES IN APRIL 2015. VEHICLE DRIVING FINE. STOPPED TO GET GAS AND WHEN STARTED CAR UP BRAKES WERE SQUISHY AND FOOT HAD TO BE DEPRESSED ALL THE WAY TO THE FLOOR IN ORDER TO STOP AND THAT WAS TRAVELING WITHOUT USING ACCELERATOR OR GOING LESS THAN 10MPH. BOTH TIMES COMPLETE REPLACEMENT OF ALL HOSES AND BRAKE FLUID. DIDN'T SEEM LIKE NORMAL WEAR AND TEAR AT ALL. IF I HAD BEEN DRIVING AT SPEED IT WOULD MOST LIKELY HAVE RESULTED IN AN ACCIDENT BOTH TIMES.

Mileage: 140,000

I STARTED TO HAVE THE BRAKE LIGHT AND ONE OTHER LIGHT COME ON WHILE DRIVING. I DISCOVERED THAT THERE WAS A RECALL FOR THIS BUT IT WAS FOR VEHICLES IN 'SNOW-BELT STATES'. I BOUGHT THIS CAR FROM CARMAX IN CHARLOTTE NC WHICH WAS NOT ON THE LIST FOR 'SNOW-BELT STATES'. I HAVE SINCE LOST MY ABS SYSTEM. I DON'T KNOW IF IT IS NOW PART OF THE RECALL AND IS MY VEHICLE STILL ELIGBLE?

A BRAKE LINE BURST FROM ABS MODULE TO RR BRAKE AND PEDAL WENT ALL THE WAY TO THE FLOOR. LOST HALF THE FLUID AND FLUID CONTINUED TO DRAIN WHEN BRAKE WAS APPLIED TO PARK THE VEHICLE. GM CLAIM THAT THE VEHICLE HAS A DUAL BRAKE SYSTEM APPARENTLY DOES NOT PREVENT COMPLETE BRAKE FAILURE. WIFE WAS VERY UPSET AS THE PEDAL WAS COMPLETELY AT THE FLOOR. LUCKILY VEHICLE WAS NOT ON THRUWAY AT 65 MPH WHEN FAILURE OCCURRED. THE VEHICLE IS IN MINT CONDITION INSIDE AND OUT AND WASHED FREQUENTLY. REPAIR SHOP INDICATED THAT THE BRAKE LINES WERE BADLY RUSTED. GM SHOULD BE OBLIGATED TO NOTIFY OWNERS OF SIMILAR VEHICLES AND TRUCK OF THE DANGER OF COMPLETE BRAKE FAILURE. BRAKE LINES SHOULD NOT BE MADE OF MILD STEEL THAT IS SUBJECT TO RUSTING THROUGH AS THIS IS LIFE AND DEATH SAFETY ISSUE.

Mileage: 103,803

TL* THE CONTACT OWNS A 2001 CHEVROLET TAHOE. AFTER REMOVING THE KEY FROM THE IGNITION SWITCH, THE ENGINE REMAINED ON. THE VEHICLE WOULD SHUT OFF SEVERAL MINUTES AFTER REMOVING THE KEY. THE CONTACT ALSO STATED THAT THE ABS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 180,000.

Mileage: 180,000

TL* THE CONTACT OWNS A 2001 CHEVROLET TAHOE. THE CONTACT STATED THAT THE BRAKE PEDAL FELT LIKE A SPONGE WHEN IT WAS DEPRESSED. THE CONTACT DISCOVERED THAT THE BRAKE LINES WERE RUSTED AND CORRODED AND THE BRAKE FLUID RESERVOIR WAS EMPTY DUE TO BRAKE FLUID LEAKING FROM THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 81,845.

Mileage: 81,845

ON MAY 20, 2015 OUR 2001 CHEVROLET TAHOE EXPERIENCED A HYDRAULIC BRAKE LINE EXPLOSION DUE TO EXCESSIVE CORROSION ALMOST CAUSING AN ACCIDENT. THERE WAS NO WARNING LIGHT INDICATION. THE WARNING LIGHT CAME ON LONG AFTER THE FACT WHEN TESTING THE BRAKES WHILE THE VEHICLE WAS STATIONARY.THE STEEL HYDRAULIC BRAKE LINE TO THE LEFT REAR WHEEL RUPTURED TOTALLY UNEXSPECTEDLY. THIS IS A SERIOUS SAFETY RELATED PROBLEM. GENERAL MOTORS IS AWARE AND ONLY A TECHNICAL SERVICE BULLETIN HAS BEEN ISSUED, NO RECALL. THE NHTSA MUST DEMAND THAT GM RECALL THESE VEHICLES FOR REPLACEMENT OF ALL THESE INFERIOR HYDRAULIC BRAKE LINES BEFORE DEATHS AND SERIOUS INJURIES OCCUR. I AM SUBMITTING THIS FORM TO MAKE IT PUBLIC KNOWLEDGE THAT THIS IS A SERIOUS PROBLEM THAT COULD CAUSE DEATH AND SERIOUS PROPERTY DAMAGE IF NOT ADDRESSED ON ALL THE AFFECTED VEHICLES. I AM TRULY GRATEFUL THAT MY WIFE WAS NOT INJURED OR KILLED.

Mileage: 193,713

MY DAUGHTER WAS DRIVING OUR 2001 CHEVY TAHOE, THAT WE HAVE OWNED SINCE NEW, IN COLUMBUS OHIO. SHE WAS DOING 35 MPH DOWN A CITY STREET, WHEN SHE WENT TO STOP, THE BRAKES WENT TO THE FLOOR. AFTER RUNNING A FEW RED LIGHTS AND ALMOST GETTING INTO 2 ACCIDENTS, SHE SLOWED THE VEHICLE DOWN AND INTO A PARKING SPACE. I HAD IT TOWED TO JACK MAXTON CHEVY AND THEY SAID THE BRAKE LINES WERE COMPLETELY RUSTED AWAY AND GAVE ME A QUOTE OF $5000.00 TO REPLACE EVERYTHING. I DID NOT DO THE REPAIR AND AM CURRENTLY WEIGHING MY OPTIONS. *TR

Mileage: 137,400

STEEL BRAKE LINES ARE RUSTED. ALL OF THE UNDER BODY LINES SHOW A LOT OF RUST. REAR FEED LINE FROM ABS BLOCK RUPTURED AT REAR AXLE. I REPAIRED THAT LINE, WHEN I ATTEMPTED TO BLEED THE SYSTEM THE REAR FEED LINE AND THE IN FLOW LINE POPPED LEAKS. LUCKILY I HAD ENOUGH BRAKING TO STOP. *TR

Mileage: 118,025

MY WIFE WAS EXECUTING A TURN, HEADED DOWNHILL, AND STEPPED ON THE BRAKE PEDAL, ONLY TO HAVE IT TRAVEL TO THE FLOOR, AND NOT STOP THE TRUCK. I HAD BEEN TOWING A TRAILER WITH SURGE BRAKES THE DAY BEFORE, WHICH WOULD NOT HAVE ACTIVATED WITHOUT BEING ABLE TO SLOW THE VEHICLE. THE PROBLEM WAS A FAILED FRONT BRAKE LINE FROM THE MASTER CYLINDER TO THE ANTILOCK ACTUATOR, RESULTING IN A COMPLETE LOSS OF FRONT BRAKE HYDRAULIC PRESSURE. I HAD ALSO HAD IT INSPECTED RECENTLY AND IT PASSED SAFETY. IN LOCATING THE BURST BRAKE LINE, IT WAS ABOVE THE FRAME RAIL, IN A SPOT I WOULD NOT EXPECT TO BE VISUALLY INSPECTABLE. I AM REPLACING ALL THE LINES IN THE TRUCK WITH THE SAME MATERIAL USED BY BMW AND VOLVO NOW, AND CONSULTING WITH MY SERVICE TECH ABOUT RELOCATING THE ANTILOCK ACTUATOR TO AN ACCESSIBLE AREA UNDER THE HOOD, FOR LESS LINE EXPOSURE TO ELEMENTS. THIS TRUCK HAS BEEN GARAGED MOST OF IT'S LIFE, AND UNDERCARRIAGE WASHED AFTER EXPOSURE TO ROAD SALT. THIS IS CLEARLY A MANUFACTURER DEFECT. I HAVE A 2006 TAHOE AT WORK, GARAGED ALL IT'S LIFE AND RARELY DRIVEN IN WET WEATHER, 60,000 MILES, THAT HAD A REAR BRAKE LINE FAIL IN 2011 OR 2012. I'LL FILE A SEPARATE COMPLAINT FOR THAT, BUT AS A FLEET VEHICLE, IT'S MAINTAINED METICULOUSLY. IT'S ALSO ESSENTIALLY THE SAME VEHICLE AS MY 2001, WHICH HAD IT'S LINES LAST LONGER, BUT STILL FAIL WITHOUT WARNING. I WANT GM TO RECALL THESE VEHICLES AND FIX THE PROBLEM. MINE WILL BE FIXED WITH BETTER MATERIALS, SO I DON'T WANT A RECALL ON MINE, TO HAVE CHEAP COST-CUTTER PARTS INSTALLED. I WANT THEM RECALLED BEFORE SOMEONE LIKE MY DAUGHTER, AN INEXPERIENCED NEW DRIVER, HAS TO DEAL WITH A LOSS OF BRAKES DURING A NORMAL LIFE AND MAINTENANCE ROUTINE OF HER VEHICLE. *TR

Mileage: 71,000

WHEN COMING TO A STOP ANTILOCK FIRES NOISILY THEN THE BRAKE PEDAL GOES TO THE FLOOR AND VEHICLE KEEPS ROLLING FORWARD (IN TRAFFIC- INTO BUILDINGS- INTO FENCES- ONTO CURBS) ANTILOCK BRAKES ARE FAILING AND MAKING THE SYSTEM NOT WORK PROPERLY. *TR

Mileage: 180,000

BRAKES FAILED DUE TO BRAKE LINES RUSTED THROUGH. *TR

Mileage: 170,000

OUR SON AND A FRIEND WERE TRAVELING ON MAJOR STREET APPROACHING A STOP LIGHT CONTROLLED INTERSECTION, APPLIED THE SERVICE BRAKE TO HAVE IT PUSH TO THE FLOORBOARD. HE NARROWLY AVOIDED REAR ENDING STOPPED TRAFFIC AND SWERVED ACROSS THE YELLOW LINE ONTO A SIDE-STREET IN ATTEMPT TO STOP VEHICLE WITHOUT A CRASH, NEXT TO THE POLICE STATION. ALL THE BRAKE LINES REQUIRED REPLACING DUE TO THE HIDDEN RUST ON THE LINES AS THEY ARE MOUNTED ON TOP OF THE FRAME. OUR SON HAD JUST RETURNED FROM COLLEGE WITH THE VEHICLE, HAD THIS HAPPENED ON THE HIGHWAY AT 75 MPH THIS COULD HAVE HAD TRAGIC RESULTS. THE REPAIR SHOPS WERE FAMILIAR WITH THIS ISSUE AS A NUMBER OF CUSTOMERS WITH SIMILAR GM MODELS HAVE RECENTLY EXPERIENCED THE SAME ISSUE. THIS WAS A VERY TIME CONSUMING AND EXPENSIVE REPAIR, AND WE CONSIDER OURSELVES LUCKY TO NOT HAVE A DIFFERENT CONCLUSION. *TR

Mileage: 113,450

TL* THE CONTACT OWNS A 2001 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH AND ATTEMPTING TO STOP, THE BRAKES MALFUNCTIONED AND CAUSED THE DRIVER TO LOSE CONTROL OF THE VEHICLE. THE CONTACT CRASHED INTO AN EMBANKMENT AND SEVERAL TREES. THE CONTACT SUFFERED FROM A LEFT LEG INJURY, MULTIPLE HIP ABRASIONS AND CONTUSIONS. A POLICE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FAILURE WAS CAUSED BY A RUPTURED BRAKE LINE AND THE FACT THAT THERE WAS NO BRAKE FLUID IN THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 141,597.

Mileage: 141,597

WHEN ATTEMPTING TO STOP MY VEHICLE GOING ABOUT 5 MPH, THERE WAS A VIBRATION IN MY BRAKE PEDAL AND THE VEHICLE CONTINUED TO ROLE IN THE PATH WAY OF A TRACTOR TRAILER. I THOUGHT MY LIFE WAS ABOUT TO END SO I HIT THE GAS AND ENDED DRIVING UP ON THE CURB TO GET OUT OF ONGOING TRAFFIC. MY BOSS TOLD ME THAT THERE WAS A RECALL ON OUR DEPARTMENT VEHICLES THAT WERE TAHOES BECAUSE OF AN ANTILOCKING BRAKE ISSUE. I LOOKED UP THE RECALL ON MOTORTREND AND THE RECALL EXPLAINS EXACTLY WHAT HAPPENED TO ME WHEN I ALMOST DIED. I TOOK MY VEHICLE TO THE CHEVY DEALER AND THE GUY RAN MAN VIN NUMBER AND STATED THERE ARE NO ACTIVE RECALLS ON MY VEHICLE. I CALLED THE CHEVY DEALER AND THE FEMALE ON THE PHONE STATED THAT RECALLS ARE DONE BY VIN NUMBERS AND MAYBE MY NUMBER WAS ACCIDENTALLY SKIPPED. THIS IS OFF MOTORTREND. RECALL DATE: AUG 29, 2005 MODEL AFFECTED: 2001 CHEVROLET TAHOE SUMMARY: CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY. CONSEQUENCES: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH. POTENTIAL UNITS AFFECTED: 1353718 NOTES: GENERAL MOTORS CORP. READ MORE: HTTP://WWW.MOTORTREND.COM/CARS/2001/CHEVROLET/TAHOE/RECALLS/#IXZZ38LPOMMDC. *TR

Mileage: 130,000

BRAKES FAILED DO TO RUSTED BRAKE LINES. DRIVING ON 55 MPH ROAD STOPLIGHT TURNED JUST AS I APPROACHED IT STEPPED ON THE BRAKE PEDDLE AND IT SLOWLY WENT TO THE FLOORBOARD. I COULD NOT STOP IN TIME AND WENT THROUGH A RED LIGHT, I WAS LUCKY, THIS COULD HAVE BEEN A DISASTER WITH LOSS OF LIFE. I WAS TOLD ALL MY BRAKE LINES WERE RUSTED AND NEEDED TO BE REPLACED AT A COST OF $1500.00. *TR

Mileage: 130,000

THE PARKING BRAKES DO NOT WORK HAVE OWNED THE TAHOE FOR 2 YEARS AND NEVER USED THE PARKING BRAKES NOW ALL THE SUDDEN THE PARKING BRAKES MAKES A LOUD SQUEALING NOISE AND I THINK THERE IS ENOUGH COMPLAINTS ABOUT THE BRAKES TO WARRANT A RECALL BEFORE SOME ONE DOES GET KILLED OR INJURED .ALSO THEY HAD A RECALL ON THE BRAKES AND ABS BUT ONLY IN THE SO CALLED SALT BELT AND THE OWNERS THAT DON'T LIVE THERE SHOULDN'T HAVE TO PAY TO GET THE SAME THING FIXED THAT THE RECALL SHOULD COVER IN THE FIRST PLACE NO MATTER WHERE YOU LIVE. *TR

ABS BRAKE LIGHT WOULD COME ON WHEN TRYING TO STOP THEN IT WOULD NOT STOP CORRECTLY AND ALMOST RAN OVER CURB ONTO SIDEWALK. REPLACED SENSOR TWICE BEFORE THE LIGHT AND BRAKES WORKED CORRECTLY. *TR

DRIVING HOME AND PRESSED ON BRAKES AT A STOP LIGHT AND PETAL WENT TO THE FLOOR. PUMPED BRAKES AND JUST BARELY STOPPED BEFORE HITTING ANOTHER CAR. TAHOE BRAKE LINES WERE COMPLETELY RUSTED TO NOTHING. THIS IS A BIG PROBLEM!! MANY PEOPLE DON'T LOOK AT THEIR BRAKE LINES UNTIL THEY CRASH. PLEASE GET GM TO FIX THIS PROBLEM BEFORE MORE CUSTOMERS ARE HURT. *TR

Mileage: 100,056

I HAD JUST COME OFF THE HIGHWAY AND FORTUNATELY WAS COMPLETING A PARALLEL PARK WHEN THE BRAKE PEDAL COULD BE PRESSED TO THE FLOOR. THE CAR DID NOT STOP. I ESSENTIALLY ROLLED INTO THE CAR IN FRONT OF ME TO STOP. A LARGE AMOUNT OF BRAKE FLUID WAS ON THE GROUND NEAR THE REAR DRIVERS SIDE WHEEL. WHEN THE CAR WAS STOPPED I OPENED THE DOOR AND LOOKED BACK AS I PUSHED THE BRAKE PEDAL TO THE FLOOR. I SAW COLORED FLUID SPRAYING OUT SIDEWAYS FROM THE REAR. SUBSEQUENTLY HAD BRAKE LINE REPAIRED. *TR

Mileage: 121,000

I HAD TO REPLACE 2 BRAKE LINES THAT FAILED ON SEPARATE OCCASIONS .THE BRAKE LINES ARE COVERED IN RUST, THE ABS SYSTEM DOES NOT WORK AND IS NOW DISCONNECTED.THE DEALER STATED ABS PROBLEM WAS FRONT WHEEL SENSORS, AFTER THEY REPLACED BOTH SENSORS THEY THAN DETERMINED IT WAS MY ABS COMPUTER.I TOLD THEM TO LEARN HOW TO TROUBLESHOOT ON SOMEONES ELSE'S VEHICLE AND REMOVED IT. THE UNDER CARRIAGE OF THIS VEHICLE HAD BEEN COATED WITH A LITE UNDERCOATING FROM THE FACTORY, AS THE COATING FALLS YOU CAN SEE EXTENSIVE RUST ON THE EXPOSED METAL SURFACES. IN MY OPINION THE METAL WAS NOT PREPARED CORRECTLY BEFORE IT WAS COATED, FOR THIS TO HAPPEN.THE SERVICE MANAGER FROM THE DEALER STATED, THE RUST CONDITION SHOULD BE A CLASS ACTION LAW SUIT.I HAVE PURCHASE NO CORROSIVE BRAKE LINE AND WILL CHANGE LINES AS NEEDED. *TR

Mileage: 1,120,000

ABS BRAKE LIGHT ON DASH STAYS ON. I HAD ALL THE SENSORS TESTED AND THEY ARE OK. I HAD THE COMPUTER TESTED AND IT SHOWS A FAULT. BUT THE ABS SEEMS TO BE WORKING FINE. IT APPEARS THAT IN ORDER TO GET THIS ERROR LIGHT TO GO OFF I HAVE TO SPEND A $1000 FOR A COMPUTER, EVEN THOUGHT HE SYSTEM APPEARS TO BE WORKING PROPERLY. I HAVE HAD NUMEROUS ELECTRICAL ISSUES WITH THIS VEHICLE SINCE PURCHASE. *TR

Mileage: 60,000

BRAKE LINE FAILURE, RESULTING IN LOSS OF BRAKE CONTROL. BRAKE LINE CORRODED. *TR

Mileage: 121,000

IN PRESSING THE BRAKE PEDAL IT WENT ALL THE WAY TO THE FLOOR BECAUSE, AS I FOUND OUT LATER, ALL OF THE BRAKE FLUID HAD LEAKED OUT DUE TO BRAKE LINE RUST AND CORROSION. NO WARNING AT ALL (E.G. SOFT PEDAL) AND THIS VEHICLE DOESN'T HAVE A SPECK OF RUST ON IT. I REPLACED ALL OF THE BRAKE LINES AT A COST OF NEARLY $1400.00. *TR

Mileage: 80,329

BRAKES WENT TO FLOOR BEFORE HOLDING - NO HYDRAULICS. BRAKE LINE FAILURE/RUPTURE WITH HEAVY LEAK OF BRAKE FLUID UNDER DRIVER SEAT AREA. SUSPECTED CORROSION. *JS

Mileage: 76,534

MY BRAKE LINES KEEP BURSTING. I WASN'T EVEN DRIVING, I WAS IN PARK, APPLIED THE BRAKES TO PUT IT GEAR AND THE PEDAL WENT RIGHT TO THE FLOOR. THIS IS THE SECOND TIME, I JUST SPENT $400 TO HAVE THE REARS REPLACED WHILE ON THE ROAD. I WAS STUCK OUT OF STATE. NOW IT HAPPENED AGAIN. PLEASE HELP, I CAN'T AFFORD A REPAIR RIGHT NOW. *TR

Mileage: 99,000

MY DAUGHTER WAS DRIVING ALONG THE FREEWAY WHEN SUDDENLY SHE HAD TO BRAKE AND THE PEDAL WENT DOWN TO THE FLOOR, THE TRUCK NOT STOPPING. SHE GOT IN THE SLOW LANE AND HAD TO GO VERY SLOW TO HER DESTINATION. THANK GOD SHE'S A GOOD DRIVER OR SHE COULD'VE KILLED HERSELF OR SOMEONE ELSE. I MET HER AT HER DESTINATION TO CHECK OUT MY TRUCK AND FOUND THAT WHEN YOU STEPPED ON THE BRAKE PEDAL, BRAKE FLUID POURED OUT FROM UNDER THE CHASSIS OF THE TRUCK IN THE AREA OF THE REAR DRIVER SIDE DOOR.SO I LOOKED AT THE REST OF MY BRAKE LINES AND THEY ARE FULL OF RUST. *TR

Mileage: 122,000

2001 TAHOE BRAKES FAILED...LINE RUPTURE, CAUSING MY WIFE TO PLOW THROUGH A RED LIGHT AT AN INTERSECTION AND NARROWLY AVOID A CRASH. THIS IS MY THIRD GM BRAKELINE FAILURE. THE OTHER TWO OCCURRED ON A 1999 PONTIAC BONNEVILLE, AGAIN WITH INSTANT, NO WARNING, LOSS OF BRAKE POWER. FORTUNATELY, THOSE EVENTS WERE IN PARKING LOTS AT VERY LOW SPEED. YES, THERE IS SOME, MAYBE 30% OF BRAKE POWER LEFT ON THE TAHOE, BUT THE STOPPING DISTANCE IS MAGNIFIED GREATLY ONCE SPEED IS ABOVE 15 MPH. I CAN CITE AT LEAST SIX OTHER ACQUAINTANCES WITH SIMIALR BRAKE LINE FAILURES ON GM VEHICLES FROM THE Y2000 ERA DESIGN. SOMETHING IS GROSSLY WRONG WITH GM, AND PERHAPS OTHERS, BRAKE LINE COMPONENTS. JUST VISUALLY EXAMINE THE BRAKELINES AND THEY APPEAR READY TO CRUMBLE AT MANY PLACES DUE TO SUBSTANTIAL EXTERIOR CORROSION. NEVER HAD THIS PROBLEM ON THE MANY VEHICLES OWNED OVER THE YEARS. MAKE THEM FIX IT AT THEIR COST, PLEASE. I CAN'T THINK OF A SINGLE MORE CRITICAL SYSTEM FOR DRIVER SAFETY ON A VEHICLE THAN THE BRAKE SYSTEM. IT HAS TO BE PHYSICALLY RELIABLE FOR THE LIFE OF THE CAR. *TR

Mileage: 114,500

TL* THE CONTACT OWNS A 2001 CHEVROLET TAHOE. THE CONTACT STATED THAT HE ATTEMPTED TO DECELERATE BUT THE BRAKE PEDAL FAILED TO RESPOND. UPON INSPECTION, IT WAS FOUND THAT THE BRAKE LINES HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000. UPDATED 08/27/13*LJ

Mileage: 105,000

OPERATING ON THE REAR ACCESS ROAD TO A MALL AND NOTICED BRAKE PEDAL ALMOST WENT TO THE FLOOR AND IT TOOK A STRONG EFFORT TO STOP THE VEHICLE. TRIED PUMPING BRAKES TO SEE IF PEDAL WOULD RISE, IT DID NOT. CHECKED BRAKE FLUID RESERVOIR AND IT WAS SLIGHTLY DOWN. LOOKED UNDER TRUCK AND NO LEAK AT ALL FOUR WHEELS OR ON INSIDE MASTER CYLINDER COWL. DROVE SLOWLY TO NEARBY MECHANIC AND THIS TIME NOTICED DRIPPING UNDER DRIVER SIDE FLOOR. MECHANIC SAID I NEEDED BRAKE LINE REPLACEMENT AND AM AWAITING REPAIR. VEHICLE IS WELL MAINTAINED, ALWAYS PARKED ON PAVED DRIVEWAY, AND WAXED ALONG WITH UNDERCARRAIGE CAR WASHES DURING THE WINTER MONTHS. PURCHASED USED FROM CHEVY DEALER AND FOUND LEFT REAR BACKING PLATE HAD ALMOST ROTTED OFF EXPOSING REAR AXLE SEALS WHICH DEALER REPLACED WITHIN WEEK OF MY PURCHASE. *TR

Mileage: 66,500

MY SON WAS DRIVING ON I-95 INTO BALTIMORE WHEN HE HAD TO SLAM ON THE BRAKES TO AVOID HITTING ANOTHER VEHICLE AND THE 2001 TAHOE IMMEDIATELY LOST BRAKING POWER. HE WAS ABLE TO MANEUVER ONTO THE SHOULDER TO AVOID HITTING THE VEHICLE IN FRONT OF HIM BUT THE BRAKES WERE NO LONGER OPERATING PROPERLY. THERE WAS NO LONGER ANY RESISTANCE IN THE BRAKE PEDAL AND MINIMAL STOPPING POWER. `HE WAS ABLE TO BRING THE VEHICLE INTO A PARKING GARAGE BY DRIVING SLOWLY AND IN LOW GEAR. I HAD THE VEHICLE TOWED HOME AND EXAMINED IT AND DETERMINED THAT THE BRAKE FLUID RESERVOIR WAS EMPTY AND THAT IT HAD LEAKED OUT OF A CORRODED AND BROKEN BRAKE LINE AT THE MIDPOINT OF THE CHASSIS. ALL OF THE METAL BRAKE LINES ARE CORRODED AND WILL NEED TO BE REPLACED. THERE WAS NO ADVANCE WARNING OF ANY IMPENDING BRAKE LINE FAILURE. THE VEHICLE HAS BEEN REGISTERED IN MARYLAND SINCE PURCHASED NEW AND THERE IS RELATIVELY LITTLE SNOW THAT FALLS IN THE WINTER AND AS A RESULT THERE IS ALMOST NO OTHER CORROSION ON THIS VEHICLE SO SEEING THE BRAKE LINES CORRODED LEADS ME TO BELIEVE THAT AN INFERIOR GRADE OF STEEL WAS USED ON THIS CRITICALLY IMPORTANT COMPONENT. TO MAKE MATTERS WORSE THE BRAKE LINE IN THE AREA OF THE FAILURE IS LOCATED ABOVE THE FRAME AND IS NOT VISIBLE FROM BELOW AND THEREFORE CANNOT BE INSPECTED FOR CORROSION. WHEN THE OIL IS CHANGED AND WHEN THE BRAKES ARE REPLACED THE BRAKE LINES ARE CHECKED BUT IN THE AREA OF THE FAILURE AS STATED THEY CANNOT BE INSPECTED. I BELIEVE GM SHOULD BE REQUIRED TO RECALL ALL VEHICLES WITH THIS TYPE OF METAL BRAKE LINE AND BE REQUIRED TO REPLACE THEM WITH A BETTER GRADE OF STAINLESS STEEL AS IT IS REASONABLY FORESEEABLE THAT FATALITIES WILL BE THE LOGICAL CONSEQUENCE OF THIS TYPE OF FAILURE IN A SIGNIFICANT PERCENTAGE OF THESE INCIDENTS. *TR

Mileage: 176,000

I WAS DRIVING MY 2001 CHEVY TAHOE AT MODERATE SPEED WHEN THE ABS AND PARKING INDICATOR LIGHT COME ON. IN ADDITION THERE WAS PULSING WHICH I BELIEVE IS FROM THE ABS SYSTEM WHEN I TRIED SLOWING DOWN FROM 25 MPH. I DID RESEARCH ON TSB AND DID FIND THERE WAS AN ISSUE WITH THIS KIND OF PROBLEM AFFECTING GM SUV FROM 2000-2006 REGARDING SPEED SENSOR AND CORROSION OF BRAKE LINES . I INFORMED THE CHEVY DEALER OF THIS TSB AND THEY REFUSED TO ACKNOWLEDGE THIS ISSUE AND WANTED ME TO PAY IN EXCESS OF $1200 TO FIX THIS PROBLEM. I FEEL THE DEALER REPRESENTING GM IS NOT ACTING IN GOOD FAITH. AS I TOLD THEM THIS IS A SAFETY ISSUE AND NOT ASKING FOR ANYTHING UNREASONABLE CONSIDERING THE ASSISTANCE FROM TAX PAYER. I APPRECIATE YOUR ASSISTANCE. REGARDS. *TR

Mileage: 180,000

I WAS DRIVING DOWN THE ROAD DOING ONLY 25 MILES A HOUR AND HAD MY KIDS IN THE CAR I WENT TO STOP AT A STOP SIGN AND BRAKE PEDAL WENT RIGHT TO THE FLOOR. WHEN HAD IT LOOKED AT THEY SAID ALL BRAKE LINES ROTTED. WITH A TRUCK THAT ONLY HAS 50,000 ON IT THIS SHOULD NOT HAPPEN. MY HUSBAND KEEPS MY TRUCK MINT IF HAD TO RATE IT ON A SCALE OF 1 TO 10 I WOULD SAY IT IS A 9.5 LOOKS BRAN NEW. *TR

Mileage: 50,000

I WAS DRIVING NORTH ON RT 67 IN SOUTHBURY CT. WHEN A DEER CROSSED THE STREET IN FRONT OF ME. I APPLIED THE BRAKES FIRMLY AND AT FIRST THEY FELT FINE, THEN THEY JUST WENT TO THE FLOOR. FORTUNATELY THE CAR SLOWED FROM THE FIRST APPLICATION OF THE BRAKES SINCE I NO BRAKES AFTER THAT POINT. USING THE E-BRAKE I INCHED MY WAY TO A SAFE SPOT ON THE SIDE OF THE ROAD AND CALLED A TOW TRUCK. THE CAR IS CURRENTLY AT A REPAIR SHOP AND I AM WAITING FOR AN ESTIMATE. THIS INCIDENT APPEARS TO MATCH MANY OTHERS RELATED TO EA11001. AS YOU KNOW, THIS MIGHT HAVE TURNED OUT DIFFERENTLY UNDER OTHER CIRCUMSTANCES. FORTUNATELY IN MY CASE, THE DEER JUMPED OUT AT THE RIGHT PLACE AT THE RIGHT TIME. IF THE DEER DID NOT JUMP OUT AND THE BRAKES FAILED LATER IN MY TRIP I MIGHT HAVE BEEN ON A HILL OR AT A BUSY INTERSECTION WHERE INJURY AND PROPERTY DAMAGE WOULD HAVE BEEN A CERTAINTY. I FIND IT REMARKABLE THAT EA11001 IS TAKING SO LONG TO RESOLVE GIVEN THE SERIOUSNESS OF THIS ISSUE. PLEASE PROVIDE ME WITH ANY UPDATED INFORMATION. THANK YOU. *TR

Mileage: 127

WAS COMING TO A STOP AT INTERSECTION. AND COULD NOT STOP, BRAKES FAILED.. MECHANIC SAYS ALL LINES ARE COMPLETELY CORRODED.. EXTREMELY DISSATISFIED, SEEMS MANY OTHER GM OWNERS HAVE SAME ISSUES, SHOULD BE RECALLED HUGE SAFETY ISSUE WITH THESE VEHICLES. *TR

Mileage: 121,000

TRUCK BRAKES LINES JUST ROTTED OUT COMPLETELY HAD TO REPLACE ENTIRE LINES. *TR

Mileage: 113,000

I WAS DRIVING ON THE PA TURNPIKE. LIGHTLY APPLIED MY BRAKES AND THE PEDAL WENT ALL THE WAY TO THE FLOOR. THE BRAKE LINES ARE CORRODED AND BLEW. *TR

Mileage: 103,000

TL* THE CONTACT OWNS A 2001 CHEVROLET TAHOE. THE CONTACT WAS DRIVING 65 AND APPLIED THE BRAKES TO TO AVOID CRASHING INTO A DEER. THE BRAKES SEIZED AND THE VEHICLE FAILED TO RESPOND. THE CONTACT LOST CONTROL OF THE VEHICLE AND ROLLED OVER MULTIPLE TIMES. ALSO, THE FRONT AND SIDE AIR BAGS ON THE PASSENGER AND DRIVER'S SIDE FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED A CONCUSSION AND SEVERAL LACERATIONS. PRIOR TO THE CRASH THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ABS SYSTEM FAILED. THE VEHICLE WAS TAKEN TO ANOTHER DEALER FOR A SECOND OPINION WHO WAS UNABLE TO FIND ANY FAILURE CODES. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS 160,000.

Mileage: 160,000

WE WERE DRIVING THE VEHICLE AND THE BRAKES STOPPED WORKING. WE DISCOVERED THAT ALL THE BRAKE LINES WERE CORRODED . RESEARCH ON THE INTERNET SHOWED THAT NUMEROUS PEOPLE HAVE HAD THE SAME ISSUE WITH CHEVROLET VEHICLES BUILT AT THIS TIME. THERE HAS NOT BEEN A RECALL BY CHEVROLET AT THIS TIME. *TR

Mileage: 129,732

LOW SPEED ABS FAILURE (BRAKES PULSATE) WHEN STOPPING OR TURNING BETWEEN 3-10 MPH. ISSUE APPEARS TO BE COORODED FRONT WHEEL SENSORS. *JS

Mileage: 119,640